Free Preview
#BS-2016-INTLON-54462016 International Lonestar
Based on reports from 1 owners and 6 recalls for this exact model.
Preliminary Verdict
Green Light
Based on 1 complaints, 0 crashes, 0 fires, and 6 recalls.
Preview: What's in your full report
Each card shows a real sample from your report — unlock all 10 sections from $1.20
Mechanic Inspection Checklist
1 owners reported fuel system issues — failures commonly reported around 187K miles.
30,000-Mile Cost Projection
Best Case
Most Likely
Worst Case
Top cost driver: Fuel System (1 reports).
Also in your report
Owner Intelligence
AI-synthesized themes from real complaints
Buyer Lot Checklist
Questions, test drive checks, walk-away triggers
Negotiation Talking Points
Data-backed dollar deductions
Buy / Skip Verdict
Final recommendation with conditions
Where the complaints fall
2016 International Lonestar: Known Issues & Problem Areas
Fuel System Issues
Fuel System complaints account for 100% of all reports filed for the 2016 International Lonestar, with 1 owners filing complaints with NHTSA. The median mileage at time of complaint is 187,000 miles, suggesting issues tend to surface around the 187K-mile mark.
Data sourced from NHTSA owner complaints and community reports. The full report analyzes severity, repair costs, and failure patterns for each category.
Don't negotiate blind — know what this car costs to own
Repair costs • Negotiation scripts • Mechanic checklist • Buy/skip verdict
Recall History (6 recalls)
SERVICE BRAKES, AIR
Navistar, Inc. (Navistar) is recalling certain model year 2015-2016 International 9900, DuraStar, LoneStar, PayStar, ProStar, WorkStar and 2015 International TranStar and IC Bus CE vehicles equipped with a Haldex air braking system. The affected brake actuators may have been manufactured with an incomplete attachment of the internal rubber diaphragm to the actuation mechanism. This could cause dragging or overheated brakes.
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
Navistar, Inc. (Navistar) is recalling certain model year 2015-2016 International 9900 trucks manufactured January 6, 2014, to March 12, 2015, and 2015-2016 International Lonestar trucks manufactured February 20, 2014, to March 13, 2015. The affected vehicles are equipped with a 6" diameter stack tail pipe, that may not have sufficient support. The unsupported weight of the upper stack tail pipe and vibration associated with normal vehicle operation over time may cause a crack of the weld joint between the inlet pipe and the flare expansion of the stack tail pipe, which may result in partial or full separation of the stack tail pipe from the vertical exhaust pipe.
ELECTRICAL SYSTEM:IGNITION:MODULE
Navistar Inc. (Navistar) is recalling certain model year 2016 International ProStar trucks manufactured August 5, 2015, to August 14, 2015, DuraStar trucks manufactured August 7, 2015, to August 13, 2015, Paystar trucks manufactured August 11, 2015, to August 14, 2015, and LoneStar trucks manufactured August 10, 2015, to August 14, 2015. In the affected vehicles, the Engine Control Module (ECM) may short circuit, causing the engine to stall without warning.
STEERING:LINKAGES:TIE ROD ASSEMBLY
Navistar, Inc. (Navistar) is recalling certain 2016 International DuraStar, LoneStar, ProStar, TerraStar, TranStar, WorkStar, 9900i, and IC Bus HC vehicles equipped with certain Spicer D or E series steer axles. The castellated nut on the steer axles may not be properly torqued, allowing the tie rod to loosen.
EXTERIOR LIGHTING:BACK UP LIGHTS
Navistar, Inc. (Navistar) is recalling certain 2000-2003 International 8100, 2001-2003 International 9100i, 2001-2007 International 9400i, 2001-2010 International 9200i, 2002-2007, 2009 International 8500, 2003-2007, 2013 International 9900i, 2003-2018 International 8600, 2004, 2007 International 9900iX, 2008-2018 International ProStar, 2010-2011, 2013, 2016 International LoneStar, 2011-2012, 2016 International 4400, 2017-2024 International LT, 2018-2024 International RH, 2019-2021 International LS, 2019-2024 International MV vehicles. The back-up lights offer low visibility when the vehicle is in reverse and bobtail mode. Also, the vehicles have not been equipped with additional unobstructed back-up lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
+ 1 more recall in the full report
Recall severity analysis & seller scripts
The full report rates each recall's severity and gives you scripts for asking the seller about recall completion.
About this data
NHTSA Complaints
Federal database of owner-filed safety complaints. 1 records for this vehicle.
NHTSA Recalls
Manufacturer-issued safety recalls. 6 recalls found for this vehicle.
Repair Cost Data
Real-world repair costs from owner reports and independent databases.
Other International Lonestar Model Years
View all International Lonestar years →2016 International Lonestar: Frequently Asked Questions
What is the most common problem with the 2016 International Lonestar?
Is the 2016 International Lonestar reliable?
How much does it cost to fix 2016 International Lonestar problems?
Does the 2016 International Lonestar have any recalls?
What mileage do International Lonestar problems start?
What’s in the full report?
How is this different from free NHTSA data?
How is this different from Carfax?
What if the report isn’t useful?
Get the Full 2016 International Lonestar Report
10 sections of AI analysis based on 1 owner reports. Know before you buy.