2007 Volvo Vhd TSBs
161 Technical Service Bulletins across 14 categories
Categories
Engine
38 bulletinsInactive Code P25AE00 Being Generated After A Hard Pull And A Momentary Drop In Engine Oil Pressure (Low Oil Pressure)...
Read full bulletin
(Possible Related Codes - SPN4811 , SPN 100 , PID 100)
TSB - V-710-001 Engine Crossmember Loose Hardware.
CBR - 11 Liter Engines - Fuel In Oil.
CBR: 11L Engine - Air Conditioner (A/C) Line Damaged At Bracket - Model Year 2007 to Present.
Barksdale Leveling Valve, Leak Test
CBR: Programming Failure - Chassis With Cummins Engine And An Allison Transmission
CBR: Volvo VHD Models - Allison Reduced Engine Load At A Stop (RELS) Diagnostic Trouble Code P071A Or P07CE - Non-Split/Drop Box PTO.
Read full bulletin
VHD chassis may experience Diagnostic Trouble Code P071A or P07CE along with symptoms of no reduced engine load (RELS) when coming to a stop and/or the transmission going into 4th gear lock up when applying the service brake.
Volvo Chassis - D12C, D12D, D11F, D13F, D16D, D16F Engines - Copper Injector Sleeves, Replacement Procedure And...
Read full bulletin
Information ( Flat Tip Injectors ) - US04 To US07 Emissions
Engine Control Module (EMS) Software (MSW) Information August 2022; Improvement List (Change Log) - US21+OBD22 (13L...
Read full bulletin
VGT, TC) And US17+OBD22 (11L) Emissions
Programming Failure - Chassis With Cummins Engine And An Allison Transmission
Cylinder Head Reuse And Replacement Guidelines - Inspection And Information - US04 And Newer Emissions, Commonly 2007...
Read full bulletin
And Newer Model Years
Volvo Chassis - Discharge Recirculation Valve (DRV) - FSB 258-029 , Engine Turbocharger Compressor Bypass Valve...
Read full bulletin
Deletion Kit , Installation
Volvo Chassis - SNV 15-016 Documented Process For Engine Oil Consumption - All Emissions, All Model Years
US07 / US10 D13 Turbocharger Gasket
Volvo Chassis - SNV16-007 Telematics Gateway ( TGW ) Goes Offline Due To VIN Mismatch When Test Engine ECU Is Installed
Automated Manual Transmission ( AMT - F ) ( I-Shift) Clutch Valve Unit ( CVU ) Makes Intermittent Buzzing Noise With The...
Read full bulletin
Key On And Engine OffChanged repair information to reflect new software available.
Engine Diagnostic Trouble Codes ( DTC's ) P24A0 And P249F Lighting The Malfunction Indicator Lamp ( MIL ) - OBD15...
Read full bulletin
(Commonly Model Year 2016) And NewerUpdated to reflect release of FSB284-064 (Above)
In the event that an EGR temperature sensor replacement is required on a VOLVO D13H engine, a new routing configuration...
Read full bulletin
is required.
Engine Control Module (ECM) Software Update
Engine Data Label
Exhaust Gas Recirculation (EGR) Valve Oil Supply Line, updated part
In some instances the exhaust rocker piston cap screw may become loose and back out causing loss of engine compression,...
Read full bulletin
or a mechanical injector Diagnostic Trouble Code (DTC).
VOLVO: ON SOME TRUCKS, THERE IS AN OIL CONTAMINATION INTO THE ENGINE WIRE HARNESS BECAUSE OF A FAILURE OF THE OIL LEVEL SENSOR.
Read full bulletin
MODELS VAH, VHD, VN, VT. NO MODEL YEARS LISTED. *PE
VOLVO TRUCKS: MISSING SIGNAL FROM ENGINE VARIABLE GEOMETRY TURBOCHARGER ACTUATOR (ENGINE VGT ACTUATOR) WITH MECHANICAL...
Read full bulletin
TRANSMISSION, CAUSES FRETTING OF CONNECTOR PINS IN ENGINE VGT ACTUATOR CONNECTOR. NEW MOUNTING ARRANGEMENT AND RELOCATION OF ENGINE VGT ACTUATOR HAS BEEN DEVELOPED. *PE UPDATED 8/17/12. *PE
VOLVO TRUCKS: CONNECTOR PIN, REPLACEMENT.
Read full bulletin
SEVERE FRETTING DAMAGE OF THE ENGINE VARIABLE GEOMETRY TURBOCHARGER ACTUATOR (ENGINE VGT ACTUATOR) HARNESS AND TURBINE SHAFT SPEED SENSOR (TSS) CONNECTOR MAY CAUSE AN UNRELIABLE SIGNAL TO THE ENGINE VGT ACTUATOR. *JS
VOLVO TRUCKS: SOME ENGINES LEAK OIL THROUGH THE GROMMET.
Read full bulletin
INFORMATION ON THE WIRING HARNESS, UNIT INJECTOR REPLACEMENT. *RM UPDATED 9/9/11. *PE
MACK TRUCKS: THERE IS REVISED MOUNTING HARDWARE FOR THE EXHAUST MANIFOLD AND TURBOCHARGER.
Read full bulletin
*RM
VOLVO TRUCK: ENGINE ECM AND ACM SOFTWARE UPDATES.
Read full bulletin
NEW SOFTWARE UPDATES WITH ENHANCEMENTS ARE AVAILABLE FOR THE ENGINE CONTROL MODULE (ECM) AND AFTERTREATMENT CONTROL MODULE (ACM). NEW UPDATES AND ENHANCEMENTS WILL ADDRESS TURBO VARNISHING DURING INCLEMENT WEATHER AND EXHAUST GAS RECIRCULATION (EGR) HIGH MASS FLOW ISSUES. NO MODEL YEARS LISTED. *PE
VOLVO TRUCKS: EXHAUST FLEX PIPE CRACKS.
Read full bulletin
BEGINNING MAY 12, 2008, A REDESIGNED EXHAUST FLEX PIPE AND TURBOCHARGER OUTLET PIPE (LOCATED BETWEEN THE TURBOCHARGER DIFFUSER PIPE AND THE EXHAUST FLEX PIPE) WERE IMPLEMENTED INTO PRODUCTION ON VN, VHD, AND VT MODEL CHASSIS. NO MODEL YEARS LISTED. *
VOLVO TRUCK: TO REDUCE THE POTENTIAL FOR CAB WATER INTRUSION, A CAB COWL SEAL HAS BEEN RELEASED BY ENGINEERING.
Read full bulletin
THE SEAL PART NUMBER 8083305 IS POSITIONED ABOVE THE TOP EDGE OF THE COWL PANEL TO DIVERT WATER FLOW ONTO THE COWL PANEL RATHER THAN BETWEEN THE COWL PANEL AND CAB. NO MODEL YEARS LISTED. *PE
VOLVO TRUCK: REPORTS PROMPTED THE RELEASE OF A REPLACEMENT CONNECTOR FOR THE CAB HVAC MOTOR RESISTOR.
Read full bulletin
REPLACEMENT CONNECTOR IS SUPPLIED AS KIT PART, WHICH CONTAINS THE CONNECTOR BODY AND THE NECESSARY TERMINALS. MODEL YEARS UNKNOWN. *PE
VOLVO TRUCKS: MEGA FUSE CORROSION.
Read full bulletin
VOLVO VEHICLES WITH US 07 EMISSIONS COMPLIANT ENGINES BUILT BETWEEN 11/12/06 AND 12/05/08 MAY HAVE CORROSION ISSUES WITH THE TWO MEGA FUSES IN THE BATTERY BOX AREA. *PE
VOLVO TRUCKS: MEGA FUSE CORROSION.
Read full bulletin
EMISSIONS COMPLAINT ENGINES BUILT BETWEEN 11/13/06 AND 12/05/08 MAY HAVE CORROSION ISSUES WITH THE TWO MEGA FUSES IN THE BATTERY BOX AREA. *PE
VOLVO TRUCKS: MEGA FUSE BREAKING.
Read full bulletin
TRUCKS WITH US 07 EMISSIONS COMPLIANT ENGINES BUILT BETWEEN 6/30/06 AND 1/15/08 MAY EXPERIENCE AN ISSUE WITH THE BATTERY COMPARTMENT MOUNTED 150 AMP POSITIVE SIDE MEGA FUSE BREAKING. MODELS VN, VHD, AND VT. MODEL YEARS UNKNOWN. *PE
VOLVO TRUCKS: ENGINE UPDATE CAMPAIGN FOR CERTAIN D13F ENGINES (VN-2, VHD-2) CONSISTS OF INSPECTING THE CAMSHAFT AND...
Read full bulletin
REPLACING THE INTAKE ROCKER ARMS, EXHAUST ROCKER ARMS, INJECTOR ROCKER ARMS, INJECTOR HOLD DOWNS, AND THE INJECTOR SEALING WASHERS. *PE UPDATED 12/17/09. *PE
SP 764-005, LOAD LEVELING VALVE, REPLACEMENT -- CERTAIN VN-2, VHD-2, AND VT MODEL TRUCKS BUILT BETWEEN 9/1/06 AND 4/1/07...
Read full bulletin
WITH REAR AIR SUSPENSION NEED TO HAVE THE REAR SUSPENSION LEVELING VALVE REPLACED. *NJ
CERTAIN VN-2, VHD-2, AND VT MODEL TRUCKS BUILT BETWEEN 9/1/06 AND 4/1/07 WITH REAR AIR SUSPENSION NEED TO HAVE THE REAR...
Read full bulletin
SUSPENSION LEVELING VALVE REPLACED. *NJ UPDATED 3/17/08. *NJ
VOLVO TRUCKS NORTH AMERICA - SP 225-007, TURBOCHARGER MOUNTING GASKET, REPLACEMENT / BUILT WITH A D13F ENGINE BETWEEN 06/30/06 AND 10/03/07.
Read full bulletin
*NJ
Electrical
26 bulletinsDEF Level (UQLS) Sensor Troubleshooting Guide - US17+OBD16 Emissions and Newer
NOx Sensor Troubleshooting Guide - US10+OBD13 And Newer Emissions
(Back Office) - Cruise Control Inoperative After Updating Software VECU5 Without ESP Package (UESP)
Temperature Sensor Troubleshooting Guide - US10+OBD13 And Newer
Unable To Retrieve "On Request" Messages For PeopleNet Or Omnitracs Modules Installed On The DL5 Data Link; Third Party...
Read full bulletin
Electronic Log Device Not Reporting Certain Data
Sensor And Parameter Values Missing Or Reading Zero When Performing A Sensor And Parameter Values Monitor With Premium...
Read full bulletin
Tech Tool ( PTT ) - US07 And US10 ( Pre-OBDII, 9-Pin Diagnostic Connector ) Chassis
Particulate Matter (PM) Sensor Troubleshooting Guide - US14+OBD16 And Newer Emissions
DEF Level (UQLS) Sensor Troubleshooting Guide - US17+OBD16 Emissions and Newer
Shipping and Handling of Volvo Lithium-ion 48V Mild Hybrid Battery to Global Battery Solutions (GBS)
Volvo Chassis - SNV 14-026 P111C Compressor Discharge Temperature Sensor
Volvo Chassis - Rain Sensor Bracket Removal And Installation Procedure when Using An Aftermarket Windshield
Exhaust Gas Recirculation (EGR) System - Fault Codes SPN 412 FMI 0,2,5; Diagnostic Trouble Codes (DTC) P040A, P040B,...
Read full bulletin
P1121 - Temperature Sensor Inspection
Volvo Chassis - Charging Lamp ( Battery Light, Alternator Light ) Illuminated (ON) In The Instrument Cluster After The...
Read full bulletin
Cluster Is Replaced - US04 Emissions, Model Years 2005 to 2007
ECM and ACM Reprogramming, OBD2015
Diagnostic Trouble Code ( DTC ) P0194 - 00 - Fuel Rail Pressure Sensor ( RPS ), Circuit Erratic, Intermittent - US17 (...
Read full bulletin
GHG17 ) Emissions And Newer ( Common Rail Fuel System ); Common Model Years 2017 And 2018Changed repair instructions to reflect new procedures
Exhaust Gas Recirculation (EGR) Differential Pressure Sensor
Seat Harness Routing (Swivel) wires pulling away from clipping points
Seat Harness Routing (Non-Swivel) wires pulling away from clipping points
Battery Cable, Routing
Oil Level Sensor Harness Wire Splice
VOLVO: LIGHT CONTROL MODULE (LCM), REPROGRAMMING.
Read full bulletin
ON SOME VOLVO UNITS EQUIPPED WITH CLEAR LED CLEARANCE LIGHTS IN THE SUN VISOR, THE MAY EXHIBIT AN ACTIVE FAULT CODE MID 216 PSID 49 FMI 5. THIS FAULT INDICATES A TRAILER MARKER OPEN ISSUE WHICH IS INCORRECT FOR THE ISSUE PRESENT ON THE VEHICLE. *JS
VOLVO: THE FRONT CHASSIS HARNESS MAY HAVE BEEN ROUTED WITH THE COMPRESSOR AIR DISCHARGE LINE WHICH CAN LEAD TO CORROSION OF THE HARNESS.
Read full bulletin
*RM
MEGA FUSE BREAKING ON VOLVO VEHICLES - VN, VHD, VT.
Read full bulletin
*PE
BATTERY CABLE ROUTING FOR CERTAIN VOLVO VEHICLES - VN-2, VHD-2, VT.
Read full bulletin
*PE
DPF REPLACEMENT -- CERTAIN VOLVO VEHICLES BUILT BETWEEN 7/1/06 AND 7/22/07 WITH A VERTICAL BACK OF CAB (VBOC) DIESEL...
Read full bulletin
PARTICULATE FILTER (DPF) AND A STACK HEIGHT OF 3.8 METERS (12' 6") OR GREATER, MAY EXPERIENCE CRACKING OF THE DPF OUTLET MODULE. *NJ
SP 258-003, DIESEL PARTICULATE FILTER OUTLET MODULE, REPLACEMENT.
Read full bulletin
CERTAIN VOLVO VEHICLES BUILT BETWEEN 07/01/06 AND 07/22/07. *NJ
Fuel System
22 bulletinsDEF Pump Troubleshooting Guide - US10+OBD13 And Newer Emissions
Diesel Particulate Filter (DPF) And Diesel Oxidation Catalyst (DOC) Pin Testing Procedure - US07 And Newer Emissions,...
Read full bulletin
Model Year 2008 And Newer
Fuel Level Gauge Reading Incorrect In The Instrument Cluster
Volvo Chassis - Fuel Level Gauge Slow To Respond To Changes In Fuel Level
Volvo Chassis - Fuel Level Sending Unit Specification Information
(Back Office Only) Volvo Chassis - Equipped With A Catalyzed Exhaust Aftertreatment System ( EATS ) - Regeneration (...
Read full bulletin
Regen ) Failure Diagnostic Process - US07 to US16 Emissions
(Back Office Only) Volvo Chassis - Equipped With A Catalyzed Exhaust Aftertreatment System ( EATS ) - Regeneration (...
Read full bulletin
Regen ) Failure Diagnostic Process - US07 to US16 Emissions
Diagnostic Trouble Code ( DTC ) P009E - 73 - Fuel Pressure Relief Control Performance / Stuck Off - GHG17 ( US17 )...
Read full bulletin
Chassis With Common Rail Fuel System, Updated to reflect GHG17 software release
Diagnostic Trouble Codes ( DTC ) P208E And P103B Logging With Possible Derate ( SCR Inducement ) - OBD15, US14+OBD16...
Read full bulletin
Emissions And Newer Rewrote test procedure for better clarity.
Volvo Chassis - Diesel Exhaust Fluid ( DEF ) Contamination In Fuel System, Inspection And Repair - US10 to US14 (...
Read full bulletin
Non-Common Rail Fuel System ) Removed information for common rail chassis - now has its own solution.
Diagnostic Trouble Code ( DTC ) P009E - 73 - Fuel Pressure Relief Control Performance / Stuck Off - GHG17 ( US17 )...
Read full bulletin
Chassis With Common Rail Fuel SystemChanged repair instructions to reflect new procedures
Service Only Regen Requested With No Warning.
Read full bulletin
Active Fault Codes P24A4 / P10FE - OBD15 And OBD16 Chassis; Does Not Apply To US17 (Common Rail Fuel System) ChassisUpdated to reflect release of FSB284-064 (Above)
Diagnostic Trouble Codes ( DTC ) P208E And P103B Logging With Possible Derate (SCR Inducement ) - US13 Emissions And...
Read full bulletin
Newer
Dual Fuel Tanks Ventilation Filter Kit
Single Fuel Tank Ventilation Filter Kit
EGR Mass Flow Rate Low, diagnostic trouble code
VOLVO: AN EXHAUST PIPE INSULATION BLANKET CAN DETERIORATE OVER TIME.
Read full bulletin
A NEW BLANKET HAS BEEN RELEASED TO PROTECT FROM ROAD SPLASH. *RM UPDATED 9/12/11. *PE
VOLVO: AN EXHAUST PIPE INSULATION BLANKET CAN DETERIORATE OVER TIME.
Read full bulletin
A NEW BLANKET HAS BEEN RELEASED TO PROTECT FROM ROAD SPLASH. *RM UPDATED 9/12/11. *PE
VOLVO TRUCK: FUEL TANK MOUNTING.
Read full bulletin
FUEL TANK STRAPS OVER TIME MAY LOSE TORQUE AND ALLOW THE FUEL TANK TO ROTATE. MODELS VN, VHD, VT, VAH. NO MODEL YEARS LISTED. *PE UPDATED 2/21/12. *PE
VOLVO TRUCKS: EXHAUST FLEX PIPE RELOCATION.
Read full bulletin
CERTAIN CAB MODEL TRUCKS MAY EXPERIENCE A DEFORMATION OF THE RIGHT HAND CAB SKIRT DUE THE CLOSE PROXIMITY OF THE EXHAUST FLEX PIPE. TO RESOLVE THIS ISSUE A NEW INTERMEDIATE PIPE HAS BEEN RELEASED, THE NEW INTERMEDIATE PIPE WILL RELOCATE THE FLEX PIPE 10 MM CLOSER TO THE FRAME RAIL. *PE
VOLVO TRUCK: ON SOME VEHICLES, COOLANT OVERFLOW OUT OF THE OVERFLOW TUBE OCCURS DURING THE DIESEL PARTICULATE FILTER REGENERATION CYCLE.
Read full bulletin
EXCESSIVE COOLANT FLOW FROM THE RADIATOR TOP TANK AND THERMOSTAT VENT LINES PREVENTS FLOW INTO THE DE-AERATION PROCESS. VN-2, VHD-2 VT MODELS ONLY. NO MODEL YEARS LISTED. *PE
VOLVO: LEAKAGE DETECTION DIAGNOSTICS IMPROVEMENTS TO REMEDY DTC'S.
Read full bulletin
ALL MODELS FROM MODEL YEARS 2003-2008. DIAGNOSTIC MONITOR FOR THE EVAPORATIVE EMISSION SYSTEM SMALL LEAK, HAS USED A SOFTWARE FUNCTION THAT CALCULATES LEAKAGE BASED ON A PRESSURE INFERRED FROM THE CURRENT CONSUMED BY AN ELECTRIC PUMP THAT PUMPS AIR INTO THE FUEL TANK SYSTEM. *PE
Other
21 bulletinsCBR - A significant GPS reporting issue is affecting fleet operations, with trucks maintaining back-office communication...
Read full bulletin
but failing to transmit GPS location data.
CBR: Diagnostic Trouble Code (DTC) P215A-64, Fault Code SPN 84 FMI 19
AMT Control Housing Bench Testing - False Failures
The Diagnostic Process
Volvo Fault Code MID 144 PSID 204 FMI 9
Volvo Chassis Ghost Codes Due To Poor Grounding
Volvo Chassis - PTO Pump Speed Calculator
VIDA QR Scanner Mobile App
Volvo Chassis - Driveline (Driveshaft, Propeller Shaft) Ride Height And Angle, Measurement And Calculation; Pinion Angle...
Read full bulletin
Measurement - Model Year 1996 And Newer
Volvo Chassis - Volvo Fusion 2 Collision Warning System Information
On some trucks with the Telematics Gateway (TGW) system, the TGW control unit may not correctly communicate with the...
Read full bulletin
vehicle systems after restarting.
Hill Start Assist Solenoid, Replacement
Oil Filter Housing
Hill Start Assist Solenoid, Replacement
AMT High Range Cone Replacement
Oil Filter Housing
High Soot Output
Timing Plate Flange Screw
Hill Start Assist Solenoid, Replacement
Range Synchronizer, Repair
Hill Start Assist Solenoid, Replacement
Transmission
20 bulletinsCBR - Automated Manual Transmission ( AMT ) Flywheel Pilot Bearing Wear On Input Shaft.
CBR: Automated Manual Transmission ( AMT ) - Transmission Electronic Control Unit ( TECU ) MID130 PSID 29 FMI 7 /...
Read full bulletin
P10AE81 Fault Codes Being Generated
CBR: Automated Manual Transmission (AMT) Transmission Kickdown Mode
CBR: Volvo Chassis - Timing Gear Plate Repair.
Read full bulletin
This solution provides supplementary information to be used when installing a Timing Gear Plate with Integrated Seal.
Volvo Chassis - ( AMT, I-Shift ) - Transmission Grinding When Downshifting ; Range Synchronizer (Synchro) Timing...
Read full bulletin
Procedure - US07 And Newer
Volvo Chassis - Equipped with An Automated Manual Transmission (AMT, iShift) - SNV 19-002 - AMT Oil Filter Housing...
Read full bulletin
Corrosion
Warranty Automated Manual Transmission ( AMT, I-Shift, mDrive ) Control Housing Assembly; Guidelines For Filing A Claim...
Read full bulletin
For Chassis Return Visit With Transmission Issues After A Repair Requiring Control Housing Removal And Reinstallation - US07 And Newer
Volvo I-Shift AMT Will Not Calibrate After Incorrect Flywheel Housing Is Installed
Volvo Chassis - Diagnostic Trouble Codes ( DTC's ) - MID130 PID160 FMI1 Or FMI2 - For The I-Shift Transmission
Volvo Chassis - Equipped With An I-Shift Automated Manual Transmission ( AMT ) - Flywheel Resurfacing And Reuse...
Read full bulletin
Guidelines
Volvo Chassis - Equipped With An Automated Manual Transmission (AMT, I-Shift ) - Error Code 126 Displayed In Premium...
Read full bulletin
Tech Tool (PTT ) While Performing The Calibration Procedure After The Shift Control Housing Has Been Removed And Installed, Rewritten to improve return from multiple search terms.
Flywheel Resurfacing Guidelines, I-Shift
Transmission ECU Programming
Transmission ECU Compatibility
VOLVO TRUCK: PROCEDURAL INFORMATION REGARDING THE REPLACEMENT OF HIGH RANGE CONE IN THE SECTION OF THE AUTOMATED MANUAL TRANSMISSION (AMT).
Read full bulletin
MODEL VN, VHD, VAH, VT. *PE UPDATED 8/8/14. *PE
VOLVO: THERE ARE NEW CLUTCH BEARING LUBRICATION TUBES.
Read full bulletin
*RM
VOLVO TRUCK: I SHIFT TRANSMISSION WITH MIXED COMPONENTS.
Read full bulletin
INSTALLATION OF REPLACEMENT PARTS IN AN I SHIFT TRANSMISSION (VERSION-C) MAY RESULT IN DIAGNOSTIC TROUBLE CODES (DTCS) MID 130 PID 160 FMI1 OR FMI2. NO MODEL YEARS LISTED. *PE
VOLVO TRUCK; CLUTCH SWITCH CLIP; IT HAS BEEN FOUND THAT VN, VHD AND VT VEHICLES USE A SPRING CLIP TO RETAIN THE CLUTCH...
Read full bulletin
SWITCH, MAY HAVE AN ISSUE WITH THE CLUTCH SWITCH MOVING OR DETACHING FROM IT'S MOUNT. *PE
TRANSMISSION ECU FUSE CONTAMINATION FOR CERTAIN VOLVO VEHICLES - VN-2, VHD-2, VT.
Read full bulletin
*PE
SP 432-025, CONTROL UNIT, GEAR SELECTOR REPLACEMENT; AT2512C, ATO2512C, AT2812C, ATO3112C.
Read full bulletin
*PE
Lighting
7 bulletinsTSB-Charge Air Cooler t-clamp install.
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P0420 Illuminating The Malfunction Indicator Lamp (MIL)
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P2459 Lighting The Malfunction Indicator Lamp ( MIL ); Possible Frequent...
Read full bulletin
Regeneration Requests - OBD15 And US14+OBD16 (Non-Common Rail) Chassis, Changed repair instructions to reflect OBD16 software release
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P2459 Lighting The Malfunction Indicator Lamp ( MIL ); Possible Frequent...
Read full bulletin
Regeneration Requests - OBD15 And Newer ChassisUpdated to reflect release of FSB284-064 (Above)
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P226C Intermittently Lighting The Malfunction Indicator Lamp ( MIL ) -...
Read full bulletin
OBD15 And OBD16 Conventional ChassisUpdated to reflect release of FSB284-064 (Above)
Diagnostic Trouble Code ( DTC ) P249C Intermittently Lighting The Malfunction Indicator Lamp ( MIL ) - OBD15 And OBD16,...
Read full bulletin
Model Year ( MY ) 2016 and 2017 ChassisUpdated to reflect release of FSB284-064 (Above)
Diagnostic Trouble Code ( DTC ) P0422 Lighting The Malfunction Indicator Light ( MIL ) - OBD15 And OBD16 Chassis...
Read full bulletin
(Non-Common Rail)Updated to reflect release of FSB284-064 (Above)
Brakes
6 bulletinsCBR: Volvo On-Highway Vehicles - Bendix ABS Fault SPN 807 FMI 13 Blink code 19-4.
Read full bulletin
The new Central Pressure Control (CPC) system has changed the way that the ABS chuff test is performed.
DTC U012100 - Lost Communication With Anti-Lock Brake System (ABS) Control Module, No Additional Information
Volvo Chassis - Bendix ABS6 TO ABS8 Service Information
Volvo Chassis - FSB 761-002, Shock Absorber, Inspection
VOLVO: ON SOME TRUCKS, AIR DISC BRAKE MAY EXPERIENCE A CONDITION OF THERMAL OVERLOAD.
Read full bulletin
THERMAL OVERLOAD REDUCES RUNNING CLEARANCE BETWEEN PAD AND ROTOR BELOW DESIRED LEVEL WHICH IS AN OVER ADJUSTMENT OF NORMAL PAD WEAR COMPENSATION. MODEL VAH, VHD, VN. NO YEARS LISTED. *PE
VOLVO: THE AIR DISC BRAKE, ON SOME TRUCKS, MAY EXPERIENCE THERMAL OVERLOAD DUE TO AN OVER ADJUSTMENT OF NORMAL PAD WEAR...
Read full bulletin
COMPENSATION THAT MAINTAINS CLEARANCE RUNNING BETWEEN BRAKE PAD AND ROTOR. MODELS VAH, VHD, VN. NO YEARS LISTED. *PE
Infotainment
5 bulletinsCBR: Volvo VHD & VN Models - Vehicle Wil Not Start, PTO Active Message Displayed In Cluster, PTO Light On When PTO...
Read full bulletin
Switch Is Turned Off
Instrument Cluster Programming - Programming Fails Or Errors Display When Replacing An Instrument Cluster With A Newer...
Read full bulletin
Part Number (Conversion Kit) - US04 To US10 Chassis (9-Pin Diagnostic Connector)
Radio, Replacement (revised from FSB 392-005)
Instrument Cluster Programming - Programming Fails Or Errors Display When Replacing An Instrument Cluster With A Newer...
Read full bulletin
Part Number (Conversion Kit) - US04 To US10 Chassis (9-Pin Diagnostic Connector)
Instrument Cluster Programming - Programming Fails Or Errors Display When Replacing An Instrument Cluster With A Newer...
Read full bulletin
Part Number (Conversion Kit) - US04 To US10 Chassis (9-Pin Diagnostic Connector)
Pre-Delivery & Maintenance
4 bulletinsCBR - Accelerator Pedal: Inspection/Instructions
Volvo Chassis - Drag Link Inspection And Replacement Criteria
Volvo Chassis - Dealer Support Communication - Selecting The Proper SR Area For Creating An eService
Volvo SNV14-035 When And How To Contact Tech Support ( eService & Phone )
Tires & Wheels
3 bulletinsFlywheel Housing Thread Repair
VOLVO TRUCKS: OIL SEEPAGE AT FLYWHEEL HOUSING.
Read full bulletin
THIS PROBLEM HAS ALREADY BEEN SOLVED IN PRODUCTION, BUT THE PRODUCTION SOLUTION IS NOT COMPATIBLE WITH PREVIOUS GENERATION FLYWHEEL HOUSINGS. *JS
NEW TECHNICAL COURSES AVAILABLE.
Read full bulletin
INTRODUCTION TO TIRE PRESSURE MONITORING SYSTEMS - CLASSES NOW AVAILABLE. THIS COURSE IS INTENDED TO FAMILIARIZE TECHNICIANS AND WORKSHOP FOREMEN WITH VOLVO'S TIRE PRESSURE MONITORING SYSTEMS. *NJ
Software & Calibration
3 bulletinsVolvo SNV15-008 Vocom Adapter ( 88890300 ) May Lock Up When Updating Firmware
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P2002, Diagnostic Information - OBD13 And NewerUpdated to reflect...
Read full bulletin
release of FSB284-064 (Above)
Software Update, revise document
Body & Paint
3 bulletinsService Door Rust Prevention
Floor Cracks Repair (Front Panel)
VOLVO TRUCK: DOOR SEAL, OUTER, REPLACEMENT.
Read full bulletin
THE OUTER SEAL ON THE CAB DOORS OF VOLVO MODEL TRUCKS MAY PREMATURELY SEPARATE FROM THE CAB SHELL. MODELS VN-2, VHD-2 AND VT. NO MODEL YEARS LISTED. *PE
Suspension
2 bulletinsCBR - Vehicles Equipped With Chalmers Suspension - Frame Bracket Hardware Loose or Interfering
Volvo Chassis - Stemco Hubcap Plug Will Not Stay In
Hybrid & EV
1 bulletinRegeneration in PTO Mode