2002 International Re Bus TSBs
71 Technical Service Bulletins across 14 categories
Categories
Other
21 bulletinsThis document will guide the user through understanding Prop Shaft Codes and understanding the variations of prop codes.
Read full bulletin
(Metric Prop codes start with the number a 4 and Non metric Prop codes start with a 2.)
Title: Driveline Information Center and Troubleshooting Procedures Applies To: All Vehicles
Title: Fan belt replacement guidelines for frayed edges Applies To: All Models
Driveline Information Center and Troubleshooting Procedures
Cleaning and Disinfecting Trucks and Buses
J1939 Data Link Troubleshooting
Driveline Information Center and Troubleshooting Procedures
J1939 Data Link Troubleshooting
NEW Ultrasonic DEF Tank Sending Unit; only models with SCR Aftertreatment system.
J1939 Data Link Troubleshooting
Cooling System Flush Procedure
J1939 Data Link Source Address Information
J1939 Data Link Troubleshooting
Updating OnCommand Link with Accelerator
OnCommand EZ-Tech
Winter Front Usage
ISX, N13, and N9 / N10 Aftertreatment Private Data Link Troubleshooting
J1939 Data Link Troubleshooting
OnCommand EZTech
OnCommand EZ-Tech Download Center
RADIATOR INTERNAL RESTRICTION AND FLUSH PROCEDURE
Engine
16 bulletinsEngine replacements for all International engines will need to follow this procedure.
In some geographic areas, ambient temperatures reaching below 15F (-10 C), including high levels of humidity, an...
Read full bulletin
operator may experience engine stalling, low performance, and or poor aftertreatment performance. This is caused by condensation accumulating and freezing within the Charge Air Cooler (CAC); affecting air flow into the engine. This article lists all the currently available winter front covers that can be installed on the front grille and bumper to reduce cold air flow to the engine compartment.
Title: Engine Emission Label Replacement, Certificate of Conformance and Clean Idle Sticker Addition Procedure Applies...
Read full bulletin
To: All Navistar Powered Trucks Requesting Engine Emission Label Replacement, Certificate of Conformance and/or Clean Idle Sticker, Clean Truck Check
Title: Vehicle Programming Information for Engine: Single Box 1998-2004 I6 & V8 Applies To: Single Box 1998-2004 I6 & V8
Title: How to Request a Horsepower Quote Applies To: All International and Cummins Electronic engines
Applies To: All Navistar Powered Trucks Requesting Engine Emission Label Replacement, Certificate of Conformance and/or...
Read full bulletin
Clean Idle Sticker, Clean Truck Check
Title: Vehicle Programming Information Associated With 2-Box Engines (2002-2006 i6, v6, & v8) Applies To: 2-Box Engines...
Read full bulletin
(2002-2006 i6, v6, & v8)
Engine Oil Capacities.
Read full bulletin
All International electronic engines 1994 to present and Cummins ISB, ISM, or ISX engines
Oil Capacities; All Electronic International Engines 1994 - Present.
Read full bulletin
Cummins ISB, ISM & ISX
Engine Oil Capacities All Electronic International Engines 1994 - Present.
Read full bulletin
Cummins ISB, ISM & ISX
Urea Quality Sensor (UQS) Supplemental Diagnostic and Service Information; only models with SCR Aftertreatment system...
Read full bulletin
and N9, N10, N13, A26 or Cummins ISB, ISL, ISX engines built from January 2016
Engine Oil Capacities
CPA Injector Misfire Detection; Only models with 2004 thru 2017 International engines.
Cylinder Performance Analyzer (CPA) Resource Center; Only models with 2004 thru 2017 International engines.
INTERNATIONAL: INFORMATION PROVIDED REGARDING PROCEDURE TO REPLACING AND ADJUSTING ELECTRIC DOOR DRIVE MOTOR ON BUSES.
Read full bulletin
*PE
INTERNATIONAL: AIR DOOR HAS BENT ADJUSTMENT RODS, POOR LINK ARM CLEARANCE, OPENS DUE TO HIGHWAY SPEEDS OR CROSS WINDS, WATER LEAKS, FAILS TO CLOSE.
Read full bulletin
WHILE ELECTRIC DOOR HAS SIMILAR ISSUES, MOTOR FAILURE, WATER LEAKS, HEADER BOX FIT, POOR LINK ARM CLEARANCE. *PE UPDATED 1/15/13. *PE
Body & Paint
7 bulletinsThis article addresses chassis lean conditions on all chassis.
Read full bulletin
This does not include any diagnostics for body leans such as a cab lean. Keep in mind that a chassis lean may cause or accentuate a cab lean. Filling out the printable form and using the notes in blue will help you to determine the source of the lean and identify the action and parts required to correct the lean.
Aftertreatment Clamp Corrosion; Single Can Aftertreatment Systems
Bus Body Entry Door Switch, LH Panel Mounted
First Check to make when Troubleshooting any Body Controller or ESC Issue
IKNOW: USE THE REINFORCEMENT KIT TO REPAIR BUS DOOR ENTRANCE FAILURES.
Read full bulletin
APPLIES TO VEHICLE MODELS CS, IC, BE CE, FE, RE BUSES BUILT BEFORE 9/15/2011. *JS UPDATED 12/18/13. *PE
NAVISTAR: FORWARD DOOR BRACKET PULLED LOOSE FROM THE DOOR.
Read full bulletin
IMPROPER ADJUSTMENT, LOOSE ATTACHMENT BOLTS, OR AN OBSTRUCTION LIMITING DOOR TRAVEL ARE THE MOST COMMON CAUSE. *RM
INTERNATIONAL BUS: BUS, PASSENGER WINDOW PLASTIC GUIDE.
Read full bulletin
PASSENGER SPLIT SASH WINDOWS THAT ARE HARD TO SLIDE AND EXHIBIT LATCHING ISSUES MAY HAVE THE PLASTIC SLIDE BROKEN LOOSE AND OUT OF POSITION CAUSING THE WINDOW TO BIND. WINDOWS ARE HARD TO SLIDE UP/DOWN; WINDOWS APPEAR TO BE OUT OF SQUARE; AND WINDOWS THAT ONLY LATCH ON ONE SIDE. MODELS BE, CE, FE AND RE BUS. NO MODEL YEARS LISTED. *PE UPDATED 1/7/13. *PE
Electrical
6 bulletinsGeneral wheel speed sensor troubleshooting
Sound Off Bus Monitor Lamps Not Illuminating While Circuits and Exterior Lights are Operating and Test Good
Tool Instruction - BCM Programming Harness
HVAC fault 2609-19 with 4th Gen BCM; Only models equipped with 4th generation BCM
IKNOW: SOME VEHICLES ARE EXPERIENCING REVERSED POLARITY OF THE POWER AND GROUND CIRCUITS TO THE PUMP.
Read full bulletin
THIS CAUSES THE PUMP TO OPERATE BACKWARDS. MODELS INCLUDE ALL CE, RE, AND FE BUSES. NO SPECIFIC MODEL YEARS WERE PROVIDED.*JS
INTERNATIONAL/NAVISTAR: A NEW DESIGN APS SENSORS (ACCELERATOR POSITION SENSOR) HAS BEEN DEVELOPED TO REPLACED...
Read full bulletin
OPEN/CLOSED IVS SWITCHES IN OLD SENSORS. *PE UPDATED 11/6/2013 *JS UPDATED 1/27/15. *PE
HVAC & Climate
4 bulletinsTitle: A/C Refrigerant and Oil Capacities Applies To: All current models
Bus Air Conditioning Service Contacts for HVAC Information
A/C Refrigerant and Oil Capacities
A/C Refrigerant and Oil Capacities
Lighting
3 bulletinsRepair Procedures for Vehicles Struck by Lightning
Bus Strobe Light Replacements
Trailer Auxiliary Switch Lamp Burning Out; Only Vehicles Equipped with Feature Code 0008TTH or 0008THG
Infotainment
2 bulletinsThis tool is designed to compare Diamond Logic feature data across multiple vehicle configuration files.
Read full bulletin
It allows users to quickly load files either manually or directly from the Diamond Logic Builder Vehicles folder using VIN-based selection. As files are added or removed, the comparison runs automatically with no manual action required. The program presents results in an interactive table that shows feature codes, descriptions, access levels, and whether each feature is present in each selected file. Built-in search, filtering, and sorting make it easy to locate specific features or focus only on differences between files. Column visibility can be customized to show or hide descriptions and access information as needed. Users can remove files individually or clear all files at once, with results updating instantly. The tool also includes reporting and export options that reflect exactly what is visible on screen, allowing results to be printed, copied, saved as text, or exported to CSV for use in Excel or other spreadsheet tools. Overall, the program streamlines the process of comparing vehicle feature configurations, helping users quickly identify differences, validate setups, and document results without manual comparison or external tools.
Radio Diagnostics and Information
Brakes
2 bulletinsThis document will guide the user through a step-by-step procedure for detecting water leaks in vehicle cabs and...
Read full bulletin
windshields using an ultrasonic sound detector.
Brake Lights Staying On
Transmission
2 bulletinsTitle: Steering Gear Seal Repair Guidelines Applies To: Steering gears
This article is for adding additional protection to the driver's area of the bus to help mitigate the transmission of...
Read full bulletin
germs.
Suspension
2 bulletinsThis document reminds technicians of the critical relationship between the truck's suspension and the driveline operating angles.
Read full bulletin
The information applies to diesel, gas, and electric vehicles.
Suspension Lean Diagnostics; All models
Software & Calibration
2 bulletinsUsing Supplier Software to Check DTCs
Dealer EZ-Tech and Diagnostic Software Support Resource Center
Steering
2 bulletinsSteering Fluids
Steering Shake, Shimmy, Shudder, or Steering Vibration; only with 14k front weight rated axles and below
Pre-Delivery & Maintenance
1 bulletinTitle: Service Portal iKNow Feedback Case Types Applies To: All
Fuel System
1 bulletinIK1500051 - DAVCO FUEL PRO 382 TECHNICAL MANUAL, INSTALLATION, DIAGNOSTICS, AND SERVICE