2004 Ford F-350 TSBs

FORD: WHEN SHIFTING BETWEEN PARK, REVERSE AND/OR DURING 2-3 SHIFT, AN INTERMITTENT CLUNK OCCURS WITH A TORQSHIFT TRANSMISSION.

FORD: ON SOME TRUCKS, THERE IS A NO CRANK SITUATION AND IF VOLTAGE ON TRANSMISSION RANGE SENSOR AT PIN 21, IS LESS THAN...

1999-2008 7.3L/6.0L/6.4L/4.5L DIESEL F-SUPER DUTY - CLEAN THE CHARGE AIR COOLER (CAC) SYSTEM AFTER CERTAIN TURBO OR ENGINE FAILURES - SERVICE TIP.

6.0L TURBOCHARGER CARBON DEPOSIT DIAGNOSTICS AND SERVICE TIPS.

6.0L DIESEL ENGINE - OIL LEAK OR BOOST PRESSURE LEAK AT HOT SIDE CHARGE AIR COOLER DUCT.

WATER IN THE FUEL TANK BEHIND REAR AXLE - 6.0L, 6.4L AND 7.3L DIESEL ENGINE.

6.0L TURBOCHARGER CARBON DEPOSIT DIAGNOSTICS AND SERVICE TIPS - LACK OF POWER, WHITE OR BLACK SMOKE, SURGE, P0238, P0299, P0404, P2262, AND/OR P2263.

WATCH FOR OIL FLOW FROM THE BASE ENGINE OIL PUMP.

OIL FLOW FROM THE BASE ENGINE OIL PUMP.

REPEAT TURBOCHARGER OR VGT REPLACEMENT.

MISFIRE, LACK OF POWER, BUCK/JERK, EXCESSIVE SMOKE OR CRANK/NO START.

VOLUNTARY EMISSION RECALL 06E17 SUPPLEMENT #1: CONTROL MODULE RECALIBRATION.

LACK OF POWER OR MIL ON - TURBOCHARGER STICKING - REVISED DIAGNOSTICS.

WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING.

SERVICE KIT AVAILABLE FOR WIPER MOTOR WIRING.

VOLUNTARY EMISSION RECALL 05E15 - SUPPLEMENT #2.

INTERMITTENT CRANK NO START DUE TO AN EGR THROTTLE PLATE THAT IS STUCK CLOSED.

RPM SURGE AT IDLE; AUDIBLE EGR SURGE; LOW POWER/SMOKE/ROUGH IDLE FOLLOWING A COLD START THAT CORRECTS AFTER ENGINE IS...

BUCK/JERK, LACKS POWER, BLACK SMOKE, ROLLING IDLE, SURGE, MIL ON, AND DIAGNOSTIC TROUBLE CODES P2263, P0299, OR P0401.

LACK OF POWER AND/OR DTC P2263 OR P0299 AFTER TURBOCHARGER REPLACEMENT - SERVICE TIP.

DIESEL EXHAUST SMELL IN CAB-6.0L ENGINE.

LOW POWER-COLD SIDE CHARGE AIR COOLER (CAC) DISCONNECTED-OIL LEAK AT CAC CONNECTIONS-6.0L-VEHICLES BUILT 4/1/2004 THROUGH 2/15/2005.

USE OF STAINLESS STEEL EXHAUST STUDS IN SERVICE FOR 5.4L 2V ENGINE.

INTERMITTENT ROUGH IDLE - NON-COMMANDED EGR (EXHAUST GAS RECIRCULATION VALVE) FLOW.

OIL LEAK AT THE ENGINE OIL COOLER/OIL FILTER HOUSING - O-RING AVAILABLE FOR SERVICE.

STEERING GEAR NOISE - 6.0L DIESEL ENGINE.

MALFUNCTION INDICATOR LAMP ON WITH MISFIRE DTC'S SPARK KNOCK PISTON SCUFFING.

TURBO-INDUCED EXHAUST MOAN/DRONE AT 1600-1800 RPM - 6.0L BUILT AFTER 9/29/2003.

LOW POWER AND/OR DIAGNOSTIC TROUBLE CODE P0299 OR P2263 - TURBOCHARGER DIAGNOSTIC SERVICE TIP.

HIGH ENGINE RPM BETWEEN DOWNSHIFTS - LACK OF ENGINE BRAKING - 5.4L AND MANUAL TRANSMISSION.

ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS.

LOW POWER - COLD SIDE CHARGE AIR COOLER (CAC) DISCONNECTED - OIL LEAK AT COLD SIDE CAC CONNECTIONS - 6.0L ENGINE -...

TURBO-INDUCED EXHAUST MOAN/DRONE AT 1600-1800 RPM ON 6.0L BUILT PRIOR TO 9/29/2003.

WATER-IN-FUEL LAMP ILLUMINATED AFTER DRAINING HEATED FUEL CONDITIONING MODULE (HFCM) ON VEHICLES BUILT PRIOR TO 11/1/2003 WITH 6.0L ENGINE.

LACK OF POWER AND/OR DIAGNOSTIC TROUBLE CODE (DTC) P2263 AFTER TURBOCHARGER REPLACEMENT.

NO START OR CONSTANT ENGINE MISFIRE - FUEL INJECTION CONTROL MODULE (FICM) DIAGNOSIS - 6.0L DIESEL.

ENGINE OIL LEAKS AT LOWER CRANKCASE.

BROKEN EXHAUST MANIFOLD STUDS.

TURBO MOAN/DRONE NOISE AND TACTILE VIBRATION BETWEEN 1500-2000 RPM.

OIL LEAK FROM FRONT OR REAR OF ENGINE.

DRIVEABILITY CONCERNS AND SET DIAGNOSTIC TROUBLE CODES (DTC'S) P2614 (CAMSHAFT POSITION OUTPUT CIRCUIT OPEN) AND P2617...

CRANK NO START, RUNS ROUGH, ENGINE MISSES, BUCKS/JERKS OR LACKS POWER CONDITION - WIRING HARNESS CHAFING.

LOW POWER CONDITION AND/OR DIAGNOSTIC TROUBLE CODE (DTC) P2263.

OIL LEAK THAT SEEMS TO BE COMING FROM HEAD GASKET AREA.

SPECIAL SERVICE INSTRUCTION 04T03.

ENGINE OIL DILUTED WITH FUEL, RUNS ROUGH AND/OR A LOW POWER CONDITION.

6.0L--MIL ON--P0401, P0402, P0404, P1335--LACK OF POWER OR SURGE WITH SOME 2003-2007 F-SUPER DUTY, 2003-2005 EXCURSION...

AIR FILTER WATER INGESTION / SNOW PACKING WITH CODES P0103.

6.0L OIL SEEP OR BOOST PRESSURE LEAK AT HOT SIDE CHARGE AIR COOLER DUCT.

LACK OF COOLING FAN OPERATION.

COOLANT DEGAS BOTTLE OVERFLOW - 6.0L.

COOLANT DEGAS BOTTLE OVERFLOW.

COOLANT DEGAS BOTTLE OVERFLOW.

BUCK/JERK OR SURGE - 6.0L VEHICLES BUILT BEFORE 8/22/2005.

CUSTOMER SATISFACTION PROGRAM 05B29: SUPPLEMENT#3.

A DRIVELINE CLUNK OR BUMP WHEN STARTING FROM A STOP.

SAFETY BELT RETRACTION SPEED.

VEHICLE LEAN SAG WHEN OBSERVED FROM REAR OF VEHICLE.

DRIVE AWAY SHUDDER OR VIBRATION.

A COLD WEATHER REVERSE ENGAGEMENT STALL.

LACK OF POWER, SURGE, AND/OR DIAGNOSTIC TROUBLE CODES P2263 OR P0299.

DELAYED/HARSH FORWARD OR REVERSE ENGAGEMENTS.

DTC U1262 (SCP COMMUNICATION BUS FAULT) STORED IN THE INSTRUMENT CLUSTER (IC).

LOW RPM, BUCK/JERK, MISS, STUMBLE AFTER DECELERATION DOWN LONG GRADE WITH THE CRUISE CONTROL ENGAGED.

DELAYED/HARSH FORWARD OR REVERSE ENGAGEMENTS.

CLUNK OR POP ON INITIAL ENGAGEMENT FROM REVERSE TO DRIVE AT APPROXIMATELY 2-3 MPH.

LOW POWER/BOOST DUE TO THE PLASTIC CHARGE AIR COOLER (CAC) DUCT BLOWING OFF.

BELT NOISE. *TT

DRIVEABILITY CONCERNS AND SET DIAGNOSTIC TROUBLE CODES P2614 AND P2617.

LACK OF POWER AND/OR DIAGNOSTIC TROUBLE CODE (DTC) P0103 - AIR INDUCTION SYSTEM WATER/SNOW DEFLECTOR KIT.

DIAGNOSTIC TROUBLE CODE (DTC) U1262 (SCP COMMUNICATION BUS FAULT) STORED IN THE INSTRUMENT CLUSTER (IC).

MOAN/DRONE NOISE AND TACTILE VIBRATION BETWEEN 1500-2000 RPM.

FALSE DIAGNOSTIC TROUBLE CODES (DTC'S SET DURING USE OF ACTIVE COMMANDS WITH WDS.

EXCESSIVE DRIVE-AWAY SHUDDER OR VIBRATION UNDER MODERATE TO HEAVY ACCELERATION FROM A STOP.

When performing any transmission fluid changes or topoffs involving MERCON SP, MERCON LV has replaced all versions of...

This SKU is a Transmission Line.

1999-2008 F250-F550 SUPER DUTY 4X4 WITH ELECTRONIC SHIFT TRANSFER CASE NOT ENGAGING 4X4.

TORQSHIFT TRANSMISSION - INTERMITTENT CLUNK WHEN SHIFTING FROM REVERSE GEAR OR DRIVE GEAR TO PARK.

DIAGNOSTIC TROUBLE CODE P0488 AND/OR P1334 WITH NO DRIVEABILITY SYMPTOMS, HARSH SHIFT AND/OR TRANSMISSION ENGAGEMENTS.

MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE (DTC) P0756, P0761 OR P0771 AFTER OVERHAUL OR...

4X4 TRANSFER CASE JUMP OUT OF 4TH OR 4L - MANUAL SHIFT TRANSFER CASE.

LOW/REVERSE GEAR SET PINION SHAFT(S) THAT MAY WALK OUT, CAUSING METALLIC PARTICLE CONTAMINATION.

HARSH/SLIPPING SHIFTS AND/OR HARSH/DELAYED ENGAGEMENT INTO DRIVE OR REVERSE.

TRANSFER CASE SHIFT ISSUES ON VEHICLES WITH AN ELECTRONIC SHIFT ON THE FLY (ESOF) TRANSFER CASE.

MANUAL TRANSMISSION FLUID LEAK.

WHITE/GRAY SMOKE AND VARIOUS DRIVEABILITY CONCERNS AFTER COLD START - TORQSHIFT HARSH DOWNSHIFT AND BUCK/JERK.

HARSH DISENGAGEMENT WHEN SHIFTING FROM REVERSE TO PARK.

VARIOUS DRIVEABILITY CONCERNS - TORQSHIFT HARSH DOWNSHIFT AND CLUCK/BUCK/JERK.

HARSH ENGAGEMENT OR SHIFT ISSUES WITH PULSATING COOLER LINES AND ERRATIC LINE PRESSURE.

HARSH/SLIPPING ENGAGEMENTS, UPSHIFTS AND/OR DOWNSHIFTS ON VEHICLES WITH TORQSHIFT - ADAPTIVE SHIFT STRATEGY.

VARIOUS DRIVEABILITY CONCERNS.

TRANSMISSION GEAR RATIO ERROR - DIAGNOSTIC TROUBLE CODE (DTC) P0730 ON VEHICLES WITH TORQSHIFT TRANSMISSION.

Some 2002-2008 F-Super Duty, F-150 and Mark LT vehicles may exhibit concern during or after programing the VSM.

FORD: THE RESTRAINT CONTROL MODULE (RCM) WHEN USING VCM II, WOULD HAVE AN ERROR CODE 35 AND DIAGNOSTIC TROUBLE CODE...

ADDING ADDITIONAL BULBS TO TURN INDICATOR OR HAZARD FLASHER CIRCUITS.

EXHAUST PRESSURE SENSOR INPUT NO LONGER USED IF PCM IS REPROGRAMMED - SERVICE TIP.

DIAGNOSTIC PROCEDURE FOR TRAILER TOW LIGHTS OR NO POWER DUE TO OPEN FUSE.

DTC'S P0488 (EGR THROTTLE POSITION RANGE/PERFORMANCE) AND/OR P1334 (EGR THROTTLE POSITION SENSOR MINIMUM STOP...

LOW BATTERY VOLTAGE - SNOW PLOW EQUIPPED VEHICLES - 6.0L DIESEL WITH SINGLE GENERATOR.

GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES.

ADDING ADDITIONAL BULBS TO TURN INDICATOR OR HAZARD FLASHER CIRCUITS - SERVICE TIPS.

LOW/OSCILLATING LINE PRESSURE OR LOW/NO PTO TORQUE DUE TO INCOMPLETE PTO WIRING INSTALLATION.

DOOR AJAR LIGHT WORKING IMPROPERLY AFTER VEHICLE SECURITY MODULE REPLACEMENT.

EMISSIONS RECALL 03E03 - POWERTRAIN CONTROL MODULE AND FUEL INJECTOR CONTROL MODULE RE-CALIBRATION.

VARIOUS ELECTRICAL CONCERNS.

MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODES P0603 (POWERTRAIN CONTROL MODULE KEEP ALIVE MEMORY...

NO CRANK/NO START WITH LOW TR-P VOLTAGE.

PCM (POWERTRAIN CONTROL MODULE)/FICM/TCM REPROGRAMMING ERRORS.

LOW CHARGING SYSTEM VOLTAGE WHILE SNOW PLOWING.

WATER IN FUEL LIGHT ON, WHICH DOES NOT TURN OFF AFTER WATER HAS BEEN DRAINED FROM THE HORIZONTAL FUEL CONDITIONING MODULE (HFCM).

LACK OF POWER DUE TO LOW FUEL PRESSURE - FUEL TANK LINER SEPERATION.

LACK OF POWER DUE TO LOW FUEL PRESSURE, FUEL TANK LINER SEPERATION.

COLD START DRIVEABILITY - WHITE SMOKE, LACKS POWER, EXHAUST ODOR, SURGES, RUNS, ROUGH, OR NO START.

WATER-IN-FUEL (WIF) LAMP ON.

WHITE SMOKE, LACKS POWER, EXHAUST ODOR, SURGES, RUNS ROUGH, OR NO START - 6.0L.

FUEL CONDITIONER. LOW POWER, POOR FUEL ECONOMY, FUEL GELLING IN COLD WEATHER, EXCESSIVE WHITE SMOKE ON COLD START, HARD...

LACK OF POWER OR RUNS ROUGH CONDITION, AND/OR THE MALFUNCTION INDICATOR LIGHT ON WITH EGR RELATED DIAGNOSTIC TROUBLE...

MALFUNCTION INDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODE P2614/P2617, MULTIPLE DRIVEABILITY ISSUES AND/OR GLOW PLUG OR WATER-IN-FUEL LAMP FLICKER.

MULTIPLE VEHICLES - FUEL LEVEL INDICATION CONCERNS - SERVICE TIP.

WATER-IN-FUEL (WIF) LAMP.

EXHAUST LEAK NOISE. *TT

LOW POWER, POOR FUEL ECONOMY, FUEL GELLING COLD, EXCESSIVE WHITE SMOKE COLD, OR HARD START.

FUEL SIGNAL TO INSTRUMENT CLUSTER SERVICE TIP.

NORMAL EGR (EXHAUST GAS RECIRCULATION) OPERATION - SERVICE TIP.

DTC'S P006A OR P132B - LACKS POWER, SURGE, OR FLUTTER AFTER FIELD SERVICE ACTION 06E17.

NEUTRAL TOW CAPABILITY - SERVICE KIT REQUIREMENTS.

P0404 SERVICE TIP. *TT

NEUTRAL TOW CAPABILITY -- SERVICE KIT REQUIREMENTS.

RECOMMENDED 12V SWITCHED ACCESSORY SOURCES.

This SKU is a Spare Tire Hoist.

This SKU is a Spare Tire Hoist.

VIBRATION DIAGNOSIS - TIRE/WHEEL RUNOUT.

REAR AXLE POPPING/CHATTER NOISE - DANA 80 MODEL DUAL REAR WHEEL (DRW).

This SKU is a front upper ball joint.

FORD TRUCKS SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER.

STEERING SYSTEM NOISE.

STEERING WHEEL FIGHT AFTER RIDING OVER BUMPS/RUTS.

VACUUM PUMP INOPERATIVE OR RUNS CONTINUOUSLY - CLIMATE CONTROL DEFAULTS TO DEFROST MODE.

VACUM PUMP INOPERATIVE OR RUNS CONTINUOSLY - CLIMATE CONTROL DEFAULT TO DEFROST.

VACUUM PUMP INOPERATIVE OR RUNS CONTINUOUSLY - CLIMATE CONTROL DEFAULTS TO DEFROST.

CLIMATE CONTROL DEFAULTS TO DEFROST.

DRIVEABILITY ISSUES AND/OR DTC P132B, P006A IMMEDIATELY AFTER REPROGRAMMING.

DIAGNOSTIC TROUBLE CODE P0488 SET AFTER REFLASH.

WARNING INDICATORS-PARKING AID-REVERSE SENSING SYSTEM (RSS) AND FORWARD SENSING SYSTEM (FSS)-FALSE ACTIVATION OF WARNING TONE-SERVICE TIPS.

HEADLIGHT ADJUSTMENT - CHASSIS CAB INCOMPLETE VEHICLES.

MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - SYSTEM LEAN DIAGNOSTIC TROUBLE CODES (DTC'S) - SERVICE TIPS.

MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE (DTC) P2263.

WATER LEAK - ROOF FLANGE AREA - WATER ACCUMULATION IN HEADLINER AND/OR LEAK AT THE CAB FLOOR PAN AREA.

SERVICE TIPS BEFORE ARC WELDING ON THE FRAME OR BODY OF A UNIT.

AIR INDUCTION SYSTEM APPEARS TO BE WARPED AND/OR NOT SEALING.

BRAKE BOOSTER SYSTEM MAY EXHIBIT A BRAKE PEDAL KICKBACK AND/OR GRABBING CONDITION WHEN APPLYING THE BRAKES.

WIRELESS KEYPAD INOPERATIVE - SERVICE TIP.

FRONT HUBS NOT ENGAGING, NOT STAYING ENGAGED AND/OR UNLOCKING.

REAR LEAF SPRING NOISE.

POPPING OR QUAVERING FROM RADIO ON THE AM BAND.

AIR BAG LIGHT ON WITH DIAGNOSTIC TROUBLE CODE (DTC) B1871 OR B1935 FOLLOWING ECS/RCM REPLACEMENT.