1993 Ford F-250 TSBs

INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS.

SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM.

VEHICLES MAY EXPERIENCE SOLID PARTICLE CONTAMINANTS FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR, MAY BE TRAPPED IN...

INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP.

TRANSMISSION- E40D/4R100-1989-99-MAIN CONTROLS, SEPARATOR PLATES AND SEPARATOR PLATE GASKETS USAGE CHART.

TRANSMISSION-E40D-NO 2-3 UPSHIFT.

SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62,628, AND/OR 1728.

INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART.

FLUID- TRANSMISSION FLUID USAGE CHARTS.

TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP.

TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP.

INFORMATION ON AODE/4R7W TRANSMISSION MAIN CONTROL & CASE REPLACEMENT.

4X4 FRONT AXLES MUST USE HYPOID 4X4 GEAR OIL P/N F1TZ-19580-A & HIGH TEMP 4X4 FRONT AXLE & WHEEL BEARING GREASE WHEN SERVICING.

STEERING GEAR-REPLACEMENT OF BENDIX, STEERING GEAR WITH NEW ROSS STEEERING GEAR.

DELAYED FORWARD ENGAGEMENT AND/OR HEAT STAINED FORWARD CLUTCH PLATES AFTER INSTALLING CENTER SUPPORT SERVICE.

REVISED DESIGN TRANSMISSION REAR CASE BUSHING.

NEW DESIGN TRANSMISSION RANGE SENSOR.

VEHICLES WITH MANUAL TRANSMISSION MAY HAVE A LACK OF POWER OR NO START CONDITION CAUSED BY A PLUGGED CATALYTIC CONVERTER OR MUFFLER.

NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS.

SERVICE TIP INFORMATION REGARDING THE REVERSE CLUTCH PISTON AND PISTON SEAL USAGE.

EXHAUST LEAK AT EXHAUST MANIFOLDS--VEHICLE EQUIPPED WITH 7.0L 0R 7.5L ENGINE.

FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR.

SOME VEHICLES MAY DEVELOP "CAVITATION" EROSION IN THE CYLINDER WALL OF THE ENGINE.

FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS.

FRONT CALIPER PISTON BOOTS DAMAGED.

NEW CLUTCH SLAVE CYLINDER WITH A REDESIGNED LIP SEAL.

THE CLUTCH MAY BE HARD TO DEPRESS DUE TO DUST/CONTAMINATION ENTERING THE SLAVE CYLINDER.

EXHAUST LEAKS OR NOISE AT THE JOINT BETWEEN THE Y-PIPE AND THE EXHAUST MANIFOLD.

ACCESSORY DRIVE BELTS- FEAD BELT COMES OFF- VEHICLES WITH 4.9L ENGINE.

EXHAUST - EXHAUST LEAK AT EXHAUST MANIFOLDS - VEHICLES EQUIPPED WITH 7.0L OR 7.5L ENGINE.

VIBRATION - DRIVELINE VIBRATION AND/OR DRIVELINE NOISE - REGULAR CAB 4X4 VEHICLES EQUIPPED WITH 7.5L ENGINE AND MANUAL TRANSMISSION.

VEHICLES MAY EXHIBIT AN EXHAUST LEAK &/OR NOISE DUE TO WARPED EXHAUST MANIFOLDS.

ENGINE- 'KNOCKING' NOISE - WHEN OPERATING ENGINE AT 200-2300 RPM - FD1460 ENGINE

GENERATOR-MOTORCRAFT 95AMP-FRONT BEARING CONCERN-FD1060/1460 ENGINES- VEHICLES BUILT BEFORE 7/3/95.

KNOCKING NOISE ON INITIAL START-UP.

DURING HIGHWAY DECELERATION OR ENGINE START-UP, THERE MAY BE A HOOTING NOISE COMING FROM THE ENGINE COMPARTMENT.

EARLY WEAR OF FEAD TENSIONER PULLEY ON VEHICLES WITH 5.0L/5.8L ENGINES.

THERE MAY BE A CONCERN OF POOR PERFORMANCE, COOLANT IN THE OIL AND ENGINE KNOCKING AND/OR HYDRAULIC LOCK ON SOME VEHICLES.

FRONT END SHIMMY MAY OCCUR AT VARIOUS DRIVING SPEEDS AND IS USUALLY INDUCED WHEN HITTING BUMPS, SUCH AS LARGE POTHOLES OR ROUGH RAILROAD CROSSINGS.

INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA.

CONCERNS WITH AXLE WIND-UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS.

RECOMMENDED GUIDELINES FOR TOWING BEHIND RECREATIONAL VEHICLES.

PART NUMBER INFORMATION FOR THE USE OF A CHILD SEAT TETHER.

VEHICLES MAY EXHIBIT A DRIVELINE VIBRATION OR NOISE WHILE DRIVING AT HIGHWAY SPEEDS ON STEADY CRUISE OR DECEL.

VEHICLES EXPERIENCING OCCASIONAL HARSH REVERSE ENGAGEMENT CONCERNS.

UNKNOWN

UNKNOWN

UNKNOWN

REVISED OIL PAN GASKET.

UNKNOWN

INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT.

AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT.

THE PARKING BRAKE PEDAL MAY GO TO THE FOOR WITH LITTLE OR NO EFFORT DURING APPLICATION.

THE REAR PARKING BRAKE CABLES MAY BIND AND NOT ALLOW THE REAR BRAKE SHOES TO RETURN FULLY TO THE ANCHOR PINS AFTER THE PARKING BRAKE IS APPLIED.

SOME VEHICLES MAY EXHIBIT EXCESSIVE BRAKE PEDAL TRAVEL, IRREGULAR FRONT LINING WEAR, AND BRAKE PULL.

THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE.

SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS.

HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE.

BRAKES - ELIMINATION OF SANDING ROTORS AND DRUMS - SERVICE TIP.

BRAKES - REAR PARKING BRAKE CABLE BINDS - VEHICLES BUILT BEFORE 8/20/96 - ALL CHASSIS CAB VEHICLES ARE EXCLUDED.

THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE BECAUSE IT MAY BE...

EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP.

EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM.

INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM.

FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE.

ACCESSORY DRIVE BELTS - ALL 7.3 IDI DIESELS COME OFF ACCESSORY DRIVE PULLEYS - VEHICLES BUILT AFTER 2/15/92.

HYDROMOUNTED CAB - EVAPORATIVE EMISSION LINES RUBBING ON THE FENDER.

SOME VEHICLES MAY EXHIBIT A LACK OF POWER OR A NO START CONDITION DUE TO AN EXHAUST RESTRICTION.

LACK OF POWER OR NO START CONDITION MAY BE DUE TO EXHAUST RESTRICTION CAUSED BY A PLUGGED CATALYTIC CONVERTER AND/OR MUFFLER.

SOME DIESEL POWERED VEHICLES ARE EXPERIENCING DRIVE BELT TRACKING CONCERNS DUE TO FRONT END ACCESSORY DRIVE PULLEYS (FEAD) MISALIGNMENT.

SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS.

INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS.

PERFORMANCE ENHANCEMENT FOR DEFROSTER.

INFORMATION ON THE DEFROSTER PERFORMANCE ENHANCEMENT.

ANNOUNCING THE FORD OEM AIR CONDITIONING RETROFIT KIT AVAILABILITY.

AIR CONDITIONING - COMPRESSOR FAILURE - INSUFFICIENT AMOUNT OF REFRIGERANT OIL.

SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES.

WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS.

UNDER HOOD WIRE HARNESS MAY BECOME CHAFED.

SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP.

SUBJECT PERTAINING TO RED RUST STAINS ON THE EDGES OF THE BUMPER CENTER VENT AND FOG LAMP OPENINGS.

WINDSHIELD AND INTERIOR GLASS - FOG/FILM.

POP/CLUNK FROM STEERING LINKAGE OVER BUMPS.

POP/CLUNK FROM STEERING LINKAGE OVER BUMPS.

POP/CLUNK FROM STEERING LINKAGE OVER BUMPS.

SOME VEHICLES MAY EXPERIENCE AXLE WIND UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING...

INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE.

FRAME- RIVET REPLACEMENT WITH BOLTS- SERVICE TIPS.

DIAGNOSTIC GUIDES FOR OUT-OF-WARRANTY VEHICLES TO BE USED AS A MASTER COPY - DIAGNOSTIC GUIDES NO LONGER AVAILABLE FROM ADISTRA.

NOISE- "POPPING/CREAKING"- FRONT FRAME OR SUSPENSION BRACKETS- FRAME- "POPPING/CREAKING"- FASTENER REPLACEMENT.

A RATTLE FROM THE SPLIT SEAT BENCH MAY BE DUE TO A LOOSE OR MISSING SEAT BUSHING.

EXPERIENCING A WHINING / BUZZING NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO.

HEADLAMP- HEADLAMP HOUSING MELTS- AMBULANCE AND EMERGENCY VEHICLES ONLY.