2009 Micro Bird G5

EQUIPMENT ADAPTIVE/MOBILITY

CORP. MICRO BIRD HAS NOTIFIED NHTSA ABOUT A DEFECT IN CERTAIN MODEL YEAR 2007 THROUGH 2010 SCHOOL BUSES MANUFACTURED BETWEEN DECEMBER 2007 AND MARCH 2010 FITTED WITH RICON PUBLIC USE S AND K SERIES WHEELCHAIR LIFTS. THE RESTRAINT BELT ON THESE LIFTS WAS DESIGNED TO PREVENT THE LIFT FROM MOVING, UNLESS THE TONGUE OF THE BELT IS FULLY ENGAGED AND LATCHED IN THE BUCKLE. RICON HAS DISCOVERED, HOWEVER, THAT IT IS POSSIBLE FOR THE OPERATOR TO INSERT THE BELT TONGUE INTO THE BUCKLE WITHOUT FULLY ENGAGING THE LATCHING MECHANISM. IN THIS CASE, THE RESTRAINT BELT WOULD APPEAR TO BE LATCHED, AND THE OPERATOR COULD RUN THE LIFT. IF THE RESTRAINT BELT TONGUE IS NOT FULLY ENGAGED INTO THE RESTRAINT BELT BUCKLE, AND LATCHED, THE LIFT MAY OPERATE WITH AN OCCUPANT ON THE PLATFORM.

EQUIPMENT ADAPTIVE/MOBILITY

CORP. MICRO BIRD HAS NOTIFIED NHTSA ABOUT A DEFECT IN CERTAIN MODEL YEAR 2009 AND 2010 SCHOOL BUSES MANUFACTURED BETWEEN OCTOBER 2008 AND MARCH 2010 FITTED WITH RICON PUBLIC USE S AND K SERIES WHEELCHAIR LIFTS. DUE TO A PROBLEM IN THE SOFTWARE THAT CONTROLS THE LIFTS UP FUNCTION, IF THE SWITCH IS RELEASED BEFORE THE FLOOR LEVEL LIMIT SWITCH IS ACTIVATED, THE LIFT MAY CONTINUE ITS UPWARD TRAVEL FOR APPROXIMATELY 1 SECOND BEFORE STOPPING. THE CONTINUED UPWARD TRAVEL MAY OVERRUN THE FLOOR LEVEL CUT OFF POINT.

EQUIPMENT

CERTAIN GIRARDIN MODEL YEAR 2006 THROUGH 2010 AND MICRO BIRD BY GIRARDIN MODEL YEAR 2009 THROUGH 2010 G5 AND 2003 THROUGH 2006 GIRARDIN MB IV TRANSIT BUSES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 217, "BUS EMERGENCY EXISTS AND WINDOW RETENTION AND RELEASE." THE VEHICLES ARE EQUIPPED WITH THERMAL T-SLIDER OR PANORAMIC TYPE PUSH-OUT WINDOWS WITH 2 RELEASE MECHANISMS (ONE ON EACH SIDE). THE WINDOW HANDLE BASE SPACER PLATE CAN TEAR DUE TO THE ROTATION OF THE EXTERIOR WINDOW FRAME.

STRUCTURE:BODY

MICRO BIRD IS RECALLING CERTAIN MODEL YEAR 2009 THROUGH 2012 G5 SCHOOL BUSES MANUFACTURED FROM NOVEMBER 24, 2009, THROUGH DECEMBER 3, 2011. THE JOINT ON THE METAL CEILING PANEL FAILS TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 221, "SCHOOL BUS BODY JOINT STRENGTH."

EQUIPMENT ADAPTIVE/MOBILITY

MICRO BIRD IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2010 MICRO BIRD G5 TRANSIT BUSES EQUIPPED WITH BRAUN CENTURY-2 AND VISTA-2 WHEELCHAIR LIFTS. OVER TIME AND WITH FREQUENT USE, THE ROLL STOP LATCHES ON THE OUTER BARRIER MAY BECOME BENT OR MISALIGNED.