Free Preview
#BS-2007-KENC50-6D5C2007 Kenworth C500
Based on reports from 1 owners and 6 recalls for this exact model.
Preliminary Verdict
Green Light
Based on 1 complaints, 0 crashes, 0 fires, and 6 recalls.
Preview: What's in your full report
Each card shows a real sample from your report — unlock all 10 sections from $1.20
Mechanic Inspection Checklist
1 owners reported other issues.
30,000-Mile Cost Projection
Best Case
Most Likely
Worst Case
Top cost driver: Other (1 reports).
Also in your report
Owner Intelligence
AI-synthesized themes from real complaints
Buyer Lot Checklist
Questions, test drive checks, walk-away triggers
Negotiation Talking Points
Data-backed dollar deductions
Buy / Skip Verdict
Final recommendation with conditions
Where the complaints fall
2007 Kenworth C500: Known Issues & Problem Areas
Data sourced from NHTSA owner complaints and community reports. The full report analyzes severity, repair costs, and failure patterns for each category.
Don't negotiate blind — know what this car costs to own
Repair costs • Negotiation scripts • Mechanic checklist • Buy/skip verdict
Recall History (6 recalls)
SERVICE BRAKES, AIR
CERTAIN TRUCKS FAIL TO COMPLY WITH THE BRAKE TIMING REGULATORY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 121, "AIR BRAKE SYSTEMS." THE BRAKE VALVE WAS MOVED TO THE OPPOSITE RAIL, INCREASING THE LENGTH OF THE AIR LINE, WHICH IN TURN INCREASED THE WHEELBASE REQUIRING A DUAL RELAY VALVE SYSTEM. THE VEHICLES WERE MANUFACTURED WITH A SINGLE VALVE SYSTEM.
POWER TRAIN:AUTOMATIC TRANSMISSION
ON CERTAIN TRUCKS, THE WIRING, PARTS, OR TRANSMISSION PROGRAMMING REQUIRED FOR THE AUTO NEUTRAL FEATURE TO FUNCTION AS DESIGNED WERE EITHER NOT INSTALLED, CONNECTED, OR PROGRAMMED PROPERLY.
STRUCTURE:BODY:HOOD
ON CERTAIN TRUCKS, THE REAR HOOD MOUNTING BRACKETS CAN CONTACT THE FRONT AXLE BRAKE CHAMBER DURING FULL AXLE ARTICULATION.
SERVICE BRAKES, AIR:SLACK ADJUSTERS
PACCAR IS RECALLING 130 MY 2005-2007 KENWORTH C500, T800, W900, AND PETERBILT MODELS 357 AND 379 TRACTOR TRAILERS EQUIPPED WITH FABCO SLACK ADJUSTERS ON SISU AXLES. THE SLACK ADJUSTERS MAY FAIL AS A RESULT OF A FATIGUE CRACK RENDERING THE SLACK ADJUSTER INOPERATIVE. THIS COULD REDUCE BRAKING EFFECTIVENESS.
TRAILER HITCHES:FIFTH WHEEL ASSEMBLY
PACCAR IS RECALLING 3,573 MY 2007 KENWORTH C500, T800, T600, T2000, AND W900 CHASSIS BUILT WITH PHILLIPS QCS II TRAILER CABLE CONNECTION AND TRAILER CABLE MOUNTING BRACKET WITH 'U-SHAPED' CUT OUT. CERTAIN TRAILER CABLE MOUNTING BRACKETS HAVE A 'U-SHAPED' CUT OUT THAT ONLY PARTIALLY SUPPORTS THE TRAILER CABLE CONNECTION. PARTIAL SUPPORT OF THE CABLE CONNECTION MAY ALLOW THE MOLDED BOOT AND ELECTRICAL GROUND PIN TO PARTIALLY OR COMPLETELY PULL AWAY FROM THE 7-WAY SOCKET. PARTIAL OR COMPLETE DETACHMENT OF THE CABLE CONNECTION CAN CAUSE REDUCED WATER RESISTANCE AND POTENTIAL LOSS OF ELECTRICAL GROUND. THERE IS ALSO A POSSIBILITY THE TRAILER LIGHTS MAY FAIL TO ILLUMINATE WITHOUT THE OPERATOR'S KNOWLEDGE.
+ 1 more recall in the full report
Recall severity analysis & seller scripts
The full report rates each recall's severity and gives you scripts for asking the seller about recall completion.
About this data
NHTSA Complaints
Federal database of owner-filed safety complaints. 1 records for this vehicle.
NHTSA Recalls
Manufacturer-issued safety recalls. 6 recalls found for this vehicle.
Repair Cost Data
Real-world repair costs from owner reports and independent databases.
Other Kenworth C500 Model Years
2007 Kenworth C500: Frequently Asked Questions
What is the most common problem with the 2007 Kenworth C500?
Is the 2007 Kenworth C500 reliable?
How much does it cost to fix 2007 Kenworth C500 problems?
Does the 2007 Kenworth C500 have any recalls?
What mileage do Kenworth C500 problems start?
What’s in the full report?
How is this different from free NHTSA data?
How is this different from Carfax?
What if the report isn’t useful?
Get the Full 2007 Kenworth C500 Report
10 sections of AI analysis based on 1 owner reports. Know before you buy.