2010 Blue Bird Micro Bird

SEATS

BLUE BIRD IS RECALLING 69 MODEL YEAR 2008 THROUGH 2010 MICRO BIRD AND VISION SCHOOL BUSES MANUFACTURED FROM SEPTEMBER 29, 2007 THROUGH MAY 2, 2009, EQUIPPED WITH OPTIONAL 34 INCH OFFSET BARRIER. THE OFFSET LEG OF THE BARRIER FRAME MAY HAVE BEEN LOCATED INCORRECTLY AND INCORRECT PADDING MAY HAVE BEEN INSTALLED ON THE 34 INCH OFFSET BARRIERS WHICH FAILS TO COMPLY WITH THE LEG PROTECTION ZONE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 222, "SCHOOL BUS PASSENGER SEATING AND CRASH PROTECTION."

SEATS

BLUE BIRD IS RECALLING CERTAIN MODEL YEAR 2004 THROUGH 2010 ALL AMERICAN, VISION, MICRO BIRD, AND CONVENTIONAL SCHOOL BUSES MANUFACTURED BETWEEN JANUARY 30, 2003 AND MAY 7, 2009. INCORRECT OFFSET LEG BARRIER PADS OR 2/3 SEAT BACK PADS MAY HAVE BEEN INSTALLED. BUSES WITH INCORRECT PADS INSTALLED FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 222, "SCHOOL BUS PASSENGER SEATING AND CRASH PROTECTION."

EQUIPMENT:OTHER:LABELS

CERTAIN MODEL YEAR 2006 THROUGH 2010 BLUE BIRD MICRO BIRD SINGLE REAR WHEEL MODEL SCHOOL BUSES MANUFACTURED FROM AUGUST 31, 2005 THROUGH SEPTEMBER 27, 2009, FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." IF THE VEHICLE IS NOT EQUIPPED WITH A SPARE TIRE, THEN THE TIRE AND LOADING PLACARD SHOULD INDICATE "NONE" UNDER THE SIZE AND RECOMMENDED TIRE INFLATION PRESSURE. THE PLACARD LISTED INFLATION PRESSURE FOR A SPARE TIRE THAT WAS THE SAME AS THE FRONT TIRE INFLATION PRESSURE.

STRUCTURE:BODY:ROOF AND PILLARS

BLUE BIRD IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2010 MICRO BIRD SCHOOL BUSES MANUFACTURED FROM AUGUST 28, 2007 THROUGH OCTOBER 29, 2009. AN INCORRECT NUMBER OF RIVETS MAY HAVE BEEN INSTALLED IN THE FRONT ROOF CAP THAT ATTACHES TO THE FRONT ROOF SHEET. THESE BUSES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 221, "SCHOOL BUS BODY JOINT STRENGTH."

EQUIPMENT ADAPTIVE/MOBILITY

BLUE BIRD HAS NOTIFIED NHTSA ABOUT A DEFECT IN CERTAIN MODEL YEAR 2008 THROUGH 2011 ALL AMERICAN, CONVENTIONAL, AND MICRO BIRD SCHOOL BUSES MANUFACTURED FROM DECEMBER 13, 2007 THROUGH JANUARY 18, 2010 EQUIPPED WITH RICON MODEL S OR K SERIES PUBLIC USE WHEELCHAIR LIFTS. THE RESTRAINT BELT ON THESE LIFTS WAS DESIGNED TO PREVENT THE LIFT FROM MOVING, UNLESS THE TONGUE OF THE BELT IS FULLY ENGAGED AND LATCHED IN THE BUCKLE. RICON HAS DISCOVERED, HOWEVER, THAT IT IS POSSIBLE FOR THE OPERATOR TO INSERT THE BELT TONGUE INTO THE BUCKLE WITHOUT FULLY ENGAGING THE LATCHING MECHANISM. IN THIS CASE, THE RESTRAINT BELT WOULD APPEAR TO BE LATCHED, AND THE OPERATOR COULD RUN THE LIFT. IF THE RESTRAINT BELT TONGUE IS NOT FULLY ENGAGED INTO THE RESTRAINT BELT BUCKLE, AND LATCHED, THE LIFT MAY OPERATE WITH AN OCCUPANT ON THE PLATFORM.