2014 Western Star 4900 TSBs
677 Technical Service Bulletins across 17 categories
Categories
Other
253 bulletinsTech Talk discussion on repair verification for codes like 'low air flow' when a trailer is not available.
Tool Letter for ICC5 Programming Cable
Tool Letter for New Tool Kit Replacement Components DDE DKICHA018006 Components 1, 2 and 3
SPN 3226 (ACM) (GHG17)
SPN 96 (MCM) (GHG17)
SPN 3226 (ACM) (GHG17)
Diagnostic tests - Two Filter System - FSIC Leak Test
SPN 3464 (MCM) (GHG14)
SPN 712 (CPC) (GHG17)
Technical Publications Ordering
SPN 3226 (ACM) (GHG17)
SPN 96 (MCM) (GHG17)
SPN 3226 (ACM) (GHG17)
Diagnostic tests - Two Filter System - FSIC Leak Test
SPN 3464 (MCM) (GHG14)
SPN 712 (CPC) (GHG17)
SPN 3226 (ACM) (GHG17)
SPN 96 (MCM) (GHG17)
SPN 3226 (ACM) (GHG17)
Diagnostic tests - Two Filter System - FSIC Leak Test
SPN 3464 (MCM) (GHG14)
SPN 712 (CPC) (GHG17)
Instructions for CSC Diagnostic Support
SPN 3556 (ACM) (GHG14)
Operating Hours for the Customer Assistance Center
Vehicles with Meritor drivelines bene from a softer durometer center bearing support.
Read full bulletin
Vehicle will continue to have a 1st order driveline vibration after the driveline assembly was rebalanced.
0505-18 SPN 3563 HDEP Inlet manifold pressure Too Low
ICI18-016 FL756 ? Automotive Connector Terminal Removal Tool
SS1033446 Driveline Support Bearing - Meritor Driveline
0505-18 SPN 3563 HDEP Inlet manifold pressure Too Low
The automatic connector terminal removal tool is part of tool kit DDE KI0CHA17001.
MY18M1a 05-MAR-2018 Vocational
0402-18 SPN 625 (CPC) (GHG14)
0401-18 SPN 1231 (MCM) (EPA10 GHG14)
528-13 SPN 3246-FMI 0 - EPA10 - GHG14
527-13 SPN 190-FMI 15,17 GHG14
518-13 SPN 4334-FMI 4 - GHG14
0105-15 SPN 102 (MCM) (GHG14)
0108-15 SPN 1323 through 1328 (MCM) (GHG14)
0106-15 SPN 3251 (ACM) (EPA10) and (GHG14)
0104-15 SPN 3464/ FMI 16, 18 (MCM) (GHG14)
0101-15 SPN 4364 (ACM) (EPA10)
0107-15 Enhanced Steam Clean
sbw2018 Western Star 4800 and 4900 Radiator Mounting
(CPC)(EPA10-GHG14) and SPN 98 (CPC)(GHG17)
0301-17 Contaminated Fluids
sbw0001Validity List Western Star
418-13 SPN 2791-FMI 12 - GHG14
603-13 SPN 84 -FMI 6 - EPA07-GHG14
711-13 SPN 100-FMI 4 - ALL YEARS
717-13 Oil Pan
sbw5455 Virtual Technician Retrofit
324-15 External Component Repair
304-15 Diagnostic Tests
303-15 Contaminated Fluids
325-15 Symptom Diagnosis - ATD Checklist
323-15 Symptom Diagnostics ? Noise
306-15 SPN 3246 (ACM)(EPA10;GHG14)
309-15 SPN 3251 (ACM)(EPA10)
307-15 SPN 3480 (MCM) (EPA07;EPA10;GHG14)
321-15 SPN 4364 (ACM) (GHG14)
320-15 SPN 4374 (ACM) (GHG14)
301-15 SPN 3251 (ACM) (EPA10) and (ACM) (GHG14), 3936 (ACM)
14TS15 Issues with PTO and Remote Throttle Combinations
522-14 Removal and Installation of the Oil Pump Cover
518-14 FMI 1, 18: Regen Temperature- Out Of Range Low
519-14 FMI 1: SCR NOx Conversion Efficiency Very Low
517-14 FMI 18: SCR NOx Conversion efficiency low
607-13 SPN 3361-FMI 7- EPA10
0402-18 SPN 625 (CPC) (GHG14)
0401-18 SPN 1231 (MCM) (EPA10 GHG14)
ssbw49019 Manguera de presin del lquido de escape disel (DEF) desconectada en la conexin del dosificador
ssbw42010 Inspeccin de fugas de aire del transportista concesionario
fsbw42009 Diagnostic de fuite d'air
13WO-2-New Standard Rpr Times orgl 11WO2 New Standard Repair Times for EPA07-10 DD13-15 Diagnostic Tests
sbw5455 Virtual Technician Retrofit
13TS12 HDEP Wastegate Solenoid Air Leaks
13TS8 GHG14 Throttle Codes SPN 91-FMI 7 and SPN 91-FMI 10
311-13 SPN 651-FMI 3 - EPA10 - GHG14
303-13 SPN 3242-FMI 4 -EPA10 - GHG14
301-13 SPN 5018- FMI 18 -GHG14
ICI12-024-DLR SF453 - Termination Date Extended
sbw3109 Huck-Spin 2 Changeover
102-13 SPN 84-FMI 13, 19, 21 (MCM) EPA10-GHG14
107-13 SPN 84-FMI 7 - GHG14
106-13 SPN 100-FMI 10 - GHG14
105-13 SPN 625-FMI 13 - GHG14
135-13 SPN 1243-FMI 14 - GHG14
104-13 SPN 1592-FMI 13 and 19 - GHG14
137-13 SPN 2798-FMI 4 - EPA10 - GHG14
109-13 SPN 3250-FMI 31 (ACM2.1) GHG14
139-13 SPN 3251-FMI 0, 16, 20, 21 GHG14
108-13 SPN 3364-FMI 18 - GHG14
101-13 SPN 3563 FMI 21 - GHG14
132-13 SPN 3597-FMI 4 - EPA10
146-13 SPN 4335-FMI 1 EPA10
133-13 SPN 4375-FMI 4 and 5 - GHG14
112-13 SPN 4364-FMI 18 - GHG14
111-13 SPN 4374/FMI 0, 1, 3, 4 - GHG14
110-13 SPN 5435-FMI 7 - GHG14
128-13 SPN 511403-FMI 0,1,2,3,4,5,6,8,9,10,11,12,13,14
103-13 SPN 520328-FMI 7 - GHG14
0201-15 SPN 3250 FMI 31 - GHG14
0204-15 Symptom Diagnostics: Noisy One-Box Aftertreatment
0203-15 Oil Filter Stand Pipe
704-15 SPN 4364 (ACM)(EPA10)
706-15 SPN 1323 (MCM) (GHG14) SPN 1324 (MCM) (GHG14) SPN 1325
sbw5463 Nexiq USB-Link Upgrade and Diagnostic Connector
805-15 FMI 0: Selective Catalyst Reduction Outlet Temperature High
sbw4911 DEF Gauge Reading Incorrectly
SPN 157 (MCM) (GHG17)
MY18M1a_05-MAR-2018_Vocational
SPN 1663 (CPC) (EPA07 10 GHG14 GHG17)
Magnetized Fill Neck for Six-Gallon DEF Tanks
0137-17 SPN 3361 FMI 5 (ACM) (GHG17) SPN 3361 FMI 5 (ACM) (GHG14)
0130-17 SPN 520211 (IPPC) (GHG14) SPN 520211 (IPPC) (GHG17)
0127-17 SPN 1077 FMI 14 (GHG14) (GHG17) (MCM)
0115-17 SPN 3226 (ACM) (EPA10;GHG14)
1207-16 SPN 4363 (ACM) (EPA10 GHG14)
1213-16 SPN 3480 (MCM) (EPA07;EPA10 GHG14)
15TS16Rev1 EPA10 Reman MCM Improvement for Fault Codes SPN 651 to 656
1202-15 Symptom Diagnostics - ATD Checklist
FMI 2 CPC Clock Data Invalid
SPN 2623 (CPC)(GHG17), SPN 2623 (CPC)(GHG14), and SPN 2623 (CPC)(EPA07 EPA10 GHG14)
SPN 3226 (ACM) (EPA10;GHG14)
12-022-DLR Daimler Trucks Remarketing Corporation (DTR) Now Requires Pre-approval for Repairs $1,200 (USD) and Greater
15TS3 Detroit? Coolant Change From Nitrite Organic Acid Technology
405-15 Symptom Diagnostics - Hard Start/No Start - Two-Filter System
406-15 SPN 97 (MCM) (EPA10) / SPN 97 (MCM) (GHG14)
403-15 SPN 677 (MCM)(EPA07)
402-15 SPN 2630 (MCM)(EPA10) and SPN 2630 (MCM)(GHG14)
404-15 SPN 4364 (ACM) (EPA10)
15CSA10 The Detroit CSC announcing a new feature ? Ability to attach files to an existing CSC
15CSA9 Release of DiagnosticLink 8.02
sbw2023 Modine Copper/Brass Bolted Downflow Radiator Rebuilding
505-15 SPN 3361 (ACM) (EPA10)
507-15 SPN 1590( CPC)(GHG14) and SPN 1590 (CPC)(EPA07;EPA10)
508-15 SPN 625 (MCM)( EPA10;GHG14)
FL680 Kidde Fire Extinguishers
15-009_Detroit_New_SDTs
15TL5 DAVCO Shop Pro FXP 95
324-15 External Component Repair
304-15 Diagnostic Tests
303-15 Contaminated Fluids
325-15 Symptom Diagnosis - ATD Checklist
323-15 Symptom Diagnostics ? Noise
306-15 SPN 3246 (ACM)(EPA10;GHG14)
309-15 SPN 3251 (ACM)(EPA10)
307-15 SPN 3480 (MCM) (EPA07;EPA10;GHG14)
321-15 SPN 4364 (ACM) (GHG14)
320-15 SPN 4374 (ACM) (GHG14)
301-15 SPN 3251 (ACM) (EPA10) and (ACM) (GHG14), 3936 (ACM)
15CSA4 Holiday Schedule for the Detroit Customer Support Center
15-009 New Detroit Standard Diagnostic Times
713-14 Symptom Diagnostics - Combustion Gas in Coolant
715-14 Symptom Diagnostics - Coolant Los
719-14 SPN 84 (CPC) (GHG14)
710-14 SPN 96 (CPC) (GHG14)
711-14 SPN 107 (CPC) (GHG14
701-14 SPN 168 FMI 0 and 1 (IPPC)(GHG14
706-14 SPN 171 FMI 3, 4 (CPC)(GHG14)
709-14 SPN 3216 (MCM) (GHG14)
703-14 SPN 3556 (ACM) (EPA10)
716-14 SPN 4077 (MCM)(EPA07 EPA10;GHG14
704-14 SPN 520200 FMI 6 (IPPC)(GHG14)
705-14 SPN 520203 FMI 6 (IPPC)(GHG14)
707-14 SPN 520229 FMI 3 (IPPC) (GHG14
702-14 SPN 520230FMI 5 (IPPC)(GHG14)
14-028 Remy Extended Coverage Direct File
14-027 Detroit's New Consolidated Labor Operations (CLOs
14-023 Detroit Axles Pre-Approval Changes
14-022 Pre-Approval Threshold Increase From $2,500 to $5,000 USD
16TL4 DOC Face Cleaning Tool P N W470589239100
16TS5 Release of the DD Platform Bearing Failure Guide
0304-16 SPN 2791 (MCM) ( GHG14) and SPN 2791 (MCM) ( GHG17)
0307-16 SPN 723 (MCM) March
0301-16 SPN 625 (CPC) (EPA07) and SPN 625 (CPC) (EPA10 GHG14)
Contaminated Fluids
Hydrocarbon Doser Coolant Lines
16-009R_OWL Enhancements
New Detroit Bearing Failure Analysis Standard Diagnostic Time
SF514 Revised Bulletin
17TL27 Injector Cup Tool DSN930E17001
17TL26 Injector Heat Sleeve Removal Tool DSN930E17002
sbw4911 DEF Gauge Reading Incorrectly
sbw4910 Gentech DEF Coolant-Flow Solenoid, Testing and Replacement
12-027-DLR Detroit and Alliance like Batteries are now interchangeable
12-043-DLR Helpline Available For Additional Support
12-039-DLR OWL Pre-approval's Time Frame Increases to 60 Days
15-028 New Detroit Coolant Line SRTs
901-15 Oil Breather Vent
0229-14 Symptom Based Diagnostics - Oil Separator
0233-14 SPN 51 FMI 2 - All Years
0204-14 SPN 1484 FMI 9, 13 (CPC4) (GHG14)
0224-14 SPN 1590 FMI 9 - CPC- All Years February 2014
0205-14 SPN 1623 FMI 9, 13 (CPC4)(GHG14)
0201-14 SPN 1761 FMI 3, 4 (ACM2-EPA10) (ACM2.1-GHG14)
0223-14 MCM SPN 2791 FMI 2 - GHG14
0207-14 SPN 3031 FMI 3, 4 (ACM) (EPA10 - GHG14)
0226-14 SPN 3216 FMI 3, 4 (ACM2)(EPA10)
0216-14 SPN 3363 FMI 1 - ACM - EPA10 - GHG14
212-14 CPC4 SPN 3719 FMI 0, 16 - GHG14
0222-14 SPN 4334 FMI 7 (ACM) (EPA10)
0227-14 SPN 4335 FMI 7 - EPA10
0240-14 SPN 4374 FMI 0 (ACM2.1)(GHG14)
0230-14 SPN 4375 FMI 6 - EPA10
0211-14 CPC4 SPN 524277 FMI 13, 14, 19 - GHG14
0213-14 CPC4 SPN 524278 FMI 13, 14, 15 - GHG14
0220-14 CPC4 SPN 524279 FMI 11, 18 - GHG14
0206-14 SPN 524280 FMI 2, 3, 4, 5, 6 (CPC4) (GHG14)
0203-14 SPN 65226 FMI 2, 3, 4 (CPC4)(GHG14)
0221-14 Description and Operation of the GHG14 Airless Dosing System
14-006 Standard Diagnostic Times (SDT)
ICI14-005-DLR FL654 Revised Bulletin
801-14 FMI 19: RCM Message Not Received or Stopped Arriving
14-017R Revised: Detroit Addition of Admin Time
14-029 New Detroit Standard Diagnostic Times
14-038_New_SRTs Additional Detroit Standard Repair Times.
14-039_additional_SDTs New Detroit Standard Diagnostic Times
14TL8 TorcUP? Non-Impacting Torque Tool.
14TS28 DD Platform Belt Drive System - Belt Part Numbers and diagnostics
1003-14 Rough Running or Stalling.
1009-14 SPN 5016 (ACM) (GHG14)
1007-14 SPN 5016/FMI 3, 4 (ACM) (EPA10)
1006-14 SPN 4374 (ACM) (GHG14)
1008-14 SPN 3510FMI 4,7, and 8 (CPC)(GHG14)
1010-14 SPN 2623 (CPC) (GHG14)
14CSA23 CSC Announces ?Tech Tips? ? DDCSN
14CSA21 Holiday Schedule for the Detroit Customer Support Center ?
14-039 New Detroit Standard Diagnostic Times
14-038 Additional Detroit Standard Repair Times
sb2080 Australian CST M1400 Isolated Radiator Retrofit
1108-14 SPN 636 (MCM) (EPA07;EPA10;GHG14)
1109-14 Diagnostic Tes
18SP711 DD15 and DD16 Axial Power Turbine Bracket Ki
912-14 Coolant in Oil
914-14 Ambient and Inlet Manifold Pressure Difference (High Box)
920-14 Additional Cleaning and Preparing
906-14 Installation of the Oil Pan
917-14 Installation and Removal of the Oil Filter Stand Pipe
1021-16 SPN 110 (MCM)(EPA07EPA07;GHG14), SPN 110 (CPC)(GHG14)
1018-16 SYMPTOM DIAGNOSTICS - NOISE
16TS18 EPA10 AND LATER DD AUTO-ELEVATE FEATURE
0810-16 SYMPTOM DIAGNOSTIC NOISE
0809-16 SYMPTOM DIAGNOSTICS : NOISY 1- BOX AFTERTREATMENT
SBW5455 VIRTUAL TECHNICIAN RETROFIT
0612-16 SPN 175 (MCM) (GHG17) AND SPN 175 (MCM); ( EPA07;EPA10;GHG14) DIAGNOSTIC PROCEDURE
0611-16 SPN 110 (MCM) (GHG17) AND SPN 110 (MCM); (EPA07;EPA10;GHG14) DIAGNOSTIC PROCEDURE
0610-16 SPN 111 (CPC) (GHG17) AND SPN 111 (CPC); (EPA07;EPA10;GHG14) DIAGNOSTIC PROCEDURE
0609-16 SPN 174 (MCM) (GHG17), SPN 174 (MCM) (EPA07), SPN 174; (MCM) (EPA10), AND SPN 174 DIAGNOSTIC PROCEDURE
0608-16 SPN 715 (CPC) (EPA07;EPA10); SPN 715 (CPC) (GHG14); SPN 715 (CPC) (GHG17) DIAGNOSTIC PROCEDURE
0605-16 SPN 625 (CPC)(GHG17) AND SPN 625 (CPC) (EPA10;GHG14) DIAGNOSTIC PROCEDURE
0601-16 SPN 103 (MCM) (GHG17) AND SPN 103 (MCM); (EPA07;EPA10;GHG14) DIAGNOSTIC PROCEDURE
Engine
118 bulletinsDetroit Technical Service Letter for DD13 Cylinder Head and Cylinder Head Gasket Change.
DTNA received a field notification on multiple units regarding diagnostic fault codes that were found to be causing...
Read full bulletin
issues to the After Treatment Control Module (ACM). These fault codes indicated that the ACM communication message was not received by the Motor Control Module (MCM) which in certain cases, led to a 25% engine de-rate situation. Further diagnosis revealed that the DT12 wiring harness was chafing and contacting the transmission TCU case. To reduce potential chafing areas, the proposed short-term containment was to route the wiring harness using additional tie straps. This communication applies to Freightliner and Western Star vehicles built with DT12 transmissions.
DDC Field Service Campaign for GHG14 DETROIT DD13 with One-Box Aftertreatment Software Reprogramming.
Read full bulletin
Certain Detroit Model Year 2013 to 2015 GHG14 DD13 engines that are registered in California will require reprogramming to a minimum of the MCM software version and fuel map version listed below: MCM Software Version 4.7.0.0 ZGS 005.
Training Solutions for Fuel Leak Found at High Pressure Fuel Pump Weep Hole for Heavy Duty DD Engines.
Read full bulletin
Occasionally we see trucks come in with fuel leaking from the high pressure fuel pump weep hole. This is NOT a defect in the pump and further diagnostics need to be performed to find the root cause.
Updated DDC Field Service Campaign for GHG14 DETROIT DD13 with Two-Box Aftertreatment Software Reprogramming.
Read full bulletin
Certain Detroit Model Year 2013 to 2015 GHG14 DD13 engines that are registered in California will require reprogramming to a minimum of the MCM software version and fuel map version listed below: MCM Software Version 4.7.0.0 ZGS 005. Certain sections have been updated for clarity.
Warranty Information Letter for Warranty Long Block Program Change.
Read full bulletin
The Detroit Reman Long Block Program has expanded. The expansion reduces complexity in ordering reman engines and promotes stocking reman engines to meet uptime commitments.
Service Bulletin explaining Western Star's courtesy engineering policy.
Updated Recall Safety Bulletin for vehicles in Australia and New Zealand with DD15 engines regarding high pressure fuel lines.
Read full bulletin
Language was clarified that this only applies to Australia and New Zealand.
Export Recall Safety Bulletin for vehicles in Australia and New Zealand with DD15 engines regarding high pressure fuel...
Read full bulletin
lines.
Field Service Campaign Revision for heavy duty engine platform oil suction manifold.
Read full bulletin
Additional repairs section added.
Revised Field Service Campaign for Heavy Duty Engine Platform Oil Suction Manifold on DD3, DD15, DD16 Engines for Model...
Read full bulletin
Year 2014
Service Bulletin to testing of EGR Cooler Water Manifold Assembly in DD13 engines.
HDEP GHG17 engines are not equipped with turbo wastegates.
Read full bulletin
Steps in this troubleshooting involving wastegates were removed.
This service kit includes all necessary parts to replace the high pressure fuel rail feed lines, mounting bracket,...
Read full bulletin
P-clips and mounting hardware in the event one of these parts are loosened, removed or missing from the engine.
This service kit includes all necessary parts to replace the high pressure fuel rail feed lines, mounting bracket,...
Read full bulletin
P-clips and mounting hardware in the event one of these parts are loosened, removed or missing from the engine.
This service kit includes all necessary parts to replace the high pressure fuel rail feed lines, mounting bracket,...
Read full bulletin
P-clips and mounting hardware in the event one of these parts are loosened, removed or missing from the engine.
This service kit includes all necessary parts to replace the high pressure fuel rail feed lines, mounting bracket,...
Read full bulletin
P-clips and mounting hardware in the event one of these parts are loosened, removed or missing from the engine.
This service kit includes all necessary parts to replace the high pressure fuel rail feed lines, mounting bracket,...
Read full bulletin
P-clips and mounting hardware in the event one of these parts are loosened, removed or missing from the engine.
This service kit includes all necessary parts to replace the high pressure fuel rail feed lines, mounting bracket,...
Read full bulletin
P-clips and mounting hardware in the event one of these parts are loosened, removed or missing from the engine.
Cylinder Liner - Testing of the Cylinder Liner Upper O-Ring
Cylinder Liner - Testing of the Cylinder Liner Upper O-Ring
Cylinder Liner - Testing of the Cylinder Liner Upper O-Ring
New Detroit Diesel Cylinder Liner Upper O-Ring Leak Test Standard Repair Time
Engine Manufacturer Diagnostics
DD13, DD15, DD16 Check Engine Light Flashing or Blinking
SS 1033403 - WST Wiper Motor not Parking Issues
0503-18 Relative Cylinder Compression Test
0502-18 Symptom Diagnostics - Low Engine Coolant Temperature
18SP734 18SP734?GHG14 DD15AT Turbocharger
Field Service Campaign: GHG14 Heavy Duty Engine Platform Vocational Application Programming
Field Service Campaign - Heavy Duty Engine Platform Oil Suction Manifold
SS 1033403 - WST Wiper Motor not Parking Issues
0503-18 Relative Cylinder Compression Test
0502-18 Symptom Diagnostics - Low Engine Coolant Temperature
18SP734 18SP734?GHG14 DD15AT Turbocharger
aeo18M1 GHG14 Heavy Duty Engine Platform Vocational Application Programming
531-13 GHG14 DD15 Asymmetrical Turbocharger
520-13 Cylinder Block
15TS4 EPA07 DD15 Piston Kits
15TS2 EPA07 and EPA10 DD Platform Engines With Low Oil Pressure Codes
15TS1 GHG14 DD Platform Engines With Codes SPN: 1323 through SPN: 1328, FMI: 31, Idle Smoothness Control/Cylinder...
Read full bulletin
Misfire At Idle
GHG14 - Intake Manifold Pressure Too Low
GHG14 Intake Manifold Pressure Too Low
707-13 Description and Operation of the HC Doser Fuel Supply Pressure Control Valve - Two Filter System
0202-17 DD13, DD15, and DD16 Cylinder Head Assembly Removal and Installation
308-15 Symptom Diagnostics - Oil Present at the Turbocharger Compressor
302-15 Crankshaft Oil Seals
18SP706 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal
14TS16 Excessive Overhead Engine Noise on DD Platform Engines
524-14 FMI 0: Engine Speed High
18SP705Rev4 18SP701Rev GHG14 Two-Filter Fuel System KM63 GEN2 DD15AT Engines High Pressure Fuel Feed Lines, Mounting...
Read full bulletin
Bracket and P-clip
18SP701Rev GHG14 Two-Filter Fuel System KM63 GEN2 DD15AT Engines High Pressure Fuel Feed Lines, Mounting Bracket and...
Read full bulletin
P-clips
13TS6 DD Platform Engine Oil Filter.pdf
207-13 Removal and Installation of the Camshaft Housing
18SP693 EPA07-10 Fuel Rail Clamp Service Kit (P-N A4720780335) for DD Platform-Three-Filter Fuel System Engines
305-13 GHG14 DD15 Asymmetrical Turbocharger Flanged Exhaust Manifold
148-13 GHG14 DD15 Asymmetrical Turbocharger Exhaust Manifold
15TS6 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal
15TS14 GHG14 DD Engine Cylinder Liner Seal Replacement
708-15 High Pressure Fuel Pump Camshaft Oil Seal - Two-Filter System
711-15 High Pressure Fuel Pump Camshaft Oil Seal - Three-Filter System
702-15 DD15 and DD16 Delphi Exhaust Gas Recirculation Valve Actuator
703-15 GHG14 DD15 AT Exhaust Gas Recirculation Valve Actuator
803-15 Removal of the Camshaft Housing
aeo18M1 GHG14 Heavy Duty Engine Platform Vocational Application Programming
Heavy Duty Engine Wastegate Repair Kit DKI470E16019
0120-17 Diagnostic Test - Engine Oil Leaks - Oil Developer Method
15TL24 OTC 1750 Revolver Engine Stand
15TS4_Rev2_ EPA07 DD15 Piston Kits
1210-14 Cylinder Head
1201-15 Crankshaft and Bearings
FMI 3 Engine Oil Pressure Sensor Circuit Failed High
Inspection of the DD13 Turbocharger
15TS10Rev DD Engine Platform Coolant Filter
401-15 Cylinder Block
501-15 Engine Lifter Brackets
504-15 DD13 Exhaust Gas Recirculation Valve Actuator Pull Rod
511-15 DD15 and DD16 Exhaust Gas Recirculation Valve Actuator Pull Rod
503-15 DD13 Exhaust Gas Recirculation Valve Actuator
sbw8326 HVAC Blower Motor Noise
15TL4 W470589050900 ? 3/8? Drive GEN2 Two-Stage Valve Socket
308-15 Symptom Diagnostics - Oil Present at the Turbocharger Compressor
302-15 Crankshaft Oil Seals
18SP706 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal
sbw0116 Pilot Bearing Spacer for Detroit Engines with Eaton transmissions
14TL2 DD Platform Engine Stand Adapter W060589023100
14TS18 GHG14 DD Engine EGR System Fault Code
714-14 Symptom Diagnostics - Low Engine Compression
712-14 Engine Coolant Temperature
16TS8 DD13 Cylinder Head and Cylinder Head Gasket Change
16-011 New Detroit Camshaft Housing Seal Standard Repair Time
sbw4713 Crank No Start, Loss of Engine Prime on Decked Vehicles
12-038-DLR - No Problem Found - Policy Claims - During Basic Vehicle Chassis or Base Engine Coverage
GHG14 DD Platform Engines With Code SPN: 3216 FMI: 18, SCR Inlet NOx Sensor Drift Low
0228-14 Engine Oil Leaks - Oil Dye Method
0237-14 Engine Brake Solenoid
49-14 - DEF Tank Coolant Valve O-Ring Kit
14TS21 HDEP Camshaft Position Sensor Change
804-14 FMI 16, 18 Intake Manifold Pressure Too high and low (Restricted Mode)
803-14 FMI 16,18: Intake Manifold Pressure Too High and Low
812-14 FMI 3, 4: Engine Aux.
Read full bulletin
Shutdown Input Failed High and Low
14-040_Additional_CLOs Additional Detroit CLOs for the Heavy Duty Engine Platform
14CSA20 EGR Valve Actuator Kit P/N E23539699
14-040 Additional Detroit CLOs for the Heavy Duty Engine Platform
1102-14 DD13 Cylinder Head R&R
1101-14 DD15 and DD16 Cylinder Head
14TS26 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal
913-14 Checking for Poor Engine Brake Performance
915-14 Backwards Running Engine Detecte
18SP706 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal
18SP701Rev3 GHG14 Two-Filter Fuel System KM63 GEN2 DD15AT Engines High Pressure Fuel Feed Lines, Mounting Bracket and...
Read full bulletin
P-clips Service Kit
16TS24 GHG14 DD Platform Engines With Code SPN: 3216/FMI 18, SCR Inlet NOx Sensor Drift Low
14TS16REV EXCESSIVE OVERHEAD ENGINE NOISE ON GHG14 DD PLATFORM ENGINES
SBW0004 WESTERN STAR COURTESY ENGINEERING POLICY
1017-16 ENGINE MODEL AND SERIAL NUMBER DESIGNATION
16TL20 HEAVY DUTY ENGINE VALVE STEM SEAL INSTALLING DRIFT AND SLEEVE
0909-16 EXCESSIVE OIL CONSUMPTION
DAIMLER TRUCKS: DURING ENGINE ROLL, INSIDE OF HOOD, AND BETWEEN HOOD TILT-ASSIST MOUNTING BRACKETS, IS AN...
Read full bulletin
INTERFERENCE DUE TO BRACKETS ARE DIFFERENT IN SIZE. *PE
Fuel System
104 bulletinsDetroit Emission recall for GHG14 DETROIT DD16 Software Reprogramming
Detroit Emission recall for GHG14 DETROIT DD16 Software Reprogramming
Detroit Emission recall for GHG14 DETROIT DD16 Software Reprogramming
Warranty Information letter announcing that DTNA is increasing the Standard Diagnostic Times (SDTs) shown.
Read full bulletin
The updated after treatment system (ATS) diesel exhaust fluid (DEF) pump times will be applied to repair orders opened on or after April 12, 2021.
Special Publication letter for Two-Filter Fuel System KM59 GEN1 DD15 DD16 Severe Duty High Pressure Fuel Rail Feed Lines...
Read full bulletin
Service Kit.
Tech Talk Discussion for DD15 GHG14 EGR linkage hex nuts.
Customer Service Announcement for Release of DiagnosticLink 8.12 Service Pack 2.
Read full bulletin
On Thursday, September 3, 2020, Service Pack (SP) 2 for DiagnosticLink 8.12 Standard and Professional will be made available to download from the Detroit Diesel server.
Technical Service Letter for EPA10, GHG14, GHG17 Diesel Particulate Filter (DPF) Compatibility.
Read full bulletin
Note: This document supersedes 14 TS-25 and 15 TS-8. Detroit Diesel has determined that some, Diesel Particulate Filters (DPFs) are compatible in pairs and or can be mixed together within EPA10 and GHG14 Systems. For 1-BOX and Two-Box Configuration Aftertreatment Systems (ATS), this is only possible when the filters are used in accordance with Tables 1 and 2 shown below. All other DPFs, NOT mentioned below, are NOT compatible.
Service Bulletin for Equiflo Fuel System Breather Tube Inspection
Service Information Bulletin for Symptom Diagnostics - Fluid in the Aftertreatment - Diesel Fuel Contamination.
Service Information Bulletin regarding PTO Dosing.
Read full bulletin
This feature enables Active Regeneration of the DPFs while in PTO mode.
Fuel System Integrity Check Routine - Two-Filter Fuel System
Fuel Level Sending Unit Retrofit
Fuel System Integrity Check Routine - Two-Filter Fuel System
Fuel System Integrity Check Routine - Two-Filter Fuel System
owner18R3 Emission Recall D18R3
GHG14_18R3_bulletin_07-MAY-2018a Emission Recall D18R3
owner18R3 Emission Recall D18R3
GHG14-18R3 bulletin-07-MAY-2018a-Emission Recall D18R3
13TS17 EPA10-GHG14 Diesel Exhaust Fluid (DEF) in Fuel System-Diesel Fuel in DEF System Contamination
102-15 High Pressure Fuel Pump - Two-Filter System
18SP687 DD15 16 EGR Actuator Replacement
414-13 Removal and Installation of the GHG14 13 and 23 Gallon Diesel Exhaust Fluid Tank Header Unit
413-13 GHG14 13 and 23 Gallon Diesel Exhaust Fluid Tank
407-13 EGR Actuator Slow Learn
608-13 High Pressure Fuel Flange-Two-Filter System
710-13 Metal in the Fuel System - Three-Filter Fuel System
712-13 Fuel Cooler Leak Test Procedure - Three-Filter Fuel System
705-13 Test-E Three-Filter Fuel System
702-13 Test E Two-Filter Fuel System
FL721 CNG Fuel Tank and CPDM Mounting Location
18SP712 EPA07 DD15/16 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel System Conversion Service Kit
18SP713 EPA10 DD13 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel System Conversion Service Kit
18SP714 EPA10 DD15/16 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel System Conversion Service Kit
14TS13Rev EPA10/GHG14 Diesel Exhaust Fluid (DEF) in Fuel System/Diesel Fuel in DEF System Contamination
505-14 Fuel Cooler Leak Test Procedure - Three-Filter Fuel System
504-14 Test-E - Three-Filter Fuel System
513-14 FMI 0: Diesel Particulate Filter Outlet Temperature - Very High
515-14 FMI 1: Over Pressurized Diesel Exhaust Fluid System
501-14 Removal and Installation of the DD13 Exhaust Flanged Manifold
611-13 Removal and Installation of the GHG14 Six-Gallon Diesel Exhaust Fluid Tank Header
fsbw49019 Conduite sous pression de fluide pour chappement diesel (DEF) dbranche au niveau du raccordement du doseur
310-13 Draining the Fuel System Using J-48710 Prior to Repairs
143-13 Low Pressure Fuel System - Measuring Fuel Pressure Using Fuel System Integrity Check, Two-Filter Fuel System
119-13 Exhaust Gas Recirculation System - Cleaning
126-13 Description and Operation of the DD15 and DD16 Exhaust Gas Recirculaton Cooler
124-13 Installation of the DD Platform EGR Actuator Pull Rod
144-13 Removal and Installation of the GHG14 Diesel Exhaust Fluid Lines
15TS8 EPA10 and GHG14 Diesel Particulate Filter (DPF) Compatibility
0202-15 EPA10 and GHG14 Diesel Oxidation Catalyst Face Cleaning
EPA10, GHG14 and GHG17 Diesel Particulate Filters
Exhaust and Exhaust Gas Recirculation
Diesel Exhaust Fluid (DEF) Pressure Line Disconnected at the Doser Connection
SPN 4765 FMI 0 - Exhaust Temperature Out Of Range High
18SP726 ? EPA10 GHG14 Two-Filter Fuel System KM59 GEN1 DD13 High Pressure Fuel Fee
15TL6 W470589129100 ? HDEP HP Fuel Rail Test Caps
18SP717 DD13 EGR Actuator Replacement
509-15 Symptom Diagnostics - Hard Start/No Start - Three-Filter Fuel
512-15 GHG14 DD15 AT Exhaust Gas Recirculation Actuator Pull Rod
502-15 Exhaust Gas Recirculation Actuator Lever
18SP716 Installation/Replacement of the Fuel Cooler Delete Bypass Plate for the Two-Filter Fuel System
15-017 Detroit: Updated Fuel Injector SDTs
18SP712 EPA07 DD15/16 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel System Conversion Service Kit
18SP713 EPA10 DD13 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel System Conversion Service Kit
18SP714 EPA10 DD15/16 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel System Conversion Service Kit
14TS19 DD Platform High Pressure Fuel Lines
18SP710Rev 18SP710Rev ? EPA10 GHG14 Two-Filter Fuel
18SP709Rev 18SP709Rev ? EPA10/GHG14 Two-Filter Fuel
18SP701Rev2 18SP701Rev2? GHG14 Two-Filter Fuel System
16TS9 DD Platform High Pressure Fuel Lines
16TS7 Reman Diesel Particulate Filter Serial Number
17TL28 Fuel Injector Removal Tool DSN930E17004
0239-14 High Pressure Fuel Injector Lines - Three-Filter System
0238-14 Removal of the High Pressure Fuel Injector Lines - Two-Filter
0217-14 Installation of the Fuel Injector Cup
0219-14 Metal in Fuel
0202-14 Symptom Diagnostics - Hard Start No Start - Two-Filter Fuel System
0215-14 Check for Rough Running or Stalling - Three-Filter Fuel System
0214-14 CPC4 SPN 524276 FMI 13 - GHG14 - MCM fuelmap to GVC
18SP703 18SP703 - GHG14 KM63 GEN2 Low Pressure Fuel Pump-Two-Filter Fuel System Ki
14TS19Rev DD Platform High Pressure Fuel Lines
1104-14 Metal in the Fuel System
18SP708Rev EPA07 10 Three-Filter Fuel
14TS25 EPA10 and GHG14 Diesel Particulate Filter (DPF) Compatibility
910-14 Installation of the High Pressure Fuel Rail Feed Lines - Two-Filter System
918-14 Removal and Installation and Inspection of the Fuel Cooler Delete Bypass Plate - Two Filter System
916-14 Fuel Cooler Leak Test Procedure - Two-Filter Fuel System
908-14 908-14 EGR Differential Pressure Failed (High Box)
919-14 Exhaust Gas Recirculation Flow Target Error Diagnostic - High Flow
18SP707Rev EPA07/10 Three-Filter Fuel System DD13 High Pressure Fuel Feed Lines, Mounting Bracket and P-clips Service...
Read full bulletin
Kit
18SP687 18SP687 DD15/16 EGR Actuator Replacement Service Kit
18SP719Rev EPA10 DD13 Three-Filter ESOC Fuel System to Two-Filter KM59 GEN1 Fuel
18SP714Rev EPA10 DD1516 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel
18SP722 DD13 KM59 GEN1 BUS TWO-FILTER SYSTEM AMPLIFIER, NEEDLE AND PLV RETURN FUEL LINE CLEARANCE PACKAGE SERVICE KIT
18SP720 EPA10 DD15/16 THREE-FILTER ESOC FUEL SYSTEM TO TWO-FILTER KM59 GEN1 FUEL SYSTEM CONVERSION SERVICE KIT
18SP720 EPA10 DD15/16 THREE-FILTER ESOC FUEL SYSTEM TO TWO-FILTER KM59 GEN1 FUEL SYSTEM CONVERSION SERVICE KIT 2
18SP718 EPA07 DD15/16 THREE-FILTER ESOC FUEL SYSTEM TO TWO-FILTER KM59 GEN1 FUEL SYSTEM CONVERSION SERVICE KIT
18SP713REV 18SP713 EPA10 DD13 THREE-FILTER FUEL SYSTEM TO TWO-FILTER KM59 GEN1 FUEL SYSTEM CONVERSION SERVICE KIT
0906-16 LOW PRESSURE FUEL PUMP
DETROIT APPROVED PRIMING TOOLS FOR THE KM63 GEN2 FUEL SYSTEMDETROIT APPROVED PRIMING
NEW DETROIT DIESEL EXHAUST FLUID AWNING STANDARD REPAIR TIME
WESTERN STAR: AT RETURN LINE FITTING, DURING COLD EXTREME TEMPERATURES, THE DIESEL EXHAUST FLUID (DEF) TANK WOULD FREEZE.
Read full bulletin
*PE
WESTERN STAR: IF DIESEL EXHAUST FLUID (DEF) SYSTEMS IS SITTING FOR EXTENDED TIME, IN TANK, WILL CRYSTALLIZE AROUND...
Read full bulletin
FLOAT OF LEVEL SENDING UNIT TUBE AND NEEDS CLEANING TO PREVENT A FALSE OR INCORRECT GAUGE READING. MODEL CONSTALLATION, 4700, 4800, 4900, 5900, 6900. NO YEARS LISTED. *PE
WESTERN STAR: WHEN TRUCK SITS, FOR ANY EXTENDED PERIOD, WITH A DIESEL EXHAUST FLUID (DEF) SYSTEM, IT WOULD...
Read full bulletin
CRYSTALLIZED, IN THE TANK, AROUND FLOAT, ON DEF LEVEL SENDING UNIT TUBE AND NEEDS TO BE CLEANED. *PE
Electrical
67 bulletinsWestern Star Service Bulletin for HVAC Actuator Replacement.
Read full bulletin
The wiring harness of the actuator of the fresh air recirculation door on Western Star vehicles equipped with Red Dot HVAC systems should be inspected for signs of water intrusion and corrosion.
HVAC Actuator Wiring Harness.
Read full bulletin
Revision History: Service kit part number changed from RDH RD5 17147 0 to WWS RD-3-9069-0 on 12/9/21. The wiring harness of the actuator of the fresh air recirculation door, shown in Fig. 1, on Western Star vehicles equipped with Red Dot HVAC systems should be inspected for signs of water intrusion and corrosion.
Customer Advisory Letter for HVAC Actuator Wiring Harness.
Read full bulletin
The wiring harness of the actuator of the fresh air recirculation door, shown in Fig. 1, on Western Star vehicles equipped with Red Dot HVAC systems should be inspected for signs of water intrusion and corrosion.
Service Solution SS 1033094 KUS Float Tube Fuel Level Sensor Inform...
Western Star Service Bulletin for Powernet Troubleshooting Guide - Batteries, Path, Alternator, and Starter.
Read full bulletin
When troubleshooting powernet issues, use the BCT-460DTNA PowerNet Assessment Tool. As of May 29, 2018, the AutoMeter is the only Daimler-approved tool for troubleshooting vehicle Powernet issues.
Service Solution on failing RX modules in Western Star vehicles.
Service Bulletin provided to customers regarding installation of a new MCM 21-pin jumper harness.
Technical Bulletin wp54018 EPA10 Wiring Harness Ordering
Technical Bulletin wp54018 EPA10 Wiring Harness Ordering
SS - 1033194 WST 4900FA Cab Mounting Crossmember Interfering with Battery Cables Heat Shield
SS - 1033194 WST 4900FA Cab Mounting Crossmember Interfering with Battery Cables Heat Shield
SS 1033333 - WST ECC Replacement Jumper Harness Installation.
0311-18 Installation of the Main Shaft Speed Sensor
13TS15 EPA10 Diesel Oxidation Catalyst (DOC) Face Plugging And Code SPN 3251-FMI2 - DOC Inlet Pressure Sensor Not...
Read full bulletin
Plausible
RX Module Fault Codes
15TS9 Hydrocarbon Doser Block Fuel Compensation Pressure Sensor
326-15 Main Shaft Speed Sensor
305-15 EPA10 Diesel Oxidation Catalyst Inlet Pressure Sensor
503-14 FMI 3, 4: High Side Digital Output 3 Circuit Failed High
511-14 FMI 9 Soot Sensor Communication Error
520-14 FMI 2 Soot Sensor Heater Faul
523-14 FMI 18: Soot Sensor Temperature Low
sbw5439 RX Module Fault Codes
13TS5 DD Platform Fuel Filter Module
13TS10 DD Platform Oil Coolant Module Plugs
13TS7 GHG14 CPC4 Vehicle Speed Sensor Code SPN 84-FMI 6
13TL2 GHG14 Test Electronic Control Units (ECUs).\
802-15 SPN 520970 FMI 7 (TCM)
801-15 SPN 520999 FMI 7 (TCM)
SS 1033333 - WST ECC Replacement Jumper Harness Installation.
0311-18 Installation of the Main Shaft Speed Sensor
SPN 521221 (TCM)
SPN 521222 (TCM)
1205-15 Selective Catalyst Reduction (SCR) Inlet Temperature Sensor
Cleaning of the Exhaust Gas Recirculation Venturi Pipe Delta P Sensor Ports
FMI 5 Oil Pressure Sensor Stuck High
FMI 3,4,5 Digital Output 1 13 Circuit
FMI 3,4,5 Digital Output 1 13 Circuit
FMI 3,4,5 Digital Output 3 10 Circuit
FMI 3,4,5 Digital Output 3 12 Circuit
FMI 2, 3, 4 Remote Accelerator Pedal Supply Voltage
15-016-DLR New Essential Tool For CPWA, CPPRA, Ltd CPPRA, & DSDWC Parties: Cadex CA-12 Battery Tester
sbw5462 Aftertreatment Harness Modification
15TS9 Hydrocarbon Doser Block Fuel Compensation Pressure Sensor
326-15 Main Shaft Speed Sensor
305-15 EPA10 Diesel Oxidation Catalyst Inlet Pressure Sensor
sbw5461 Guidelines for Repairing or Replacing an Electrical Harness
16TL5 DD Platform Aftertreatment Soot Sensor Socket DSN0ATZ16001
16_TL-2 DD Platform Aftertreatment NOx Sensor Socket W470589060900
0218-14 GHG14 Diesel Exhaust Fluid Pump Module Filter
14-005 Warranty Change for Remy 39MT Starter
813-14 Installation of the One & Two-Piece Fuel Injector Wiring Harness - Two & Three-Filter System
14TS30 Aftertreatment Harness Diagnostics
1005-14 Oil Coolant Module
14CSA22 DTNA Chassis Wiring Diagrams
18SP684Rev4 18SP684Rev4 ? EPA07 and EPA10 DD Platform EGR Delta Pressure Sensor Update
18SP705Rev5 18SP705Rev5 ? DD Platform Delta Pressure Sensor
1110-14 EPA10 DOC Inlet Pressure Sensor
sbw5462 Aftertreatment Harness Modification
905-14 Coolant Level Circuit Failed
903-14 Selective Catalyst Reduction Inlet NOx Sensor Circuit Failed High and Low
904-14 Selective Catalyst Reduction Outlet NOx Sensor Circuit Failed High and Low
911-14 5V Sensor Supply Bank 2 Circuit Failed High
909-14 Diesel Exhaust Fluid Metering Unit Air Pressure Sensor Circuit Failed High and Low
16TL17 LABEL UPDATE FOR GHG14 TEST AFTERTREATMENT CONTROL MODULE (ACM)
WESTERN STAR: INSTRUCTIONS PROVIDED TO HELP REDUCE VIBRATION ON POWER DISTRIBUTION MODULES (PDM), TO PREVENT CRACKING...
Read full bulletin
OF FUSES ON HORIZONTALLY MOUNTED POWERTRAIN. *PE UPDATED 03/02/15*LJ
WESTERN STAR: TROUBLESHOOTING INFORMATION REGARDING POWERNET ASSESSMENT WORKSHEET GUIDE FOR STARTING ISSUES,...
Read full bulletin
ALTERNATOR, PATH, BATTERY AND CHARGING OF VEHICLES WITH SEPARATE CABLE VOLTAGE DROP CHECKS. MODEL CONSTELLATION, 4800, 5900, HERITAGE, 4900, 6900, 4700. *PE
Pre-Delivery & Maintenance
32 bulletinsTechnical Service Bulletin for StarNet Manuals Moving to Technical Literature
Important Campaign Information letter for DDC D24R4 - Campaign Reactivated
Important Campaign Information letter for DDC D24R4 - Campaign Inactivated
Important Campaign Information letter for DDC D23M3 - Campaign Reactivated and Extended.
Read full bulletin
Field Service Campaign D23M3 - GHG17 DETROITTM DD16 Vibration Damper Replacement has been extended for an additional 6 months.
Western Star Service Bulletin for DEF Connector Reinforcement Caps
Western Star Service Bulletin for Key Fob ID Retention.
Read full bulletin
Key fobs for remote keyless entry on Western Star vehicles are delivered in packages that include a unique ID for the fob. The ID is required when pairing the key fob with a vehicle.
Technical Service Letter for SPN 3711 FMI 31 on GHG17 DD15 Trucks.
Service Bulletin for Guidelines for Cleaning and Disinfecting Cab Surfaces.
Read full bulletin
The following guidelines are for cleaning and disinfecting commonly touched surfaces on the inside and outside of a vehicle. For best results, follow cleaning and disinfecting procedures fully and consistently. Ensure there is adequate ventilation when using chemicals. NOTICE: Wipe down fragile components carefully to avoid damaging the vehicle.
Warranty Information Letter for Warranty Training Online.
Read full bulletin
DTNA is pleased to announce the release of new Warranty-related training videos. The videos provide Warranty content in short instructional videos that are available on demand through the AftermarkeTV Video Channel icon on the Aftermarket Resource Center (ARC) home page.
Warranty Policy Letter for Handling for Authorized Service Location Part Transfers.
Read full bulletin
To promote 24-hour throughput and maximum efficiency, DTNA is adjusting multiple handling policies: Launching a new handling allowance for parts ordered from another Authorized Service Location because the facing Part Distribution Center (PDC) is out of stock Retiring Detroit's Customer First Program
Open recall and Field service Campaigns report send out to Dealers, General Managers, Service managers and warranty...
Read full bulletin
managers
Service Solution for Western Star vehicles equipped with Hendrickson AIRTEK Axles experiencing a Harsh Ride.
Important Campaign Information notice for field service campaign D18M3 being revised which added additional repair...
Read full bulletin
information,
Technical Service Letter communicating that information on DD Heavy Duty Platform Belt and Belt Tensioner can be found...
Read full bulletin
on TechLit.
Service Information Bulletin was released, to add new procedures to address diagnostics near the high pressure pump
Service Bulletin Vibration and Harsh Ride Troubleshooting
Service information Bulletin -HDEP PLV Return Line Tool DSN470E17006
Service Solution for Western Star 4900, Frame Beaming - Rough Ride Vibration in bob tail mode
Service Information Bulletin for Aftertreamtent Failure Guide
Service Information Bulletin
Field Service Campaign D18M3 Oil_Suction_Manifold_072718, Owner Notice
Release of DiagnosticLink 8.08 Service Pack 1
If a GVWR certification label is lost or damaged, Freightliner will supply a duplicate label.
Read full bulletin
Log on to DTNAConnect.com and under "DTNAConnect Resources", select the "Tool and Services" plus sign. Select "Request for Certification Labl or OWI." Fillout the form, then select "Review."
ICI18-014 Owner Notice ? Kidde Fire Extinguisher Recall
ICI18-014 Owner Notice ? Kidde Fire Extinguisher Recall
15-015 Warranty Exclusions Reminder
14-026-DLR SelecTruck Warranty Enhancements
Canadian Warranty Parts Return Address Change
_Warranty Recognition Program - Coming Soon
14WO-9_Warranty_Access Detroit New User Warranty Access Request
14TL9 Special Tool Warranty Program.
16TS14 EPA10 AND GHG14 SERVICE REPLACEMENT 1-BOX DOC INLET CHANGE
Brakes
19 bulletinsUpdated Western Star Parts Technical Bulletin for Universal Design Floor Mats.
Read full bulletin
This bulletin replaces the version dated February 12, 2021. Information about parts notes in the Paragon system have been added and the trimming instructions are revised. Universal floor mat designs fit multiple cab configurations and may require trimming. Trim lines displaying size options are scored into the pad side of the mat; use an existing floor mat as a guide for optimal results. The new mat should not interfere with safety-critical equipment, such as foot pedals.
Western Star Parts Technical Bulletin for Universal Design Floor Mats.
Read full bulletin
Universal floor mat designs fit multiple cab configurations and may require trimming. Trim lines displaying size options are scored into the pad side of the mat; use an existing floor mat as a guide for optimal results. The new mat should not interfere with safety-critical equipment, such as foot pedals.
Training Solution for Western Star Front Brake Squeal - Burnishing Procedure.
Read full bulletin
The brake burnishing procedure can be used to help reduce brake related noise or imbalance concerns which may occur in the field.
Recall Bulletin FL773 Lowmax Brake Hoses
Recall Bulletin FL773 Lowmax Brake Hoses
TS 1033768: Western Star Front Brake Squeal - Burnishing Procedure
FL756 Brake Light Pressure Switches
Brake Light Pressure switch may not activate the brake lights with a light application of the brake pedal.
FL756 Brake Light Pressure Switches
SF483-DLR Western Star ECC Park Brake Output Signals
sbw4206 Brake Shimmy?Meritor SteeLite X30? Brake Drum With Excessive Runout
fsbw42010 Inspection d'absence de fuites d'air par les transporteurs concessionnaires
FL756 Brake Light Pressure Switches
sbw5401 Turn Signal and Brake Override Circuit
sbw4206 Brake Shimmy - Meritor SteeLite X30 Brake Drum With Excessive Runout
14TL5 ABS Power Line Carrier Converter Available Through PDC
16TL3 Pocket iQ? ABS Product Family Kit is Available at PDC
Western Star ABS Wiring - Export Only
sbw4205 Bendix Air Disc Brake Thermal Overload Issues
Transmission
17 bulletinsImportant Campaign Information Letter for DDC D21M1 Termination Date Extended.
Read full bulletin
This letter is to inform you that a revised bulletin for Detroit Diesel Field Service Campaign D21M1, DT12 Transmission Drive Shaft Cover Plug Reseal has been EXTENDED for an additional three months. Please use the extended termination date for all work under D21M1 from this point forward. REVISION: D21M1 termination date extended to July 1, 2022.
Detroit Field Service Campaign for DT12 Transmission Drive Shaft Cover Plug Reseal.
Read full bulletin
Daimler Trucks North America LLC, on behalf of its DETROIT Powertrain Division, is initiating Field Service Campaign D21M1 on certain DT12 transmissions in order to reseal the bypass plugs of the drive shaft cover located in front housing.
Revised Warranty Policy Letter for Alliance/Mascot Aftermarket Warranty and Claim Filing.
Read full bulletin
Revisions are in blue. With Mascot now in partnership with Detroit Reman and Alliance Parts, DTNA is pleased to announce that Mascot coverage has been added to OWL. Remanufactured Alliance/Mascot parts include transmission, differential, steering gear, and steering pump used in an on-highway vehicle applications. The Alliance/Mascot aftermarket warranty coverage period has not changed: depending on the part, coverage is for one (1) or two (2) years and current parts, labor, and reimbursement policies apply.
Warranty Policy Letter for Alliance/Mascot Aftermarket Warranty and Claim Filing.
Read full bulletin
With Mascot now in partnership with Detroit Reman and Alliance Parts, DTNA is pleased to announce that Mascot coverage has been added to OWL. Remanufactured Alliance/Mascot parts include transmission, differential, steering gear, and steering pump used in an on-highway vehicle applications. The Alliance/Mascot aftermarket warranty coverage period has not changed: depending on the part, coverage is for one (1) or two (2) years and current parts, labor, and reimbursement policies apply.
Service Bulletin for Lengthening the Backup Light Harness.
Read full bulletin
Though the back-up light harness is long enough to connect to the backup light switch, it may be short enough that the wire seals in the connector can be stressed. Moisture entering through the seals can cause corrosion, resulting in a bad connection and/or failure of the switch. As a result, backup lights and, if equipped, the backup alarm, may not function when the vehicle is shifted into reverse.
Field Service Campaign for Remanufactured Detroit DT12 Transmissions
TS 1033699: DT12 Transmission Driver Interview: Shifting Complaint Questionnaire
0405-18 Symptom Diagnostics - Range Up or Down Shift Issue
0405-18 Symptom Diagnostics - Range Up or Down Shift Issue
sbw2019 Kysor Fan Clutch Rocking Runout Inspection
145-13 Description and Operation of Gear Train and Related Parts
15TS15Rev Detroit? DT12? Transmission Proper Towing Procedure
Detroit? DT12? Transmission Proper Moving Procedure
FMI 2- Automatic Gear Selection - Incompatible or missing dataset
15-010-DLR Transmission Cooler Line Photos
811-14 FMI 7: Internal Error with the DT12 Shift Stalk Lever
1105-14 Flywheel, Ring Gear and Flywheel Housing
Body & Paint
14 bulletinsSF626 Western Star Window Replacement Inspection Notification.
Read full bulletin
This letter is to inform you that Field Service Campaign SF626 Western Star Window Replacement Inspection Notification campaign was released.
Portland Truck Plant Paint Changes
Service Bulletin for Window Regulator Retrofit.
Read full bulletin
The bulletin dated December 4, 2019 has been revised to include 4800 Models. Beginning 04/01/2019 Western Star cab doors were updated to a new style regulator and window. When replacing an older style regulator or window the vehicle must be retrofitted to the new style regulator and window.
Service Solution for Western Star Velvac Door Mirror Seal Curling.
Read full bulletin
The rubber that is rolling back is actually a rubber tape. Originally, the mirrors did not have this tape. Velvac added the tape to address some whistling complaints from customers.
Service Bulletin for Window Regulator Retrofit.
Tool Letter for DT12 Seal Protector Sleeve
SS 1033462 - WST Cab Mounted Mekra Mirror Cover Chrome Peeling
SS 1033462 - WST Cab Mounted Mekra Mirror Cover Chrome Peeling
0312-18 Installation Output Shaft Seal
sbw9801 Paint Finish Standards
0312-18 Installation Output Shaft Seal
Reducing Excessive Hood Opening Effort, 4900 Models
Body SRT Updates -2012.12.12
12-040-DLR Roof Fairing Removal Program
Suspension
11 bulletinsService Solution for Thread Spring Pin Suspension Alignment & Installation
Western Star Service Bulletin for Axle Flange Gasket Replaced with O-Ring.
Read full bulletin
Daimler Trucks North America has released a new axle shaft to hub rubber O-ring (part number 11-30728-000) as a replacement for the paper gasket (part number 11-14418-000). The new O-ring will provide better sealing and is reusable. It is quicker and easier to use compared to the paper gasket, because using a paper gasket requires cleaning the hub when the axle shaft is removed.
Western Star Bulletin for Non-Airliner Rear Suspension Crossmember Fastener Change.
Read full bulletin
With the start of production on March 2, 2020, the fasteners used to assemble the non-Airliner rear suspension (bogie) crossmember have changed. The rear suspension bogie crossmember gussets to the C-channel will be assembled with 5/818 fasteners. This change includes a revision to a higher friction nut that requires an increase in tightening torque. The new higher friction nut can be identified by its green color.
SS 1034171 Airliner Rear Suspension Chassis Lean Troubleshooting
33-4- Bearing Spacer Replacement, ConMet PreSet Steer Hubs
35-11 - Bearing Spacer Replacement, ConMet PreSet Drive Hubs
Detroit? DT12? Split Rod Bushing Repair
Warranty Recognition Program Suspension
FL718 FRONT AXLE HUB RATING
WESTERN STAR: CONMET RECOMMENDS REPLACING THE BEARING SPACER WHEN THE HUB IS REMOVED.
Read full bulletin
MODEL 4700, 4900, 6900. NO YEARS LISTED. *PE
WESTERN STAR: IT HAS BEEN RECOMMENDED, BY CONMET, THAT THE BEARING SPACER BE REPLACED WITH NEW ONE WHEN HUB IS REMOVED.
Read full bulletin
MODEL 4700, 4900, 6900.. NO YEARS LISTED. *PE
Tires & Wheels
11 bulletinsFL782 Interim Recall Ending - Final Recall Beginning
FL773 ? Interim Recall Notice
With the start of production on March 6, 2018, the fasteners used to attach the slide- and plate-mount style fifth...
Read full bulletin
wheels to the outboard angles changed to M16 metric bolts, nuts, and washers.
FL721 Interim Recall Ending ? Final Recall to Begin
14TL-7Rev DD Platform Flywheel Housing Runout Tool W470589032100
17TL25 TruckCam? Alignment System
- Auto Hauler Tire Failure Due to Improper Operation and Maintenance
14TL7 DD Platform Flywheel Housing Runout Tool W470589032100
907-14 Installation and Removal of the Flywheel Housing
ICI16-027 FL725 ? Interim Recall Notice
0902-16 SYMPTOM DIAGNOSTICS - BELT COMING OFF, SHREDDING OR MISALIGNMENT
Software & Calibration
8 bulletinsWarranty Information Letter announcing DTNA is adjusting the Standard Repair Times (SRTs) shown.
Read full bulletin
The updated times will be applied to repair orders opened on or after April 5, 2021.
129-13 DD Platform GHG 14 SPN 3361 FMI 3, 4, 5 UPDATE
1207-15 Updated procedures with adding EPA10 to the GHG14 title
15TL21 GHG17 Diagnostic Connector Update
20-18 - Western Star 4800 and 4900 Radiator Mounting, Update?EPA10
FINAL_15M1_BULLETIN GHG14 DD PLATFORM SOFTWARE REPROGRAMMING FOR AUTO ELEVATE
AEO15M1 GHG14 DD PLATFORM SOFTWARE REPROGRAMMING FOR AUTO ELEVATE
16-032_DETROIT STANDARD DIAGNOSTIC TIME FOR GHG14 AFTERTREATMENT DEVICE CHECKLIST UPDATED
HVAC & Climate
7 bulletinsUpdated Western Star Service Bulletin for HVAC Actuator Replacement
Service Solution for HVAC Fresh Air Intake Water Leak in certaian Western Star models-4700, 4900, and 5700
Service Bulletin: HVAC Fresh Air Intake Water Leak
In some operating conditions, water may leak into the cab onto the passenger floor through the HVAC fresh air intake on...
Read full bulletin
the frontwall on 47,00,4900, and 5700 models.
sbw8325 Side Window Defroster and Cooling Improvement Retrofit
506-15 Air Compressor Coolant Lines
49-13 - DEF Return Line Fitting Heater, 6-Gallon Tanks
Lighting
5 bulletinsWarranty Policy Letter for Chassis Progressive Damage Policy Change.
Read full bulletin
Effective for repair orders opened on or after April 27, 2020, if an Authorized Service Location installed a part which later has a warrantable failure, progressive damage and labor may be covered under the Aftermarket Parts Limited Parts Warranty (Parts Warranty).
Warranty Policy Letter for Handling Change: Over the Counter Aftermarket Parts Replacement Program.
Read full bulletin
DTNA is pleased to announce that handling will increase to 33% for Misc. Replacement Part type claims filed under the Over the Counter (OTC) Aftermarket Parts Replacement Program.
Some vehicles may have been incorrectly shimmed at the factory, and may lean slightly to the right or left.
Read full bulletin
While this does not affect the operation of the vehicle, it may be visually unpleasing to many customers.
sbw5430 Disconnecting or Connecting Daytime Running Lights
14-024-DLR DTNA & JAD Highlights - Q1 & Q2
Hybrid & EV
4 bulletinsThe modified parked regeneration strategy has been standard on GHG17 units since the start of GHG17 production and was...
Read full bulletin
added to EPA10 and GHG14 units with a software update. The modified regeneration utilizes an improved strategy to clean the DOC inlet face and reduce downtime due to DOC face plugging.
15TS5Rev GHG14 DD Platform DEF Pump Leaks and Code 4374 FMI 0 Under Pressurized DEF System
604-13 Performing a Parked Regeneration
SPN 3556 FMI 0, 1, 18 - Regeneration Temperature Update Procedures
Steering
3 bulletinsTech Talk discussion about power steering fluid.
Recall FL782- Detroit Steer Axle Tie Rods
Dealer Bulletin- FL782 Detroit Steer Axle Tie Rods
Air Bags & Safety
3 bulletinsFL725 Western Star Seat Belt Anchor Plates
Recall FL654A-Z-rev_IMMI Seat Belt Buckle
Recall FL654A-Z_IMMI Seat Belt Buckles
Infotainment
1 bulletinDTNA Special Tools Group has approved the use of Haweka Axis4000 aftermarket alignment system for use on DTNA products at DTNA service locations.
Read full bulletin
The Axis4000 system uses the reference points required by DTNA for precise, accurate, and repeatable measurements. Axis4000 is a sophisticated, user-friendly system that utilizes computer based camera-radio technology and references the center line of the frame for measuring and providing alignment results to DTNA specifications.