2007 Volvo VT TSBs
105 Technical Service Bulletins across 13 categories
Categories
Engine
20 bulletinsEngine Control Module (EMS) Software (MSW) Information August 2022; Improvement List (Change Log) - US21+OBD22 (13L...
Read full bulletin
VGT, TC) And US17+OBD22 (11L) Emissions
Programming Failure - Chassis With Cummins Engine And An Allison Transmission
Cylinder Head Reuse And Replacement Guidelines - Inspection And Information - US04 And Newer Emissions, Commonly 2007...
Read full bulletin
And Newer Model Years
Volvo Chassis - SNV 15-016 Documented Process For Engine Oil Consumption - All Emissions, All Model Years
Engine Coolant Thermostat Software Update
Engine Data Label
In some instances the exhaust rocker piston cap screw may become loose and back out causing loss of engine compression,...
Read full bulletin
or a mechanical injector Diagnostic Trouble Code (DTC).
VOLVO: LOW OIL PRESSURE, ON CERTAIN VEHICLES, DURING LONG HARD PULL CONDITIONS, DIAGNOSTIC TROUBLE CODES (DTCS) PID 100...
Read full bulletin
FM1, SPN 100 FMI 1 OR P252400, CAN LOG ON, WITH OR WITHOUT ENGINE SHUT DOWN LAMP. MODEL VN, VT. NO YEARS LISTED. *PE
VOLVO: ON SOME TRUCKS, THERE IS AN OIL CONTAMINATION INTO THE ENGINE WIRE HARNESS BECAUSE OF A FAILURE OF THE OIL LEVEL SENSOR.
Read full bulletin
MODELS VAH, VHD, VN, VT. NO MODEL YEARS LISTED. *PE
VOLVO TRUCKS: CONNECTOR PIN, REPLACEMENT.
Read full bulletin
SEVERE FRETTING DAMAGE OF THE ENGINE VARIABLE GEOMETRY TURBOCHARGER ACTUATOR (ENGINE VGT ACTUATOR) HARNESS AND TURBINE SHAFT SPEED SENSOR (TSS) CONNECTOR MAY CAUSE AN UNRELIABLE SIGNAL TO THE ENGINE VGT ACTUATOR. *JS
MACK TRUCKS: THERE IS REVISED MOUNTING HARDWARE FOR THE EXHAUST MANIFOLD AND TURBOCHARGER.
Read full bulletin
*RM
VOLVO TRUCKS: EXHAUST FLEX PIPE CRACKS.
Read full bulletin
BEGINNING MAY 12, 2008, A REDESIGNED EXHAUST FLEX PIPE AND TURBOCHARGER OUTLET PIPE (LOCATED BETWEEN THE TURBOCHARGER DIFFUSER PIPE AND THE EXHAUST FLEX PIPE) WERE IMPLEMENTED INTO PRODUCTION ON VN, VHD, AND VT MODEL CHASSIS. NO MODEL YEARS LISTED. *
VOLVO TRUCK: TO REDUCE THE POTENTIAL FOR CAB WATER INTRUSION, A CAB COWL SEAL HAS BEEN RELEASED BY ENGINEERING.
Read full bulletin
THE SEAL PART NUMBER 8083305 IS POSITIONED ABOVE THE TOP EDGE OF THE COWL PANEL TO DIVERT WATER FLOW ONTO THE COWL PANEL RATHER THAN BETWEEN THE COWL PANEL AND CAB. NO MODEL YEARS LISTED. *PE
VOLVO TRUCK: REPORTS PROMPTED THE RELEASE OF A REPLACEMENT CONNECTOR FOR THE CAB HVAC MOTOR RESISTOR.
Read full bulletin
REPLACEMENT CONNECTOR IS SUPPLIED AS KIT PART, WHICH CONTAINS THE CONNECTOR BODY AND THE NECESSARY TERMINALS. MODEL YEARS UNKNOWN. *PE
VOLVO TRUCKS: MEGA FUSE CORROSION.
Read full bulletin
VOLVO VEHICLES WITH US 07 EMISSIONS COMPLIANT ENGINES BUILT BETWEEN 11/12/06 AND 12/05/08 MAY HAVE CORROSION ISSUES WITH THE TWO MEGA FUSES IN THE BATTERY BOX AREA. *PE
VOLVO TRUCKS: MEGA FUSE CORROSION.
Read full bulletin
EMISSIONS COMPLAINT ENGINES BUILT BETWEEN 11/13/06 AND 12/05/08 MAY HAVE CORROSION ISSUES WITH THE TWO MEGA FUSES IN THE BATTERY BOX AREA. *PE
VOLVO TRUCKS: MEGA FUSE BREAKING.
Read full bulletin
TRUCKS WITH US 07 EMISSIONS COMPLIANT ENGINES BUILT BETWEEN 6/30/06 AND 1/15/08 MAY EXPERIENCE AN ISSUE WITH THE BATTERY COMPARTMENT MOUNTED 150 AMP POSITIVE SIDE MEGA FUSE BREAKING. MODELS VN, VHD, AND VT. MODEL YEARS UNKNOWN. *PE
SP 764-005, LOAD LEVELING VALVE, REPLACEMENT -- CERTAIN VN-2, VHD-2, AND VT MODEL TRUCKS BUILT BETWEEN 9/1/06 AND 4/1/07...
Read full bulletin
WITH REAR AIR SUSPENSION NEED TO HAVE THE REAR SUSPENSION LEVELING VALVE REPLACED. *NJ
CERTAIN VN-2, VHD-2, AND VT MODEL TRUCKS BUILT BETWEEN 9/1/06 AND 4/1/07 WITH REAR AIR SUSPENSION NEED TO HAVE THE REAR...
Read full bulletin
SUSPENSION LEVELING VALVE REPLACED. *NJ UPDATED 3/17/08. *NJ
VOLVO TRUCKS NORTH AMERICA - SP 366-002, ACTIVE PRESSURE COOLANT SYSTEM MODULE FAILURE / BUILT WITH A D16D ENGINE BETWEEN 01/10/05 AND 02/27/07.
Read full bulletin
*NJ
Electrical
17 bulletinsOverheating has been observed at the alternator power cable and ground cable connection, resulting in melted insulation around the terminal area.
Read full bulletin
The alternator power cable connection should maintain a stable electrical contact without overheating or insulation damage during normal vehicle operation. The alternator power cable shows signs of overheating and melted insulation at the connection point, which may affect electrical conductivity and charging system performance.
DEF Level (UQLS) Sensor Troubleshooting Guide - US17+OBD16 Emissions and Newer
NOx Sensor Troubleshooting Guide - US10+OBD13 And Newer Emissions
(Back Office) - Cruise Control Inoperative After Updating Software VECU5 Without ESP Package (UESP)
Temperature Sensor Troubleshooting Guide - US10+OBD13 And Newer
Unable To Retrieve "On Request" Messages For PeopleNet Or Omnitracs Modules Installed On The DL5 Data Link; Third Party...
Read full bulletin
Electronic Log Device Not Reporting Certain Data
Sensor And Parameter Values Missing Or Reading Zero When Performing A Sensor And Parameter Values Monitor With Premium...
Read full bulletin
Tech Tool ( PTT ) - US07 And US10 ( Pre-OBDII, 9-Pin Diagnostic Connector ) Chassis
DEF Level (UQLS) Sensor Troubleshooting Guide - US17+OBD16 Emissions and Newer
Shipping and Handling of Volvo Lithium-ion 48V Mild Hybrid Battery to Global Battery Solutions (GBS)
Exhaust Gas Recirculation (EGR) Differential Pressure Sensor
Oil Level Sensor Harness Wire Splice
VOLVO: LIGHT CONTROL MODULE (LCM), REPROGRAMMING.
Read full bulletin
ON SOME VOLVO UNITS EQUIPPED WITH CLEAR LED CLEARANCE LIGHTS IN THE SUN VISOR, THE MAY EXHIBIT AN ACTIVE FAULT CODE MID 216 PSID 49 FMI 5. THIS FAULT INDICATES A TRAILER MARKER OPEN ISSUE WHICH IS INCORRECT FOR THE ISSUE PRESENT ON THE VEHICLE. *JS
VOLVO: THE FRONT CHASSIS HARNESS MAY HAVE BEEN ROUTED WITH THE COMPRESSOR AIR DISCHARGE LINE WHICH CAN LEAD TO CORROSION OF THE HARNESS.
Read full bulletin
*RM
MEGA FUSE BREAKING ON VOLVO VEHICLES - VN, VHD, VT.
Read full bulletin
*PE
BATTERY CABLE ROUTING FOR CERTAIN VOLVO VEHICLES - VN-2, VHD-2, VT.
Read full bulletin
*PE
DPF REPLACEMENT -- CERTAIN VOLVO VEHICLES BUILT BETWEEN 7/1/06 AND 7/22/07 WITH A VERTICAL BACK OF CAB (VBOC) DIESEL...
Read full bulletin
PARTICULATE FILTER (DPF) AND A STACK HEIGHT OF 3.8 METERS (12' 6") OR GREATER, MAY EXPERIENCE CRACKING OF THE DPF OUTLET MODULE. *NJ
SP 258-003, DIESEL PARTICULATE FILTER OUTLET MODULE, REPLACEMENT.
Read full bulletin
CERTAIN VOLVO VEHICLES BUILT BETWEEN 07/01/06 AND 07/22/07. *NJ
Transmission
17 bulletinsCBR - Automated Manual Transmission ( AMT ) Flywheel Pilot Bearing Wear On Input Shaft.
Volvo Chassis - ( AMT, I-Shift ) - Transmission Grinding When Downshifting ; Range Synchronizer (Synchro) Timing...
Read full bulletin
Procedure - US07 And Newer
Volvo Chassis - Equipped with An Automated Manual Transmission (AMT, iShift) - SNV 19-002 - AMT Oil Filter Housing...
Read full bulletin
Corrosion
Warranty Automated Manual Transmission ( AMT, I-Shift, mDrive ) Control Housing Assembly; Guidelines For Filing A Claim...
Read full bulletin
For Chassis Return Visit With Transmission Issues After A Repair Requiring Control Housing Removal And Reinstallation - US07 And Newer
Volvo I-Shift AMT Will Not Calibrate After Incorrect Flywheel Housing Is Installed
Volvo Chassis - Diagnostic Trouble Codes ( DTC's ) - MID130 PID160 FMI1 Or FMI2 - For The I-Shift Transmission
Volvo Chassis - Equipped With An I-Shift Automated Manual Transmission ( AMT ) - Flywheel Resurfacing And Reuse...
Read full bulletin
Guidelines
Flywheel Resurfacing Guidelines, I-Shift
Twin Mass Flywheel Conversion, Transmission Removed
Transmission ECU Compatibility
VOLVO TRUCK: PROCEDURAL INFORMATION REGARDING THE REPLACEMENT OF HIGH RANGE CONE IN THE SECTION OF THE AUTOMATED MANUAL TRANSMISSION (AMT).
Read full bulletin
MODEL VN, VHD, VAH, VT. *PE UPDATED 8/8/14. *PE
VOLVO TRUCKS: DURING OPERATION OF DRIVER SIDE SWIVEL SEAT AND I SHIFT TRANSMISSION, THE HARNESS RUBBING OR WIRES, ARE PULLED OUT OF CONNECTORS.
Read full bulletin
THIS CAUSES SEAT HARNESS DROPPING OR PULLING AWAY FROM CLIPPING POINTS. *PE
VOLVO: THERE ARE NEW CLUTCH BEARING LUBRICATION TUBES.
Read full bulletin
*RM
VOLVO TRUCK: I SHIFT TRANSMISSION WITH MIXED COMPONENTS.
Read full bulletin
INSTALLATION OF REPLACEMENT PARTS IN AN I SHIFT TRANSMISSION (VERSION-C) MAY RESULT IN DIAGNOSTIC TROUBLE CODES (DTCS) MID 130 PID 160 FMI1 OR FMI2. NO MODEL YEARS LISTED. *PE
VOLVO TRUCK; CLUTCH SWITCH CLIP; IT HAS BEEN FOUND THAT VN, VHD AND VT VEHICLES USE A SPRING CLIP TO RETAIN THE CLUTCH...
Read full bulletin
SWITCH, MAY HAVE AN ISSUE WITH THE CLUTCH SWITCH MOVING OR DETACHING FROM IT'S MOUNT. *PE
TRANSMISSION ECU FUSE CONTAMINATION FOR CERTAIN VOLVO VEHICLES - VN-2, VHD-2, VT.
Read full bulletin
*PE
SP 432-025, CONTROL UNIT, GEAR SELECTOR REPLACEMENT; AT2512C, ATO2512C, AT2812C, ATO3112C.
Read full bulletin
*PE
Other
15 bulletinsCBR - A significant GPS reporting issue is affecting fleet operations, with trucks maintaining back-office communication...
Read full bulletin
but failing to transmit GPS location data.
AMT Control Housing Bench Testing - False Failures
The Diagnostic Process
Volvo Fault Code MID 144 PSID 204 FMI 9
Volvo Chassis Ghost Codes Due To Poor Grounding
Volvo Chassis - PTO Pump Speed Calculator
VIDA QR Scanner Mobile App
Volvo Chassis - Driveline (Driveshaft, Propeller Shaft) Ride Height And Angle, Measurement And Calculation; Pinion Angle...
Read full bulletin
Measurement - Model Year 1996 And Newer
Hill Start Assist Solenoid, Replacement
Hill Start Assist Solenoid, Replacement
AMT High Range Cone Replacement
Hill Start Assist Solenoid, Replacement
Timing Plate Leak Repair
Range Synchronizer, Repair
Hill Start Assist Solenoid, Replacement
Fuel System
15 bulletinsDEF Pump Troubleshooting Guide - US10+OBD13 And Newer Emissions
Fuel Level Gauge Reading Incorrect In The Instrument Cluster
Volvo Chassis - Fuel Level Gauge Slow To Respond To Changes In Fuel Level
Volvo Chassis - Fuel Level Sending Unit Specification Information
(Back Office Only) Volvo Chassis - Equipped With A Catalyzed Exhaust Aftertreatment System ( EATS ) - Regeneration (...
Read full bulletin
Regen ) Failure Diagnostic Process - US07 to US16 Emissions
(Back Office Only) Volvo Chassis - Equipped With A Catalyzed Exhaust Aftertreatment System ( EATS ) - Regeneration (...
Read full bulletin
Regen ) Failure Diagnostic Process - US07 to US16 Emissions
Volvo Chassis - Diesel Exhaust Fluid ( DEF ) Contamination In Fuel System, Inspection And Repair - US10 to US14 (...
Read full bulletin
Non-Common Rail Fuel System ) Removed information for common rail chassis - now has its own solution.
Dual Fuel Tanks Ventilation Filter Kit
Single Fuel Tank Ventilation Filter Kit
VOLVO: AN EXHAUST PIPE INSULATION BLANKET CAN DETERIORATE OVER TIME.
Read full bulletin
A NEW BLANKET HAS BEEN RELEASED TO PROTECT FROM ROAD SPLASH. *RM UPDATED 9/12/11. *PE
VOLVO: AN EXHAUST PIPE INSULATION BLANKET CAN DETERIORATE OVER TIME.
Read full bulletin
A NEW BLANKET HAS BEEN RELEASED TO PROTECT FROM ROAD SPLASH. *RM UPDATED 9/12/11. *PE
VOLVO TRUCK: FUEL TANK MOUNTING.
Read full bulletin
FUEL TANK STRAPS OVER TIME MAY LOSE TORQUE AND ALLOW THE FUEL TANK TO ROTATE. MODELS VN, VHD, VT, VAH. NO MODEL YEARS LISTED. *PE UPDATED 2/21/12. *PE
VOLVO TRUCKS: EXHAUST FLEX PIPE RELOCATION.
Read full bulletin
CERTAIN CAB MODEL TRUCKS MAY EXPERIENCE A DEFORMATION OF THE RIGHT HAND CAB SKIRT DUE THE CLOSE PROXIMITY OF THE EXHAUST FLEX PIPE. TO RESOLVE THIS ISSUE A NEW INTERMEDIATE PIPE HAS BEEN RELEASED, THE NEW INTERMEDIATE PIPE WILL RELOCATE THE FLEX PIPE 10 MM CLOSER TO THE FRAME RAIL. *PE
VOLVO TRUCK: ON SOME VEHICLES, COOLANT OVERFLOW OUT OF THE OVERFLOW TUBE OCCURS DURING THE DIESEL PARTICULATE FILTER REGENERATION CYCLE.
Read full bulletin
EXCESSIVE COOLANT FLOW FROM THE RADIATOR TOP TANK AND THERMOSTAT VENT LINES PREVENTS FLOW INTO THE DE-AERATION PROCESS. VN-2, VHD-2 VT MODELS ONLY. NO MODEL YEARS LISTED. *PE
VOLVO: LEAKAGE DETECTION DIAGNOSTICS IMPROVEMENTS TO REMEDY DTC'S.
Read full bulletin
ALL MODELS FROM MODEL YEARS 2003-2008. DIAGNOSTIC MONITOR FOR THE EVAPORATIVE EMISSION SYSTEM SMALL LEAK, HAS USED A SOFTWARE FUNCTION THAT CALCULATES LEAKAGE BASED ON A PRESSURE INFERRED FROM THE CURRENT CONSUMED BY AN ELECTRIC PUMP THAT PUMPS AIR INTO THE FUEL TANK SYSTEM. *PE
Body & Paint
5 bulletinsService Door Rust Prevention
Floor Cracks Repair (Rear Panel)
Floor Cracks Repair (Front Panel)
VOLVO: THERE MAY BE LEAKS AT THE LOWER SLEEPER WINDOW.
Read full bulletin
*RM
VOLVO TRUCK: DOOR SEAL, OUTER, REPLACEMENT.
Read full bulletin
THE OUTER SEAL ON THE CAB DOORS OF VOLVO MODEL TRUCKS MAY PREMATURELY SEPARATE FROM THE CAB SHELL. MODELS VN-2, VHD-2 AND VT. NO MODEL YEARS LISTED. *PE
Pre-Delivery & Maintenance
3 bulletinsVolvo Chassis - Drag Link Inspection And Replacement Criteria
Volvo Chassis - Dealer Support Communication - Selecting The Proper SR Area For Creating An eService
Volvo SNV14-035 When And How To Contact Tech Support ( eService & Phone )
Brakes
3 bulletinsDTC U012100 - Lost Communication With Anti-Lock Brake System (ABS) Control Module, No Additional Information
Volvo Chassis - Bendix ABS6 TO ABS8 Service Information
Volvo Chassis - FSB 761-002, Shock Absorber, Inspection
Software & Calibration
3 bulletinsVolvo SNV15-008 Vocom Adapter ( 88890300 ) May Lock Up When Updating Firmware
INSTRUMENT CLUSTER REPROGRAMMING.
Read full bulletin
*TT
COOLING SYSTEM UPDATE, US VEHICLES ONLY.
Read full bulletin
REPLACEMENT OF THE COOLANT EXPANSION TANK, EXPANSION TANK RIGHT HAND SUPPORT BRACKET, AND THE UPPER RADIATOR HOSE. *TT
Lighting
2 bulletinsTSB-Charge Air Cooler t-clamp install.
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P0420 Illuminating The Malfunction Indicator Lamp (MIL)
Infotainment
2 bulletinsInstrument Cluster Programming - Programming Fails Or Errors Display When Replacing An Instrument Cluster With A Newer...
Read full bulletin
Part Number (Conversion Kit) - US04 To US10 Chassis (9-Pin Diagnostic Connector)
Instrument Cluster Programming - Programming Fails Or Errors Display When Replacing An Instrument Cluster With A Newer...
Read full bulletin
Part Number (Conversion Kit) - US04 To US10 Chassis (9-Pin Diagnostic Connector)
Tires & Wheels
2 bulletinsTwin Mass Flywheel Conversion
NEW TECHNICAL COURSES AVAILABLE.
Read full bulletin
INTRODUCTION TO TIRE PRESSURE MONITORING SYSTEMS - CLASSES NOW AVAILABLE. THIS COURSE IS INTENDED TO FAMILIARIZE TECHNICIANS AND WORKSHOP FOREMEN WITH VOLVO'S TIRE PRESSURE MONITORING SYSTEMS. *NJ
Suspension
1 bulletinCBR - Z Spring Bracket Wear.
Read full bulletin
Volvo Chassis