2016 Volvo Vnl TSBs
202 Technical Service Bulletins across 13 categories
Categories
Fuel System
72 bulletinsEmissions Campaign: Volvo has determined that certain 2014 -2018 model year VN, VHD, and VAH Vehicles require a...
Read full bulletin
replacement Diesel Particulate Filter (DPF) along with updated software.
CBR: Vehicle Speed Factor (K-Factor) Programming - Speed Factor Value Incorrect When Calculated In Premium Tech Tool...
Read full bulletin
(PTT); Speedometer Reading Incorrectly Following A Change To Vehicle Speed Factor - US17+OBD16 And Newer Emissions, Common Model Year 2018.
Volvo DEF Pump Troubleshooting Guide - US10+OBD13 And Newer Emissions
Diagnostic Trouble Codes (DTC) P24F600 Or P24F700 - US14+OBD15 Emissions And Newer, Model Year 2016 And Newer
Diagnostic Trouble Code P200200 - Diagnostic Information; US14+OBD16 And Newer Emissions
DEF Pump Troubleshooting Guide - US10+OBD13 And Newer Emissions
Diesel Particulate Filter (DPF) And Diesel Oxidation Catalyst (DOC) Pin Testing Procedure - US07 And Newer Emissions,...
Read full bulletin
Model Year 2008 And Newer
Premium Tech Tool (PTT) - Message For Data Mismatch, Product Configuration Mismatch; Instruction To Run An Accessory Kit...
Read full bulletin
Displayed When Attempting To Run Diagnostics For Diagnostic Trouble Codes (DTC) Or Programming - US10+OBD13 And Newer Emissions,
Electronic Stability Program (ESP), Electronic Stability Control (ESC): Changes And Removal Information; Permissible PAR...
Read full bulletin
File Changes - US07 And Newer Emissions, Model Year 2008 And Newer
Back Office - Diagnostic / Troubleshooting Procedures For Exhaust Gas Recirculation (EGR) System Components; Covers Most...
Read full bulletin
EGR System Diagnostic Trouble Codes (DTC), See List In Solution - US10, US10+OBD13, US14+OBD*, US17+OBD* With A Variable Geometry
Fuel Level Gauge Reading Incorrect In The Instrument Cluster
Volvo Chassis - Fuel Level Gauge Slow To Respond To Changes In Fuel Level
(Back Office Only) Volvo Chassis - Equipped With A Catalyzed Exhaust Aftertreatment System ( EATS ) - Regeneration (...
Read full bulletin
Regen ) Failure Diagnostic Process - US07 to US16 Emissions
DEF Pump Troubleshooting Guide - US10+OBD13 And Newer Emissions
Selective Catalytic Reduction (SCR) Muffler Troubleshooting Guide - US10+OBD13 And Newer Emissions
Aftertreatment Hydrocarbon Injector (AHI) Troubleshooting Guide - US10+OBD13 And Newer Emissions
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P02FA US17+OBD16 And US17+OBD18 (GHG17) Emissions
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P2459 Lighting The Malfunction Indicator Lamp ( MIL ); Possible Frequent...
Read full bulletin
Regeneration Requests - US14+OBD15 And US14+OBD16 Emissions
Volvo Chassis - Diagnostic Trouble Codes ( DTC's ) P24A0 And P249F Lighting The Malfunction Indicator Lamp ( MIL ) -...
Read full bulletin
US14+OBD15, US14+OBD16 (Common Model Years 2016 And 2017), US17+OBD16 And Newer ( Common Rail Fuel System, Model Year 2018)
(Back Office Only) Volvo Chassis - Equipped With A Catalyzed Exhaust Aftertreatment System ( EATS ) - Regeneration (...
Read full bulletin
Regen ) Failure Diagnostic Process - US07 to US16 Emissions
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P0422 Lighting The Malfunction Indicator Light ( MIL ) - US14+OBD15 And...
Read full bulletin
US14+OBD16 Emissions, Common Model Years 2016 And 2017
Diagnostic Trouble Codes ( DTC ) P20EE, P207F And P103C, Diagnostic Procedure - REPLACES GUIDED DIAGNOSTICS IN PREMIUM...
Read full bulletin
TECH TOOL ( PTT ) - US10+OBD2013 to US14+OBD2016 (Non-Common Rail) Emissions, Commonly Model Years 2014 To 2017
Diagnostic Trouble Code ( DTC ) P26E8 Intermittently Lighting The Malfunction Indicator Lamp ( MIL ); Possible Derate...
Read full bulletin
Warning - US10+OBD13 And Newer Emissions, Model Year 2014 And Newer
Diagnostic Trouble Codes (DTC) P24F600 Or P24F700 - US14+OBD15 Emissions And Newer, Model Year 2016 And Newer
Volvo Chassis - US10 to US16 Emissions - Soot Level Will Not Reset After Regen Or Locked At 140%
Volvo Chassis - Diagnostic Trouble Codes ( DTC ) P208E And P103B Logging With Possible Derate( SCR Inducement ) -...
Read full bulletin
US14+OBD13, US14+OBD15, US14+OBD16 And US17+OBD16 And NewerEmissions, Common Year Models 2015 And Newer
Grounding Bus Bar (Cloverleaf, Grounding Star, Four Point Ground Stud) On Frame Rail; Inspection To Be Performed For...
Read full bulletin
Power And Ground, Data Link DTCs - US10 And Newer Emissions, Model Year 2011 And Newer
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P20CF, Diagnosis And Repair - US14+OBD15 Emissions, Common Model Year...
Read full bulletin
2016
* Revised * How And When To Diagnose A US14 / US15 Emissions P2463 Diagnostic Trouble Code ( DTC )
Premium Tech Tool (PTT) Error Code 43: Service Regeneration Fails To Start; Service Regen Does Not Complete With Error...
Read full bulletin
43 Displayed - US10+OBD13 And Newer Emissions, Common Model Year 2014 And Newer
Diesel Fuel Information - Acceptable Biodiesel, Fuel Blend For Summer And Winter - US07 And Newer Emissions, Model Year...
Read full bulletin
2008 And Newer
Diagnostic Trouble Codes ( DTC ) P2080, P2084, P242B Lighting The Malfunction Indicator Lamp ( MIL ) - US14+OBD13 And...
Read full bulletin
US14+OBD15 Emissions, Model Years 2015 And 2016
Correct Aftermarket Installation Of Permanent Electronic Log Devices ( ELD )( Qualcomm, PeopleNet, Omnitracs, GPS,...
Read full bulletin
Location Tracker, Etc.) RP1226 connection On The Data Link; Installation Instructions And Information For Third Party ( Aftermarket ) Devices Connected To The Data Link - US17+OBD16 And Newer Emissions, Models Built up to Week 37 (9/13) 2019.
Diagnostic Trouble Codes ( DTC ) P20EE, P207F And P103C, Diagnostic Procedure - REPLACES GUIDED DIAGNOSTICS IN PREMIUM...
Read full bulletin
TECH TOOL ( PTT ) - US10+OBD2013 to US14+OBD2016 (Non-Common Rail) Emissions, Commonly Model Years 2014 To 2017
Diagnostic Trouble Codes ( DTC ) P2080, P2084, P242B Lighting The Malfunction Indicator Lamp ( MIL ) - US14+OBD13 And...
Read full bulletin
US14+OBD15 Emissions, Model Years 2015 And 2016
Expired - Volvo Chassis - Diagnostic Trouble Code ( DTC ) P026C Lighting The Malfunction Indicator Light ( MIL ) -...
Read full bulletin
US14+OBD13, US14+OBD15 And US14+OBD16 - Commonly Model Years 2015 To 2017 (Non-Common Rail Fuel System) Chassis
Diagnostic Trouble Codes ( DTC ) P2080, P2084, P242B Lighting The Malfunction Indicator Lamp ( MIL ) - US14+OBD13 And...
Read full bulletin
OBD15 Emissions (Commonly Model Years 2015 And 2016)
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P205B Lighting The Malfunction Indicator Lamp ( MIL ) - US14+OBD15...
Read full bulletin
Emissions, Common Model Year 2016 ONLY
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P2002, Diagnostic Information - US14+OBD15 Emissions, Common Model Year...
Read full bulletin
2016
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P226C Intermittently Lighting The Malfunction Indicator Lamp ( MIL ) -...
Read full bulletin
US14+OBD13, US14+OBD15 And US14+OBD16 Emissions, Common Model Years 2015 to 2017
Volvo Chassis - Diagnostic Trouble Codes ( DTC ) P10FE And P24A4 Lighting The Malfunction Indicator Light ( MIL ) -...
Read full bulletin
US14+OBD13, US14+OBD15 And US14+OBD16 Emissions, Common Model Years 2015 To 2017
Volvo Chassis - Diagnostic Trouble Codes ( DTC ) P208E And P103B Logging With Possible Derate ( SCR Inducement ) -...
Read full bulletin
US14+OBD13, US14+OBD15, US14+OBD16 And US17+OBD16 And Newer Emissions, Common Year Models 2015 And Newer
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P2459 Lighting The Malfunction Indicator Lamp ( MIL ); Possible Frequent...
Read full bulletin
Regeneration Requests - US14+OBD15 And US14+OBD16 Emissions, Common Model Years 2016 And 2017
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P249C Intermittently Lighting The Malfunction Indicator Lamp ( MIL ) -...
Read full bulletin
US14+OBD15 And US14+OBD16 (Non-Common Rail Fuel System) Emissions, Common Model Years 2016 and 2017
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P20CF, Diagnosis And Repair - US14+OBD15 Emissions, Common Model Year...
Read full bulletin
2016
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P208A Lighting The Malfunction Indicator Lamp ( MIL ) - US14+OBD13 And...
Read full bulletin
US14+OBD15 Emissions, Common Model Years 2015 And 2016
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P226D Intermittently Lighting The Malfunction Indicator Lamp ( MIL ) -...
Read full bulletin
US14+OBD15 And US14+OBD16 Emissions (Non-Common Rail Fuel System), Commonly Model Years 2015 and 2016
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P0422 Lighting The Malfunction Indicator Light ( MIL ) - US14+OBD15 And...
Read full bulletin
US14+OBD16 Emissions, Common Model Years 2016 And 2017
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P0507 Lighting The Malfunction Indicator Lamp ( MIL ) - US14+OBD13,...
Read full bulletin
US14+OBD15, US14+OBD16 Emissions (Non-Common Rail Fuel System), Common Model Years 2015 To 2017
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P2002, Diagnostic Information - US10+OBD13, US14+OBD13, US14+OBD15,...
Read full bulletin
US14+OBD16 Emissions (Non-Common Rail Fuel System), Commonly Model Years 2014 to 2017
Volvo Chassis - Diagnostic Trouble Codes ( DTC's ) P24A0 And P249F Lighting The Malfunction Indicator Lamp ( MIL ) -...
Read full bulletin
US14+OBD15 (Commonly Model Year 2016) And Newer (Includes Common Rail Fuel System)
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P226D Intermittently Lighting The Malfunction Indicator Lamp ( MIL ) -...
Read full bulletin
US14+OBD15 And US14+OBD16 Emissions (Non-Common Rail Fuel System), Commonly Model Years 2015 and 2016
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P226C Intermittently Lighting The Malfunction Indicator Lamp ( MIL ) -...
Read full bulletin
US14+OBD13, US14+OBD15 And US14+OBD16 Emissions (Non-Common Rail Fuel System), Commonly Model Years 2015 to 2017
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P208A Lighting The Malfunction Indicator Lamp ( MIL ) - US14+OBD13 And...
Read full bulletin
US14+OBD15 Emissions, Common Model Years 2015 And 2016
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P205B Lighting The Malfunction Indicator Lamp ( MIL ) - US14+OBD15...
Read full bulletin
Emissions, Common Model Year 2016 ONLY
Volvo Chassis - Without Tire Pressure Monitoring System ( TPMS ) - Intermittent Brief Loss Of Throttle, Possible Data...
Read full bulletin
Link Codes - FSB 776-002 - US14+OBD13 Through US14+OBD16 Emissions, Commonly Model Years 2015 To 2017
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P0507 Lighting The Malfunction Indicator Lamp ( MIL ) - US14+OBD13,...
Read full bulletin
US14+OBD15, US14+OBD16 Emissions (Non-Common Rail Fuel System), Common Model Years 2015 To 2017
Volvo Chassis - Diagnostic Trouble Codes ( DTC ) P10FE And P24A4 Lighting The Malfunction Indicator Light ( MIL ) -...
Read full bulletin
US14+OBD13, US14+OBD15 And US14+OBD16 - Commonly Model Years 2015 To 2017 (Non-Common Rail Fuel System) Chassis
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P0422 Lighting The Malfunction Indicator Light ( MIL ) - US14+OBD15 And...
Read full bulletin
US14+OBD16 Emissions, Commonly Model Years 2016 And 2017
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P026C Lighting The Malfunction Indicator Light ( MIL ) - US14+OBD13,...
Read full bulletin
US14+OBD15 And US14+OBD16 - Commonly Model Years 2015 To 2017 (Non-Common Rail Fuel System) Chassis
Diagnostic Trouble Code ( DTC ) P249C Intermittently Lighting The Malfunction Indicator Lamp ( MIL ) - OBD15 And...
Read full bulletin
US14+OBD16 (Non-Common Rail Fuel System) Chassis
Diagnostic Trouble Codes ( DTC ) P2080, P2084, P242B Lighting The Malfunction Indicator Lamp ( MIL ) - US14+OBD13 And...
Read full bulletin
OBD15 Emissions (Commonly Model Years 2015 And 2016)
Diagnostic Trouble Code ( DTC ) P026C Lighting The Malfunction Indicator Light ( MIL ) - OBD15 And US14+OBD16...
Read full bulletin
(Non-Common Rail Fuel System) Chassis
Diagnostic Trouble Code ( DTC ) P009E - 73 - Fuel Pressure Relief Control Performance / Stuck Off - GHG17 ( US17 )...
Read full bulletin
Chassis With Common Rail Fuel System, Updated to reflect GHG17 software release
Diagnostic Trouble Codes ( DTC ) P208E And P103B Logging With Possible Derate ( SCR Inducement ) - OBD15, US14+OBD16...
Read full bulletin
Emissions And Newer Rewrote test procedure for better clarity.
Service Only Regen Requested With No Warning.
Read full bulletin
Diagnostic Trouble Codes ( DTC ) P24A4 / P10FE Active Or Inactive With Several Counts - OBD15 And OBD16 Conventional Chassis; Does Not Apply To US17 (Common Rail Fuel System) Chassis, Changed repair instructions to reflect OBD16 software release
Volvo Chassis - Diesel Exhaust Fluid ( DEF ) Contamination In Fuel System, Inspection And Repair - US10 to US14 (...
Read full bulletin
Non-Common Rail Fuel System ) Removed information for common rail chassis - now has its own solution.
Diagnostic Trouble Code ( DTC ) P009E - 73 - Fuel Pressure Relief Control Performance / Stuck Off - GHG17 ( US17 )...
Read full bulletin
Chassis With Common Rail Fuel SystemChanged repair instructions to reflect new procedures
Diagnostic Trouble Code ( DTC ) P208A Logging Intermittently - OBD15, OBD16 Emissions; Commonly Model Year ( MY ) 2016,...
Read full bulletin
2017 ChassisUpdated to reflect release of FSB284-064 (Above)
Service Only Regen Requested With No Warning.
Read full bulletin
Active Fault Codes P24A4 / P10FE - OBD15 And OBD16 Chassis; Does Not Apply To US17 (Common Rail Fuel System) ChassisUpdated to reflect release of FSB284-064 (Above)
Diagnostic Trouble Codes ( DTC ) P208E And P103B Logging With Possible Derate (SCR Inducement ) - US13 Emissions And...
Read full bulletin
Newer
Volvo Chassis - Logging Diagnostic Trouble Code ( DTC ) P026D - Fuel Injection Quantity Higher Than Expected - US15...
Read full bulletin
Emissions, Model Year ( MY ) 2016
Engine
33 bulletinsCBR: 11L Engine - Air Conditioner (A/C) Line Damaged At Bracket - Model Year 2007 to Present.
Barksdale Leveling Valve, Leak Test
CBR: Volvo DEF Dosing Valve Diagnostic Trouble Codes (DTC) P202D00, P208E00, P103B00 - US10+OBD13 And Newer Emissions
CBR: Programming Failure - Chassis With Cummins Engine And An Allison Transmission
Engine Control Module (EMS) Software (MSW) Information August 2022; Improvement List (Change Log) - US21+OBD22 (13L...
Read full bulletin
VGT, TC) And US17+OBD22 (11L) Emissions
Programming Failure - Chassis With Cummins Engine And An Allison Transmission
US10 Emission Engines - Diagnostic Trouble Code ( DTC ) SPN 1231 FMI 9 Troubleshooting
Vehicles Equipped With An Automated Manual Transmission Model D or F ( AMT-D, AMT-F ) - Transmission Oil Leakage From...
Read full bulletin
Transmission Input Shaft Seal Or Output Shaft Seal - US10 And Newer Emissions, Common Model Years 2010 And Newer
Volvo Chassis - Automated Manual Transmission Model F (AMT-F, I-Shift) - Possible Infrequent Hiccup/Stumble During...
Read full bulletin
Steady Engine/Vehicle Speed; Diagnostic Trouble Code P1074-92, P1074-94, P1074-96 Logging, Appears As Inactive
Volvo Chassis - Equipped With An I-Shift Automatic Manual Transmission ( AMT ) And D16 ( 16L ) Engine - Technical...
Read full bulletin
Service Bulletin V-216-001 Twin Mass Flywheel Conversion
Variable Geometry Turbocharger ( VGT ) Function Test ( 2551-08-03-02 ), OBD13 Model Year ( MY ) 2014 And Newer
Volvo Chassis - Approved Engine Oil For Volvo Engines, Factory Fill Oil Information - US07 And Newer Emissions, Model...
Read full bulletin
Year 2008 And Newer
Cylinder Head Reuse And Replacement Guidelines - Inspection And Information - US04 And Newer Emissions, Commonly 2007...
Read full bulletin
And Newer Model Years
Volvo Chassis - Models VNL, VNX Only Equipped With A USD16 Volvo Engine - AHI Harness Failure Related Fault Codes...
Read full bulletin
P249F00, P20DD13, P113413
Volvo Chassis - Equipped With A Cummins Engine - Cummins Fuel Pump Timing Correction to Reduce Engine Noise; Drone Noise...
Read full bulletin
at 1500 RPM and Increases With Engine Load - US10 And Newer Emissions, Common Model Year 2014 And Newer
"Intermittent Occurrences Of Very Brief Loss Of Power, Engine Stumble Or Hiccup Lasting Much Less Than A Second, Most...
Read full bulletin
Frequently Between 1500 And 1700 RPM, No Diagnostic Trouble Codes (DTC ) Generated - All Common Rail Fuel System Chassis"
Diagnostic Trouble Codes (DTC) For The Engine Pre-Heat Relay: Supplementary Instructions - US10+OBD13 And Newer...
Read full bulletin
Emissions, Model Year 2014 And Newer
This SKU is a DEF Injector.
Read full bulletin
The customer communication requested return of unsold inventory to inspect the sealing. The injector sealing may have an issue which will cause a slow leak. A slow leak of the DEF Injector can lead to crystal formation which can cause aftertreatment related fault codes and ECU driven engine derating.
Volvo Chassis - Discharge Recirculation Valve (DRV) - FSB 258-029 , Engine Turbocharger Compressor Bypass Valve...
Read full bulletin
Deletion Kit , Installation
Volvo Chassis - SNV 15-016 Documented Process For Engine Oil Consumption - All Emissions, All Model Years
US07 / US10 D13 Turbocharger Gasket
Volvo Chassis - SNV16-007 Telematics Gateway ( TGW ) Goes Offline Due To VIN Mismatch When Test Engine ECU Is Installed
Volvo Chassis - Equipped With An Automated Manual Transmission Model D or F ( I-Shift, AMT-D, AMT-F ) - Transmission Oil...
Read full bulletin
Leakage From Transmission Input Shaft Seal Or Output Shaft Seal - US10 And Newer Emissions, Common Model Years 2010 And Newer
Diagnostic Trouble Code (DTC) P24F6-00, Exhaust Aftertreatment Fuel Air Purge Valve Stuck Open Or DTC P24F7-00, Exhaust...
Read full bulletin
Aftertreatment Fuel Air Purge Valve Stuck Closed - US14+OBD15 Emissions And Newer, Model Year 2016 And Newer
Volvo Chassis - Crankcase Ventilation ( CCV ) Oil Leaks - FSB 257 - 004, FSB 257 - 006 - US14 And US15 Emissions
Volvo Chassis - Vehicles Equipped With Two-Piece Valve Cover - FSB 211-002 Two Piece Valve Cover Name Plate,...
Read full bulletin
Replacement; Name Plate Loose Or Missing - Model Year 2015 To 2018
Fuel Injector Offset Learning Diagnostic Trouble Codes ( DTC ) / Fault Codes Logged In Engine Control Module ( EMS );...
Read full bulletin
Possible Rough / Uneven Idle - US14+OBD15 Emissions (Commonly Model Year 2016)
Selective Catalytic Reduction ( SCR ) Efficiency And Diesel Exhaust Fluid ( DEF ) Dosing Valve Diagnostic Trouble Codes...
Read full bulletin
( DTC ) P208E, P103C, P0422, P20EE, P207F, P225E; Dosing Valve Diagnostic Information TO BE USED BEFORE DEF DOSING VALVE REPLACEMENT - OBD13 And Newer Emissions (Commonly Model Year 2014 And Newer)
Engine Diagnostic Trouble Codes ( DTC's ) P24A0 And P249F Lighting The Malfunction Indicator Lamp ( MIL ) - OBD15...
Read full bulletin
(Commonly Model Year 2016) And Newer, Changed repair instructions to reflect OBD16 software release
Automated Manual Transmission ( AMT - F ) ( I-Shift) Clutch Valve Unit ( CVU ) Makes Intermittent Buzzing Noise With The...
Read full bulletin
Key On And Engine OffChanged repair information to reflect new software available.
Engine Diagnostic Trouble Codes ( DTC's ) P24A0 And P249F Lighting The Malfunction Indicator Lamp ( MIL ) - OBD15...
Read full bulletin
(Commonly Model Year 2016) And NewerUpdated to reflect release of FSB284-064 (Above)
Volvo Trucks has received reports from the aftermarket regarding oil leaks at the CCV housing inlet tube and at the...
Read full bulletin
split line between the upper and the lower housings on chassis builds between January 1, 2014 and January 26, 2016 with D11, D13, and D16 engines.
Engine Data Label
Other
29 bulletinsCBR - Telematics Gateway (TGW) Connect Ability Issues.
CBR: TGW Will Not Connect After SIM Card Replacement
Expendable Items Parts List.
Part information for AMT input shaft repair kits and the shim kit that is required for repair.
AMT Control Housing Bench Testing - False Failures
The Diagnostic Process
Volvo Fault Code MID 144 PSID 204 FMI 9
Volvo Chassis Ghost Codes Due To Poor Grounding
Volvo Chassis - PTO Pump Speed Calculator
(Back Office Only) Volvo Chassis Loss Of Cruise Control After Disabling Electronic Stability Program (ESP)
VIDA QR Scanner Mobile App
Volvo Monthly Bulletin Release Letter - Feb 2022
Volvo Chassis US13 And Up Pre-trip Assistant Enable
Volvo Chassis - Driveline (Driveshaft, Propeller Shaft) Ride Height And Angle, Measurement And Calculation; Pinion Angle...
Read full bulletin
Measurement - Model Year 1996 And Newer
Diagnostic Trouble Code (DTC) U3017 - OBD2015/16 Model Year ( MY ) 2016/2017 Vehicles
Dynamometer Testing On 2016-17 Volvo Chassis
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P05EB, Diagnostic And Repair Information - US14+OBD15 And US14+OBD16...
Read full bulletin
(Commonly Model Years 2016 And 2017)
Volvo Chassis - Performance Bonus OBD13 And Newer
Volvo Chassis - Volvo Fusion 2 Collision Warning System Information
Diagnostic Trouble Code (DTC) P215A-64, Fault Code SPN 84 FMI 19; Speedometer Drop-Out, Speedometer Inoperative
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P0128, Diagnostic And Repair - US14+OBD15, Common Model Year 2016
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P20CF, Diagnosis And Repair - US14+OBD15, Commonly Model Year 2016
Diagnostic Trouble Code ( DTC ) P2698, Diagnostic And Repair Information - US14+OBD15 And US14+OBD16 (Commonly Model...
Read full bulletin
Years 2016 And 2017)
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P0128, Diagnostic And Repair - US14+OBD13 US14+OBD15 And US14+OBD16,...
Read full bulletin
Commonly Model Year 2015 Through 2017
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P05EB, Diagnostic And Repair Information - US14+OBD15 And US14+OBD16...
Read full bulletin
(Commonly Model Years 2016 And 2017)
Volvo Chassis - Equipped With Volvo Active Driver Assist ( VADA ), With Or Without Lane Departure Warning ( LDWS ) -...
Read full bulletin
Diagnostic Trouble Code ( DTC ) SPN 516103 FMI 19, Bendix Code 167 With Possible "Lane Departure Warning Malfunction" Message - US17 And Newer
"Volvo Chassis - Equipped With Volvo Active Driver Assist ( VADA ), With Or Without Lane Departure Warning ( LDWS ) -...
Read full bulletin
Diagnostic Trouble Code ( DTC ) SPN 70 MI 9, Bendix Code 64 With Possible ""Lane Departure Warning Malfunction"" Message - US17 And Newer"
OBD2015/16 ( MY - 2016/2017 ) Trucks are logging U3017 Fault Code ( DTC )
Some Volvo VNM, VNL and VAH trucks built between 02/23/2009 and 07/14/2017 with steel bogie cross members may develop...
Read full bulletin
cracks depending on application or duty cycle.
Electrical
20 bulletinsAftertreatment Diesel Exhaust Fluid (DEF) Tank, Level Sensor, Replacement
Aftertreatment Diesel Exhaust Fluid (DEF) Tank, Level Sensor, Replacement
DEF Level (UQLS) Sensor Troubleshooting Guide - US17+OBD16 Emissions and Newer
NOx Sensor Troubleshooting Guide - US10+OBD13 And Newer Emissions
(Back Office) - Cruise Control Inoperative After Updating Software VECU5 Without ESP Package (UESP)
Particulate Matter (PM) Sensor Troubleshooting Guide - US14+OBD16 And Newer Emissions
Temperature Sensor Troubleshooting Guide - US10+OBD13 And Newer
Unable To Retrieve "On Request" Messages For PeopleNet Or Omnitracs Modules Installed On The DL5 Data Link; Third Party...
Read full bulletin
Electronic Log Device Not Reporting Certain Data
DEF Level (UQLS) Sensor Troubleshooting Guide - US17+OBD16 Emissions and Newer
Shipping and Handling of Volvo Lithium-ion 48V Mild Hybrid Battery to Global Battery Solutions (GBS)
Volvo Chassis - SNV 14-026 P111C Compressor Discharge Temperature Sensor
Volvo Chassis - Rain Sensor Bracket Removal And Installation Procedure when Using An Aftermarket Windshield
Diagnostic Trouble Code ( DTC ) P10AE Logged In TECU With ACTIVE Or INACTIVE Status, Fault Code Cannot Be Cleared;...
Read full bulletin
Possibly Accompanied By P105817 And P105818 - US10+OBD13 And Newer Emissions (16-Pin Diagnostic Connector), Commonly Model Year 2014 And Newer
Exhaust Gas Recirculation (EGR) System - Fault Codes SPN 412 FMI 0,2,5; Diagnostic Trouble Codes (DTC) P040A, P040B,...
Read full bulletin
P1121 - Temperature Sensor Inspection
Exhaust Particulate Sensor, Repair (2016 Vehicles)
Selective Catalytic Reduction ( SCR ) Efficiency And NOx Sensor Codes P225C, P225E, P221A, P2201, P103C, P20EE, And...
Read full bulletin
P207F : NOx Sensor Diagnostic Information TO BE USED BEFORE SENSOR REPLACEMENT - OBD13 And Newer Emissions (Commonly Model Year 2014 And Newer)
Diagnostic Trouble Code ( DTC ) P0194 - 00 - Fuel Rail Pressure Sensor ( RPS ), Circuit Erratic, Intermittent - US17 (...
Read full bulletin
GHG17 ) Emissions And Newer ( Common Rail Fuel System ); Common Model Years 2017 And 2018Changed repair instructions to reflect new procedures
Exhaust Gas Recirculation (EGR) Differential Pressure Sensor
The bolt connecting the upper steering shaft to the lower steering shaft at the junction block may not properly secure the upper steering shaft.
Read full bulletin
Also the roll pin that secures that the lower shaft may have not been installed. As a result, the upper steering shaft may separate without warning with complete loss of steering which may result in a vehicle crash.
THE BOLT CONNECTING THE UPPER STEERING SHAFT TO THE LOWER STEERING SHAFT AT THE JUNCTION BLOCK MAY NOT PROPERLY SECURE THE UPPER STEERING SHAFT.
Read full bulletin
ALSO THE ROLL PIN THAT SECURES THAT THE LOWER SHAFT MAY HAVE NOT BEEN INSTALLED. AS A RESULT, THE UPPER STEERING SHAFT MAY SEPARATE WITHOUT WARNING WITH COMPLETE LOSS OF STEERING WHICH MAY RESULT IN A VEHICLE CRASH.
Lighting
13 bulletinsTSB-Charge Air Cooler t-clamp install.
Volvo Chassis - LED Headlights Conversion Programming Procedure - Model VNL
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P0420 Illuminating The Malfunction Indicator Lamp (MIL)
Volvo Chassis 2008 And Up LED Headlight Conversion Programming Procedure
Volvo Chassis - Exterior Lights - Converting From Incandescent To LED Lamps; Hardware And Software Requirements And...
Read full bulletin
Programming Information - Model Year 2008 Through 2017
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P226C Intermittently Lighting The Malfunction Indicator Lamp ( MIL )...
Read full bulletin
-OBD15 And OBD16 Conventional Chassis, Changed repair instructions to reflect OBD16 software release
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P2459 Lighting The Malfunction Indicator Lamp ( MIL ); Possible Frequent...
Read full bulletin
Regeneration Requests - OBD15 And US14+OBD16 (Non-Common Rail) Chassis, Changed repair instructions to reflect OBD16 software release
Diagnostic Trouble Code ( DTC ) P249C Intermittently Lighting The Malfunction Indicator Lamp ( MIL ) - OBD15 And...
Read full bulletin
US14+OBD16 (Non-Common Rail) Chassis, Changed repair instructions to reflect OBD16 software release
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P2459 Lighting The Malfunction Indicator Lamp ( MIL ); Possible Frequent...
Read full bulletin
Regeneration Requests - OBD15 And Newer ChassisUpdated to reflect release of FSB284-064 (Above)
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P226C Intermittently Lighting The Malfunction Indicator Lamp ( MIL ) -...
Read full bulletin
OBD15 And OBD16 Conventional ChassisUpdated to reflect release of FSB284-064 (Above)
Diagnostic Trouble Code ( DTC ) P249C Intermittently Lighting The Malfunction Indicator Lamp ( MIL ) - OBD15 And OBD16,...
Read full bulletin
Model Year ( MY ) 2016 and 2017 ChassisUpdated to reflect release of FSB284-064 (Above)
Diagnostic Trouble Code ( DTC ) P0422 Lighting The Malfunction Indicator Light ( MIL ) - OBD15 And OBD16 Chassis...
Read full bulletin
(Non-Common Rail)Updated to reflect release of FSB284-064 (Above)
Fog Lamp Moisture Intrusion
Transmission
11 bulletinsCBR - Automated Manual Transmission ( AMT ) Flywheel Pilot Bearing Wear On Input Shaft.
Volvo Chassis - ( AMT, I-Shift ) - Transmission Grinding When Downshifting ; Range Synchronizer (Synchro) Timing...
Read full bulletin
Procedure - US07 And Newer
Volvo Chassis - Equipped with An Automated Manual Transmission (AMT, iShift) - SNV 19-002 - AMT Oil Filter Housing...
Read full bulletin
Corrosion
Warranty Automated Manual Transmission ( AMT, I-Shift, mDrive ) Control Housing Assembly; Guidelines For Filing A Claim...
Read full bulletin
For Chassis Return Visit With Transmission Issues After A Repair Requiring Control Housing Removal And Reinstallation - US07 And Newer
Volvo I-Shift AMT Will Not Calibrate After Incorrect Flywheel Housing Is Installed
Automated Manual Transmission (AMT) (Spigot Bearing) Input Shaft Repair Kit And Shim Kit, Part Number Information,...
Read full bulletin
Reference Guide - US07 And Newer Emissions, Model Year 2008 And Newer
Automated Manual Transmission Gearbox Will Not Shift To High Range After Gearbox Repair; MID 130 PSID 24 FMI 1, P1072-92...
Read full bulletin
Unintentional Disengagement Of High Range - US07 And Newer Emissions, Model Year 2008 And Newer
Vehicles Equipped With An Automated Manual Transmission (AMT) - Input Shaft/Spigot Bearing Repair, Replacement,...
Read full bulletin
Inspection And Reuse Guidelines - US07 And Newer Emissions, Model Year 2008 And Newer
Automated Manual Transmission (AMT) Faults - Diagnostic Trouble Codes (DTC) P1052-18 Or MID 130 PID 33 FMI 5...
Read full bulletin
Intermittent Fault In Cold Weather - US07 And Newer Emissions, Model Year 2008 And Newer
Volvo Chassis - Equipped With An Automated Manual Transmission (AMT, I-Shift ) - Error Code 126 Displayed In Premium...
Read full bulletin
Tech Tool (PTT ) While Performing The Calibration Procedure After The Shift Control Housing Has Been Removed And Installed, Rewritten to improve return from multiple search terms.
This document is a Technical Journal: If vibration or jerk occur during drive in different speeds with small throttle...
Read full bulletin
angle and gears at constant speed, follow the advice under Service. This might be due to the tires. If the tires are from different brands, has different tyre wear or with different rolling circumference, DEM (Differential Electronic Module) interprets this as spare wheel is used on the vehicle and try to compensate to get RPM correct on all four wheels.
Brakes
5 bulletinsCBR - Active "Set Park Brake" Message On Drivers Information Display (DID)
DTC U012100 - Lost Communication With Anti-Lock Brake System (ABS) Control Module, No Additional Information
Volvo Chassis - Bendix ABS6 TO ABS8 Service Information
(Back Office Only) Volvo Chassis - VN Model - Front Brake Squeal - US14 And Newer
Volvo Chassis - VN Models Equipped With Bendix Brakes, Bendix S-Cam On Steer Axle - Excessive Brake Noise; Diagnosis And...
Read full bulletin
Repair Information; FSB 514-001, Brake S-Cam, Replacement - Model Years 2014 To 2018
Software & Calibration
5 bulletinsVolvo SNV15-008 Vocom Adapter ( 88890300 ) May Lock Up When Updating Firmware
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P2002, Diagnostic Information - OBD13 And Newer Changed repair...
Read full bulletin
instructions to reflect OBD16 software release
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P0128, Diagnostic And Repair - US14+OBD13 (Commonly Year Model 2015) And...
Read full bulletin
NewerUpdated to reflect release of FSB284-064 (Above)
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P2002, Diagnostic Information - OBD13 And NewerUpdated to reflect...
Read full bulletin
release of FSB284-064 (Above)
This document is a Technical Journal: TJ updated with chassis breakpoint and structure week end date.Customer may...
Read full bulletin
experience some road noise coming from the B-pillar belt adjuster area.
Infotainment
4 bulletinsCBR: Volvo VHD & VN Models - Vehicle Wil Not Start, PTO Active Message Displayed In Cluster, PTO Light On When PTO...
Read full bulletin
Switch Is Turned Off
Vehicle Overspeed Warning Comes Active At A Lower Speed Than Expected; Vehicle Overspeed Warning In Driver Information...
Read full bulletin
Display (DID) - Model Year 2018 And Newer With New Style Instrument Cluster
Volvo Chassis - Enable The Fault Code, Diagnostic Trouble Code ( DTC ) Screen (Menu) In The Instrument Cluster ( IC,...
Read full bulletin
Dash ); Fault Code Screen (Menu) Missing From Driver Information Display (DID); Read Fault Codes (DTCs) In Cluster
Instrument Cluster Programming - Programming Fails Or Errors Display When Replacing An Instrument Cluster With A Newer...
Read full bulletin
Part Number (Conversion Kit) - US04 To US10 Chassis (9-Pin Diagnostic Connector)
Pre-Delivery & Maintenance
3 bulletinsVolvo Chassis - Drag Link Inspection And Replacement Criteria
Volvo Chassis - Dealer Support Communication - Selecting The Proper SR Area For Creating An eService
Volvo SNV14-035 When And How To Contact Tech Support ( eService & Phone )
Steering
3 bulletinsThe draglink rod boot may be compromised and enable dirt/water to contaminate the draglink rod ball socket on some VOLVO...
Read full bulletin
VN trucks equipped with a sealed Uresko draglink rod. If this condition is untreated, failure of the ball socket and a complete loss of steering may be possible.
ONE PIECE STEERING SHAFT, REPLACEMENT RECALL
THE DRAGLINK ROD BOOT MAY BE COMPROMISED AND ENABLE DIRT/WATER TO CONTAMINATE THE DRAGLINK ROD BALL SOCKET ON SOME VOLVO...
Read full bulletin
VN TRUCKS EQUIPPED WITH A SEALED URESKO DRAGLINK ROD. IF THIS CONDITION IS UNTREATED, FAILURE OF THE BALL SOCKET AND A COMPLETE LOSS OF STEERING MAY BE POSSIBLE.
Suspension
2 bulletinsCBR - Driveline Noise, Suspension Ride Height Too High, Suspension Will Not Exhaust - Chassis Built 2016w01 And Newer
Volvo Chassis US13 And Up Enable " Air Suspension Pressure Gauge " In The Cluster
Body & Paint
2 bulletinsVolvo Chassis - Model VN - Updated Chassis Fairing DEF Door Magnet/Plate
Customer may intermittently experience the vehicle ORVM (outer rear view mirror) will not fold when locking/unlocking.