2002 Volvo VNL TSBs
66 Technical Service Bulletins across 11 categories
Categories
Engine
12 bulletinsBarksdale Leveling Valve, Leak Test
CBR: Programming Failure - Chassis With Cummins Engine And An Allison Transmission
Engine Control Module (EMS) Software (MSW) Information August 2022; Improvement List (Change Log) - US21+OBD22 (13L...
Read full bulletin
VGT, TC) And US17+OBD22 (11L) Emissions
Programming Failure - Chassis With Cummins Engine And An Allison Transmission
"Intermittent Occurrences Of Very Brief Loss Of Power, Engine Stumble Or Hiccup Lasting Much Less Than A Second, Most...
Read full bulletin
Frequently Between 1500 And 1700 RPM, No Diagnostic Trouble Codes (DTC ) Generated - All Common Rail Fuel System Chassis"
Volvo Chassis - Discharge Recirculation Valve (DRV) - FSB 258-029 , Engine Turbocharger Compressor Bypass Valve...
Read full bulletin
Deletion Kit , Installation
Volvo Chassis - SNV 15-016 Documented Process For Engine Oil Consumption - All Emissions, All Model Years
US07 / US10 D13 Turbocharger Gasket
Volvo Chassis - SNV16-007 Telematics Gateway ( TGW ) Goes Offline Due To VIN Mismatch When Test Engine ECU Is Installed
Automated Manual Transmission ( AMT - F ) ( I-Shift) Clutch Valve Unit ( CVU ) Makes Intermittent Buzzing Noise With The...
Read full bulletin
Key On And Engine OffChanged repair information to reflect new software available.
Engine Diagnostic Trouble Codes ( DTC's ) P24A0 And P249F Lighting The Malfunction Indicator Lamp ( MIL ) - OBD15...
Read full bulletin
(Commonly Model Year 2016) And NewerUpdated to reflect release of FSB284-064 (Above)
Engine Data Label
Electrical
12 bulletinsDEF Level (UQLS) Sensor Troubleshooting Guide - US17+OBD16 Emissions and Newer
NOx Sensor Troubleshooting Guide - US10+OBD13 And Newer Emissions
(Back Office) - Cruise Control Inoperative After Updating Software VECU5 Without ESP Package (UESP)
Temperature Sensor Troubleshooting Guide - US10+OBD13 And Newer
Unable To Retrieve "On Request" Messages For PeopleNet Or Omnitracs Modules Installed On The DL5 Data Link; Third Party...
Read full bulletin
Electronic Log Device Not Reporting Certain Data
DEF Level (UQLS) Sensor Troubleshooting Guide - US17+OBD16 Emissions and Newer
Shipping and Handling of Volvo Lithium-ion 48V Mild Hybrid Battery to Global Battery Solutions (GBS)
Volvo Chassis - SNV 14-026 P111C Compressor Discharge Temperature Sensor
Volvo Chassis - Rain Sensor Bracket Removal And Installation Procedure when Using An Aftermarket Windshield
Exhaust Gas Recirculation (EGR) System - Fault Codes SPN 412 FMI 0,2,5; Diagnostic Trouble Codes (DTC) P040A, P040B,...
Read full bulletin
P1121 - Temperature Sensor Inspection
Diagnostic Trouble Code ( DTC ) P0194 - 00 - Fuel Rail Pressure Sensor ( RPS ), Circuit Erratic, Intermittent - US17 (...
Read full bulletin
GHG17 ) Emissions And Newer ( Common Rail Fuel System ); Common Model Years 2017 And 2018Changed repair instructions to reflect new procedures
Exhaust Gas Recirculation (EGR) Differential Pressure Sensor
Other
10 bulletinsAMT Control Housing Bench Testing - False Failures
The Diagnostic Process
Volvo Fault Code MID 144 PSID 204 FMI 9
Volvo Chassis Ghost Codes Due To Poor Grounding
Volvo Chassis - PTO Pump Speed Calculator
VIDA QR Scanner Mobile App
Volvo Chassis - Driveline (Driveshaft, Propeller Shaft) Ride Height And Angle, Measurement And Calculation; Pinion Angle...
Read full bulletin
Measurement - Model Year 1996 And Newer
Volvo Chassis - Volvo Fusion 2 Collision Warning System Information
Volvo Chassis - Equipped With Volvo Active Driver Assist ( VADA ), With Or Without Lane Departure Warning ( LDWS ) -...
Read full bulletin
Diagnostic Trouble Code ( DTC ) SPN 516103 FMI 19, Bendix Code 167 With Possible "Lane Departure Warning Malfunction" Message - US17 And Newer
"Volvo Chassis - Equipped With Volvo Active Driver Assist ( VADA ), With Or Without Lane Departure Warning ( LDWS ) -...
Read full bulletin
Diagnostic Trouble Code ( DTC ) SPN 70 MI 9, Bendix Code 64 With Possible ""Lane Departure Warning Malfunction"" Message - US17 And Newer"
Fuel System
9 bulletinsDEF Pump Troubleshooting Guide - US10+OBD13 And Newer Emissions
Fuel Level Gauge Reading Incorrect In The Instrument Cluster
Volvo Chassis - Fuel Level Gauge Slow To Respond To Changes In Fuel Level
Diagnostic Trouble Code ( DTC ) P009E - 73 - Fuel Pressure Relief Control Performance / Stuck Off - GHG17 ( US17 )...
Read full bulletin
Chassis With Common Rail Fuel System, Updated to reflect GHG17 software release
Diagnostic Trouble Codes ( DTC ) P208E And P103B Logging With Possible Derate ( SCR Inducement ) - OBD15, US14+OBD16...
Read full bulletin
Emissions And Newer Rewrote test procedure for better clarity.
Volvo Chassis - Diesel Exhaust Fluid ( DEF ) Contamination In Fuel System, Inspection And Repair - US10 to US14 (...
Read full bulletin
Non-Common Rail Fuel System ) Removed information for common rail chassis - now has its own solution.
Diagnostic Trouble Code ( DTC ) P009E - 73 - Fuel Pressure Relief Control Performance / Stuck Off - GHG17 ( US17 )...
Read full bulletin
Chassis With Common Rail Fuel SystemChanged repair instructions to reflect new procedures
Service Only Regen Requested With No Warning.
Read full bulletin
Active Fault Codes P24A4 / P10FE - OBD15 And OBD16 Chassis; Does Not Apply To US17 (Common Rail Fuel System) ChassisUpdated to reflect release of FSB284-064 (Above)
Diagnostic Trouble Codes ( DTC ) P208E And P103B Logging With Possible Derate (SCR Inducement ) - US13 Emissions And...
Read full bulletin
Newer
Lighting
8 bulletinsVolvo Chassis - LED Headlights Conversion Programming Procedure - Model VNL
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P0420 Illuminating The Malfunction Indicator Lamp (MIL)
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P2459 Lighting The Malfunction Indicator Lamp ( MIL ); Possible Frequent...
Read full bulletin
Regeneration Requests - OBD15 And US14+OBD16 (Non-Common Rail) Chassis, Changed repair instructions to reflect OBD16 software release
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P2459 Lighting The Malfunction Indicator Lamp ( MIL ); Possible Frequent...
Read full bulletin
Regeneration Requests - OBD15 And Newer ChassisUpdated to reflect release of FSB284-064 (Above)
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P226C Intermittently Lighting The Malfunction Indicator Lamp ( MIL ) -...
Read full bulletin
OBD15 And OBD16 Conventional ChassisUpdated to reflect release of FSB284-064 (Above)
Diagnostic Trouble Code ( DTC ) P249C Intermittently Lighting The Malfunction Indicator Lamp ( MIL ) - OBD15 And OBD16,...
Read full bulletin
Model Year ( MY ) 2016 and 2017 ChassisUpdated to reflect release of FSB284-064 (Above)
Diagnostic Trouble Code ( DTC ) P0422 Lighting The Malfunction Indicator Light ( MIL ) - OBD15 And OBD16 Chassis...
Read full bulletin
(Non-Common Rail)Updated to reflect release of FSB284-064 (Above)
Fog Lamp Moisture Intrusion
Transmission
3 bulletinsVolvo Chassis - Equipped with An Automated Manual Transmission (AMT, iShift) - SNV 19-002 - AMT Oil Filter Housing...
Read full bulletin
Corrosion
Warranty Automated Manual Transmission ( AMT, I-Shift, mDrive ) Control Housing Assembly; Guidelines For Filing A Claim...
Read full bulletin
For Chassis Return Visit With Transmission Issues After A Repair Requiring Control Housing Removal And Reinstallation - US07 And Newer
Volvo Chassis - Equipped With An Automated Manual Transmission (AMT, I-Shift ) - Error Code 126 Displayed In Premium...
Read full bulletin
Tech Tool (PTT ) While Performing The Calibration Procedure After The Shift Control Housing Has Been Removed And Installed, Rewritten to improve return from multiple search terms.
Pre-Delivery & Maintenance
3 bulletinsVolvo Chassis - Drag Link Inspection And Replacement Criteria
Volvo Chassis - Dealer Support Communication - Selecting The Proper SR Area For Creating An eService
Volvo SNV14-035 When And How To Contact Tech Support ( eService & Phone )
Brakes
3 bulletinsDTC U012100 - Lost Communication With Anti-Lock Brake System (ABS) Control Module, No Additional Information
Volvo Chassis - Bendix ABS6 TO ABS8 Service Information
VOLVO: BRAKE CAM TUBE REINFORCEMENT WITH SUPER SINGLE WHEELS/TIRES AND ARVIN MERITOR BRAKES.
Read full bulletin
A REAR BRAKE S CAM TUBE SUPPORT BRACKET KIT HAS BEEN DESIGNED FOR SPECIFIC VEHICLES EQUIPPED WITH ARVIN MERITOR S CAMS AND SINGLE, WIDE DRIVE TIRES. NO MODEL YEARS LISTED. *PE
Software & Calibration
3 bulletinsVolvo SNV15-008 Vocom Adapter ( 88890300 ) May Lock Up When Updating Firmware
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P0128, Diagnostic And Repair - US14+OBD13 (Commonly Year Model 2015) And...
Read full bulletin
NewerUpdated to reflect release of FSB284-064 (Above)
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P2002, Diagnostic Information - OBD13 And NewerUpdated to reflect...
Read full bulletin
release of FSB284-064 (Above)
Infotainment
2 bulletinsCBR: Volvo VHD & VN Models - Vehicle Wil Not Start, PTO Active Message Displayed In Cluster, PTO Light On When PTO...
Read full bulletin
Switch Is Turned Off
Instrument Cluster Programming - Programming Fails Or Errors Display When Replacing An Instrument Cluster With A Newer...
Read full bulletin
Part Number (Conversion Kit) - US04 To US10 Chassis (9-Pin Diagnostic Connector)
Body & Paint
1 bulletinVolvo Chassis - Model VN - Updated Chassis Fairing DEF Door Magnet/Plate