2017 Volvo VN TSBs
318 Technical Service Bulletins across 16 categories
Categories
Engine
63 bulletinsEmissions - Volvo Trucks has determined that certain vehicles equipped with a model year (MY) 2017-2018 11L engine may...
Read full bulletin
not meet California and Federal Regulations (CARB).
Inactive Code P25AE00 Being Generated After A Hard Pull And A Momentary Drop In Engine Oil Pressure (Low Oil Pressure)...
Read full bulletin
(Possible Related Codes - SPN4811 , SPN 100 , PID 100)
ER - Volvo Trucks has identified that the Selective Catalyst Reduction (SCR) system in certain vehicles equipped with...
Read full bulletin
the MY 2017 or 2018 13L VGT and Turbo Compound (TC) engine are not meeting California and EPA emissions standards, or Volvo cannot confirm its compliance.
CBR - Vertical Exhaust Aftertreatment System (EATS) Catalyst Cracking -Trucks Equipped With a Cummins 12LCompressed...
Read full bulletin
Natural Gas (CNG) Engine
CBR - 11L, 13L, And 16L Engine Oil Analysis Specifications - US10 And Newer Emissions
EM - Volvo Trucks has identified that the Selective Catalyst Reduction (SCR) system in certain vehicles equipped with...
Read full bulletin
the MY 2017 or 2018 13L Turbo Compound (TC) engine are not meeting California and EPA emissions standards, or Volvo cannot confirm its compliance.
EM - Volvo Trucks has identified that the Selective Catalyst Reduction (SCR) system in certain vehicles equipped with...
Read full bulletin
the MY 2017 or 2018 (13L VGT) engine are not meeting California and EPA emissions standards, or Volvo cannot confirm its compliance.
These repair instructions are intended to address the following fault(s): P009B-13 (Electric Pressure Relief Valve ...
Read full bulletin
Circuit Open).
Volvo Trucks has identified that the Selective Catalyst Reduction (SCR) system in certain vehicles equipped with the MY...
Read full bulletin
2017 or 2018 (13L VGT) engine are not meeting California and EPA emissions standards, or Volvo cannot confirm its compliance. These vehicles have been flagged due to telematics data showing that the NOx conversion efficiency of the SCR system has dropped below 94% for eight weeks. Alternatively, these vehicles may have communication issues with telematics, such as not reporting or ceasing reporting for the same period.
Vehicles may present with oil leak coming from the clutch/flywheel housing and observation of burned clutch smell or clutch slipping.
Read full bulletin
These symptoms can be mistaken as a crankshaft rear main seal leak, when the actual cause is the crankshaft adaptor O-ring.
CBR - Automated Manual Transmission (AMT) Model D or F (mDrive and I-Shift, AMT-D, AMT-F) - Transmission Oil Leakage...
Read full bulletin
From Transmission Input Shaft Seal Or Output Shaft Seal - US10 And Newer Emissions, Common Model Years 2010 And Newer
CBR: 11L, 13L, And 16L Engine Oil Analysis Specifications - US10 And Newer Emissions
CBR: Cummins CU12 CNG only, P2560 Low Engine Coolant.
CBR - Volvo Chassis - Models VNL, VNX Only Equipped With A USD16 Volvo Engine - AHI Harness Failure Related Fault Codes...
Read full bulletin
P249F00, P20DD13, P113413
CBR - 11 Liter Engines - Fuel In Oil.
CBR: 11L Engine - Air Conditioner (A/C) Line Damaged At Bracket - Model Year 2007 to Present.
Barksdale Leveling Valve, Leak Test
CBR: Volvo DEF Dosing Valve Diagnostic Trouble Codes (DTC) P202D00, P208E00, P103B00 - US10+OBD13 And Newer Emissions
CBR: Programming Failure - Chassis With Cummins Engine And An Allison Transmission
CBR: Model Year 2017 to Current - Fuel Filter Change ( Primary And Secondary ) For The EM - USA17 Emission Engines
CBR: 11L Engines, Non-Common Rail - Air Compressor Coolant Pipe, Parts Substitution - US14+OBD13 To US14+OBD16
Model Year 2017, 2018 - Fuel Filter Change ( Primary And Secondary ) For The EM - USA17 Emission Engines
TBS- Jumper Harness, Wiper Motor, Replacement
Engine Control Module (EMS) Software (MSW) Information October 2022; Improvement List (Change Log) - US21+OBD22 (13L...
Read full bulletin
VGT, TC) And US17+OBD22 (11L) Emissions
Engine Control Module (EMS) Software (MSW) Information August 2022; Improvement List (Change Log) - US21+OBD22 (13L...
Read full bulletin
VGT, TC) And US17+OBD22 (11L) Emissions
Programming Failure - Chassis With Cummins Engine And An Allison Transmission
11L, 13L, And 16L Engine Oil Analysis Specifications - US10 And Newer Emissions
Model Year 2017, 2018 - US17 Emission Engines - The ( Donaldson ) Fuel Filter - Part Number P550529 - " Cannot " Be Used
Volvo Chassis - Technical Service Bulletin V-728-005, Leveling Valve, Leak Test, Air Leaks From The Leveling Valve After...
Read full bulletin
The Vehicle Is Parked (Shut Off)
Variable Geometry Turbocharger ( VGT ) Function Test ( 2551-08-03-02 ), OBD13 Model Year ( MY ) 2014 And Newer
Model Year 2017, 2018 - US17 GHG Engines - One Box System - How To Inspect The Diesel Oxidation Catalyst ( DOC )
Volvo Chassis - Coolant Leak Test - Dye Information
Chassis Equipped With An AMT-F (I-Shift, mDrive) - Idle Drive Function Activates When Vehicle Is Reversing/Backing Up At...
Read full bulletin
Low Speed; Information And Repair - Build Date Beginning Of Production 2017 To February 2018
Model Year 2017, 2018 - Fuel Filter Change ( Primary And Secondary ) For The EM - USA17 Emission Engines
Volvo Chassis - Approved Engine Oil For Volvo Engines, Factory Fill Oil Information - US07 And Newer Emissions, Model...
Read full bulletin
Year 2008 And Newer
Cylinder Head Reuse And Replacement Guidelines - Inspection And Information - US04 And Newer Emissions, Commonly 2007...
Read full bulletin
And Newer Model Years
Volvo Chassis - Equipped With A Cummins Engine - Cummins Fuel Pump Timing Correction to Reduce Engine Noise; Drone Noise...
Read full bulletin
at 1500 RPM and Increases With Engine Load - US10 And Newer Emissions, Common Model Year 2014 And Newer
Revision: Valve, Common Rail, Removal
Valve, Common Rail, Removal
Volvo Chassis - Discharge Recirculation Valve (DRV) - FSB 258-029 , Engine Turbocharger Compressor Bypass Valve...
Read full bulletin
Deletion Kit , Installation
Model Year ( MY ) 2017, 2018 - US17 GHG Emissions Engine - Common Rail Fuel Injector - Electrical Test
Leveling Valve, Leak Test
Volvo Chassis - Equipped With An Automated Manual Transmission Model D or F ( I-Shift, AMT-D, AMT-F ) - Transmission Oil...
Read full bulletin
Leakage From Transmission Input Shaft Seal Or Output Shaft Seal - US10 And Newer Emissions, Common Model Years 2010 And Newer
Volvo Trucks has received reports from the aftermarket regarding oil leaks at the CCV housing inlet tube and at the...
Read full bulletin
split line between the upper and the lower housings on chassis builds between January 1, 2014 and January 26, 2016 with D11, D13, and D16 engines.
In the event that an EGR temperature sensor replacement is required on a VOLVO D13H engine, a new routing configuration...
Read full bulletin
is required.
Software updates with enhancements are available for the Engine Control Module (ECM) for VOLVO D11J, D13J and D16J...
Read full bulletin
engines with US2016 emission level on vehicles built from January 4, 2016 to May 6, 2016.
Turbocharger Outlet Pipe
Engine Coolant Thermostat Software Update
Engine Control Module (ECM) Software Update
Exhaust Gas Recirculation (EGR) Valve Oil Supply Line, updated part
VOLVO VN, VHD, VAH, and VT trucks built from 2009 to 2017 and equipped with 11, 13, and 16 liter engines (EM-USA10,...
Read full bulletin
EM-USA14, and EM-USA17), will require a new torque specification for the Unit Injector Yoke Hold-Down Bolt.
On some VOLVO VN, VHD, and VAH trucks built from January 2014 to July 2017 and equipped with the name plate on a two...
Read full bulletin
piece valve cover, the name plate may come loose.
SCR Harness Connector, Replacement: The front chassis harness on some Volvo VNL trucks equipped with a Cummins engine...
Read full bulletin
and aftertreatment system built between 02/04/2013 and 12/31/2016 may have paint inside the SCR connector.
VOLVO VN, VHD, VAH, and VT trucks built from 2009 to 2017 and equipped with 11, 13, and 16 liter engines (EM-USA10,...
Read full bulletin
EM-USA14, and EM-USA17), will require a new torque specification for the Unit Injector Yoke Hold-Down Bolt. Effective immediately, the torque value in step 3 has changed to 25 +5/-0 Nm (18 +4/-0 ft-lb).
Certain VOLVO VN, VHD, and VAH trucks built from 05/16/2015 to 09/09/2016 and equipped with HDE13 engines have been...
Read full bulletin
identified as high risk for injector sleeve combustion gas leakage due to excessive graphite paste application during assembly, possibly resulting in loss clamp load.
VOLVO VN, VHD, VAH, and VT trucks built from 2009 to 2017 and equipped with 11, 13, and 16 liter engines (EM-USA10,...
Read full bulletin
EM-USA14, and EM-USA17), will require a new torque specification for the Unit Injector Yoke Hold-Down Bolt. Effective immediately, the torque value in step 4 has changed to 25 +5/-0 Nm (18 +4/-0 ft-lb).
The engine harness on VOLVO D11 US2015 engines built between March 1, 2015 and September 2, 2016 may be making contact...
Read full bulletin
with the air compressor head and rubbing through.
Software updates with enhancements are available for the Engine Control Module (ECM) for VOLVO D11J, D13J and D16J...
Read full bulletin
engines with US2016 emission level on vehicles built from January 4, 2016 to May 6, 2016.
VOLVO Trucks has received reports from the aftermarket regarding oil leaks at the CCV housing inlet tube and at the...
Read full bulletin
split line between the upper and lower housings on chassis builds between January 1, 2014 and January 26, 2016 with D11 engines. It has been determined that the O-ring installed on the inlet tube is the source of the leak and oil may leak down the back of the housing giving the impression that the housing split line is also leaking.
Certain VOLVO VN trucks built between 10/03/2016 and 11/07/2016 may experience a coolant leakage issue with the...
Read full bulletin
Aftertreatment Diesel Exhaust Fluid (DEF) Dosing Valve.
In some instances the exhaust rocker piston cap screw may become loose and back out causing loss of engine compression,...
Read full bulletin
or a mechanical injector Diagnostic Trouble Code (DTC).
SOFTWARE UPDATES WITH ENHANCEMENTS ARE AVAILABLE FOR THE ENGINE CONTROL MODULE (ECM) FOR VOLVO D11J, D13J AND D16J...
Read full bulletin
ENGINES WITH US2016 EMISSION LEVEL ON VEHICLES BUILT FROM JANUARY 4, 2016 TO MAY 6, 2016.
VOLVO TRUCKS HAS RECEIVED REPORTS FROM THE AFTERMARKET REGARDING OIL LEAKS AT THE CCV HOUSING INLET TUBE AND AT THE...
Read full bulletin
SPLIT LINE BETWEEN THE UPPER AND LOWER HOUSINGS ON CHASSIS BUILDS BETWEEN JANUARY 1, 2014 AND JANUARY 26, 2016 WITH D11 ENGINES. IT HAS BEEN DETERMINED THAT THE O-RING INSTALLED ON THE INLET TUBE IS THE SOURCE OF THE LEAK AND OIL MAY LEAK DOWN THE BACK OF THE HOUSING GIVING THE IMPRESSION THAT THE HOUSING SPLIT LINE IS ALSO LEAKING.
Other
60 bulletinsCBR - Frame or Cab Lean
CBR - A significant GPS reporting issue is affecting fleet operations, with trucks maintaining back-office communication...
Read full bulletin
but failing to transmit GPS location data.
Volvo Chassis - Frame Or Cab Lean
CBR - Volvo Chassis - No-Crank Issue After Programming
CBR - Frame Or Cab Lean
CBR - SCR Replacement
CBR - SCR replacement
CBR: Telematics Gateway (TGW) Connect Ability Issues
EM - SCR Replacement 13LVGT
CBR - Volvo Chassis - Equipped With Volvo Active Driver Assist ( VADA ), With Or Without Lane Departure warning ( LDWS )...
Read full bulletin
.
CBR - Telematics Gateway (TGW) Connect Ability Issues.
CBR: TGW Will Not Connect After SIM Card Replacement
CBR: Volvo Chassis - Nonfunctioning 12vAccessory Power Supply - Model Year(MY) 2017 To Present
CBR: Volvo Chassis - Nonfunctioning 12v Accessory Power Supply - Model Year (MY) 2017 To Present
CBR - Volvo Chassis - Model VNX - One piece Propeller Shaft ( Drive Shaft ) Contacts Cross Member
CBR: Diagnostic Trouble Code (DTC) P215A-64, Fault Code SPN 84 FMI 19
Expendable Items Parts List.
Part information for AMT input shaft repair kits and the shim kit that is required for repair.
AMT Control Housing Bench Testing - False Failures
The Diagnostic Process
Volvo Chassis Ghost Codes Due To Poor Grounding
(Back Office Only) Volvo Chassis Loss Of Cruise Control After Disabling Electronic Stability Program (ESP)
VIDA QR Scanner Mobile App
Volvo Monthly Bulletin Release Letter - Feb 2022
Volvo Chassis US13 And Up Pre-trip Assistant Enable
Volvo Chassis - Driveline (Driveshaft, Propeller Shaft) Ride Height And Angle, Measurement And Calculation; Pinion Angle...
Read full bulletin
Measurement - Model Year 1996 And Newer
Diagnostic Trouble Code (DTC) U3017 - OBD2015/16 Model Year ( MY ) 2016/2017 Vehicles
Dynamometer Testing On 2016-17 Volvo Chassis
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P05EB, Diagnostic And Repair Information - US14+OBD15 And US14+OBD16...
Read full bulletin
(Commonly Model Years 2016 And 2017)
Volvo Chassis - Performance Bonus OBD13 And Newer
Volvo Chassis - Model VN - Loss Of Cab Heat, Bunk Heat Working - Model Year 2016 And Newer
Volvo Chassis - Model VN - Loss Of Cab Heat, Bunk Heat Working - Model Year 2016 And Newer
Data Logger Installations - Red Card Activity
Volvo Chassis - Volvo Hill Start Assist System Information
Volvo Chassis - Fusion 2 Adaptive Cruise Function Document
EC0020C Analysis & SCR Hardware Replacement - 2 Box
Volvo Chassis - Volvo Active Driver Assist (VADA)
EC0022B SCR,Label Only-1 Box
EC0022A SCR Hardware Replacement,11L-1 Box
EC0020A SCR Hardware Replacement-2 Box
Diagnostic Trouble Code (DTC) P215A-64, Fault Code SPN 84 FMI 19; Speedometer Drop-Out, Speedometer Inoperative
For certain Volvo VN trucks built between 09/21/2015 and 09/07/2018, a new improved torque procedure has been introduced...
Read full bulletin
to maintain and distribute torque properly on the hardware attaching the Link auxiliary axle to the frame mounted brackets. Follow the repair instructions outlined in this document for retorquing the indicated nuts or bolts.
Plugs, Pressure Protection Manifold
On some trucks with the Telematics Gateway (TGW) system, the TGW control unit may not correctly communicate with the...
Read full bulletin
vehicle systems after restarting.
Hill Start Assist Solenoid, Replacement
Oil Filter Housing
Aftertreatment DEF Tank Vent Filter
Hill Start Assist Solenoid, Replacement
AMT High Range Cone Replacement
Oil Filter Housing
High Soot Output
Timing Plate Flange Screw
Hill Start Assist Solenoid, Replacement
Timing Plate Leak Repair
Range Synchronizer, Repair
Hill Start Assist Solenoid, Replacement
OBD2015/16 ( MY - 2016/2017 ) Trucks are logging U3017 Fault Code ( DTC )
VOLVO Trucks has determined that some VN truck models may experience cracked or broken back of cab fairing brackets on...
Read full bulletin
vehicles manufactured from 03/12/2012 to 07/12/2016.
CCV Housing Inlet Tube, Replacement
VOLVO TRUCKS HAS DETERMINED THAT SOME VN TRUCK MODELS MAY EXPERIENCE CRACKED OR BROKEN BACK OF CAB FAIRING BRACKETS ON...
Read full bulletin
VEHICLES MANUFACTURED FROM 03/12/2012 TO 07/12/2016.
Electrical
54 bulletinsOverheating has been observed at the alternator power cable and ground cable connection, resulting in melted insulation around the terminal area.
Read full bulletin
The alternator power cable connection should maintain a stable electrical contact without overheating or insulation damage during normal vehicle operation. The alternator power cable shows signs of overheating and melted insulation at the connection point, which may affect electrical conductivity and charging system performance.
TSB - Aftertreatment Diesel Exhaust Fluid (DEF) Tank, Level Sensor Replacement.
Volvo Trucks has identified that some VN model vehicles equipped with auxiliary power unit batteries may experience...
Read full bulletin
insufficient battery system charging. This could lead to early battery failure and improper functioning of the auxiliary power systems. Follow the instructions in the attached document to upgrade the charging system.
CBR - Volvo Chassis - Diagnostic Trouble Code (DTC) P009B13 Fuel Pressure Relief Control Circuit Open; Possible Derate...
Read full bulletin
- US17+OBD16 And US17+OBD18 Emissions
CBR - US17 GHG Common Rail Fuel System Component Electrical Faults - Model Year 2017 To 2024
CBR: Diagnostic Trouble Code (DTC) U010187- Lost Communication With TECU
Owner Notification Letter, Extended Warranty Coverage U113.
Read full bulletin
The Pre-SCR NOx Sensor is the component provided coverage under this warranty extension.
Owner Notification Letter, Extended Warranty Coverage U112.
Read full bulletin
The Pre-SCR NOx Sensor is the component provided coverage under this warranty extension.
Owner Notification Letter, Extended Warranty Coverage U111.
Read full bulletin
The Fuel Control Module is the component provided coverage under this warranty extension.
Aftertreatment Diesel Exhaust Fluid (DEF) Tank, Level Sensor, Replacement
Aftertreatment Diesel Exhaust Fluid (DEF) Tank, Level Sensor, Replacement
CBR: Model Year 2017, 2018 - US17GHG Common Rail Fuel System Component Electrical Faults
CBR - Volvo NOx Sensor Troubleshooting Guide - US10+OBD13 And Newer Emissions
CBR - Volvo NOx Sensor Troubleshooting Guide - US10+OBD13 And Newer Emissions
CBR: Volvo NOx Sensor Troubleshooting Guide - US10+OBD13 And Newer Emissions.
Read full bulletin
The primary failure mode the NOx Sensors is internal failure, which will generate a sensor specific fault code.
Diagnostic Trouble Code ( DTC ) P10AE Logged In TECU With ACTIVE Or INACTIVE Status, Fault Code Cannot Be Cleared;...
Read full bulletin
Possibly Accompanied By P105817 And P105818 - US10+OBD13 And Newer Emissions (16-Pin Diagnostic Connector), Commonly Model Year 2014
DEF Level (UQLS) Sensor Troubleshooting Guide - US17+OBD16 Emissions and Newer
NOx Sensor Troubleshooting Guide - US10+OBD13 And Newer Emissions
(Back Office) - Cruise Control Inoperative After Updating Software VECU5 Without ESP Package (UESP)
Particulate Matter (PM) Sensor Troubleshooting Guide - US14+OBD16 And Newer Emissions
Temperature Sensor Troubleshooting Guide - US10+OBD13 And Newer
Unable To Retrieve "On Request" Messages For PeopleNet Or Omnitracs Modules Installed On The DL5 Data Link; Third Party...
Read full bulletin
Electronic Log Device Not Reporting Certain Data
Particulate Matter (PM) Sensor Troubleshooting Guide - US14+OBD16 And Newer Emissions
DEF Level (UQLS) Sensor Troubleshooting Guide - US17+OBD16 Emissions and Newer
Particulate Matter (PM) Sensor Troubleshooting Guide - US14+OBD16 And Newer Emissions
Shipping and Handling of Volvo Lithium-ion 48V Mild Hybrid Battery to Global Battery Solutions (GBS)
Volvo Chassis - Technical Service Bulletin V-284 - 069, Exhaust Particulate Sensor, Repair
Model Year 2017, 2018 - US17 GHG Common Rail Fuel System Component Electrical Faults
Volvo Chassis - FSB 284 - 069, Exhaust Particulate Sensor, Repair ( 2017 Vehicles )
Front Accessory Drive noise, Alternator Belt Wear, Alternator Belt Tensioner Failure - MY 2017 And Newer
Volvo Chassis - Particulate Matter (PM) Sensor Diagnostic Trouble Codes (DTC) Illuminating The Malfunction Indicator...
Read full bulletin
Lamp (MIL); Tech Tip TT-014-2016 - US14+OBD16, US17+OBD16 And Newer Emissions, Common Model Year 2017 And Newer - To Be Used For EVER
3rd Party NOx Sensor Identification
DTC P0194-00 and/or P016E-00, Fuel Rail Pressure Sensor (RPS) and wiring harness, Replacement
SCR Fittings, One Box, Replacement PM, NOx and Temperature Sensor Fittings
Remote Diagnostics - ACM and ECM Software Update
Particulate Matter (PM) Sensor Diagnostic Trouble Codes (DTC) Illuminating The Malfunction Indicator Lamp (MIL) -...
Read full bulletin
US14+OBD16, US17+OBD16 And Newer Emissions, Model Year 2017 And Newer - To Be Used For EVERY Visit
Particulate Matter (PM) Sensor Diagnostic Trouble Codes (DTC) Illuminating The Malfunction Indicator Lamp (MIL) -...
Read full bulletin
US14+OBD16, US17+OBD16 And Newer Emissions, Model Year 2017 And Newer - To Be Used For EVERY Visit
Volvo Chassis - Rain Sensor Bracket Removal And Installation Procedure when Using An Aftermarket Windshield
Diagnostic Trouble Code ( DTC ) P10AE Logged In TECU With ACTIVE Or INACTIVE Status, Fault Code Cannot Be Cleared;...
Read full bulletin
Possibly Accompanied By P105817 And P105818 - US10+OBD13 And Newer Emissions (16-Pin Diagnostic Connector), Commonly Model Year 2014 And Newer
Volvo Chassis - Particulate Matter (PM) Sensor Diagnostic Trouble Codes (DTC) Illuminating The Malfunction Indicator...
Read full bulletin
Lamp (MIL); Tech Tip TT-014-2016 - US14+OBD16, US17+OBD16 And Newer Emissions, Common Model Year 2017 And Newer - To Be Used For EVERY Visit
Volvo Chassis - Particulate Matter (PM) Sensor Diagnostic Trouble Codes (DTC) Illuminating The Malfunction Indicator...
Read full bulletin
Lamp (MIL); Tech Tip TT-014-2016 - US14+OBD16, US17+OBD16 And Newer Emissions, Common Model Year 2017 And Newer - To Be Used For EVERY Visit
Diagnostic Trouble Codes (DTC) P0194-00 - Fuel Rail Pressure Sensor, Circuit Erratic, Intermittent And/Or P016E-00...
Read full bulletin
Closed Loop Fuel Pressure At Control Limit, Pressure Too High - US17+OBD16 (Common Rail Fuel System) Emissions And Newer; Model Year 2017 And Newer
ECM and ACM, Software Updates
ECM and ACM, Reprogramming, OBD2016
Selective Catalytic Reduction ( SCR ) Efficiency And NOx Sensor Codes P225C, P225E, P221A, P2201, P103C, P20EE, And...
Read full bulletin
P207F : NOx Sensor Diagnostic Information TO BE USED BEFORE SENSOR REPLACEMENT - OBD13 And Newer Emissions (Commonly Model Year 2014 And Newer)
ECM and ACM, Reprogramming, OBD2016
DEF Sensor Assembly Routing
Exhaust Gas Recirculation (EGR) Differential Pressure Sensor
Seat Harness Routing (Swivel) wires pulling away from clipping points
Seat Harness Routing (Non-Swivel) wires pulling away from clipping points
Fuel Management Module, Replacement, incorrect calibration
Battery Cable, Routing
Oil Level Sensor Harness Wire Splice
Front Radar, Reprogramming, Certain VOLVO Trucks built from 11/11/2013 through 07/01/2016, and equipped with Front Radar...
Read full bulletin
(collision avoidance system with adaptive cruise control), may display an ACC Sensor Fault (warning / pop-up) at key OFF. Additionally, this fault is linked to multiple counts of inactive fault code MID140 SID 216. This is due to a front radar software issue.
Fuel System
51 bulletinsVehicles Equipped With a Common Rail Fuel System - Aftermarket Secondary Fuel Filters, Important Information On Approved...
Read full bulletin
Filters - US17+OBD16 toUS21+OBD23
Emission Recall: EC0033-M0312 SCR Recall
Emissions - SCR Replacement 13LVGT
Emissions Campaign: Volvo has determined that certain 2014 -2018 model year VN, VHD, and VAH Vehicles require a...
Read full bulletin
replacement Diesel Particulate Filter (DPF) along with updated software.
CBR: Vehicle Speed Factor (K-Factor) Programming - Speed Factor Value Incorrect When Calculated In Premium Tech Tool...
Read full bulletin
(PTT); Speedometer Reading Incorrectly Following A Change To Vehicle Speed Factor - US17+OBD16 And Newer Emissions, Common Model Year 2018.
CBR - Volvo Selective Catalytic Reduction (SCR) Muffler Troubleshooting Guide - US10+OBD13 And Newer Emissions
Volvo DEF Pump Troubleshooting Guide - US10+OBD13 And Newer Emissions
Diagnostic Trouble Codes (DTC) P24F600 Or P24F700 - US14+OBD15 Emissions And Newer, Model Year 2016 And Newer
Diagnostic Trouble Codes (DTC) P24F600 Or P24F700 - US14+OBD15 Emissions And Newer, Model Year 2016 And Newer
Diagnostic Trouble Code P200200 - Diagnostic Information; US14+OBD16 And Newer Emissions
Diagnostic Trouble Code P200200 - Diagnostic Information; US14+OBD16 And Newer Emissions
inquiries received concerning an open connection port present on the exhaust pipe after the One Box System DPF/SCR
Fuel Filters ( Primary and Secondary ) ( Backwards Compatible ) and Fuel Filter Housings
Diesel Particulate Filter (DPF) And Diesel Oxidation Catalyst (DOC) Pin Testing Procedure - US07 And Newer Emissions,...
Read full bulletin
Model Year 2008 And Newer.
Aftertreatment Hydrocarbon Injector (AHI) Troubleshooting Guide - US10+OBD13 And Newer Emissions
DEF Pump Troubleshooting Guide - US10+OBD13 And Newer Emissions
Electronic Stability Program (ESP), Electronic Stability Control (ESC): Changes And Removal Information; Permissible PAR...
Read full bulletin
File Changes - US07 And Newer Emissions, Model Year 2008 And Newer
Back Office - Diagnostic / Troubleshooting Procedures For Exhaust Gas Recirculation (EGR) System Components; Covers Most...
Read full bulletin
EGR System Diagnostic Trouble Codes (DTC), See List In Solution - US10, US10+OBD13, US14+OBD*, US17+OBD* With A Variable Geometry
Fuel Level Gauge Reading Incorrect In The Instrument Cluster
DEF Pump Troubleshooting Guide - US10+OBD13 And Newer Emissions
Selective Catalytic Reduction (SCR) Muffler Troubleshooting Guide - US10+OBD13 And Newer Emissions
Aftertreatment Hydrocarbon Injector (AHI) Troubleshooting Guide - US10+OBD13 And Newer Emissions
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P226C Intermittently Lighting The Malfunction Indicator Lamp ( MIL ) -...
Read full bulletin
US14+OBD13, US14+OBD15 And US14+OBD16 Emissions, Common Model Years 2015 to 2017
Volvo Chassis - Without Tire Pressure Monitoring System ( TPMS ) - Intermittent Brief Loss Of Throttle, Possible Data...
Read full bulletin
Link Codes - Technical Service Bulletin V-776-002 - US14+OBD13 Through US14+OBD16 Emissions, Commonly Model Years 2015 To 2017
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P02FA US17+OBD16 And US17+OBD18 (GHG17) Emissions
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P249C Intermittently Lighting The Malfunction Indicator Lamp ( MIL ) -...
Read full bulletin
US14+OBD15 And US14+OBD16 (Non-Common Rail Fuel System) Emissions, Common Model Years 2016 and 2017
Volvo Chassis - Diagnostic Trouble Codes ( DTC's ) P24A0 And P249F Lighting The Malfunction Indicator Lamp ( MIL ) -...
Read full bulletin
US14+OBD15, US14+OBD16 (Common Model Years 2016 And 2017), US17+OBD16 And Newer ( Common Rail Fuel System, Model Year 2018)
Volvo Chassis - Diagnostic Trouble Codes ( DTC ) P10FE And P24A4 Lighting The Malfunction Indicator Light ( MIL ) -...
Read full bulletin
US14+OBD13, US14+OBD15 And US14+OBD16 Emissions, Common Model Years 2015 To 2017
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P0507 Lighting The Malfunction Indicator Lamp ( MIL ) - US14+OBD13,...
Read full bulletin
US14+OBD15, US14+OBD16 Emissions (Non-Common Rail Fuel System), Common Model Years 2015 To 2017
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P0422 Lighting The Malfunction Indicator Light ( MIL ) - US14+OBD15 And...
Read full bulletin
US14+OBD16 Emissions, Common Model Years 2016 And 2017
Diagnostic Trouble Codes ( DTC ) P20EE, P207F And P103C, Diagnostic Procedure - REPLACES GUIDED DIAGNOSTICS IN PREMIUM...
Read full bulletin
TECH TOOL ( PTT ) - US10+OBD2013 to US14+OBD2016 (Non-Common Rail) Emissions, Commonly Model Years 2014 To 2017
Diagnostic Trouble Code ( DTC ) P26E8 Intermittently Lighting The Malfunction Indicator Lamp ( MIL ); Possible Derate...
Read full bulletin
Warning - US10+OBD13 And Newer Emissions, Model Year 2014 And Newer
Diagnostic Trouble Codes (DTC) P24F600 Or P24F700 - US14+OBD15 Emissions And Newer, Model Year 2016 And Newer
Volvo Chassis - Diagnostic Trouble Codes ( DTC ) P208E And P103B Logging With Possible Derate( SCR Inducement ) -...
Read full bulletin
US14+OBD13, US14+OBD15, US14+OBD16 And US17+OBD16 And NewerEmissions, Common Year Models 2015 And Newer
Grounding Bus Bar (Cloverleaf, Grounding Star, Four Point Ground Stud) On Frame Rail; Inspection To Be Performed For...
Read full bulletin
Power And Ground, Data Link DTCs - US10 And Newer Emissions, Model Year 2011 And Newer
Premium Tech Tool (PTT) Error Code 43: Service Regeneration Fails To Start; Service Regen Does Not Complete With Error...
Read full bulletin
43 Displayed - US10+OBD13 And Newer Emissions, Common Model Year 2014 And Newer
Diesel Fuel Information - Acceptable Biodiesel, Fuel Blend For Summer And Winter - US07 And Newer Emissions, Model Year...
Read full bulletin
2008 And Newer
Emissions Recall EC0022 Expanded
FSB 233-007, Fuel Filter Housing, Replacement; Extra Port On Fuel Filter Housing When Replacing With New Part - Vehicles...
Read full bulletin
Manufactured Between 14 November 2016 And 31 December 2019
Fuel Filter Housing, Replacement
Correct Aftermarket Installation Of Permanent Electronic Log Devices ( ELD )( Qualcomm, PeopleNet, Omnitracs, GPS,...
Read full bulletin
Location Tracker, Etc.) RP1226 connection On The Data Link; Installation Instructions And Information For Third Party ( Aftermarket ) Devices Connected To The Data Link - US17+OBD16 And Newer Emissions, Models Built up to Week 37 (9/13) 2019.
Diagnostic Trouble Codes ( DTC ) P20EE, P207F And P103C, Diagnostic Procedure - REPLACES GUIDED DIAGNOSTICS IN PREMIUM...
Read full bulletin
TECH TOOL ( PTT ) - US10+OBD2013 to US14+OBD2016 (Non-Common Rail) Emissions, Commonly Model Years 2014 To 2017
Diagnostic Trouble Codes ( DTC ) P2080, P2084, P242B Lighting The Malfunction Indicator Lamp ( MIL ) - US14+OBD16,...
Read full bulletin
US17+OBD16, And US17+OBD18 Emissions, Model Years 2017 To 2019
Expired - Volvo Chassis - Diagnostic Trouble Code ( DTC ) P026C Lighting The Malfunction Indicator Light ( MIL ) -...
Read full bulletin
US14+OBD13, US14+OBD15 And US14+OBD16 - Commonly Model Years 2015 To 2017 (Non-Common Rail Fuel System) Chassis
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P0422 Lighting The Malfunction Indicator Light ( MIL ) - US14+OBD15 And...
Read full bulletin
US14+OBD16 Emissions, Commonly Model Years 2016 And 2017
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P026C Lighting The Malfunction Indicator Light ( MIL ) - US14+OBD13,...
Read full bulletin
US14+OBD15 And US14+OBD16 - Commonly Model Years 2015 To 2017 (Non-Common Rail Fuel System) Chassis
Diagnostic Trouble Code ( DTC ) P0422 Lighting The Malfunction Indicator Light ( MIL ) - US17 (GHG17), Common Rail Fuel...
Read full bulletin
System ONLY, Updated programming and diagnostic instructions
Coolant Hose, EGR Cooler, Replacement
Dual Fuel Tanks Ventilation Filter Kit
Single Fuel Tank Ventilation Filter Kit
EGR Mass Flow Rate Low, diagnostic trouble code
Transmission
26 bulletinsCBR - Volvo Chassis - I-Shift Transmission - Moisture / Contamination Found In The Transmission Electronic Control Unit...
Read full bulletin
(TECU ) Air Ports And Control Housing.
Fleet Campaign - Certain VN model trucks could experience excessive moisture build up within chassis mounted auxiliary...
Read full bulletin
air tank due to limited driver access to I-Shift air tank drain.
CBR - Driver Display Popup Error "Door Is Open.
Read full bulletin
Shift Transmission To Neutral." -Instrument Cluster Software Update
CBR: On Volvo chassis with an I-Shift and Mack chassis with an mDRIVE transmission, there have been reports of complete...
Read full bulletin
shift assemblies and TECUs being replaced due to technicians being unable to pinpoint the source of the air leak.
CBR - Automated Manual Transmission ( AMT ) Flywheel Pilot Bearing Wear On Input Shaft.
CBR: Automated Manual Transmission ( AMT ) - Transmission Electronic Control Unit ( TECU ) MID130 PSID 29 FMI 7 /...
Read full bulletin
P10AE81 Fault Codes Being Generated
CBR: Automated Manual Transmission (AMT) Transmission Kickdown Mode
CBR: Volvo - Transmission Will Not Shift Into 12TH Gear Under A Load.
CBR: Volvo Chassis - Timing Gear Plate Repair.
Read full bulletin
This solution provides supplementary information to be used when installing a Timing Gear Plate with Integrated Seal.
Timing Gear Plate Inspection
Volvo Chassis - ( AMT, I-Shift ) - Transmission Grinding When Downshifting ; Range Synchronizer (Synchro) Timing...
Read full bulletin
Procedure - US07 And Newer
Volvo Chassis - Equipped with An Automated Manual Transmission (AMT, iShift) - SNV 19-002 - AMT Oil Filter Housing...
Read full bulletin
Corrosion
Warranty Automated Manual Transmission ( AMT, I-Shift, mDrive ) Control Housing Assembly; Guidelines For Filing A Claim...
Read full bulletin
For Chassis Return Visit With Transmission Issues After A Repair Requiring Control Housing Removal And Reinstallation - US07 And Newer
Volvo I-Shift AMT Will Not Calibrate After Incorrect Flywheel Housing Is Installed
Volvo Chassis - Equipped With An I-Shift Automated Manual Transmission ( AMT ) - Flywheel Resurfacing And Reuse...
Read full bulletin
Guidelines
Automated Manual Transmission (AMT) (Spigot Bearing) Input Shaft Repair Kit And Shim Kit, Part Number Information,...
Read full bulletin
Reference Guide - US07 And Newer Emissions, Model Year 2008 And Newer
Automated Manual Transmission Gearbox Will Not Shift To High Range After Gearbox Repair; MID 130 PSID 24 FMI 1, P1072-92...
Read full bulletin
Unintentional Disengagement Of High Range - US07 And Newer Emissions, Model Year 2008 And Newer
Vehicles Equipped With An Automated Manual Transmission (AMT) - Input Shaft/Spigot Bearing Repair, Replacement,...
Read full bulletin
Inspection And Reuse Guidelines - US07 And Newer Emissions, Model Year 2008 And Newer
Automated Manual Transmission (AMT) Faults - Diagnostic Trouble Codes (DTC) P1052-18 Or MID 130 PID 33 FMI 5...
Read full bulletin
Intermittent Fault In Cold Weather - US07 And Newer Emissions, Model Year 2008 And Newer
Flywheel Resurfacing Guidelines, I-Shift
Transmission ECU Programming
This document is a Technical Journal: If vibration or jerk occur during drive in different speeds with small throttle...
Read full bulletin
angle and gears at constant speed, follow the advice under Service. This might be due to the tires. If the tires are from different brands, has different tyre wear or with different rolling circumference, DEM (Differential Electronic Module) interprets this as spare wheel is used on the vehicle and try to compensate to get RPM correct on all four wheels.
Twin Mass Flywheel Conversion, Transmission Removed
Transmission ECU Compatibility
Some Volvo trucks equipped with iShift transmissions built between January 15, 2007 and August 14, 2017 may have PTO...
Read full bulletin
solenoid bracket or transmission harness connector failures due to excessive vibration.
This repair requires the installation of a missing screw in the timing gear plate into the flywheel housing as the...
Read full bulletin
referenced in this installation procedure.
Brakes
11 bulletinsCBR - US17AbstractVolvo Chassis equipped with Volvo Active Driver Assist may display DTC / Fault code SPN 516103 FMI 19...
Read full bulletin
on Premium Tech Tool ( PTT ) or J-Pro, and code 167 in Bendix ACOM software.
CBR - Active "Set Park Brake" Message On Drivers Information Display (DID)
Service Campaign: For certain Volvo Trucks configurations an updated adaptive cruise software has been developed.
Read full bulletin
The new software will be delivered as an updated PAR file to the ABS Module and will help reduce heat load on steer axles brake assemblies during an adaptive cruise control braking event. Follow the instructions below to visually inspect the brake rotors on the steer axle for excessive heat damage and update the ABS software.
CBR: Volvo On-Highway Vehicles - Bendix ABS Fault SPN 807 FMI 13 Blink code 19-4.
Read full bulletin
The new Central Pressure Control (CPC) system has changed the way that the ABS chuff test is performed.
(Back Office Only) Volvo Chassis - Enable Parking Brake Alarm, Parameters - US17 And Newer ( INT-GEN2 )
DTC U012100 - Lost Communication With Anti-Lock Brake System (ABS) Control Module, No Additional Information
" Volvo Chassis - SNV 20-005 - HD Disc Brake Rotor Upgrade"
(Back Office Only) Volvo Chassis - VN Model - Front Brake Squeal - US14 And Newer
Volvo Chassis - Redundant Brake Switch Test - Code MID136 SID55 FMI2, or( DTC ) P1055
Volvo Chassis - VN Models Equipped With Bendix Brakes, Bendix S-Cam On Steer Axle - Excessive Brake Noise; Diagnosis And...
Read full bulletin
Repair Information; FSB 514-001, Brake S-Cam, Replacement - Model Years 2014 To 2018
Brake S-Cam, Replacement,Some VOLVO VN trucks built after 05/13/2013, equipped with Bendix Brake S-Cams on the steer...
Read full bulletin
axle may require replacement to reduce or eliminate brake noise during braking.
Body & Paint
10 bulletinsTSB - Due to cracking in the step area of the fairing, an updated support bracket has been introduced.
Read full bulletin
The new support bracket will provide the better structure behind the fairing, reducing the likelihood of cracking.
CBR: On certain VNL model Volvos built August 21 , 2017 through January 01,2021 and equipped with chassis fairing p/n...
Read full bulletin
84744212 or 84744213, the DEF fill door in the fairing may become loose or break.
Volvo Chassis - VNL - Skylight Seal Repair - Model Year 2017 And Newer
Volvo Chassis - Model VN, Hood Release Cable Interference
Volvo Chassis - Model VN - Water Intrusion In Back Of Cab, Back Wall Of Bunk Leaking
Volvo Chassis - Model VN - Hood Latch/Cable Sticking Or Binding
Service Door Rust Prevention
Floor Cracks Repair (Rear Panel)
Floor Cracks Repair (Front Panel)
Customer may intermittently experience the vehicle ORVM (outer rear view mirror) will not fold when locking/unlocking.
Lighting
10 bulletinsCBR - Troubleshooting cab lean should only begin after completing a vehicle preparation procedure to ensure all...
Read full bulletin
components are in place and settled.
CBR: On a Volvo Chassis - US16 - with the Bendix Lane Departure Warning System ( LDW )the alarm would not cancel once...
Read full bulletin
the turn signals were activated.
TSB-Charge Air Cooler t-clamp install.
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P0420 Illuminating The Malfunction Indicator Lamp (MIL)
Volvo Chassis - Bendix Lane Departure Warning System ( LDWS ) Audible Alarm Does Not Deactivate When The Turn Signal Is...
Read full bulletin
Switched On - US16; Model Year ( MY ) 2017
Volvo Chassis 2008 And Up LED Headlight Conversion Programming Procedure
Volvo VN Models - Overhead Light Loose, Detaching From Headliner
Volvo Chassis - Exterior Lights - Converting From Incandescent To LED Lamps; Hardware And Software Requirements And...
Read full bulletin
Programming Information - Model Year 2008 Through 2017
Some VOLVO VN model trucks built from 11/01/2011 to 10/03/2016, and equipped with the Meritor/WABCO Electronic...
Read full bulletin
Controlled Air Dryer (ECAD) may experience excessive moisture build up in the air tanks.
SOME VOLVO VN MODEL TRUCKS BUILT FROM 11/01/2011 TO 10/03/2016, AND EQUIPPED WITH THE MERITOR/WABCO ELECTRONIC...
Read full bulletin
CONTROLLED AIR DRYER (ECAD) MAY EXPERIENCE EXCESSIVE MOISTURE BUILD UP IN THE AIR TANKS.
Infotainment
9 bulletinsVolvo Chassis equipped with Volvo Active Driver Assist may display DTC / Fault code SPN 516103 FMI 19 on Premium Tech...
Read full bulletin
Tool (PTT) or J-Pro, and code 167 in Bendix ACOM software.
CBR: Volvo VHD & VN Models - Vehicle Wil Not Start, PTO Active Message Displayed In Cluster, PTO Light On When PTO...
Read full bulletin
Switch Is Turned Off
Infotainment System - Volume Drop During A Phone Call, Phone Connected Via Bluetooth
Vehicle Overspeed Warning Comes Active At A Lower Speed Than Expected; Vehicle Overspeed Warning In Driver Information...
Read full bulletin
Display (DID) - Model Year 2018 And Newer With New Style Instrument Cluster
Volvo Chassis - Enable The Fault Code, Diagnostic Trouble Code ( DTC ) Screen (Menu) In The Instrument Cluster ( IC,...
Read full bulletin
Dash ); Fault Code Screen (Menu) Missing From Driver Information Display (DID); Read Fault Codes (DTCs) In Cluster
Model Year 2017, 2018 - ** Tech Tip ** TT - 000 - 2017 GPS Inoperative Message In DID ( Driver Information Display ) -...
Read full bulletin
Telematics Gateway ( TGW )
On certain Volvo models built between November 10, 2014 and July 7, 2017, with Bluetooth radio and LDWS (Lane Departure...
Read full bulletin
Warning System); the audio for the Bluetooth phone call may be low and with poor quality.
On some Volvo Trucks built between August 19, 2014 and August 19, 2016 possible audible feedback may occur while using...
Read full bulletin
the AM/FM bands when the CB microphone is keyed. Keying the microphone could also cut the volume of the radio when using the AM/FM bands. This issue has been caused by a filtering problem inside the radio. To correct the issue a filter should be installed using the following procedure.
ON SOME VOLVO TRUCKS BUILT BETWEEN AUGUST 19, 2014 AND AUGUST 19, 2016 POSSIBLE AUDIBLE FEEDBACK MAY OCCUR WHILE USING...
Read full bulletin
THE AM/FM BANDS WHEN THE CB MICROPHONE IS KEYED. KEYING THE MICROPHONE COULD ALSO CUT THE VOLUME OF THE RADIO WHEN USING THE AM/FM BANDS. THIS ISSUE HAS BEEN CAUSED BY A FILTERING PROBLEM INSIDE THE RADIO. TO CORRECT THE ISSUE A FILTER SHOULD BE INSTALLED USING THE FOLLOWING PROCEDURE.
Suspension
7 bulletinsCBR - Z Spring Bracket Wear.
Read full bulletin
Volvo Chassis
Frame lean can be caused by several seemingly isolated possibilities.
Read full bulletin
The two most common are suspension and frame assembly issues.
CBR - Driveline Noise, Suspension Ride Height Too High, Suspension Will Not Exhaust - Chassis Built 2016w01 And Newer
CBR - Vehicles Equipped With Chalmers Suspension - Frame Bracket Hardware Loose or Interfering
Volvo Chassis US13 And Up Enable " Air Suspension Pressure Gauge " In The Cluster
Volvo Chassis - Stemco Hubcap Plug Will Not Stay In
Some VOLVO VN, VHD and VNX trucks built from 09/03/2012 to 07/17/2017, and equipped with the NEWAY ADZ rear suspension...
Read full bulletin
may exhibit cracks in the rear suspension front of bogie or bogie crossmember.
Pre-Delivery & Maintenance
5 bulletinsCBR - Accelerator Pedal: Inspection/Instructions
Service Literature Published and Released in May, 2023
Volvo Chassis - Drag Link Inspection And Replacement Criteria
Forward Looking Radar Shortage - Plug Inspection
EXPANDED SCOPE- Non-Compliance Recall Alert, EC0020 & EC0022 SCR System
Tires & Wheels
4 bulletinsCBR - Vehicles Equipped With A Lift Axle - Wheel Speed Fault Code SPN 793, SPN 794 Set When Axle Is Up
Flywheel Housing Thread Repair
Twin Mass Flywheel Conversion
Tire Pressure Monitoring System (TPMS) Connector, Remove
Software & Calibration
3 bulletinsEM - SCR Monitoring Software 13L VGT
Software Update, revise document
This document is a Technical Journal: TJ updated with chassis breakpoint and structure week end date.Customer may...
Read full bulletin
experience some road noise coming from the B-pillar belt adjuster area.
HVAC & Climate
2 bulletinsThis CBR solution addresses the issue of binding between the outer air filter housing and inner HVAC box due to...
Read full bulletin
misalignment during installation.
CBR - Volvo Chassis - HVAC Fresh Air Door Binding
Steering
2 bulletinsOne Piece Steering Shaft, Replacement recall
ONE PIECE STEERING SHAFT, REPLACEMENT RECALL
Hybrid & EV
1 bulletinRegeneration in PTO Mode