2009 Volvo VN TSBs
159 Technical Service Bulletins across 15 categories
Categories
Engine
35 bulletinsInactive Code P25AE00 Being Generated After A Hard Pull And A Momentary Drop In Engine Oil Pressure (Low Oil Pressure)...
Read full bulletin
(Possible Related Codes - SPN4811 , SPN 100 , PID 100)
CBR - 11 Liter Engines - Fuel In Oil.
CBR: 11L Engine - Air Conditioner (A/C) Line Damaged At Bracket - Model Year 2007 to Present.
Barksdale Leveling Valve, Leak Test
CBR: Programming Failure - Chassis With Cummins Engine And An Allison Transmission
Volvo Chassis - D12C, D12D, D11F, D13F, D16D, D16F Engines - Copper Injector Sleeves, Replacement Procedure And...
Read full bulletin
Information ( Flat Tip Injectors ) - US04 To US07 Emissions
Engine Control Module (EMS) Software (MSW) Information August 2022; Improvement List (Change Log) - US21+OBD22 (13L...
Read full bulletin
VGT, TC) And US17+OBD22 (11L) Emissions
Programming Failure - Chassis With Cummins Engine And An Allison Transmission
Volvo Chassis - Equipped With An I-Shift Automatic Manual Transmission ( AMT ) And D16 ( 16L ) Engine - Technical...
Read full bulletin
Service Bulletin V-216-001 Twin Mass Flywheel Conversion
Volvo Chassis - Approved Engine Oil For Volvo Engines, Factory Fill Oil Information - US07 And Newer Emissions, Model...
Read full bulletin
Year 2008 And Newer
Cylinder Head Reuse And Replacement Guidelines - Inspection And Information - US04 And Newer Emissions, Commonly 2007...
Read full bulletin
And Newer Model Years
On some VOLVO VHD, VN, VT, and VAH truck models built between 04/31/2008 and 11/30/2015, the solenoid valve for the Hill...
Read full bulletin
Start Assist feature is prone to internal contamination in harsh environments. The internal contamination of the solenoid valve is caused by the buildup of grime, salt, road debris and other solid contaminants. In some cases, the buildup of solid contaminants caused the solenoid valve to malfunction. A similar malfunction is possible if the solenoid valve is equipped with a vent fitting that freezes over. The malfunction causes the trailer brake circuit to maintain trailer brake pressure after a grade Hill Start Assist event. Replacement of the existing solenoid valve, elbow, and the addition of a new tube fitting and tube will ensure proper functionality of the Hill Start Assist feature.
Volvo Chassis - Discharge Recirculation Valve (DRV) - FSB 258-029 , Engine Turbocharger Compressor Bypass Valve...
Read full bulletin
Deletion Kit , Installation
In the event that an EGR temperature sensor replacement is required on a VOLVO D13H engine, a new routing configuration...
Read full bulletin
is required.
Turbocharger Outlet Pipe
Engine Coolant Thermostat Software Update
Engine Control Module (ECM) Software Update
Exhaust Gas Recirculation (EGR) Valve Oil Supply Line, updated part
In some instances the exhaust rocker piston cap screw may become loose and back out causing loss of engine compression,...
Read full bulletin
or a mechanical injector Diagnostic Trouble Code (DTC).
VOLVO TRUCK: DUE TO INTERNAL BUILD UP CONTAMINATION OF GRIME, SALT, ROAD DEBRIS, IN HARSH ENVIRONMENTS, CAUSES SOLENOID...
Read full bulletin
VALVE TO MALFUNCTION AND TRAILER BRAKE CIRCUIT TO MAINTAIN TRAILER BRAKE PRESSURE AFTER HILL START ASSIST EVENT. MODEL VHD, VN, VT, VAH. *PE
VOLVO: LOW OIL PRESSURE, ON CERTAIN VEHICLES, DURING LONG HARD PULL CONDITIONS, DIAGNOSTIC TROUBLE CODES (DTCS) PID 100...
Read full bulletin
FM1, SPN 100 FMI 1 OR P252400, CAN LOG ON, WITH OR WITHOUT ENGINE SHUT DOWN LAMP. MODEL VN, VT. NO YEARS LISTED. *PE
VOLVO: ON SOME TRUCKS, THERE IS AN OIL CONTAMINATION INTO THE ENGINE WIRE HARNESS BECAUSE OF A FAILURE OF THE OIL LEVEL SENSOR.
Read full bulletin
MODELS VAH, VHD, VN, VT. NO MODEL YEARS LISTED. *PE
VOLVO: INFORMATION REGARDING REPROGRAMMING OF ENGINE ECM WITH THE NEW SOFTWARE.
Read full bulletin
MODELS VN, VHD, VAH, D13H EPA2010. NO MODEL YEARS LISTED. *PE
VOLVO TRUCK: RELOCATING OF ENGINE VGT ACTUATOR CONNECTOR AND MOUNTING ARRANGEMENT WAS DEVELOPED TO ELIMINATE FRETTING...
Read full bulletin
OF CONNECTOR PINS IN ENGINE DIAGNOSTIC TROUBLE CODES (DTC) AND MISSING SIGNAL. *PE
VOLVO TRUCKS: MISSING SIGNAL FROM ENGINE VARIABLE GEOMETRY TURBOCHARGER ACTUATOR (ENGINE VGT ACTUATOR) WITH MECHANICAL...
Read full bulletin
TRANSMISSION, CAUSES FRETTING OF CONNECTOR PINS IN ENGINE VGT ACTUATOR CONNECTOR. NEW MOUNTING ARRANGEMENT AND RELOCATION OF ENGINE VGT ACTUATOR HAS BEEN DEVELOPED. *PE UPDATED 8/17/12. *PE
VOLVO: SEVERE FRETTING DAMAGE OF ENGINE VARIABLE GEOMETRY TURBOCHARGER (VGT) ACTUATOR HARNESS CAUSE SIGNAL TO BE...
Read full bulletin
UNRELIABLE TO ENGINE VGT ACTUATOR CONNECTOR PIN AND SOCKET CONTACTS WHICH SHOULD BE REPLACED. MODELS VN, VHD, VT, VAH, D11, D13, D16. MODEL YEAR 2008-2012. *PE UPDATED 9/17/12. *PE
VOLVO: TO PREVENT EROSION OF ENGINE FUEL INJECTOR TIPS, FUEL TANK VENTILATION FILTER WAS ADDED TO VENT LINES AND...
Read full bulletin
MOUNTED ON STANCHION EXHAUST BRACKET ON RIGHT SIDE OF TRUCK. MODELS VN, VHD, VT, VAH, D11, D13, D16, US07, US10. MODEL YEARS 2008-2012 *PE
VOLVO TRUCKS: CONNECTOR PIN, REPLACEMENT.
Read full bulletin
SEVERE FRETTING DAMAGE OF THE ENGINE VARIABLE GEOMETRY TURBOCHARGER ACTUATOR (ENGINE VGT ACTUATOR) HARNESS AND TURBINE SHAFT SPEED SENSOR (TSS) CONNECTOR MAY CAUSE AN UNRELIABLE SIGNAL TO THE ENGINE VGT ACTUATOR. *JS
VOLVO: VEHICLES WITH 11L, 13L, AND ISX ENGINES BUILT BETWEEN JULY 2007 AND DECEMBER 2011, BLOCK HEATER CABLES WITH...
Read full bulletin
THERMOSTAT CONTROLS HAVE BEEN FOUND TO BE NONFUNCTIONAL. *JS
VOLVO TRUCKS: SOME ENGINES LEAK OIL THROUGH THE GROMMET.
Read full bulletin
INFORMATION ON THE WIRING HARNESS, UNIT INJECTOR REPLACEMENT. *RM UPDATED 9/9/11. *PE
MACK TRUCKS: THERE IS REVISED MOUNTING HARDWARE FOR THE EXHAUST MANIFOLD AND TURBOCHARGER.
Read full bulletin
*RM
VOLVO: THERE IS AN OIL LEAK ON THE SIDE OF THE ENGINE TURBOCHARGER.
Read full bulletin
*RM
VOLVO TRUCK: ENGINE ECU AND ACM SOFTWARE UPDATES.
Read full bulletin
NEW SOFTWARE UPDATES WITH ENHANCEMENTS ARE AVAILABLE FOR THE ENGINE CONTROL MODULE (ECM) AND AFTERTREATMENT CONTROL MODULE (ACM). MODEL VN. NO MODEL YEARS LISTED. *PE
VOLVO TRUCK: ENGINE ECM AND ACM SOFTWARE UPDATES.
Read full bulletin
NEW SOFTWARE UPDATES WITH ENHANCEMENTS ARE AVAILABLE FOR THE ENGINE CONTROL MODULE (ECM) AND AFTERTREATMENT CONTROL MODULE (ACM). NEW UPDATES AND ENHANCEMENTS WILL ADDRESS TURBO VARNISHING DURING INCLEMENT WEATHER AND EXHAUST GAS RECIRCULATION (EGR) HIGH MASS FLOW ISSUES. NO MODEL YEARS LISTED. *PE
VOLVO TRUCK: TO REDUCE THE POTENTIAL FOR CAB WATER INTRUSION, A CAB COWL SEAL HAS BEEN RELEASED BY ENGINEERING.
Read full bulletin
THE SEAL PART NUMBER 8083305 IS POSITIONED ABOVE THE TOP EDGE OF THE COWL PANEL TO DIVERT WATER FLOW ONTO THE COWL PANEL RATHER THAN BETWEEN THE COWL PANEL AND CAB. NO MODEL YEARS LISTED. *PE
Other
26 bulletinsCBR - A significant GPS reporting issue is affecting fleet operations, with trucks maintaining back-office communication...
Read full bulletin
but failing to transmit GPS location data.
CBR: Diagnostic Trouble Code (DTC) P215A-64, Fault Code SPN 84 FMI 19
Part information for AMT input shaft repair kits and the shim kit that is required for repair.
AMT Control Housing Bench Testing - False Failures
Mack Chassis - Data Link Diagnostics - Diagnostic Trouble Codes ( DTC ) / Fault Codes From Multiple Components - Unable...
Read full bulletin
To Connect To Chassis, Programming Failure With Premium Tech Tool ( PTT ) Errors - Troubleshooting And Oscilloscope Instructions
The Diagnostic Process
Volvo Chassis Ghost Codes Due To Poor Grounding
VIDA QR Scanner Mobile App
Volvo Chassis - Driveline (Driveshaft, Propeller Shaft) Ride Height And Angle, Measurement And Calculation; Pinion Angle...
Read full bulletin
Measurement - Model Year 1996 And Newer
Volvo Chassis - Volvo Hill Start Assist System Information
Volvo Chassis - Fusion 2 Adaptive Cruise Function Document
Volvo Chassis - Volvo Active Driver Assist (VADA)
On some trucks with the Telematics Gateway (TGW) system, the TGW control unit may not correctly communicate with the...
Read full bulletin
vehicle systems after restarting.
Hill Start Assist Solenoid, Replacement
Oil Filter Housing
Aftertreatment DEF Tank Vent Filter
Hill Start Assist Solenoid, Replacement
AMT High Range Cone Replacement
Oil Filter Housing
High Soot Output
Timing Plate Flange Screw
Hill Start Assist Solenoid, Replacement
Timing Plate Leak Repair
Range Synchronizer, Repair
Hill Start Assist Solenoid, Replacement
VOLVO: THERE MAY BE A COOLANT LEVEL SIGNAL FAILURE.
Read full bulletin
*RM
Transmission
23 bulletinsCBR: On Volvo chassis with an I-Shift and Mack chassis with an mDRIVE transmission, there have been reports of complete...
Read full bulletin
shift assemblies and TECUs being replaced due to technicians being unable to pinpoint the source of the air leak.
CBR - Automated Manual Transmission ( AMT ) Flywheel Pilot Bearing Wear On Input Shaft.
CBR: Automated Manual Transmission ( AMT ) - Transmission Electronic Control Unit ( TECU ) MID130 PSID 29 FMI 7 /...
Read full bulletin
P10AE81 Fault Codes Being Generated
CBR: Automated Manual Transmission (AMT) Transmission Kickdown Mode
CBR: Volvo Chassis - Timing Gear Plate Repair.
Read full bulletin
This solution provides supplementary information to be used when installing a Timing Gear Plate with Integrated Seal.
Volvo Chassis - ( AMT, I-Shift ) - Transmission Grinding When Downshifting ; Range Synchronizer (Synchro) Timing...
Read full bulletin
Procedure - US07 And Newer
Volvo Chassis - Equipped with An Automated Manual Transmission (AMT, iShift) - SNV 19-002 - AMT Oil Filter Housing...
Read full bulletin
Corrosion
Warranty Automated Manual Transmission ( AMT, I-Shift, mDrive ) Control Housing Assembly; Guidelines For Filing A Claim...
Read full bulletin
For Chassis Return Visit With Transmission Issues After A Repair Requiring Control Housing Removal And Reinstallation - US07 And Newer
Volvo I-Shift AMT Will Not Calibrate After Incorrect Flywheel Housing Is Installed
Volvo Chassis - Diagnostic Trouble Codes ( DTC's ) - MID130 PID160 FMI1 Or FMI2 - For The I-Shift Transmission
Volvo Chassis - Equipped With An I-Shift Automated Manual Transmission ( AMT ) - Flywheel Resurfacing And Reuse...
Read full bulletin
Guidelines
Automated Manual Transmission (AMT) (Spigot Bearing) Input Shaft Repair Kit And Shim Kit, Part Number Information,...
Read full bulletin
Reference Guide - US07 And Newer Emissions, Model Year 2008 And Newer
Automated Manual Transmission Gearbox Will Not Shift To High Range After Gearbox Repair; MID 130 PSID 24 FMI 1, P1072-92...
Read full bulletin
Unintentional Disengagement Of High Range - US07 And Newer Emissions, Model Year 2008 And Newer
Flywheel Resurfacing Guidelines, I-Shift
Transmission ECU Programming
Twin Mass Flywheel Conversion, Transmission Removed
Transmission ECU Compatibility
Some Volvo trucks equipped with iShift transmissions built between January 15, 2007 and August 14, 2017 may have PTO...
Read full bulletin
solenoid bracket or transmission harness connector failures due to excessive vibration.
VOLVO TRUCK: PROCEDURAL INFORMATION REGARDING THE REPLACEMENT OF HIGH RANGE CONE IN THE SECTION OF THE AUTOMATED MANUAL TRANSMISSION (AMT).
Read full bulletin
MODEL VN, VHD, VAH, VT. *PE UPDATED 8/8/14. *PE
VOLVO TRUCKS: DURING OPERATION OF DRIVER SIDE SWIVEL SEAT AND I SHIFT TRANSMISSION, THE HARNESS RUBBING OR WIRES, ARE PULLED OUT OF CONNECTORS.
Read full bulletin
THIS CAUSES SEAT HARNESS DROPPING OR PULLING AWAY FROM CLIPPING POINTS. *PE
VOLVO: THERE ARE NEW CLUTCH BEARING LUBRICATION TUBES.
Read full bulletin
*RM
VOLVO TRUCKS: THE TRANSMISSION HAS AN INPUT SHAFT THAT WAS THREADED WRONG WHICH COULD CAUSE LEAKAGE IN THE AREA.
Read full bulletin
*RM
VOLVO TRUCK: I SHIFT TRANSMISSION WITH MIXED COMPONENTS.
Read full bulletin
INSTALLATION OF REPLACEMENT PARTS IN AN I SHIFT TRANSMISSION (VERSION-C) MAY RESULT IN DIAGNOSTIC TROUBLE CODES (DTCS) MID 130 PID 160 FMI1 OR FMI2. NO MODEL YEARS LISTED. *PE
Electrical
19 bulletinsOverheating has been observed at the alternator power cable and ground cable connection, resulting in melted insulation around the terminal area.
Read full bulletin
The alternator power cable connection should maintain a stable electrical contact without overheating or insulation damage during normal vehicle operation. The alternator power cable shows signs of overheating and melted insulation at the connection point, which may affect electrical conductivity and charging system performance.
DEF Level (UQLS) Sensor Troubleshooting Guide - US17+OBD16 Emissions and Newer
NOx Sensor Troubleshooting Guide - US10+OBD13 And Newer Emissions
(Back Office) - Cruise Control Inoperative After Updating Software VECU5 Without ESP Package (UESP)
Temperature Sensor Troubleshooting Guide - US10+OBD13 And Newer
Unable To Retrieve "On Request" Messages For PeopleNet Or Omnitracs Modules Installed On The DL5 Data Link; Third Party...
Read full bulletin
Electronic Log Device Not Reporting Certain Data
Particulate Matter (PM) Sensor Troubleshooting Guide - US14+OBD16 And Newer Emissions
DEF Level (UQLS) Sensor Troubleshooting Guide - US17+OBD16 Emissions and Newer
Shipping and Handling of Volvo Lithium-ion 48V Mild Hybrid Battery to Global Battery Solutions (GBS)
Volvo Chassis - Rain Sensor Bracket Removal And Installation Procedure when Using An Aftermarket Windshield
DEF Sensor Assembly Routing
Exhaust Gas Recirculation (EGR) Differential Pressure Sensor
Seat Harness Routing (Swivel) wires pulling away from clipping points
Seat Harness Routing (Non-Swivel) wires pulling away from clipping points
Fuel Management Module, Replacement, incorrect calibration
Battery Cable, Routing
Oil Level Sensor Harness Wire Splice
VOLVO: LIGHT CONTROL MODULE (LCM), REPROGRAMMING.
Read full bulletin
ON SOME VOLVO UNITS EQUIPPED WITH CLEAR LED CLEARANCE LIGHTS IN THE SUN VISOR, THE MAY EXHIBIT AN ACTIVE FAULT CODE MID 216 PSID 49 FMI 5. THIS FAULT INDICATES A TRAILER MARKER OPEN ISSUE WHICH IS INCORRECT FOR THE ISSUE PRESENT ON THE VEHICLE. *JS
VOLVO: THE FRONT CHASSIS HARNESS MAY HAVE BEEN ROUTED WITH THE COMPRESSOR AIR DISCHARGE LINE WHICH CAN LEAD TO CORROSION OF THE HARNESS.
Read full bulletin
*RM
Fuel System
17 bulletinsDiesel Particulate Filter (DPF) And Diesel Oxidation Catalyst (DOC) Pin Testing Procedure - US07 And Newer Emissions,...
Read full bulletin
Model Year 2008 And Newer.
DEF Pump Troubleshooting Guide - US10+OBD13 And Newer Emissions
Electronic Stability Program (ESP), Electronic Stability Control (ESC): Changes And Removal Information; Permissible PAR...
Read full bulletin
File Changes - US07 And Newer Emissions, Model Year 2008 And Newer
Fuel Level Gauge Reading Incorrect In The Instrument Cluster
Volvo Chassis - Fuel Level Sending Unit Specification Information
(Back Office Only) Volvo Chassis - Equipped With A Catalyzed Exhaust Aftertreatment System ( EATS ) - Regeneration (...
Read full bulletin
Regen ) Failure Diagnostic Process - US07 to US16 Emissions
(Back Office Only) Volvo Chassis - Equipped With A Catalyzed Exhaust Aftertreatment System ( EATS ) - Regeneration (...
Read full bulletin
Regen ) Failure Diagnostic Process - US07 to US16 Emissions
Diesel Fuel Information - Acceptable Biodiesel, Fuel Blend For Summer And Winter - US07 And Newer Emissions, Model Year...
Read full bulletin
2008 And Newer
Coolant Hose, EGR Cooler, Replacement
Dual Fuel Tanks Ventilation Filter Kit
Single Fuel Tank Ventilation Filter Kit
EGR Mass Flow Rate Low, diagnostic trouble code
VOLVO TRUCK: WHEN CAB LUGGAGE DOOR IS CLOSED, ACCESS TO FUEL FILLER NECK OF FUEL TANKS WITH D SHAPE MAY BE LIMITED.
Read full bulletin
CAB DOOR MUST BE OPEN TO REFUEL. *PE
VOLVO: ACCESS TO THE FUEL FILLER NECK MAY BE LIMITED WHEN THE CAB LUGGAGE DOOR IS CLOSED.
Read full bulletin
*RM
VOLVO: INFORMATION ON FUEL HOSE REPLACEMENT.
Read full bulletin
*RM
VOLVO: AN EXHAUST PIPE INSULATION BLANKET CAN DETERIORATE OVER TIME.
Read full bulletin
A NEW BLANKET HAS BEEN RELEASED TO PROTECT FROM ROAD SPLASH. *RM UPDATED 9/12/11. *PE
VOLVO TRUCK: FUEL TANK MOUNTING.
Read full bulletin
FUEL TANK STRAPS OVER TIME MAY LOSE TORQUE AND ALLOW THE FUEL TANK TO ROTATE. MODELS VN, VHD, VT, VAH. NO MODEL YEARS LISTED. *PE UPDATED 2/21/12. *PE
Body & Paint
8 bulletinsVolvo Chassis - Model VN, Hood Release Cable Interference
Volvo Chassis - Model VN - Water Intrusion In Back Of Cab, Back Wall Of Bunk Leaking
Service Door Rust Prevention
Floor Cracks Repair (Rear Panel)
Floor Cracks Repair (Front Panel)
VOLVO: THERE MAY BE LEAKS AT THE LOWER SLEEPER WINDOW.
Read full bulletin
*RM
VOLVO TRUCKS: VEHICLES WITH PARTIAL CHASSIS FAIRINGS MAY EXPERIENCE DAMAGE TO THE FAIRINGS LOWER SUPPORT RAIL.
Read full bulletin
IT CAN BE CAUSED BY VIBRATION OF THE FAIRING AGAINST THE FIBERGLASS RAIL. A PROCEDURE HAS BEEN DEVELOPED TO IMPROVE THE SITUATION. *RM
VOLVO TRUCK: DOOR SEAL, OUTER, REPLACEMENT.
Read full bulletin
THE OUTER SEAL ON THE CAB DOORS OF VOLVO MODEL TRUCKS MAY PREMATURELY SEPARATE FROM THE CAB SHELL. MODELS VN-2, VHD-2 AND VT. NO MODEL YEARS LISTED. *PE
Brakes
7 bulletinsCBR - Active "Set Park Brake" Message On Drivers Information Display (DID)
CBR: Volvo On-Highway Vehicles - Bendix ABS Fault SPN 807 FMI 13 Blink code 19-4.
Read full bulletin
The new Central Pressure Control (CPC) system has changed the way that the ABS chuff test is performed.
DTC U012100 - Lost Communication With Anti-Lock Brake System (ABS) Control Module, No Additional Information
Volvo Chassis - Redundant Brake Switch Test - Code MID136 SID55 FMI2, or( DTC ) P1055
VOLVO: ON SOME TRUCKS, AIR DISC BRAKE MAY EXPERIENCE A CONDITION OF THERMAL OVERLOAD.
Read full bulletin
THERMAL OVERLOAD REDUCES RUNNING CLEARANCE BETWEEN PAD AND ROTOR BELOW DESIRED LEVEL WHICH IS AN OVER ADJUSTMENT OF NORMAL PAD WEAR COMPENSATION. MODEL VAH, VHD, VN. NO YEARS LISTED. *PE
VOLVO: THE AIR DISC BRAKE, ON SOME TRUCKS, MAY EXPERIENCE THERMAL OVERLOAD DUE TO AN OVER ADJUSTMENT OF NORMAL PAD WEAR...
Read full bulletin
COMPENSATION THAT MAINTAINS CLEARANCE RUNNING BETWEEN BRAKE PAD AND ROTOR. MODELS VAH, VHD, VN. NO YEARS LISTED. *PE
VOLVO: THE BATTERY BOX MAY EXPERIENCE PREMATURE WEAR ON THE TABS OF THE LID.
Read full bulletin
*RM
Infotainment
6 bulletinsCBR: Volvo VHD & VN Models - Vehicle Wil Not Start, PTO Active Message Displayed In Cluster, PTO Light On When PTO...
Read full bulletin
Switch Is Turned Off
Instrument Cluster Programming - Programming Fails Or Errors Display When Replacing An Instrument Cluster With A Newer...
Read full bulletin
Part Number (Conversion Kit) - US04 To US10 Chassis (9-Pin Diagnostic Connector)
Volvo Chassis - FSB 392 - 004 - Radio, Replacement
Instrument Cluster Programming - Programming Fails Or Errors Display When Replacing An Instrument Cluster With A Newer...
Read full bulletin
Part Number (Conversion Kit) - US04 To US10 Chassis (9-Pin Diagnostic Connector)
On Volvo Trucks built between October 6, 2008 and August 18, 2014, with a factory installed programmable radio, the old...
Read full bulletin
radio may no longer be available for purchase. To upgrade from a GLAD format radio to a DEA500 format radio follow the following instructions.
VOLVO: BUG SCREEN, LOCATED ON THE GRILLE OF TRUCK, IS LOOSENING.
Read full bulletin
THE INSERT THREADING IN GRILLE MAY NOT BE DEEP ENOUGH FOR BUG SCREENER RETAINER. MODEL VN. MODEL YEARS 2008-2012.
Lighting
5 bulletinsTSB-Charge Air Cooler t-clamp install.
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P0420 Illuminating The Malfunction Indicator Lamp (MIL)
Volvo Chassis 2008 And Up LED Headlight Conversion Programming Procedure
Volvo VN Models - Overhead Light Loose, Detaching From Headliner
Volvo Chassis - Exterior Lights - Converting From Incandescent To LED Lamps; Hardware And Software Requirements And...
Read full bulletin
Programming Information - Model Year 2008 Through 2017
Suspension
4 bulletinsCBR - Z Spring Bracket Wear.
Read full bulletin
Volvo Chassis
CBR - Vehicles Equipped With Chalmers Suspension - Frame Bracket Hardware Loose or Interfering
Volvo Chassis - Stemco Hubcap Plug Will Not Stay In
VOLVO: TRUCKS BUILT PRIOR TO 18/8/2011 WERE SHIPPED WITHOUT FOUR (4) SPRING NUTS PRE-INSTALLED FROM THE FACTORY.
Read full bulletin
*JS
Tires & Wheels
3 bulletinsFlywheel Housing Thread Repair
Twin Mass Flywheel Conversion
VOLVO TRUCKS: OIL SEEPAGE AT FLYWHEEL HOUSING.
Read full bulletin
THIS PROBLEM HAS ALREADY BEEN SOLVED IN PRODUCTION, BUT THE PRODUCTION SOLUTION IS NOT COMPATIBLE WITH PREVIOUS GENERATION FLYWHEEL HOUSINGS. *JS
Pre-Delivery & Maintenance
2 bulletinsCBR - Accelerator Pedal: Inspection/Instructions
Volvo Chassis - Drag Link Inspection And Replacement Criteria
Software & Calibration
2 bulletinsSoftware Update, revise document
Instrument Cluster Reprogramming
Hybrid & EV
1 bulletinRegeneration in PTO Mode
Steering
1 bulletinVOLVO TRUCKS: ON THE STEERING AXLE OF THE VOLVO TRUCKS, THE ZERK FITTING ON THE MERITOR SLACK ADJUSTER COMES INTO...
Read full bulletin
CONTACT WITH THE BOLT HEAD OF THE STEERING ARM CAUSING THE FITTING TO BREAK. *JS UPDATED 8/17/12. *PE