1999 Volvo VN TSBs
88 Technical Service Bulletins across 15 categories
Categories
Other
20 bulletinsAMT Control Housing Bench Testing - False Failures
Volvo Chassis Ghost Codes Due To Poor Grounding
VIDA QR Scanner Mobile App
Volvo Chassis - Driveline (Driveshaft, Propeller Shaft) Ride Height And Angle, Measurement And Calculation; Pinion Angle...
Read full bulletin
Measurement - Model Year 1996 And Newer
Volvo Chassis - Volvo Hill Start Assist System Information
Volvo Chassis - Fusion 2 Adaptive Cruise Function Document
Volvo Chassis - Volvo Active Driver Assist (VADA)
On some trucks with the Telematics Gateway (TGW) system, the TGW control unit may not correctly communicate with the...
Read full bulletin
vehicle systems after restarting.
Hill Start Assist Solenoid, Replacement
Oil Filter Housing
Aftertreatment DEF Tank Vent Filter
Hill Start Assist Solenoid, Replacement
AMT High Range Cone Replacement
Oil Filter Housing
High Soot Output
Timing Plate Flange Screw
Hill Start Assist Solenoid, Replacement
Timing Plate Leak Repair
Range Synchronizer, Repair
Hill Start Assist Solenoid, Replacement
Electrical
16 bulletinsDEF Level (UQLS) Sensor Troubleshooting Guide - US17+OBD16 Emissions and Newer
NOx Sensor Troubleshooting Guide - US10+OBD13 And Newer Emissions
(Back Office) - Cruise Control Inoperative After Updating Software VECU5 Without ESP Package (UESP)
Temperature Sensor Troubleshooting Guide - US10+OBD13 And Newer
Unable To Retrieve "On Request" Messages For PeopleNet Or Omnitracs Modules Installed On The DL5 Data Link; Third Party...
Read full bulletin
Electronic Log Device Not Reporting Certain Data
Particulate Matter (PM) Sensor Troubleshooting Guide - US14+OBD16 And Newer Emissions
DEF Level (UQLS) Sensor Troubleshooting Guide - US17+OBD16 Emissions and Newer
Shipping and Handling of Volvo Lithium-ion 48V Mild Hybrid Battery to Global Battery Solutions (GBS)
Volvo Chassis - Rain Sensor Bracket Removal And Installation Procedure when Using An Aftermarket Windshield
DEF Sensor Assembly Routing
Seat Harness Routing (Swivel) wires pulling away from clipping points
Seat Harness Routing (Non-Swivel) wires pulling away from clipping points
Fuel Management Module, Replacement, incorrect calibration
Battery Cable, Routing
Oil Level Sensor Harness Wire Splice
VOLVO: LIGHT CONTROL MODULE (LCM), REPROGRAMMING.
Read full bulletin
ON SOME VOLVO UNITS EQUIPPED WITH CLEAR LED CLEARANCE LIGHTS IN THE SUN VISOR, THE MAY EXHIBIT AN ACTIVE FAULT CODE MID 216 PSID 49 FMI 5. THIS FAULT INDICATES A TRAILER MARKER OPEN ISSUE WHICH IS INCORRECT FOR THE ISSUE PRESENT ON THE VEHICLE. *JS
Engine
15 bulletinsBarksdale Leveling Valve, Leak Test
CBR: Programming Failure - Chassis With Cummins Engine And An Allison Transmission
Programming Failure - Chassis With Cummins Engine And An Allison Transmission
Volvo Chassis - Discharge Recirculation Valve (DRV) - FSB 258-029 , Engine Turbocharger Compressor Bypass Valve...
Read full bulletin
Deletion Kit , Installation
In the event that an EGR temperature sensor replacement is required on a VOLVO D13H engine, a new routing configuration...
Read full bulletin
is required.
Turbocharger Outlet Pipe
Engine Coolant Thermostat Software Update
Engine Control Module (ECM) Software Update
Exhaust Gas Recirculation (EGR) Valve Oil Supply Line, updated part
In some instances the exhaust rocker piston cap screw may become loose and back out causing loss of engine compression,...
Read full bulletin
or a mechanical injector Diagnostic Trouble Code (DTC).
VOLVO: LOW OIL PRESSURE, ON CERTAIN VEHICLES, DURING LONG HARD PULL CONDITIONS, DIAGNOSTIC TROUBLE CODES (DTCS) PID 100...
Read full bulletin
FM1, SPN 100 FMI 1 OR P252400, CAN LOG ON, WITH OR WITHOUT ENGINE SHUT DOWN LAMP. MODEL VN, VT. NO YEARS LISTED. *PE
VOLVO TRUCKS: CONNECTOR PIN, REPLACEMENT.
Read full bulletin
SEVERE FRETTING DAMAGE OF THE ENGINE VARIABLE GEOMETRY TURBOCHARGER ACTUATOR (ENGINE VGT ACTUATOR) HARNESS AND TURBINE SHAFT SPEED SENSOR (TSS) CONNECTOR MAY CAUSE AN UNRELIABLE SIGNAL TO THE ENGINE VGT ACTUATOR. *JS
VOLVO TRUCK: TO REDUCE THE POTENTIAL FOR CAB WATER INTRUSION, A CAB COWL SEAL HAS BEEN RELEASED BY ENGINEERING.
Read full bulletin
THE SEAL PART NUMBER 8083305 IS POSITIONED ABOVE THE TOP EDGE OF THE COWL PANEL TO DIVERT WATER FLOW ONTO THE COWL PANEL RATHER THAN BETWEEN THE COWL PANEL AND CAB. NO MODEL YEARS LISTED. *PE
VOLVO TRUCK: REPORTS PROMPTED THE RELEASE OF A REPLACEMENT CONNECTOR FOR THE CAB HVAC MOTOR RESISTOR.
Read full bulletin
REPLACEMENT CONNECTOR IS SUPPLIED AS KIT PART, WHICH CONTAINS THE CONNECTOR BODY AND THE NECESSARY TERMINALS. MODEL YEARS UNKNOWN. *PE
VOLVO TRUCKS: ENGINE UPDATE CAMPAIGN FOR CERTAIN D13F ENGINES (VN-2, VHD-2) CONSISTS OF INSPECTING THE CAMSHAFT AND...
Read full bulletin
REPLACING THE INTAKE ROCKER ARMS, EXHAUST ROCKER ARMS, INJECTOR ROCKER ARMS, INJECTOR HOLD DOWNS, AND THE INJECTOR SEALING WASHERS. *PE UPDATED 12/17/09. *PE
Transmission
9 bulletinsCBR: Volvo Chassis - Timing Gear Plate Repair.
Read full bulletin
This solution provides supplementary information to be used when installing a Timing Gear Plate with Integrated Seal.
Volvo Chassis - Equipped with An Automated Manual Transmission (AMT, iShift) - SNV 19-002 - AMT Oil Filter Housing...
Read full bulletin
Corrosion
Warranty Automated Manual Transmission ( AMT, I-Shift, mDrive ) Control Housing Assembly; Guidelines For Filing A Claim...
Read full bulletin
For Chassis Return Visit With Transmission Issues After A Repair Requiring Control Housing Removal And Reinstallation - US07 And Newer
Volvo Chassis - Equipped With An I-Shift Automated Manual Transmission ( AMT ) - Flywheel Resurfacing And Reuse...
Read full bulletin
Guidelines
Flywheel Resurfacing Guidelines, I-Shift
Transmission ECU Programming
Twin Mass Flywheel Conversion, Transmission Removed
Transmission ECU Compatibility
VOLVO TRUCK; CLUTCH SWITCH CLIP; IT HAS BEEN FOUND THAT VN, VHD AND VT VEHICLES USE A SPRING CLIP TO RETAIN THE CLUTCH...
Read full bulletin
SWITCH, MAY HAVE AN ISSUE WITH THE CLUTCH SWITCH MOVING OR DETACHING FROM IT'S MOUNT. *PE
Fuel System
8 bulletinsDEF Pump Troubleshooting Guide - US10+OBD13 And Newer Emissions
Fuel Level Gauge Reading Incorrect In The Instrument Cluster
Volvo Chassis - Fuel Level Sending Unit Specification Information
Coolant Hose, EGR Cooler, Replacement
Dual Fuel Tanks Ventilation Filter Kit
Single Fuel Tank Ventilation Filter Kit
EGR Mass Flow Rate Low, diagnostic trouble code
VOLVO TRUCK: ON SOME VEHICLES, COOLANT OVERFLOW OUT OF THE OVERFLOW TUBE OCCURS DURING THE DIESEL PARTICULATE FILTER REGENERATION CYCLE.
Read full bulletin
EXCESSIVE COOLANT FLOW FROM THE RADIATOR TOP TANK AND THERMOSTAT VENT LINES PREVENTS FLOW INTO THE DE-AERATION PROCESS. VN-2, VHD-2 VT MODELS ONLY. NO MODEL YEARS LISTED. *PE
Brakes
5 bulletinsCBR: Volvo On-Highway Vehicles - Bendix ABS Fault SPN 807 FMI 13 Blink code 19-4.
Read full bulletin
The new Central Pressure Control (CPC) system has changed the way that the ABS chuff test is performed.
DTC U012100 - Lost Communication With Anti-Lock Brake System (ABS) Control Module, No Additional Information
Volvo Chassis - Redundant Brake Switch Test - Code MID136 SID55 FMI2, or( DTC ) P1055
VOLVO: ON SOME TRUCKS, AIR DISC BRAKE MAY EXPERIENCE A CONDITION OF THERMAL OVERLOAD.
Read full bulletin
THERMAL OVERLOAD REDUCES RUNNING CLEARANCE BETWEEN PAD AND ROTOR BELOW DESIRED LEVEL WHICH IS AN OVER ADJUSTMENT OF NORMAL PAD WEAR COMPENSATION. MODEL VAH, VHD, VN. NO YEARS LISTED. *PE
VOLVO: THE AIR DISC BRAKE, ON SOME TRUCKS, MAY EXPERIENCE THERMAL OVERLOAD DUE TO AN OVER ADJUSTMENT OF NORMAL PAD WEAR...
Read full bulletin
COMPENSATION THAT MAINTAINS CLEARANCE RUNNING BETWEEN BRAKE PAD AND ROTOR. MODELS VAH, VHD, VN. NO YEARS LISTED. *PE
Body & Paint
4 bulletinsVolvo Chassis - Model VN, Hood Release Cable Interference
Service Door Rust Prevention
Floor Cracks Repair (Rear Panel)
Floor Cracks Repair (Front Panel)
Tires & Wheels
3 bulletinsFlywheel Housing Thread Repair
Twin Mass Flywheel Conversion
VOLVO TRUCKS: OIL SEEPAGE AT FLYWHEEL HOUSING.
Read full bulletin
THIS PROBLEM HAS ALREADY BEEN SOLVED IN PRODUCTION, BUT THE PRODUCTION SOLUTION IS NOT COMPATIBLE WITH PREVIOUS GENERATION FLYWHEEL HOUSINGS. *JS
Suspension
2 bulletinsVolvo Chassis - Stemco Hubcap Plug Will Not Stay In
VOLVO: TRUCKS BUILT PRIOR TO 18/8/2011 WERE SHIPPED WITHOUT FOUR (4) SPRING NUTS PRE-INSTALLED FROM THE FACTORY.
Read full bulletin
*JS
Infotainment
1 bulletinCBR: Volvo VHD & VN Models - Vehicle Wil Not Start, PTO Active Message Displayed In Cluster, PTO Light On When PTO...
Read full bulletin
Switch Is Turned Off
Pre-Delivery & Maintenance
1 bulletinVolvo Chassis - Drag Link Inspection And Replacement Criteria
Lighting
1 bulletinVolvo Chassis - Diagnostic Trouble Code ( DTC ) P0420 Illuminating The Malfunction Indicator Lamp (MIL)
Software & Calibration
1 bulletinSoftware Update, revise document
Hybrid & EV
1 bulletinRegeneration in PTO Mode
Steering
1 bulletinVOLVO TRUCKS: ON THE STEERING AXLE OF THE VOLVO TRUCKS, THE ZERK FITTING ON THE MERITOR SLACK ADJUSTER COMES INTO...
Read full bulletin
CONTACT WITH THE BOLT HEAD OF THE STEERING ARM CAUSING THE FITTING TO BREAK. *JS UPDATED 8/17/12. *PE