2023 Volvo VHD TSBs
120 Technical Service Bulletins across 13 categories
Categories
Engine
24 bulletinsCBR - 3 Liter Engines ONLY - Engine Coolant Pump Housing Leak; Coolant Found Around The Oil Cooler Duct Cover Or In...
Read full bulletin
Between The Coolant Pump Housing And Oil Cooler Housing
CBR - 13 Liter Engines ONLY - Engine Coolant Pump Housing Leak; Coolant Found Around The Oil Cooler Duct Cover Or In...
Read full bulletin
Between The Coolant Pump Housing And Oil Cooler Housing
Inactive Code P25AE00 Being Generated After A Hard Pull And A Momentary Drop In Engine Oil Pressure (Low Oil Pressure)...
Read full bulletin
(Possible Related Codes - SPN4811 , SPN 100 , PID 100)
TSB - V-710-001 Engine Crossmember Loose Hardware.
CBR - 11L, 13L, And 16L Engine Oil Analysis Specifications - US10 And Newer Emissions
These repair instructions are intended to address the following fault(s): P009B-13 (Electric Pressure Relief Valve ...
Read full bulletin
Circuit Open).
Vehicles may present with oil leak coming from the clutch/flywheel housing and observation of burned clutch smell or clutch slipping.
Read full bulletin
These symptoms can be mistaken as a crankshaft rear main seal leak, when the actual cause is the crankshaft adaptor O-ring.
11L Engine Block Compatibility and Backward Conversion Parts Requirements
CBR - 13L engines may be equipped with an improper engine software calibration that does not match the engine...
Read full bulletin
certification label.
CBR - Automated Manual Transmission (AMT) Model D or F (mDrive and I-Shift, AMT-D, AMT-F) - Transmission Oil Leakage...
Read full bulletin
From Transmission Input Shaft Seal Or Output Shaft Seal - US10 And Newer Emissions, Common Model Years 2010 And Newer
CBR: 11L, 13L, And 16L Engine Oil Analysis Specifications - US10 And Newer Emissions
CBR - 11 Liter Engines - Fuel In Oil.
Service Campaign: Volvo trucks has determined that certain VAH, VHD, and VN model trucks built with a D13 engine could...
Read full bulletin
experience a reduced clamping load on the turbocharger mounting hardware causing the hardware to become loose. On affected vehicles follow the instructions below to remove the turbocharger and replace the mounting hardware and mounting gasket with new parts.
CBR: Vehicles built with an 11 liter engine may experience a complaint of excessive fuel in the oil.
Read full bulletin
It is possible that the source of the fuel is the rear fuel galley plug in the cylinder head.
CBR: 11L Engine - Air Conditioner (A/C) Line Damaged At Bracket - Model Year 2007 to Present.
CBR: Valve Stem Extension Contacting Outer Wheel
Barksdale Leveling Valve, Leak Test
CBR: Volvo DEF Dosing Valve Diagnostic Trouble Codes (DTC) P202D00, P208E00, P103B00 - US10+OBD13 And Newer Emissions
CBR: Programming Failure - Chassis With Cummins Engine And An Allison Transmission
CBR - Engine Control Module (EMS) Software (MSW) Information - Improvement List, Through June 2023 - US21+OBD2020...
Read full bulletin
Emissions
CBR: Model Year 2017 to Current - Fuel Filter Change ( Primary And Secondary ) For The EM - USA17 Emission Engines
CBR: 11L Engines, Non-Common Rail - Air Compressor Coolant Pipe, Parts Substitution - US14+OBD13 To US14+OBD16
CBR: Volvo VHD Models - Allison Reduced Engine Load At A Stop (RELS) Diagnostic Trouble Code P071A Or P07CE - Non-Split/Drop Box PTO.
Read full bulletin
VHD chassis may experience Diagnostic Trouble Code P071A or P07CE along with symptoms of no reduced engine load (RELS) when coming to a stop and/or the transmission going into 4th gear lock up when applying the service brake.
Volvo Chassis - Electronically Controlled Air Dryer System (ECADS) Building Too Much Air Pressure; Pressure Relief Valve...
Read full bulletin
Opening
Other
22 bulletinsCBR - Volvo Chassis - Model VHD - Splash Shield Rubbing Lower Cowl - Model Year 2018 - Current.
CBR - Frame or Cab Lean
CBR - A significant GPS reporting issue is affecting fleet operations, with trucks maintaining back-office communication...
Read full bulletin
but failing to transmit GPS location data.
Volvo Chassis - Frame Or Cab Lean
CBR - Volvo Chassis - No-Crank Issue After Programming
CBR - Frame Or Cab Lean
CBR - Diagnostic Trouble Code (DTC) P107471 - AMT-F
CBR: Telematics Gateway (TGW) Connect Ability Issues
CBR: Diagnostic Trouble Code (DTC) P107471 - AMT-F
CBR: Diagnostic Trouble Code (DTC) P107471 -AMT-F
CBR - Telematics Gateway (TGW) Connect Ability Issues.
CBR - Diagnostic Trouble Code (DTC) P107471 - AMT-F
CBR: TGW Will Not Connect After SIM Card Replacement
CBR: Volvo Chassis - Nonfunctioning 12vAccessory Power Supply - Model Year(MY) 2017 To Present
CBR: Volvo Chassis - Nonfunctioning 12v Accessory Power Supply - Model Year (MY) 2017 To Present
CBR - iLok Fastener Torque
CBR: Diagnostic Trouble Code (DTC) U1FFF68 - Factory Mode Active, Event Information - Model Year (MY) 2023
CBR: Diagnostic Trouble Code (DTC) P215A-64, Fault Code SPN 84 FMI 19
Adaptive Cruise Control, Deactivation
New TSB for oil galley plug leaking oil.
Google Built In Premium Customer Experience Program
13L Oil Pickup Replacement
Electrical
16 bulletinsOverheating has been observed at the alternator power cable and ground cable connection, resulting in melted insulation around the terminal area.
Read full bulletin
The alternator power cable connection should maintain a stable electrical contact without overheating or insulation damage during normal vehicle operation. The alternator power cable shows signs of overheating and melted insulation at the connection point, which may affect electrical conductivity and charging system performance.
CBR - No Start Condition After Over the Air Programing - VECU5 No Start "Safe State"
CBR - Volvo DEF Level (UQLS) Sensor Troubleshooting Guide - US17+OBD16 Emissions and US22+OBD23 (DOES NOT APPLY TO...
Read full bulletin
VN(4))
CBR - When an OTA (Over-The-Air) job starts to program the VECU blocks the starter relay out, if the job ends in a...
Read full bulletin
Critical failure, the vehicle will remain in Safe State.
Volvo Trucks has identified that some VN model vehicles equipped with auxiliary power unit batteries may experience...
Read full bulletin
insufficient battery system charging. This could lead to early battery failure and improper functioning of the auxiliary power systems. Follow the instructions in the attached document to upgrade the charging system.
Volvo Trucks has identified that some VN model vehicles equipped with auxiliary power unit batteries may experience...
Read full bulletin
insufficient battery system charging. This could lead to early battery failure and improper functioning of the auxiliary power systems. Follow the instructions in the attached document to upgrade the charging system.
CBR - US17 GHG Common Rail Fuel System Component Electrical Faults - Model Year 2017 To 2024
CBR: Diagnostic Trouble Code (DTC) U010187- Lost Communication With TECU
Aftertreatment Diesel Exhaust Fluid (DEF) Tank, Level Sensor, Replacement
Aftertreatment Diesel Exhaust Fluid (DEF) Tank, Level Sensor, Replacement
CBR - Diagnostic Trouble Code (DTC) P103200: Particulate Matter Sensor Removed from Exhaust - US21+OBD22 Emissions
CBR - Volvo NOx Sensor Troubleshooting Guide - US10+OBD13 And Newer Emissions
CBR - Volvo NOx Sensor Troubleshooting Guide - US10+OBD13 And Newer Emissions
CBR: Diagnostic Trouble Code (DTC) P225C00 : NOx1 Sensor Stuck High - US17+OBD2019 And Newer Emissions
CBR: Volvo NOx Sensor Troubleshooting Guide - US10+OBD13 And Newer Emissions.
Read full bulletin
The primary failure mode the NOx Sensors is internal failure, which will generate a sensor specific fault code.
Diagnostic Trouble Code ( DTC ) P10AE Logged In TECU With ACTIVE Or INACTIVE Status, Fault Code Cannot Be Cleared;...
Read full bulletin
Possibly Accompanied By P105817 And P105818 - US10+OBD13 And Newer Emissions (16-Pin Diagnostic Connector), Commonly Model Year 2014
Suspension
12 bulletinsCBR - Z Spring Bracket Wear.
Read full bulletin
Volvo Chassis
SC - Volvo Proprietary Fixed Axle Hubcap Replacement.
SC - Volvo Proprietary Steerable Axle Hubcap Replacement
This Service Campaign is the solution for vehicles affected by the Hub cover Insufficient Retention Recall RVXX2302.
Read full bulletin
This campaign also covers trucks that were shipped from the factory without hubcaps.
Frame lean can be caused by several seemingly isolated possibilities.
Read full bulletin
The two most common are suspension and frame assembly issues.
CBR - Volvo Chassis - Enable Air Suspension Gauge Function - US17 And Newer Chassis ONLY
CBR - Driveline Noise, Suspension Ride Height Too High, Suspension Will Not Exhaust - Chassis Built 2016w01 And Newer
Service Campaign: On certain Volvo VN, VHD, VAH chassis, with a Meritor rear carrier, there is a possibility of the rear...
Read full bulletin
differentials being filled with incorrect fluid. This campaign will require draining the rear differential/differentials, hubs and refilling with the correct fluid.
Service Campaign: This Service Campaign is the solution for the Ship Shortage of Proprietary Hubcap Recall SC0425 that...
Read full bulletin
effected Volvo VAH, VHD, VN, VNE Models. This Service Campaign also covers trucks that were shipped short from the factory or removed in the field. Volvo Trucks now has a solution to replace the Proprietary Hubcaps with new updated hubcaps.
Service Campaign: This Service Campaign is the solution for the Proprietary Hubcap Recall SC0425 that effected Volvo VAH, VHD, VN, VNE Models.
Read full bulletin
This Service Campaign also covers trucks that were shipped short from the factory or removed in the field. Volvo Trucks now has a solution to replace the Proprietary Hubcaps with new updated hubcaps.
CBR - Vehicles Equipped With Chalmers Suspension - Frame Bracket Hardware Loose or Interfering
Hub Cap, Leaking
Transmission
9 bulletinsCBR - Volvo Chassis - I-Shift Transmission - Moisture / Contamination Found In The Transmission Electronic Control Unit...
Read full bulletin
(TECU ) Air Ports And Control Housing.
CBR - Driver Display Popup Error "Door Is Open.
Read full bulletin
Shift Transmission To Neutral." -Instrument Cluster Software Update
CBR - Volvo Chassis - Timing Gear Plate Repair
CBR: On Volvo chassis with an I-Shift and Mack chassis with an mDRIVE transmission, there have been reports of complete...
Read full bulletin
shift assemblies and TECUs being replaced due to technicians being unable to pinpoint the source of the air leak.
CBR - Automated Manual Transmission ( AMT ) Flywheel Pilot Bearing Wear On Input Shaft.
Parts Sales and Marketing Bulletin: Volvo Trucks is excited to announce an additional year warranty program on Volvo...
Read full bulletin
Reman AMT I-Shift Complete Transmissions. This extended warranty of 3 years or 350,000 miles on the transmission will be applicable when dealer installed, required parts are installed and is registered via eService.
CBR: Automated Manual Transmission ( AMT ) - Transmission Electronic Control Unit ( TECU ) MID130 PSID 29 FMI 7 /...
Read full bulletin
P10AE81 Fault Codes Being Generated
CBR: Automated Manual Transmission (AMT) Transmission Kickdown Mode
CBR: Volvo Chassis - Timing Gear Plate Repair.
Read full bulletin
This solution provides supplementary information to be used when installing a Timing Gear Plate with Integrated Seal.
Infotainment
8 bulletinsCBR - Drivers Information Display (DID) Inoperative/Goes Blank During Vehicle Operation
CBR: Drivers Information Display (DID)Inoperative After Cluster Replacement And Programming
CBR - Drivers Information Display (DID) Inoperative/Goes Blank During Vehicle Operation
CBR - Drivers Information Display (DID) Inoperative After Cluster Replacement And Programming
CBR: After cluster replacement and programming, the Driver Information Display (DID) may not function as designed.
Vehicle Overspeed Warning Comes Active At A Lower Speed Than Expected; Vehicle Overspeed Warning In Driver Information...
Read full bulletin
Display (DID) - Model Year 2018 And Newer With New Style Instrument Cluster.
CBR: Volvo VHD & VN Models - Vehicle Wil Not Start, PTO Active Message Displayed In Cluster, PTO Light On When PTO...
Read full bulletin
Switch Is Turned Off
Infotainment System - Volume Drop During A Phone Call, Phone Connected Via Bluetooth
Lighting
7 bulletinsCBR - Troubleshooting cab lean should only begin after completing a vehicle preparation procedure to ensure all...
Read full bulletin
components are in place and settled.
CBR - Volvo Chassis - Debris In 13L Cooling Systems Filled With Extended Life (VCS2)
CBR - Volvo Chassis - Debris In 13L Cooling Systems Filled With Extended Life (VCS2).
CBR: Volvo Chassis - Debris In 13L Cooling Systems Filled With Extended Life(VCS2)
CBR: Volvo Chassis - Debris In 13L Cooling Systems Filled With Extended Life(VCS2)
CBR: On a Volvo Chassis - US16 - with the Bendix Lane Departure Warning System ( LDW )the alarm would not cancel once...
Read full bulletin
the turn signals were activated.
On certain Volvo VN, VHD, VAH chassis, with a Meritor rear carrier, there is a possibility of the rear differentials...
Read full bulletin
being filled with incorrect fluid.
Brakes
5 bulletinsCBR - US17AbstractVolvo Chassis equipped with Volvo Active Driver Assist may display DTC / Fault code SPN 516103 FMI 19...
Read full bulletin
on Premium Tech Tool ( PTT ) or J-Pro, and code 167 in Bendix ACOM software.
CBR - Brake Caliper Concerns And Premature Brake Pad Wear - Model Year 2023 - 2024
CBR: Chassis Equipped With VECU5 Active Datalink/Communication Faults For Multiple Modules; ABS And SRS Communication...
Read full bulletin
Faults.
CBR - Active "Set Park Brake" Message On Drivers Information Display (DID)
CBR: Volvo On-Highway Vehicles - Bendix ABS Fault SPN 807 FMI 13 Blink code 19-4.
Read full bulletin
The new Central Pressure Control (CPC) system has changed the way that the ABS chuff test is performed.
Body & Paint
5 bulletinsRemote Control Central Door Lock, Programming; Key Fob Cannot Be Programmed Or Does Not Work After Programming - Model...
Read full bulletin
Year 2018 And Newer
TSB - Due to cracking in the step area of the fairing, an updated support bracket has been introduced.
Read full bulletin
The new support bracket will provide the better structure behind the fairing, reducing the likelihood of cracking.
This CBR solution provides a step-by-step procedure for using longer Hood Tilt Switch mount screws and additional...
Read full bulletin
washers on Volvo Auto Hauler (VAH) and Volvo Heavy Duty (VHD) models.
This CBR solution provides a step-by-step procedure to replace the hood tilt switch on Volvo Autohauler (VAH) and Volvo...
Read full bulletin
Heavy Duty (VHD) models, specifically for units equipped with bodybuilder applications that enable remote start/stop functionality outside the cab when the PTO (Power Take-Off) is engaged. The hood tilt switch is a critical safety component that disables remote start when the hood is opened or tilted.
Hood Cable Breaking or Binding
Fuel System
5 bulletinsCBR: Overhead Wear Overview - Model Year2018 To Current (Common Rail Fuel System ONLY)
CBR: Vehicle Speed Factor (K-Factor) Programming - Speed Factor Value Incorrect When Calculated In Premium Tech Tool...
Read full bulletin
(PTT); Speedometer Reading Incorrectly Following A Change To Vehicle Speed Factor - US17+OBD16 And Newer Emissions, Common Model Year 2018.
CBR: Intermittent Diagnostic Trouble Codes U02A3,U029D, U029E - USE FOR NEW VEHICLES (US21+OBD22 Emissions)
CBR - Volvo Selective Catalytic Reduction (SCR) Muffler Troubleshooting Guide - US10+OBD13 And Newer Emissions
CBR: Diagnostic Trouble Code (DTC) P008A - Low Pressure Fuel System Pressure - Too Low
Pre-Delivery & Maintenance
4 bulletinsService Campaign: TGW3 Non-Communication
CBR - Accelerator Pedal: Inspection/Instructions
Service Literature Published and Released in May, 2023
CBR: Volvo - Pre-Delivery Inspection (PDI) Torque Values.
Read full bulletin
This solution provides the torque specs needed to complete a Pre- Delivery Inspection (PDI).
HVAC & Climate
2 bulletinsThis CBR solution addresses the issue of binding between the outer air filter housing and inner HVAC box due to...
Read full bulletin
misalignment during installation.
CBR - Volvo Chassis - HVAC Fresh Air Door Binding
Software & Calibration
1 bulletinService Campaign: Volvo trucks has determined that certain VN and VHD model trucks built with TGW3 have stopped communicating after production.
Read full bulletin
Follow the instructions below to update the TGW software and perform the SIM card calibration procedure to re-establish TGW connection.