2022 Volvo VHD TSBs

Engine Control Module (EMS) Software Information - Improvement List (Change Log), US21+OBD2021 Emissions ONLY

CBR - 3 Liter Engines ONLY - Engine Coolant Pump Housing Leak; Coolant Found Around The Oil Cooler Duct Cover Or In...

CBR - 13 Liter Engines ONLY - Engine Coolant Pump Housing Leak; Coolant Found Around The Oil Cooler Duct Cover Or In...

Inactive Code P25AE00 Being Generated After A Hard Pull And A Momentary Drop In Engine Oil Pressure (Low Oil Pressure)...

TSB - V-710-001 Engine Crossmember Loose Hardware.

CBR - 11L, 13L, And 16L Engine Oil Analysis Specifications - US10 And Newer Emissions

These repair instructions are intended to address the following fault(s): P009B-13 (Electric Pressure Relief Valve ...

Vehicles may present with oil leak coming from the clutch/flywheel housing and observation of burned clutch smell or clutch slipping.

11L Engine Block Compatibility and Backward Conversion Parts Requirements

CBR - 13L engines may be equipped with an improper engine software calibration that does not match the engine...

CBR - Automated Manual Transmission (AMT) Model D or F (mDrive and I-Shift, AMT-D, AMT-F) - Transmission Oil Leakage...

CBR: 11L, 13L, And 16L Engine Oil Analysis Specifications - US10 And Newer Emissions

Service Campaign: Certain model year 2022 VHD/VAH vehicles could experience headlight vibration, which makes the...

CBR - 11 Liter Engines - Fuel In Oil.

CBR: Vehicles built with an 11 liter engine may experience a complaint of excessive fuel in the oil.

CBR: 11L Engine - Air Conditioner (A/C) Line Damaged At Bracket - Model Year 2007 to Present.

Service Campaign: Volvo Trucks has determined that certain model year 2022 VHD/VAH vehicles could experience headlight...

CBR: Valve Stem Extension Contacting Outer Wheel

Barksdale Leveling Valve, Leak Test

CBR: Volvo DEF Dosing Valve Diagnostic Trouble Codes (DTC) P202D00, P208E00, P103B00 - US10+OBD13 And Newer Emissions

CBR: Programming Failure - Chassis With Cummins Engine And An Allison Transmission

CBR - Engine Control Module (EMS) Software (MSW) Information - Improvement List, Through June 2023 - US21+OBD2020...

CBR: Model Year 2017 to Current - Fuel Filter Change ( Primary And Secondary ) For The EM - USA17 Emission Engines

CBR: 11L Engines, Non-Common Rail - Air Compressor Coolant Pipe, Parts Substitution - US14+OBD13 To US14+OBD16

CBR: Volvo VHD Models - Allison Reduced Engine Load At A Stop (RELS) Diagnostic Trouble Code P071A Or P07CE - Non-Split/Drop Box PTO.

Oil In Coolant - Cross Contamination From Oil Cooler - 13L VGT Engines

Volvo Chassis - Electronically Controlled Air Dryer System (ECADS) Building Too Much Air Pressure; Pressure Relief Valve...

Engine Control Module (EMS) Software (MSW) Information October 2022; Improvement List (Change Log) - US21+OBD22 (13L...

TBS- Jumper Harness, Wiper Motor, Replacement

Document revised to state that a software update has been released for P0244-00 on TurboCompound US20 - US21 Emission...

Engine Control Module (EMS) Software (MSW) Information October 2022; Improvement List (Change Log) - US21+OBD22 (13L...

11 Liter Engines - Fuel In Oil - Vehicles Built Between October 2020 And June 2021

Engine Control Module (EMS) Software Information - Improvement List (Change Log), US21+OBD2020 US21+OBD2021 Emissions...

Engine Control Module (EMS) Software (MSW) Information August 2022; Improvement List (Change Log) - US21+OBD22 (13L...

Engine Control Module (EMS) Software (MSW) Information August 2022; Improvement List (Change Log) - US21+OBD22 (13L...

Programming Failure - Chassis With Cummins Engine And An Allison Transmission

11L, 13L, And 16L Engine Oil Analysis Specifications - US10 And Newer Emissions

(Back Office Only) - Engine Brake Vibration When In High Setting - 13L Engine With Variable Geometry Turbo ( VGT ) -...

US10 Emission Engines - Diagnostic Trouble Code ( DTC ) SPN 1231 FMI 9 Troubleshooting

Vehicles Equipped With An Automated Manual Transmission Model D or F ( AMT-D, AMT-F ) - Transmission Oil Leakage From...

Volvo Chassis - Automated Manual Transmission Model F (AMT-F, I-Shift) - Possible Infrequent Hiccup/Stumble During...

Volvo Chassis - Technical Service Bulletin V-728-005, Leveling Valve, Leak Test, Air Leaks From The Leveling Valve After...

TC Engine Turbochargers

Variable Geometry Turbocharger ( VGT ) Function Test ( 2551-08-03-02 ), OBD13 Model Year ( MY ) 2014 And Newer

Volvo Chassis - Coolant Leak Test - Dye Information

Volvo Chassis - Approved Engine Oil For Volvo Engines, Factory Fill Oil Information - US07 And Newer Emissions, Model...

Cylinder Head Reuse And Replacement Guidelines - Inspection And Information - US04 And Newer Emissions, Commonly 2007...

Volvo Chassis - Equipped With A Cummins Engine - Cummins Fuel Pump Timing Correction to Reduce Engine Noise; Drone Noise...

Valve Cover Oil Leak at T Joint

CBR - Volvo Chassis - Model VHD - Splash Shield Rubbing Lower Cowl - Model Year 2018 - Current.

CBR - Frame or Cab Lean

CBR - A significant GPS reporting issue is affecting fleet operations, with trucks maintaining back-office communication...

Volvo Chassis - Frame Or Cab Lean

CBR - Volvo Chassis - No-Crank Issue After Programming

CBR - Frame Or Cab Lean

CBR: Telematics Gateway (TGW) Connect Ability Issues

CBR: Diagnostic Trouble Code (DTC) P107471 - AMT-F

CBR - Telematics Gateway (TGW) Connect Ability Issues.

CBR - Diagnostic Trouble Code (DTC) P107471 - AMT-F

CBR: TGW Will Not Connect After SIM Card Replacement

CBR: Volvo Chassis - Nonfunctioning 12vAccessory Power Supply - Model Year(MY) 2017 To Present

CBR: Volvo Chassis - Nonfunctioning 12v Accessory Power Supply - Model Year (MY) 2017 To Present

CBR: Diagnostic Trouble Code (DTC) P215A-64, Fault Code SPN 84 FMI 19

Adaptive Cruise Control, Deactivation

Diagnostic Trouble Code (DTC) P107471 - AMT-F

Google Built In Premium Customer Experience Program

13L Oil Pickup Replacement

Volvo Essential Tool Shipment

Google Built In Premium Customer Experience Program.

13L Oil Pickup Replacement

Drive Axle Oil

Part information for AMT input shaft repair kits and the shim kit that is required for repair.

VADA, Front Radar Fulfillment

AMT Control Housing Bench Testing - False Failures

Oil Pickup Replacement

The Diagnostic Process

Volvo Fault Code MID 144 PSID 204 FMI 9

Volvo Chassis Ghost Codes Due To Poor Grounding

Volvo Chassis - PTO Pump Speed Calculator

(Back Office Only) Volvo Chassis Loss Of Cruise Control After Disabling Electronic Stability Program (ESP)

Volvo Chassis - Volvo ( Bergstrom )Parking Cooler System, Technical Information And Diagnostic Guide - Model Year 2018...

VIDA QR Scanner Mobile App

Volvo Chassis - Accessory / Auxiliary Connection Points ( Power/Ground Points ) - VNL, VNR, VNX, VAH, VHD - Model Year...

V-MAC III - Smart Fan Will Not Disengage

Volvo Chassis US13 And Up Pre-trip Assistant Enable

Volvo Chassis - Driveline (Driveshaft, Propeller Shaft) Ride Height And Angle, Measurement And Calculation; Pinion Angle...

Convert Care Key to Standard Key.

Volvo Chassis - Performance Bonus OBD13 And Newer

Forward Looking Radar Shortage

Volvo Chassis - Diagnostic Code ( DTC ) B105254 Active And Unable To Be Cleared - Vehicles Manufactured On Or After 1...

Vehicles Equipped With a Common Rail Fuel System - Aftermarket Secondary Fuel Filters, Important Information On Approved...

CBR: Overhead Wear Overview - Model Year2018 To Current (Common Rail Fuel System ONLY)

CBR: Vehicle Speed Factor (K-Factor) Programming - Speed Factor Value Incorrect When Calculated In Premium Tech Tool...

CBR: Intermittent Diagnostic Trouble Codes U02A3,U029D, U029E - USE FOR NEW VEHICLES (US21+OBD22 Emissions)

CBR - Volvo Selective Catalytic Reduction (SCR) Muffler Troubleshooting Guide - US10+OBD13 And Newer Emissions

EC: Volvo Vehicle Emission Label

Diagnostic Trouble Codes (DTC) P208064, P208464, P242B64 and P246F64 Lighting The Malfunction Indicator Lamp (MIL) -...

Volvo DEF Pump Troubleshooting Guide - US10+OBD13 And Newer Emissions

Diagnostic Trouble Codes (DTC) P24F600 Or P24F700 - US14+OBD15 Emissions And Newer, Model Year 2016 And Newer

Diagnostic Trouble Codes (DTC) P24F600 Or P24F700 - US14+OBD15 Emissions And Newer, Model Year 2016 And Newer

Diagnostic Trouble Code P200200 - Diagnostic Information; US14+OBD16 And Newer Emissions

USE FOR NEW VEHICLES (US21+OBD22 Emissions) - Intermittent Diagnostic Trouble Codes U02A3, U029D, U029E

Diesel Particulate Filter (DPF) And Diesel Oxidation Catalyst (DOC) Pin Testing Procedure - US07 And Newer Emissions,...

Aftertreatment Hydrocarbon Injector (AHI) Troubleshooting Guide - US10+OBD13 And Newer Emissions

DEF Pump Troubleshooting Guide - US10+OBD13 And Newer Emissions

Diesel Particulate Filter (DPF) And Diesel Oxidation Catalyst (DOC) Pin Testing Procedure - US07 And Newer Emissions,...

Premium Tech Tool (PTT) - Message For Data Mismatch, Product Configuration Mismatch; Instruction To Run An Accessory Kit...

Electronic Stability Program (ESP), Electronic Stability Control (ESC): Changes And Removal Information; Permissible PAR...

Fuel Level Gauge Reading Incorrect In The Instrument Cluster

Volvo Chassis - Fuel Level Gauge Slow To Respond To Changes In Fuel Level

DEF Pump Troubleshooting Guide - US10+OBD13 And Newer Emissions

Selective Catalytic Reduction (SCR) Muffler Troubleshooting Guide - US10+OBD13 And Newer Emissions

Aftertreatment Hydrocarbon Injector (AHI) Troubleshooting Guide - US10+OBD13 And Newer Emissions

USE FOR NEW VEHICLES (US21+OBD22 Emissions) - Intermittent Diagnostic Trouble Codes U02A3, U029D, U029E

Diagnostic Trouble Code ( DTC ) P26E8 Intermittently Lighting The Malfunction Indicator Lamp ( MIL ); Possible Derate...

Diagnostic Trouble Codes (DTC) P24F600 Or P24F700 - US14+OBD15 Emissions And Newer, Model Year 2016 And Newer

Volvo Chassis - Diagnostic Trouble Codes ( DTC ) P208E And P103B Logging With Possible Derate( SCR Inducement ) -...

Grounding Bus Bar (Cloverleaf, Grounding Star, Four Point Ground Stud) On Frame Rail; Inspection To Be Performed For...

Premium Tech Tool (PTT) Error Code 43: Service Regeneration Fails To Start; Service Regen Does Not Complete With Error...

Diesel Fuel Information - Acceptable Biodiesel, Fuel Blend For Summer And Winter - US07 And Newer Emissions, Model Year...

Diagnostic Trouble Codes (DTC) P208064, P208464, P242B64 and P246F64 Lighting The Malfunction Indicator Lamp (MIL) -...

Overheating has been observed at the alternator power cable and ground cable connection, resulting in melted insulation around the terminal area.

CBR - No Start Condition After Over the Air Programing - VECU5 No Start "Safe State"

CBR - Volvo DEF Level (UQLS) Sensor Troubleshooting Guide - US17+OBD16 Emissions and US22+OBD23 (DOES NOT APPLY TO...

CBR - When an OTA (Over-The-Air) job starts to program the VECU blocks the starter relay out, if the job ends in a...

Volvo Trucks has identified that some VN model vehicles equipped with auxiliary power unit batteries may experience...

Volvo Trucks has identified that some VN model vehicles equipped with auxiliary power unit batteries may experience...

CBR - US17 GHG Common Rail Fuel System Component Electrical Faults - Model Year 2017 To 2024

CBR: Diagnostic Trouble Code (DTC) U010187- Lost Communication With TECU

Aftertreatment Diesel Exhaust Fluid (DEF) Tank, Level Sensor, Replacement

Aftertreatment Diesel Exhaust Fluid (DEF) Tank, Level Sensor, Replacement

Emission Campaign: OBD MONITOR, This Recall includes an updated software in the EECU and ACM to address potential issues...

CBR - Diagnostic Trouble Code (DTC) P103200: Particulate Matter Sensor Removed from Exhaust - US21+OBD22 Emissions

CBR - Volvo NOx Sensor Troubleshooting Guide - US10+OBD13 And Newer Emissions

CBR - Volvo NOx Sensor Troubleshooting Guide - US10+OBD13 And Newer Emissions

CBR: Diagnostic Trouble Code (DTC) P225C00 : NOx1 Sensor Stuck High - US17+OBD2019 And Newer Emissions

CBR: Volvo NOx Sensor Troubleshooting Guide - US10+OBD13 And Newer Emissions.

Diagnostic Trouble Code ( DTC ) P10AE Logged In TECU With ACTIVE Or INACTIVE Status, Fault Code Cannot Be Cleared;...

(Back Office) - Cruise Control Inoperative After Updating Software VECU5 Without ESP Package (UESP)

DEF Level (UQLS) Sensor Troubleshooting Guide - US17+OBD16 Emissions and Newer

NOx Sensor Troubleshooting Guide - US10+OBD13 And Newer Emissions

(Back Office) - Cruise Control Inoperative After Updating Software VECU5 Without ESP Package (UESP)

Particulate Matter (PM) Sensor Troubleshooting Guide - US14+OBD16 And Newer Emissions

Temperature Sensor Troubleshooting Guide - US10+OBD13 And Newer

Unable To Retrieve "On Request" Messages For PeopleNet Or Omnitracs Modules Installed On The DL5 Data Link; Third Party...

Particulate Matter (PM) Sensor Troubleshooting Guide - US14+OBD16 And Newer Emissions

Particulate Matter (PM) Sensor Troubleshooting Guide - US14+OBD16 And Newer Emissions

Shipping and Handling of Volvo Lithium-ion 48V Mild Hybrid Battery to Global Battery Solutions (GBS)

Front Accessory Drive noise, Alternator Belt Wear, Alternator Belt Tensioner Failure - MY 2017 And Newer

Volvo Chassis - Particulate Matter (PM) Sensor Diagnostic Trouble Codes (DTC) Illuminating The Malfunction Indicator...

VECU Software Update

CBR - Drivers Information Display (DID) Inoperative/Goes Blank During Vehicle Operation

CBR: Drivers Information Display (DID)Inoperative After Cluster Replacement And Programming

CBR - Drivers Information Display (DID) Inoperative/Goes Blank During Vehicle Operation

CBR - Drivers Information Display (DID) Inoperative After Cluster Replacement And Programming

CBR: After cluster replacement and programming, the Driver Information Display (DID) may not function as designed.

Vehicle Overspeed Warning Comes Active At A Lower Speed Than Expected; Vehicle Overspeed Warning In Driver Information...

CBR: Volvo VHD & VN Models - Vehicle Wil Not Start, PTO Active Message Displayed In Cluster, PTO Light On When PTO...

Infotainment System - Volume Drop During A Phone Call, Phone Connected Via Bluetooth

Vehicle Overspeed Warning Comes Active At A Lower Speed Than Expected; Vehicle Overspeed Warning In Driver Information...

Vehicle Overspeed Warning Comes Active At A Lower Speed Than Expected; Vehicle Overspeed Warning In Driver Information...

Vehicle Overspeed Warning Comes Active At A Lower Speed Than Expected; Vehicle Overspeed Warning In Driver Information...

Vehicle Overspeed Warning Comes Active At A Lower Speed Than Expected; Vehicle Overspeed Warning In Driver Information...

Vehicle Overspeed Warning Comes Active At A Lower Speed Than Expected; Vehicle Overspeed Warning In Driver Information...

Radio, Replacement (revised from FSB 392-005)

Noise On The AM Radio Band; Thumping, Ticking, Fluttering Sound On AM Radio Band - Model Year 2018 And Newer

If a customer complains that the SiriusXM satellite radio media source is missing from the vehicle.

Volvo Chassis - With 2018 New Style Instrument Cluster - Radio Mutes When In Reverse - Model Years 2018 And Newer

Vehicle Will Not Start, PTO Active Message Displayed In Cluster, PTO Light On When PTO Switch Is Turned Off

Volvo Chassis - Enable The Fault Code, Diagnostic Trouble Code ( DTC ) Screen (Menu) In The Instrument Cluster ( IC,...

Volvo Chassis - Field Service Bulletin Trucks ( FSB ) 395 001 Radio Antenna Filter, Installation VAH, VHD, VN ( Noise,...

CBR - Volvo Chassis - I-Shift Transmission - Moisture / Contamination Found In The Transmission Electronic Control Unit...

CBR - Driver Display Popup Error "Door Is Open.

CBR - Volvo Chassis - Timing Gear Plate Repair

CBR: On Volvo chassis with an I-Shift and Mack chassis with an mDRIVE transmission, there have been reports of complete...

CBR - Automated Manual Transmission ( AMT ) Flywheel Pilot Bearing Wear On Input Shaft.

Parts Sales and Marketing Bulletin: Volvo Trucks is excited to announce an additional year warranty program on Volvo...

CBR: Automated Manual Transmission ( AMT ) - Transmission Electronic Control Unit ( TECU ) MID130 PSID 29 FMI 7 /...

CBR: Automated Manual Transmission (AMT) Transmission Kickdown Mode

CBR: Volvo Chassis - Timing Gear Plate Repair.

Campaign for checking steering gear hardware torque

Timing Gear Plate Inspection

Volvo Chassis - ( AMT, I-Shift ) - Transmission Grinding When Downshifting ; Range Synchronizer (Synchro) Timing...

Volvo Chassis - Equipped with An Automated Manual Transmission (AMT, iShift) - SNV 19-002 - AMT Oil Filter Housing...

Warranty Automated Manual Transmission ( AMT, I-Shift, mDrive ) Control Housing Assembly; Guidelines For Filing A Claim...

Volvo I-Shift AMT Will Not Calibrate After Incorrect Flywheel Housing Is Installed

Volvo Chassis - Equipped With An I-Shift Automated Manual Transmission ( AMT ) - Flywheel Resurfacing And Reuse...

Automated Manual Transmission (AMT) (Spigot Bearing) Input Shaft Repair Kit And Shim Kit, Part Number Information,...

Automated Manual Transmission Gearbox Will Not Shift To High Range After Gearbox Repair; MID 130 PSID 24 FMI 1, P1072-92...

CBR - Z Spring Bracket Wear.

SC - Volvo Proprietary Fixed Axle Hubcap Replacement.

SC - Volvo Proprietary Steerable Axle Hubcap Replacement

Frame lean can be caused by several seemingly isolated possibilities.

CBR - Volvo Chassis - Enable Air Suspension Gauge Function - US17 And Newer Chassis ONLY

CBR - Driveline Noise, Suspension Ride Height Too High, Suspension Will Not Exhaust - Chassis Built 2016w01 And Newer

Service Campaign: On certain Volvo VN, VHD, VAH chassis, with a Meritor rear carrier, there is a possibility of the rear...

Service Campaign: This Service Campaign is the solution for the Ship Shortage of Proprietary Hubcap Recall SC0425 that...

Service Campaign: This Service Campaign is the solution for the Proprietary Hubcap Recall SC0425 that effected Volvo VAH, VHD, VN, VNE Models.

CBR - Vehicles Equipped With Chalmers Suspension - Frame Bracket Hardware Loose or Interfering

Hub Cap, Leaking

Proprietary Steerable Axle Hubcap Replacement

Proprietary Fixed Axle Hubcap Replacement

Proprietary Fixed Axle Hubcap Replacement

Volvo Chassis US13 And Up Enable " Air Suspension Pressure Gauge " In The Cluster

1-Piece Hub Covers

Volvo Chassis - Stemco Hubcap Plug Will Not Stay In

CBR - US17AbstractVolvo Chassis equipped with Volvo Active Driver Assist may display DTC / Fault code SPN 516103 FMI 19...

CBR: Chassis Equipped With VECU5 Active Datalink/Communication Faults For Multiple Modules; ABS And SRS Communication...

CBR - Active "Set Park Brake" Message On Drivers Information Display (DID)

CBR: Volvo On-Highway Vehicles - Bendix ABS Fault SPN 807 FMI 13 Blink code 19-4.

(Back Office Only) Volvo Chassis - Enable Parking Brake Alarm, Parameters - US17 And Newer ( INT-GEN2 )

DTC U012100 - Lost Communication With Anti-Lock Brake System (ABS) Control Module, No Additional Information

B/O Volvo Park Brake warning POPup displays in DID when Park Brake is released and driver door is open Model Year 2018...

Volvo Chassis - Bendix ABS6 TO ABS8 Service Information

(Back Office Only) Volvo Chassis - VN Model - Front Brake Squeal - US14 And Newer

Volvo Chassis - FSB 761-002, Shock Absorber, Inspection

Brake Hose Routing Bracket, Installation

Disc Brake Rotor, Replacement

Remote Control Central Door Lock, Programming; Key Fob Cannot Be Programmed Or Does Not Work After Programming - Model...

TSB - Due to cracking in the step area of the fairing, an updated support bracket has been introduced.

This CBR solution provides a step-by-step procedure for using longer Hood Tilt Switch mount screws and additional...

This CBR solution provides a step-by-step procedure to replace the hood tilt switch on Volvo Autohauler (VAH) and Volvo...

Hood Cable Breaking or Binding

CBR - Volvo Chassis - Hood Release Cable Binding Or Broken

Hood Cable Breaking or Binding

Volvo Chassis - Water leaking Around The Windshield - Model Year 2018 and Newer

CBR - Troubleshooting cab lean should only begin after completing a vehicle preparation procedure to ensure all...

CBR: On a Volvo Chassis - US16 - with the Bendix Lane Departure Warning System ( LDW )the alarm would not cancel once...

Service Campaign: VAH/VHD Heated Headlights

On certain Volvo VN, VHD, VAH chassis, with a Meritor rear carrier, there is a possibility of the rear differentials...

Volvo Complimentary Factory Scheduled Maintenance.

TSB-Charge Air Cooler t-clamp install.

Volvo Chassis - Diagnostic Trouble Code ( DTC ) P0420 Illuminating The Malfunction Indicator Lamp (MIL)

Volvo Chassis - Bendix Lane Departure Warning System ( LDWS ) Audible Alarm Does Not Deactivate When The Turn Signal Is...

Service Campaign: TGW3 Non-Communication

CBR - Accelerator Pedal: Inspection/Instructions

Service Literature Published and Released in May, 2023

Service Literature Published and Released in November, 2022

Volvo Chassis - Drag Link Inspection And Replacement Criteria

Volvo Chassis - Dealer Support Communication - Selecting The Proper SR Area For Creating An eService

Volvo SNV14-035 When And How To Contact Tech Support ( eService & Phone )

This CBR solution addresses the issue of binding between the outer air filter housing and inner HVAC box due to...

CBR - Volvo Chassis - HVAC Fresh Air Door Binding

CBR: It may be possible for Bergstrom controlled Eberspacher Espar parking heaters to ignite and burn for 5 min and...

Service Campaign: Volvo trucks has determined that certain VN and VHD model trucks built with TGW3 have stopped communicating after production.

Volvo SNV15-008 Vocom Adapter ( 88890300 ) May Lock Up When Updating Firmware

Ghost DTC after software download, FLC2-C100154.

Flywheel Housing Thread Repair

TPMS (Tire Pressure Monitoring System) not available