2013 Volvo Vhd TSBs
220 Technical Service Bulletins across 15 categories
Categories
Engine
48 bulletinsInactive Code P25AE00 Being Generated After A Hard Pull And A Momentary Drop In Engine Oil Pressure (Low Oil Pressure)...
Read full bulletin
(Possible Related Codes - SPN4811 , SPN 100 , PID 100)
TSB - V-710-001 Engine Crossmember Loose Hardware.
CBR - 11L, 13L, And 16L Engine Oil Analysis Specifications - US10 And Newer Emissions
CBR - Automated Manual Transmission (AMT) Model D or F (mDrive and I-Shift, AMT-D, AMT-F) - Transmission Oil Leakage...
Read full bulletin
From Transmission Input Shaft Seal Or Output Shaft Seal - US10 And Newer Emissions, Common Model Years 2010 And Newer
CBR: 11L, 13L, And 16L Engine Oil Analysis Specifications - US10 And Newer Emissions
CBR - 11 Liter Engines - Fuel In Oil.
CBR: 11L Engine - Air Conditioner (A/C) Line Damaged At Bracket - Model Year 2007 to Present.
Barksdale Leveling Valve, Leak Test
CBR: Programming Failure - Chassis With Cummins Engine And An Allison Transmission
CBR: 11L Engines, Non-Common Rail - Air Compressor Coolant Pipe, Parts Substitution - US14+OBD13 To US14+OBD16
CBR: Volvo VHD Models - Allison Reduced Engine Load At A Stop (RELS) Diagnostic Trouble Code P071A Or P07CE - Non-Split/Drop Box PTO.
Read full bulletin
VHD chassis may experience Diagnostic Trouble Code P071A or P07CE along with symptoms of no reduced engine load (RELS) when coming to a stop and/or the transmission going into 4th gear lock up when applying the service brake.
Volvo Chassis - Electronically Controlled Air Dryer System (ECADS) Building Too Much Air Pressure; Pressure Relief Valve...
Read full bulletin
Opening
Engine Control Module (EMS) Software (MSW) Information August 2022; Improvement List (Change Log) - US21+OBD22 (13L...
Read full bulletin
VGT, TC) And US17+OBD22 (11L) Emissions
Programming Failure - Chassis With Cummins Engine And An Allison Transmission
US10 Emission Engines - Diagnostic Trouble Code ( DTC ) SPN 1231 FMI 9 Troubleshooting
Vehicles Equipped With An Automated Manual Transmission Model D or F ( AMT-D, AMT-F ) - Transmission Oil Leakage From...
Read full bulletin
Transmission Input Shaft Seal Or Output Shaft Seal - US10 And Newer Emissions, Common Model Years 2010 And Newer
Volvo Chassis - Automated Manual Transmission Model F (AMT-F, I-Shift) - Possible Infrequent Hiccup/Stumble During...
Read full bulletin
Steady Engine/Vehicle Speed; Diagnostic Trouble Code P1074-92, P1074-94, P1074-96 Logging, Appears As Inactive
Volvo Chassis - Equipped With An I-Shift Automatic Manual Transmission ( AMT ) And D16 ( 16L ) Engine - Technical...
Read full bulletin
Service Bulletin V-216-001 Twin Mass Flywheel Conversion
Volvo Chassis - Coolant Leak Test - Dye Information
Volvo Chassis - Approved Engine Oil For Volvo Engines, Factory Fill Oil Information - US07 And Newer Emissions, Model...
Read full bulletin
Year 2008 And Newer
Cylinder Head Reuse And Replacement Guidelines - Inspection And Information - US04 And Newer Emissions, Commonly 2007...
Read full bulletin
And Newer Model Years
On some VOLVO VHD, VN, VT, and VAH truck models built between 04/31/2008 and 11/30/2015, the solenoid valve for the Hill...
Read full bulletin
Start Assist feature is prone to internal contamination in harsh environments. The internal contamination of the solenoid valve is caused by the buildup of grime, salt, road debris and other solid contaminants. In some cases, the buildup of solid contaminants caused the solenoid valve to malfunction. A similar malfunction is possible if the solenoid valve is equipped with a vent fitting that freezes over. The malfunction causes the trailer brake circuit to maintain trailer brake pressure after a grade Hill Start Assist event. Replacement of the existing solenoid valve, elbow, and the addition of a new tube fitting and tube will ensure proper functionality of the Hill Start Assist feature.
This SKU is a DEF Injector.
Read full bulletin
The customer communication requested return of unsold inventory to inspect the sealing. The injector sealing may have an issue which will cause a slow leak. A slow leak of the DEF Injector can lead to crystal formation which can cause aftertreatment related fault codes and ECU driven engine derating.
Volvo Chassis - Discharge Recirculation Valve (DRV) - FSB 258-029 , Engine Turbocharger Compressor Bypass Valve...
Read full bulletin
Deletion Kit , Installation
Volvo Chassis - SNV 15-016 Documented Process For Engine Oil Consumption - All Emissions, All Model Years
US07 / US10 D13 Turbocharger Gasket
Volvo Chassis - SNV16-007 Telematics Gateway ( TGW ) Goes Offline Due To VIN Mismatch When Test Engine ECU Is Installed
Volvo Chassis - Equipped With An Automated Manual Transmission Model D or F ( I-Shift, AMT-D, AMT-F ) - Transmission Oil...
Read full bulletin
Leakage From Transmission Input Shaft Seal Or Output Shaft Seal - US10 And Newer Emissions, Common Model Years 2010 And Newer
Automated Manual Transmission ( AMT - F ) ( I-Shift) Clutch Valve Unit ( CVU ) Makes Intermittent Buzzing Noise With The...
Read full bulletin
Key On And Engine OffChanged repair information to reflect new software available.
Engine Diagnostic Trouble Codes ( DTC's ) P24A0 And P249F Lighting The Malfunction Indicator Lamp ( MIL ) - OBD15...
Read full bulletin
(Commonly Model Year 2016) And NewerUpdated to reflect release of FSB284-064 (Above)
In the event that an EGR temperature sensor replacement is required on a VOLVO D13H engine, a new routing configuration...
Read full bulletin
is required.
Engine Control Module (ECM) Software Update
Engine Data Label
Exhaust Gas Recirculation (EGR) Valve Oil Supply Line, updated part
Engine Brake Loss
VOLVO VN, VHD, VAH, and VT trucks built from 2009 to 2017 and equipped with 11, 13, and 16 liter engines (EM-USA10,...
Read full bulletin
EM-USA14, and EM-USA17), will require a new torque specification for the Unit Injector Yoke Hold-Down Bolt.
VOLVO VN, VHD, VAH, and VT trucks built from 2009 to 2017 and equipped with 11, 13, and 16 liter engines (EM-USA10,...
Read full bulletin
EM-USA14, and EM-USA17), will require a new torque specification for the Unit Injector Yoke Hold-Down Bolt. Effective immediately, the torque value in step 3 has changed to 25 +5/-0 Nm (18 +4/-0 ft-lb).
VOLVO VN, VHD, VAH, and VT trucks built from 2009 to 2017 and equipped with 11, 13, and 16 liter engines (EM-USA10,...
Read full bulletin
EM-USA14, and EM-USA17), will require a new torque specification for the Unit Injector Yoke Hold-Down Bolt. Effective immediately, the torque value in step 4 has changed to 25 +5/-0 Nm (18 +4/-0 ft-lb).
In some instances the exhaust rocker piston cap screw may become loose and back out causing loss of engine compression,...
Read full bulletin
or a mechanical injector Diagnostic Trouble Code (DTC).
VOLVO TRUCK: SOME TRUCKS WILL EXPERIENCE PREMIUM TECH TOOL (PTT) 38 ERROR CODE AND SHOULD CHECK ENGINE ECU SOFTWARE...
Read full bulletin
BEFORE ANY TROUBLESHOOTING, IF ECU SOFTWARE HAS LESS NUMBER REFERENCED, THEN ECU AND AFTERTREATMENT CONTROL MODULE (ACM) SHOULD BE REPROGRAMMED. NEW LOGIC ASSOCIATED WITH SOFTWARE ALLOWS REGENERATION TEMPERATURES REACH MAXIMUM LEVEL. MODEL 2013-15 VAH, VHD, VN. *PE
VOLVO TRUCK: DUE TO INTERNAL BUILD UP CONTAMINATION OF GRIME, SALT, ROAD DEBRIS, IN HARSH ENVIRONMENTS, CAUSES SOLENOID...
Read full bulletin
VALVE TO MALFUNCTION AND TRAILER BRAKE CIRCUIT TO MAINTAIN TRAILER BRAKE PRESSURE AFTER HILL START ASSIST EVENT. MODEL VHD, VN, VT, VAH. *PE
VOLVO TRUCK: THE ENGINE CONTROL MODULE (ECM) HAS SOFTWARE UPDATES WITH ENHANCEMENTS, AVAILABLE, TO ADDRESS COLD START...
Read full bulletin
TIME, PISTON COOLING JET (PCJ), REGENERATIONS IN COLD CLIMATES. MODEL VAH, VHD, VN. *PE
VOLVO TRUCKS: ON SOME TRUCKS, THE HDMS FAN DRIVE WAS REDESIGNED, DUE TO HDMS COOL LOGIC ENGINE COOLING FAN DRIVE WAS...
Read full bulletin
LEAKING FLUID FROM REAR OF DRIVE, WITH IMPROVEMENTS OF SEALING AND OVERALL DURABILITY OF DRIVE, MODEL 2013 VAH, VHD, VN. *PE
VOLVO: THERE ARE ENHANCEMENTS TO SOFTWARE UPDATES FOR ENGINE CONTROL MODULE (ECM) AND AFTERTREATMENT CONTROL MODULE...
Read full bulletin
(ACM) TO RESOLVE DIAGNOSTIC TROUBLESHOOTING CODES P1086, P0420, P205B, P2002. MODEL 2013 VAH, VHD, VN. *PE UPDATED 2/28/2014 *JS
VOLVO: SOFTWARE UPDATES BEING PROVIDED FOR ENHANCEMENT OF THE ENGINE CONTROL MODULE (ECM) AND AFTERTREATMENT CONTROL...
Read full bulletin
MODULE (ACM) FOR SOME TRUCKS BUILT 5/11/13 TO 10/2/13. MODELS VAH, VHD, VN. *PE UPDATED 2/28/2014 *JS
VOLVO: ON SOME TRUCKS, THERE IS AN OIL CONTAMINATION INTO THE ENGINE WIRE HARNESS BECAUSE OF A FAILURE OF THE OIL LEVEL SENSOR.
Read full bulletin
MODELS VAH, VHD, VN, VT. NO MODEL YEARS LISTED. *PE
VOLVO TRUCKS: INFORMATION REGARDING THE BREAKING OR CRACKING OF 90 DEGREE POSITIVE BATTERY ABLE LUG AT STARTER SOLENOID...
Read full bulletin
STUD; AT TIME OF ASSEMBLY, THE LUG WAS BENT AND ENGINE VIBRATES, CAUSING TERMINATION OF TERMINAL TO WEAKEN AND FAIL. MODELS VN, VHD. NO MODEL YEARS LISTED. *PE UPDATED 1/24/2014 *JS
VOLVO: SOFTWARE UPDATE.
Read full bulletin
ENHANCEMENTS ON THE SOFTWARE UPDATE FOR THE ENGINE CONTROL MODULE (ECM), INSTRUMENT CLUSTER (IC), VEHICLE ELECTRONIC CONTROL UNIT (VECU), AFTERTREATMENT CONTROL MODULE (ACM), AND TRANSMISSION ELECTRONIC CONTROL UNIT (TECU). *KB
Other
36 bulletinsCBR - A significant GPS reporting issue is affecting fleet operations, with trucks maintaining back-office communication...
Read full bulletin
but failing to transmit GPS location data.
CBR - Volvo Chassis - No-Crank Issue After Programming
CBR: Telematics Gateway (TGW) Connect Ability Issues
CBR - Telematics Gateway (TGW) Connect Ability Issues.
CBR: TGW Will Not Connect After SIM Card Replacement
CBR: Diagnostic Trouble Code (DTC) P215A-64, Fault Code SPN 84 FMI 19
Keyless Drive receiver issues
Expendable Items Parts List.
Part information for AMT input shaft repair kits and the shim kit that is required for repair.
AMT Control Housing Bench Testing - False Failures
Mack Chassis - Data Link Diagnostics - Diagnostic Trouble Codes ( DTC ) / Fault Codes From Multiple Components - Unable...
Read full bulletin
To Connect To Chassis, Programming Failure With Premium Tech Tool ( PTT ) Errors - Troubleshooting And Oscilloscope Instructions
The Diagnostic Process
Volvo Fault Code MID 144 PSID 204 FMI 9
Volvo Chassis Ghost Codes Due To Poor Grounding
Volvo Chassis - PTO Pump Speed Calculator
(Back Office Only) Volvo Chassis Loss Of Cruise Control After Disabling Electronic Stability Program (ESP)
VIDA QR Scanner Mobile App
Volvo Monthly Bulletin Release Letter - Feb 2022
Volvo Chassis US13 And Up Pre-trip Assistant Enable
Volvo Chassis - Driveline (Driveshaft, Propeller Shaft) Ride Height And Angle, Measurement And Calculation; Pinion Angle...
Read full bulletin
Measurement - Model Year 1996 And Newer
Volvo Chassis - Performance Bonus OBD13 And Newer
Volvo Chassis - Volvo Fusion 2 Collision Warning System Information
Diagnostic Trouble Code (DTC) P215A-64, Fault Code SPN 84 FMI 19; Speedometer Drop-Out, Speedometer Inoperative
Volvo Chassis - Vehicle with Diagnostic Trouble Code (DTC) P2002-00, Diagnostic Instructions - US10+OBD13 Emssions ONLY,...
Read full bulletin
Model Years 2013 (Rare), 2014
On some trucks with the Telematics Gateway (TGW) system, the TGW control unit may not correctly communicate with the...
Read full bulletin
vehicle systems after restarting.
Hill Start Assist Solenoid, Replacement
Oil Filter Housing
Hill Start Assist Solenoid, Replacement
AMT High Range Cone Replacement
Oil Filter Housing
High Soot Output
Timing Plate Flange Screw
Hill Start Assist Solenoid, Replacement
Range Synchronizer, Repair
Hill Start Assist Solenoid, Replacement
DIAGNOSTIC TROUBLE CODES (DTCS), LOW OIL PRESSURE, VAH, VHD, VN
Fuel System
32 bulletinsCBR - Volvo Selective Catalytic Reduction (SCR) Muffler Troubleshooting Guide - US10+OBD13 And Newer Emissions
Volvo DEF Pump Troubleshooting Guide - US10+OBD13 And Newer Emissions
Back Office - Diagnostic / Troubleshooting Procedures For Exhaust Gas Recirculation (EGR) System Components; Covers Most...
Read full bulletin
EGR System Diagnostic Trouble Codes (DTC), See List In Solution - US10, US10+OBD13, US14+OBD*, US17+OBD* With A Variable Geometry
Diesel Particulate Filter (DPF) And Diesel Oxidation Catalyst (DOC) Pin Testing Procedure - US07 And Newer Emissions,...
Read full bulletin
Model Year 2008 And Newer.
Selective Catalytic Reduction (SCR) Muffler Troubleshooting Guide - US10+OBD13 And Newer Emissions
DEF Pump Troubleshooting Guide - US10+OBD13 And Newer Emissions
Diesel Particulate Filter (DPF) And Diesel Oxidation Catalyst (DOC) Pin Testing Procedure - US07 And Newer Emissions,...
Read full bulletin
Model Year 2008 And Newer
Premium Tech Tool (PTT) - Message For Data Mismatch, Product Configuration Mismatch; Instruction To Run An Accessory Kit...
Read full bulletin
Displayed When Attempting To Run Diagnostics For Diagnostic Trouble Codes (DTC) Or Programming - US10+OBD13 And Newer Emissions,
Electronic Stability Program (ESP), Electronic Stability Control (ESC): Changes And Removal Information; Permissible PAR...
Read full bulletin
File Changes - US07 And Newer Emissions, Model Year 2008 And Newer
Back Office - Diagnostic / Troubleshooting Procedures For Exhaust Gas Recirculation (EGR) System Components; Covers Most...
Read full bulletin
EGR System Diagnostic Trouble Codes (DTC), See List In Solution - US10, US10+OBD13, US14+OBD*, US17+OBD* With A Variable Geometry
Fuel Level Gauge Reading Incorrect In The Instrument Cluster
Volvo Chassis - Fuel Level Gauge Slow To Respond To Changes In Fuel Level
Volvo Chassis - Fuel Level Sending Unit Specification Information
(Back Office Only) Volvo Chassis - Equipped With A Catalyzed Exhaust Aftertreatment System ( EATS ) - Regeneration (...
Read full bulletin
Regen ) Failure Diagnostic Process - US07 to US16 Emissions
DEF Pump Troubleshooting Guide - US10+OBD13 And Newer Emissions
Selective Catalytic Reduction (SCR) Muffler Troubleshooting Guide - US10+OBD13 And Newer Emissions
Aftertreatment Hydrocarbon Injector (AHI) Troubleshooting Guide - US10+OBD13 And Newer Emissions
(Back Office Only) Volvo Chassis - Equipped With A Catalyzed Exhaust Aftertreatment System ( EATS ) - Regeneration (...
Read full bulletin
Regen ) Failure Diagnostic Process - US07 to US16 Emissions
Volvo Chassis - US10 to US16 Emissions - Soot Level Will Not Reset After Regen Or Locked At 140%
Grounding Bus Bar (Cloverleaf, Grounding Star, Four Point Ground Stud) On Frame Rail; Inspection To Be Performed For...
Read full bulletin
Power And Ground, Data Link DTCs - US10 And Newer Emissions, Model Year 2011 And Newer
Diesel Fuel Information - Acceptable Biodiesel, Fuel Blend For Summer And Winter - US07 And Newer Emissions, Model Year...
Read full bulletin
2008 And Newer
Correct Aftermarket Installation Of Permanent Electronic Log Devices ( ELD )( Qualcomm, PeopleNet, Omnitracs, GPS,...
Read full bulletin
Location Tracker, Etc.) RP1226 connection On The Data Link; Installation Instructions And Information For Third Party ( Aftermarket ) Devices Connected To The Data Link - US17+OBD16 And Newer Emissions, Models Built up to Week 37 (9/13) 2019.
Diagnostic Trouble Code ( DTC ) P009E - 73 - Fuel Pressure Relief Control Performance / Stuck Off - GHG17 ( US17 )...
Read full bulletin
Chassis With Common Rail Fuel System, Updated to reflect GHG17 software release
Diagnostic Trouble Codes ( DTC ) P208E And P103B Logging With Possible Derate ( SCR Inducement ) - OBD15, US14+OBD16...
Read full bulletin
Emissions And Newer Rewrote test procedure for better clarity.
Volvo Chassis - Diesel Exhaust Fluid ( DEF ) Contamination In Fuel System, Inspection And Repair - US10 to US14 (...
Read full bulletin
Non-Common Rail Fuel System ) Removed information for common rail chassis - now has its own solution.
Diagnostic Trouble Code ( DTC ) P009E - 73 - Fuel Pressure Relief Control Performance / Stuck Off - GHG17 ( US17 )...
Read full bulletin
Chassis With Common Rail Fuel SystemChanged repair instructions to reflect new procedures
Service Only Regen Requested With No Warning.
Read full bulletin
Active Fault Codes P24A4 / P10FE - OBD15 And OBD16 Chassis; Does Not Apply To US17 (Common Rail Fuel System) ChassisUpdated to reflect release of FSB284-064 (Above)
Diagnostic Trouble Codes ( DTC ) P208E And P103B Logging With Possible Derate (SCR Inducement ) - US13 Emissions And...
Read full bulletin
Newer
Dual Fuel Tanks Ventilation Filter Kit
Single Fuel Tank Ventilation Filter Kit
EGR Mass Flow Rate Low, diagnostic trouble code
VOLVO: ON SOME TRUCKS, THERE IS AN INTERFERENCE WITH THE FUEL LEVEL SENDING UNIT FLOAT.
Read full bulletin
MODEL 2014 VN, VHD, VAH. *PE
Electrical
30 bulletinsAftertreatment Diesel Exhaust Fluid (DEF) Tank, Level Sensor, Replacement
Aftertreatment Diesel Exhaust Fluid (DEF) Tank, Level Sensor, Replacement
CBR - Volvo NOx Sensor Troubleshooting Guide - US10+OBD13 And Newer Emissions
CBR - Volvo NOx Sensor Troubleshooting Guide - US10+OBD13 And Newer Emissions
CBR: Volvo NOx Sensor Troubleshooting Guide - US10+OBD13 And Newer Emissions.
Read full bulletin
The primary failure mode the NOx Sensors is internal failure, which will generate a sensor specific fault code.
DEF Level (UQLS) Sensor Troubleshooting Guide - US17+OBD16 Emissions and Newer
NOx Sensor Troubleshooting Guide - US10+OBD13 And Newer Emissions
(Back Office) - Cruise Control Inoperative After Updating Software VECU5 Without ESP Package (UESP)
Temperature Sensor Troubleshooting Guide - US10+OBD13 And Newer
Unable To Retrieve "On Request" Messages For PeopleNet Or Omnitracs Modules Installed On The DL5 Data Link; Third Party...
Read full bulletin
Electronic Log Device Not Reporting Certain Data
Particulate Matter (PM) Sensor Troubleshooting Guide - US14+OBD16 And Newer Emissions
DEF Level (UQLS) Sensor Troubleshooting Guide - US17+OBD16 Emissions and Newer
Shipping and Handling of Volvo Lithium-ion 48V Mild Hybrid Battery to Global Battery Solutions (GBS)
Volvo Chassis - SNV 14-026 P111C Compressor Discharge Temperature Sensor
Volvo Chassis - Rain Sensor Bracket Removal And Installation Procedure when Using An Aftermarket Windshield
Exhaust Gas Recirculation (EGR) System - Fault Codes SPN 412 FMI 0,2,5; Diagnostic Trouble Codes (DTC) P040A, P040B,...
Read full bulletin
P1121 - Temperature Sensor Inspection
ECM and ACM Reprogramming, OBD2015
Diagnostic Trouble Code ( DTC ) P0194 - 00 - Fuel Rail Pressure Sensor ( RPS ), Circuit Erratic, Intermittent - US17 (...
Read full bulletin
GHG17 ) Emissions And Newer ( Common Rail Fuel System ); Common Model Years 2017 And 2018Changed repair instructions to reflect new procedures
Exhaust Gas Recirculation (EGR) Differential Pressure Sensor
Vehicle Speed Sensor, fault codes
Seat Harness Routing (Swivel) wires pulling away from clipping points
Seat Harness Routing (Non-Swivel) wires pulling away from clipping points
Battery Cable, Routing
Oil Level Sensor Harness Wire Splice
Battery Cable Lug, Failure
Charging System Voltage
Battery Cable Mounting Clamps
Jumper Harness, Repair
VOLVO TRUCKS: ON CERTAIN TRUCKS, AN IMPROVEMENT CHANGE WAS MADE, FOR PROTECTION OF STACKABLE BATTERY BOX, FROM...
Read full bulletin
ENVIRONMENT, OF PREMATURE CORROSION CONDITION OF TERMINALS, CABLES, AND CONNECTIONS WITHIN. MODEL 2010-2013 VHD. *PE
VOLVO TRUCK: ON SOME TRUCKS, DUE TO A POSSIBLE REPLACEMENT OF EGR TEMPERATURE SENSOR, A NEW CONFIGURATION ROUTING...
Read full bulletin
REQUIRES THREE DOUBLE LOOP CABLE TIES TO SECURE EGR TEMPERATURE SENSOR CONNECTOR DIRECTLY TO COOLANT PIPE. MODELS VAH, VHD, VN, D13H. NO MODEL YEARS. *PE
Transmission
25 bulletinsCBR: On Volvo chassis with an I-Shift and Mack chassis with an mDRIVE transmission, there have been reports of complete...
Read full bulletin
shift assemblies and TECUs being replaced due to technicians being unable to pinpoint the source of the air leak.
CBR - Automated Manual Transmission ( AMT ) Flywheel Pilot Bearing Wear On Input Shaft.
CBR: Automated Manual Transmission ( AMT ) - Transmission Electronic Control Unit ( TECU ) MID130 PSID 29 FMI 7 /...
Read full bulletin
P10AE81 Fault Codes Being Generated
CBR: Automated Manual Transmission (AMT) Transmission Kickdown Mode
CBR: Volvo Chassis - Timing Gear Plate Repair.
Read full bulletin
This solution provides supplementary information to be used when installing a Timing Gear Plate with Integrated Seal.
Volvo Chassis - Equipped With An Automated Manual Transmission (AMT-C, AMT-D, I-Shift) - - Unable To Program...
Read full bulletin
Transmission Electronic Control Unit (TECU) That Comes With A Reman Transmission - US07 TO US14 OBD13
Volvo Chassis - ( AMT, I-Shift ) - Transmission Grinding When Downshifting ; Range Synchronizer (Synchro) Timing...
Read full bulletin
Procedure - US07 And Newer
Volvo Chassis - Equipped with An Automated Manual Transmission (AMT, iShift) - SNV 19-002 - AMT Oil Filter Housing...
Read full bulletin
Corrosion
Warranty Automated Manual Transmission ( AMT, I-Shift, mDrive ) Control Housing Assembly; Guidelines For Filing A Claim...
Read full bulletin
For Chassis Return Visit With Transmission Issues After A Repair Requiring Control Housing Removal And Reinstallation - US07 And Newer
Volvo I-Shift AMT Will Not Calibrate After Incorrect Flywheel Housing Is Installed
Volvo Chassis - Diagnostic Trouble Codes ( DTC's ) - MID130 PID160 FMI1 Or FMI2 - For The I-Shift Transmission
Volvo Chassis - Equipped With An I-Shift Automated Manual Transmission ( AMT ) - Flywheel Resurfacing And Reuse...
Read full bulletin
Guidelines
Volvo Chassis - Equipped With An Automated Manual Transmission ( AMT, I-Shift ) - Reverse / Back-Up Lights Inoperative,...
Read full bulletin
No Diagnostic Trouble Codes (DTC), No Issues With Circuit, Additional Check - US10 And US13 Emissions, Model Years 2011 To 2014
Automated Manual Transmission (AMT) (Spigot Bearing) Input Shaft Repair Kit And Shim Kit, Part Number Information,...
Read full bulletin
Reference Guide - US07 And Newer Emissions, Model Year 2008 And Newer
Automated Manual Transmission Gearbox Will Not Shift To High Range After Gearbox Repair; MID 130 PSID 24 FMI 1, P1072-92...
Read full bulletin
Unintentional Disengagement Of High Range - US07 And Newer Emissions, Model Year 2008 And Newer
Automated Manual Transmission (AMT) Faults - Diagnostic Trouble Codes (DTC) P1052-18 Or MID 130 PID 33 FMI 5...
Read full bulletin
Intermittent Fault In Cold Weather - US07 And Newer Emissions, Model Year 2008 And Newer
Volvo Chassis - Equipped With An Automated Manual Transmission ( AMT, I-Shift ) - Reverse / Back-Up Lights Inoperative,...
Read full bulletin
No Diagnostic Trouble Codes (DTC), No Issues With Circuit, Additional Check - US10 And US13 Emissions, Commonly Model Years 2011 To 2014
Volvo Chassis - Equipped With An Automated Manual Transmission (AMT, I-Shift ) - Error Code 126 Displayed In Premium...
Read full bulletin
Tech Tool (PTT ) While Performing The Calibration Procedure After The Shift Control Housing Has Been Removed And Installed, Rewritten to improve return from multiple search terms.
Flywheel Resurfacing Guidelines, I-Shift
Transmission ECU Programming
Transmission Control Module, Programming
Transmission ECU Compatibility
Some Volvo trucks equipped with iShift transmissions built between January 15, 2007 and August 14, 2017 may have PTO...
Read full bulletin
solenoid bracket or transmission harness connector failures due to excessive vibration.
VOLVO TRUCK: PROCEDURAL INFORMATION REGARDING THE REPLACEMENT OF HIGH RANGE CONE IN THE SECTION OF THE AUTOMATED MANUAL TRANSMISSION (AMT).
Read full bulletin
MODEL VN, VHD, VAH, VT. *PE UPDATED 8/8/14. *PE
VOLVO TRUCK: ON SOME TRUCKS, DUE TO LOSS OF CALIBRATION AND ABILITY TO ENABLE SINGLE PTO FUNCTIONALITY, SOFTWARE...
Read full bulletin
UPDATES ARE AVAILABLE TO ENHANCE TRANSMISSION ELECTRONIC CONTROL UNIT (TECU). MODELS OBD2013, D11H, D13H, D16H, VHD, VN. MODEL YEARS NOT LISTED. *PE
Brakes
14 bulletinsCBR - Active "Set Park Brake" Message On Drivers Information Display (DID)
CBR: Volvo On-Highway Vehicles - Bendix ABS Fault SPN 807 FMI 13 Blink code 19-4.
Read full bulletin
The new Central Pressure Control (CPC) system has changed the way that the ABS chuff test is performed.
DTC U012100 - Lost Communication With Anti-Lock Brake System (ABS) Control Module, No Additional Information
Volvo Chassis - Bendix ABS6 TO ABS8 Service Information
Volvo Chassis - FSB 761-002, Shock Absorber, Inspection
Volvo Chassis - Air Brake System Schematics And Routing VN, VHD Version 2, VT From Build Date 11.2011
VOLVO: BRAKE SHOE IS PROTRUDING BEYOND BRAKE DRUM AND CAN BE RESOLVED BY REPLACING AND INSTALLING 152 MM (6.0 IN) BRAKE...
Read full bulletin
SHOES, DUST SHIELDS, NEW 178 MM (7.0 IN) BRAKE DRUMS WITH NEW Z BRACKETS. MODEL 2011-2014 VN, VHD, VAH. *PE
VOLVO: THE MERITOR OR BENDIX BRAKE SHOES ARE SHOWING SIGNS OF BRAKE SHOE PROTRUSION BEYOND BRAKE DRUM AND CAN BE...
Read full bulletin
RESOLVED BY REPLACING BRAKE SHOES (152 MM (6.0 IN) AND WIDE BRAKE DRUMS (178 MM (7.0 IN.)) MODEL 2011-2014 VN, VHD, VAH. *PE
VOLVO: BRAKE SHOE IS PROTRUDING BEYOND BRAKE DRUM AND IS CORRECTED BY REPLACING/INSTALLING NEW 152 MM (6.0 IN) BRAKE...
Read full bulletin
SHOES, DUST SHIELDS, NEW 178 MM (7.0 IN) WIDE BRAKE DRUMS. MODEL 2011-2014 VN, VHD, VAH. *PE
VOLVO: REPLACEMENT OF BRAKE SHOES THAT SHOWS BRAKE SHOE PROTRUSION BEYOND BRAKE DRUM.
Read full bulletin
MODEL 2011-2014 VN, VHD, VAH. *PE
VOLVO: TO RESOLVE CONDITION OF BRAKE SHOES, SHOWING SIGNS OF PROTRUSION OF BRAKE SHOE BEYOND BRAKE DRUM, BY INSTALLING...
Read full bulletin
NEW DUST SHIELDS, WIDE BRAKE DRUMS (178 MM) (7.0) AND BRAKE SHOES (152 MM) (6.0). MODEL 2011-2014 VAH, VHD, VN. *PE
VOLVO: SOME TRUCKS SHOW SIGNS OF BRAKE SHOE PROTRUSION BEYOND BRAKE DRUM AND NEED REPLACING.
Read full bulletin
MODEL 2011-2014 VN, VHD, VAH. *PE
VOLVO: ON SOME TRUCKS, AIR DISC BRAKE MAY EXPERIENCE A CONDITION OF THERMAL OVERLOAD.
Read full bulletin
THERMAL OVERLOAD REDUCES RUNNING CLEARANCE BETWEEN PAD AND ROTOR BELOW DESIRED LEVEL WHICH IS AN OVER ADJUSTMENT OF NORMAL PAD WEAR COMPENSATION. MODEL VAH, VHD, VN. NO YEARS LISTED. *PE
VOLVO: THE AIR DISC BRAKE, ON SOME TRUCKS, MAY EXPERIENCE THERMAL OVERLOAD DUE TO AN OVER ADJUSTMENT OF NORMAL PAD WEAR...
Read full bulletin
COMPENSATION THAT MAINTAINS CLEARANCE RUNNING BETWEEN BRAKE PAD AND ROTOR. MODELS VAH, VHD, VN. NO YEARS LISTED. *PE
Lighting
10 bulletinsTSB-Charge Air Cooler t-clamp install.
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P0420 Illuminating The Malfunction Indicator Lamp (MIL)
Volvo US13, US14, US15,Chassis LED Headlights Conversion Programming Procedure
Volvo Chassis 2008 And Up LED Headlight Conversion Programming Procedure
Volvo Chassis - Exterior Lights - Converting From Incandescent To LED Lamps; Hardware And Software Requirements And...
Read full bulletin
Programming Information - Model Year 2008 Through 2017
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P2459 Lighting The Malfunction Indicator Lamp ( MIL ); Possible Frequent...
Read full bulletin
Regeneration Requests - OBD15 And US14+OBD16 (Non-Common Rail) Chassis, Changed repair instructions to reflect OBD16 software release
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P2459 Lighting The Malfunction Indicator Lamp ( MIL ); Possible Frequent...
Read full bulletin
Regeneration Requests - OBD15 And Newer ChassisUpdated to reflect release of FSB284-064 (Above)
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P226C Intermittently Lighting The Malfunction Indicator Lamp ( MIL ) -...
Read full bulletin
OBD15 And OBD16 Conventional ChassisUpdated to reflect release of FSB284-064 (Above)
Diagnostic Trouble Code ( DTC ) P249C Intermittently Lighting The Malfunction Indicator Lamp ( MIL ) - OBD15 And OBD16,...
Read full bulletin
Model Year ( MY ) 2016 and 2017 ChassisUpdated to reflect release of FSB284-064 (Above)
Diagnostic Trouble Code ( DTC ) P0422 Lighting The Malfunction Indicator Light ( MIL ) - OBD15 And OBD16 Chassis...
Read full bulletin
(Non-Common Rail)Updated to reflect release of FSB284-064 (Above)
Infotainment
6 bulletinsCBR: Volvo VHD & VN Models - Vehicle Wil Not Start, PTO Active Message Displayed In Cluster, PTO Light On When PTO...
Read full bulletin
Switch Is Turned Off
Radio, Replacement (revised from FSB 392-005)
Volvo Chassis - FSB 392 - 004 - Radio, Replacement
Volvo Chassis - Enable The Fault Code, Diagnostic Trouble Code ( DTC ) Screen (Menu) In The Instrument Cluster ( IC,...
Read full bulletin
Dash ); Fault Code Screen (Menu) Missing From Driver Information Display (DID); Read Fault Codes (DTCs) In Cluster
Instrument Cluster Programming - Programming Fails Or Errors Display When Replacing An Instrument Cluster With A Newer...
Read full bulletin
Part Number (Conversion Kit) - US04 To US10 Chassis (9-Pin Diagnostic Connector)
On Volvo Trucks built between October 6, 2008 and August 18, 2014, with a factory installed programmable radio, the old...
Read full bulletin
radio may no longer be available for purchase. To upgrade from a GLAD format radio to a DEA500 format radio follow the following instructions.
Pre-Delivery & Maintenance
5 bulletinsCBR - Accelerator Pedal: Inspection/Instructions
Service Literature Published and Released in May, 2023
Volvo Chassis - Drag Link Inspection And Replacement Criteria
Volvo Chassis - Dealer Support Communication - Selecting The Proper SR Area For Creating An eService
Volvo SNV14-035 When And How To Contact Tech Support ( eService & Phone )
Suspension
4 bulletinsCBR - Vehicles Equipped With Chalmers Suspension - Frame Bracket Hardware Loose or Interfering
Volvo Chassis US13 And Up Enable " Air Suspension Pressure Gauge " In The Cluster
Volvo Chassis - Stemco Hubcap Plug Will Not Stay In
Some VOLVO VN, VHD and VNX trucks built from 09/03/2012 to 07/17/2017, and equipped with the NEWAY ADZ rear suspension...
Read full bulletin
may exhibit cracks in the rear suspension front of bogie or bogie crossmember.
Software & Calibration
4 bulletinsVolvo SNV15-008 Vocom Adapter ( 88890300 ) May Lock Up When Updating Firmware
Volvo Chassis - Diagnostic Trouble Code ( DTC ) P2002, Diagnostic Information - OBD13 And NewerUpdated to reflect...
Read full bulletin
release of FSB284-064 (Above)
Software Update, revise document
VOLVO: DUE TO A BUG IN THE SOFTWARE, IN SOME VEHICLES, THERE WERE MULTIPLE COUNTS OF INACTIVE FAULTS ON ACCELERATOR...
Read full bulletin
PEDAL (STANDARD OR KICKDOWN, ONE OR THE OTHER). MODEL 2013 VN, VHD, VAH. *PE
Body & Paint
3 bulletinsService Door Rust Prevention
Floor Cracks Repair (Front Panel)
VOLVO: ON SOME TRUCKS, AN IMPROPER TORQUE HAS ALLOWED CORROSION INHIBITOR BETWEEN RING TERMINALS OF MAIN GROUND STUD,...
Read full bulletin
LOCATED ON FRAME RAIL, CAUSING INTERMITTENT ISSUES AND DIAGNOSTIC TROUBLE CODES (DTC). MODEL 2010-2014 VAH, VHD, VN. *PE
Tires & Wheels
1 bulletinFlywheel Housing Thread Repair
Hybrid & EV
1 bulletinRegeneration in PTO Mode
Steering
1 bulletinVOLVO: ON SOME VEHICLES, THE STEERING KNUCKLE WOULD HAVE WHEEL HUB DISPLACED AND WOULD TO REPLACE WHEEL HUB.
Read full bulletin
*PE