2022 Volvo V60 TSBs
183 Technical Service Bulletins across 14 categories
Categories
Electrical
39 bulletinsThis is a Technical Journal: VCM Backup Battery Replacement with VCM-U105000.
Read full bulletin
Replace the VCM Backup Battery and download the relevant Software.
This is a Technical Journal: Remote connection, BOMGAR application.
Read full bulletin
Before joining a remote session: Connect a suitable battery maintainer/charger and verify that the battery voltage indicated in VIDA is between 12.5V and 14.9V. Connect to the vehicle over a wired connection using a VOE (Volvo OBD to Ethernet) adapter and perform a NEW vehicle readout.
This is a Technical Journal: Improved 12V battery test in VIDA.
Read full bulletin
Service: Dont charge the battery before the test, jump start the vehicle if needed. Read out the vehicle with VIDA and start the test.
This is a Technical Journal: Remote connection, BOMGAR application.
Read full bulletin
Before joining a remote session: Connect a suitable battery maintainer/charger and verify that the battery voltage indicated in VIDA is between 12.5V and 14.9V. Connect to the vehicle over a wired connection using a VOE (Volvo OBD to Ethernet) adapter and perform a NEW vehicle readout.
This is a Technical Journal: Improved 12V battery test in VIDA.
Read full bulletin
Improved 12V battery test in VIDA
This is a Technical Journal: Improved 12V battery test in VIDA.
Read full bulletin
Improved 12V battery test in VIDA
This is a Technical Journal: VCM Backup Battery Replacement with VCM-U105000.
Read full bulletin
Replace the VCM Backup Battery and download the relevant Software.
This is a Technical Journal: Oxygen Sensor DTCs.
Read full bulletin
Perform a Total Upgrade of the vehicle software.
Volvo Car USA LLC and Volvo Car Canada LTD, on behalf of Volvo Car Corporation, has decided to launch Complimentary...
Read full bulletin
Upgrade C00013 on certain Android-based Infotainment system (iCup) vehicles that have missed three (3) or more consecutive Over-The-Air (OTA) downloads. Complimentary Upgrade C00013 addresses vehicles that are no longer able to receive OTA updates. This Upgrade is necessary to have the correct baseline for future OTA deployments. In order to explain the features and benefits we recommend noting the software level before the download is completed. This will aid in explaining to the customer what improvements have been added since their last software download. To remedy concerned cars, please follow the instructions outlined in TJ 36139.
This is a Technical Journal: SPA/CMA - 12V Battery Testing / Maintenance Guide.
Read full bulletin
After capturing a NEW VIDA readout, conduct the steps in VIDA.
This is a Technical Journal: SPA/CMA - 12V Battery Testing / Maintenance Guide.
Read full bulletin
After capturing a NEW VIDA readout, conduct the steps in VIDA.
This is a Technical Journal: SPA/CMA - 12V Battery Testing / Maintenance Guide.
Read full bulletin
After capturing a NEW VIDA readout, conduct the steps in VIDA.
This is a Technical Journal: VIDA Main battery diagnostic - Prompted to charge battery a second time.
Read full bulletin
Use had held tester.
This is a Technical Journal: SR PHEV Cell Module Replacement.
Read full bulletin
Updated BECM software was released
This is a Technical Journal: PHEV IEM P060700 Control Module Performance DTC.
Read full bulletin
Clear DTCs, road test and then perform a new readout.
Creaking noise from Steering Wheel Module (SWM)
(MY22) VCM: U210909 Back-up Battery - Updated Instruction
This is a Technical Journal: 12V Battery Testing Method
Battery, complete.
Propulsion Message in DIM with BECM DTC
PHEV BECM software released
high-voltage battery cell module in a PHEV.
Service Action A10241 BECM Update.
BECM Update.
Electrical rear axis drive
This is a Quality Bulletin: Service Action A10241: BECM Update: The corrective action is to perform a Total Software...
Read full bulletin
Upgrade
This is a Technical Journal.
Read full bulletin
Recovering control modules stuck in not responding after failed SW download. Connect VIDA to read-out the car. Follow steps outlined in this TJ.
Electrical rear axis drive
Creaking noise from Steering Wheel Module (SWM)
(MY22) VCM: U210909 Back-up Battery - Updated Instruction
PHEV High Voltage Battery Repairs
U210909 Back-up Battery - Updated Instruction
IGM: Inverter Generator Module
BEV High Voltage Battery Replacement
Long Range PHEV BECM DTC P065800
Generator Position Sensor Circuit.
The Deutronic DBL-1200 is an advanced battery maintainer/charger with the flexibility to be updated as products and...
Read full bulletin
repair methods evolve.
Battery Charger/maintainer requirement
Shipping and Handling of Volvo Lithium-ion 48V Mild Hybrid Battery to Global Battery Solutions (GBS)
Other
37 bulletinsThis is a Technical Journal: Text plus 1 .jpg attachment - If remote control key is not detected by the car and shows...
Read full bulletin
message in DIM "Car key not found" or if functions such as lock/unlock are not working, please follow advice for detecting key
This is a Technical Journal.
Read full bulletin
Vehicle type and platform identification.
this a Technical Journal: ASDM = Active Safety Domain Master To prevent unnecessary replacements of ASDM and as a...
Read full bulletin
troubleshooting aid for the Intellisafe system, please follow the advice in Technical Journal
This is a Technical Journal: Vehicle/Connectivity report checklist.
Read full bulletin
To provide timely and high-quality feedback to the appropriate department or factory
This is a Technical Journal: DIM Message and DTC IEM P0A4000.
Read full bulletin
Erase DTC. -Let the vehicle go to "Abandoned mode" - this can take up to 20 minutes. -Perform a new VIDA readout
Convert CARE KEY to normal key
Alleged issues with Intellisafe functionality.
No internet connection and intermittent.
COMPLIMENTARY UPGRADE C00009 DESCRIPTION.
Driver support systems
Rubber cushion
New Information.
Remote Control Key No function
Fresh air hose loose from air filter housing
SiriusXM Tuner Replacement Process
Towbar TRM not responding
Convert CARE KEY to normal key
Google Built In Premium Customer Experience Program
Vehicle type and platform identification
Cannot lock/unlock vehicle with remote control key
Do not swap TCAM?s unless instructed and guided by the Retailer Technical Support team
Call button in the OHC might not be lit
OTA not available for customer
OTA - FAQ for technicians
Product, Safety and Compliance.
Customer Experience Program.
Google Built In Premium Customer Experience Program.
Google Built In Premium Customer Experience Program.
Google Built In Premium Customer Experience Program.
Part information for AMT input shaft repair kits and the shim kit that is required for repair.
Google Built In Premium Customer Experience Program.
Google Built In Premium Customer Experience Program.
ICUP/Google Built-In Diagnostic Operations
VIDA QR Scanner Mobile App
News Letter 70
Convert Care Key to Standard Key.
This is a Technical Journal: Ghost DTC set, VCU1-U210782.
Read full bulletin
does not affect any of the functions in the car.
Software & Calibration
21 bulletinsThis is a TJ - Text Plus 1 .mp4 file - When using the CSD for seat adjustments mode for example lumbar support and seat...
Read full bulletin
Cushing, the visualization does not match the selected part for adjustment. Do not fault trace for this symptom. Advice the customer to use the physical seat mode switch knob. A new improved software is planned to be released during quarter 3 2026.
This is a TJ text only - The purpose of this TJ is to be a master reference list to easily identify any components that are on prior approval.
Read full bulletin
This TJ will be regularily updated as items are added or removed from prior approval. Current items under prior approval are listed in the "Service" section
Volvo Cars USA LLC and Volvo Car Canada LTD on behalf of the Volvo Car Corporation has decided to launch Service Action...
Read full bulletin
S10303 on certain model year 2025 EX90 vehicles. Volvo Car Investigations have identified that there is a pairing issue with the key fob. As a result, there is a possibility that the customers key fob is not paired to the vehicle. The corrective action is to download SP Software. S10303 affects 151 vehicles in the U.S and 5 in Canada.
Volvo Cars USA LLC and Volvo Car Canada LTD on behalf of the Volvo Car Corporation has decided to launch Service Action...
Read full bulletin
S10303 on certain model year 2025 EX90 vehicles. Volvo Car Investigations have identified that there is a pairing issue with the key fob. As a result, there is a possibility that the customers key fob is not paired to the vehicle. The corrective action is to download SP Software. S10303 affects 151 vehicles in the U.S and 5 in Canada.
Information about valid Software partnumbers to order and download Software for "PDS" Pre-Delivery Service
This is a Technical Journal: SENSUS - IHU Software Improvement (Voice Control).
Read full bulletin
software is available in VIDA beginning 2024 week 21.
This is a Technical Journal: Slippery Road alert on DIM.
Read full bulletin
Perform Software download.
P5(SPA)/P6(CMA) Software Download Guide
Updated Chassis Range.
Software Improvements
If the software is older than V2.4, which was released 22w42, perform a software upgrade
Over The Air Software Update (OTA)
Vehicle cannot receive OTA updates
OTA Software check
The corrective action is to perform a Total Upgrade Software download.
The corrective action is to perform a Total Upgrade Software download.
The corrective action is to perform a Total Upgrade Software download.
Vehicle cannot receive OTA updates.
Ghost DTC after software download, FLC2-C100154.
Perform a software upgrade in accordance with TJ 31543.
New Software Products (SP) have been developed to convert a Care Key to a standard key.
Engine
17 bulletinsThis is a Technical Journal: Intermittent knocking noise during acceleration.
Read full bulletin
If the sound corresponds to attached sound file, change front drive shafts to the below part numbers.
This is a Technical Journal: Text plus 2 PDFs and 1 .PNG Oil Consumption test.
Read full bulletin
Perform the test. Follow service procedure Description and Service sections updated to clarify that vehicle reports are not required.
This is a TJ - 1 document plus one attachment of detailed repair instructions - If the Check Engine Light is illuminated...
Read full bulletin
in the DIM and DTC ECM P244A00 is set, please follow the advice under "Service". This TJ is a complement to the fault tracing in VIDA. Please follow the steps below.
This is a TJ - 1 document plus one attachment of detailed repair instructions - If the Check Engine Light is illuminated...
Read full bulletin
in the DIM and DTC ECM P244A00 is set, please follow the advice under "Service". This TJ is a complement to the fault tracing in VIDA. Please follow the steps below.
This is a Technical Journal: Check Engine Light in DIM (BCM2 P25A268 / U003700).
Read full bulletin
Download software.
This is a Technical Journal: Long Range PHEV ERAD Knocking Noise Repair Kit.
Read full bulletin
Install a repair kit.
Creaking noise from right engine pad
PHEV Intermittent Start of the Combustion Engine in Hybrid or Pure Mode
PHEV Intermittent Start of the Combustion Engine in Hybrid
This is a Technical Journal: Check Engine Lamp and Misfire DTC - ECM P030098.
Read full bulletin
Do not replace any parts. Improved software was released in 2023 week 48 (version 2.13.1). If the SW is earlier than 2.13.1 first please perform a total upgrade of the SW according to TJ 31543, then reset the flywheel adaptation according to VIDA.
PHEV Intermittent Start of the Combustion Engine in Hybrid or Pure Mode
PHEV Intermittent Start of the Combustion Engine in Hybrid
Electrical motor sound information
Engine Control Module (EMS) Software Information - Improvement List (Change Log), US21+OBD2020 US21+OBD2021 Emissions...
Read full bulletin
Turbo compound Engines ONLY
Engine Control Module (EMS) Software (MSW) Information August 2022; Improvement List (Change Log) - US21+OBD22 (13L...
Read full bulletin
VGT, TC) And US17+OBD22 (11L) Emissions
Engine Control Module (EMS) Software (MSW) Information August 2022; Improvement List (Change Log) - US21+OBD22 (13L...
Read full bulletin
VGT, TC) And US17+OBD22 (11L) Emissions
Driving, Twin Engine/Propulsion using electric motor not possible.
Infotainment
14 bulletinsThis is a TJ - Text plus two .mov attachments - If the customer is experiencing a frozen Sirius Radio banner, meaning in...
Read full bulletin
the app view the title of the song and station name will stay on the previous selected station; the audio will be for the station that is selected and not what is shown on the screen, follow the advice on this TJ under Service
This is a TJ - Text plus two .mov attachments - If the customer is experiencing a frozen Sirius Radio banner, meaning in...
Read full bulletin
the app view the title of the song and station name will stay on the previous selected station; the audio will be for the station that is selected and not what is shown on the screen, follow the advice on this TJ under Service
This is a TJ If detected during Pre-delivery inspection or if customer complaints of chipped/cracked/distorted...
Read full bulletin
screen/glass within 6 months in service we request more information, follow advise under "Service".
This is a TJ If detected during Pre-delivery inspection or if customer complaints of chipped/cracked/distorted...
Read full bulletin
screen/glass within 6 months in service we request more information, follow advise under "Service".
This is a Technical Journal: Apple CarPlay Not OK - iPhone with USB-C, SENSUS.
Read full bulletin
The 56 kO resistor ensures safe and appropriate power delivery.
No bass function (High Performance Audio)
Poor radio reception and sound (FM)
Media, navigation and communication.
No bass function (High Performance Audio)
Infotainment System Reboots while driving (blank screen)
No bass function (High Performance Audio)
General radio deviations ICUP vehicles
Media, navigation and Communication.
If a customer complains that the SiriusXM satellite radio media source is missing from the vehicle.
Hybrid & EV
14 bulletinsThis is a Technical Journal.
Read full bulletin
If you experience difficulty programming remote keys on Hybrid vehicles, please follow the advise in Technical Journal under service.
This is a Technical Journal: WPC, none or unstable charging.
Read full bulletin
recalibrate the WPC by performing a WPC reload.
WPC (Wireless Phone Charger) charging information
Unnecessary Replacements of BEV and PHEV Charging Cables
Unnecessary Replacements of BEV and PHEV Charging Cables
Unnecessary Replacements of BEV and PHEV Charging Cables
WPC (Wireless Phone Charger) charging information
Unnecessary Replacements of BEV and PHEV Charging Cables
Unnecessary Replacements of BEV and PHEV Charging Cables
Unnecessary Replacements of BEV and PHEV Charging Cables
Disconnect Charging Cable? With No Cable Attached.
Long Range PHEV Message in DIM ?System Check Please Wait?
Inverter E-Machine.
ISGM and charging error DTC?s
Lighting
10 bulletinsThis is a TJ - Text plus 1 PDF attachment - f the headlamp horizontal light aim cannot be adjusted via the set screw, If...
Read full bulletin
the horizontal light aim cannot be adjusted because the cogwheel knob is broken, do not replace the entire headlamp. Instead, use the spare part kit part number 32476677 to replace the affected component, please follow the instructions under "Service".
This is a TJ - text only no attachments - If customer complains of a headlamp error message in DIM, in combination with...
Read full bulletin
any of the DTCs stated below, follow advice under "Service".
This is a TJ Text only no attachments -- If the FLC2 is not responding when attempting to load software, or after a...
Read full bulletin
failed software upgrade, VIDA will report that the FLC2 cannot be unlocked. To resolve this issue, follow the instructions in this TJ under "Service".
This is a Technical Journal: Headlamp condensation inside lens - information/leak test.
Read full bulletin
If the result is not ok (air leak), it is ok to replace the headlamp
This is a Technical Journal: Headlamp condensation inside lens - information/leak test.
Read full bulletin
If the result is not ok (air leak), it is ok to replace the headlamp
This is a Technical Journal: Headlamp condensation inside lens - information/leak test.
Read full bulletin
If the result is not ok (air leak), it is ok to replace the headlamp
This is a Technical Journal: Changed front fog/cornering lights behavior.
Read full bulletin
This logic of the cornering lights is now changed in the cars with software version 3.3.16 or later
This is a Technical Journal: Headlamp condensation inside lens - information/leak test.
Read full bulletin
If the result is not ok (air leak), it is ok to replace the headlamp
This is a Technical Journal: Long Range PHEV ERAD Sound Information.
Read full bulletin
A slight whining sound noticed during electric drive is to be considered normal.
Volvo Complimentary Factory Scheduled Maintenance.
HVAC & Climate
7 bulletinsThis is a Technical Journal: Climate system heating performance (HVCH).
Read full bulletin
Replace HVCH.
Volvo Cars App Remote climate or ERS, not possible
Volvo Cars App Remote climate or ERS, not possible
Climate system heating performance (HVCH)
Volvo Cars App Android, no climate setting button
Climate system heating performance.
Climate system heating performance.
Body & Paint
6 bulletinsThis is a Technical Journal: Panoramic sunroof, sealing strip has a gap
This is a TJ - Text plus 2 jpeg files and 1 mp4 file - If customer complains of the hood being hard to close or "Open...
Read full bulletin
Hood" DIM message, please follow advice under "service". And before replacing any parts, follow the 3 steps in the instructions.
This is a TJ - Text plus 2 jpeg files and 1 mp4 file - If customer complains of the hood being hard to close or "Open...
Read full bulletin
Hood" DIM message, please follow advice under "service". And before replacing any parts, follow the 3 steps in the instructions.
This is a Technical Journal: White patch defect in paint when removed rapgard.
Read full bulletin
Expose vehicle to outside daylight for 48hrs.
Body, cab and interior.
Outer rear view mirror glass incorrect position after reversing.
Brakes
6 bulletinsThis is a Technical Journal: DIM message about parking brake.
Read full bulletin
Manually order and download software part number 32429456
This is a Technical Journal: DIM message about parking brake.
Read full bulletin
Manually order and download software part number 32429456
This is a Technical Journal: DIM message about parking brake.
Read full bulletin
Download the available total upgrade software.
This is a Technical Journal: Vibration/shudder while braking.
Read full bulletin
Replace front brake pads
This is a Technical Journal: DIM message about parking brake.
Read full bulletin
Download the available total upgrade software.
Vibration/shudder while braking
Pre-Delivery & Maintenance
5 bulletinsThis is a Tech Journal - Text only no attachments - If a customer experiences a Propulsion System Performance message in...
Read full bulletin
the DIM with diagnostic trouble code IEM P060700, often in combination with IEM P061A00, please follow the instructions under "Service".
This is a Tech Journal - Text only no attachments - If a customer experiences a Propulsion System Performance message in...
Read full bulletin
the DIM with diagnostic trouble code IEM P060700, often in combination with IEM P061A00, please follow the instructions under "Service".
This is a Tech Journal - Text only no attachments - If a customer experiences a Propulsion System Performance message in...
Read full bulletin
the DIM with diagnostic trouble code IEM P060700, often in combination with IEM P061A00, please follow the instructions under "Service".
Mobile data services, general
This is a Service Manager Bulletin: Retail Car Pre-Delivery Process
Fuel System
5 bulletinsThis is a Technical Journal: AC evaporator repair, additional parts needed.
Read full bulletin
Add resister in line jumper cable.
This is a Technical Journal: AC evaporator repair, additional parts needed.
Read full bulletin
Add resister in line jumper cable.
Incorrect fuel level or tank capacity
Incorrect fuel level or tank capacity
USE FOR NEW VEHICLES (US21+OBD22 Emissions) - Intermittent Diagnostic Trouble Codes U02A3, U029D, U029E
Steering
1 bulletinThis is a Technical Journal: Text plus 1 jpg and 1 mp4 file -- If there is a strange chafing or creaking noise when...
Read full bulletin
turning the steering wheel, follow the advice under Service.
Tires & Wheels
1 bulletinTPMS (Tire Pressure Monitoring System) not available