2024 Volvo S90 TSBs
68 Technical Service Bulletins across 10 categories
Categories
Other
20 bulletinsThis is a Technical Journal: DIM Message and DTC IEM P0A4000.
Read full bulletin
Erase DTC. -Let the vehicle go to "Abandoned mode" - this can take up to 20 minutes. -Perform a new VIDA readout
This is a Technical Journal: iCUP, Searching for GPS message in DIM / CSD.
Read full bulletin
Restart IHU via home button.
This is a Technical Journal: Internet Connectivity symbols in CCD
This is a Technical Journal:
CSD Stuck in Recovery Mode, iCUP
CSD Stuck in Recovery Mode, iCUP
IHU General Issues
ICUP, Upper & Lower bar in CSD not visible
Call button in the OHC might not be lit
ICUP - ?Searching for GPS? message in DIM / CSD
Convert CARE KEY to normal key
TCAM Replacement Needs Prior Approval
Alleged issues with Intellisafe functionality.
This is a Technical Journal: TCAM Replacement Needs Prior Approval
This is a Technical Journal: iCUP, Searching for GPS message in DIM / CSD.
Read full bulletin
Restart IHU via home button.
Shudder/Vibrations during acceleration, 40-65 mph
Ghost DTC set, VCU1-U230056
ISGM Faults - Replacement Countermeasures
COMPLIMENTARY UPGRADE C00009 DESCRIPTION.
Rubber cushion
Electrical
16 bulletinsThis is a Technical Journal: LR PHEV IGM P060700/P061A00 Control Module Performance DTCs.
Read full bulletin
Software download
This is a Technical Journal: Oxygen Sensor DTCs.
Read full bulletin
Perform a Total Upgrade of the vehicle software.
This is a Technical Journal: SPA/CMA - 12V Battery Testing / Maintenance Guide.
Read full bulletin
After capturing a NEW VIDA readout, conduct the steps in VIDA.
This is a Technical Journal: SPA/CMA - 12V Battery Testing / Maintenance Guide.
Read full bulletin
After capturing a NEW VIDA readout, conduct the steps in VIDA.
This is a Technical Journal: MY24 PHEV 12-Volt Battery Drained After Charging the HV Battery.
Read full bulletin
Avoid preventable drainage.
This is a Technical Journal: SPA/CMA - 12V Battery Testing / Maintenance Guide.
Read full bulletin
After capturing a NEW VIDA readout, conduct the steps in VIDA.
This is a Technical Journal: VIDA Main battery diagnostic - Prompted to charge battery a second time.
Read full bulletin
Use had held tester.
This is a Technical Journal: PHEV IEM P060700 Control Module Performance DTC.
Read full bulletin
Clear DTCs, road test and then perform a new readout.
This is a Technical Journal: MY24 PHEV 12-Volt Battery Drained After Charging the HV Battery.
Read full bulletin
Avoid preventable drainage.
Volvo has identified an issue with the Primary Boot Loader (PBL).
Read full bulletin
Due to the release of a new PBL of the Integrated Starter Generator Module (ISGM), the PBL needs to be updated BEFORE doing the Pre-Delivery Software (PDS) upgrade to avoid failure in the the Pre-Delivery Software (PDS) upgrade to avoid failure in the Software Download.
Volvo has identified an issue with the Primary Boot Loader (PBL).
Read full bulletin
Due to the release of a new PBL of the Integrated Starter Generator Module (ISGM), the PBL needs to be updated BEFORE doing the Pre-Delivery Software (PDS) upgrade to avoid failure in the Software Download.
This is a Technical Journal: 12V Battery Testing Method
This is a Technical Journal: Unintentional VIDA Wi-Fi Connection Leading to 12V Battery Drain.
Read full bulletin
Software Solution was made available with V2.8 SW, which was released 23w16. Please ensure vehicle is on V2.8+ SW.
Propulsion Message in DIM with BECM DTC
PHEV BECM software released
Aftermarket Wiring Diagrams SPA MY24.
Software & Calibration
8 bulletinsThis is a Technical Journal: Google acceptance required for SW 3.0.3.
Read full bulletin
Software download.
This is a Technical Journal: 12V Critical Charge Message w/ MVBM-B166094 MVBM-B165F94 DTC's set.
Read full bulletin
Do not replace the MVBM. Delete the DTCs and perform a SW update. A new SW fix is planned 2024 quarter 1.
This is a Technical Journal: Slippery Road alert on DIM.
Read full bulletin
Perform Software download.
Software Update Fails and VIDA Can?t Connect, VGM Unresponsive
P5(SPA)/P6(CMA) Software Download Guide
This is a Technical Journal: 12V Critical Charge Message w/ MVBM-B166094 MVBM-B165F94 DTC's set.
Read full bulletin
Do not replace the MVBM. Delete the DTCs and perform a SW update. A new SW fix is planned 2024 quarter 1.
Updated Chassis Range.
Upgrade Software.
Engine
7 bulletinsThis is a Technical Journal: Chirping noise from engine during engine shutoff.
Read full bulletin
Replace both front camshaft seals
This is a Technical Journal: Check Engine Light in DIM (BCM2 P25A268 / U003700).
Read full bulletin
Download software.
This is a Technical Journal: Check engine light and DTC - ECM P061C48/P060C48.
Read full bulletin
Change engine oil and filter.
Creaking noise from right engine pad
This is a Technical Journal: Transmission Shifts From D or R to P Immediately After Starting.
Read full bulletin
This symptom can occur if the driver changes the position of the gear shifter from P to D or R very quickly after starting the engine and the starting process is not completed. Inform the driver to pause briefly after starting the vehicle before shifting into D or R.
This is a Technical Journal: Check Engine Lamp and Misfire DTC - ECM P030098.
Read full bulletin
Do not replace any parts. Improved software was released in 2023 week 48 (version 2.13.1). If the SW is earlier than 2.13.1 first please perform a total upgrade of the SW according to TJ 31543, then reset the flywheel adaptation according to VIDA.
Model Year 24 PHEV (H6 engine) with BECM DTC P0D1F62
Hybrid & EV
4 bulletinsThis is a Technical Journal.
Read full bulletin
If you experience difficulty programming remote keys on Hybrid vehicles, please follow the advise in Technical Journal under service.
This is a Technical Journal: WPC, none or unstable charging.
Read full bulletin
recalibrate the WPC by performing a WPC reload.
WPC (Wireless Phone Charger) charging information
Wireless Phone Charger
Lighting
4 bulletinsVC App: PHEV Scheduled Charging Turned Off
PAC - Low brightness image in lower-light environment
This is a Technical Journal: PAC - Low brightness image in lower-light environment.
Read full bulletin
Perform a software total upgrade.
PHEV Scheduled Charging Turned Off.
Fuel System
3 bulletinsThis is a Technical Journal: Fuel Door Won't Open.
Read full bulletin
Using the key fob buttons: Press the lock button Wait approximately 10 seconds Press the unlock button
Chirping sound from exhaust
This is a Technical Journal: AC evaporator repair, additional parts needed.
Read full bulletin
Add resister in line jumper cable.
Infotainment
3 bulletinsThis is a Technical Journal: Issues with Touch Functions in Center Stack Display.
Read full bulletin
Software update planned.
This is a Technical Journal: Issues with Touch Functions in Center Stack Display.
Read full bulletin
Software update planned.
This is a Technical Journal: Audio or media sound system, distorted sound - upgrade to V2.13.1 SW.
Read full bulletin
Do not replace any parts. Improved software is available from version 2.13.1 in VIDA or via OTA (Over The Air).
Brakes
2 bulletinsDIM message ?Parking brake service required?
This is a Technical Journal: DIM message about parking brake.
Read full bulletin
Download the available total upgrade software.
Transmission
1 bulletin?Transmission performance reduced? Message in DIM, TCM-P073168