2022 Volvo S60 TSBs
188 Technical Service Bulletins across 14 categories
Categories
Electrical
42 bulletinsThis is a Technical Journal: VCM Backup Battery Replacement with VCM-U105000.
Read full bulletin
Replace the VCM Backup Battery and download the relevant Software.
This is a Technical Journal: Remote connection, BOMGAR application.
Read full bulletin
Before joining a remote session: Connect a suitable battery maintainer/charger and verify that the battery voltage indicated in VIDA is between 12.5V and 14.9V. Connect to the vehicle over a wired connection using a VOE (Volvo OBD to Ethernet) adapter and perform a NEW vehicle readout.
This is a Technical Journal: Improved 12V battery test in VIDA.
Read full bulletin
Service: Dont charge the battery before the test, jump start the vehicle if needed. Read out the vehicle with VIDA and start the test.
This is a Technical Journal: Remote connection, BOMGAR application.
Read full bulletin
Before joining a remote session: Connect a suitable battery maintainer/charger and verify that the battery voltage indicated in VIDA is between 12.5V and 14.9V. Connect to the vehicle over a wired connection using a VOE (Volvo OBD to Ethernet) adapter and perform a NEW vehicle readout.
This is a Technical Journal: Improved 12V battery test in VIDA.
Read full bulletin
Improved 12V battery test in VIDA
This is a Technical Journal: SPA/CMA - 12V Battery Testing / Maintenance Guide.
Read full bulletin
After capturing a NEW VIDA readout, conduct the steps in VIDA.
This is a Technical Journal: SPA/CMA - 12V Battery Testing / Maintenance Guide.
Read full bulletin
After capturing a NEW VIDA readout, conduct the steps in VIDA.
This is a Technical Journal: SPA/CMA - 12V Battery Testing / Maintenance Guide.
Read full bulletin
After capturing a NEW VIDA readout, conduct the steps in VIDA.
This is a Technical Journal: Improved 12V battery test in VIDA.
Read full bulletin
Improved 12V battery test in VIDA
This is a Technical Journal: VCM Backup Battery Replacement with VCM-U105000.
Read full bulletin
Replace the VCM Backup Battery and download the relevant Software.
This is a Technical Journal: Oxygen Sensor DTCs.
Read full bulletin
Perform a Total Upgrade of the vehicle software.
Volvo Car USA LLC and Volvo Car Canada LTD, on behalf of Volvo Car Corporation, has decided to launch Complimentary...
Read full bulletin
Upgrade C00013 on certain Android-based Infotainment system (iCup) vehicles that have missed three (3) or more consecutive Over-The-Air (OTA) downloads. Complimentary Upgrade C00013 addresses vehicles that are no longer able to receive OTA updates. This Upgrade is necessary to have the correct baseline for future OTA deployments. In order to explain the features and benefits we recommend noting the software level before the download is completed. This will aid in explaining to the customer what improvements have been added since their last software download. To remedy concerned cars, please follow the instructions outlined in TJ 36139.
This is a Technical Journal: SPA/CMA - 12V Battery Testing / Maintenance Guide.
Read full bulletin
After capturing a NEW VIDA readout, conduct the steps in VIDA.
This is a Technical Journal: SPA/CMA - 12V Battery Testing / Maintenance Guide.
Read full bulletin
After capturing a NEW VIDA readout, conduct the steps in VIDA.
This is a Technical Journal: SPA/CMA - 12V Battery Testing / Maintenance Guide.
Read full bulletin
After capturing a NEW VIDA readout, conduct the steps in VIDA.
This is a Technical Journal: VIDA Main battery diagnostic - Prompted to charge battery a second time.
Read full bulletin
Use had held tester.
This is a Technical Journal: SR PHEV Cell Module Replacement.
Read full bulletin
Updated BECM software was released
Creaking noise from Steering Wheel Module (SWM)
(MY22) VCM: U210909 Back-up Battery - Updated Instruction
This is a Technical Journal: 12V Battery Testing Method
This is a Technical Journal: Unintentional VIDA Wi-Fi Connection Leading to 12V Battery Drain.
Read full bulletin
Software Solution was made available with V2.8 SW, which was released 23w16. Please ensure vehicle is on V2.8+ SW.
Battery, complete.
Propulsion Message in DIM with BECM DTC
PHEV BECM software released
high-voltage battery cell module in a PHEV.
Service Action A10241 BECM Update.
BECM Update.
Electrical rear axis drive
This is a Quality Bulletin: Service Action A10241: BECM Update: The corrective action is to perform a Total Software...
Read full bulletin
Upgrade
This is a Technical Journal.
Read full bulletin
Recovering control modules stuck in not responding after failed SW download. Connect VIDA to read-out the car. Follow steps outlined in this TJ.
Electrical rear axis drive
Creaking noise from Steering Wheel Module (SWM)
(MY22) VCM: U210909 Back-up Battery - Updated Instruction
PHEV High Voltage Battery Repairs
U210909 Back-up Battery - Updated Instruction
IGM: Inverter Generator Module
BEV High Voltage Battery Replacement
Long Range PHEV BECM DTC P065800
Generator Position Sensor Circuit.
The Deutronic DBL-1200 is an advanced battery maintainer/charger with the flexibility to be updated as products and...
Read full bulletin
repair methods evolve.
Battery Charger/maintainer requirement
Shipping and Handling of Volvo Lithium-ion 48V Mild Hybrid Battery to Global Battery Solutions (GBS)
Other
39 bulletinsThis is a Technical Journal.
Read full bulletin
Vehicle type and platform identification.
this a Technical Journal: ASDM = Active Safety Domain Master To prevent unnecessary replacements of ASDM and as a...
Read full bulletin
troubleshooting aid for the Intellisafe system, please follow the advice in Technical Journal
This is a Technical Journal: Vehicle/Connectivity report checklist.
Read full bulletin
To provide timely and high-quality feedback to the appropriate department or factory
This is a Technical Journal: Alleged issues with Intellisafe functionality.
Read full bulletin
Inform the customer of the functions and limitations
This is a Technical Journal: Difficulty clearing SODx DTCs.
Read full bulletin
put the car in usage mode "Driving" and continue the erasing process
This is a Technical Journal: DIM Message and DTC IEM P0A4000.
Read full bulletin
Erase DTC. -Let the vehicle go to "Abandoned mode" - this can take up to 20 minutes. -Perform a new VIDA readout
Convert CARE KEY to normal key
Alleged issues with Intellisafe functionality.
No internet connection and intermittent.
COMPLIMENTARY UPGRADE C00009 DESCRIPTION.
Driver support systems
Rubber cushion
New Information.
Remote Control Key No function
Wind deflector net clogged
Fresh air hose loose from air filter housing
SiriusXM Tuner Replacement Process
Towbar TRM not responding
Convert CARE KEY to normal key
Google Built In Premium Customer Experience Program
Vehicle type and platform identification
Cannot lock/unlock vehicle with remote control key
Do not swap TCAM?s unless instructed and guided by the Retailer Technical Support team
Call button in the OHC might not be lit
OTA not available for customer
OTA - FAQ for technicians
Product, Safety and Compliance.
Customer Experience Program.
Google Built In Premium Customer Experience Program.
Google Built In Premium Customer Experience Program.
Google Built In Premium Customer Experience Program.
Part information for AMT input shaft repair kits and the shim kit that is required for repair.
Google Built In Premium Customer Experience Program.
Google Built In Premium Customer Experience Program.
ICUP/Google Built-In Diagnostic Operations
VIDA QR Scanner Mobile App
Convert Care Key to Standard Key.
Convert Care Key to Standard Key.
This is a Technical Journal: Ghost DTC set, VCU1-U210782.
Read full bulletin
does not affect any of the functions in the car.
Engine
24 bulletinsThis is a Technical Journal: CEL with DTC ECM P001100, P001200, P001400, P001500.
Read full bulletin
For MY 23-26 vehicles with engine code L1, an improved software is released in version 3.5.14 (and newer). Perform a Total Upgrade according to TJ 31543 before performing additional VIDA symptom-based fault tracing. Software for remaining models will be released later in calendar year 2025
This is a Technical Journal: If the sound can be located towards camshaft sealing area according to attached files: ...
Read full bulletin
Loosen the oil filling cap a little bit and turn engine off again to see if affects the noise. If sound is gone with cap loosened, replace the camshaft seals according to instructions in VIDA.
This is a Technical Journal: CEL with DTC ECM P001100, P001200, P001400, P001500.
Read full bulletin
For MY 23-26 vehicles with engine code L1, an improved software is released in version 3.5.14 (and newer). Perform a Total Upgrade according to TJ 31543 before performing additional VIDA symptom-based fault tracing. Software for remaining models will be released later in calendar year 2025
This is a Technical Journal: CEL with DTC ECM P001100, P001200, P001400, P001500.
Read full bulletin
For MY 23-26 vehicles with engine code L1, an improved software is released in version 3.5.14 (and newer). Perform a Total Upgrade according to TJ 31543 before performing additional VIDA symptom-based fault tracing. Software for remaining models will be released later in calendar year 2025
This is a Technical Journal: CEL with DTC ECM P001100, P001200, P001400, P001500.
Read full bulletin
For MY 23-26 vehicles with engine code L1, an improved software is released in version 3.5.14 (and newer). Perform a Total Upgrade according to TJ 31543 before performing additional VIDA symptom-based fault tracing. Software for remaining models will be released later in calendar year 2025
This is a Technical Journal: CEL with DTC ECM P001100, P001200, P001400, P001500.
Read full bulletin
For MY 23-26 vehicles with engine code L1, an improved software is released in version 3.5.14 (and newer). Perform a Total Upgrade according to TJ 31543 before performing additional VIDA symptom-based fault tracing. Software for remaining models will be released later in calendar year 2025
This is a Technical Journal: Check Engine Light in DIM (BCM2 P25A268 / U003700).
Read full bulletin
Download software.
This is a Technical Journal: Check engine light and DTC - ECM P061C48/P060C48.
Read full bulletin
Change engine oil and filter.
This is a Technical Journal: Long Range PHEV ERAD Knocking Noise Repair Kit.
Read full bulletin
Install a repair kit.
Creaking noise from right engine pad
PHEV Intermittent Start of the Combustion Engine in Hybrid or Pure Mode
PHEV Intermittent Start of the Combustion Engine in Hybrid
Turbo wastegate rod rattling noise
This is a Technical Journal: Unnecessary Replacements of TurboCord Charge Cable (PN 31419235)
This is a Technical Journal: Transmission Shifts From D or R to P Immediately After Starting.
Read full bulletin
This symptom can occur if the driver changes the position of the gear shifter from P to D or R very quickly after starting the engine and the starting process is not completed. Inform the driver to pause briefly after starting the vehicle before shifting into D or R.
This is a Technical Journal: Check Engine Lamp and Misfire DTC - ECM P030098.
Read full bulletin
Do not replace any parts. Improved software was released in 2023 week 48 (version 2.13.1). If the SW is earlier than 2.13.1 first please perform a total upgrade of the SW according to TJ 31543, then reset the flywheel adaptation according to VIDA.
This is a Technical Journal: Turbo wastegate rod rattling noise.
Read full bulletin
Replace wastegate rod.
PHEV Intermittent Start of the Combustion Engine in Hybrid or Pure Mode
PHEV Intermittent Start of the Combustion Engine in Hybrid
Electrical motor sound information
Engine Control Module (EMS) Software Information - Improvement List (Change Log), US21+OBD2020 US21+OBD2021 Emissions...
Read full bulletin
Turbo compound Engines ONLY
Engine Control Module (EMS) Software (MSW) Information August 2022; Improvement List (Change Log) - US21+OBD22 (13L...
Read full bulletin
VGT, TC) And US17+OBD22 (11L) Emissions
Engine Control Module (EMS) Software (MSW) Information August 2022; Improvement List (Change Log) - US21+OBD22 (13L...
Read full bulletin
VGT, TC) And US17+OBD22 (11L) Emissions
Driving, Twin Engine/Propulsion using electric motor not possible.
Software & Calibration
17 bulletinsVolvo Cars USA LLC and Volvo Car Canada LTD on behalf of the Volvo Car Corporation has decided to launch Service Action...
Read full bulletin
S10303 on certain model year 2025 EX90 vehicles. Volvo Car Investigations have identified that there is a pairing issue with the key fob. As a result, there is a possibility that the customers key fob is not paired to the vehicle. The corrective action is to download SP Software. S10303 affects 151 vehicles in the U.S and 5 in Canada.
Volvo Cars USA LLC and Volvo Car Canada LTD on behalf of the Volvo Car Corporation has decided to launch Service Action...
Read full bulletin
S10303 on certain model year 2025 EX90 vehicles. Volvo Car Investigations have identified that there is a pairing issue with the key fob. As a result, there is a possibility that the customers key fob is not paired to the vehicle. The corrective action is to download SP Software. S10303 affects 151 vehicles in the U.S and 5 in Canada.
This is a Technical Journal: Software Upgrade / Download Guide.
Read full bulletin
If one control unit is upgraded and not all, it may result in various problems.
This is a Technical Journal: SENSUS - IHU Software Improvement (Voice Control).
Read full bulletin
software is available in VIDA beginning 2024 week 21.
P5(SPA)/P6(CMA) Software Download Guide
Updated Chassis Range.
Software Improvements
If the software is older than V2.4, which was released 22w42, perform a software upgrade
Over The Air Software Update (OTA)
Vehicle cannot receive OTA updates
OTA Software check
The corrective action is to perform a Total Upgrade Software download.
Vehicle cannot receive OTA updates.
Ghost DTC after software download, FLC2-C100154.
Software Installation.
Perform a software upgrade in accordance with TJ 31543.
New Software Products (SP) have been developed to convert a Care Key to a standard key.
Hybrid & EV
14 bulletinsThis is a Technical Journal.
Read full bulletin
If you experience difficulty programming remote keys on Hybrid vehicles, please follow the advise in Technical Journal under service.
This is a Technical Journal: WPC, none or unstable charging.
Read full bulletin
recalibrate the WPC by performing a WPC reload.
WPC (Wireless Phone Charger) charging information
Unnecessary Replacements of BEV and PHEV Charging Cables
Unnecessary Replacements of BEV and PHEV Charging Cables
Unnecessary Replacements of BEV and PHEV Charging Cables
WPC (Wireless Phone Charger) charging information
Unnecessary Replacements of BEV and PHEV Charging Cables
Unnecessary Replacements of BEV and PHEV Charging Cables
Unnecessary Replacements of BEV and PHEV Charging Cables
Disconnect Charging Cable? With No Cable Attached.
Long Range PHEV Message in DIM ?System Check Please Wait?
Inverter E-Machine.
ISGM and charging error DTC?s
Infotainment
13 bulletinsThis is a Technical Journal: Alleged issues with Intellisafe functionality.
Read full bulletin
Please inform the car user of Intellisafe functionality and limitations in case of alleged issues with Intellisafe. The owner's manual is a good source of information together with films in the owner's manual in the car center screen about Intellisafe
This is a Technical Journal: Alleged issues with Intellisafe functionality.
Read full bulletin
Please inform the car user of Intellisafe functionality and limitations in case of alleged issues with Intellisafe. The owner's manual is a good source of information together with films in the owner's manual in the car center screen about Intellisafe
This is a Technical Journal: Apple CarPlay Not OK - iPhone with USB-C, SENSUS.
Read full bulletin
The 56 kO resistor ensures safe and appropriate power delivery.
No bass function (High Performance Audio)
This is a Technical Journal: Audio or media sound system, distorted sound - upgrade to V2.13.1 SW.
Read full bulletin
Do not replace any parts. Improved software is available from version 2.13.1 in VIDA or via OTA (Over The Air).
Poor radio reception and sound (FM)
Media, navigation and communication.
No bass function (High Performance Audio)
Infotainment System Reboots while driving (blank screen)
No bass function (High Performance Audio)
General radio deviations ICUP vehicles
Media, navigation and Communication.
If a customer complains that the SiriusXM satellite radio media source is missing from the vehicle.
HVAC & Climate
8 bulletinsThis is a Technical Journal: Climate system heating performance (HVCH).
Read full bulletin
Replace HVCH.
Volvo Cars App Remote climate or ERS, not possible
Volvo Cars App Remote climate or ERS, not possible
Climate system heating performance (HVCH)
Volvo Cars App Android, no climate setting button
Climate system heating performance.
Climate system heating performance.
Climate system heating performance (HVCH)
Brakes
7 bulletinsThis is a Technical Journal: DIM message about parking brake.
Read full bulletin
Manually order and download software part number 32429456
This is a Technical Journal: DIM message about parking brake.
Read full bulletin
Manually order and download software part number 32429456
This is a Technical Journal: DIM message about parking brake.
Read full bulletin
Download the available total upgrade software.
This is a Technical Journal: Vibration/shudder while braking.
Read full bulletin
Replace front brake pads
This is a Technical Journal: DIM message about parking brake.
Read full bulletin
Download the available total upgrade software.
Vibration/shudder while braking
Front brake pads, early or uneven wear on right side on 16" and 16.5" brakes
Fuel System
6 bulletinsThis is a Technical Journal: AC evaporator repair, additional parts needed.
Read full bulletin
Add resister in line jumper cable.
Chirping sound from exhaust
This is a Technical Journal: AC evaporator repair, additional parts needed.
Read full bulletin
Add resister in line jumper cable.
Incorrect fuel level or tank capacity
Incorrect fuel level or tank capacity
USE FOR NEW VEHICLES (US21+OBD22 Emissions) - Intermittent Diagnostic Trouble Codes U02A3, U029D, U029E
Lighting
5 bulletinsThis is a Technical Journal: Headlamp condensation inside lens - information/leak test.
Read full bulletin
If the result is not ok (air leak), it is ok to replace the headlamp
This is a Technical Journal: Changed front fog/cornering lights behavior.
Read full bulletin
This logic of the cornering lights is now changed in the cars with software version 3.3.16 or later
This is a Technical Journal: Headlamp condensation inside lens - information/leak test.
Read full bulletin
If the result is not ok (air leak), it is ok to replace the headlamp
This is a Technical Journal: Long Range PHEV ERAD Sound Information.
Read full bulletin
A slight whining sound noticed during electric drive is to be considered normal.
Volvo Complimentary Factory Scheduled Maintenance.
Pre-Delivery & Maintenance
5 bulletinsThis is a Technical Journal: Prior Approval - lack of airflow combined with a poor cooling performance follow the advice...
Read full bulletin
under service.
This is a Technical Journal: Prior Approval - lack of airflow combined with a poor cooling performance follow the advice...
Read full bulletin
under service.
This is a Technical Journal: Prior Approval - lack of airflow combined with a poor cooling performance follow the advice...
Read full bulletin
under service.
Mobile data services, general
This is a Service Manager Bulletin: Retail Car Pre-Delivery Process
Body & Paint
5 bulletinsThis is a Technical Journal: Sunroof Sun Protection.
Read full bulletin
During periods of intense sunlight, it is recommended to keep the sunroof closed when parked to minimize direct sunlight entering the vehicle, as prolonged exposure may cause deterioration or quality issues in the interior materials.
This is a Technical Journal: White patch defect in paint when removed rapgard.
Read full bulletin
Expose vehicle to outside daylight for 48hrs.
This is a Technical Journal: Outer rear view mirror intermittently not folding.
Read full bulletin
May required replacing terminals.
Body, cab and interior.
Outer rear view mirror glass incorrect position after reversing.
Tires & Wheels
2 bulletinsCenter wheel caps, removal instruction
TPMS (Tire Pressure Monitoring System) not available
Steering
1 bulletinThis is a Technical Journal: Text plus 1 jpg and 1 mp4 file -- If there is a strange chafing or creaking noise when...
Read full bulletin
turning the steering wheel, follow the advice under Service.