2004 Volkswagen R32 TSBs
108 Technical Service Bulletins across 13 categories
Categories
Engine
25 bulletinsEngine Oils Which Meet Volkswagen Oil Quality Standard VW 502 00/505 00/505 01 and VW 504 00/507 00
Oil Consumption Measurement
Oil Consumption Measurement
Oil Consumption Measurement
Fuel Additive to Help Prevent Sporadic Misfire Faults
Update to Volkswagen engine oil standards
To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line.
Read full bulletin
The check must be performed with the engine running and heated rear window switched on. Switch OFF the ignition and visually locate the damage. Proceed with checking any other lines as necessary. Once the damaged line is identified, repair utilizing the Repair kit by Permatex ITEM 09117.
Incorrect torque converter or flywheel/flexplate installation can result in transmission damage.
Read full bulletin
When installing an engine, flywheel or transmission, please follow the installation procedures outlined in ELSA. For the flywheel/flexplate, please be certain the correct shim is installed between it and the crankshaft (reference VWIQ120). When installing a torque converter, press the torque converter hub through the seal as far as the first stop. Turn the torque converter while pushing toward the transmission using light force, until the cut outs in the torque converter hub lock into the pump wheel plate. The torque converter slides in. The torque converter is installed correctly if it is easy to turn by hand and if it fits evenly in the transmission bell housing. Additionally, it should spin freely when the transmission bell housing bolts are torqued to the engine block, prior to installation of the flywheel to converter bolts (reference VWIQ121).
Fault code P1297 may be set and fuel mixtures may go lean if the vehicle is driven under load or revved up and then...
Read full bulletin
returned to idle.
Volkswagen Engine oil quality standards, update to attachments.
Fuel Additive to Help Prevent Sporadic Misfire Faults
Engine oil quality standards, update to attachments.
Update to Volkswagen engine oil standards.
Update to Volkswagen engine oil standards.
Update to Volkswagen engine oil standards.
Update to Volkswagen engine oil standards.
Read full bulletin
Also includes 2004 and 2005 Jetta Wagon and 2018-2020 Tiguan LWB
Engine oil quality standards.
Read full bulletin
Also includes all models for 1997-2003. Also Rabbit from 2006-2009.
Engine Oils Which Meet Volkswagen Oil Quality Standards
Gasoline Engine Misfire Diagnosis document
17 17 01 July 5, 2017 2012855 Supersedes Technical Bulletin 17-16-02 (V171602) dated April 29, 2016 due to updated oil...
Read full bulletin
standards lists to current specifications. Engine Oils Which Meet Volkswagen Oil Quality Standards
VOLKSWAGEN: GASOLINE ENGINES HAVE ROUGH IDLE, HAVE SIGNIFICANT LOSS OF POWER OR STALLING WITH REDUCED PERFORMANCE.
Read full bulletin
*PE
VOLKSWAGEN: GASOLINE ENGINE VEHICLES INSPECT, AND IF NECESSARY, REPLACE IGNITION COILS.
Read full bulletin
VEHICLES AFFECTED BY THIS ACTION MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. MODELS PASSAT AND WAGON; GOLF; GTI; JETTA AND WAGON; NEW BEETLE AND CONVERTIBLE; PHAETON; EOS; RABBIT, ETC. *PE
VOLKSWAGEN: MIL ON OR FLASHING, MISFIRE DTCS P0300-0312 STORED IN ECM.
Read full bulletin
THE MISFIRE CONDITION MAY BE CAUSED BY A MALFUNCTIONING IGNITION COIL. VEHICLES ARE OUT OF PRODUCTION. *PE
ENGINE COOLANT TEMPERATURE (ECT) SENSOR.
Read full bulletin
*TC
THE LOWER RADIATOR HOSE COULD CONTACT THE ENGINE COOLING FAN WHICH MAY LEAD TO RADIATOR HOSE WEAR.
Read full bulletin
*TT
Other
21 bulletinsDamage to Data Link Connector (DLC) from Aftermarket Devices (Cannot Communicate with Vehicle OBD System)
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
Squeaks, Rattles, Noise, Repair Materials
Contacting the parts helpline
Part ordering
Tool number added to table.
Read full bulletin
Removal of Behr Flush Kit. VAS 6337/1A
Include new special tool adapter and 2018 model year Jetta only
TT 001202........Also includes 2005 Jetta wagon and 2018-2020 Tiguan LWB
The part number listed in the document is to be returned if it meets the criteria provided.
VAS 6154 Replacement Part Setup Guide
This special notice is to inform dealers to return all part numbers listed in the document and order the superseded part...
Read full bulletin
numbers going forward.
This information bulletin contains instructions for checking the pins/terminals for contacts and nano contacts.
Reminder for dealers to reference the repair manual and replace all necessary fasteners (bolts, nuts) that cannot be...
Read full bulletin
re-used
Tech Tips Damage to Data Link Connector (DLC) from Aftermarket Devices (Cannot Communicate with Vehicle OBD System)
DIAGNOSTIC TROUBLE CODE (DTC) P1603 (18011) STORED IN DTC MEMORY.
Read full bulletin
*TT
Software & Calibration
20 bulletinsSoftware Version Management
In SAGA, the time units for the Volkswagen DoubleCheck labor operation were reduced in error from 50 time units to 30...
Read full bulletin
time units during the system update posted on July 4th.
Quick reference update guide.
Update model year applicability to include 2023.
This bulletin contains general instructions for software updates.
Updated to include additional models and model year applicability.
Update model applicability to MY 2020.
Update to mode; and model year applicability.
Update vehicle metadata to include pull ahead models.
Read full bulletin
Also includes R32 2002-2007 and 2002-2006 Jetta Wagon.
Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the...
Read full bulletin
customer concerns about a vehicle
Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the...
Read full bulletin
customer concerns about a vehicle
Quick Reference Update Guide of the vehicles expected upgraded software level.
Read full bulletin
The latest corresponding technical bulletins that address the issues, and concerns that have been had with the vehicles.
This communication is to update our ProFi dealers of the current status of the latest inbound and outbound ProFi...
Read full bulletin
requests.
Data Link connector pin assignment chart that is applicable to all models.
Read full bulletin
Update model year applicability.
Update to include additional model year applicability.
Update to model year applicability.
Update model year applicability to include 2017.
Update model and model year applicability.
Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the...
Read full bulletin
customer concerns about a vehicle
Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the...
Read full bulletin
customer concerns about a vehicle
Electrical
14 bulletinsBattery, Testing and Charging Using Midtronics VAS6161, MCR340V, InCharge 940, or GRX3000 Charger
Air Conditioning, Cleaning of the Refrigerant Circuit (U.S.Only)
If key blade is found to stick or bind when opening or closing, check position of roll pin that secures key blade to mechanism.
Read full bulletin
If roll pin is sticking out on either side (as shown below), do not replace key. Instead, use appropriate sized punch and hammer to drive in the roll pin so that it is flush with edge of mechanism.
To clear static ECM fault P1250 ?Fuel Level Too Low?, add fuel to vehicle and complete a road test of at least 10 miles.
Read full bulletin
Simply adding fuel without completing a road test may not allow fault to clear.
To clear static ECM fault P1250 ?Fuel Level Too Low?, add fuel to vehicle and complete a road test of at least 10 miles.
Read full bulletin
Simply adding fuel without completing a road test may not allow fault to clear.
Battery testing and charging using special tools VAS6161 & GRX3000VAS Charger.
Read full bulletin
Updated to include additional model year applicability.
REMOVED all 12 hour wait period before starting references.
Read full bulletin
ADDED EFB to "Select correct battery type" in bottom box. Also Jetta Wagon 2005 and 2018-2020 Tiguan LWB.
Battery Testing and Charging instruction.
Read full bulletin
Updated to include model year 2019 applicability.
Body/Infotainment Module Software Updates: This document informs of various complaints that were addressed in software...
Read full bulletin
updates, and technical bulletins.
Body/Infotainment Module Software Updates: This document informs of various complaints that were addressed in software...
Read full bulletin
updates, and technical bulletins.
This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, technical...
Read full bulletin
bulletins, pending service solutions, tech tips, campaigns, updates, and suggestions.
This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, ElsaPro...
Read full bulletin
infomedia icons grayed out, workshop equipment tool storage application, technical bulletins, pending service solutions, tech tips, campaigns, updates, and suggestions.
VOLKSWAGEN: (REVISED) VEHICLES MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS.
Read full bulletin
IF THIS HAPPENS, THE MALFUNCTION INDICATOR LAMP (MIL) WILL ILLUMINATED TO LET YOU KNOW THAT VEHICLE MAY EXPERIENCE SOME DETERIORATION IN PERFORMANCE. IN SOME CASES, A MALFUNCTIONING IGNITION COIL MAY CAUSE A VEHICLE TO EXCEED FEDERAL AND/OR CALIFORNIA EMISSIONS STANDARDS. 2001-2007 PASSA/PASSAT WAGON. *PE UPDATED 8/9/10. *PE UPDATED 11/8/10. *PE UPDATED 12/8/10. *PE UPDATED 2/28/11. *PE UPDATED 3/21/11. *PE
VOLKSWAGEN: VEHICLES MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS.
Read full bulletin
IF THIS HAPPENS, THE MALFUNCTION INDICATOR LAMP (MIL) WILL ILLUMINATED TO LET YOU KNOW THAT THE VEHICLE MAY EXPERIENCE SOME DETERIORATION IN PERFORMANCE. IN SOME CASES, A MALFUNCTIONING IGNITION COIL MAY CAUSE A VEHICLE TO EXCEED FEDERAL AND/OR CALIFORNIA EMISSIONS STANDARDS. NO MODELS LISTED. *PE
Lighting
8 bulletinsExterior Lights, Moisture Accumulation
Exterior Lights, Moisture Accumulation
Exterior Lights, Moisture Accumulation
Exterior Lights, Moisture Accumulation
Exterior Lights, Moisture Accumulation
Exterior Lights, Moisture Accumulation
Condensation and or water droplets visible on inside of exterior light lenses.
Read full bulletin
TB updated to include model year 2019 applicability.
MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODES (DTC) P1347/17755 AND P1340/17748 STORED IN MEMORY.
Read full bulletin
INCLUDING VARIOUS MODELS VOLKSWAGEN 2002-2003. *MJ
HVAC & Climate
4 bulletinsAir Conditioning Does not Operate
HVAC, Unpleasant Odor
HVAC, Unpleasant Odor
HVAC, Unpleasant Odor
Fuel System
4 bulletinsGasoline Quality
The DLC is intended for use with diagnostic scan tools and by emissions testing stations.
Read full bulletin
However, aftermarket devices (i.e., drive data recorders) that connect to the DLC have now become available.
Gasoline quality.
Technical tips on what to do if improper gasoline has been added to the vehicle.
Pre-Delivery & Maintenance
3 bulletinsVolkswagen Warranty Policies and Procedures ? April 2014
If a needed service part is on back order, upgrade the daily order to a red order and check the ?Car Down? box to escalate the order.
Read full bulletin
If parts assistance is needed, please call 800-767-6552 to speak with a VWGoA Parts Specialist.
If a needed service part is on back order, upgrade the daily order to a red order and check the ?Car Down? box to escalate the order.
Read full bulletin
If parts assistance is needed, please call 800-767-6552 to speak with a VWGoA Parts Specialist.
Transmission
3 bulletinsFor concerns of no or intermittent A/C operation where pressure diagnosis does not lead to a cause, be sure to check the N25 A/C clutch coil.
Read full bulletin
The fan control module may send a brief voltage signal to the clutch and then shut it off due to an open or high resistance in the coil circuit. The coil resistance should be between 3.5 and 4.5 ohms. If the reading is high or low when checked at the fan module, be sure to double check right at the coil to rule out any wiring concerns. Additionally, check ground circuit integrity for the clutch coil.
VOLKSWAGEN: THE GEAR BOX HAS A MOMENTARILY DELAY WHILE ACCELERATING.
Read full bulletin
*RM
VOLKSWAGEN: EXHAUST HEAT SHIELD, REPLACEMENT GUIDELINES.
Read full bulletin
HEAT SHIELDS ARE TO BE INSPECTED AFTER COMPLETION O ANY TYPE OF REPAIR TO THE UNDERBODY (EXHAUST SYSTEM TRANSMISSION, ETC.), AND IF DAMAGED, REPLACED. *PE
Infotainment
2 bulletinsWhen performing SVM updates, the scan tool should be hardwired to the vehicle and the Bluetooth physically turned off.
Read full bulletin
A hard wired internet connection is also recommended.
Alternative method for radio code retrieval.
Air Bags & Safety
2 bulletinsAirbag Issues.
VOLKSWAGEN: CHILD RESTRAINT LATCH GUIDANCE FIXTURE; COMPLIANCE WITH FMVSS 225 (USA ONLY).
Read full bulletin
UPDATE TO EXISTING TECHNICAL BULLETIN. NO PRODUCTION CHANGE REQUIRED. ALL MODELS. *PE
Tires & Wheels
1 bulletinThe use of tire dressing gives your tires that shiny finish that completes the image of a clean (new) vehicle.
Read full bulletin
There are many different tire dressing products available. When choosing a product please pay close attention to its contents. Always use a water based product.
Body & Paint
1 bulletinVOLKSWAGEN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER.
Read full bulletin
INSPECT, CLEAN AND MODIFY SUNROOF DRAINS FOR CERTAIN VOLKSWAGEN VEHICLES AND REVISED MAINTENANCE SCHEDULE; SUNROOF DRAIN INSPECTION AND CLEANING. NO MODELS OR MODEL YEARS LISTED. CSC LETTER WAS REC'D. *PE MODEL AND MODEL YEARS INCLUDED. UPDATED *PE