2009 Volkswagen Passat TSBs
738 Technical Service Bulletins across 16 categories
Categories
Engine
216 bulletinsHow to measure engine oil consumption.
Engine misfire diagnostic aid.
Fuel Additive to prevent sporatic misfire
This supporting FAQ is for the Turbocharger Limited Warranty Extension Class Action Settlement.
Read full bulletin
This extension includes 2008-2015 GTI and Golf R*, 2012-2013 VW Beetle*, 2009 VW Jetta SportWagen*, 2013 VW Jetta Sedan and GLI*, 2009-2016 VW Eos*, 2008-2010 VW Passat*, 2009-2017 VW CC*, 2009-2018 VW Tiguan*, Certain model year 2015-2018 VW Golf*, 2015-2021 VW GTI*, 2015-2019 VW Golf R*, 2015-2019 VW Golf SportWagen and Alltrack*, 2019-2024 VW Jetta GLI*, 2019-2021 VW Arteon*, 2018-2023 VW Atlas*, and 2020-2023 VW Atlas Cross Sport*
Volkswagen Engine Oil Quality Standards (U.S.
Read full bulletin
Only)
Volkswagen Engine Oil Quality Standards
Identifying and Mixing Engine Coolant
Engine Oil Standards
A list of engine oil that meet Volkswagen Engine Oil Standards
How to perform the engine oil consumption measurement
Checking Engine Oil and correctly reading dip stick
Engine Misfire Diagnostic Aid
Fuel additive to help with misfire faults
Engine Oil Standards
Engine oil quality standards
Engine Assembly Tip
Engine Replacement Tip
Engine oil quality standards
Engine oil quality standards
Engine Exhaust Flap Limited Warranty Extension
Volkswagen Carefree Maintenance Program ? Gasoline Engines (Except Routan) - REVISED
VW Engine oil quality standards
VW Engine oil quality standards
Carefree Maintenance Coverage for Interim Oil Changes for Certain 2009 ? 2015 MY Volkswagen TDI Clean Diesel Engine...
Read full bulletin
Vehicles Registered in the State of Minnesota Only (US Dealers
VW Engine oil quality standards
VW Engine oil quality standards
VW Engine oil quality standards
Rattling Noises from Engine Compartment Area or Exhaust System
VW Engine oil quality standards
Engine Oils Which Meet Volkswagen Oil Quality Standard VW 502 00/505 00/505 01 and VW 504 00/507 00
Oil Consumption Measurement
Oil Consumption Measurement
Oil Consumption Measurement
Proper Removal of Engine Cover to Avoid Breakage
Engine, Misfire Diagnostic Aid
Engine, Misfire Diagnostic Aid
Fuel Additive to Help Prevent Sporadic Misfire Faults
Fuel Additive to Help Prevent Sporadic Misfire Faults
Fuel Additive to Help Prevent Sporadic Misfire Faults
Fuel Additive to Help Prevent Sporadic Misfire Faults
Update to Volkswagen engine oil standards
Warranty Extension for Intake Manifold & Fuel Injectors Certain 2008-2011
Slave Cylinder - Clutch Pedal Operation Diagnosis
MIL ON, DTCs P2014 or P2015 Intake Manifold Faults Stored in ECM Fault Memory
MIL ON, DTCs P2014 or P2015 Intake Manifold Faults Stored in ECM Fault Memory
MIL ON, DTCs P2014 or P2015 Intake Manifold Faults Stored in ECM Fault Memory
Customers may complain of a rattling noise from engine or exhaust area while accelerating from 1800-3000 RPM.
To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line.
Read full bulletin
The check must be performed with the engine running and heated rear window switched on. Switch OFF the ignition and visually locate the damage. Proceed with checking any other lines as necessary. Once the damaged line is identified, repair utilizing the Repair kit by Permatex ITEM 09117.
Volkswagen Engine oil quality standards, update to attachments.
Activated Charcoal Filter System, Solenoid Valve 1 -N80- (Canister Purge Valve) Diagnosis
For an upcoming campaign that will include all MY09-14 TDI (CBEA/CJAA) vehicles, we need to test the SVM3339 code in 200...
Read full bulletin
vehicles of various model-years and engine/transmission combinations.
Because Volkswagen supports the development and use of renewable fuels (such as biodiesel fuel blends), customers with...
Read full bulletin
certain 2009-2015 MY Volkswagen TDI Clean Diesel Engine vehicles registered in the State of Minnesota only will receive a communication in July 2014 regarding the use of biodiesel fuel blends in their vehicles.
Use the diagram below to test the N75 Solenoid Valve in the event of a turbocharger fault code such as P0299 or P0234.
Read full bulletin
This applies to Mechanical Injection Style Diesel Engines, Pumpe Duse Style Diesel Engines and the new Common Rail Style Diesel Engines.
Inspect the water pump for signs of contact with engine oil.
Read full bulletin
Engine oil may cause the water pump gasket to swell, which may lead to a coolant leak. If water pump replacement is necessary, ensure that any engine oil is thoroughly cleaned off, prior to water pump installation. Please note that when replacing the water pump or opening the cooling system, there is a special bleed procedure that has to be performed. Vacuum bleed the cooling system for 10 minutes. Start the engine and let idle until the thermostat opens and the cooling fan runs, before driving vehicle or raising engine RPM.
When servicing the timing chain sprocket or removing the vibration damper, be aware that one bolt holds both the...
Read full bulletin
vibration damper (harmonic balancer) and the crankshaft timing chain sprocket to the crankshaft. Once the damper is removed, the crankshaft should not be rotated unless special tool spacer T10368 has been installed. The crankshaft timing chain sprocket and spur gear drive on the crankshaft have a coupling that must be seated correctly during assembly. Failure to install special tool spacer T10368 before rotating engine will cause the engine to skip time and bend valves.
CBFA 2.0T TSI Engine
Install a vacuum gauge on the dipstick tube and check crankcase vacuum at idle.
Read full bulletin
Compare to a known good vehicle. If the vacuum reading is lower than the comparison vehicle, visually inspect for oil leaks between the engine and the transmission. Smoke test the crankcase by connecting the EVAP smoke machine to the dipstick tube and inspect for leaks at the rear main seal (this will limit pressure to 2 PSI). DO NOT apply shop air to the dipstick tube or the crankcase. If a rear main seal leak is identified, replace the seal. Once replaced, recheck crankcase vacuum at idle. If low, check for additional oil leaks and verify crankcase breather operation (repairing as necessary). Erase the faults and road test 10 miles to recheck operation.
Install a vacuum gauge on the dipstick tube and check crankcase vacuum at idle.
Read full bulletin
Compare to a known good vehicle. If the vacuum reading is lower than the comparison vehicle, visually inspect for oil leaks between the engine and the transmission. Smoke test the crankcase by connecting the EVAP smoke machine to the dipstick tube and inspect for leaks at the rear main seal (this will limit pressure to 2 PSI). DO NOT apply shop air to the dipstick tube or the crankcase. If a rear main seal leak is identified, replace the seal.
Incorrect torque converter or flywheel/flexplate installation can result in transmission damage.
Read full bulletin
When installing an engine, flywheel or transmission, please follow the installation procedures outlined in ELSA. For the flywheel/flexplate, please be certain the correct shim is installed between it and the crankshaft (reference VWIQ120). When installing a torque converter, press the torque converter hub through the seal as far as the first stop. Turn the torque converter while pushing toward the transmission using light force, until the cut outs in the torque converter hub lock into the pump wheel plate. The torque converter slides in. The torque converter is installed correctly if it is easy to turn by hand and if it fits evenly in the transmission bell housing. Additionally, it should spin freely when the transmission bell housing bolts are torqued to the engine block, prior to installation of the flywheel to converter bolts (reference VWIQ121).
Disconnect both O2 sensors (front and rear), start engine and let idle.
Read full bulletin
Check MVB's 41/4 and 136/4 and verify have both changed from a 1 to a 0 (you may have to drive the car 4 miles to get them to reset to 0). Also a key cycle may be required for values to reset. This forces the ECM to re-learn the O2 sensor adaptation. Once MVB 41/4 and 136/4 read 0, re-connect the O2 sensors, road test and recheck for faults.
When diagnosing a vehicle concern, and fault P130A ?Hide Cylinder? is found in the Engine Control Module (ECM), be aware...
Read full bulletin
that Engine Control Module (ECM) fault P130A ?Hide Cylinder? indicates a cylinder shut down and does not require diagnosis.
When replacing fuel system components on the Common Rail TDI engine (including the fuel filter), the fuel system must be...
Read full bulletin
primed.
If mechanical damage is found to the turbocharger (e.g.
Read full bulletin
damaged compression wheel, loose or broken shaft), it is not enough to just replace the turbocharger.
When diagnosis on the above engine leads to the testing of the N75, please refer to the picture below.
Read full bulletin
The diagram shows which vacuum ports on the N75 valve should hold vacuum and which ones should not.
Volkswagen Engine Oil Standards, updated to include model year 2024.
Engine Oil Consumption Measurement Instruction and Work sheet.
Gasoline quality information in regards to gasoline engine performance.
Diagnostic Aid for engine misfire.
When replacing the complete vehicle lock set (all vehicle keys and lock cylinders) for any reason, be aware that the...
Read full bulletin
?Adapt keys? test plan will not allow the new keys to adapt to the vehicle. Instead, perform the test plan for ?New identity?. During this test plan, make the appropriate selection to indicate only the lock set has been replaced, as shown below in figures 1 and 2.
Volkswagen Engine oil quality standards, update to attachments.
Introduce new engine coolant compatible with all models and all model years.
Fuel Additive to Help Prevent Sporadic Misfire Faults
Fuel additive to help prevent sporadic misfire faults.
Engine oil quality standards, update to attachments.
Volkswagen Engine Oil Quality Standards
Engine Oil Quality Standards updated to include the latest Engine Oil attachments (excludes Routan & ID.4).
Engine Oil Quality Standards updated to include the latest Engine Oil attachments (excludes Routan & ID.4).
Engine Oil Quality Standards updated to include the latest Engine Oil attachments (excludes Routan & ID.4).
Engine Oil Quality Standards updated to include the latest Engine Oil attachments (excludes Routan & ID.4).
Engine Oil Quality Standards updated to include the latest Engine Oil ) excluding Routan & ID.4attachments.
Read full bulletin
(excludes Routan & ID.4)
Engine Oil Quality Standards updated to include the latest Engine Oil attachments.
Read full bulletin
(excludes Routan & ID.4)
Engine Oil Quality Standards updated to include the latest Engine Oil attachments.
Read full bulletin
(excludes Routan & ID.4)
In conjunction with the Georgia Department of Revenue - Motor Vehicle Division and Department of Driver Services,...
Read full bulletin
Volkswagen sent Takata airbag recall reminder notices to approximately 158 Volkswagen owners in the State of Puerto Rico on July 25, 2022.
In conjunction with the Georgia Department of Revenue - Motor Vehicle Division and Department of Driver Services,...
Read full bulletin
Volkswagen sent Takata airbag recall reminder notices to approximately 158 Volkswagen owners in the State of Puerto Rico on July 25, 2022.
Engine Oil Quality Standards updated to include model year 2023 and the latest Engine Oil attachments.
Read full bulletin
(excludes Routan & ID.4)
Engine oil consumption measurement.
VW engine oil specifications.
Read full bulletin
Update to model year applicability.
VW engine oil specifications.
Read full bulletin
Update to attachments.
In conjunction with the Georgia Department of Revenue - Motor Vehicle Division and Department of Driver Services,...
Read full bulletin
Volkswagen sent Takata airbag recall reminder notices to approximately 4,588 Volkswagen owners in the State of Georgia on June 22, 2022.
Recommended fuel additive to avoid engine misfires.
Engine misfire diagnostic aid.
VW Engine Oil Capacities.
Engine oil pressure priming.
In conjunction with the California Department of Motor Vehicles (DMV), Volkswagen sent Takata airbag recall reminder...
Read full bulletin
notices to approximately 7,152 Volkswagen owners in the State of California on April 29, 2022.
Update engine oil quality standard lists (attachments)
Rattling noises from engine compartmen area or exhaust system.
Update engine oil quality standard lists (attachments)
Engine oil consumption measurement.
Read full bulletin
Update procedure and work sheet.
Update engine oil quality standard lists (attachments)
Update engine oil quality standard lists (attachments)
Update engine oil quality standard lists (attachments)
Update engine oil quality standard lists (attachments)
Update engine oil quality standard lists (attachments)
Update engine oil quality standard lists (attachments)
Update engine oil quality standard lists (attachments)
Update engine oil quality standard lists (attachments)
Engine Misfire Diagnostic Aid.
Read full bulletin
Updated to include additional model and model year applicability.
Engine oil consumption measurement.
Fuel Additive to Help Prevent Sporadic Misfire Faults
Update engine oil quality standard lists (attachments)
Update engine oil quality standard lists (attachments)
Update engine oil quality standard lists (attachments)
Updated to include update recommended engine oil attachments.
Body surfaces (engine compartment and underside of hood) are not directly visible (exposed) therefore do not match...
Read full bulletin
exterior paint finish.
Oil consumption test updated to include additional models and model year applicability.
Oil pressure priming after engine replacement or internal repair.
Update to Volkswagen engine oil specification attachments.
Update to Volkswagen engine oil specification attachments.
Update to Volkswagen engine oil specification attachments.
Update to Volkswagen engine oil standards.
Update to Volkswagen engine oil standards.
In conjunction with the Florida Dept.
Read full bulletin
of Highway Safety and Motor Vehicles, Volkswagen will be sending Takata airbag recall reminder notices to approximately 20,200 Volkswagen owners in the state of Florida on October 14, 2019.
Update to Volkswagen engine oil standards.
Update to Volkswagen engine oil standards.
Read full bulletin
Also includes 2004 and 2005 Jetta Wagon and 2018-2020 Tiguan LWB
Engine oil quality standards.
Read full bulletin
Also includes all models for 1997-2003. Also Rabbit from 2006-2009.
Engine oils which meet Volkswagen oil quality standards.
Engine oils which meet Volkswagen oil quality standards.
Engine Oils Which Meet Volkswagen Oil Quality Standards
Valve spring diagnosis.
Installation Instruction for fresh air line during CCTA Intake Manifold Replacement
Supersedes Technical Bulletin 24-17 03 (V241703) dated March 6, 2017 for information regarding a new style solenoid...
Read full bulletin
valve for Intake Manifold Flap
Ensure correct intake manifold is installed on engine, refer to ETKA.
Gasoline Engine Misfire Diagnosis document
Information only. Replacement intake manifolds for CCTA engines have an improved intake manifold flap valve -N316.The...
Read full bulletin
new -N316- valve has 3 hose ports rather than 2 (See Figure 1), requiring a fresh air line be installed during intake manifold replacement. This fresh air line will prevent dirt and debris from contaminating the -N316- solenoid.
Tech Tips (N75 Solenoid Valve Diagnosis): This document informs with a diagram which vacuum ports on the N75 valve...
Read full bulletin
should hold vacuum and which ones should not for diagnosis on the Vehicles with 2.0T Gasoline Engine (Engine Codes BPY, CCTA, CBFA) to the testing of the N75
Engine Control Module Updates: This document informs of complaints, and the software updates/Tech Bulletins associated...
Read full bulletin
with servicing engine control module issues:
Technical Bulletin (Hood, Under Hood Not Painted Body Color): The paint color and/or finish of the engine compartment...
Read full bulletin
and underside of hood may not match the exterior paint color of the vehicle. Depending on vehicle model and production plant, the color of the engine compartment and underside hood may not match the vehicle body color. This document informs dealers to let their customers know that these body surfaces (engine compartment and underside of hood) are not directly visible (exposed) and therefore do not require the same finish as visible, exterior surfaces.
Technical Bulletin (Front Suspension, Knocking Noise): A Knocking noise from vehicle front.
Read full bulletin
Typically occurs only one time after each direction change (forward or backward, left or right). The sub frame shifts slightly relative to the body due to wax residue in-between components. Maximum acceleration and braking in vehicles that are driven hard are contributors to the occurrence. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also available.
Technical Bulletin (Slave Cylinder - Clutch Pedal Operation Diagnosis): A Customer may comment: ? Complaints on clutch system.
Read full bulletin
? After pressing the clutch pedal, it remains on the floor. Due to mis-diagnosis of clutch systems, and to prevent incorrect parts replacement, diagnostic procedure implemented into guided fault finding. This document is meant to inform.
Technical Bulletin (Rattling Noises from Engine Compartment Area or Exhaust System): Customers may complain of a...
Read full bulletin
rattling noise from engine or exhaust area while accelerating from 1800-3000 RPM. In order to complete proper diagnosis and ensure that the noise is coming from the turbocharger use the procedure in this document.
Technical Bulletin (Electric Coolant Fans Continue to Run after Ignition is Switched OFF): This document informs it...
Read full bulletin
is considered normal operation for the electric coolant fans to continue to run for up to 15 minutes after the ignition is switched off in gasoline engine applications, and up to 16 minutes in diesel engine applications.
Technical Bulletin (Oil Consumption Measurement): Customers have stated oil consumption is higher than the Volkswagen...
Read full bulletin
oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. This document informs how to test the oil consumption rate
Tech Tips (2.0L CCTA/CBFA Coolant Leak or Repeat Coolant Leak from the Water Pump Area): This document informs of the...
Read full bulletin
observations that need to be taken to service a water pump replacement
Tech Tips (CBEA, CJAA, CKRA engine codes DPF replacement and/or DTCS P2413, P2463): This document informs of the use...
Read full bulletin
of aftermarket air filters such as cotton bed steel mesh or cone style, can cause the MAF sensor to not read accurately, affecting vehicle performance and critical monitoring functions for the diesel particulate filter. This can also result in premature DPF failure. Only use factory air filters. The use of aftermarket air filters is not supported as the system was designed and calibrated to work with factory air filters.
Volkswagen Note (Warranty Extension for Intake Manifold & Fuel Injectors Certain 2008-2011 Model Year Volkswagen...
Read full bulletin
Vehicles with 2.0 TFSI Engine): As part of Volkswagen?s ongoing commitment to our environment, and in cooperation with the United States Environmental Protection Agency and the California Air Resources Board, Volkswagen is informing customers of the decision to extend the customers Emissions Control Systems Warranty for the intake manifold and fuel injectors under specific conditions to 10 years or 120,000 miles, whichever occurs first.
Tech Tips (N75 Solenoid Valve Diagnosis): This document informs with a diagram which vacuum ports on the N75 valve...
Read full bulletin
should hold vacuum and which ones should not for diagnosis on the Vehicles with 2.0T Gasoline Engine (Engine Codes BPY, CCTA, CBFA) to the testing of the N75
Engine Control Module Updates: This document informs of complaints, and the software updates / Tech Bulletins...
Read full bulletin
associated with servicing engine control module issues:
Technical Bulletin (Slave Cylinder - Clutch Pedal Operation Diagnosis): A Customer may comment: ? Complaints on clutch system.
Read full bulletin
? After pressing the clutch pedal, it remains on the floor. Due to mis-diagnosis of clutch systems, and to prevent incorrect parts replacement, diagnostic procedure implemented into guided fault finding. This document is meant to inform.
Technical Bulletin (Hood, Under Hood Not Painted Body Color): The paint color and/or finish of the engine compartment...
Read full bulletin
and underside of hood may not match the exterior paint color of the vehicle. Depending on vehicle model and production plant, the color of the engine compartment and underside hood may not match the vehicle body color. This document informs dealers to let their customers know that these body surfaces (engine compartment and underside of hood) are not directly visible (exposed) and therefore do not require the same finish as visible, exterior surfaces.
Technical Bulletin (Front Suspension, Knocking Noise): A Knocking noise from vehicle front.
Read full bulletin
Typically occurs only one time after each direction change (forward or backward, left or right). The sub frame shifts slightly relative to the body due to wax residue in-between components. Maximum acceleration and braking in vehicles that are driven hard are contributors to the occurrence. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also available.
Technical Bulletin (Rattling Noises from Engine Compartment Area or Exhaust System): Customers may complain of a...
Read full bulletin
rattling noise from engine or exhaust area while accelerating from 1800-3000 RPM. In order to complete proper diagnosis and ensure that the noise is coming from the turbocharger use the procedure in this document.
Technical Bulletin (Electric Coolant Fans Continue to Run after Ignition is Switched OFF): This document informs it...
Read full bulletin
is considered normal operation for the electric coolant fans to continue to run for up to 15 minutes after the ignition is switched off in gasoline engine applications, and up to 16 minutes in diesel engine applications.
Technical Bulletin (Oil Consumption Measurement): Customers have stated oil consumption is higher than the Volkswagen...
Read full bulletin
oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. This document informs how to test the oil consumption rate
Tech Tips (CBEA, CJAA, CKRA engine codes DPF replacement and/or DTCS P2413, P2463): This document informs of the use...
Read full bulletin
of aftermarket air filters such as cotton bed steel mesh or cone style, can cause the MAF sensor to not read accurately, affecting vehicle performance and critical monitoring functions for the diesel particulate filter. This can also result in premature DPF failure. Only use factory air filters. The use of aftermarket air filters is not supported as the system was designed and calibrated to work with factory air filters.
Tech Tips (2.0L CCTA/CBFA Coolant Leak or Repeat Coolant Leak from the Water Pump Area): This document informs of the...
Read full bulletin
observations that need to be taken to service a water pump replacement
Volkswagen Note (Warranty Extension for Intake Manifold & Fuel Injectors Certain 2008-2011 Model Year Volkswagen...
Read full bulletin
Vehicles with 2.0 TFSI Engine): As part of Volkswagen?s ongoing commitment to our environment, and in cooperation with the United States Environmental Protection Agency and the California Air Resources Board, Volkswagen is informing customers of the decision to extend the customers Emissions Control Systems Warranty for the intake manifold and fuel injectors under specific conditions to 10 years or 120,000 miles, whichever occurs first.
This Document was revised to include information on when the replacement engine contains a Timing Chain or Timing Chain Tensioner.
Read full bulletin
Also includes the CPPA engine code labor operation and time units.
The Vehicle Maintenance Declaration has been added back to WISE for the Timing Chain Warranty Extension.
Incorrect removal of Turbocharger oil feed line may cause engine damage
Engine replacement tip
This document advises dealers regarding the Timing Chain/Timing Chain Tensioner Limited Warranty Extension
Timing Chain Class Action Update
17 17 01 July 5, 2017 2012855 Supersedes Technical Bulletin 17-16-02 (V171602) dated April 29, 2016 due to updated oil...
Read full bulletin
standards lists to current specifications. Engine Oils Which Meet Volkswagen Oil Quality Standards
VOLKSWAGEN DEALERSHIP COMMUNICATION: Volkswagen announced a warranty extension program to cover the High Pressure...
Read full bulletin
Fuel Pump on 2009-2012 model year TDI Clean Diesel Engine vehicles
VOLKSWAGEN DEALERSHIP COMMUNICATION: This document announced a warranty Volkswagen extension program to cover the High...
Read full bulletin
Pressure Fuel Pump on 2009-2012 model year TDI Clean Diesel Engine vehicles.
Update TB to include model year 2017 and include additional engine applicability.
The strainer screen in the camshaft bearing bracket can tear and cause camshaft adjuster issues.
Tech Tips (Equipped with Turbocharged Engine Turbocharger Replacement Tip): If mechanical damage is found to the turbocharger (e.g.
Read full bulletin
damaged compression wheel, loose or broken shaft), it is not enough to just replace the turbocharger. This document informs the procedure of checks for damage.
Technical Bulletin (Oil Consumption Measurement): Customer states oil consumption is higher than the Volkswagen oil...
Read full bulletin
consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. In order to provide effective lubrication and cooling of internal engine components, all internal combustion engines consume a certain amount of engine oil. Oil consumption varies from engine to engine and may change significantly over the life of the engine. Typically, engines with specified break-in periods consume more oil during the break-in period, and the oil consumption will stabilize after the break-in period. This document informs of oil consumption tests to check a vehicles performance.
Technical Bulletin Activated Charcoal Filter System, Solenoid Valve 1 -N80- (Canister Purge Valve) Diagnosis): ...
Read full bulletin
Completing the GFF function test and performing a vacuum check on the Canister Purge Valve -N80- are essential to diagnose proper operation and to avoid unnecessary replacements. This document informs how to perform the Diagnosis check
Tech Tips (Technician Helpline Vehicle Check Sheets): When it becomes necessary to open a VW Technician Helpline VTA...
Read full bulletin
case while performing diagnosis for a diesel particulate filter, manual transmission repair, or turbocharger concern, it is recommended to complete the related worksheet/check sheet before calling. This document informs where Worksheets/Check Sheets are available on ServiceNet.
Tech Tips 92006-2014 Vehicles with 2.0T Gasoline Engine - N75 Solenoid Valve Diagnosis): When diagnosis on the above...
Read full bulletin
engine leads to the testing of the N75, please refer this document with graphical aid. The diagram shows which vacuum ports on the N75 valve should hold vacuum and which ones should not. Turbocharger fault codes P0299 and P0234 can be diagnosed using this test.
Tech Tips (Engine Control Module Fault P130A ?Hide Cylinder?): This document informs that DTC P130A ?Hide Cylinder?...
Read full bulletin
indicates that excessive misfiring has occurred. As a result, the ECM has turned off a fuel injector to prevent catalyst damage. To address this fault, diagnose and repair all misfire concerns that are present. Repairing the other faults will resolve the P130A.
Technical Bulletin (HVAC, Unpleasant Odor): Condensation, which is a normal condition in all A/C systems, can cause a musty odor.
Read full bulletin
If the odor is noticeable in the vehicle when the engine is not turned on, the cause may be mold and mildew in the passenger compartment, and not be related to the A/C system. All other possible sources of the odor must be investigated before this document can be performed. This document contains the procedure for the VW method to remove musty odors
Technical Bulletin The use of contaminated gasoline, seasonal fuel changes (summer/winter fuel) or gasoline with a low...
Read full bulletin
content of deposit control additives may result in one or more of the following conditions: -Excessive accumulation of deposits on intake valves, intake manifold, fuel injectors and combustion chambers. -Engine runs rough after cold start. -Excessive engine cranking time. -Stumbles while driving. -Rough engine idle. -Loss of engine performance. -Poor fuel economy. This document informs of the procedure for the vehicle if it is diagnoised with poor quality gas
Technical Bulletin (Proper Removal of Engine Cover to Avoid Breakage): Pulling on the engine cover in some areas can cause damage.
Read full bulletin
This document informs on the procedure to remove the engine cover.
Idler roller for ribbed bely now available as a parts kit.
Remove engine coolant from parts table.
Technical Bulletin (Intake manifold runner position sensor issues): This document informs what repairs are needed to fix the issue.
Read full bulletin
This document contains the fault codes necessary to check the warranty coverage for servicing this issue.
Tech Tips: The document discusses the conditions of when turbo can to be fixed or replaced
Tech Tips (Coolant Leak or Repeat Coolant Leak from the Water Pump Area): The document informs to inspect for issues, and why issues may happen.
Read full bulletin
It also notes how to fix the issue, and other issues that could happen while repairing the issue
Warranty Information (Policies and Procedures Bulletin): Volkswagen has extended the warranty for the high-pressure...
Read full bulletin
fuel pump (HPFP) under specific conditions to 10 years or 120,000 miles, whichever occurs first, from the vehicle's original in-service date, for certain 2009 - 2012 Model Year (MY) Volkswagen TDI Clean Diesel Engine vehicles
Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt...
Read full bulletin
meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engine running and heated rear window switched on. Switch OFF the ignition and visually locate the damage.
Technical Bulletin: This document has the fault codes to trouble shoot Intake Manifold Faults.
Read full bulletin
It also contains the claim codes for warranty coverage
Technical Bulletin (Rear Door Glass Inoperative): The rear glass cannot be opened / closed, the rear glass may slide...
Read full bulletin
down into the door, or the rear glass motor operates but the glass does not move. This document contains the fault codes, and procedure to service these issues
Tech Tips (Oxygen Sensor Reset Procedures): This document informs of the procedure to rest oxygen sensors -For...
Read full bulletin
2009-2014 vehicles with engine codes CJAA or CBEA: -For 2012-2015 vehicles with engine codes CKRA, CVCA or CRUA:
Technical Bulletin (Fuel Additive to Help Prevent Sporadic Misfire Faults): Fuel quality impacts the operating...
Read full bulletin
performance, efficiency and service life of the engine. The use of poor quality fuels may result in deposit build up on the fuel injectors and intake valves. This may result in a rough running condition, sporadic misfires, or cold start misfire faults storing in the ECM fault memory. This document informs a Volkswagen approved fuel additive is available to help remove and prevent deposits on fuel injectors and intake valves.
Technical Bulletin (Fuel Additive to Help Prevent Sporadic Misfire Faults): Fuel quality impacts the operating...
Read full bulletin
performance, efficiency and service life of the engine. The use of poor quality fuels may result in deposit build up on the fuel injectors and intake valves. This may result in a rough running condition, sporadic misfires, or cold start misfire faults storing in the ECM fault memory. A Volkswagen approved fuel additive is available to help remove and prevent deposits on fuel injectors and intake valves. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also available.
Technical Bulletin (Engine, Misfire Diagnostic Aid): This document informs that Multiple components SHOULD NOT be replaced for 1 misfiring cylinder.
Read full bulletin
Repeat repairs must be carefully addressed to identify the root cause of the concern. If misfires are determined to be related to a specific component(s) (fuel injector, spark plug, ignition coil), replace only one defective component at a time and re-evaluate the concern
Job Aid ? VW Engine Oil Capacities (Gasoline, Diesel, Hybrid Engines)
Technical Bulletin (Electric Coolant Fans Continue to Run after Ignition is Switched OFF): This documentation informs...
Read full bulletin
it is considered normal operation for the electric coolant fans to continue to run for up to 15 minutes after the ignition is switched off in gasoline engine applications, and up to 16 minutes in diesel engine applications. The production solution to service this issue is that no production change is required.
Tech Tips (Lean Fuel Trim Readings): This document informs to recheck the crankcase vacuum at idle.
Read full bulletin
If low, check for additional oil leaks and verify crankcase breather operation (repairing as necessary). Erase the faults and road test 10 miles to recheck operation.
Tech Tips (2.0L CCTA/CBFA Coolant Leak or Repeat Coolant Leak from the Water Pump Area): Inspect the water pump for...
Read full bulletin
signs of contact with engine oil. Engine oil may cause the water pump gasket to swell, which may lead to a coolant leak. This document informs of the precaustions necessary if a water pump replacement is necessary.
Tech Tips (Common Rail TDI ? Fuel Filter Replacement and Prime/Bleed Procedure): This document informs when replacing...
Read full bulletin
fuel system components on the Common Rail TDI engine (including the fuel filter), the fuel system must be primed. The procedure should be available on most models through Guided Functions. If not shown, then access through Control Module OBD. Run ?Basic Settings block 35? three times in a row. This activates the electric fuel pumps and bleeds the fuel system. Once the system has been bled, it will be necessary to start the engine and idle for a minimum of 5 minutes before depressing the gas pedal.
Technical Bulletin (Rear Door Glass Inoperative issue diagnosis): The rear glass cannot be opened / closed, the rear...
Read full bulletin
glass may slide down into the door, or the rear glass motor operates but the glass does not move
Technical Bulletin (P2014 or P2015 Intake Manifold Faults Stored in ECM Fault Memory ): Document discusses diagnosis...
Read full bulletin
Codes necessary to diagnosis, and potential remedy of issue. The diagnosis codes for checking warranty coverage for servicing the vehicle are also available
Fuel Additive to Help Prevent Sporadic Misfire Faults A Volkswagen approved fuel additive is available to help remove...
Read full bulletin
and prevent deposits on fuel injectors and intake valves.
Technical Bulletin about a customer concern stating that customer observed one or more of the shocks/struts appearing to have an oil leak.
Read full bulletin
Document contains examples of Strut or Shock Absorber Leak Assessments
Steps to address false misfire indication
Technical Bulletin (Engine Oils Which Meet Volkswagen Oil Quality Standard): This document informs of a sample list...
Read full bulletin
of products generally available in the North American market that meet the Volkswagen Oil Quality Standard
Technical Bulletin (Intake Manifold issues): This document informs of a failure of Intake manifold causing fault codes to be stored in the ECM.
Read full bulletin
The fault codes are written in the document. The product solution for this issue an Improved intake manifold design. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also available.
Technical Bulletin (Intake Manifold Fault issues): This document informs of Intake Manifold issues that are recognized in the ECM fault memory.
Read full bulletin
The Production Solution to this issue was an improved intake manifold design. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also available.
Technical Bulletin (Intake Manifold Faults Stored in ECM Fault Memory issues): This document informs of a failure of...
Read full bulletin
Intake manifold causing fault codes to be stored in the ECM. The production solution improved intake manifold design. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also available.
Technical Bulletin (Slave Cylinder - Clutch Pedal Operation Diagnosis): Customer may comment: ? Complaints on clutch system.
Read full bulletin
? After pressing the clutch pedal, it remains on the floor. Due to mis-diagnosis of clutch systems, and to prevent incorrect parts replacement, diagnostic procedure implemented into guided fault finding (GFF). This document is for identifying the issue for diagnosis.
Tech Tips (Torque Converter/Flywheel/Flexplate installation): Incorrect torque converter or flywheel/flexplate...
Read full bulletin
installation can result in transmission damage. When installing an engine, flywheel or transmission, please follow the installation procedures outlined in ELSA. This document also contains advice on the installation of these devices
"ENGINE, MISFIRE DIAGNOSTIC AID THE MIL IS FLASHING OR ILLUMINATED."
VOLKSWAGEN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER.
Read full bulletin
AN EXTENSION WARRANTY, WITH SPECIFIC CONDITIONS, 10 YRS OR 120,000 MILES,WHICHEVER IS FIRST, HAS BEEN ISSUED FOR EMISSIONS CONTROL SYSTEMS WARRANTY FOR INTAKE MANIFOLD AND FUEL INJECTORS. MODEL 2008-2011. *PE
VOLKSWAGEN: ACTIVATED CHARCOAL FILTER SYSTEM, SOLENOID VALVE AND PERFORMING GFF FUNCTION TEST A VACUUM CHECK ON...
Read full bulletin
CANISTER PURGE VALVE N80 ARE ESSENTIAL TO DIAGNOSE PROPER OPERATION. MODEL 2009-14 ALL BUT ROUTAN. *PE
VOLKSWAGEN: DIAGNOSIS FOR HIGH PRESSURE FUEL PUMP WHERE NO START, ENGINE CRANK, WITHOUT DRIVING, AFTER LONG PERIODS AND MAY HAVE ROUGH RUNNING ENGINE.
Read full bulletin
MODELS 2008-2014 EOS, GTI, BEETLE CONVERTIBLE, JETTA, CC, PASSAT, TIGUAN, BEETLE. *PE
VOLKSWAGEN: ON SOME VEHICLES, LOW FUEL STORED IN ECM PRESSURE, ENGINE WOULD CRANK BUT NOT START LONG PERIODS WITHOUT...
Read full bulletin
DRIVING, MAY RUN ROUGH AND/OR MIL ON. ALL MODELS 2008-2013. *PE
VOLKSWAGEN: SOME VEHICLES MAY EXPERIENCE A MISFIRE AND/OR REDUCED ENGINE PERFORMANCE.
Read full bulletin
*JS
VOLKSWAGEN: ALL MODELS EXPERIENCE THE TIMING CHAIN SLIPPING, RATTLING NOISES OF THE ENGINE AFTER STARTING, AND ENGINE FAILS TO START.
Read full bulletin
2008-13 ALL MODELS. *PE
VOLKSWAGEN: FRONT SUSPENSION, KNOCKING NOISE.
Read full bulletin
KNOCKING NOISE FROM VEHICLE FRONT. TYPICALLY OCCURS ONLY ONE TIME AFTER EACH DIRECTION CHANGE (FORWARD OR BACKWARD, LEFT OR RIGHT). THE SUB FRAME SHIFTS SLIGHTLY RELATIVE TO THE BODY DUE TO WAX RESIDUE IN-BETWEEN COMPONENTS. MAXIMUM ACCELERATION AND BRAKING IN VEHICLES THAT ARE DRIVEN HARD ARE CONTRIBUTORS TO THE OCCURRENCE. ALSO INCLUDED MODEL PASSAT YEAR 2011. *JS
VOLKSWAGEN: CERTAIN MODEL YEAR VEHICLES ARE EXPERIENCING ENGINE NOT STARTING, MAKING A RATTLING NOISE WHEN ENGINE HAS...
Read full bulletin
STARTED, TIMING CHAIN KEEPS SLIPPING AND EXHAUST LIGHT COMES ON. *PE
VOLKSWAGEN: MALFUNCTION LIGHT IS ON AND THERE IS NOISE WITH THE ENGINE RUNNING ROUGH.
Read full bulletin
MULTIPLE TROUBLE CODES POSSIBLY STORED. ALL MODELS 2008-2012. *RM
VOLKSWAGEN: THE POSITIVE BATTERY CABLE ON PASSAT VEHICLES WITH V6 ENGINE MAY CORRODE AND IN INDIVIDUAL CASES BREAK.
Read full bulletin
AS A RESULT, THE POWER SUPPLY MAY BE DISRUPTED AND E.G. THE VEHICLE CANNOT BE STARTED. *PE
Other
121 bulletinsGFF Requirements regardless of concern plus System flush requirement
G12Evo can now be mixed with previous coolants.
Additional reporting
Fluid requirements
Antenna Diagnosis Overview
Damage to Data Link Connector (DLC) from Aftermarket Devices (Cannot Communicate with Vehicle OBD System)
Vehicles equipped with Immobilizer 4 (Download) ? Adapting Keys after Vehicle Lock Set Replacement
GPS Antenna Concerns
Volkswagen Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
Safety Related Inquiry and Reporting
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
Squeaks, Rattles, Noise, Repair Materials
Please contact VW Helpline before attempting repair
Please contact VW Helpline before attempting repair
Please contact VW Helpline before attempting repair
Please contact VW Helpline before attempting repair
Diagnostic assistance for excessive static current draw
Antenna Diagnosis Overview
Damage on External Chrome or Aluminum Surfaces
When diagnosing fault code P2279-Leaking Air in Intake System, be sure to check the cam timing first.
Contacting the parts helpline
This special notice is to inform dealers to return the parts listed only order the successor parts going forward.
This Document informs dealers on VWP-23-01
Installation of original remote start feature accessory
Part ordering
Diagnostic aid for DTC P0088 & P1025.
This Document informs dealers on VWP-22-03
Additional safety related Inquiry and Reporting instruction.
This special notice is to inform dealers to return the parts listed if it meets the criteria provided.
Parts ordering information
This special notice is to inform dealers to return the parts listed if it meets the criteria provided.
Data link diagnostics and tips
This special notice is to inform dealers to return the part numbers listed (State of California only).
Mandatory fastener.
Electronic Stabilization Program (ESP) function test may not end on its own causing DTC.
Tool number added to table.
Read full bulletin
Removal of Behr Flush Kit. VAS 6337/1A
Volkswagen After Sales Weekly Communication - March 10, 2020
ERP fault information.
Include new special tool adapter and 2018 model year Jetta only
Added: Torque Spec table
The part number listed in the document is to be returned if it meets the criteria provided.
The part number listed in the document is to be returned.
Include additional photo's of water ingress.
Read full bulletin
Also includes 2018-2020 Tiguan LWB
TT 001202........Also includes 2005 Jetta wagon and 2018-2020 Tiguan LWB
Additional Safety Inquiry and Reporting instruction.
Additional Safety Inquiry and Reporting instruction.
Additional Safety Inquiry and Reporting instruction.
Additional Safety Inquiry and Reporting instruction.
Adhesive circular. Note: also includes 2004 Golf, Jetta, Passat, Touareg, GTI,
The part number listed in the document is to be returned if it meets the criteria provided.
Iinclude additional model year applicability and tool information.
Tip demonstrating label information for clarity
This communication informs the dealers of details on the Takata parts allocation/ordering.
VAS 6154 Replacement Part Setup Guide
Iinclude additional model year applicability and tool information.
Tip demonstrating label information for clarity
This communication informs the dealers of details on the Takata parts allocation/ordering.
This special notice is to inform dealers to return all part numbers listed in the document and order the superseded part...
Read full bulletin
numbers going forward.
This Document informs is the dealer FAQ associated with VWP-18-07
Balance shaft direction for debris issues.
Scan tool tip to address no identification of AW77
DTC Status Bit Definitions.
This Document informs dealers on the Revised VWP-18-07.
Read full bulletin
New info on coverage for consequential damages
To include an additional model year applicability.
This special notice is to inform dealers to return all part numbers listed in the document.
Read full bulletin
Only superseded part numbers to be ordered going forward.
This special notice is to inform dealers to return all part numbers listed in the document.
Read full bulletin
Only superseded part numbers to be ordered going forward.
This information bulletin contains instructions for checking the pins/terminals for contacts and nano contacts.
Tip for Scan tool concerns that may occur duing a test plan
This communication informs the dealers of details on the Takata parts allocation/ordering.
Metadata adjustment. TB appeared with tech tips in Elsa.
Reminder for dealers to reference the repair manual and replace all necessary fasteners (bolts, nuts) that cannot be...
Read full bulletin
re-used
Takata Enrollment Form
Assembly Instructions: Installation of original remote start feature accessory, Volkswagen Passat.
Technical Bulletin: Diagnosing with Damage on External Chrome or Aluminum Surfaces
Tech Tips: Vehicles with Immobilizer with Download/Discharge? New Key Will Not Program
Tech Tips Damage to Data Link Connector (DLC) from Aftermarket Devices (Cannot Communicate with Vehicle OBD System)
This communication informs the dealers of details on the Takata parts allocation.
ENHANCED DIAGNOSTIC ASSISTANCE FOR DTCS P0088 AND P1025
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
Software & Calibration
87 bulletinsHow to manage software versions using VW diagnostic Tool
Software Version Management
In SAGA, the time units for the Volkswagen DoubleCheck labor operation were reduced in error from 50 time units to 30...
Read full bulletin
time units during the system update posted on July 4th.
Quick Reference Update Guide
Quick Reference Update Guide
Software Version Management (SVM) instruction.
Update model year applicability to include 2023.
ACC Calibration Process
Update warranty table labor operation numbers due to recent Saga updates.
Update warranty table labor operation numbers due to recent Saga updates.
Cleaning of Heating and Ventilation system, Updated to include additional model year applicability and cost of cleaning...
Read full bulletin
solution in warranty table.
Update model and model year applicability, introduce new coolant G12Evo.
This bulletin contains general instructions for software updates.
Update to model year applicability.
Update to model year applicability.
Software Version Management (SVM)
Update to brochure purchase url
Update to top tier brochure purchasing url.
Software Version Management (SVM) instruction updated to include model year 2021
Updated to include an additional model year applicability.
Updated key ordering protocol
Update Top Tier brochure part number.
Update brochure part number and recording URL.
Read full bulletin
Update model and model year applicability.
Metadata update (add MY 2014 Eos (missing).
Update to include 2020-2021 model and model year applicability.
Updated to include additional models and model year applicability.
Operational Update - Takata Return Parts Pickup
Update to Volkswagen Identifying and mixing of coolant.
Read full bulletin
Introducing new coolant type.
Update to Volkswagen Identifying and mixing of coolant.
Read full bulletin
Introducing new coolant type.
Update model applicability to MY 2020.
Update to mode; and model year applicability.
Update to mode; and model year applicability.
Quick Reference Update Guide.
Update vehicle metadata to include pull ahead models.
Read full bulletin
Also includes R32 2002-2007 and 2002-2006 Jetta Wagon.
Update vehicle metadata.
Update to TB to include model year 2018 & 2019 applicability.
Update vehicle metadata.
Update to TB to include model year 2018 & 2019 applicability.
Instrument cluster production mode solution, updated to include additional model and model year applicability.
Update brochure part number, literature ordering websie address and include an additional model year applicability
Updated to include model year 2014 thru 2018 applicability.
Updated to address additional model years.
Read full bulletin
Tip to reinforce dealer scan tool update importance in regards to 23Q3/24CV/23U3 campaign
Warranty Information (Volkswagen DoubleCheck Labor Operations): Volkswagen DoubleCheck Labor Operations for All VW...
Read full bulletin
Models Except Routan ElsaWeb/Pro was updated on August 12, 2013 with the following Volkswagen DoubleCheck labor operations for all Volkswagen models except Routan. This document informs where in ElsaWeb/Pro this information can be located.
Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the...
Read full bulletin
customer concerns about a vehicle
Instrument cluster production mode solution, updated to include additional model and model year applicability.
Update brochure part number, literature ordering websie address and include an additional model year applicability
Updated to include model year 2014 thru 2018 applicability.
Updated to address additional model years.
Read full bulletin
Tip to reinforce dealer scan tool update importance in regards to 23Q3/24CV/23U3 campaign
Warranty Information (Volkswagen DoubleCheck Labor Operations): Volkswagen DoubleCheck Labor Operations for All VW...
Read full bulletin
Models Except Routan ElsaWeb/Pro was updated on August 12, 2013 with the following Volkswagen DoubleCheck labor operations for all Volkswagen models except Routan. This document informs where in ElsaWeb/Pro this information can be located.
Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the...
Read full bulletin
customer concerns about a vehicle
Instrument cluster production mode solution, updated to include additional model and model year applicability.
Updated existing tip to include latest model years for explanation of P130A
Update content and include additional models and model year applicability.
Updated to include additional models and model year applicability.
Update Tiguan oil pan labor operation number in warranty table.
This communication gives more information on the REPAIR & OWNER MOBILITY UPDATE
Quick Reference of vehicle concerns.
Read full bulletin
Includes a list of Software versions and the technical bulletin numbers that referred to the concerns Updated
Campaign Parts Bulletin - 69M8 and 69M9 - Takata Part ordering process - On May 5th, a Campaign Parts Bulletin about the...
Read full bulletin
updated Takata part ordering process was sent to all dealers. We?ve closely monitored the impact of that communication and would like to address several emerging trends.
To update claim processing statement.
To update claim processing statement.
Takata - Parts allocation update - dealer communication
Quick Reference Update Guide of the vehicles expected upgraded software level.
Read full bulletin
The latest corresponding technical bulletins that address the issues, and concerns that have been had with the vehicles.
This communication is to update our ProFi dealers of the current status of the latest inbound and outbound ProFi...
Read full bulletin
requests.
This technical bulletin was updated per powertain team and warranty team.
Read full bulletin
Info from this bulletin is combined with TB 2031075 (V241208) and 2038161 (V241506) due to warranty extension claiming/processing confusion. (Basically 3 technical bulletins covering the same DTC were combined into 1 technical bulletin). By combining the three technical bulletins it allowed for archiving (removal from publication) of V241208 and V241506 stated above.
Data Link connector pin assignment chart that is applicable to all models.
Read full bulletin
Update model year applicability.
Updated to include additional model year and required documentation instruction.
Quick Reference of vehicle concerns.
Read full bulletin
Includes a list of Software versions and the technical bulletin numbers that referred to the concerns Updated
Updated to include additional model year applicability.
Update to include additional model year applicability.
Update model year applicability.
Update to model year applicability.
Update model year applicability to include 2017.
Update model and model year applicability.
Updated to include an additional diagnostic trouble code (P04F0)
Update to existing article that addressed additional diagnostics for lean running concerns.
Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the...
Read full bulletin
customer concerns about a vehicle
Technical Bulletin This Technical Bulletin details the general process for carrying out a Software Version Management...
Read full bulletin
(SVM) software update for any Technical Bulletin (TSB) / Required Vehicle Update (RVU).
Updated to include additional model year and required documentation instruction.
Update parts table.
Update Parts Table.
To update required parts table.
To update required parts table.
Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the...
Read full bulletin
customer concerns about a vehicle
UPDATE TECHNICAL BULLETIN TO INCLUDE ALL MODELS FOR 2015, 2016, 2017 MODEL YEAR APPLICABILITY.
UPDATE TECHNICAL BULLETIN TO INCLUDE ALL 2017 MODELS
TO UPDATE MODEL TABLE TO CLARIFY JETTA WAGON APPLICABILITY TO TB CONTENT.
TO UPDATE CLAIM PROCESSING STATEMENT.
Electrical
68 bulletinsThis is a notice for software changes with the ODIS diagnostic program to correct the communication during vehicle...
Read full bulletin
programming function: A software fix is needed to correct a test that is not reading any information from the battery data module (BDM) and will output:
Battery testing
Cruise Control Inoperative, Fault B115411 ?Cruise Control Switch Short Circuit to Ground? after J527 Steering Column...
Read full bulletin
Control Module Replacement
Radio Navigation Unit Security Label
Battery Testing and Charging Using Midtronics VAS6161 and or GRX3000VAS Charger.
Read full bulletin
Update Tool terminology
Electric Coolant Fans Continue to Run after Ignition is Switched OFF
Electric Coolant Fans Continue to Run after Ignition is OFF
Electric Coolant Fans Continue to Run after Ignition is OFF
P0102, P1128, P1296 - WA front oxygen sensor faults
Battery, Testing and Charging Using Midtronics VAS6161, MCR340V, InCharge 940, or GRX3000 Charger
MIL ON, No Start, or Rough Running with DTCs P0087, P0088 or P0191 Stored in ECM Fault Memory (TDI ONLY)
MIL ON, No Start, or Rough Running with DTCs P0087, P0088 or P0191 Stored in ECM Fault Memory (TDI ONLY)
Battery Testing and Charging using Midtronics VAS6161 and or GRX3000 Vas Charger
Air Conditioning, Cleaning of the Refrigerant Circuit (U.S.Only)
If key blade is found to stick or bind when opening or closing, check position of roll pin that secures key blade to mechanism.
Read full bulletin
If roll pin is sticking out on either side (as shown below), do not replace key. Instead, use appropriate sized punch and hammer to drive in the roll pin so that it is flush with edge of mechanism.
If the steering rack is replaced on the above models for any reason, it is necessary to replace the steering harness as well.
Read full bulletin
The new harness may be equipped with an extra connector. If all connections are made correctly, then it is necessary to remove that connector and tape the exposed wires back into the harness. Be sure to tape tightly in order to provide a water-tight repair.
Some Golf, GTI, Jetta, and Passat vehicles equipped with electromechanical power steering have the G85 steering angle...
Read full bulletin
sensor located in the steering rack. These vehicles do not have a G85 in the steering column. To determine G85 location, check the J500 Power steering control module part number in the GFF printout. Do not use the part number on the steering rack for this check.
Use the following procedure to diagnose active wheel speed sensor complaints
To clear static ECM fault P1250 ?Fuel Level Too Low?, add fuel to vehicle and complete a road test of at least 10 miles.
Read full bulletin
Simply adding fuel without completing a road test may not allow fault to clear.
To clear static ECM fault P1250 ?Fuel Level Too Low?, add fuel to vehicle and complete a road test of at least 10 miles.
Read full bulletin
Simply adding fuel without completing a road test may not allow fault to clear.
Use the following procedure to diagnose active wheel speed sensor complaints:
Use of aftermarket air filters such as cotton bed steel mesh or cone style, can cause the MAF sensor to not read...
Read full bulletin
accurately, affecting vehicle performance and critical monitoring functions for the diesel particulate filter. This can also result in premature DPF failure. Only use factory air filters. The use of aftermarket air filters is not supported as the system was designed and calibrated to work with factory air filters.
Battery Testing and Charging using Midtronics VAS6161 and or GRX3000 Vas Charger
When replacing J527 steering column control module, be aware that there may be two different replacement part numbers listed in ETKA.
Read full bulletin
The correct replacement part number is determined by the hardware part number of the module originally installed in the vehicle.
When replacing a radio navigation unit, inspect the security labels on both the new and replacement units for damage.
Read full bulletin
If damage is found to a label on either unit, be sure to note this on the repair order along with the reason the radio is being replaced.
Electric coolant fans continue to run after ignition is switched off.
Battery testing and charging using special tools VAS6161 & GRX3000VAS Charger.
Read full bulletin
Updated to include additional model year applicability.
Minimum battery charger requirements during software updates
Battery Testing and Charging using VAS6161 and or GRX3000VAS
Software Version Management (SVM) instruction.
Read full bulletin
Update to require 70amp minimum battery charger during procedure.
Battery Testing and Charging using recommended VW test equipment.
Battery Tester VAS 6161 introduction.
Discharged Battery, Diagnosis for excessive current draw.
Battery testing using VW special tools, updated to include additional model year applicability and include I.D.4.
Explanation of error message received from scan tool when erasing diagnostic trouble codes (DTCs) in Control Module...
Read full bulletin
-623- after repair.
Battery testing. Updated to include additional model and model year applicability.
REMOVED all 12 hour wait period before starting references.
Read full bulletin
ADDED EFB to "Select correct battery type" in bottom box. Also Jetta Wagon 2005 and 2018-2020 Tiguan LWB.
Remote Key Battery Replacement
Battery Testing and Charging instruction.
Read full bulletin
Updated to include model year 2019 applicability.
Update procedure to reset oxygen sensor adaptations, as a result of erratic test plan function.
Body/Infotainment Module Software Updates: This document informs of various complaints that were addressed in software...
Read full bulletin
updates, and technical bulletins.
Tech Tips ("Steering Column Defective? Message on MFI): Be aware that the MFI message ?Steering Column Defective?...
Read full bulletin
does not necessary indicate the electronic steering column lock (ESCL) requires replacement. This document informs of what faults to check to that may indicate a concern with the comfort module.
Update procedure to reset oxygen sensor adaptations, as a result of erratic test plan function.
Body/Infotainment Module Software Updates: This document informs of various complaints that were addressed in software...
Read full bulletin
updates, and technical bulletins.
Tech Tips ("Steering Column Defective? Message on MFI): Be aware that the MFI message ?Steering Column Defective?...
Read full bulletin
does not necessary indicate the electronic steering column lock (ESCL) requires replacement. This document informs of what faults to check to that may indicate a concern with the comfort module.
Comfort/BCM Replacement direction, updated to include additional model year applicability.
This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, technical...
Read full bulletin
bulletins, pending service solutions, tech tips, campaigns, updates, and suggestions.
This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, ElsaPro...
Read full bulletin
infomedia icons grayed out, workshop equipment tool storage application, technical bulletins, pending service solutions, tech tips, campaigns, updates, and suggestions.
Tech Tips (Comfort Module (J393) or BCM (J519) Replacement): This document informs If a comfort or body control module...
Read full bulletin
is replaced during normal diagnosis, make sure the factory mode has been switched OFF. This can be accomplished by selecting the test plan through GFF or through Vehicle Self Diagnosis in adaptation channel 99. Failure to deactivate factory mode will create a concern where the door locks will not lock and/or unlock with the switch and/or the remotes.
Tech Tips (with 1K0 Part Number J500 ? Replacement Steering Harness): If the steering rack is replaced on the above...
Read full bulletin
models for any reason, it is necessary to replace the steering harness as well. The new harness may be equipped with an extra connector. If all connections are made correctly, then it is necessary to remove that connector and tape the exposed wires back into the harness. Be sure to tape tightly in order to provide a water-tight repair.
Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit (U.S.Only)): In cases where an air...
Read full bulletin
conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or component is circulated throughout the refrigerant circuit, the refrigerant circuit must be cleaned of any and all debris or damage to the replacement components will result. This document contains information on how to diagnose, and service this issue.
Tech Tips (Radiator Identification Sensor): On TSI (2.0l CCTA, CBFA) equipped vehicles with fault code P2568 Direct...
Read full bulletin
Ozone Reduction Catalyst Temperature Sensor, this fault refers to - G611- as Radiator Identification Sensor. If the radiator requires replacement on any above listed vehicle, the -G611- will be packaged separately within the radiator packaging. The new sensor will need to be bonded to the radiator.
Tech Tips (Active Wheel Speed Sensor Diagnosis): This document informs of a procedure to diagnose active wheel...
Read full bulletin
speed sensor complaints
Tech Tips (ECM Fault P1250 "Fuel Level Too Low" Will Not Clear): This document informs to clear static ECM fault...
Read full bulletin
P1250 "Fuel Level Too Low", add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without completing a road test may not allow fault to clear.
Tech Tips (Rear View Camera Inoperative issues): The rear view camera operates in conjunction with the rear parking aid system.
Read full bulletin
If there are no faults in the radio or rear view camera, be sure to check the parking aid system for faults. Buzzer or sensor faults must be corrected for proper rear view camera operation.
Technical Bulletin: Battery, Discharged, Diagnosis for Excessive Static Current Draw
Technical Bulletin: Battery, Testing and Charging Using Midtronics VAS6161, MCR340V, InCharge 940, or GRX3000VAS...
Read full bulletin
Charger
Tech Tips (Active Wheel Speed Sensor Diagnosis): This document informs of a procedure to diagnose active wheel speed...
Read full bulletin
sensor complaints.
Tech Bullentin concerning Electric Coolant Fans that Continue to Run after Ignition is Switched OFF
Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit): In cases where an air conditioning system...
Read full bulletin
component (such as a compressor or other system component) has failed and debris from the compressor or component is circulated throughout the refrigerant circuit, the refrigerant circuit must be cleaned of any and all debris or damage to the replacement components will result. Debris can be dispersed throughout the refrigerant circuit after a/c component damage. In order to maintain A/C operating efficiency, it is important to flush the refrigerant circuit after A/C component repairs.
Tech Tips (2009-2015 Jetta, Eos, Rabbit, Golf, GTI, Passat, CC, and Tiguan Equipped with Electromechanical Power...
Read full bulletin
Steering ? G85 Location Identification Tip): Ths document informs of the location of the G85 steering sensor. The sensors expected settings, and which vehicles do not have this sensor for electromechanical power steering.
Tech Tips (Comfort Module (J393) or BCM (J519) Replacement): This document informs if a comfort or body control module...
Read full bulletin
is replaced during normal diagnosis, make sure the factory mode has been switched OFF. This can be accomplished by selecting guided function of either the J393 or J519 or control module OBD of J393 or J519 then selecting adaptation channel 99. Failure to deactivate factory mode will create a concern where the door locks will not lock and/or unlock with the switch and/or the remotes.
VOLKSWAGEN: BEFORE REAR VIEW CAMERA IS PROPERLY OPERATIONAL, SHOULD BE CONNECTED TO BUZZER OR SENSOR FAULTS AND WORKING...
Read full bulletin
IN CONJUNCTION WITH REAR PARKING AID SYSTEM. MODELS 2009-15 TIGUAN, CC, PASSAT, TOUAREG. *PE
VOLKSWAGEN: IT IS A NORMAL OCCURRENCE FOR THE ELECTRIC COOLANT FANS TO CONTINUE TO RUN AFTER THE IGNITION IS SWITCHED OFF.
Read full bulletin
*JS
VOLKSWAGEN: MIL ON; DTC P0087 AND/OR P0192 STORED IN ECM FAULT MEMORY.
Read full bulletin
ONE OR MORE OF THE FOLLOWING CODES MAY BE STORED IN THE ECM FAULT MEMORY-LOW FUEL RAIL PRESSURE DETECTED; FUEL RAIL PRESSURE SENSOR CIRCUIT LOW. ASSISTANCE TO PROPERLY DIAGNOSE A FUEL PRESSURE SENSOR-G247-CONCERN. MODELS CC, EOS, PASSAT AND WAGON, GTI, (A5) JETTA, (A6) JETTA, TIGUAN. *PE
VOLKSWAGEN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER.
Read full bulletin
INSPECT, AND IF NECESSARY, REPLACE POSITIVE BATTERY CABLE. VEHICLES AFFECTED BY THIS ACTION MAY HAVE A POSITIVE BATTERY CABLE THAT MAY CORRODE AND, IN RARE CASES, BREAK. IF THIS HAPPENS, THE POWER SUPPLY MAY BE DISRUPTED AND THE VEHICLE CANNOT BE STARTED. *PE UPDATED ON 5/2/2012. *KB
VOLKSWAGEN: THIS IS TO INFORM YOU OF THE RELEASE OF A NEW REQUIRED VEHICLE UPDATE.
Read full bulletin
CHECK AND, IF NECESSARY, REPLACE POSITIVE BATTERY CABLE. MODELS PASSAT, PASSAT WAGON, PASSAT CC. *PE
VOLKSWAGEN: THE POSITIVE BATTERY CABLE ON VEHICLES MAY CORRODE AND IN INDIVIDUAL CASES BREAK.
Read full bulletin
AS A RESULT, THE POWER SUPPLY MAY BE DISRUPTED AND E.G. THE VEHICLE CANNOT BE STARTED. *PE
Air Bags & Safety
38 bulletinsAirbag / Pyrotechnic Safety Belt Deployment Inquiries, update to contact information due to retirement.
In conjunction with the New Mexico DMV, Volkswagen will be sending Takata airbag recall reminder notices to...
Read full bulletin
approximately 363 Volkswagen owners in the State of New Mexico on March 13, 2023.
In conjunction with the Massachusetts DMV, Volkswagen will be sending Takata airbag recall reminder notices to...
Read full bulletin
approximately 1,498 Volkswagen owners in the State of Massachusetts on March 13, 2023.
In conjunction with the Colorado DMV, Volkswagen will be sending Takata airbag recall reminder notices to approximately...
Read full bulletin
1,414 Volkswagen owners in the State of Colorado on February 13, 2023.
VW contact when reporting a Airbag or Pyrotechnic safety belt deployment.
Read full bulletin
Update to model year applicability.
In conjunction with the New York DMV, Volkswagen will be sending Takata airbag recall reminder notices to approximately...
Read full bulletin
2,743 Volkswagen owners in the State of New York on October 17, 2022.
In conjunction with the South Carolina Department of Public Safety, Volkswagen is sending Takata airbag recall reminder...
Read full bulletin
notices to approximately 1,824 Volkswagen owners in the state of South Carolina on September 19, 2022.
In conjunction with the Virginia DMV, Audi will be sending Takata airbag recall reminder notices to approximately 2,217...
Read full bulletin
VW owners in the State of Virginia on July 21, 2022
Airbag Issues.
In conjunction with the Alabama Law Enforcement Agency (ALEA), Volkswagen is sending Takata airbag recall reminder...
Read full bulletin
notices to approximately 1,387 Volkswagen owners in the State of Alabama on March 23, 2022.
In conjunction with the South Carolina Department of Public Safety, Volkswagen is sending Takata airbag recall reminder...
Read full bulletin
notices to approximately 1,571 Volkswagen owners in the state of South Carolina on January 24, 2022.
In conjunction with the Pennsylvania Department of Transportation, Volkswagen is sending Takata airbag recall reminder...
Read full bulletin
notices to approximately 4,041 Volkswagen owners in the state of Pennsylvania on January 24, 2022.
In conjunction with the Idaho DMV, Volkswagen will be sending Takata airbag recall reminder notices to approximately 406...
Read full bulletin
Volkswagen owners in the State of Idaho on August 30, 2021.
In conjunction with the New York DMV, Volkswagen will be sending Takata airbag recall reminder notices to approximately...
Read full bulletin
4,206 Volkswagen owners in the State of New York on June 21, 2021.
In conjunction with the Texas DMV, Volkswagen will be sending Takata airbag recall reminder notices to approximately...
Read full bulletin
12,375 Volkswagen owners in the State of Texas on May 17, 2021.
In conjunction with the Michigan Department of State, Volkswagen will be sending Takata airbag recall reminder notices...
Read full bulletin
to approximately 3,000 Volkswagen owners in the State of Michigan on August 10, 2020.
In conjunction with the County of Fort Bend, Volkswagen will be sending Takata airbag recall reminder notices to...
Read full bulletin
approximately 640 Volkswagen owners in the State of Texas on July 28, 2020.
In conjunction with the Tennessee DMV, Volkswagen will be sending Takata airbag recall reminder notices to approximately...
Read full bulletin
4,400 Volkswagen owners in the State of Tennessee July 7, 2020.
In conjunction with the City of Miramar, Volkswagen sent Takata airbag recall reminder notices to approximately 218...
Read full bulletin
Volkswagen owners in the State of Florida on June 26, 2020.
In conjunction with the Nebraska DMV, Volkswagen will be sending Takata airbag recall reminder notices to approximately...
Read full bulletin
600 Volkswagen owners in the State of Nebraska on March 23, 2020.
In conjunction with the Ohio DMV, Volkswagen will be sending Takata airbag recall reminder notices to approximately...
Read full bulletin
9,000 Volkswagen owners in the State of Ohio on February 10, 2020.
In conjunction with the Georgia DMV, Volkswagen will be sending Takata airbag recall reminder notices to approximately...
Read full bulletin
7,900 Volkswagen owners in the State of Georgia on January 24, 2020.
In conjunction with the South Carolina Department of Public Safety, Volkswagen sent Takata airbag recall reminder...
Read full bulletin
notices to approximately 2,800 Volkswagen owners in the state of South Carolina on January 20, 2020.
In conjunction with the California Bureau of Automotive Repair, Volkswagen sent Takata airbag recall reminder notices to...
Read full bulletin
approximately 21,100 Volkswagen owners in the state of California on January 14, 2020.
In conjunction with the Houston Dept.
Read full bulletin
of Neighborhoods, Volkswagen will be sending Takata airbag recall reminder notices to approximately 4,600 Volkswagen owners in the state of Texas on November 4, 2019.
XPO Phone Outage - Takata Airbag/Inflator Returns
In conjunction with the Minnesota DMV, Volkswagen will be sending Takata airbag recall reminder notices to approximately...
Read full bulletin
3,400 Volkswagen owners in the State of Minnesota on September 16, 2019.
In conjunction with the North Carolina DMV, Volkswagen will be sending Takata airbag recall reminder notices to...
Read full bulletin
approximately 7,400 Volkswagen owners in the State of North Carolina on August 19, 2019.
In conjunction with the Virginia DMV, Volkswagen will be sending Takata airbag recall reminder notices to approximately...
Read full bulletin
6,235 Volkswagen owners in the State of Virginia on August 12, 2019.
In conjunction with the City of Compton, Volkswagen will be sending Takata airbag recall reminder notices to...
Read full bulletin
approximately 68 Volkswagen owners in the State of California on August 5, 2019.
Volkswagen will be sending Takata airbag recall reminder notices daily over a span of five business days to...
Read full bulletin
approximately 1,712 High Risk Volkswagen owners.
In conjunction with the Commonwealth of Kentucky Transportation Cabinet, Volkswagen will be sending Takata airbag recall...
Read full bulletin
reminder notices to approximately 2,592 Volkswagen owners in the state of Kentucky on July 15, 2019.
Dealer Communication - ODIS Service Takata Airbag Recall Hotfix "Resolved".
Dealer Communication - ODIS Service Takata Airbag Recall Hotfix "Resolved".
Dealer Communication - ODIS Service TDI Flash & Takata Airbag Recall
Campaign Parts Bulletin - 69M8 and 69M9 - Today, May 5th is the final standard weekly allocation of Takata airbag inflators.
Read full bulletin
After this date, Takata allocations will be based on the previous week?s paid claim volume. It is CRITICAL that claims are submitted in a timely fashion in order to receive an appropriate volume of additional parts to support demand.
This document reminds dealers that Takata SDI Frontal Airbag Inflators replaced with the 69M9 Safety Recall will not be...
Read full bulletin
requested for return through the Warranty Parts Portal but will be requested for return through the Takata XPO Return Program.
VOLKSWAGEN: CHILD RESTRAINT LATCH GUIDANCE FIXTURE; COMPLIANCE WITH FMVSS 225 (USA ONLY).
Read full bulletin
UPDATE TO EXISTING TECHNICAL BULLETIN. NO PRODUCTION CHANGE REQUIRED. ALL MODELS. *PE
Fuel System
36 bulletinsA list of suggested fuel stations
Fuel Additive
Recommended Gasoline Quality
High Pressure Fuel Pump Diagnosis
Gasoline Quality
Install Misfueling Guard
Install Misfueling Guard
We would like to inform you that the FAQ for Service Action 20T8 has been revised to include additional information for...
Read full bulletin
dealers to share with customers about the misfueling guard.
2009-2015 Model Year Volkswagen TDI Clean Diesel Vehicles Registered in Minnesota
Be aware that fuel lines are color coded on vehicles with return fuel pressure lines.
Read full bulletin
The black line is for fuel pressure supply and the blue line is for fuel pressure return. To verify correct line installation, remove the metal cover exposing the fuel pump flange assembly (generally under the rear seat). Refer to the ELSA Repair Manual for specific location. Check for raised arrows on the flange housing. The black line (Fuel Pressure Supply) attaches to the connection with the arrow pointing away from it. The blue line (fuel return) attaches to the connection with arrow pointing to it.
When replacing or adapting fuel injectors, if there is no Guided Functions Test Plan, utilize the following
When replacing or adapting fuel injectors, if there is no Guided Functions Test Plan, utilize the following :UDS...
Read full bulletin
vehicles: Go to Guided Functions / Adapting Injector Quantity Adjustment correct values (IMA-IVA).
Gasoline fuel additive
The DLC is intended for use with diagnostic scan tools and by emissions testing stations.
Read full bulletin
However, aftermarket devices (i.e., drive data recorders) that connect to the DLC have now become available.
Gasoline quality.
DTC's P053F,P0087, P0088, P1025 may set due to the high pressure fuel pump being out of time (sync).
Gasoline quality.
VW approved gasoline fuel additive, update to include additional models and model year applicability.
VW approved gasoline fuel additive, update to include additional models and model year applicability.
Symptom based diagnostic assistance for high pressure fuel pump being out of time.
Symptom based diagnostic assistance for high pressure fuel pump being out of time.
Diganostic direction to locate exhaust leak
This Document informs dealers on the Revised VWP-15-06 to exclude the fuel sample requirements.
Technical Bulletin (High Pressure Fuel Pump Diagnosis): Completing the GFF high pressure pump function test is...
Read full bulletin
essential to diagnose proper pump operation and to avoid unnecessary replacements. This document informs how to perform the diagnostic. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also available.
Update to expand fuel testing for lean DTCS.
Update to existing tip for fuel quality checking.
Technical Bulletin: High Pressure Fuel Pump Diagnosis.
Read full bulletin
Completing the GFF high pressure pump function test is essential to diagnose proper pump operation and to avoid unnecessary replacements. This document contains the procedure to update the programming on the diagnostic hardware. This document contains the fault codes necessary to check the warranty coverage for servicing this issue.
Technical Bulletin (High Pressure Fuel Pump Diagnosis): Completing the GFF high pressure pump function test is...
Read full bulletin
essential to diagnose proper pump operation and to avoid unnecessary replacements
Tech Tips (Lean Fuel Trim Readings): This document informs on the procedure to diagnose for issues with excess fuel...
Read full bulletin
trim, and what needs to be serviced
Technical Bulletin (High Pressure Fuel Pump Diagnosis): Completing the GFF high pressure pump function test is...
Read full bulletin
essential to diagnose proper pump operation and to avoid unnecessary replacements.
Discusses the issues associated with using contaiminated gasoline.
Read full bulletin
There are recommendations to use top tier gasoline retailers
Technical tips on what to do if improper gasoline has been added to the vehicle.
Tech Tips (Fuel line connections): Be aware that fuel lines are color coded on vehicles with return fuel pressure lines.
Read full bulletin
The black line is for fuel pressure supply and the blue line is for fuel pressure return.
Tech Tips (Adapting Injector Quantity adjustment correction values (IMA/IVA)): When replacing or adapting fuel...
Read full bulletin
injectors, if there is no Guided Functions Test Plan, utilize this documents procedure
VOLKSWAGEN:EVAPORATIVE (EVAP) EMISSION SYSTEM, DIAGNOSTIC TROUBLE CODE DIAGNOSIS.
Read full bulletin
REVISED PROCEDURE DEVELOPED TO TEST EVAP SYSTEM WITHOUT FUEL CAP. *JS
VOLKSWAGEN: MALFUNCTION LIGHT IS ON WITH TWO POSSIBLE FAULT CODES PRESENT.
Read full bulletin
THIS IS A FUEL PRESSURE CONCERN. *RM
Body & Paint
32 bulletinsLack of paint under roof
Wind & Water Leak Checking
Customer States Windshield Wipers Streak or Smear
Corrosion on Rear Door in Trim Strip Area
Corrosion on Rear Door in Trim Strip Area
Rear Doors, Outer Seal, Water Retention at Sill Plate
Corrosion on the Front Door in Trim Strip Area
Corrosion on the Front Door in Trim Strip Area
Front Fender - Corrosion on Wheel Arch
Front Fender - Corrosion on Wheel Arch
Corrosion on hood edge.
Rear quarter panel corrosion.
Corrosion on wheel arch.
Technical Bulletin (Rear Doors, Outer Seal, Water Retention at Sill Plate): Rear door seals are retaining water until door is open.
Read full bulletin
Water is collecting between lower door seal and lower body seal of the rear doors. The production solution to this issue was New design rear outer door seals. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also available.
Technical Bulletin (Paint Finish, Reducing Swirl Marks and Fine Scratches): New vehicles (prior to Retail Delivery)...
Read full bulletin
with swirl marks and or fine scratches from polishing or cleaning. This document informs of how the Finish can be significantly improved without the use of harsh polishing compounds and high speed buffing.
Technical Bulletin (Rear Doors, Outer Seal, Water Retention at Sill Plate): Rear door seals are retaining water until door is open.
Read full bulletin
Water is collecting between lower door seal and lower body seal of the rear doors. The production solution to this issue was New design rear outer door seals. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also available.
Technical Bulletin (Paint Finish, Reducing Swirl Marks and Fine Scratches): New vehicles (prior to Retail Delivery)...
Read full bulletin
with swirl marks and or fine scratches from polishing or cleaning. This document informs of how the Finish can be significantly improved without the use of harsh polishing compounds and high speed buffing.
58 16 03 June 13, 2016 2039212 Supersedes Technical Bulletin 581503 dated July 21, 2015 to update Claim Processing statement.
Read full bulletin
Corrosion on Rear Door in Trim Strip Area
Corrosion may be found on the folded edge of the hood.
Read full bulletin
Supersedes TB V551603
explaination of cross car distorion when looking through the windshield and how the "effect" in normal.
Technical Bulletin (Squeaks, Rattles, Noise, Repair Materials): This doucment contains a list of components and...
Read full bulletin
applications developed to repair concerns of squeaks, rattles, noise and trim fit conditions.
Technical Bulletin (Corrosion on the Front Door in Trim Strip Area): Because of incomplete bonding of the trim strip...
Read full bulletin
water can get between trim strip and door. This document contains information on how to diagnose, and service this issue. This document also gives examples on filling out a claim form for the service.
Technical Bulletin (Corrosion on Rear Door in Trim Strip Area): Because of incomplete bonding of the trim strip water...
Read full bulletin
can get between trim strip and door. Because of water ingress, corrosion is possible in the area of the guide holes. This document contains information on how to diagnose, and service this issue. This document also gives examples on filling out a claim form for the service.
Technical Bulletin (Windshield Wipers Streak or Smear): Windshield or rear window is streaked, has a snakeskin appearance, or the surface feels rough.
Read full bulletin
To avoid unnecessary replacement of wiper blades, the condition and cleanliness of the windshield, rear window and wiper blades, should be checked first. This document contains information on how to diagnose, and service this issue.
Technical Bulletin (Sunroof or Power Sunshade, Does Not Open/Close or Automatic Operation Does Not Function).
Read full bulletin
This document contains Warranty information for coverage, and informs of methods to to service the issue
Technical Bulletin (Front Fender - Corrosion on Wheel Arch): The wheel liner touches the arch area of the fender and...
Read full bulletin
rubs off the paint in the contact area. The corrosion is caused by dirt accumulations and movements of the wheel liner. The document informs how to identify affected parts. It then gives direction on servicing the issue
Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt...
Read full bulletin
meter to check for 0 V, which will be present after the open in the grid line. This document informs of how to diagnose the issue and tips on servicing the issue
Technical Bulletin about Paint Finish, Reducing Swirl Marks and Fine Scratches New vehicles (prior to Retail Delivery)...
Read full bulletin
with swirl marks and or fine scratches from polishing or cleaning. The document also have infromation about where to find warrenty coverage for the service
Document discusses issues with The wheel liner touches the arch area of the fender and rubs off the paint in the contact area.
Read full bulletin
The corrosion is caused by dirt accumulations and movements of the wheel liner. It discusses how to service the corrosion issue, and how to document it
The document refers to Corrosion being found where the rear bumper cover meets the quarter panel.
Read full bulletin
It discusses how it can happen, and where to find warranty coverage to service the parts
Document discusses Corrosion that may be found on the folded edge of the hood.
Read full bulletin
The corrosion may be found on this edge anywhere around the hood. It discusses how to service it, and document that service. It discusses where to find what applies to warranties that offer coverage for the service
Tech Tips (All vehicles-Tire dressing for vehicle detailing): The use of tire dressing gives your tires that shiny...
Read full bulletin
finish that completes the image of a clean (new) vehicle. This document informs that The use of non-water based products will increase the risk of causing damage to painted surfaces. The document also gives graphical examples of the dame that can occur if non-water based products are used.
Pre-Delivery & Maintenance
30 bulletinsVehicle Concerns Before Recall Repair Available
Wiper Blade Inspection for Proper Warranty Coding
Wiper Blade Inspection for Proper Warranty Coding
Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections
Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections
Wiper Blade Inspection for Proper Warranty Coding
Wiper Blade Inspection for Proper Warranty Coding
Volkswagen Warranty Policies and Procedures ? April 2014
If a needed service part is on back order, upgrade the daily order to a red order and check the ?Car Down? box to escalate the order.
Read full bulletin
If parts assistance is needed, please call 800-767-6552 to speak with a VWGoA Parts Specialist.
If a needed service part is on back order, upgrade the daily order to a red order and check the ?Car Down? box to escalate the order.
Read full bulletin
If parts assistance is needed, please call 800-767-6552 to speak with a VWGoA Parts Specialist.
Takata Recall Reminder / 69Q9 Vehicles with Criteria SP-Towing & Loaner Vehicle
Recall Reminder Part Labels
Effective immediately, TK Services Inc.
Read full bulletin
will resume scheduling part pick-up from dealerships and service centers.
Takata Incentive Program - Safety Recalls 69Q8 and 69Q9
This Document informs dealers on the the Frequently Asked Questions for the new Water Pump Limited Warranty Extension
This Document informs dealers on the the new Water Pump Limited Warranty Extension
Technical Bulletin (Wiper Blade Inspection for Proper Warranty Coding): Wiper blade inspection guidelines for wear and...
Read full bulletin
tear, outside influence and factory defect.
Tech Tips (All Models 2000-2014 - Part ordering): If a needed service part is on back order, upgrade the daily order...
Read full bulletin
to a red order and check the ?Car Down? box to escalate the order. This document informs how to contact VWGoA Parts Specialist for help.
Technical Bulletin (Wiper Blade Inspection for Proper Warranty Coding): Wiper blade inspection guidelines for wear and...
Read full bulletin
tear, outside influence and factory defect.
Tech Tips (All Models 2000-2014 - Part ordering): If a needed service part is on back order, upgrade the daily order...
Read full bulletin
to a red order and check the ?Car Down? box to escalate the order. This document informs how to contact VWGoA Parts Specialist for help.
This Document informs dealers on the Revised VWP-18-07.
Read full bulletin
New info on 10% maintenance intervals
Vacuum line inspection for specific DTCS.
Campaign Tip - 69M8 and 69M9 - Takata part label Information
Passat Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections: A checklist to insure a customer...
Read full bulletin
receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has purchased
Technical Bulletin (Wiper Blade Inspection for Proper Warranty Coding): Wiper blade inspection guidelines for wear...
Read full bulletin
and tear, outside influence or a factory issue. This document informs what is under coverage for wiper blade issues.
Passat Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections: A checklist to insure a customer...
Read full bulletin
receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has purchased
Technical Bulletin (Damage on External Chrome or Aluminum Surfaces) The surfaces of chrome parts can get damaged in...
Read full bulletin
the production process or by external influences. This document discusses options for repairs covered under warranty, and methods to prevent damage.
VOLKSWAGEN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER.
Read full bulletin
WHEN TRYING TO START THERE MAY BE AN EXTENDED CRANK OR NO START. 2006-2010 PASSAT. *RM
VOLKSWAGEN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER.
Read full bulletin
WHEN TRYING TO START THE VEHICLE THERE IS A LONG CRANK OR NO START CONDITION. 2009-2010 PASSAT. *RM
VOLKSWAGEN: THERE IS A WARRANTY EXTENSION ON HARD START CONDITIONS FOR CUSTOMERS WHO HAD AN EARLIER CAMPAIGN ADDRESSED ON THEIR VEHICLES.
Read full bulletin
*RM
Transmission
29 bulletinsDTC P2711 Implausible Transmission Shift Sequence Stored in the Transmission Control Module
DTC P2711 Implausible Transmission Shift Sequence Stored in the Transmission Control Module
DTC P2711 Implausible Transmission Shift Sequence Stored in the Transmission Control Module
When diagnosing a generator charging concern, it is recommended to verify operation of the one way clutch located in the...
Read full bulletin
generator pulley (if equipped) before replacing generator assembly. To check the one way clutch, remove the belt from the generator pulley and use a trim removal tool to hold fan blades inside generator, as shown below. When attempting to turn pulley by hand with fan blades held, pulley should spin freely in only one direction. If pulley spins freely in both directions, the one way clutch has failed and should be replaced before continuing diagnosis.
This bulletin provides a procedure to determine ?repair? versus ?replacement? of an automatic transmission.
Read full bulletin
This procedure is to be used ?After? the transmission has been removed from the vehicle.
Auto Trans fluid requirements.
Addressing Transmission Fluid Temperature Sensor Concerns, update authing system metadata.
Addressing Transmission Fluid Temperature Sensor Concerns, update authing system metadata.
Addressing Transmission Fluid Temperature Sensor Concerns, update authing system metadata.
Addressing Transmission Fluid Temperature Sensor Concerns, update authing system metadata.
Update to model year applicability and existing tip for Dual clutch basic settings procedure.
Update model year applicability and existing tip for transmission basic settings direction.
Update to model year applicability and existing tip for Dual clutch basic settings procedure.
Update model year applicability and existing tip for transmission basic settings direction.
On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex)
On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex)
On-car analysis list of Customer Complaints: Transmission
On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex)
On-car analysis list of customer complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex)
On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex)
On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex)
On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex)
Tech Tips: Generator Charging Concern Diagnosis Tip - One Way Clutch Pulley Testing
REMINDER TO FOLLOW THE CORRECT REPAIR PROCEDURE OF PILOT BEARING REPLACEMENT, WHEN REMOVING AND RE-INSTALLING THE DSG...
Read full bulletin
TRANSMISSION
VOLKSWAGEN: THE TRANSMISSION CONTROL MODULE HAS AN IMPLAUSIBLE TRANSMISSION SHIFT SEQUENCE DUE TO THE CLUTCH ASSEMBLY HAVING DEBRIS IN IT.
Read full bulletin
8PE
VOLKSWAGEN: THE GEAR BOX HAS A MOMENTARILY DELAY WHILE ACCELERATING.
Read full bulletin
*RM
VOLKSWAGEN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER.
Read full bulletin
IN SOME VEHICLES IT IS POSSIBLE THAT A BUSHING INSIDE THE MECHATRONIC UNIT HAS THE POTENTIAL TO WEAR OUT PREMATURELY, CAUSING THE CLUTCHES INSIDE THE TRANSMISSION TO OPERATE LESS SMOOTHLY THAN BEFORE. THE DRIVER WILL BEGIN TO NOTICE CHANGES IN THE WAY THE VEHICLE FEELS AS THE TRANSMISSION SHIFTS (JERKING). THIS CHANGE CAN BECOME VERY PRONOUNCED, THE VEHICLE REMAINS SAFE TO DRIVE. *PE
VOLKSWAGEN: CONCERNS REGARDING FLUID LEAKING FROM THE TRANSMISSION AREA, INSPECT THE TRANSMISSION OIL PAN'S ATF INSPECTION PLUG.
Read full bulletin
*PE
VOLKSWAGEN: EXHAUST HEAT SHIELD, REPLACEMENT GUIDELINES.
Read full bulletin
HEAT SHIELDS ARE TO BE INSPECTED AFTER COMPLETION O ANY TYPE OF REPAIR TO THE UNDERBODY (EXHAUST SYSTEM TRANSMISSION, ETC.), AND IF DAMAGED, REPLACED. *PE
Infotainment
28 bulletinsSatellite Radio Overview
RNS 510 ? Radio Preset Display
Replacement Radio/Navigation Unit has no Sound
Replacement Radio/Navigation Unit has no Sound
Vehicles Equipped with Bluetooth Hands-Free Phone ? Pairing of Android Phones
All Vehicles with Bluetooth Phone Kit Installed ? Streaming Audio from Phone to Radio
Satellite Radio Overview
When performing SVM updates, the scan tool should be hardwired to the vehicle and the Bluetooth physically turned off.
Read full bulletin
A hard wired internet connection is also recommended.
Be aware that the 24 RNS-510 radio presets are not band dependent, and can be programmed to any mix of AM, FM, or satellite stations.
Read full bulletin
The presets shown on the display will not change when switching between bands.
For concerns of navigation inaccuracy, with or without antenna fault codes, begin by checking the number of received...
Read full bulletin
satellites in the area of the concern. This can be accomplished by following the instruction in Technical Bulletin 2023490 Antenna Diagnosis Overview.
Replacement RNS 510 radio/navigation units may be shipped in transportation safeguard mode and therefore will have no sound output.
Read full bulletin
In order to switch the unit out of this mode, hold down the forward seek button, the back seek button, and the music button at the same time until the unit shuts down. Once the unit is powered back ?ON? the safeguard mode will be deactivated.
Replacement RNS 510 radio/navigation units may be shipped in transportation safeguard mode and therefore will have no sound output.
Read full bulletin
In order to switch the unit out of this mode, hold down the forward seek button, the back seek button, and the music button at the same time until the unit shuts down. Once the unit is powered back ?ON? the safeguard mode will be deactivated.
When pairing an Android phone to the Bluetooth system, a few extra steps may be necessary.
Read full bulletin
Follow the instructions below to pair the phone:
The streaming music feature on vehicles equipped with factory or dealer installed Bluetooth will be available only in certain instances.
Read full bulletin
The vehicle must be equipped with the RCD 310 or RCD 510 (Premium 8) radios or the RNS 510 or RNS 315 navigation systems. The Bluetooth system must be either the UHV low (9W2), UHV?NAR (9W7 or 9ZR) factory installed systems or the Volk ? L dealer installed system.
Radio knob replacement instead of radio replacement w/ knob part number.
Elsa2Go campaign information is now 100% aligned with ElsaPro.
Read full bulletin
This update to Elsa2Go ensures that both systems are displaying the same campaign information, including OPEN/CLOSED status, repair date as well as criterions at the same time without any discrepancy.
Cam screen damage.
Alternative method for radio code retrieval.
Technical Bulletin (Bluetooth System Identification): This document informs of the method to understand how to identify...
Read full bulletin
the various Bluetooth systems by: ? Visual Identification ? PR Code ? Part Number
Technical Bulletin (Bluetooth System Identification): This document informs of the method to understand how to identify...
Read full bulletin
the various Bluetooth systems by: ? Visual Identification ? PR Code ? Part Number
Alternative method for radio code retrieval.
Tech Tips (Instrument Cluster Production Mode): During PDI, or after installation of a replacement cluster, ?Pro? may...
Read full bulletin
be displayed in place of the odometer. The high beam indicator may be flashing in the instrument cluster as well. This indicates the cluster is in Production mode. Production mode is not the same as ?Transport? mode. This document infroms of the difference between Production, and Transport mode.
Technical Bulletin (Bluetooth System Identification): This document informs how to identify the various Bluetooth...
Read full bulletin
systems by: ? Visual Identification ? PR Code ? Part Number
Tech Tips (Instrument Cluster Production Mode): This document informs the procedure to remove the production mode...
Read full bulletin
setting when it is displayed in the instrument cluster.
Tech Tips (SVM Update Instructions): This document informs when performing SVM updates, the scan tool should be...
Read full bulletin
hardwired to the vehicle and the Bluetooth physically turned off. A hard wired internet connection is also recommended.
Tech Tips (RNS 510? Replacement Radio/Navigation Unit has no Sound): Replacement RNS 510 radio/navigation units may...
Read full bulletin
be shipped in transportation safeguard mode and therefore will have no sound output. This document informs how to deactivate the safeguard mode.
DIRECTIONS TO DEACTIVATE TRANSPORT SAFEGUARD MODE IN REPLACEMENT RADIOS.
Read full bulletin
NO DIRECTIONS TO ADDRESS THIS IN THE REPAIR MANUAL OR SCAN TOOL.
DIRECTIONS TO DEACTIVATE TRANSPORT SAFEGUARD MODE IN REPLACEMENT RADIOS.
Read full bulletin
NO DIRECTIONS TO ADDRESS THIS IN THE REPAIR MANUAL OR SCAN TOOL.
Lighting
16 bulletinsExterior Lights, Moisture Accumulation
Exterior Lights, Moisture Accumulation
Exterior Lights, Moisture Accumulation
Exterior Lights, Moisture Accumulation
Exterior Lights, Moisture Accumulation
Exterior Lights, Moisture Accumulation
Exterior Lights, Moisture Accumulation.
Read full bulletin
Update model year applicability to include 2022.
Exterior lighting moisture in lens updated to exclude LED lighting.
Adaptive front lighting descriptive
Condensation and or water droplets visible on inside of exterior light lenses.
Read full bulletin
TB updated to include model year 2019 applicability.
Warranty Information (Regularly Scheduled Maintenance Interval Time or Mileage Guidelines): The Volkswagen Customer...
Read full bulletin
Experience Team has monitored the claims processed through the Carefree Maintenance (CFM) program from its inception. Their findings reveal that, in many cases, the first maintenance interval service (10K) has been claimed multiple times while subsequent maintenance interval services (20K and 30K), although being performed for the customer, have been submitted erroneously. It is crucial that Volkswagen of America receives accurate claim coding information regarding the Carefree Maintenance (CFM) Program. Accurate claim data enables Volkswagen to assist Dealers to improve their CFM penetration and customer return rates. In addition, it allows VWoA to assess the perceived benefits of the program to our customers. To assist Dealer Service Departments in determining the most appropriate service number and maintenance interval to use, Volkswagen has established the guidelines in this document.
Warranty Information (Regularly Scheduled Maintenance Interval Time or Mileage Guidelines): The Volkswagen Customer...
Read full bulletin
Experience Team has monitored the claims processed through the Carefree Maintenance (CFM) program from its inception. Their findings reveal that, in many cases, the first maintenance interval service (10K) has been claimed multiple times while subsequent maintenance interval services (20K and 30K), although being performed for the customer, have been submitted erroneously. It is crucial that Volkswagen of America receives accurate claim coding information regarding the Carefree Maintenance (CFM) Program. Accurate claim data enables Volkswagen to assist Dealers to improve their CFM penetration and customer return rates. In addition, it allows VWoA to assess the perceived benefits of the program to our customers. To assist Dealer Service Departments in determining the most appropriate service number and maintenance interval to use, Volkswagen has established the guidelines in this document.
Technical Bulletin (Factory Installed Media-In (MDI), Updated Programming for Various iPod Concerns): The update...
Read full bulletin
programming procedure in this document addresses the following concerns: ? Music skips at beginning of track. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also available.
Technical Bulletin (Exterior Lights, Moisture Accumulation): Exterior light assemblies (headlights, taillights, fog...
Read full bulletin
lights, turn signals) are vented and may collect moisture on their inner surfaces, depending on humidity and other climatic changes. This document discusses necessary to diagnosis, and potential remedy of the issue.
Technical Bulletin: Condensation and or water droplets becomming visible on inside of exterior light lenses issue is...
Read full bulletin
discussed in this document
Technical Bulletin (Exterior Lights, Moisture Accumulation): This document informs of the Condensation and or water...
Read full bulletin
droplets visible on inside of exterior light lenses. The document also informs how to service the issue.
HVAC & Climate
16 bulletinsReporting procedure for A/C compressor replacement regardless of the reason for failure.
Read full bulletin
Update to model year applicability and new warranty GFF labor operation number
HVAC, Unpleasant Odor
HVAC, Unpleasant Odor
HVAC, Unpleasant Odor
A/C requirements, update to model year applicability.
A/C Compressor replacement requirements, updated to include additional model year applicability.
Removing musty odor from A/C system.
Read full bulletin
Updated to include additional model and model year applicability.
A/C requirements, update to title.
Statement referring to TB 2043893 removed.
Read full bulletin
To include additional models and model year applicability. A.C. Compressor Replacement, GFF Required Regardless of Concern and Flush Requirement
Technical Bulletin (HVAC, Unpleasant Odor): An unpleasant odor is coming from Heating and Ventilation system.
Read full bulletin
Odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first started. Contaminants are effectively neutralized using the AIRCOMATIC? II Ultrasonic Climate System Cleaner (VAS 6189A) or AIRCOMATIC III Ultrasonic Climate System Cleaner (VAS 6189B) and AIRCO-CLEAN Ultrasonic HVAC Treatment (30208). All other cleaning methods are no longer permitted. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also available.
Technical Bulletin (HVAC, Unpleasant Odor): An unpleasant odor is coming from Heating and Ventilation system.
Read full bulletin
Odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first started. Contaminants are effectively neutralized using the AIRCOMATIC? II Ultrasonic Climate System Cleaner (VAS 6189A) or AIRCOMATIC? III Ultrasonic Climate System Cleaner (VAS 6189B) and AIRCO-CLEAN? Ultrasonic HVAC Treatment (30208). All other cleaning methods are no longer permitted. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also available.
Technical Bulletin (HVAC, Unpleasant Odor): Unpleasant odor is coming from Heating and Ventilation system.
Read full bulletin
Odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first started. Condensation is a normal characteristic in all A/C systems. If odor is noticeable continue to follow this document. Contaminants are effectively neutralized using the AIRCOMATIC? II Ultrasonic Climate System Cleaner (VAS 6189A) or AIRCOMATIC? III Ultrasonic Climate System Cleaner (VAS 6189B) and AIRCO-CLEAN? Ultrasonic HVAC Treatment (30208). All other cleaning methods are no longer permitted. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also available.
Technical Bulletin (HVAC, Unpleasant Odor): Unpleasant odor is coming from Heating and Ventilation system.
Read full bulletin
Odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first started. This document contains information on how to diagnose, and service this issue.
DIRECTION TO PERFORM SYSTEM RESET AFTER COMPONENT REPLACMENT OR DISCONNECT OF THE HVAC SYSTEM CONTROL HEAD.
Read full bulletin
NO TEST PLAN INFORMATION TO ADDRESS THIS.
DIRECTION TO PERFORM SYSTEM RESET AFTER COMPONENT REPLACMENT OR DISCONNECT OF THE HVAC SYSTEM CONTROL HEAD.
Read full bulletin
NO TEST PLAN INFORMATION TO ADDRESS THIS.
VOLKSWAGEN: HVAC BLOWER ONLY OPERATES ON HIGH SPEED (US ONLY).
Read full bulletin
FRESH AIR BLOWER RUNS ONLY AT HIGHEST LEVEL. BECAUSE OF PERMANENT FROST AND SNOWFALL FINE SNOW CAN GET INTO THE FRESH AIR BLOWER VIA THE AIR INTAKE. *PE
Brakes
15 bulletinsMDI Functions with iPhone 5 Variants (5, 5c, 5s and iPad fourth generation, iPod Nano seventh generation)
MDI Control of Apple Devices with Lightning Connector (iPhone 5, iPad fourth generation, iPod Nano seventh generation)
If fault code 03200 or 16352 is present in the Electromechanical Parking Brake (EPB) module, it may be due to the switch...
Read full bulletin
and module not being synchronized.
If, after replacement of the steering rack, fault code 01309 008 is set in the ABS/ESP module only, follow the test plan...
Read full bulletin
in GFF for Driver Steering Recommendation (DSR) or channel 3 activation. If the test plan fails to clear the fault, follow the direction below using Vehicle Self Diagnosis in Address Word 44 - Steering Assistance
The Apple iPhone 5, iPad fourth generation, and iPod nano seventh generation use a proprietary ?Lightning? connector...
Read full bulletin
that is different than the 30 pin dock connector found on previous iPhone and iPod models.
Strut or Shock Absorber Leak Assesment.
"Instructional document regarding the installation of a hotfix for the ODIS service software.
Read full bulletin
Hotfix is to be used during the following actions: Brake Electronics (ABS) A3 Passat NMS Software Configuration/Coding
Antilock brake function test direction.
Antilock brake function test direction.
Tech Tips (Electro - Steering issues): If, after replacement of the steering rack, fault code 01309 008 is set in the...
Read full bulletin
ABS/ESP module only, follow the test plan in GFF for Driver Steering Recommendation (DSR) or channel 3 activation. If the test plan fails to clear the fault, follow the directions in this document
Tech Tips (MDI Functions with iPhone 5 Variants (5, 5c, 5s and iPad fourth generation, iPod Nano seventh generation)): ...
Read full bulletin
The Apple iPhone 5, iPhone 5c, and iPhone 5s, as well as the iPad 4th generation and iPod Nano 7th generation use a proprietary ?Lightning? connector that is different than the 30-pin dock connector found on previous iPhone and iPad/iPod models. A new MDI cable (?MDI Adapter Cable ? Lightning Charger?) is now available through the VW Accessories eCatalog that is made for use with iPhone 5 variants as well as the previously mentioned iPad/iPod models. This cable should provide full functionality on any vehicle equipped with a UMI (Unified Multimedia Interface). On MY 13 and older vehicles equipped with an MDI, the software level of the MDI must be at or above SW 240 (see Technical Bulletin 2024337) in order to be fully functional.
Tech Tips (Electro ? Steering - DTC 01309 008 ?No Communication with -J500-? is Stored in the ABS/ESP Module Only): ...
Read full bulletin
This document informs If, after replacement of the steering rack, fault code 01309 008 is set in the ABS/ESP module only, follow the test plan in GFF for Driver Steering Recommendation (DSR) or channel 3 activation. If the test plan fails to clear the fault, follow the directions in this document using Vehicle Self Diagnosis in Address Word 44 - Steering Assistance:
VOLKSWAGEN: STEERING RACK.
Read full bulletin
AFTER REPLACING THE STEERING RACK THE FAULT CODE 01309 008 IS SET IN ABS/ESP MODULE. ALSO INCLUDED MODEL GTI MY 2013, MODEL TIGUAN MY 2005-2007, MODEL RABBIT MY 2005/2011-2013, MODEL EOS MY 2005/2013, MODEL CC MY 2005-2008*JS
VOLKSWAGEN: UPDATE INFORMATION ON MODELS AND MODEL YEARS REGARDING SYNCHRONIZATION OF ELECTROMECHANICAL PARKING BRAKE...
Read full bulletin
(EPB) MODULE AND DUE TO SWITCH AND MODULE NOT BEING SYNCHRONIZED, FAULT CODES FOUND. MODELS 2006-2010 PASSAT, 2009-2013 CC, TIGUAN. *PE
VOLKSWAGEN: SOFTWARE PARAMETERS IN ABS MODULE CAUSE UNNECESSARY FAULT CODE 02543-0089 VACUUM SENSOR IMPLAUSIBLE SIGNAL.
Read full bulletin
SW PROGRAMMING UPDATE CORRECTS THE SYSTEM REACTION. *PE
Suspension
3 bulletinsWhat is and what is not a leaking suspension strut.
How to identify and when to replace a leaking strut
Strut or Shock leak assessment.
Tires & Wheels
2 bulletinsThe use of tire dressing gives your tires that shiny finish that completes the image of a clean (new) vehicle.
Read full bulletin
There are many different tire dressing products available. When choosing a product please pay close attention to its contents. Always use a water based product.
Tire Chain Information (for California dealers only) All Model Years.
Read full bulletin
Information only for all other dealers.
Hybrid & EV
1 bulletinCampaign Reminder Communication.
Read full bulletin
Also includes: 1998-2004 Beetle, 2003-2004 Beetle Convertible, 2019 Beetle Convertible, 1994-2004 Eurovan, 1994-2004 Golf, 1994-2004 Jetta, 2001-2004 Jetta Wagon, 2018-2019 Tiguan LWB, 1994-2004 Passat, 1994-2004 Passat Wagon, 2004 Phaeton, 2013-2016 Jetta Hybrid, 2004 R32 and 1995-2006 Cabrio.