2006 Volkswagen Passat TSBs
521 Technical Service Bulletins across 16 categories
Categories
Engine
117 bulletinsEngine Oils Which Meet Volkswagen Oil Quality Standard VW 502 00/505 00/505 01 and VW 504 00/507 00
Oil Consumption Measurement
Oil Consumption Measurement
Oil Consumption Measurement
Engine, Misfire Diagnostic Aid
Engine, Misfire Diagnostic Aid
Fuel Additive to Help Prevent Sporadic Misfire Faults
Fuel Additive to Help Prevent Sporadic Misfire Faults
Fuel Additive to Help Prevent Sporadic Misfire Faults
Fuel Additive to Help Prevent Sporadic Misfire Faults
Update to Volkswagen engine oil standards
To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line.
Read full bulletin
The check must be performed with the engine running and heated rear window switched on. Switch OFF the ignition and visually locate the damage. Proceed with checking any other lines as necessary. Once the damaged line is identified, repair utilizing the Repair kit by Permatex ITEM 09117.
Use the diagram below to test the N75 Solenoid Valve in the event of a turbocharger fault code such as P0299 or P0234.
Read full bulletin
This applies to Mechanical Injection Style Diesel Engines, Pumpe Duse Style Diesel Engines and the new Common Rail Style Diesel Engines.
If replacing the high pressure fuel pump, also remove and inspect the cam follower from the timing cover/cylinder head to inspect it for wear.
Read full bulletin
If wear is found, contact the Volkswagen Dealer Technician Helpline Powertrain Team for additional instructions.
Incorrect torque converter or flywheel/flexplate installation can result in transmission damage.
Read full bulletin
When installing an engine, flywheel or transmission, please follow the installation procedures outlined in ELSA. For the flywheel/flexplate, please be certain the correct shim is installed between it and the crankshaft (reference VWIQ120). When installing a torque converter, press the torque converter hub through the seal as far as the first stop. Turn the torque converter while pushing toward the transmission using light force, until the cut outs in the torque converter hub lock into the pump wheel plate. The torque converter slides in. The torque converter is installed correctly if it is easy to turn by hand and if it fits evenly in the transmission bell housing. Additionally, it should spin freely when the transmission bell housing bolts are torqued to the engine block, prior to installation of the flywheel to converter bolts (reference VWIQ121).
If mechanical damage is found to the turbocharger (e.g.
Read full bulletin
damaged compression wheel, loose or broken shaft), it is not enough to just replace the turbocharger.
When diagnosis on the above engine leads to the testing of the N75, please refer to the picture below.
Read full bulletin
The diagram shows which vacuum ports on the N75 valve should hold vacuum and which ones should not.
Volkswagen Engine oil quality standards, update to attachments.
Fuel Additive to Help Prevent Sporadic Misfire Faults
Fuel additive to help prevent sporadic misfire faults.
Engine oil quality standards, update to attachments.
In conjunction with the Georgia Department of Revenue - Motor Vehicle Division and Department of Driver Services,...
Read full bulletin
Volkswagen sent Takata airbag recall reminder notices to approximately 158 Volkswagen owners in the State of Puerto Rico on July 25, 2022.
In conjunction with the Georgia Department of Revenue - Motor Vehicle Division and Department of Driver Services,...
Read full bulletin
Volkswagen sent Takata airbag recall reminder notices to approximately 158 Volkswagen owners in the State of Puerto Rico on July 25, 2022.
In conjunction with the Georgia Department of Revenue - Motor Vehicle Division and Department of Driver Services,...
Read full bulletin
Volkswagen sent Takata airbag recall reminder notices to approximately 4,588 Volkswagen owners in the State of Georgia on June 22, 2022.
In conjunction with the California Department of Motor Vehicles (DMV), Volkswagen sent Takata airbag recall reminder...
Read full bulletin
notices to approximately 7,152 Volkswagen owners in the State of California on April 29, 2022.
Update engine oil quality standard lists (attachments)
Update engine oil quality standard lists (attachments)
Update engine oil quality standard lists (attachments)
Update engine oil quality standard lists (attachments)
Update engine oil quality standard lists (attachments)
Update engine oil quality standard lists (attachments)
Update engine oil quality standard lists (attachments)
Engine oil consumption measurement.
Fuel Additive to Help Prevent Sporadic Misfire Faults
Update engine oil quality standard lists (attachments)
Update engine oil quality standard lists (attachments)
Update engine oil quality standard lists (attachments)
Updated to include update recommended engine oil attachments.
Body surfaces (engine compartment and underside of hood) are not directly visible (exposed) therefore do not match...
Read full bulletin
exterior paint finish.
Oil consumption test updated to include additional models and model year applicability.
Oil pressure priming after engine replacement or internal repair.
Update to Volkswagen engine oil specification attachments.
Update to Volkswagen engine oil specification attachments.
Update to Volkswagen engine oil specification attachments.
Update to Volkswagen engine oil standards.
Update to Volkswagen engine oil standards.
In conjunction with the Florida Dept.
Read full bulletin
of Highway Safety and Motor Vehicles, Volkswagen will be sending Takata airbag recall reminder notices to approximately 20,200 Volkswagen owners in the state of Florida on October 14, 2019.
Update to Volkswagen engine oil standards.
Update to Volkswagen engine oil standards.
Read full bulletin
Also includes 2004 and 2005 Jetta Wagon and 2018-2020 Tiguan LWB
Engine oil quality standards.
Read full bulletin
Also includes all models for 1997-2003. Also Rabbit from 2006-2009.
In conjunction with the New York Department of Motor Vehicles, Volkswagen will be sending Takata airbag recall reminder...
Read full bulletin
notices to approximately 11,500 Volkswagen owners in the state of New York on May 23, 2019.
Engine Oils Which Meet Volkswagen Oil Quality Standards
Supersedes Technical Bulletin 24-17 03 (V241703) dated March 6, 2017 for information regarding a new style solenoid...
Read full bulletin
valve for Intake Manifold Flap
Ensure correct intake manifold is installed on engine, refer to ETKA.
Gasoline Engine Misfire Diagnosis document
Tech Tips (N75 Solenoid Valve Diagnosis): This document informs with a diagram which vacuum ports on the N75 valve...
Read full bulletin
should hold vacuum and which ones should not for diagnosis on the Vehicles with 2.0T Gasoline Engine (Engine Codes BPY, CCTA, CBFA) to the testing of the N75
Engine Control Module Updates: This document informs of complaints, and the software updates/Tech Bulletins associated...
Read full bulletin
with servicing engine control module issues:
Technical Bulletin (Hood, Under Hood Not Painted Body Color): The paint color and/or finish of the engine compartment...
Read full bulletin
and underside of hood may not match the exterior paint color of the vehicle. Depending on vehicle model and production plant, the color of the engine compartment and underside hood may not match the vehicle body color. This document informs dealers to let their customers know that these body surfaces (engine compartment and underside of hood) are not directly visible (exposed) and therefore do not require the same finish as visible, exterior surfaces.
Technical Bulletin (Front Suspension, Knocking Noise): A Knocking noise from vehicle front.
Read full bulletin
Typically occurs only one time after each direction change (forward or backward, left or right). The sub frame shifts slightly relative to the body due to wax residue in-between components. Maximum acceleration and braking in vehicles that are driven hard are contributors to the occurrence. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also available.
Tech Tips (2.0 Turbo FSI (BPY) High Pressure Fuel Pump Replacement): If replacing the high pressure fuel pump, also...
Read full bulletin
remove and inspect the cam follower from the timing cover/cylinder head to inspect it for wear. If wear is found, contact the Volkswagen Dealer Technician Helpline Powertrain Team for additional instructions. This document also provides a diagram to look for issues.
Technical Bulletin (Electric Coolant Fans Continue to Run after Ignition is Switched OFF): This document informs it...
Read full bulletin
is considered normal operation for the electric coolant fans to continue to run for up to 15 minutes after the ignition is switched off in gasoline engine applications, and up to 16 minutes in diesel engine applications.
Technical Bulletin (Oil Consumption Measurement): Customers have stated oil consumption is higher than the Volkswagen...
Read full bulletin
oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. This document informs how to test the oil consumption rate
Tech Tips (N75 Solenoid Valve Diagnosis): This document informs with a diagram which vacuum ports on the N75 valve...
Read full bulletin
should hold vacuum and which ones should not for diagnosis on the Vehicles with 2.0T Gasoline Engine (Engine Codes BPY, CCTA, CBFA) to the testing of the N75
Engine Control Module Updates: This document informs of complaints, and the software updates / Tech Bulletins...
Read full bulletin
associated with servicing engine control module issues:
Technical Bulletin (Hood, Under Hood Not Painted Body Color): The paint color and/or finish of the engine compartment...
Read full bulletin
and underside of hood may not match the exterior paint color of the vehicle. Depending on vehicle model and production plant, the color of the engine compartment and underside hood may not match the vehicle body color. This document informs dealers to let their customers know that these body surfaces (engine compartment and underside of hood) are not directly visible (exposed) and therefore do not require the same finish as visible, exterior surfaces.
Technical Bulletin (Front Suspension, Knocking Noise): A Knocking noise from vehicle front.
Read full bulletin
Typically occurs only one time after each direction change (forward or backward, left or right). The sub frame shifts slightly relative to the body due to wax residue in-between components. Maximum acceleration and braking in vehicles that are driven hard are contributors to the occurrence. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also available.
Tech Tips (2.0 Turbo FSI (BPY) High Pressure Fuel Pump Replacement): If replacing the high pressure fuel pump, also...
Read full bulletin
remove and inspect the cam follower from the timing cover/cylinder head to inspect it for wear. If wear is found, contact the Volkswagen Dealer Technician Helpline Powertrain Team for additional instructions. This document also provides a diagram to look for issues.
Technical Bulletin (Electric Coolant Fans Continue to Run after Ignition is Switched OFF): This document informs it...
Read full bulletin
is considered normal operation for the electric coolant fans to continue to run for up to 15 minutes after the ignition is switched off in gasoline engine applications, and up to 16 minutes in diesel engine applications.
Technical Bulletin (Oil Consumption Measurement): Customers have stated oil consumption is higher than the Volkswagen...
Read full bulletin
oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. This document informs how to test the oil consumption rate
Incorrect removal of Turbocharger oil feed line may cause engine damage
Engine replacement tip
17 17 01 July 5, 2017 2012855 Supersedes Technical Bulletin 17-16-02 (V171602) dated April 29, 2016 due to updated oil...
Read full bulletin
standards lists to current specifications. Engine Oils Which Meet Volkswagen Oil Quality Standards
A Volkswagen FLUID CAPACITY CHART which contains the various fluids necessary for a vehicle to run Cateorgories include...
Read full bulletin
(Engine Oil, Manual Transmission, Automatic Transmission, Differential Automatic Transmission, Cooling System, Power Steering, Windshield Washer, A/C Refrigerant, A/C Refrigerant Oil
Tech Tips (Equipped with Turbocharged Engine Turbocharger Replacement Tip): If mechanical damage is found to the turbocharger (e.g.
Read full bulletin
damaged compression wheel, loose or broken shaft), it is not enough to just replace the turbocharger. This document informs the procedure of checks for damage.
Technical Bulletin (Oil Consumption Measurement): Customer states oil consumption is higher than the Volkswagen oil...
Read full bulletin
consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. In order to provide effective lubrication and cooling of internal engine components, all internal combustion engines consume a certain amount of engine oil. Oil consumption varies from engine to engine and may change significantly over the life of the engine. Typically, engines with specified break-in periods consume more oil during the break-in period, and the oil consumption will stabilize after the break-in period. This document informs of oil consumption tests to check a vehicles performance.
Tech Tips (Technician Helpline Vehicle Check Sheets): When it becomes necessary to open a VW Technician Helpline VTA...
Read full bulletin
case while performing diagnosis for a diesel particulate filter, manual transmission repair, or turbocharger concern, it is recommended to complete the related worksheet/check sheet before calling. This document informs where Worksheets/Check Sheets are available on ServiceNet.
Tech Tips 92006-2014 Vehicles with 2.0T Gasoline Engine - N75 Solenoid Valve Diagnosis): When diagnosis on the above...
Read full bulletin
engine leads to the testing of the N75, please refer this document with graphical aid. The diagram shows which vacuum ports on the N75 valve should hold vacuum and which ones should not. Turbocharger fault codes P0299 and P0234 can be diagnosed using this test.
Tech Tips (2.0L FSI (BPY) Engines - Low Fuel Pressure DTCs (P310B)): This document informs on how to check fuel...
Read full bulletin
pressure If you have a complaint of DTCs for the low side fuel pressure being out of specification
Technical Bulletin (HVAC, Unpleasant Odor): Condensation, which is a normal condition in all A/C systems, can cause a musty odor.
Read full bulletin
If the odor is noticeable in the vehicle when the engine is not turned on, the cause may be mold and mildew in the passenger compartment, and not be related to the A/C system. All other possible sources of the odor must be investigated before this document can be performed. This document contains the procedure for the VW method to remove musty odors
Technical Bulletin The use of contaminated gasoline, seasonal fuel changes (summer/winter fuel) or gasoline with a low...
Read full bulletin
content of deposit control additives may result in one or more of the following conditions: -Excessive accumulation of deposits on intake valves, intake manifold, fuel injectors and combustion chambers. -Engine runs rough after cold start. -Excessive engine cranking time. -Stumbles while driving. -Rough engine idle. -Loss of engine performance. -Poor fuel economy. This document informs of the procedure for the vehicle if it is diagnoised with poor quality gas
Technical Bulletin (Fuel Rail / System Pressure, Fuel Trim, and Fuel Pressure issues): This document informs of...
Read full bulletin
Excessive wear of intake camshaft lobe that drives the high pressure fuel pump. The wear limits maximum pump piston lift, causing fuel rail pressure fluctuations. The wear on the camshaft lobe can also lead to wear on the base of the high pressure fuel pump cam follower. The product solution for this issue was to Increase surface hardening of camshaft lobe for the high pressure fuel pump.
Remove engine coolant from parts table.
Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt...
Read full bulletin
meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engine running and heated rear window switched on. Switch OFF the ignition and visually locate the damage.
Technical Bulletin (Rear Door Glass Inoperative): The rear glass cannot be opened / closed, the rear glass may slide...
Read full bulletin
down into the door, or the rear glass motor operates but the glass does not move. This document contains the fault codes, and procedure to service these issues
Technical Bulletin (Fuel Additive to Help Prevent Sporadic Misfire Faults): Fuel quality impacts the operating...
Read full bulletin
performance, efficiency and service life of the engine. The use of poor quality fuels may result in deposit build up on the fuel injectors and intake valves. This may result in a rough running condition, sporadic misfires, or cold start misfire faults storing in the ECM fault memory. This document informs a Volkswagen approved fuel additive is available to help remove and prevent deposits on fuel injectors and intake valves.
Technical Bulletin (Fuel Additive to Help Prevent Sporadic Misfire Faults): Fuel quality impacts the operating...
Read full bulletin
performance, efficiency and service life of the engine. The use of poor quality fuels may result in deposit build up on the fuel injectors and intake valves. This may result in a rough running condition, sporadic misfires, or cold start misfire faults storing in the ECM fault memory. A Volkswagen approved fuel additive is available to help remove and prevent deposits on fuel injectors and intake valves. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also available.
Technical Bulletin (Electric Coolant Fans Continue to Run after Ignition is Switched OFF): This documentation informs...
Read full bulletin
it is considered normal operation for the electric coolant fans to continue to run for up to 15 minutes after the ignition is switched off in gasoline engine applications, and up to 16 minutes in diesel engine applications. The production solution to service this issue is that no production change is required.
Technical Bulletin (Rear Door Glass Inoperative issue diagnosis): The rear glass cannot be opened / closed, the rear...
Read full bulletin
glass may slide down into the door, or the rear glass motor operates but the glass does not move
Diagnosis of servicing camshaft lobe that drives the high pressure fuel pump.
Read full bulletin
Information of finding warrenty coverage for service
Fuel Additive to Help Prevent Sporadic Misfire Faults A Volkswagen approved fuel additive is available to help remove...
Read full bulletin
and prevent deposits on fuel injectors and intake valves.
Technical Bulletin about a customer concern stating that customer observed one or more of the shocks/struts appearing to have an oil leak.
Read full bulletin
Document contains examples of Strut or Shock Absorber Leak Assessments
Technical Bulletin (Engine Oils Which Meet Volkswagen Oil Quality Standard): This document informs of a sample list...
Read full bulletin
of products generally available in the North American market that meet the Volkswagen Oil Quality Standard
Tech Tips (2.0 Turbo FSI (BPY) High Pressure Fuel Pump Replacement): If replacing the high pressure fuel pump, also...
Read full bulletin
remove the cam follower from the timing cover/cylinder head and inspect for wear. Per Reference Technical Bulletin 2015153 (V151401). This document also provides a graphical aid to the placement of the respective parts
Technical Bulletin (Internal Control Module Memory Check Sum Errors): This document contains Updates for the Engine...
Read full bulletin
Control Module using the SVM Unit code as listed in the document to address the Memory Check Sum Errors issue. The production solution for these issues is A change to ECM software was completed in the factories as of November 2006.
Tech Tips (Torque Converter/Flywheel/Flexplate installation): Incorrect torque converter or flywheel/flexplate...
Read full bulletin
installation can result in transmission damage. When installing an engine, flywheel or transmission, please follow the installation procedures outlined in ELSA. This document also contains advice on the installation of these devices
VOLKSWAGEN: REMOVE AND INSPECT CAM FOLLOWER FROM TIMING COVER/CYLINDER HEAD, AFTER REPLACING HIGH PRESSURE FUEL PUMP, ...
Read full bulletin
FOR ANY WEAR AND IF FOUND, NOTIFY DEALER TECHNICIAN FOR ADDITIONAL INSTRUCTIONS. MODEL 2006-2007 JETTA A5, GTI, PASSAT. *PE UPDATED 12/2/14. *PE
VOLKSWAGEN: FRONT SUSPENSION, KNOCKING NOISE.
Read full bulletin
KNOCKING NOISE FROM VEHICLE FRONT. TYPICALLY OCCURS ONLY ONE TIME AFTER EACH DIRECTION CHANGE (FORWARD OR BACKWARD, LEFT OR RIGHT). THE SUB FRAME SHIFTS SLIGHTLY RELATIVE TO THE BODY DUE TO WAX RESIDUE IN-BETWEEN COMPONENTS. MAXIMUM ACCELERATION AND BRAKING IN VEHICLES THAT ARE DRIVEN HARD ARE CONTRIBUTORS TO THE OCCURRENCE. ALSO INCLUDED MODEL PASSAT YEAR 2011. *JS
VOLKSWAGEN: SEE DOCUMENT SEARCHBUTTON FOR OWNER LETTER.
Read full bulletin
UPDATE- 24W2 INTAKE FLAP MOTOR. PERFORM THIS UPDATE ON ALL APPLICABLE VEHICLES WITHIN INTAKE MANIFOLD RUNNER CONTROL WARRANTY EXT (10 YEARS OR 120,000 MILES (192, 000KM), WHICHEVER OCCURS FIRST. *JS
VOLKSWAGEN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER.
Read full bulletin
UPDATE- 17D2 POSITIVE CRANKCASE VENTILATION VALVE. IT IS MANDATORY TO PERFORM UPDATES ON ALL APPLICABLE VEHICLES IN DEALER INVENTORY PRIOR TO RETAIL SALE. *JS
VOLKSWAGEN: GASOLINE ENGINES HAVE ROUGH IDLE, HAVE SIGNIFICANT LOSS OF POWER OR STALLING WITH REDUCED PERFORMANCE.
Read full bulletin
*PE
VOLKSWAGEN: ON SOME VEHICLES, THE HIGH PRESSURE FUEL PUMP, DRIVEN BY INTAKE CAMSHAFT LOBE, CAN WEAR EXCESSIVELY.
Read full bulletin
FUEL RAIL PRESSURE FLUCTUATIONS CAUSED BY THE LIMITED PUMP PISTON LIFT. *PE
VOLKSWAGEN: INTAKE MANIFOLD RUNNER POSITION SENSOR OR INTAKE FLAP MOTOR MAY BE INOPERATIVE.
Read full bulletin
*PE
VOLKSWAGEN: CERTAIN MODEL YEAR VEHICLES MAY EXPERIENCE AN OIL FILLER CAP LEAKING, OR RUSHING NOISE FROM ENGINE OR A...
Read full bulletin
WHISTLING NOISE DUE TO CRANKCASE VENTILATION PRESSURE OR INTAKE TURBO PIPE MALFUNCTION. *PE
VOLKSWAGEN: ON CERTAIN MODEL VEHICLES THE INTAKE MANIFOLD RUNNER POSITION SENSOR OR INTAKE FLAP MOTOR COULD BE INOPERATIVE.
Read full bulletin
*PE
VOLKSWAGEN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER.
Read full bulletin
INFORMATION PERTAINING TO SOME VEHICLES INTAKE MANIFOLD RUNNER CONTROL MOTOR AND THE PCV, POSITIVE CRANKCASE VENTILATION VALVE WARRANTY. *PE
VOLKSWAGEN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER.
Read full bulletin
PRODUCTION ISSUES MAY CAUSE PREMATURE WEAR ON THE INTAKE CAMSHAFT AND CAMSHAFT FOLLOWER. MALFUNCTION LIGHT WILL ILLUMINATE. *RM
VOLKSWAGEN: EXCESSIVE WEAR OF INTAKE CAMSHAFT LOBE CAUSING FUEL PRESSURE FLUCTUATIONS.
Read full bulletin
IT CAN ALSO LEAD TO WEAR ON THE BASE OF THE FUEL PUMP CAM FOLLOWER. *RM
VOLKSWAGEN: PRODUCTION PROBLEMS MAY MAKE CAMSHAFT COMPONENTS SUSCEPTIBLE TO PREMATURE WEAR.
Read full bulletin
THIS COULD LEAD TO WEAR IN THE BASE OF THE HIGH PRESSURE FUEL PUMP CAMSHAFT FOLLOWER. THIS ISSUE DOES NOT CAUSE VEHICLE STALLING. THE MALFUNCTION LIGHT WILL BE ON WITH FAULT CODES. *RM
VOLKSWAGEN OF AMERICA: THE CAMSHAFT MAY EXPERIENCE PREMATURE WEAR.
Read full bulletin
THE MALFUNCTION LIGHT WILL ILLUMINATE. *RM
VOLKSWAGEN: MALFUNCTION LIGHT IS ON WITH THREE POSSIBLE TROUBLE CODES STORED.
Read full bulletin
THERE IS WEAR OF THE CAMSHAFT LOBE CAUSING FUEL PRESSURE FLUCTUATIONS. *RM
VOLKSWAGEN: WARRANTY INFORMATION FOR TH E TRANSMISSION VALVE BODY.
Read full bulletin
*RM
VOLKSWAGEN: GASOLINE ENGINE VEHICLES INSPECT, AND IF NECESSARY, REPLACE IGNITION COILS.
Read full bulletin
VEHICLES AFFECTED BY THIS ACTION MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. MODELS PASSAT AND WAGON; GOLF; GTI; JETTA AND WAGON; NEW BEETLE AND CONVERTIBLE; PHAETON; EOS; RABBIT, ETC. *PE
VOLKSWAGEN: MIL ON OR FLASHING, MISFIRE DTCS P0300-0312 STORED IN ECM.
Read full bulletin
THE MISFIRE CONDITION MAY BE CAUSED BY A MALFUNCTIONING IGNITION COIL. VEHICLES ARE OUT OF PRODUCTION. *PE
VOLKSWAGEN: MIL ON, DTC P0299 STORED IN ECM FAULT MEMORY.
Read full bulletin
CHARGE PRESSURE CONTROL, NEGATIVE DEVIATION. THE CONDITION MAY BE THE RESULT OF AN ABNORMAL TURBOCHARGER RECIRCULATIONG VALVE. *PE
VOLKSWAGEN: FUEL PUMP REPLACEMENT CLARIFICATION.
Read full bulletin
EXCESSIVE WEAR OF INTAKE CAMSHAFT LOBE THAT DRIVES THE HIGH PRESSURE FUEL PUMP. THE WEAR LIMITS MAXIMUM PUMP PISTON LIFT, CAUSING FUEL RAIL PRESSURE FLUCTUATIONS. THE WEAR ON THE CAMSHAFT LOBE CAN ALSO LEAD TO WEAR ON THE BASE OF THE HIGH PRESSURE FUEL PUMP CAM FOLLOWER. *PE
VOLKSWAGEN: THE POSITIVE BATTERY CABLE ON PASSAT VEHICLES WITH V6 ENGINE MAY CORRODE AND IN INDIVIDUAL CASES BREAK.
Read full bulletin
AS A RESULT, THE POWER SUPPLY MAY BE DISRUPTED AND E.G. THE VEHICLE CANNOT BE STARTED. *PE
VOLKSWAGEN: THE INTAKE FLAP MOTOR OR INTAKE MANIFOLD RUNNER POSITION SENSOR G336 MAY BE INOPERATIVE (BOTH ARE INCLUDED IN ONE SINGLE UNIT).
Read full bulletin
MODELS GOLF, GTI, A5 JETTA, GLI, EOS, PASSAT, PASSAT WAGON. *PE UPDATED 9/25/09. *PE
Other
93 bulletinsAntenna Diagnosis Overview
Damage to Data Link Connector (DLC) from Aftermarket Devices (Cannot Communicate with Vehicle OBD System)
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
Squeaks, Rattles, Noise, Repair Materials
FLUID CAPACITY CHART
FLUID CAPACITY CHART
Antenna Diagnosis Overview
Passat with MIL ON, DTC P119A
When diagnosing fault code P2279-Leaking Air in Intake System, be sure to check the cam timing first.
Contacting the parts helpline
Installation of original remote start feature accessory
This special notice is to inform dealers to return the parts listed if it meets the criteria provided.
ODIS Quick Reference Guide.
Part ordering
Diagnostic aid for DTC P0088 & P1025.
This Document informs dealers on VWP-22-03
Additional safety related Inquiry and Reporting instruction.
Parts ordering information
This special notice is to inform dealers to return the parts listed if it meets the criteria provided.
Data link diagnostics and tips
This special notice is to inform dealers to return the part numbers listed (State of California only).
Mandatory fastener.
Electronic Stabilization Program (ESP) function test may not end on its own causing DTC.
Tool number added to table.
Read full bulletin
Removal of Behr Flush Kit. VAS 6337/1A
Volkswagen After Sales Weekly Communication - March 10, 2020
Include new special tool adapter and 2018 model year Jetta only
The part number listed in the document is to be returned if it meets the criteria provided.
The part number listed in the document is to be returned.
Include additional photo's of water ingress.
Read full bulletin
Also includes 2018-2020 Tiguan LWB
TT 001202........Also includes 2005 Jetta wagon and 2018-2020 Tiguan LWB
Adhesive circular. Note: also includes 2004 Golf, Jetta, Passat, Touareg, GTI,
The part number listed in the document is to be returned if it meets the criteria provided.
This communication informs the dealers of details on the Takata parts allocation/ordering.
2006 FLUID CAPACITY CHART This document contains information on what fluids, and how much for each of them are...
Read full bulletin
necessary to have a car up and running
VAS 6154 Replacement Part Setup Guide
This communication informs the dealers of details on the Takata parts allocation/ordering.
2006 FLUID CAPACITY CHART This document contains information on what fluids, and how much for each of them are...
Read full bulletin
necessary to have a car up and running
This special notice is to inform dealers to return all part numbers listed in the document and order the superseded part...
Read full bulletin
numbers going forward.
DTC Status Bit Definitions.
To include an additional model year applicability.
Part number listed in the document to be returned if it meets the criteria provided.
This information bulletin contains instructions for checking the pins/terminals for contacts and nano contacts.
Tip for Scan tool concerns that may occur duing a test plan
This communication informs the dealers of details on the Takata parts allocation/ordering.
Reminder for dealers to reference the repair manual and replace all necessary fasteners (bolts, nuts) that cannot be...
Read full bulletin
re-used
Takata Enrollment Form
Assembly Instructions: Installation of original remote start feature accessory, Volkswagen Passat.
Tech Tips Damage to Data Link Connector (DLC) from Aftermarket Devices (Cannot Communicate with Vehicle OBD System)
This communication informs the dealers of details on the Takata parts allocation.
TECH TIP DENOTING POTENTIAL FOR DAMAGE OF THE DATA LINK CONNECTOR WHEN USING AFTER MARKET PLUG IN DEVICES OR SCAN TOOLS...
Read full bulletin
AND SUBSEQUENT DIAGNOSTIC DIRECTION.
ENHANCED DIAGNOSTIC ASSISTANCE FOR DTCS P0088 AND P1025
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
MIL ON, DTCS P0442, OR P0456 STORED (OA).
Read full bulletin
*TT
COOLANT HOSE RETENTION CLIP (B9).
Read full bulletin
CUSTOMER MAY REPORT A COOLANT ODOR, DRIPS AND POSSIBLE COOLANT SEEPAGE OR LEAK DUE TO A MISALIGNED COOLANT HOSE RETENTION CLIP. *TT
Software & Calibration
73 bulletinsODIS Service Update
Update Programming to Eliminate DTC P0601 Stored in DTC Memory
Software Version Management
In SAGA, the time units for the Volkswagen DoubleCheck labor operation were reduced in error from 50 time units to 30...
Read full bulletin
time units during the system update posted on July 4th.
Quick Reference Update Guide
Quick Reference Update Guide
Quick Reference Update Guide
Quick reference update guide.
Update model year applicability to include 2023.
Update warranty table labor operation numbers due to recent Saga updates.
Update warranty table labor operation numbers due to recent Saga updates.
This bulletin contains general instructions for software updates.
Update to model year applicability.
Update to model year applicability.
Software Version Management (SVM)
Update to brochure purchase url
Update to top tier brochure purchasing url.
Software Version Management (SVM) instruction updated to include model year 2021
Updated to include an additional model year applicability.
Update Top Tier brochure part number.
Update brochure part number and recording URL.
Read full bulletin
Update model and model year applicability.
Metadata update (add MY 2014 Eos (missing).
Update to include 2020-2021 model and model year applicability.
Updated to include additional models and model year applicability.
Operational Update - Takata Return Parts Pickup
Update to Volkswagen Identifying and mixing of coolant.
Read full bulletin
Introducing new coolant type.
Update to Volkswagen Identifying and mixing of coolant.
Read full bulletin
Introducing new coolant type.
Update model applicability to MY 2020.
Update to mode; and model year applicability.
Quick Reference Update Guide.
Update vehicle metadata to include pull ahead models.
Read full bulletin
Also includes R32 2002-2007 and 2002-2006 Jetta Wagon.
Update vehicle metadata.
Update vehicle metadata.
Instrument cluster production mode solution, updated to include additional model and model year applicability.
Update information regarding Top Tier brochure part number andVW literature ordering address
Update brochure part number, literature ordering websie address and include an additional model year applicability
Updated to include model year 2014 thru 2018 applicability.
Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the...
Read full bulletin
customer concerns about a vehicle
Instrument cluster production mode solution, updated to include additional model and model year applicability.
Update information regarding Top Tier brochure part number andVW literature ordering address
Update brochure part number, literature ordering websie address and include an additional model year applicability
Updated to include model year 2014 thru 2018 applicability.
Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the...
Read full bulletin
customer concerns about a vehicle
Instrument cluster production mode solution, updated to include additional model and model year applicability.
Takata_Updated Part Return_VW Dealer USA 07_2018
Update content and include additional models and model year applicability.
This communication gives more information on the REPAIR & OWNER MOBILITY UPDATE
Quick Reference of vehicle concerns.
Read full bulletin
Includes a list of Software versions and the technical bulletin numbers that referred to the concerns Updated
Campaign Parts Bulletin - 69M8 and 69M9 - Takata Part ordering process - On May 5th, a Campaign Parts Bulletin about the...
Read full bulletin
updated Takata part ordering process was sent to all dealers. We?ve closely monitored the impact of that communication and would like to address several emerging trends.
To update claim processing statement.
To update claim processing statement.
Takata - Parts allocation update - dealer communication
Quick Reference Update Guide of the vehicles expected upgraded software level.
Read full bulletin
The latest corresponding technical bulletins that address the issues, and concerns that have been had with the vehicles.
This communication is to update our ProFi dealers of the current status of the latest inbound and outbound ProFi...
Read full bulletin
requests.
This technical bulletin was updated per powertain team and warranty team.
Read full bulletin
Info from this bulletin is combined with TB 2031075 (V241208) and 2038161 (V241506) due to warranty extension claiming/processing confusion. (Basically 3 technical bulletins covering the same DTC were combined into 1 technical bulletin). By combining the three technical bulletins it allowed for archiving (removal from publication) of V241208 and V241506 stated above.
Data Link connector pin assignment chart that is applicable to all models.
Read full bulletin
Update model year applicability.
Quick Reference of vehicle concerns.
Read full bulletin
Includes a list of Software versions and the technical bulletin numbers that referred to the concerns Updated
Updated to include additional model year applicability.
Update to include additional model year applicability.
Update model year applicability.
Update to model year applicability.
Update model year applicability to include 2017.
Update model and model year applicability.
Update information regarding Top Tier brochure.
Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the...
Read full bulletin
customer concerns about a vehicle
Technical Bulletin This Technical Bulletin details the general process for carrying out a Software Version Management...
Read full bulletin
(SVM) software update for any Technical Bulletin (TSB) / Required Vehicle Update (RVU).
Update parts table.
To update required parts table.
To update required parts table.
Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the...
Read full bulletin
customer concerns about a vehicle
TO UPDATE MODEL TABLE TO CLARIFY JETTA WAGON APPLICABILITY TO TB CONTENT.
2006-2008 WITH 2.0L (BPY) UPDATE SERVICE NUMBER IN WARRANTY TABLE.
Read full bulletin
2008-2009 ALL MODELS WITH 2.0L (CCTA,CBFA) UPDATE SERVICE NUMBER IN WARRANTY TABLE.
TO UPDATE CLAIM PROCESSING STATEMENT.
Electrical
66 bulletinsElectric Coolant Fans Continue to Run after Ignition is Switched OFF
Electric Coolant Fans Continue to Run after Ignition is OFF
Electric Coolant Fans Continue to Run after Ignition is OFF
MIL ON, DTC P0087, P1093 or P2293 Stored in ECM Fault Memory
P0102, P1128, P1296 - WA front oxygen sensor faults
2006 -2007 Rabbit/R32/GTI, 2005-2007 Jetta/Jetta Wagon, 2007-2008 Eos and 2006-2007 Passat/Passat Wagon Inspect Front...
Read full bulletin
Seat Side Impack Airbag Connectors & Install Wiring Harness Kit(s), if Necessary
Battery, Testing and Charging Using Midtronics VAS6161, MCR340V, InCharge 940, or GRX3000 Charger
Air Conditioning, Cleaning of the Refrigerant Circuit (U.S.Only)
If key blade is found to stick or bind when opening or closing, check position of roll pin that secures key blade to mechanism.
Read full bulletin
If roll pin is sticking out on either side (as shown below), do not replace key. Instead, use appropriate sized punch and hammer to drive in the roll pin so that it is flush with edge of mechanism.
Use the following procedure to diagnose active wheel speed sensor complaints
To clear static ECM fault P1250 ?Fuel Level Too Low?, add fuel to vehicle and complete a road test of at least 10 miles.
Read full bulletin
Simply adding fuel without completing a road test may not allow fault to clear.
To clear static ECM fault P1250 ?Fuel Level Too Low?, add fuel to vehicle and complete a road test of at least 10 miles.
Read full bulletin
Simply adding fuel without completing a road test may not allow fault to clear.
If you have a complaint of DTCs for the low side fuel pressure being out of specification (e.g.
Read full bulletin
P310B), check the fuel pressure with BOTH a mechanical gauge and by the display in Measured Value Block 103. The readings should be 1 bar higher in the MVB due to reading atmospheric pressure + fuel pressure. If the mechanical gauge reading is within specification BUT the MVB 103 reading is not 1 bar higher, check for a possible faulty G410 Low Fuel Pressure sensor.
Use the following procedure to diagnose active wheel speed sensor complaints:
Electric coolant fans continue to run after ignition is switched off.
Battery testing and charging using special tools VAS6161 & GRX3000VAS Charger.
Read full bulletin
Updated to include additional model year applicability.
Battery testing using VW special tools, updated to include additional model year applicability and include I.D.4.
Explanation of error message received from scan tool when erasing diagnostic trouble codes (DTCs) in Control Module...
Read full bulletin
-623- after repair.
Battery testing. Updated to include additional model and model year applicability.
REMOVED all 12 hour wait period before starting references.
Read full bulletin
ADDED EFB to "Select correct battery type" in bottom box. Also Jetta Wagon 2005 and 2018-2020 Tiguan LWB.
Remote Key Battery Replacement
Battery Testing and Charging instruction.
Read full bulletin
Updated to include model year 2019 applicability.
Body/Infotainment Module Software Updates: This document informs of various complaints that were addressed in software...
Read full bulletin
updates, and technical bulletins.
Tech Tips ("Steering Column Defective? Message on MFI): Be aware that the MFI message ?Steering Column Defective?...
Read full bulletin
does not necessary indicate the electronic steering column lock (ESCL) requires replacement. This document informs of what faults to check to that may indicate a concern with the comfort module.
Tech Tips (3.6L Passat with MIL ON, DTC P119A (lean conditions/vacuum leaks or a faulty MAF sensor reading)): This...
Read full bulletin
fault can set as a result of lean conditions/vacuum leaks or a faulty MAF sensor reading. This document informs by providing an overview of how to service this issue.
Body/Infotainment Module Software Updates: This document informs of various complaints that were addressed in software...
Read full bulletin
updates, and technical bulletins.
Tech Tips ("Steering Column Defective? Message on MFI): Be aware that the MFI message ?Steering Column Defective?...
Read full bulletin
does not necessary indicate the electronic steering column lock (ESCL) requires replacement. This document informs of what faults to check to that may indicate a concern with the comfort module.
Tech Tips (3.6L Passat with MIL ON, DTC P119A (lean conditions/vacuum leaks or a faulty MAF sensor reading)): This...
Read full bulletin
fault can set as a result of lean conditions/vacuum leaks or a faulty MAF sensor reading. This document informs by providing an overview of how to service this issue.
Comfort/BCM Replacement direction, updated to include additional model year applicability.
This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, technical...
Read full bulletin
bulletins, pending service solutions, tech tips, campaigns, updates, and suggestions.
This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, ElsaPro...
Read full bulletin
infomedia icons grayed out, workshop equipment tool storage application, technical bulletins, pending service solutions, tech tips, campaigns, updates, and suggestions.
Tech Tips (Comfort Module (J393) or BCM (J519) Replacement): This document informs If a comfort or body control module...
Read full bulletin
is replaced during normal diagnosis, make sure the factory mode has been switched OFF. This can be accomplished by selecting the test plan through GFF or through Vehicle Self Diagnosis in adaptation channel 99. Failure to deactivate factory mode will create a concern where the door locks will not lock and/or unlock with the switch and/or the remotes.
Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit (U.S.Only)): In cases where an air...
Read full bulletin
conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or component is circulated throughout the refrigerant circuit, the refrigerant circuit must be cleaned of any and all debris or damage to the replacement components will result. This document contains information on how to diagnose, and service this issue.
Tech Tips (Active Wheel Speed Sensor Diagnosis): This document informs of a procedure to diagnose active wheel...
Read full bulletin
speed sensor complaints
Tech Tips (ECM Fault P1250 "Fuel Level Too Low" Will Not Clear): This document informs to clear static ECM fault...
Read full bulletin
P1250 "Fuel Level Too Low", add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without completing a road test may not allow fault to clear.
Technical Bulletin: Battery, Discharged, Diagnosis for Excessive Static Current Draw
Technical Bulletin: Battery, Testing and Charging Using Midtronics VAS6161, MCR340V, InCharge 940, or GRX3000VAS...
Read full bulletin
Charger
Tech Tips (Active Wheel Speed Sensor Diagnosis): This document informs of a procedure to diagnose active wheel speed...
Read full bulletin
sensor complaints.
Tech Bullentin concerning Electric Coolant Fans that Continue to Run after Ignition is Switched OFF
Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit): In cases where an air conditioning system...
Read full bulletin
component (such as a compressor or other system component) has failed and debris from the compressor or component is circulated throughout the refrigerant circuit, the refrigerant circuit must be cleaned of any and all debris or damage to the replacement components will result. Debris can be dispersed throughout the refrigerant circuit after a/c component damage. In order to maintain A/C operating efficiency, it is important to flush the refrigerant circuit after A/C component repairs.
Tech Tips (Comfort Module (J393) or BCM (J519) Replacement): This document informs if a comfort or body control module...
Read full bulletin
is replaced during normal diagnosis, make sure the factory mode has been switched OFF. This can be accomplished by selecting guided function of either the J393 or J519 or control module OBD of J393 or J519 then selecting adaptation channel 99. Failure to deactivate factory mode will create a concern where the door locks will not lock and/or unlock with the switch and/or the remotes.
VOLKSWAGEN: IT IS A NORMAL OCCURRENCE FOR THE ELECTRIC COOLANT FANS TO CONTINUE TO RUN AFTER THE IGNITION IS SWITCHED OFF.
Read full bulletin
*JS
VOLKSWAGEN: NO TERMINAL 15 POWER, FAULT 02403-012.
Read full bulletin
TERMINAL 15 RELAY ACTIVATION CAN BE CHECKED IN MEASURED VALUE BLOCKS FOR MODULE THAT CONTROLS RELAY, AND J519 VEHICLE ELECTRICAL SYSTEM CONTROL MODULE. MEASURED VALUE BLOCK NUMBER VARIES BETWEEN VEHICLES. ALL 2006 MODELS EXCEPT ROUTAN. *PE
VOLKSWAGEN: FUEL PUMP CONTROL MODULE UPDATE INFORMATION.
Read full bulletin
*RM
VOLKSWAGEN: AIR BAG LIGHT IS ON WITH AN INTERNAL TROUBLE CODE STORED.
Read full bulletin
THIS COULD BE A WIRING PROBLEM. *RM
VOLKSWAGEN: DUE TO FUEL INTRUSION INTO THE LOW PRESSURE SIDE FUEL PRESSURE SENSOR G410, A FALSE SIGNAL MAY BE SENT TO...
Read full bulletin
THE ECM RESULTING IN A READING THAT IS OUT OF TOLERANCE. *PE
VOLKSWAGEN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER.
Read full bulletin
INSPECT, AND IF NECESSARY, REPLACE POSITIVE BATTERY CABLE. VEHICLES AFFECTED BY THIS ACTION MAY HAVE A POSITIVE BATTERY CABLE THAT MAY CORRODE AND, IN RARE CASES, BREAK. IF THIS HAPPENS, THE POWER SUPPLY MAY BE DISRUPTED AND THE VEHICLE CANNOT BE STARTED. *PE UPDATED ON 5/2/2012. *KB
VOLKSWAGEN: (REVISED) VEHICLES MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS.
Read full bulletin
IF THIS HAPPENS, THE MALFUNCTION INDICATOR LAMP (MIL) WILL ILLUMINATED TO LET YOU KNOW THAT VEHICLE MAY EXPERIENCE SOME DETERIORATION IN PERFORMANCE. IN SOME CASES, A MALFUNCTIONING IGNITION COIL MAY CAUSE A VEHICLE TO EXCEED FEDERAL AND/OR CALIFORNIA EMISSIONS STANDARDS. 2001-2007 PASSA/PASSAT WAGON. *PE UPDATED 8/9/10. *PE UPDATED 11/8/10. *PE UPDATED 12/8/10. *PE UPDATED 2/28/11. *PE UPDATED 3/21/11. *PE
VOLKSWAGEN: VEHICLES MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS.
Read full bulletin
IF THIS HAPPENS, THE MALFUNCTION INDICATOR LAMP (MIL) WILL ILLUMINATED TO LET YOU KNOW THAT THE VEHICLE MAY EXPERIENCE SOME DETERIORATION IN PERFORMANCE. IN SOME CASES, A MALFUNCTIONING IGNITION COIL MAY CAUSE A VEHICLE TO EXCEED FEDERAL AND/OR CALIFORNIA EMISSIONS STANDARDS. NO MODELS LISTED. *PE
VOLKSWAGEN: STEERING COLUMN, ELECTRONIC LOCK INOPERATIVE, DTC 02638012 STORED IN GATEWAY CONTROL MODULE.
Read full bulletin
RELAY DRIVER FOR ENABLING STEERING COLUMN LOCK-FAULT IN ELECTRICAL CIRCUIT. INTERNAL SOFTWARE FAULT WITH J533 DATA BUS ON BOARD DIAGNOSTIC INTERFACE (GATEWAY MODULE). *PE
VOLKSWAGEN: MIL ON, DTC P129F AND/OR P310B STORED IN ECM FAULT MEMORY.
Read full bulletin
DUE TO FUEL INTRUSION INTO THE LOW PRESSURE SIDE FUEL PRESSURE SENSOR-G410, A FALSE SIGNAL MAY BE SENT TO THE ECM RESULTING IN A READING THAT IS OUT OF TOLERANCE. *PE
VOLKSWAGEN: FUEL PRESSURE SENSOR REPLACEMENT (SAGA CODE 24M5/05).
Read full bulletin
MIL ON AND DTC P310B AND/OR P129F STORED IN THE ECM FAULT MEMORY. A MALFUCTION OF FUEL PRESSURE SENSOR-G410 (LOW PRESSURE SIDE) MAY CAUSE AN INCORRECT FUEL PRESSURE READING FROM THE ECM. THIS CONDITION MAY RESULT IN MIL ILLUMINATION AND DTC'S STORED IN FAULT MEMORY. *PE
VOLKSWAGEN: DUE TO FUEL INTRUSION INTO THE LOW PRESSURE SIDE FUEL PRESSURE SENSOR G410, A FALSE SIGNAL MAY BE SENT TO...
Read full bulletin
THE ECM RESULTING IN A READING THAT IS OUT OF TOLERANCE. A FALSE SIGNAL MAY RESULT IN ILLUMINATION OF THE MALFUNCTION INDICATOR LAMP AND DTC P129F OR DTC P310B BEING STORED IN FAULT MEMORY. IMPROVED FUEL PRESSURE SENSOR G410 TO AIR AGAINST FUEL INTRUSION. *PE
VOLKSWAGEN: SOME VEHICLES FRONT AND REAR PARK ASSIST SENSORS (PARK DISTANCE CONTROL SENSORS) MAY NOT ALWAYS FUNCTION PROPERLY.
Read full bulletin
DEALERS WILL INSPECT AND, IF NECESSARY, INSTALL NEW FRONT AND REAR PARK ASSIST SENSORS. *PE
VOLKSWAGEN: SOME VEHICLES WITH XENON HEADLAMPS, CONDENSATION CAN OCCUR INSIDE THE XENON HEADLAMPS.
Read full bulletin
VEHICLES WILL BE INSPECTED AND IF NECESSARY THE XENON HEADLAMP CAPS WILL BE REPLACED AND SPRING CLIPS INSTALLED. THE FRONT AND REAR PARK ASSIST SENSORS (PARK DISTANCE CONTROL SENSORS) ON SOME VEHICLES MAY NOT ALWAYS FUNCTION PROPERLY. *PE
VOLKSWAGEN: THIS IS TO INFORM YOU OF THE RELEASE OF A NEW REQUIRED VEHICLE UPDATE.
Read full bulletin
CHECK AND, IF NECESSARY, REPLACE POSITIVE BATTERY CABLE. MODELS PASSAT, PASSAT WAGON, PASSAT CC. *PE
VOLKSWAGEN: THE POSITIVE BATTERY CABLE ON VEHICLES MAY CORRODE AND IN INDIVIDUAL CASES BREAK.
Read full bulletin
AS A RESULT, THE POWER SUPPLY MAY BE DISRUPTED AND E.G. THE VEHICLE CANNOT BE STARTED. *PE
VW: RVU-FUEL PRESSURE SENSOR REPLACEMENT (SAGA CODE 24M5/05.
Read full bulletin
A MALFUNCTION OF FUEL PRESSURE SENSOR-G410-(LOW PRESSURE SIDE) MAY CAUSE AN INCORRECT FUEL PRESSURE READING FROM THE ECM. MAY RESULT IN MIL ILLUMINATION AND DTC'S STORED IN FAULT MEMORY. *PE
STEERING COLUMN, ELECTRONIC LOCK INOPERATIVE, DTC 02638012 STORED IN GATEWAY CONTROL MODULE.
Read full bulletin
*NJ
MIL ON, DTC P0299 STORED IN ECM FAULT MEMORY.
Read full bulletin
*NJ
MIL ON, DTC P129F AND/OR P310B STORED IN ECM FAULT MEMORY.
Read full bulletin
*NJ
MIL ON, DTC P0087, P1093 OR P2293 STORED IN ECM FAULT MEMORY.
Read full bulletin
*NJ
VOLKSWAGEN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER.
Read full bulletin
2006 MODEL YEAR PASSAT AND PASSAT WAGON - CHECK/REPLACE FRONT & REAR PARK ASSIST SENSORS. *NJ CSC WAS RECEIVED. UPDATED 3/20/08. *NJ
VOLKSWAGEN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER.
Read full bulletin
2006-2007 MODEL YEAR PASSAT & PASSAT WAGON WITH XENON HEADLAMPS - REPLACE HEADLAMP CAPS AND INSTALL SPRING CLIPS AND CHECK/REPLACE FRONT & REAR PARK DISTANCE CONTROL SENSORS (IF EQUIPPED). *NJ
MIL ON, DTC'S P0442, P0445, P0456 OR P2404 STORED IN ECM FAULT MEMORY, NO LEAKS PRESENT.
Read full bulletin
*KB
MIL ON, DTC P0087, P1093 OR P2293 STORED IN ECM FAULT MEMORY.
Read full bulletin
*KB
Air Bags & Safety
42 bulletinsIn conjunction with the New Mexico DMV, Volkswagen will be sending Takata airbag recall reminder notices to...
Read full bulletin
approximately 363 Volkswagen owners in the State of New Mexico on March 13, 2023.
In conjunction with the Massachusetts DMV, Volkswagen will be sending Takata airbag recall reminder notices to...
Read full bulletin
approximately 1,498 Volkswagen owners in the State of Massachusetts on March 13, 2023.
In conjunction with the Colorado DMV, Volkswagen will be sending Takata airbag recall reminder notices to approximately...
Read full bulletin
1,414 Volkswagen owners in the State of Colorado on February 13, 2023.
In conjunction with the New York DMV, Volkswagen will be sending Takata airbag recall reminder notices to approximately...
Read full bulletin
2,743 Volkswagen owners in the State of New York on October 17, 2022.
In conjunction with the South Carolina Department of Public Safety, Volkswagen is sending Takata airbag recall reminder...
Read full bulletin
notices to approximately 1,824 Volkswagen owners in the state of South Carolina on September 19, 2022.
In conjunction with the Virginia DMV, Audi will be sending Takata airbag recall reminder notices to approximately 2,217...
Read full bulletin
VW owners in the State of Virginia on July 21, 2022
Airbag Issues.
In conjunction with the Alabama Law Enforcement Agency (ALEA), Volkswagen is sending Takata airbag recall reminder...
Read full bulletin
notices to approximately 1,387 Volkswagen owners in the State of Alabama on March 23, 2022.
In conjunction with the South Carolina Department of Public Safety, Volkswagen is sending Takata airbag recall reminder...
Read full bulletin
notices to approximately 1,571 Volkswagen owners in the state of South Carolina on January 24, 2022.
In conjunction with the Pennsylvania Department of Transportation, Volkswagen is sending Takata airbag recall reminder...
Read full bulletin
notices to approximately 4,041 Volkswagen owners in the state of Pennsylvania on January 24, 2022.
In conjunction with the Idaho DMV, Volkswagen will be sending Takata airbag recall reminder notices to approximately 406...
Read full bulletin
Volkswagen owners in the State of Idaho on August 30, 2021.
In conjunction with the New York DMV, Volkswagen will be sending Takata airbag recall reminder notices to approximately...
Read full bulletin
4,206 Volkswagen owners in the State of New York on June 21, 2021.
In conjunction with the Texas DMV, Volkswagen will be sending Takata airbag recall reminder notices to approximately...
Read full bulletin
12,375 Volkswagen owners in the State of Texas on May 17, 2021.
In conjunction with the Michigan Department of State, Volkswagen will be sending Takata airbag recall reminder notices...
Read full bulletin
to approximately 3,000 Volkswagen owners in the State of Michigan on August 10, 2020.
In conjunction with the County of Fort Bend, Volkswagen will be sending Takata airbag recall reminder notices to...
Read full bulletin
approximately 640 Volkswagen owners in the State of Texas on July 28, 2020.
In conjunction with the Tennessee DMV, Volkswagen will be sending Takata airbag recall reminder notices to approximately...
Read full bulletin
4,400 Volkswagen owners in the State of Tennessee July 7, 2020.
In conjunction with the City of Miramar, Volkswagen sent Takata airbag recall reminder notices to approximately 218...
Read full bulletin
Volkswagen owners in the State of Florida on June 26, 2020.
In conjunction with the Nebraska DMV, Volkswagen will be sending Takata airbag recall reminder notices to approximately...
Read full bulletin
600 Volkswagen owners in the State of Nebraska on March 23, 2020.
In conjunction with the Ohio DMV, Volkswagen will be sending Takata airbag recall reminder notices to approximately...
Read full bulletin
9,000 Volkswagen owners in the State of Ohio on February 10, 2020.
In conjunction with the Georgia DMV, Volkswagen will be sending Takata airbag recall reminder notices to approximately...
Read full bulletin
7,900 Volkswagen owners in the State of Georgia on January 24, 2020.
In conjunction with the South Carolina Department of Public Safety, Volkswagen sent Takata airbag recall reminder...
Read full bulletin
notices to approximately 2,800 Volkswagen owners in the state of South Carolina on January 20, 2020.
In conjunction with the California Bureau of Automotive Repair, Volkswagen sent Takata airbag recall reminder notices to...
Read full bulletin
approximately 21,100 Volkswagen owners in the state of California on January 14, 2020.
In conjunction with the Houston Dept.
Read full bulletin
of Neighborhoods, Volkswagen will be sending Takata airbag recall reminder notices to approximately 4,600 Volkswagen owners in the state of Texas on November 4, 2019.
XPO Phone Outage - Takata Airbag/Inflator Returns
In conjunction with the Minnesota DMV, Volkswagen will be sending Takata airbag recall reminder notices to approximately...
Read full bulletin
3,400 Volkswagen owners in the State of Minnesota on September 16, 2019.
In conjunction with the North Carolina DMV, Volkswagen will be sending Takata airbag recall reminder notices to...
Read full bulletin
approximately 7,400 Volkswagen owners in the State of North Carolina on August 19, 2019.
In conjunction with the Virginia DMV, Volkswagen will be sending Takata airbag recall reminder notices to approximately...
Read full bulletin
6,235 Volkswagen owners in the State of Virginia on August 12, 2019.
In conjunction with the City of Compton, Volkswagen will be sending Takata airbag recall reminder notices to...
Read full bulletin
approximately 68 Volkswagen owners in the State of California on August 5, 2019.
In conjunction with the Commonwealth of Kentucky Transportation Cabinet, Volkswagen will be sending Takata airbag recall...
Read full bulletin
reminder notices to approximately 2,592 Volkswagen owners in the state of Kentucky on July 15, 2019.
In conjunction with the Alabama Law Enforcement Agency, Volkswagen sent Takata airbag recall reminder notices to...
Read full bulletin
approximately 3,991 Volkswagen owners in Wisconsin on July 8, 2019.
In conjunction with the Alabama Law Enforcement Agency, Volkswagen sent Takata airbag recall reminder notices to...
Read full bulletin
approximately 3,200 Volkswagen owners in Alabama on June 17, 2019.
Dealer Communication - ODIS Service Takata Airbag Recall Hotfix "Resolved".
Dealer Communication - ODIS Service Takata Airbag Recall Hotfix "Resolved".
Dealer Communication - ODIS Service TDI Flash & Takata Airbag Recall
Takata driver frontal airbag exchange program Dealer Letter
Campaign Parts Bulletin - 69M8 and 69M9 - Today, May 5th is the final standard weekly allocation of Takata airbag inflators.
Read full bulletin
After this date, Takata allocations will be based on the previous week?s paid claim volume. It is CRITICAL that claims are submitted in a timely fashion in order to receive an appropriate volume of additional parts to support demand.
This communication covers the driver airbag analysis for 2006-2008 Passat vehicles.
VOLKSWAGEN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER.
Read full bulletin
RESISTANCE IN THE AIR BAG SYSTEM CAN CAUSE THE AIR BAG LIGHT TO TURN ON EVEN THOUGH THERE IS NO PROBLEM. *RM UPDATED 4/9/13. *PE
VOLKSWAGEN: CHILD RESTRAINT LATCH GUIDANCE FIXTURE; COMPLIANCE WITH FMVSS 225 (USA ONLY).
Read full bulletin
UPDATE TO EXISTING TECHNICAL BULLETIN. NO PRODUCTION CHANGE REQUIRED. ALL MODELS. *PE
IGNITER, SIDE AIRBAG, DIAGNOSTIC TROUBLE CODE(S) STORED IN DTC MEMORY.
Read full bulletin
*NJ
AIRBAG MONITORING LIGHT ON, PASSENGER OCCUPANT DETECTION SYSTEM, DTC 02511 014 STORED IN MEMORY.
Read full bulletin
*NJ
IGNITER, SIDE AIRBAG, DIAGNOSTIC TROUBLE CODE STORED IN DTC MEMORY.
Read full bulletin
*KB
Body & Paint
27 bulletinsCustomer States Windshield Wipers Streak or Smear
Corrosion on Rear Door in Trim Strip Area
Corrosion on Rear Door in Trim Strip Area
Corrosion on the Front Door in Trim Strip Area
Corrosion on the Front Door in Trim Strip Area
Front Fender - Corrosion on Wheel Arch
Front Fender - Corrosion on Wheel Arch
Corrosion on hood edge.
Rear quarter panel corrosion.
Corrosion on wheel arch.
Technical Bulletin (Paint Finish, Reducing Swirl Marks and Fine Scratches): New vehicles (prior to Retail Delivery)...
Read full bulletin
with swirl marks and or fine scratches from polishing or cleaning. This document informs of how the Finish can be significantly improved without the use of harsh polishing compounds and high speed buffing.
Technical Bulletin (Paint Finish, Reducing Swirl Marks and Fine Scratches): New vehicles (prior to Retail Delivery)...
Read full bulletin
with swirl marks and or fine scratches from polishing or cleaning. This document informs of how the Finish can be significantly improved without the use of harsh polishing compounds and high speed buffing.
58 16 03 June 13, 2016 2039212 Supersedes Technical Bulletin 581503 dated July 21, 2015 to update Claim Processing statement.
Read full bulletin
Corrosion on Rear Door in Trim Strip Area
Corrosion may be found on the folded edge of the hood.
Read full bulletin
Supersedes TB V551603
explaination of cross car distorion when looking through the windshield and how the "effect" in normal.
Technical Bulletin (Squeaks, Rattles, Noise, Repair Materials): This doucment contains a list of components and...
Read full bulletin
applications developed to repair concerns of squeaks, rattles, noise and trim fit conditions.
Technical Bulletin (Corrosion on the Front Door in Trim Strip Area): Because of incomplete bonding of the trim strip...
Read full bulletin
water can get between trim strip and door. This document contains information on how to diagnose, and service this issue. This document also gives examples on filling out a claim form for the service.
Technical Bulletin (Corrosion on Rear Door in Trim Strip Area): Because of incomplete bonding of the trim strip water...
Read full bulletin
can get between trim strip and door. Because of water ingress, corrosion is possible in the area of the guide holes. This document contains information on how to diagnose, and service this issue. This document also gives examples on filling out a claim form for the service.
Technical Bulletin (Windshield Wipers Streak or Smear): Windshield or rear window is streaked, has a snakeskin appearance, or the surface feels rough.
Read full bulletin
To avoid unnecessary replacement of wiper blades, the condition and cleanliness of the windshield, rear window and wiper blades, should be checked first. This document contains information on how to diagnose, and service this issue.
Technical Bulletin (Front Fender - Corrosion on Wheel Arch): The wheel liner touches the arch area of the fender and...
Read full bulletin
rubs off the paint in the contact area. The corrosion is caused by dirt accumulations and movements of the wheel liner. The document informs how to identify affected parts. It then gives direction on servicing the issue
Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt...
Read full bulletin
meter to check for 0 V, which will be present after the open in the grid line. This document informs of how to diagnose the issue and tips on servicing the issue
Technical Bulletin about Paint Finish, Reducing Swirl Marks and Fine Scratches New vehicles (prior to Retail Delivery)...
Read full bulletin
with swirl marks and or fine scratches from polishing or cleaning. The document also have infromation about where to find warrenty coverage for the service
Document discusses issues with The wheel liner touches the arch area of the fender and rubs off the paint in the contact area.
Read full bulletin
The corrosion is caused by dirt accumulations and movements of the wheel liner. It discusses how to service the corrosion issue, and how to document it
The document refers to Corrosion being found where the rear bumper cover meets the quarter panel.
Read full bulletin
It discusses how it can happen, and where to find warranty coverage to service the parts
Document discusses Corrosion that may be found on the folded edge of the hood.
Read full bulletin
The corrosion may be found on this edge anywhere around the hood. It discusses how to service it, and document that service. It discusses where to find what applies to warranties that offer coverage for the service
Tech Tips (All vehicles-Tire dressing for vehicle detailing): The use of tire dressing gives your tires that shiny...
Read full bulletin
finish that completes the image of a clean (new) vehicle. This document informs that The use of non-water based products will increase the risk of causing damage to painted surfaces. The document also gives graphical examples of the dame that can occur if non-water based products are used.
HOOD RELEASE LEVER INSIDE VEHICLE IS INOPERATIVE (BT).
Read full bulletin
*TT
Pre-Delivery & Maintenance
18 bulletinsPerfect Delivery Inspection (PDI) - Technician and Detailer Inspections
Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections
Volkswagen Warranty Policies and Procedures ? April 2014
If a needed service part is on back order, upgrade the daily order to a red order and check the ?Car Down? box to escalate the order.
Read full bulletin
If parts assistance is needed, please call 800-767-6552 to speak with a VWGoA Parts Specialist.
If a needed service part is on back order, upgrade the daily order to a red order and check the ?Car Down? box to escalate the order.
Read full bulletin
If parts assistance is needed, please call 800-767-6552 to speak with a VWGoA Parts Specialist.
Recall Reminder Part Labels
Takata Reminder Mailing.
Read full bulletin
City of La Puente (CA) / Safety Recalls 69Q8, 69Q9, 69Y5
Effective immediately, TK Services Inc.
Read full bulletin
will resume scheduling part pick-up from dealerships and service centers.
Takata Incentive Program - Safety Recalls 69Q8 and 69Q9
Takata Reminder Mailing - Mississippi DMV /Safety Recalls 69Q8, 69Q9, 69Y5
Tech Tips (All Models 2000-2014 - Part ordering): If a needed service part is on back order, upgrade the daily order...
Read full bulletin
to a red order and check the ?Car Down? box to escalate the order. This document informs how to contact VWGoA Parts Specialist for help.
Tech Tips (All Models 2000-2014 - Part ordering): If a needed service part is on back order, upgrade the daily order...
Read full bulletin
to a red order and check the ?Car Down? box to escalate the order. This document informs how to contact VWGoA Parts Specialist for help.
Takata Parts Allocation & Warranty Claims Submissions
Campaign Tip - 69M8 and 69M9 - Takata part label Information
Passat Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections: A checklist to insure a customer...
Read full bulletin
receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has purchased
Passat Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections: A checklist to insure a customer...
Read full bulletin
receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has purchased
VOLKSWAGEN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER.
Read full bulletin
WHEN TRYING TO START THERE MAY BE AN EXTENDED CRANK OR NO START. 2006-2010 PASSAT. *RM
VOLKSWAGEN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER.
Read full bulletin
WHEN TRYING TO START THE VEHICLE THERE IS A LONG CRANK OR NO START CONDITION. 2009-2010 PASSAT. *RM
Transmission
17 bulletinsWhen diagnosing a generator charging concern, it is recommended to verify operation of the one way clutch located in the...
Read full bulletin
generator pulley (if equipped) before replacing generator assembly. To check the one way clutch, remove the belt from the generator pulley and use a trim removal tool to hold fan blades inside generator, as shown below. When attempting to turn pulley by hand with fan blades held, pulley should spin freely in only one direction. If pulley spins freely in both directions, the one way clutch has failed and should be replaced before continuing diagnosis.
Addressing Transmission Fluid Temperature Sensor Concerns, update authing system metadata.
Addressing Transmission Fluid Temperature Sensor Concerns, update authing system metadata.
Addressing Transmission Fluid Temperature Sensor Concerns, update authing system metadata.
Addressing Transmission Fluid Temperature Sensor Concerns, update authing system metadata.
Update to model year applicability and existing tip for Dual clutch basic settings procedure.
Update model year applicability and existing tip for transmission basic settings direction.
Transmission Control Module Updates: This document informs of the software, and technical bulletins that service...
Read full bulletin
corresponding cars and their Transmission Control Module complaint issues.
Update to model year applicability and existing tip for Dual clutch basic settings procedure.
Update model year applicability and existing tip for transmission basic settings direction.
Transmission Control Module Updates: This document informs of the software, and technical bulletins that service...
Read full bulletin
corresponding cars and their Transmission Control Module complaint issues.
Tech Tips: Generator Charging Concern Diagnosis Tip - One Way Clutch Pulley Testing
REMINDER TO FOLLOW THE CORRECT REPAIR PROCEDURE OF PILOT BEARING REPLACEMENT, WHEN REMOVING AND RE-INSTALLING THE DSG...
Read full bulletin
TRANSMISSION
VOLKSWAGEN: THE GEAR BOX HAS A MOMENTARILY DELAY WHILE ACCELERATING.
Read full bulletin
*RM
VOLKSWAGEN: EXHAUST HEAT SHIELD, REPLACEMENT GUIDELINES.
Read full bulletin
HEAT SHIELDS ARE TO BE INSPECTED AFTER COMPLETION O ANY TYPE OF REPAIR TO THE UNDERBODY (EXHAUST SYSTEM TRANSMISSION, ETC.), AND IF DAMAGED, REPLACED. *PE
TCM, HARSH UP/DOWN SHIFT FROM TRANSMISSION WHEN COLD.
Read full bulletin
*KB
COOLER, TRANSMISSION FLUID SEEPAGE (BU).
Read full bulletin
TRANSMISSION FLUID MAY SEEP FROM O-RING SEALS AT THE FRONT OF THE VEHICLE. *TT
Lighting
16 bulletinsExterior Lights, Moisture Accumulation
Exterior Lights, Moisture Accumulation
Exterior Lights, Moisture Accumulation
Exterior Lights, Moisture Accumulation
Exterior Lights, Moisture Accumulation
Exterior Lights, Moisture Accumulation
Exterior lighting moisture in lens updated to exclude LED lighting.
Condensation and or water droplets visible on inside of exterior light lenses.
Read full bulletin
TB updated to include model year 2019 applicability.
Part number listed is to be returned and only the success part number to be installed going forwward.
Technical Bulletin (Exterior Lights, Moisture Accumulation): Exterior light assemblies (headlights, taillights, fog...
Read full bulletin
lights, turn signals) are vented and may collect moisture on their inner surfaces, depending on humidity and other climatic changes. This document discusses necessary to diagnosis, and potential remedy of the issue.
Technical Bulletin: Condensation and or water droplets becomming visible on inside of exterior light lenses issue is...
Read full bulletin
discussed in this document
Technical Bulletin (Exterior Lights, Moisture Accumulation): This document informs of the Condensation and or water...
Read full bulletin
droplets visible on inside of exterior light lenses. The document also informs how to service the issue.
HEADLAMP INOPERATIVE, ADAPTIVEHID XENON SYSTEM.
Read full bulletin
*KB
HEADLAMP INOPERATIVE, ADAPTIVE HID XENON SYSTEM.
Read full bulletin
*KB
DTC'S P1297 (17705) OR P1557 (17965) STORED IN DTC MEMORY.
Read full bulletin
THIS MAY BE CAUSED BY INTAKE HOSES LEAKING (DURING BOOST CONDITIONS) DUE TO INCORRECT TORQUE ON CLAMPS OR IMPROPER PLACEMENT, WORN OR TORN INTAKE HOSES. *KB
CONSUMER MAY REPORT MOISTURE INSIDE HID HEADLAMP HOUSING.
Read full bulletin
*KB
Fuel System
14 bulletinsGasoline Quality
The DLC is intended for use with diagnostic scan tools and by emissions testing stations.
Read full bulletin
However, aftermarket devices (i.e., drive data recorders) that connect to the DLC have now become available.
Gasoline quality.
DTC's P053F,P0087, P0088, P1025 may set due to the high pressure fuel pump being out of time (sync).
Pressure Fuel Pump Replacement.
VW approved gasoline fuel additive, update to include additional models and model year applicability.
VW approved gasoline fuel additive, update to include additional models and model year applicability.
Symptom based diagnostic assistance for high pressure fuel pump being out of time.
Symptom based diagnostic assistance for high pressure fuel pump being out of time.
Update to existing tip for fuel quality checking.
Discusses the issues associated with using contaiminated gasoline.
Read full bulletin
There are recommendations to use top tier gasoline retailers
Technical tips on what to do if improper gasoline has been added to the vehicle.
VOLKSWAGEN:EVAPORATIVE (EVAP) EMISSION SYSTEM, DIAGNOSTIC TROUBLE CODE DIAGNOSIS.
Read full bulletin
REVISED PROCEDURE DEVELOPED TO TEST EVAP SYSTEM WITHOUT FUEL CAP. *JS
VOLKSWAGEN - 2006 PASSAT 4 MOTION VEHICLES-FUEL GAUGE INCORRECT AT FULL FILL.
Read full bulletin
*NJ
HVAC & Climate
13 bulletinsHVAC, Unpleasant Odor
HVAC, Unpleasant Odor
HVAC, Unpleasant Odor
Removing musty odor from A/C system.
Read full bulletin
Updated to include additional model and model year applicability.
Technical Bulletin (HVAC, Unpleasant Odor): An unpleasant odor is coming from Heating and Ventilation system.
Read full bulletin
Odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first started. Contaminants are effectively neutralized using the AIRCOMATIC? II Ultrasonic Climate System Cleaner (VAS 6189A) or AIRCOMATIC III Ultrasonic Climate System Cleaner (VAS 6189B) and AIRCO-CLEAN Ultrasonic HVAC Treatment (30208). All other cleaning methods are no longer permitted. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also available.
Technical Bulletin (HVAC, Unpleasant Odor): An unpleasant odor is coming from Heating and Ventilation system.
Read full bulletin
Odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first started. Contaminants are effectively neutralized using the AIRCOMATIC? II Ultrasonic Climate System Cleaner (VAS 6189A) or AIRCOMATIC? III Ultrasonic Climate System Cleaner (VAS 6189B) and AIRCO-CLEAN? Ultrasonic HVAC Treatment (30208). All other cleaning methods are no longer permitted. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also available.
Technical Bulletin (HVAC, Unpleasant Odor): Unpleasant odor is coming from Heating and Ventilation system.
Read full bulletin
Odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first started. Condensation is a normal characteristic in all A/C systems. If odor is noticeable continue to follow this document. Contaminants are effectively neutralized using the AIRCOMATIC? II Ultrasonic Climate System Cleaner (VAS 6189A) or AIRCOMATIC? III Ultrasonic Climate System Cleaner (VAS 6189B) and AIRCO-CLEAN? Ultrasonic HVAC Treatment (30208). All other cleaning methods are no longer permitted. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also available.
Technical Bulletin (HVAC, Unpleasant Odor): Unpleasant odor is coming from Heating and Ventilation system.
Read full bulletin
Odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first started. This document contains information on how to diagnose, and service this issue.
DIRECTION TO PERFORM SYSTEM RESET AFTER COMPONENT REPLACMENT OR DISCONNECT OF THE HVAC SYSTEM CONTROL HEAD.
Read full bulletin
NO TEST PLAN INFORMATION TO ADDRESS THIS.
DIRECTION TO PERFORM SYSTEM RESET AFTER COMPONENT REPLACMENT OR DISCONNECT OF THE HVAC SYSTEM CONTROL HEAD.
Read full bulletin
NO TEST PLAN INFORMATION TO ADDRESS THIS.
VOLKSWAGEN: SEAT, HEATING INOPERATIVE.
Read full bulletin
SEAT HEATER WILL NOT OPERATE PROPERLY OR BECOMES INOPERATIVE. *PE
SEAT, HEATING INOPERATIVE - SEAT HEATER WILL NOT OPERATE PROPERLY OR BECOMES INOPERATIVE.
Read full bulletin
*NJ
HVAC AIRFLOW COMING FROM WRONG VENT (OB).
Read full bulletin
*TT
Infotainment
11 bulletinsSatellite Radio Overview
All Vehicles with Bluetooth Phone Kit Installed ? Streaming Audio from Phone to Radio
Satellite Radio Overview
When performing SVM updates, the scan tool should be hardwired to the vehicle and the Bluetooth physically turned off.
Read full bulletin
A hard wired internet connection is also recommended.
The streaming music feature on vehicles equipped with factory or dealer installed Bluetooth will be available only in certain instances.
Read full bulletin
The vehicle must be equipped with the RCD 310 or RCD 510 (Premium 8) radios or the RNS 510 or RNS 315 navigation systems. The Bluetooth system must be either the UHV low (9W2), UHV?NAR (9W7 or 9ZR) factory installed systems or the Volk ? L dealer installed system.
Elsa2Go campaign information is now 100% aligned with ElsaPro.
Read full bulletin
This update to Elsa2Go ensures that both systems are displaying the same campaign information, including OPEN/CLOSED status, repair date as well as criterions at the same time without any discrepancy.
Alternative method for radio code retrieval.
Tech Tips (Instrument Cluster Production Mode): During PDI, or after installation of a replacement cluster, ?Pro? may...
Read full bulletin
be displayed in place of the odometer. The high beam indicator may be flashing in the instrument cluster as well. This indicates the cluster is in Production mode. Production mode is not the same as ?Transport? mode. This document infroms of the difference between Production, and Transport mode.
Tech Tips (Instrument Cluster Production Mode): This document informs the procedure to remove the production mode...
Read full bulletin
setting when it is displayed in the instrument cluster.
Tech Tips (SVM Update Instructions): This document informs when performing SVM updates, the scan tool should be...
Read full bulletin
hardwired to the vehicle and the Bluetooth physically turned off. A hard wired internet connection is also recommended.
VOLKSWAGEN - 2006 PASSAT, 2008 TOUAREG U.S.
Read full bulletin
VEHICLES - ODOMETER DISPLAY. *NJ
Brakes
10 bulletinsIf fault code 03200 or 16352 is present in the Electromechanical Parking Brake (EPB) module, it may be due to the switch...
Read full bulletin
and module not being synchronized.
If, after replacement of the steering rack, fault code 01309 008 is set in the ABS/ESP module only, follow the test plan...
Read full bulletin
in GFF for Driver Steering Recommendation (DSR) or channel 3 activation. If the test plan fails to clear the fault, follow the direction below using Vehicle Self Diagnosis in Address Word 44 - Steering Assistance
Fault code 02543 000 ?Brake Vacuum Sensor no Display? may be encountered in the ABS module.
Read full bulletin
This may be caused by the hydraulic brake boost function (HBV) in adaptation value 61 being turned off (value = 0). All Passat Wagons (including 4motion) and 3.6L equipped sedans with front drive should have this function turned on (value = 1). Change the adaptation value and verify the fault has cleared. Additionally, it may be necessary to lock the vehicle and allow the modules to go to sleep to clear the fault.
Strut or Shock Absorber Leak Assesment.
Antilock brake function test direction.
Antilock brake function test direction.
Tech Tips (Electro - Steering issues): If, after replacement of the steering rack, fault code 01309 008 is set in the...
Read full bulletin
ABS/ESP module only, follow the test plan in GFF for Driver Steering Recommendation (DSR) or channel 3 activation. If the test plan fails to clear the fault, follow the directions in this document
Tech Tips (Electro ? Steering - DTC 01309 008 ?No Communication with -J500-? is Stored in the ABS/ESP Module Only): ...
Read full bulletin
This document informs If, after replacement of the steering rack, fault code 01309 008 is set in the ABS/ESP module only, follow the test plan in GFF for Driver Steering Recommendation (DSR) or channel 3 activation. If the test plan fails to clear the fault, follow the directions in this document using Vehicle Self Diagnosis in Address Word 44 - Steering Assistance:
VOLKSWAGEN: STEERING RACK.
Read full bulletin
AFTER REPLACING THE STEERING RACK THE FAULT CODE 01309 008 IS SET IN ABS/ESP MODULE. ALSO INCLUDED MODEL GTI MY 2013, MODEL TIGUAN MY 2005-2007, MODEL RABBIT MY 2005/2011-2013, MODEL EOS MY 2005/2013, MODEL CC MY 2005-2008*JS
VOLKSWAGEN: UPDATE INFORMATION ON MODELS AND MODEL YEARS REGARDING SYNCHRONIZATION OF ELECTROMECHANICAL PARKING BRAKE...
Read full bulletin
(EPB) MODULE AND DUE TO SWITCH AND MODULE NOT BEING SYNCHRONIZED, FAULT CODES FOUND. MODELS 2006-2010 PASSAT, 2009-2013 CC, TIGUAN. *PE
Tires & Wheels
2 bulletinsThe use of tire dressing gives your tires that shiny finish that completes the image of a clean (new) vehicle.
Read full bulletin
There are many different tire dressing products available. When choosing a product please pay close attention to its contents. Always use a water based product.
TIRE PRESSURE MONITORING SYSTEM (TPMS), OPERATION OVERVIEW.
Read full bulletin
*SC
Hybrid & EV
1 bulletinCampaign Reminder Communication.
Read full bulletin
Also includes: 1998-2004 Beetle, 2003-2004 Beetle Convertible, 2019 Beetle Convertible, 1994-2004 Eurovan, 1994-2004 Golf, 1994-2004 Jetta, 2001-2004 Jetta Wagon, 2018-2019 Tiguan LWB, 1994-2004 Passat, 1994-2004 Passat Wagon, 2004 Phaeton, 2013-2016 Jetta Hybrid, 2004 R32 and 1995-2006 Cabrio.
Steering
1 bulletinDRIVER STEERING RECOMMENDATIONS (DSR) ACTIVATION AND SOFTWARE PROGRAMMING FOR DTCS.
Read full bulletin
*TT