2000 Volkswagen GTI TSBs
99 Technical Service Bulletins across 13 categories
Categories
Engine
22 bulletinsEngine Oils Which Meet Volkswagen Oil Quality Standard VW 502 00/505 00/505 01 and VW 504 00/507 00
Oil Consumption Measurement
Oil Consumption Measurement
Oil Consumption Measurement
Fuel Additive to Help Prevent Sporadic Misfire Faults
Update to Volkswagen engine oil standards
1999-2002 Jetta, Golf and GTI with VR6 Engine Update ECM Software for Catalytic Converter Monitoring System.
To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line.
Read full bulletin
The check must be performed with the engine running and heated rear window switched on. Switch OFF the ignition and visually locate the damage. Proceed with checking any other lines as necessary. Once the damaged line is identified, repair utilizing the Repair kit by Permatex ITEM 09117.
Incorrect torque converter or flywheel/flexplate installation can result in transmission damage.
Read full bulletin
When installing an engine, flywheel or transmission, please follow the installation procedures outlined in ELSA. For the flywheel/flexplate, please be certain the correct shim is installed between it and the crankshaft (reference VWIQ120). When installing a torque converter, press the torque converter hub through the seal as far as the first stop. Turn the torque converter while pushing toward the transmission using light force, until the cut outs in the torque converter hub lock into the pump wheel plate. The torque converter slides in. The torque converter is installed correctly if it is easy to turn by hand and if it fits evenly in the transmission bell housing. Additionally, it should spin freely when the transmission bell housing bolts are torqued to the engine block, prior to installation of the flywheel to converter bolts (reference VWIQ121).
Fault code P1297 may be set and fuel mixtures may go lean if the vehicle is driven under load or revved up and then...
Read full bulletin
returned to idle.
Volkswagen Engine oil quality standards, update to attachments.
Fuel Additive to Help Prevent Sporadic Misfire Faults
Engine oil quality standards, update to attachments.
Update engine oil quality standard lists (attachments)
Engine Oils Which Meet Volkswagen Oil Quality Standards
Gasoline Engine Misfire Diagnosis document
Emissions Service Action Circular (VR6 Engine Update ECM Software for Catalytic Converter Monitoring System): The ECM...
Read full bulletin
software for the catalytic converter monitoring system is too sensitive. This can cause the MIL to come on, and some vehicles may exceed Federal and/or California emissions standards. Also, in some cases this leads to unnecessary catalytic converter replacement. The corrective action taken for this issue was to Update ECM software.
Emissions Service Action Circular (VR6 Engine Update ECM Software for Catalytic Converter Monitoring System): The ECM...
Read full bulletin
software for the catalytic converter monitoring system is too sensitive. This can cause the MIL to come on, and some vehicles may exceed Federal and/or California emissions standards. Also, in some cases this leads to unnecessary catalytic converter replacement. The corrective action taken for this issue was to Update ECM software.
Tech Tips (Equipped with Turbocharged Engine Turbocharger Replacement Tip): If mechanical damage is found to the turbocharger (e.g.
Read full bulletin
damaged compression wheel, loose or broken shaft), it is not enough to just replace the turbocharger. This document informs the procedure of checks for damage.
Tech Tips (TDI Engine - N75 Solenoid Valve Diagnosis): This document informs with graphical aid the testing of the N75...
Read full bulletin
Solenoid Valve in the event of a turbocharger fault code such as P0299 or P0234. This applies to Mechanical Injection Style Diesel Engines, Pumpe Duse Style Diesel Engines and the new Common Rail Style Diesel Engines.
VOLKSWAGEN: HEADLIGHTS MAY INTERMITTENTLY DIM SLIGHTLY AT IDLE.
Read full bulletin
THE HEADLAMPS OR INSIDE LIGHTS INTERMITTENTLY DIM SLIGHTLY AT IDLE SPEED. AT IDLE SPEED THE ALTERNATOR VOLTAGE CAN FLUCTUATE, AS THE ALTERNATOR CANNOT FULLY COMPENSATE THE FLUCTUATIONS. GOLF & WAGON GTI, NEW BEETLE & CONVERTIBLE, EOS, JETTA & WAGON & SPORTWAGON, RABBIT, R32, TIGUAN. *PE
VOLKSWAGEN: HEADLIGHTS MAY INTERMITTENTLY DIM SLIGHTLY AT IDLE.
Read full bulletin
AT IDLE SPEED THE ALTERNATOR VOLTAGE CAN FLUCTUATE, AS THE ALTERNATOR CANNOT FULLY COMPENSATE THE FLUCTUATIONS. SOME ELECTRIC CONSUMERS COME ON IN CYCLES OR HAVE NO CONSTANT CURRENT CONSUMPTION, WHICH AMPLIFIES THIS EFFECT. THE LOAD CONDITION OF THE VEHICLE BATTERY CAN ALSO INFLUENCE THIS EFFECT. MODELS GOLF, GTI, NEW BEETLE & CONVERTIBLE, EOS, JETTA, WAGON, SPORTWAGEN, RABBIT, R32, GOLF WAGON, TIGUAN. *PE
Other
19 bulletinsVW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
Squeaks, Rattles, Noise, Repair Materials
Contacting the parts helpline
Part ordering
Tool number added to table.
Read full bulletin
Removal of Behr Flush Kit. VAS 6337/1A
The part number listed in the document is to be returned if it meets the criteria provided.
VAS 6154 Replacement Part Setup Guide
This special notice is to inform dealers to return all part numbers listed in the document and order the superseded part...
Read full bulletin
numbers going forward.
This information bulletin contains instructions for checking the pins/terminals for contacts and nano contacts.
Tip for Scan tool concerns that may occur duing a test plan
Reminder for dealers to reference the repair manual and replace all necessary fasteners (bolts, nuts) that cannot be...
Read full bulletin
re-used
Software & Calibration
11 bulletinsIn SAGA, the time units for the Volkswagen DoubleCheck labor operation were reduced in error from 50 time units to 30...
Read full bulletin
time units during the system update posted on July 4th.
Update model year applicability to include 2023.
Updated to include additional models and model year applicability.
Update vehicle metadata.
Update vehicle metadata.
This communication is to update our ProFi dealers of the current status of the latest inbound and outbound ProFi...
Read full bulletin
requests.
Data Link connector pin assignment chart that is applicable to all models.
Read full bulletin
Update model year applicability.
Update to include additional model year applicability.
Update to model year applicability.
Update model year applicability to include 2017.
Update model and model year applicability.
Electrical
10 bulletinsBattery, Testing and Charging Using Midtronics VAS6161, MCR340V, InCharge 940, or GRX3000 Charger
Air Conditioning, Cleaning of the Refrigerant Circuit (U.S.Only)
If key blade is found to stick or bind when opening or closing, check position of roll pin that secures key blade to mechanism.
Read full bulletin
If roll pin is sticking out on either side (as shown below), do not replace key. Instead, use appropriate sized punch and hammer to drive in the roll pin so that it is flush with edge of mechanism.
To clear static ECM fault P1250 ?Fuel Level Too Low?, add fuel to vehicle and complete a road test of at least 10 miles.
Read full bulletin
Simply adding fuel without completing a road test may not allow fault to clear.
To clear static ECM fault P1250 ?Fuel Level Too Low?, add fuel to vehicle and complete a road test of at least 10 miles.
Read full bulletin
Simply adding fuel without completing a road test may not allow fault to clear.
Battery testing and charging using special tools VAS6161 & GRX3000VAS Charger.
Read full bulletin
Updated to include additional model year applicability.
Battery Testing and Charging instruction.
Read full bulletin
Updated to include model year 2019 applicability.
This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, technical...
Read full bulletin
bulletins, pending service solutions, tech tips, campaigns, updates, and suggestions.
This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, ElsaPro...
Read full bulletin
infomedia icons grayed out, workshop equipment tool storage application, technical bulletins, pending service solutions, tech tips, campaigns, updates, and suggestions.
VOLKSWAGEN: THE CATALYTIC CONVERTER MONITORING SYSTEM, WITH THE ECM SOFTWARE, IS TOO SENSITIVE AND CAUSES THE...
Read full bulletin
MALFUNCTION INDICATOR LAMP (MIL) TO COME ON AND EXCEED EMISSIONS STANDARDS FOR FEDERAL AND/OR CALIFORNIA. MODEL 1999-2002 JETTA, GOLF, GTI. *PE
Lighting
8 bulletinsExterior Lights, Moisture Accumulation
Exterior Lights, Moisture Accumulation
Exterior Lights, Moisture Accumulation
Exterior Lights, Moisture Accumulation
Exterior Lights, Moisture Accumulation
Exterior Lights, Moisture Accumulation
Condensation and or water droplets visible on inside of exterior light lenses.
Read full bulletin
TB updated to include model year 2019 applicability.
DTC'S P1297 (17705) OR P1557 (17965) STORED IN DTC MEMORY.
Read full bulletin
THIS MAY BE CAUSED BY INTAKE HOSES LEAKING (DURING BOOST CONDITIONS) DUE TO INCORRECT TORQUE ON CLAMPS OR IMPROPER PLACEMENT, WORN OR TORN INTAKE HOSES. *KB
Fuel System
8 bulletinsGasoline Quality
The DLC is intended for use with diagnostic scan tools and by emissions testing stations.
Read full bulletin
However, aftermarket devices (i.e., drive data recorders) that connect to the DLC have now become available.
Gasoline quality.
Update to existing tip for fuel quality checking.
Discusses the issues associated with using contaiminated gasoline.
Read full bulletin
There are recommendations to use top tier gasoline retailers
Technical tips on what to do if improper gasoline has been added to the vehicle.
MIL IS ON AND/OR CATALYTIC CONVERTER IS RATTLING.
Read full bulletin
*KB
MIL IS ON AND OR CATALYTIC CONVERTER IS RATTLING.
Read full bulletin
*SC
Pre-Delivery & Maintenance
6 bulletinsVolkswagen Warranty Policies and Procedures ? April 2014
If a needed service part is on back order, upgrade the daily order to a red order and check the ?Car Down? box to escalate the order.
Read full bulletin
If parts assistance is needed, please call 800-767-6552 to speak with a VWGoA Parts Specialist.
If a needed service part is on back order, upgrade the daily order to a red order and check the ?Car Down? box to escalate the order.
Read full bulletin
If parts assistance is needed, please call 800-767-6552 to speak with a VWGoA Parts Specialist.
Golf Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections: A checklist to insure a customer receives...
Read full bulletin
a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has purchased
Golf Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections: A checklist to insure a customer receives...
Read full bulletin
a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has purchased
Golf/GTI Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections:
Body & Paint
5 bulletinsSUBJECT PERTAINING TO THE LUBRICATION OF THE DOOR LOCKS DURING THE PRE-DELIVERY INSPECTION.
Read full bulletin
MJS
INTERMITTENT WINDSHIELD WIPER, WIPES ACROSS WINDSHIELD ONCE THEN STOPS.
Read full bulletin
*KB
DOOR WINDOWS, MAY SEPERATE FROM WINDOW REGULATOR CLAMPS.
Read full bulletin
*KB
DRIVER AND PASSENGER DOOR WINDOW REGULATOR REPAIRING.
Read full bulletin
*MJ ADDITIONAL INFORMATION REGARDING DOOR WINDOW, SEPARATES FROM WINDOW REGULATOR CLAMPS. *TT
DRIVER AND PASSENGER DOOR WINDOW REGULATOR REPAIRS.
Read full bulletin
*TT
HVAC & Climate
4 bulletinsAir Conditioning Does not Operate
HVAC, Unpleasant Odor
HVAC, Unpleasant Odor
HVAC, Unpleasant Odor
Infotainment
2 bulletinsWhen performing SVM updates, the scan tool should be hardwired to the vehicle and the Bluetooth physically turned off.
Read full bulletin
A hard wired internet connection is also recommended.
Alternative method for radio code retrieval.
Transmission
2 bulletinsFor concerns of no or intermittent A/C operation where pressure diagnosis does not lead to a cause, be sure to check the N25 A/C clutch coil.
Read full bulletin
The fan control module may send a brief voltage signal to the clutch and then shut it off due to an open or high resistance in the coil circuit. The coil resistance should be between 3.5 and 4.5 ohms. If the reading is high or low when checked at the fan module, be sure to double check right at the coil to rule out any wiring concerns. Additionally, check ground circuit integrity for the clutch coil.
VOLKSWAGEN: EXHAUST HEAT SHIELD, REPLACEMENT GUIDELINES.
Read full bulletin
HEAT SHIELDS ARE TO BE INSPECTED AFTER COMPLETION O ANY TYPE OF REPAIR TO THE UNDERBODY (EXHAUST SYSTEM TRANSMISSION, ETC.), AND IF DAMAGED, REPLACED. *PE
Tires & Wheels
1 bulletinThe use of tire dressing gives your tires that shiny finish that completes the image of a clean (new) vehicle.
Read full bulletin
There are many different tire dressing products available. When choosing a product please pay close attention to its contents. Always use a water based product.
Air Bags & Safety
1 bulletinAirbag Issues.