2007 Volkswagen Golf TSBs
356 Technical Service Bulletins across 16 categories
Categories
Engine
90 bulletinsEngine Oils Which Meet Volkswagen Oil Quality Standard VW 502 00/505 00/505 01 and VW 504 00/507 00
Oil Consumption Measurement
Oil Consumption Measurement
Oil Consumption Measurement
Fuel Additive to Help Prevent Sporadic Misfire Faults
Fuel Additive to Help Prevent Sporadic Misfire Faults
Fuel Additive to Help Prevent Sporadic Misfire Faults
Fuel Additive to Help Prevent Sporadic Misfire Faults
Update to Volkswagen engine oil standards
To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line.
Read full bulletin
The check must be performed with the engine running and heated rear window switched on. Switch OFF the ignition and visually locate the damage. Proceed with checking any other lines as necessary. Once the damaged line is identified, repair utilizing the Repair kit by Permatex ITEM 09117.
Use the diagram below to test the N75 Solenoid Valve in the event of a turbocharger fault code such as P0299 or P0234.
Read full bulletin
This applies to Mechanical Injection Style Diesel Engines, Pumpe Duse Style Diesel Engines and the new Common Rail Style Diesel Engines.
Incorrect torque converter or flywheel/flexplate installation can result in transmission damage.
Read full bulletin
When installing an engine, flywheel or transmission, please follow the installation procedures outlined in ELSA. For the flywheel/flexplate, please be certain the correct shim is installed between it and the crankshaft (reference VWIQ120). When installing a torque converter, press the torque converter hub through the seal as far as the first stop. Turn the torque converter while pushing toward the transmission using light force, until the cut outs in the torque converter hub lock into the pump wheel plate. The torque converter slides in. The torque converter is installed correctly if it is easy to turn by hand and if it fits evenly in the transmission bell housing. Additionally, it should spin freely when the transmission bell housing bolts are torqued to the engine block, prior to installation of the flywheel to converter bolts (reference VWIQ121).
If mechanical damage is found to the turbocharger (e.g.
Read full bulletin
damaged compression wheel, loose or broken shaft), it is not enough to just replace the turbocharger.
When diagnosis on the above engine leads to the testing of the N75, please refer to the picture below.
Read full bulletin
The diagram shows which vacuum ports on the N75 valve should hold vacuum and which ones should not.
Volkswagen Engine oil quality standards, update to attachments.
Fuel Additive to Help Prevent Sporadic Misfire Faults
Fuel additive to help prevent sporadic misfire faults.
Engine oil quality standards, update to attachments.
Engine Oil Quality Standards updated to include the latest Engine Oil attachments (excludes Routan & ID.4).
Engine Oil Quality Standards updated to include the latest Engine Oil attachments (excludes Routan & ID.4).
Engine Oil Quality Standards updated to include the latest Engine Oil attachments.
Read full bulletin
(excludes Routan & ID.4)
Engine Oil Quality Standards updated to include the latest Engine Oil attachments.
Read full bulletin
(excludes Routan & ID.4)
Engine Oil Quality Standards updated to include model year 2023 and the latest Engine Oil attachments.
Read full bulletin
(excludes Routan & ID.4)
Engine oil consumption measurement.
VW engine oil specifications.
Read full bulletin
Update to model year applicability.
VW engine oil specifications.
Read full bulletin
Update to attachments.
Recommended fuel additive to avoid engine misfires.
Engine oil pressure priming.
Update engine oil quality standard lists (attachments)
Update engine oil quality standard lists (attachments)
Engine oil consumption measurement.
Read full bulletin
Update procedure and work sheet.
Update engine oil quality standard lists (attachments)
Update engine oil quality standard lists (attachments)
Update engine oil quality standard lists (attachments)
Update engine oil quality standard lists (attachments)
Update engine oil quality standard lists (attachments)
Update engine oil quality standard lists (attachments)
Update engine oil quality standard lists (attachments)
Update engine oil quality standard lists (attachments)
Engine oil consumption measurement.
Fuel Additive to Help Prevent Sporadic Misfire Faults
Update engine oil quality standard lists (attachments)
Update engine oil quality standard lists (attachments)
Update engine oil quality standard lists (attachments)
Updated to include update recommended engine oil attachments.
Body surfaces (engine compartment and underside of hood) are not directly visible (exposed) therefore do not match...
Read full bulletin
exterior paint finish.
Oil consumption test updated to include additional models and model year applicability.
Oil pressure priming after engine replacement or internal repair.
Update to Volkswagen engine oil specification attachments.
Update to Volkswagen engine oil specification attachments.
Update to Volkswagen engine oil specification attachments.
Update to Volkswagen engine oil standards.
Update to Volkswagen engine oil standards.
Update to Volkswagen engine oil standards.
Update to Volkswagen engine oil standards.
Read full bulletin
Also includes 2004 and 2005 Jetta Wagon and 2018-2020 Tiguan LWB
Engine oil quality standards.
Read full bulletin
Also includes all models for 1997-2003. Also Rabbit from 2006-2009.
Engine Oils Which Meet Volkswagen Oil Quality Standards
Supersedes Technical Bulletin 24-17 03 (V241703) dated March 6, 2017 for information regarding a new style solenoid...
Read full bulletin
valve for Intake Manifold Flap
Ensure correct intake manifold is installed on engine, refer to ETKA.
Gasoline Engine Misfire Diagnosis document
Technical Bulletin (Hood, Under Hood Not Painted Body Color): The paint color and/or finish of the engine compartment...
Read full bulletin
and underside of hood may not match the exterior paint color of the vehicle. Depending on vehicle model and production plant, the color of the engine compartment and underside hood may not match the vehicle body color. This document informs dealers to let their customers know that these body surfaces (engine compartment and underside of hood) are not directly visible (exposed) and therefore do not require the same finish as visible, exterior surfaces.
Technical Bulletin (Electric Coolant Fans Continue to Run after Ignition is Switched OFF): This document informs it...
Read full bulletin
is considered normal operation for the electric coolant fans to continue to run for up to 15 minutes after the ignition is switched off in gasoline engine applications, and up to 16 minutes in diesel engine applications.
Technical Bulletin (Oil Consumption Measurement): Customers have stated oil consumption is higher than the Volkswagen...
Read full bulletin
oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. This document informs how to test the oil consumption rate
Technical Bulletin (Hood, Under Hood Not Painted Body Color): The paint color and/or finish of the engine compartment...
Read full bulletin
and underside of hood may not match the exterior paint color of the vehicle. Depending on vehicle model and production plant, the color of the engine compartment and underside hood may not match the vehicle body color. This document informs dealers to let their customers know that these body surfaces (engine compartment and underside of hood) are not directly visible (exposed) and therefore do not require the same finish as visible, exterior surfaces.
Technical Bulletin (Electric Coolant Fans Continue to Run after Ignition is Switched OFF): This document informs it...
Read full bulletin
is considered normal operation for the electric coolant fans to continue to run for up to 15 minutes after the ignition is switched off in gasoline engine applications, and up to 16 minutes in diesel engine applications.
Technical Bulletin (Oil Consumption Measurement): Customers have stated oil consumption is higher than the Volkswagen...
Read full bulletin
oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. This document informs how to test the oil consumption rate
Incorrect removal of Turbocharger oil feed line may cause engine damage
Engine replacement tip
17 17 01 July 5, 2017 2012855 Supersedes Technical Bulletin 17-16-02 (V171602) dated April 29, 2016 due to updated oil...
Read full bulletin
standards lists to current specifications. Engine Oils Which Meet Volkswagen Oil Quality Standards
Tech Tips (Equipped with Turbocharged Engine Turbocharger Replacement Tip): If mechanical damage is found to the turbocharger (e.g.
Read full bulletin
damaged compression wheel, loose or broken shaft), it is not enough to just replace the turbocharger. This document informs the procedure of checks for damage.
Technical Bulletin (Oil Consumption Measurement): Customer states oil consumption is higher than the Volkswagen oil...
Read full bulletin
consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. In order to provide effective lubrication and cooling of internal engine components, all internal combustion engines consume a certain amount of engine oil. Oil consumption varies from engine to engine and may change significantly over the life of the engine. Typically, engines with specified break-in periods consume more oil during the break-in period, and the oil consumption will stabilize after the break-in period. This document informs of oil consumption tests to check a vehicles performance.
Tech Tips (Technician Helpline Vehicle Check Sheets): When it becomes necessary to open a VW Technician Helpline VTA...
Read full bulletin
case while performing diagnosis for a diesel particulate filter, manual transmission repair, or turbocharger concern, it is recommended to complete the related worksheet/check sheet before calling. This document informs where Worksheets/Check Sheets are available on ServiceNet.
Technical Bulletin (Oil Consumption Measurement): Customer states oil consumption is higher than the Volkswagen oil...
Read full bulletin
consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. In order to provide effective lubrication and cooling of internal engine components, all internal combustion engines consume a certain amount of engine oil. Oil consumption varies from engine to engine and may change significantly over the life of the engine. Typically, engines with specified break-in periods consume more oil during the break-in period, and the oil consumption will stabilize after the break-in period. Refer to the Owners Manual for specific break-in procedures. Under normal conditions, the rate of oil consumption depends on the quality and viscosity of the oil, the RPM at which the engine is operated, the ambient temperature and road conditions. Further factors include the amount of oil dilution from water condensation or fuel residue and the oxidation level of the oil. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also available.
Technical Bulletin (HVAC, Unpleasant Odor): Condensation, which is a normal condition in all A/C systems, can cause a musty odor.
Read full bulletin
If the odor is noticeable in the vehicle when the engine is not turned on, the cause may be mold and mildew in the passenger compartment, and not be related to the A/C system. All other possible sources of the odor must be investigated before this document can be performed. This document contains the procedure for the VW method to remove musty odors
Technical Bulletin The use of contaminated gasoline, seasonal fuel changes (summer/winter fuel) or gasoline with a low...
Read full bulletin
content of deposit control additives may result in one or more of the following conditions: -Excessive accumulation of deposits on intake valves, intake manifold, fuel injectors and combustion chambers. -Engine runs rough after cold start. -Excessive engine cranking time. -Stumbles while driving. -Rough engine idle. -Loss of engine performance. -Poor fuel economy. This document informs of the procedure for the vehicle if it is diagnoised with poor quality gas
Remove engine coolant from parts table.
Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt...
Read full bulletin
meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engine running and heated rear window switched on. Switch OFF the ignition and visually locate the damage.
Technical Bulletin (Rear Door Glass Inoperative): The rear glass cannot be opened / closed, the rear glass may slide...
Read full bulletin
down into the door, or the rear glass motor operates but the glass does not move. This document contains the fault codes, and procedure to service these issues
Technical Bulletin (Fuel Additive to Help Prevent Sporadic Misfire Faults): Fuel quality impacts the operating...
Read full bulletin
performance, efficiency and service life of the engine. The use of poor quality fuels may result in deposit build up on the fuel injectors and intake valves. This may result in a rough running condition, sporadic misfires, or cold start misfire faults storing in the ECM fault memory. This document informs a Volkswagen approved fuel additive is available to help remove and prevent deposits on fuel injectors and intake valves.
Technical Bulletin (Fuel Additive to Help Prevent Sporadic Misfire Faults): Fuel quality impacts the operating...
Read full bulletin
performance, efficiency and service life of the engine. The use of poor quality fuels may result in deposit build up on the fuel injectors and intake valves. This may result in a rough running condition, sporadic misfires, or cold start misfire faults storing in the ECM fault memory. A Volkswagen approved fuel additive is available to help remove and prevent deposits on fuel injectors and intake valves. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also available.
Technical Bulletin (Electric Coolant Fans Continue to Run after Ignition is Switched OFF): This documentation informs...
Read full bulletin
it is considered normal operation for the electric coolant fans to continue to run for up to 15 minutes after the ignition is switched off in gasoline engine applications, and up to 16 minutes in diesel engine applications. The production solution to service this issue is that no production change is required.
Technical Bulletin (Rear Door Glass Inoperative issue diagnosis): The rear glass cannot be opened / closed, the rear...
Read full bulletin
glass may slide down into the door, or the rear glass motor operates but the glass does not move
Fuel Additive to Help Prevent Sporadic Misfire Faults A Volkswagen approved fuel additive is available to help remove...
Read full bulletin
and prevent deposits on fuel injectors and intake valves.
Technical Bulletin about a customer concern stating that customer observed one or more of the shocks/struts appearing to have an oil leak.
Read full bulletin
Document contains examples of Strut or Shock Absorber Leak Assessments
Technical Bulletin (Engine Oils Which Meet Volkswagen Oil Quality Standard): This document informs of a sample list...
Read full bulletin
of products generally available in the North American market that meet the Volkswagen Oil Quality Standard
Tech Tips (Torque Converter/Flywheel/Flexplate installation): Incorrect torque converter or flywheel/flexplate...
Read full bulletin
installation can result in transmission damage. When installing an engine, flywheel or transmission, please follow the installation procedures outlined in ELSA. This document also contains advice on the installation of these devices
VOLKSWAGEN: GASOLINE ENGINES HAVE ROUGH IDLE, HAVE SIGNIFICANT LOSS OF POWER OR STALLING WITH REDUCED PERFORMANCE.
Read full bulletin
*PE
VOLKSWAGEN: GASOLINE ENGINE VEHICLES INSPECT, AND IF NECESSARY, REPLACE IGNITION COILS.
Read full bulletin
VEHICLES AFFECTED BY THIS ACTION MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. MODELS PASSAT AND WAGON; GOLF; GTI; JETTA AND WAGON; NEW BEETLE AND CONVERTIBLE; PHAETON; EOS; RABBIT, ETC. *PE
VOLKSWAGEN: HEADLIGHTS MAY INTERMITTENTLY DIM SLIGHTLY AT IDLE.
Read full bulletin
THE HEADLAMPS OR INSIDE LIGHTS INTERMITTENTLY DIM SLIGHTLY AT IDLE SPEED. AT IDLE SPEED THE ALTERNATOR VOLTAGE CAN FLUCTUATE, AS THE ALTERNATOR CANNOT FULLY COMPENSATE THE FLUCTUATIONS. GOLF & WAGON GTI, NEW BEETLE & CONVERTIBLE, EOS, JETTA & WAGON & SPORTWAGON, RABBIT, R32, TIGUAN. *PE
VOLKSWAGEN: HEADLIGHTS MAY INTERMITTENTLY DIM SLIGHTLY AT IDLE.
Read full bulletin
AT IDLE SPEED THE ALTERNATOR VOLTAGE CAN FLUCTUATE, AS THE ALTERNATOR CANNOT FULLY COMPENSATE THE FLUCTUATIONS. SOME ELECTRIC CONSUMERS COME ON IN CYCLES OR HAVE NO CONSTANT CURRENT CONSUMPTION, WHICH AMPLIFIES THIS EFFECT. THE LOAD CONDITION OF THE VEHICLE BATTERY CAN ALSO INFLUENCE THIS EFFECT. MODELS GOLF, GTI, NEW BEETLE & CONVERTIBLE, EOS, JETTA, WAGON, SPORTWAGEN, RABBIT, R32, GOLF WAGON, TIGUAN. *PE
Software & Calibration
57 bulletinsODIS Service Update
Update Programming to Eliminate DTC P0601 Stored in DTC Memory
Software Version Management
In SAGA, the time units for the Volkswagen DoubleCheck labor operation were reduced in error from 50 time units to 30...
Read full bulletin
time units during the system update posted on July 4th.
Quick Reference Update Guide
Quick Reference Update Guide
Update model year applicability to include 2023.
ACC Calibration Process
Cleaning of Heating and Ventilation system, Updated to include additional model year applicability and cost of cleaning...
Read full bulletin
solution in warranty table.
Update model and model year applicability, introduce new coolant G12Evo.
This bulletin contains general instructions for software updates.
Update to model year applicability.
Update to model year applicability.
Software Version Management (SVM)
Update to brochure purchase url
Update to top tier brochure purchasing url.
Software Version Management (SVM) instruction updated to include model year 2021
Updated to include an additional model year applicability.
This document outlines updates to the ODIS diagnostic software.
Read full bulletin
Updates include corrected diagnostic test plans for the stated vehicles.
Update brochure part number and recording URL.
Read full bulletin
Update model and model year applicability.
Metadata update (add MY 2014 Eos (missing).
Update to include 2020-2021 model and model year applicability.
Updated to include additional models and model year applicability.
Update to Volkswagen Identifying and mixing of coolant.
Read full bulletin
Introducing new coolant type.
Update to Volkswagen Identifying and mixing of coolant.
Read full bulletin
Introducing new coolant type.
Update model applicability to MY 2020.
Update to mode; and model year applicability.
Quick Reference Update Guide.
Update vehicle metadata to include pull ahead models.
Read full bulletin
Also includes R32 2002-2007 and 2002-2006 Jetta Wagon.
This document outlines updates to the diagnostic software (ODIS).
Update vehicle metadata.
Update vehicle metadata.
Update to labor operation numbers per Saga updates.
Read full bulletin
Also applies to the 2006-2007 Beetle Convertible.
Instrument cluster production mode solution, updated to include additional model and model year applicability.
Update information regarding Top Tier brochure part number andVW literature ordering address
Update brochure part number, literature ordering websie address and include an additional model year applicability
Updated to include model year 2014 thru 2018 applicability.
Instrument cluster production mode solution, updated to include additional model and model year applicability.
Update information regarding Top Tier brochure part number andVW literature ordering address
Update brochure part number, literature ordering websie address and include an additional model year applicability
Updated to include model year 2014 thru 2018 applicability.
Instrument cluster production mode solution, updated to include additional model and model year applicability.
Update content and include additional models and model year applicability.
To update claim processing statement.
This communication is to update our ProFi dealers of the current status of the latest inbound and outbound ProFi...
Read full bulletin
requests.
This technical bulletin was updated per powertain team and warranty team.
Read full bulletin
Info from this bulletin is combined with TB 2031075 (V241208) and 2038161 (V241506) due to warranty extension claiming/processing confusion. (Basically 3 technical bulletins covering the same DTC were combined into 1 technical bulletin). By combining the three technical bulletins it allowed for archiving (removal from publication) of V241208 and V241506 stated above.
Data Link connector pin assignment chart that is applicable to all models.
Read full bulletin
Update model year applicability.
Updated to include additional model year applicability.
Update to include additional model year applicability.
Update model year applicability.
Update to model year applicability.
Update model year applicability to include 2017.
Update model and model year applicability.
Update information regarding Top Tier brochure.
Technical Bulletin This Technical Bulletin details the general process for carrying out a Software Version Management...
Read full bulletin
(SVM) software update for any Technical Bulletin (TSB) / Required Vehicle Update (RVU).
TO UPDATE MODEL TABLE TO CLARIFY JETTA WAGON APPLICABILITY TO TB CONTENT.
TO UPDATE CLAIM PROCESSING STATEMENT.
Other
53 bulletinsDamage to Data Link Connector (DLC) from Aftermarket Devices (Cannot Communicate with Vehicle OBD System)
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
Squeaks, Rattles, Noise, Repair Materials
When diagnosing fault code P2279-Leaking Air in Intake System, be sure to check the cam timing first.
Contacting the parts helpline
This special notice is to inform dealers to return the parts listed if it meets the criteria provided.
Technical Bulletins.
Part ordering
Additional safety related Inquiry and Reporting instruction.
Parts ordering information
Data link diagnostics and tips
This special notice is to inform dealers to return the part numbers listed (State of California only).
Mandatory fastener.
Electronic Stabilization Program (ESP) function test may not end on its own causing DTC.
Tool number added to table.
Read full bulletin
Removal of Behr Flush Kit. VAS 6337/1A
Volkswagen After Sales Weekly Communication - March 10, 2020
Include new special tool adapter and 2018 model year Jetta only
The part number listed in the document is to be returned if it meets the criteria provided.
The part number listed in the document is to be returned.
Parts are currently blocked from sale at this time.
Include additional photo's of water ingress.
Read full bulletin
Also includes 2018-2020 Tiguan LWB
TT 001202........Also includes 2005 Jetta wagon and 2018-2020 Tiguan LWB
Adhesive circular. Note: also includes 2004 Golf, Jetta, Passat, Touareg, GTI,
The part number listed in the document is to be returned if it meets the criteria provided.
VAS 6154 Replacement Part Setup Guide
This special notice is to inform dealers to return all part numbers listed in the document and order the superseded part...
Read full bulletin
numbers going forward.
DTC Status Bit Definitions.
To include an additional model year applicability.
This information bulletin contains instructions for checking the pins/terminals for contacts and nano contacts.
Tip for Scan tool concerns that may occur duing a test plan
Reminder for dealers to reference the repair manual and replace all necessary fasteners (bolts, nuts) that cannot be...
Read full bulletin
re-used
Tech Tips Damage to Data Link Connector (DLC) from Aftermarket Devices (Cannot Communicate with Vehicle OBD System)
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
Electrical
45 bulletinsElectric Coolant Fans Continue to Run after Ignition is Switched OFF
Electric Coolant Fans Continue to Run after Ignition is OFF
Electric Coolant Fans Continue to Run after Ignition is OFF
P0102, P1128, P1296 - WA front oxygen sensor faults
2006 -2007 Rabbit/R32/GTI, 2005-2007 Jetta/Jetta Wagon, 2007-2008 Eos and 2006-2007 Passat/Passat Wagon Inspect Front...
Read full bulletin
Seat Side Impack Airbag Connectors & Install Wiring Harness Kit(s), if Necessary
Battery, Testing and Charging Using Midtronics VAS6161, MCR340V, InCharge 940, or GRX3000 Charger
MIL ON, Secondary Air DTCs P2431, P2432, P2433 Stored in ECM Fault Memory
Air Conditioning, Cleaning of the Refrigerant Circuit (U.S.Only)
If key blade is found to stick or bind when opening or closing, check position of roll pin that secures key blade to mechanism.
Read full bulletin
If roll pin is sticking out on either side (as shown below), do not replace key. Instead, use appropriate sized punch and hammer to drive in the roll pin so that it is flush with edge of mechanism.
Use the following procedure to diagnose active wheel speed sensor complaints
To clear static ECM fault P1250 ?Fuel Level Too Low?, add fuel to vehicle and complete a road test of at least 10 miles.
Read full bulletin
Simply adding fuel without completing a road test may not allow fault to clear.
To clear static ECM fault P1250 ?Fuel Level Too Low?, add fuel to vehicle and complete a road test of at least 10 miles.
Read full bulletin
Simply adding fuel without completing a road test may not allow fault to clear.
Use the following procedure to diagnose active wheel speed sensor complaints:
For concerns of Fault Code P117A ?Bank 1, correction Lambda middle reached adjustment limit? stored in the ECM, check...
Read full bulletin
that the O2 sensors have not been installed or connected improperly.
Electric coolant fans continue to run after ignition is switched off.
Battery testing and charging using special tools VAS6161 & GRX3000VAS Charger.
Read full bulletin
Updated to include additional model year applicability.
Minimum battery charger requirements during software updates
Battery Testing and Charging using VAS6161 and or GRX3000VAS
Software Version Management (SVM) instruction.
Read full bulletin
Update to require 70amp minimum battery charger during procedure.
Battery Testing and Charging using recommended VW test equipment.
Battery Tester VAS 6161 introduction.
Discharged Battery, Diagnosis for excessive current draw.
Battery testing using VW special tools, updated to include additional model year applicability and include I.D.4.
Explanation of error message received from scan tool when erasing diagnostic trouble codes (DTCs) in Control Module...
Read full bulletin
-623- after repair.
Battery testing. Updated to include additional model and model year applicability.
REMOVED all 12 hour wait period before starting references.
Read full bulletin
ADDED EFB to "Select correct battery type" in bottom box. Also Jetta Wagon 2005 and 2018-2020 Tiguan LWB.
Remote Key Battery Replacement
Battery Testing and Charging instruction.
Read full bulletin
Updated to include model year 2019 applicability.
Comfort/BCM Replacement direction, updated to include additional model year applicability.
This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, technical...
Read full bulletin
bulletins, pending service solutions, tech tips, campaigns, updates, and suggestions.
This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, ElsaPro...
Read full bulletin
infomedia icons grayed out, workshop equipment tool storage application, technical bulletins, pending service solutions, tech tips, campaigns, updates, and suggestions.
Tech Tips (Comfort Module (J393) or BCM (J519) Replacement): This document informs If a comfort or body control module...
Read full bulletin
is replaced during normal diagnosis, make sure the factory mode has been switched OFF. This can be accomplished by selecting the test plan through GFF or through Vehicle Self Diagnosis in adaptation channel 99. Failure to deactivate factory mode will create a concern where the door locks will not lock and/or unlock with the switch and/or the remotes.
Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit (U.S.Only)): In cases where an air...
Read full bulletin
conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or component is circulated throughout the refrigerant circuit, the refrigerant circuit must be cleaned of any and all debris or damage to the replacement components will result. This document contains information on how to diagnose, and service this issue.
Tech Tips (Active Wheel Speed Sensor Diagnosis): This document informs of a procedure to diagnose active wheel...
Read full bulletin
speed sensor complaints
Tech Tips (ECM Fault P1250 "Fuel Level Too Low" Will Not Clear): This document informs to clear static ECM fault...
Read full bulletin
P1250 "Fuel Level Too Low", add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without completing a road test may not allow fault to clear.
Technical Bulletin: Battery, Discharged, Diagnosis for Excessive Static Current Draw
Technical Bulletin: Battery, Testing and Charging Using Midtronics VAS6161, MCR340V, InCharge 940, or GRX3000VAS...
Read full bulletin
Charger
Tech Tips (Active Wheel Speed Sensor Diagnosis): This document informs of a procedure to diagnose active wheel speed...
Read full bulletin
sensor complaints.
Tech Bullentin concerning Electric Coolant Fans that Continue to Run after Ignition is Switched OFF
Technical Bulletin (Secondary Air Injection System Air Flow/Pressure): This document informs the Secondary Air Pressure...
Read full bulletin
Sensor may be contaminated by foreign particles during secondary air injection. The production solution for this issue was a new sensor placed in production. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also available.
Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit): In cases where an air conditioning system...
Read full bulletin
component (such as a compressor or other system component) has failed and debris from the compressor or component is circulated throughout the refrigerant circuit, the refrigerant circuit must be cleaned of any and all debris or damage to the replacement components will result. Debris can be dispersed throughout the refrigerant circuit after a/c component damage. In order to maintain A/C operating efficiency, it is important to flush the refrigerant circuit after A/C component repairs.
Tech Tips (Comfort Module (J393) or BCM (J519) Replacement): This document informs if a comfort or body control module...
Read full bulletin
is replaced during normal diagnosis, make sure the factory mode has been switched OFF. This can be accomplished by selecting guided function of either the J393 or J519 or control module OBD of J393 or J519 then selecting adaptation channel 99. Failure to deactivate factory mode will create a concern where the door locks will not lock and/or unlock with the switch and/or the remotes.
VOLKSWAGEN: IT IS A NORMAL OCCURRENCE FOR THE ELECTRIC COOLANT FANS TO CONTINUE TO RUN AFTER THE IGNITION IS SWITCHED OFF.
Read full bulletin
*JS
VOLKSWAGEN: (REVISED) VEHICLES MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS.
Read full bulletin
IF THIS HAPPENS, THE MALFUNCTION INDICATOR LAMP (MIL) WILL ILLUMINATED TO LET YOU KNOW THAT VEHICLE MAY EXPERIENCE SOME DETERIORATION IN PERFORMANCE. IN SOME CASES, A MALFUNCTIONING IGNITION COIL MAY CAUSE A VEHICLE TO EXCEED FEDERAL AND/OR CALIFORNIA EMISSIONS STANDARDS. 2001-2007 PASSA/PASSAT WAGON. *PE UPDATED 8/9/10. *PE UPDATED 11/8/10. *PE UPDATED 12/8/10. *PE UPDATED 2/28/11. *PE UPDATED 3/21/11. *PE
VOLKSWAGEN: VEHICLES MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS.
Read full bulletin
IF THIS HAPPENS, THE MALFUNCTION INDICATOR LAMP (MIL) WILL ILLUMINATED TO LET YOU KNOW THAT THE VEHICLE MAY EXPERIENCE SOME DETERIORATION IN PERFORMANCE. IN SOME CASES, A MALFUNCTIONING IGNITION COIL MAY CAUSE A VEHICLE TO EXCEED FEDERAL AND/OR CALIFORNIA EMISSIONS STANDARDS. NO MODELS LISTED. *PE
Body & Paint
31 bulletinsCustomer States Windshield Wipers Streak or Smear
Rocker Panel - Front Fender ? Corrosion
Surface corrosion or corrosion perforation can occur on various locations around the front wheel arch.
Corrosion on hood edge.
Rear quarter panel corrosion.
Corrosion, Front fenders, at upper wheel opening.
Surface corrosion or corrosion perforation can occur on various locations around the front wheel arch.
Technical Bulletin (Paint Finish, Reducing Swirl Marks and Fine Scratches): New vehicles (prior to Retail Delivery)...
Read full bulletin
with swirl marks and or fine scratches from polishing or cleaning. This document informs of how the Finish can be significantly improved without the use of harsh polishing compounds and high speed buffing.
Technical Bulletin (Paint Finish, Reducing Swirl Marks and Fine Scratches): New vehicles (prior to Retail Delivery)...
Read full bulletin
with swirl marks and or fine scratches from polishing or cleaning. This document informs of how the Finish can be significantly improved without the use of harsh polishing compounds and high speed buffing.
Corrosion may be found on the folded edge of the hood.
Read full bulletin
Supersedes TB V551603
explaination of cross car distorion when looking through the windshield and how the "effect" in normal.
Technical Bulletin (Squeaks, Rattles, Noise, Repair Materials): This doucment contains a list of components and...
Read full bulletin
applications developed to repair concerns of squeaks, rattles, noise and trim fit conditions.
Technical Bulletin (Windshield Wipers Streak or Smear): Windshield or rear window is streaked, has a snakeskin appearance, or the surface feels rough.
Read full bulletin
To avoid unnecessary replacement of wiper blades, the condition and cleanliness of the windshield, rear window and wiper blades, should be checked first. This document contains information on how to diagnose, and service this issue.
Technical Bulletin: Rear Quarter Panel Corrosion issues.
Read full bulletin
This document has the Warranty documentation to inquire about coverage. It also has examples of instances calculating the services performed
Technical Bulletin: Rear Quarter Panel Corrosion issues.
Read full bulletin
This document discusses causes, fault codes for servicing, and example claim forms for the servicing of the vehicle
Technical Bulletin (Rocker Panel - Front Fender ? Corrosion): This document informs of Corrosion on contact surfaces of...
Read full bulletin
the front fender to rocker panel (side member). This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also available.
Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt...
Read full bulletin
meter to check for 0 V, which will be present after the open in the grid line. This document informs of how to diagnose the issue and tips on servicing the issue
Technical Bulletin Corrosion, Front Fenders, at Upper Wheel Opening (U.S.
Read full bulletin
Only) ): Document discusses diagnosis, and potential remedy of issue. The diagnosis codes for checking warranty coverage for servicing the vehicle are also available
Technical Bulletin (Rocker Panel - Front Fender ? Corrosion ): Document discusses diagnosis, and potential remedy of issue.
Read full bulletin
The document also has example claim forms for repears. The diagnosis codes for checking warranty coverage for servicing the vehicle are also available
Technical Bulletin (Corrosion Hood Edge ): Document discusses diagnosis, and potential remedy of issue.
Read full bulletin
The document also has example claim forms for repears. The diagnosis codes for checking warranty coverage for servicing the vehicle are also available
Technical Bulletin about Paint Finish, Reducing Swirl Marks and Fine Scratches New vehicles (prior to Retail Delivery)...
Read full bulletin
with swirl marks and or fine scratches from polishing or cleaning. The document also have infromation about where to find warrenty coverage for the service
Document refers to Surface corrosion or corrosion perforation that can occur on various locations around the front wheel arch.
Read full bulletin
It gives examples on where to check for repair coverage from warranties, fixing possible issues, and how to document the corrections
The document refers to Corrosion being found where the rear bumper cover meets the quarter panel.
Read full bulletin
It discusses how it can happen, and where to find warranty coverage to service the parts
Document discusses Corrosion that may be found on the folded edge of the hood.
Read full bulletin
The corrosion may be found on this edge anywhere around the hood. It discusses how to service it, and document that service. It discusses where to find what applies to warranties that offer coverage for the service
Information on areas Surface corrosion or corrosion perforation can occur on various locations around the front wheel arch.
Read full bulletin
Also gives examples of how to calculate cost to repair or replace
Summary of Technical Bulletin to include additional model and model year applicability.
Read full bulletin
Corrosion, Front Fenders, at Upper Wheel Opening (U.S. Only)
Tech Tips (All vehicles-Tire dressing for vehicle detailing): The use of tire dressing gives your tires that shiny...
Read full bulletin
finish that completes the image of a clean (new) vehicle. This document informs that The use of non-water based products will increase the risk of causing damage to painted surfaces. The document also gives graphical examples of the dame that can occur if non-water based products are used.
BETTER DEFINE CORROSION DAMAGE AND LOCATION COVERED BY THIS TECHNICAL BULLETIN.
TO UPDATE CLAIM PROCESS STATEMENT.
Read full bulletin
Rocker Panel - Front Fender Corrosion Corrosion on contact surfaces of the front fender to rocker panel (side member).
VOLKSWAGEN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER.
Read full bulletin
INSPECT, CLEAN AND MODIFY SUNROOF DRAINS FOR CERTAIN VOLKSWAGEN VEHICLES AND REVISED MAINTENANCE SCHEDULE; SUNROOF DRAIN INSPECTION AND CLEANING. NO MODELS OR MODEL YEARS LISTED. CSC LETTER WAS REC'D. *PE MODEL AND MODEL YEARS INCLUDED. UPDATED *PE
INTERMITTENT WINDSHIELD WIPER, WIPES ACROSS WINDSHIELD ONCE THEN STOPS.
Read full bulletin
*KB
Pre-Delivery & Maintenance
15 bulletinsPerfect Delivery Inspection (PDI) - Technician and Detailer Inspections
Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections
Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections
Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections
Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections
Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections
Volkswagen Warranty Policies and Procedures ? April 2014
If a needed service part is on back order, upgrade the daily order to a red order and check the ?Car Down? box to escalate the order.
Read full bulletin
If parts assistance is needed, please call 800-767-6552 to speak with a VWGoA Parts Specialist.
If a needed service part is on back order, upgrade the daily order to a red order and check the ?Car Down? box to escalate the order.
Read full bulletin
If parts assistance is needed, please call 800-767-6552 to speak with a VWGoA Parts Specialist.
Recall Reminder Part Labels
Tech Tips (All Models 2000-2014 - Part ordering): If a needed service part is on back order, upgrade the daily order...
Read full bulletin
to a red order and check the ?Car Down? box to escalate the order. This document informs how to contact VWGoA Parts Specialist for help.
Tech Tips (All Models 2000-2014 - Part ordering): If a needed service part is on back order, upgrade the daily order...
Read full bulletin
to a red order and check the ?Car Down? box to escalate the order. This document informs how to contact VWGoA Parts Specialist for help.
Golf Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections: A checklist to insure a customer receives...
Read full bulletin
a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has purchased
Golf Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections: A checklist to insure a customer receives...
Read full bulletin
a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has purchased
Golf/GTI Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections:
Transmission
15 bulletinsWhen diagnosing a generator charging concern, it is recommended to verify operation of the one way clutch located in the...
Read full bulletin
generator pulley (if equipped) before replacing generator assembly. To check the one way clutch, remove the belt from the generator pulley and use a trim removal tool to hold fan blades inside generator, as shown below. When attempting to turn pulley by hand with fan blades held, pulley should spin freely in only one direction. If pulley spins freely in both directions, the one way clutch has failed and should be replaced before continuing diagnosis.
Auto Trans fluid requirements.
Addressing Transmission Fluid Temperature Sensor Concerns, update authing system metadata.
Addressing Transmission Fluid Temperature Sensor Concerns, update authing system metadata.
Addressing Transmission Fluid Temperature Sensor Concerns, update authing system metadata.
Addressing Transmission Fluid Temperature Sensor Concerns, update authing system metadata.
Update to model year applicability and existing tip for Dual clutch basic settings procedure.
Update model year applicability and existing tip for transmission basic settings direction.
Update to model year applicability and existing tip for Dual clutch basic settings procedure.
Update model year applicability and existing tip for transmission basic settings direction.
Tech Tips: Generator Charging Concern Diagnosis Tip - One Way Clutch Pulley Testing
REMINDER TO FOLLOW THE CORRECT REPAIR PROCEDURE OF PILOT BEARING REPLACEMENT, WHEN REMOVING AND RE-INSTALLING THE DSG...
Read full bulletin
TRANSMISSION
VOLKSWAGEN: THE GEAR BOX HAS A MOMENTARILY DELAY WHILE ACCELERATING.
Read full bulletin
*RM
VOLKSWAGEN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER.
Read full bulletin
IN SOME VEHICLES IT IS POSSIBLE THAT A BUSHING INSIDE THE MECHATRONIC UNIT HAS THE POTENTIAL TO WEAR OUT PREMATURELY, CAUSING THE CLUTCHES INSIDE THE TRANSMISSION TO OPERATE LESS SMOOTHLY THAN BEFORE. THE DRIVER WILL BEGIN TO NOTICE CHANGES IN THE WAY THE VEHICLE FEELS AS THE TRANSMISSION SHIFTS (JERKING). THIS CHANGE CAN BECOME VERY PRONOUNCED, THE VEHICLE REMAINS SAFE TO DRIVE. *PE
VOLKSWAGEN: EXHAUST HEAT SHIELD, REPLACEMENT GUIDELINES.
Read full bulletin
HEAT SHIELDS ARE TO BE INSPECTED AFTER COMPLETION O ANY TYPE OF REPAIR TO THE UNDERBODY (EXHAUST SYSTEM TRANSMISSION, ETC.), AND IF DAMAGED, REPLACED. *PE
Lighting
12 bulletinsExterior Lights, Moisture Accumulation
Exterior Lights, Moisture Accumulation
Exterior Lights, Moisture Accumulation
Exterior Lights, Moisture Accumulation
Exterior Lights, Moisture Accumulation
Exterior Lights, Moisture Accumulation
Exterior Lights, Moisture Accumulation.
Read full bulletin
Update model year applicability to include 2022.
Exterior lighting moisture in lens updated to exclude LED lighting.
Condensation and or water droplets visible on inside of exterior light lenses.
Read full bulletin
TB updated to include model year 2019 applicability.
Technical Bulletin (Exterior Lights, Moisture Accumulation): Exterior light assemblies (headlights, taillights, fog...
Read full bulletin
lights, turn signals) are vented and may collect moisture on their inner surfaces, depending on humidity and other climatic changes. This document discusses necessary to diagnosis, and potential remedy of the issue.
Technical Bulletin: Condensation and or water droplets becomming visible on inside of exterior light lenses issue is...
Read full bulletin
discussed in this document
Technical Bulletin (Exterior Lights, Moisture Accumulation): This document informs of the Condensation and or water...
Read full bulletin
droplets visible on inside of exterior light lenses. The document also informs how to service the issue.
Infotainment
10 bulletinsSatellite Radio Overview
All Vehicles with Bluetooth Phone Kit Installed ? Streaming Audio from Phone to Radio
Satellite Radio Overview
When performing SVM updates, the scan tool should be hardwired to the vehicle and the Bluetooth physically turned off.
Read full bulletin
A hard wired internet connection is also recommended.
The streaming music feature on vehicles equipped with factory or dealer installed Bluetooth will be available only in certain instances.
Read full bulletin
The vehicle must be equipped with the RCD 310 or RCD 510 (Premium 8) radios or the RNS 510 or RNS 315 navigation systems. The Bluetooth system must be either the UHV low (9W2), UHV?NAR (9W7 or 9ZR) factory installed systems or the Volk ? L dealer installed system.
Elsa2Go campaign information is now 100% aligned with ElsaPro.
Read full bulletin
This update to Elsa2Go ensures that both systems are displaying the same campaign information, including OPEN/CLOSED status, repair date as well as criterions at the same time without any discrepancy.
Alternative method for radio code retrieval.
Tech Tips (Instrument Cluster Production Mode): During PDI, or after installation of a replacement cluster, ?Pro? may...
Read full bulletin
be displayed in place of the odometer. The high beam indicator may be flashing in the instrument cluster as well. This indicates the cluster is in Production mode. Production mode is not the same as ?Transport? mode. This document infroms of the difference between Production, and Transport mode.
Tech Tips (Instrument Cluster Production Mode): This document informs the procedure to remove the production mode...
Read full bulletin
setting when it is displayed in the instrument cluster.
Tech Tips (SVM Update Instructions): This document informs when performing SVM updates, the scan tool should be...
Read full bulletin
hardwired to the vehicle and the Bluetooth physically turned off. A hard wired internet connection is also recommended.
Fuel System
10 bulletinsGasoline Quality
The DLC is intended for use with diagnostic scan tools and by emissions testing stations.
Read full bulletin
However, aftermarket devices (i.e., drive data recorders) that connect to the DLC have now become available.
Gasoline quality.
Gasoline quality.
VW approved gasoline fuel additive, update to include additional models and model year applicability.
VW approved gasoline fuel additive, update to include additional models and model year applicability.
Update to existing tip for fuel quality checking.
Discusses the issues associated with using contaiminated gasoline.
Read full bulletin
There are recommendations to use top tier gasoline retailers
Technical tips on what to do if improper gasoline has been added to the vehicle.
VOLKSWAGEN:EVAPORATIVE (EVAP) EMISSION SYSTEM, DIAGNOSTIC TROUBLE CODE DIAGNOSIS.
Read full bulletin
REVISED PROCEDURE DEVELOPED TO TEST EVAP SYSTEM WITHOUT FUEL CAP. *JS
HVAC & Climate
9 bulletinsHVAC, Unpleasant Odor
HVAC, Unpleasant Odor
HVAC, Unpleasant Odor
HVAC, Temperature Output Control Cannot Be Adjusted
Removing musty odor from A/C system.
Read full bulletin
Updated to include additional model and model year applicability.
Technical Bulletin (HVAC, Unpleasant Odor): An unpleasant odor is coming from Heating and Ventilation system.
Read full bulletin
Odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first started. Contaminants are effectively neutralized using the AIRCOMATIC? II Ultrasonic Climate System Cleaner (VAS 6189A) or AIRCOMATIC III Ultrasonic Climate System Cleaner (VAS 6189B) and AIRCO-CLEAN Ultrasonic HVAC Treatment (30208). All other cleaning methods are no longer permitted. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also available.
Technical Bulletin (HVAC, Unpleasant Odor): An unpleasant odor is coming from Heating and Ventilation system.
Read full bulletin
Odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first started. Contaminants are effectively neutralized using the AIRCOMATIC? II Ultrasonic Climate System Cleaner (VAS 6189A) or AIRCOMATIC? III Ultrasonic Climate System Cleaner (VAS 6189B) and AIRCO-CLEAN? Ultrasonic HVAC Treatment (30208). All other cleaning methods are no longer permitted. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also available.
Technical Bulletin (HVAC, Unpleasant Odor): Unpleasant odor is coming from Heating and Ventilation system.
Read full bulletin
Odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first started. Condensation is a normal characteristic in all A/C systems. If odor is noticeable continue to follow this document. Contaminants are effectively neutralized using the AIRCOMATIC? II Ultrasonic Climate System Cleaner (VAS 6189A) or AIRCOMATIC? III Ultrasonic Climate System Cleaner (VAS 6189B) and AIRCO-CLEAN? Ultrasonic HVAC Treatment (30208). All other cleaning methods are no longer permitted. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also available.
Technical Bulletin (HVAC, Unpleasant Odor): Unpleasant odor is coming from Heating and Ventilation system.
Read full bulletin
Odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first started. This document contains information on how to diagnose, and service this issue.
Brakes
3 bulletinsStrut or Shock Absorber Leak Assesment.
Antilock brake function test direction.
Antilock brake function test direction.
Tires & Wheels
2 bulletinsThe use of tire dressing gives your tires that shiny finish that completes the image of a clean (new) vehicle.
Read full bulletin
There are many different tire dressing products available. When choosing a product please pay close attention to its contents. Always use a water based product.
Tire Chain Information (for California dealers only) All Model Years.
Read full bulletin
Information only for all other dealers.
Air Bags & Safety
2 bulletinsAirbag Issues.
VOLKSWAGEN: CHILD RESTRAINT LATCH GUIDANCE FIXTURE; COMPLIANCE WITH FMVSS 225 (USA ONLY).
Read full bulletin
UPDATE TO EXISTING TECHNICAL BULLETIN. NO PRODUCTION CHANGE REQUIRED. ALL MODELS. *PE
Hybrid & EV
1 bulletinCampaign Reminder Communication.
Read full bulletin
Also includes: 1998-2004 Beetle, 2003-2004 Beetle Convertible, 2019 Beetle Convertible, 1994-2004 Eurovan, 1994-2004 Golf, 1994-2004 Jetta, 2001-2004 Jetta Wagon, 2018-2019 Tiguan LWB, 1994-2004 Passat, 1994-2004 Passat Wagon, 2004 Phaeton, 2013-2016 Jetta Hybrid, 2004 R32 and 1995-2006 Cabrio.
Suspension
1 bulletinTechnical Bulletin (Temperature Output Control Cannot Be Adjusted): Customer states cannot adjust temperature and/or A/C is not cold.
Read full bulletin
The blend door control lever moves freely, but the blend door does not operate. A bushing that fits on the lever may have a broken tab/clip. This document discusses the potential remedy of the issue.