2015 Volkswagen Golf Sportswagen TSBs
78 Technical Service Bulletins across 11 categories
Categories
Software & Calibration
26 bulletinsUpdate to MIB2 information to include 2015 and 2017 model year.
Update to existing tip for addressing Kessy vehicles in the AEM flash
Updated to include additional model year applicability.
This communication is to update our ProFi dealers of the current status of the latest inbound and outbound ProFi...
Read full bulletin
requests.
Data Link connector pin assignment chart that is applicable to all models.
Read full bulletin
Update model year applicability.
Update to include model year 2017 applicability.
Updated to include additional model year applicability.
Update to include additional model year applicability.
Update model year applicability.
Updated to include an additional model year applicability.
Updated to include model year 2017 applicability
Update model year applicability.
Updated to include additional model year applicability.
Update to model year applicability.
Update model year applicability to include 2017.
Update model and model year applicability.
Update to existing article that addressed additional diagnostics for lean running concerns.
This tip informs the dealers about the updated SVM Flash procedure on the 23Q3 campaign.
Update technical publication to include model year 2018 Atlas
Technical Bulletin: Improved diagnostic strategy for better diagnosis by updating software
Update TB to include model year 2016 & 2017 applicability
UPDATED TO ADD JETTA, BEETLE AND BEETLE CONVERTIBLE MODEL APPLICABILITY.
UPDATED TO ADD JETTA, BEETLE AND BEETLE CONVERTIBLE MODEL APPLICABILITY.
UPDATE "CONDITIONS NOT COVERED BY WARRANTY" SECTION, REMOVE OXYDATION WORDING, INSERT ANODIZED WORDING, AND UPDATE MODEL...
Read full bulletin
YEAR AND MODEL APPLICABILITY.
THE UPDATE TO THE TECH TIP INCLUDES AN ADDITIONAL MODEL YEAR APPLICABILITY AND ADDITIONAL INSTRUCTION ON HOW TO ADAPT...
Read full bulletin
KEYS USING THE ADAPT IMMOBILIZER TEST PLAN.
UPDATED TO INCLUDE ADDITIONAL MODEL APPLICABILITY.
Other
13 bulletinsThe part number listed in the document is to be returned if it meets the criteria provided.
Adhesive application for installation on all areo parts solds as an accessory
VAS 6154 Replacement Part Setup Guide
Adhesive application for installation on all areo parts solds as an accessory
This special notice is to inform dealers to return all part numbers listed in the document and order the superseded part...
Read full bulletin
numbers going forward.
Reminder for dealers to reference the repair manual and replace all necessary fasteners (bolts, nuts) that cannot be...
Read full bulletin
re-used
additional symptom gathering information and guidence to isolate customer concern before beginning repair.
On-car analysis list of customer compliants Customer Complaint: Mil-on no electric drive mode, untouched vehicles
Seach tips to assist in finding DTC information
Tip to perform GFF feedback for test plan issues.
Tech Tips: Vehicles with Immobilizer with Download/Discharge? New Key Will Not Program
Tech Tips Damage to Data Link Connector (DLC) from Aftermarket Devices (Cannot Communicate with Vehicle OBD System)
TECH TIP DENOTING POTENTIAL FOR DAMAGE OF THE DATA LINK CONNECTOR WHEN USING AFTER MARKET PLUG IN DEVICES OR SCAN TOOLS...
Read full bulletin
AND SUBSEQUENT DIAGNOSTIC DIRECTION.
Electrical
11 bulletinsBattery Testing and Charging instruction.
Read full bulletin
Updated to include model year 2019 applicability.
MIL-on P0420 and/or P0430 in the ECM
MIL-on P0420 and/or P0430 in the ECM
MIL-on, Fault P013E in the ECM
MIL-on, Fault P013E in the ECM
MIL-on, Fault P013E in the ECM
This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, technical...
Read full bulletin
bulletins, pending service solutions, tech tips, campaigns, updates, and suggestions.
This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, ElsaPro...
Read full bulletin
infomedia icons grayed out, workshop equipment tool storage application, technical bulletins, pending service solutions, tech tips, campaigns, updates, and suggestions.
Example of devices, modifications or alterations that can impede Adaptive Cruise Control Radar Sensor function.
MIL-on fault P2407 in the ECM
REMOVAL OF SENTENCE REQUIRING GUIDED FAULT FINDING (GFF) FEEDBACK FOR LOST CONTROL MODULE CODING.
Engine
11 bulletinsGasoline Engine Misfire Diagnosis document
Instruction to protect oil pressure sw.
Read full bulletin
to prevent contamination and possible failure when removing 1.8L & 2.0L engines
Instruction to protect oil pressure sw.
Read full bulletin
to prevent contamination and possible failure when removing 1.8L & 2.0L engines
To add model year 2016 and 2017 applicability and reminder about Programming Activation of Oil Pressure...
Read full bulletin
Regulation/Retraction on all models with 1.8L CPKA and CPRA engines after engine assembly, cylinder head or turbocharger replacement.
The Environmental Protection Agency and California Air Resources Board have determined that Volkswagen vehicles equipped...
Read full bulletin
with a 2.0L 4-cylinder TDI engine do not comply with applicable emissions regulations. The emissions control systems on the vehicles will not control emissions under off-cycle conditions as effectively as during the federal test procedure. The extent of the emissions increase under off-cycle conditions depends upon how the vehicles are driven.
The Environmental Protection Agency and California Air Resources Board have determined that Volkswagen vehicles equipped...
Read full bulletin
with a 2.0L 4-cylinder TDI engine do not comply with applicable emissions regulations. The emissions control systems on the vehicles will not control emissions under off-cycle conditions as effectively as during the federal test procedure. The extent of the emissions increase under off-cycle conditions depends upon how the vehicles are driven. Updated SVM Flash procedure.
MIL-ON, FAULT P309F OR P309D, NO ELECTRIC DRIVE MODE CUSTOMER STATES CRANK NO START AND/OR IN-TANK FUEL PUMP MAKING...
Read full bulletin
NOISE AND POSSIBLY WITH FUEL PUMP FAULTS MIL-ON, FAULT P013E IN THE ECM MIL-ON, FAULT P164B IN ECM MIL-ON, FAULT P0011 AND/OR P0016 IN THE ECM MIL-ON, FAULT P2407 IN THE ECM CUSTOMER STATES NOISE FORM THE ENGINE/TURBO CUSTOMER STATES THE FUEL GAUGE DOES NOT READ FULL MIL ON, FAULT P2181 IN THE ECM MIL-ON, FAULT P0456 IN THE ECM CUSTOMER STATES THERE IS A NOISE WHILE TURNING/ GOING OVER BUMPS VEHICLE ALIGNMENT NOT CORRECT, STEERING OFF CENTER, PULLS, DRIFTS, DURING PDI CLUTCH PEDAL SQUEAL/SQUEAK WHEN OPERATING CLUTCH PEDAL CUSTOMER STATES THE A/C SYSTEM DOES NOT PERFORM PROPERLY CUSTOMER STATES INTERIOR "A" PILLAR TRIM IS LOOSE CUSTOMER STATES WIND NOISE FROM DRIVERS DOOR/WINDOW GUIDE CUSTOMER STATES AIRBAG LIGHT IS ON ANY KEY FUNCTIONS (INCLUDING STARTING, KESSY, REMOTE BUTTONS)
INFORMATIONAL PUBLICATION DISCRIBING THE MANUFACTURING USE OF RUST INHIBITORS AND ANTI SEIZE PRODUCTS DURING ASSEMBLY,...
Read full bulletin
AND HOW THE PRODUCT(S) "RUN OFF" MAY BE MISINTERPRETED AS AN ENGINE OIL OR AUTOMATIC TRANSMISSION OIL LEAK.
"ENGINE, MISFIRE DIAGNOSTIC AID THE MIL IS FLASHING OR ILLUMINATED."
MIL-ON, FAULT P309F OR P309D, NO ELECTRIC DRIVE MODE MIL-ON, FAULT P013E IN THE ECM CUSTOMER STATES NOISE FORM THE...
Read full bulletin
ENGINE/TURBO FUEL GAUGE NOT READING FULL AFTER TOPPING UP FUEL FUEL LINE RATTLE CLUTCH PEDAL SQUEAL/SQUEAK WHEN OPERATING CLUTCH PEDAL MIL-ON P0299 MIL-ON P0101 AND OR P0100 EPC LIGHT P03AF, P03A5, P03B9, P039B CENTER CAP MISSING AFTER PDI BACK-UP CAMERA
DIAGNOSTIC ASSISTANCE SHOULD THE YELLOW ENGINE OIL LAMP REMAIN ILLUMINATED WITH ENGINE OIL LEVEL AT THE PROPER LEVEL.
Infotainment
6 bulletinsAlternative method for radio code retrieval.
Update to existing information to address phone concerns via bluetooth resulting from saved emoji information
Diagnostic tip to look for aftermarket phone software that can effect infotainment operation.
Update to existing information to address phone concerns via bluetooth resulting from saved emoji information
Diagnostic tip to look for aftermarket phone software that can effect infotainment operation.
CLEAR REPAIR INFORMATION/EXPLANATION TO ADDRESS A MESSAGE THAT DISPLAYS WHEN THE BACK UP CAMERA IS USE.
Transmission
5 bulletinsUpdate to model year applicability and existing tip for Dual clutch basic settings procedure.
Update model year applicability and existing tip for transmission basic settings direction.
Update to model year applicability and existing tip for Dual clutch basic settings procedure.
Update model year applicability and existing tip for transmission basic settings direction.
MIL-ON, FAULT P309F OR P309D, NO ELECTRIC DRIVE MODE CUSTOMER STATES CRANK NO START AND/OR IN-TANK FUEL PUMP MAKING...
Read full bulletin
NOISE AND POSSIBLY WITH FUEL PUMP FAULTS MIL-ON, FAULT P013E IN THE ECM MIL-ON, FAULT P164B IN ECM MIL-ON, FAULT P0011 AND/OR P0016 IN THE ECM MIL-ON, FAULT P0011 AND/OR P0016 IN THE ECM MIL-ON, FAULT P0011 AND/OR P0016 IN THE ECM MIL-ON, FAULT P2407 IN THE ECM CUSTOMER STATES THE FUEL GAUGE DOES NOT READ FULL MIL ON, FAULT P2181 IN THE ECM MIL-ON, FAULT P0456 IN THE ECM CUSTOMER STATES THERE IS A NOISE WHILE TURNING/ GOING OVER BUMPS VEHICLE ALIGNMENT NOT CORRECT, STEERING OFF CENTER, PULLS, DRIFTS, DURING PDI CLUTCH PEDAL SQUEAL/SQUEAK WHEN OPERATING CLUTCH PEDAL CUSTOMER STATES THE A/C SYSTEM DOES NOT PERFORM PROPERLY CUSTOMER STATES WIND NOISE FROM DRIVERS DOOR/WINDOW GUIDE WATER LEAK FROM SUNROOF/HEADLINER, WATER STAINS ON HEADLINER CUSTOMER STATES AIRBAG LIGHT IS ON ANY KEY FUNCTIONS (INCLUDING STARTING, KESSY, REMOTE BUTTONS)
Pre-Delivery & Maintenance
2 bulletinsAdjustment of Time Unit Correction Payments for 2014/2015 Model Year Maintenance Claims
INSTRUCTIONS TO MANUALLY SET SERVICE INTERNAL MAXIMUM VALUES AFTER INSTRUMENT CLUSTER REPLACEMENT, TO PREVENT FALSE...
Read full bulletin
MESSAGES TO THE CUSTOMER.
Hybrid & EV
1 bulletinCampaign Reminder Communication.
Read full bulletin
Also includes: 1998-2004 Beetle, 2003-2004 Beetle Convertible, 2019 Beetle Convertible, 1994-2004 Eurovan, 1994-2004 Golf, 1994-2004 Jetta, 2001-2004 Jetta Wagon, 2018-2019 Tiguan LWB, 1994-2004 Passat, 1994-2004 Passat Wagon, 2004 Phaeton, 2013-2016 Jetta Hybrid, 2004 R32 and 1995-2006 Cabrio.
Body & Paint
1 bulletinexplaination of cross car distorion when looking through the windshield and how the "effect" in normal.
Tires & Wheels
1 bulletinBrand specific Alignment rack software information to address calibration concerns for adaptive cruise control.
Fuel System
1 bulletinTHIS DEALER LETTER GIVES AN UPDATE ON THE CURRENT EMISSIONS ISSUES WITH REGARDS TO 2.0L TDI VEHICLES.