1999 Volkswagen Eurovan TSBs
64 Technical Service Bulletins across 12 categories
Categories
Other
15 bulletinsSUBJECT REGARDING LATCH SYSTEM LOWER ANCHORS AND TETHERS FOR CHILDREN, INSTALLING / RETROFITTING.
Read full bulletin
*TT
SOME VEHICLES MAY EXHIBIT DIAGNOSTIC TROUBLE CODES P1580 (17988) AND P0103 (16487) STORED IN DIAGNOSTIC TROUBLE CODE MEMORY.
Read full bulletin
*TT
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
Squeaks, Rattles, Noise, Repair Materials
Contacting the parts helpline
Tool number added to table.
Read full bulletin
Removal of Behr Flush Kit. VAS 6337/1A
The part number listed in the document is to be returned if it meets the criteria provided.
VAS 6154 Replacement Part Setup Guide
This special notice is to inform dealers to return all part numbers listed in the document and order the superseded part...
Read full bulletin
numbers going forward.
Tip for Scan tool concerns that may occur duing a test plan
DIAGNOSTIC TROUBLE CODE (DTC) P1603 (18011) STORED IN DTC MEMORY.
Read full bulletin
*TT
RADIATOR FAN DAMAGED CAUSED BY IMPROPERLY SUPPORTING THE RADIATOR ASSEMBLY WHEN REPAIRS REQUIRE THE RADIATOR TO BE PIVOTED FORWARD.
Read full bulletin
*TT
RADIATOR FAN DAMAGED CAUSED BY IMPROPERLY SUPPORTING THE RADIATOR ASSEMBLY WHEN REPAIRS REQUIRE THE RADIATOR TO BE TIPPED FORWARD.
Read full bulletin
*TT
Engine
15 bulletinsSUBJECT REGARDING ENGINE OIL CAPACITIES.
Read full bulletin
*TT
Engine Oils Which Meet Volkswagen Oil Quality Standard VW 502 00/505 00/505 01 and VW 504 00/507 00
Fuel Additive to Help Prevent Sporadic Misfire Faults
Update to Volkswagen engine oil standards
To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line.
Read full bulletin
The check must be performed with the engine running and heated rear window switched on. Switch OFF the ignition and visually locate the damage. Proceed with checking any other lines as necessary. Once the damaged line is identified, repair utilizing the Repair kit by Permatex ITEM 09117.
Fault code P1297 may be set and fuel mixtures may go lean if the vehicle is driven under load or revved up and then...
Read full bulletin
returned to idle.
Volkswagen Engine oil quality standards, update to attachments.
Engine oil quality standards, update to attachments.
Update engine oil quality standard lists (attachments)
Engine Oils Which Meet Volkswagen Oil Quality Standards
17 17 01 July 5, 2017 2012855 Supersedes Technical Bulletin 17-16-02 (V171602) dated April 29, 2016 due to updated oil...
Read full bulletin
standards lists to current specifications. Engine Oils Which Meet Volkswagen Oil Quality Standards
Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt...
Read full bulletin
meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engine running and heated rear window switched on. Switch OFF the ignition and visually locate the damage.
Technical Bulletin (Engine Oils Which Meet Volkswagen Oil Quality Standard): This document informs of a sample list...
Read full bulletin
of products generally available in the North American market that meet the Volkswagen Oil Quality Standard
ENGINE COOLANT TEMPERATURE (ECT) SENSOR.
Read full bulletin
*TC
THE RADIATOR FANS CAN BE DAMAGED IF THE PROPER TOOL IS NOT USED TO HOLD THE RADIATOR ASSEMBLY IN THE SERVICE POSITION.
Read full bulletin
SERVICE ACTION TO ALERT SERVICE PERSONNEL BY AFFIXING A RADIATOR FAN SERVICE POSITION WARNING LABEL IN THE ENGINE COMPARTMENT. *TT
Electrical
10 bulletinsBattery, Testing and Charging Using Midtronics VAS6161, MCR340V, InCharge 940, or GRX3000 Charger
Air Conditioning, Cleaning of the Refrigerant Circuit (U.S.Only)
Battery testing and charging using special tools VAS6161 & GRX3000VAS Charger.
Read full bulletin
Updated to include additional model year applicability.
Battery Testing and Charging instruction.
Read full bulletin
Updated to include model year 2019 applicability.
This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, technical...
Read full bulletin
bulletins, pending service solutions, tech tips, campaigns, updates, and suggestions.
This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, ElsaPro...
Read full bulletin
infomedia icons grayed out, workshop equipment tool storage application, technical bulletins, pending service solutions, tech tips, campaigns, updates, and suggestions.
Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit (U.S.Only)): In cases where an air...
Read full bulletin
conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or component is circulated throughout the refrigerant circuit, the refrigerant circuit must be cleaned of any and all debris or damage to the replacement components will result. This document contains information on how to diagnose, and service this issue.
Technical Bulletin: Battery, Discharged, Diagnosis for Excessive Static Current Draw
Technical Bulletin: Battery, Testing and Charging Using Midtronics VAS6161, MCR340V, InCharge 940, or GRX3000VAS...
Read full bulletin
Charger
Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit): In cases where an air conditioning system...
Read full bulletin
component (such as a compressor or other system component) has failed and debris from the compressor or component is circulated throughout the refrigerant circuit, the refrigerant circuit must be cleaned of any and all debris or damage to the replacement components will result. Debris can be dispersed throughout the refrigerant circuit after a/c component damage. In order to maintain A/C operating efficiency, it is important to flush the refrigerant circuit after A/C component repairs.
Lighting
7 bulletinsExterior Lights, Moisture Accumulation
Exterior Lights, Moisture Accumulation
Exterior Lights, Moisture Accumulation
Condensation and or water droplets visible on inside of exterior light lenses.
Read full bulletin
TB updated to include model year 2019 applicability.
Technical Bulletin (Exterior Lights, Moisture Accumulation): Exterior light assemblies (headlights, taillights, fog...
Read full bulletin
lights, turn signals) are vented and may collect moisture on their inner surfaces, depending on humidity and other climatic changes. This document discusses necessary to diagnosis, and potential remedy of the issue.
Technical Bulletin: Condensation and or water droplets becomming visible on inside of exterior light lenses issue is...
Read full bulletin
discussed in this document
Technical Bulletin (Exterior Lights, Moisture Accumulation): This document informs of the Condensation and or water...
Read full bulletin
droplets visible on inside of exterior light lenses. The document also informs how to service the issue.
Software & Calibration
7 bulletinsIn SAGA, the time units for the Volkswagen DoubleCheck labor operation were reduced in error from 50 time units to 30...
Read full bulletin
time units during the system update posted on July 4th.
Update model year applicability to include 2023.
Updated to include additional models and model year applicability.
This communication is to update our ProFi dealers of the current status of the latest inbound and outbound ProFi...
Read full bulletin
requests.
Data Link connector pin assignment chart that is applicable to all models.
Read full bulletin
Update model year applicability.
Update to model year applicability.
Update model year applicability to include 2017.
Body & Paint
3 bulletinsTechnical Bulletin (Squeaks, Rattles, Noise, Repair Materials): This doucment contains a list of components and...
Read full bulletin
applications developed to repair concerns of squeaks, rattles, noise and trim fit conditions.
Technical Bulletin (Windshield Wipers Streak or Smear): Windshield or rear window is streaked, has a snakeskin appearance, or the surface feels rough.
Read full bulletin
To avoid unnecessary replacement of wiper blades, the condition and cleanliness of the windshield, rear window and wiper blades, should be checked first. This document contains information on how to diagnose, and service this issue.
Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt...
Read full bulletin
meter to check for 0 V, which will be present after the open in the grid line. This document informs of how to diagnose the issue and tips on servicing the issue
Fuel System
2 bulletinsUpdate to existing tip for fuel quality checking.
EVALUATING FUEL MIXTURE DIAGNOSTIC TROUBLE CODES- HOW TO PERFORM EFFECTIVE DIAGNOSIS RELATED TO FUEL SYSTEM ADAPTATION - SYSTEM TOO RICH/TOO LEAN.
Read full bulletin
VOLKSWAGEN. *MJ
Pre-Delivery & Maintenance
1 bulletinVolkswagen Warranty Policies and Procedures ? April 2014
Air Bags & Safety
1 bulletinAirbag Issues.
Infotainment
1 bulletinAlternative method for radio code retrieval.
Steering
1 bulletinSteering angle adaptation instructions, not included in repair manual
Transmission
1 bulletinVOLKSWAGEN: EXHAUST HEAT SHIELD, REPLACEMENT GUIDELINES.
Read full bulletin
HEAT SHIELDS ARE TO BE INSPECTED AFTER COMPLETION O ANY TYPE OF REPAIR TO THE UNDERBODY (EXHAUST SYSTEM TRANSMISSION, ETC.), AND IF DAMAGED, REPLACED. *PE