1999 Volkswagen Beetle TSBs
108 Technical Service Bulletins across 14 categories
Categories
Engine
25 bulletinsSOME VEHICLES MAY EXHIBIT THROTTLE PEDAL VIBRATION AT IDLE AND / OR RAPPING NOISE AGAINST ENGINE COVER HEARD ON VEHICLES WITH SECONDARY AIR INJECTION.
Read full bulletin
*TT
SUBJECT REGARDING ENGINE OIL CAPACITIES.
Read full bulletin
*TT
Engine Oils Which Meet Volkswagen Oil Quality Standard VW 502 00/505 00/505 01 and VW 504 00/507 00
Fuel Additive to Help Prevent Sporadic Misfire Faults
Update to Volkswagen engine oil standards
Emissions Recall Circular - 1999-2001 Volkswagen Folf/Jetta and New Beetle 2.0 Liter Gasoline Engine Vehicles...
Read full bulletin
Reprogramming of Engine Control Module and Replacement of Malfunctioning Oxygen Sensor
To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line.
Read full bulletin
The check must be performed with the engine running and heated rear window switched on. Switch OFF the ignition and visually locate the damage. Proceed with checking any other lines as necessary. Once the damaged line is identified, repair utilizing the Repair kit by Permatex ITEM 09117.
Fault code P1297 may be set and fuel mixtures may go lean if the vehicle is driven under load or revved up and then...
Read full bulletin
returned to idle.
Volkswagen Engine oil quality standards, update to attachments.
Engine oil quality standards, update to attachments.
Update engine oil quality standard lists (attachments)
Engine Oils Which Meet Volkswagen Oil Quality Standards
Emissions Recall Circular (2.0 Liter Gasoline Engine Vehicles Reprogramming of Engine Control Module and Replacement...
Read full bulletin
of Malfunctioning Oxygen Sensor): Volkswagen has found that the oxygen sensor in the upper part of the exhaust system could fail under certain conditions, potentially causing a vehicle to exceed Federal and/or California emission standards, or to experience increased fuel consumption. ?Thermal shock? within the sensor caused by moisture accumulation could cause oxygen sensor failure. If the oxygen sensor fails, the vehicle?s "check engine" light on the dashboard will illuminate. The corrective action taken for this issue was to Check the emission control system for proper function, reset electronically the engine?s control module and replace the oxygen sensor, if necessary.
Emissions Recall Circular (2.0 Liter Gasoline Engine Vehicles Reprogramming of Engine Control Module and Replacement of...
Read full bulletin
Malfunctioning Oxygen Sensor): Volkswagen has found that the oxygen sensor in the upper part of the exhaust system could fail under certain conditions, potentially causing a vehicle to exceed Federal and/or California emission standards, or to experience increased fuel consumption. ?Thermal shock? within the sensor caused by moisture accumulation could cause oxygen sensor failure. If the oxygen sensor fails, the vehicle?s "check engine" light on the dashboard will illuminate. The corrective action taken for this issue was to Check the emission control system for proper function, reset electronically the engine?s control module and replace the oxygen sensor, if necessary.
Engine replacement tip
17 17 01 July 5, 2017 2012855 Supersedes Technical Bulletin 17-16-02 (V171602) dated April 29, 2016 due to updated oil...
Read full bulletin
standards lists to current specifications. Engine Oils Which Meet Volkswagen Oil Quality Standards
Tech Tips (Equipped with ALH TDI Engine - Glow Plug Replacement Tip): This document informs that there are 2...
Read full bulletin
suppliers for the TDI glow plugs-Bosch and Beru. When replacing the glow plugs make sure that you do not mix stock. The vehicle must have all the same supplier
Tech Tips (Models with 1.8T Engine - Pressure Loss issues): Fault code P1297 may be set and fuel mixtures may go lean...
Read full bulletin
if the vehicle is driven under load or revved up and then returned to idle. This document informs of what to do should these systems occur.
Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt...
Read full bulletin
meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engine running and heated rear window switched on. Switch OFF the ignition and visually locate the damage.
Technical Bulletin (Engine Oils Which Meet Volkswagen Oil Quality Standard): This document informs of a sample list...
Read full bulletin
of products generally available in the North American market that meet the Volkswagen Oil Quality Standard
VOLKSWAGEN: HEADLIGHTS MAY INTERMITTENTLY DIM SLIGHTLY AT IDLE.
Read full bulletin
THE HEADLAMPS OR INSIDE LIGHTS INTERMITTENTLY DIM SLIGHTLY AT IDLE SPEED. AT IDLE SPEED THE ALTERNATOR VOLTAGE CAN FLUCTUATE, AS THE ALTERNATOR CANNOT FULLY COMPENSATE THE FLUCTUATIONS. GOLF & WAGON GTI, NEW BEETLE & CONVERTIBLE, EOS, JETTA & WAGON & SPORTWAGON, RABBIT, R32, TIGUAN. *PE
VOLKSWAGEN: HEADLIGHTS MAY INTERMITTENTLY DIM SLIGHTLY AT IDLE.
Read full bulletin
AT IDLE SPEED THE ALTERNATOR VOLTAGE CAN FLUCTUATE, AS THE ALTERNATOR CANNOT FULLY COMPENSATE THE FLUCTUATIONS. SOME ELECTRIC CONSUMERS COME ON IN CYCLES OR HAVE NO CONSTANT CURRENT CONSUMPTION, WHICH AMPLIFIES THIS EFFECT. THE LOAD CONDITION OF THE VEHICLE BATTERY CAN ALSO INFLUENCE THIS EFFECT. MODELS GOLF, GTI, NEW BEETLE & CONVERTIBLE, EOS, JETTA, WAGON, SPORTWAGEN, RABBIT, R32, GOLF WAGON, TIGUAN. *PE
EMISSIONS RECALL CIRCULAR.
Read full bulletin
REPROGRAMMING OF ENGINE CONTROL MODULE AND REPLACEMENT OF MALFUNCTIONING OXYGEN SENSOR. *KB
DIAGNOSTIC TROUBLE CODE (DTC) P1176 IS STORED IN DTC MEMORY (NEW BEETLE 1.8T, ENGINE CODE APH).
Read full bulletin
*NM
ENGINE PRE-HEATER INSTALLATION.
Read full bulletin
CALIX. *TT
Software & Calibration
24 bulletinsQuick Reference Update Guide
In SAGA, the time units for the Volkswagen DoubleCheck labor operation were reduced in error from 50 time units to 30...
Read full bulletin
time units during the system update posted on July 4th.
Quick Reference Update Guide
Quick Reference Update Guide
Quick Reference Update Guide
Quick reference update guide.
Update model year applicability to include 2023.
Updated to include additional models and model year applicability.
Quick Reference Update Guide.
Update to model year applicability.
Updated to include model year 2014 thru 2018 applicability.
Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the...
Read full bulletin
customer concerns about a vehicle
Update to model year applicability.
Updated to include model year 2014 thru 2018 applicability.
Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the...
Read full bulletin
customer concerns about a vehicle
Quick Reference of vehicle concerns.
Read full bulletin
Includes a list of Software versions and the technical bulletin numbers that referred to the concerns Updated
Quick Reference Update Guide of the vehicles expected upgraded software level.
Read full bulletin
The latest corresponding technical bulletins that address the issues, and concerns that have been had with the vehicles.
This communication is to update our ProFi dealers of the current status of the latest inbound and outbound ProFi...
Read full bulletin
requests.
Data Link connector pin assignment chart that is applicable to all models.
Read full bulletin
Update model year applicability.
Quick Reference of vehicle concerns.
Read full bulletin
Includes a list of Software versions and the technical bulletin numbers that referred to the concerns Updated
Update to model year applicability.
Update model year applicability to include 2017.
Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the...
Read full bulletin
customer concerns about a vehicle
Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the...
Read full bulletin
customer concerns about a vehicle
Other
18 bulletinsVW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
Squeaks, Rattles, Noise, Repair Materials
Be aware that there are 2 suppliers for the TDI glow plugs-Bosch and Beru.
Read full bulletin
When replacing the glow plugs make sure that you do not mix stock. The vehicle must have all the same supplier or DTC P0380 (Glow Plug Monitoring) may set.
Contacting the parts helpline
Tool number added to table.
Read full bulletin
Removal of Behr Flush Kit. VAS 6337/1A
The part number listed in the document is to be returned if it meets the criteria provided.
VAS 6154 Replacement Part Setup Guide
This special notice is to inform dealers to return all part numbers listed in the document and order the superseded part...
Read full bulletin
numbers going forward.
Tip for Scan tool concerns that may occur duing a test plan
DIAGNOSTIC TROUBLE CODE (DTC) P1603 (18011) STORED IN DTC MEMORY.
Read full bulletin
*TT
Electrical
12 bulletinsINFORMATION REGARDING ELECTRONIC CONTROL MODULE (ECM) CODING.
Read full bulletin
*TT
P0102, P1128, P1296 - WA front oxygen sensor faults
Battery, Testing and Charging Using Midtronics VAS6161, MCR340V, InCharge 940, or GRX3000 Charger
Air Conditioning, Cleaning of the Refrigerant Circuit (U.S.Only)
Battery testing and charging using special tools VAS6161 & GRX3000VAS Charger.
Read full bulletin
Updated to include additional model year applicability.
Battery Testing and Charging instruction.
Read full bulletin
Updated to include model year 2019 applicability.
This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, technical...
Read full bulletin
bulletins, pending service solutions, tech tips, campaigns, updates, and suggestions.
This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, ElsaPro...
Read full bulletin
infomedia icons grayed out, workshop equipment tool storage application, technical bulletins, pending service solutions, tech tips, campaigns, updates, and suggestions.
Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit (U.S.Only)): In cases where an air...
Read full bulletin
conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or component is circulated throughout the refrigerant circuit, the refrigerant circuit must be cleaned of any and all debris or damage to the replacement components will result. This document contains information on how to diagnose, and service this issue.
Technical Bulletin: Battery, Testing and Charging Using Midtronics VAS6161, MCR340V, InCharge 940, or GRX3000VAS...
Read full bulletin
Charger
Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit): In cases where an air conditioning system...
Read full bulletin
component (such as a compressor or other system component) has failed and debris from the compressor or component is circulated throughout the refrigerant circuit, the refrigerant circuit must be cleaned of any and all debris or damage to the replacement components will result. Debris can be dispersed throughout the refrigerant circuit after a/c component damage. In order to maintain A/C operating efficiency, it is important to flush the refrigerant circuit after A/C component repairs.
WIRING HARNESS, COOLANT CONTAMINATION AT INSTRUMENT CLUSTER.
Read full bulletin
*KB
Lighting
8 bulletinsExterior Lights, Moisture Accumulation
Exterior Lights, Moisture Accumulation
Exterior Lights, Moisture Accumulation
Condensation and or water droplets visible on inside of exterior light lenses.
Read full bulletin
TB updated to include model year 2019 applicability.
Technical Bulletin (Exterior Lights, Moisture Accumulation): Exterior light assemblies (headlights, taillights, fog...
Read full bulletin
lights, turn signals) are vented and may collect moisture on their inner surfaces, depending on humidity and other climatic changes. This document discusses necessary to diagnosis, and potential remedy of the issue.
Technical Bulletin: Condensation and or water droplets becomming visible on inside of exterior light lenses issue is...
Read full bulletin
discussed in this document
Technical Bulletin (Exterior Lights, Moisture Accumulation): This document informs of the Condensation and or water...
Read full bulletin
droplets visible on inside of exterior light lenses. The document also informs how to service the issue.
DTC'S P1297 (17705) OR P1557 (17965) STORED IN DTC MEMORY.
Read full bulletin
THIS MAY BE CAUSED BY INTAKE HOSES LEAKING (DURING BOOST CONDITIONS) DUE TO INCORRECT TORQUE ON CLAMPS OR IMPROPER PLACEMENT, WORN OR TORN INTAKE HOSES. *KB
Body & Paint
6 bulletinsSUBJECT PERTAINING TO THE SUNROOF SLIDING HEADLINER, REPLACING SLIDES.
Read full bulletin
*TT
Customer States Windshield Wipers Streak or Smear
Technical Bulletin (Squeaks, Rattles, Noise, Repair Materials): This doucment contains a list of components and...
Read full bulletin
applications developed to repair concerns of squeaks, rattles, noise and trim fit conditions.
Technical Bulletin (Windshield Wipers Streak or Smear): Windshield or rear window is streaked, has a snakeskin appearance, or the surface feels rough.
Read full bulletin
To avoid unnecessary replacement of wiper blades, the condition and cleanliness of the windshield, rear window and wiper blades, should be checked first. This document contains information on how to diagnose, and service this issue.
Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt...
Read full bulletin
meter to check for 0 V, which will be present after the open in the grid line. This document informs of how to diagnose the issue and tips on servicing the issue
DOOR WINDOWS, MAY SEPERATE FROM WINDOW REGULATOR CLAMPS.
Read full bulletin
*KB
Pre-Delivery & Maintenance
4 bulletinsPerfect Delivery Inspection (PDI) - Technician and Detailer Inspections
Volkswagen Warranty Policies and Procedures ? April 2014
Beetle Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections: A checklist to insure a customer...
Read full bulletin
receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has purchased
Beetle Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections: A checklist to insure a customer...
Read full bulletin
receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has purchased
Fuel System
3 bulletinsUpdate to existing tip for fuel quality checking.
MIL IS ON AND/OR CATALYTIC CONVERTER IS RATTLING.
Read full bulletin
*KB
MIL IS ON AND OR CATALYTIC CONVERTER IS RATTLING.
Read full bulletin
*SC
Transmission
2 bulletinsCONCERNS WITH TRANSMISSION IN LIMP MODE WITH NO MALFUNCTION INDICATOR LAMP ILLUMINATED.
Read full bulletin
*TT
VOLKSWAGEN: EXHAUST HEAT SHIELD, REPLACEMENT GUIDELINES.
Read full bulletin
HEAT SHIELDS ARE TO BE INSPECTED AFTER COMPLETION O ANY TYPE OF REPAIR TO THE UNDERBODY (EXHAUST SYSTEM TRANSMISSION, ETC.), AND IF DAMAGED, REPLACED. *PE
Infotainment
2 bulletinsCONCERNS WITH POOR OR NO RECEPTION FROM AM RADIO.
Read full bulletin
*TT
Alternative method for radio code retrieval.
HVAC & Climate
1 bulletinHVAC, Temperature Output Control Cannot Be Adjusted
Air Bags & Safety
1 bulletinAirbag Issues.
Suspension
1 bulletinTechnical Bulletin (Temperature Output Control Cannot Be Adjusted): Customer states cannot adjust temperature and/or A/C is not cold.
Read full bulletin
The blend door control lever moves freely, but the blend door does not operate. A bushing that fits on the lever may have a broken tab/clip. This document discusses the potential remedy of the issue.
Hybrid & EV
1 bulletinHYBRID OIL PAN, INSTALLING.
Read full bulletin
*TT