2014 Volkswagen Beetle Convertible TSBs
1,000 Technical Service Bulletins across 17 categories
Categories
Engine
229 bulletinsHow to measure engine oil consumption.
Proper engine oil level before leaving the factory.
Engine misfire diagnostic aid.
Fuel Additive to prevent sporatic misfire
Volkswagen Engine Oil Quality Standards (U.S.
Read full bulletin
Only)
Volkswagen Engine Oil Quality Standards
Identifying and Mixing Engine Coolant
Engine Oil Standards
A list of engine oil that meet Volkswagen Engine Oil Standards
How to perform the engine oil consumption measurement
Checking Engine Oil and correctly reading dip stick
Engine Misfire Diagnostic Aid
Fuel additive to help with misfire faults
Engine Oil Standards
Engine oil quality standards
Engine Assembly Tip
Engine Replacement Tip
Engine oil quality standards
Engine oil quality standards
VW Engine oil quality standards
Frozen Charge Air Cooler, Engine no start updated to include Parts ordering notification.
VW Engine oil quality standards
Carefree Maintenance Coverage for Interim Oil Changes for Certain 2009 ? 2015 MY Volkswagen TDI Clean Diesel Engine...
Read full bulletin
Vehicles Registered in the State of Minnesota Only (US Dealers
VW Engine oil quality standards
VW Engine oil quality standards
VW Engine oil quality standards
Rattling Noises from Engine Compartment Area or Exhaust System
VW Engine oil quality standards
2.5L Engine
Beetle Convertible Maintenance Schedule For USA 1.8T Engine
Engine Oil Level
Engine Oils Which Meet Volkswagen Oil Quality Standard VW 502 00/505 00/505 01 and VW 504 00/507 00
Oil Consumption Measurement
Engine Oil Level
Oil Consumption Measurement
Oil Consumption Measurement
Camshaft Adjustment Valve 1 -N205- Diagnosis
Proper Removal of Engine Cover to Avoid Breakage
MIL ON, Cylinder Contribution/Balance Faults Stored in ECM Fault Memory P0263, P0266, P0269 and/or P0272
MIL ON, Cylinder Contribution/Balance Faults Stored in ECM Fault Memory P0263, P0266, P0269 and/or P0272
Update Programming ECM to Correct Engine Load Calculations
MIL ON, Cylinder Contribution/Balance Faults Stored in ECM Fault Memory P0263, P0266, P0269 and/or P0272
MIL ON, Cylinder Contribution/Balance Faults Stored in ECM Fault Memory P0263, P0266, P0269 and/or P0272
Engine, Misfire Diagnostic Aid
Fuel Additive to Help Prevent Sporadic Misfire Faults
Fuel Additive to Help Prevent Sporadic Misfire Faults
Fuel Additive to Help Prevent Sporadic Misfire Faults
Fuel Additive to Help Prevent Sporadic Misfire Faults
Update to Volkswagen engine oil standards
Slave Cylinder - Clutch Pedal Operation Diagnosis
MIL ON in Sub-Freezing Conditions (DTC P0087), Engine Cranks but does not Start
Engine will not start after standing in cold weather below 0C (32F), MIL may be illuminated with various induction...
Read full bulletin
and/or boost system faults stored in ECM.
Customers may complain of a rattling noise from engine or exhaust area while accelerating from 1800-3000 RPM.
Engine will not start after standing in cold weather below 0C (32F), MIL may be illuminated with various induction...
Read full bulletin
and/or boost system faults stored in ECM.
To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line.
Read full bulletin
The check must be performed with the engine running and heated rear window switched on. Switch OFF the ignition and visually locate the damage. Proceed with checking any other lines as necessary. Once the damaged line is identified, repair utilizing the Repair kit by Permatex ITEM 09117.
Volkswagen Engine oil quality standards, update to attachments.
Wiper Motor Noisy or Inoperative
Activated Charcoal Filter System, Solenoid Valve 1 -N80- (Canister Purge Valve) Diagnosis
Temporary warranty process and parts return program (1.8T engine models)
Because Volkswagen supports the development and use of renewable fuels (such as biodiesel fuel blends), customers with...
Read full bulletin
certain 2009-2015 MY Volkswagen TDI Clean Diesel Engine vehicles registered in the State of Minnesota only will receive a communication in July 2014 regarding the use of biodiesel fuel blends in their vehicles.
A change was made to the engine Oil Filter Adapter (OFA) for 2014 Model Year vehicles that resulted in a change in the oil filter element.
Read full bulletin
It is important to note that the two different designs are Not interchangeable. Failure to install the correct oil filter WILL result in permanent engine damage.
Incorrect torque converter or flywheel/flexplate installation can result in transmission damage.
Read full bulletin
When installing an engine, flywheel or transmission, please follow the installation procedures outlined in ELSA. For the flywheel/flexplate, please be certain the correct shim is installed between it and the crankshaft (reference VWIQ120). When installing a torque converter, press the torque converter hub through the seal as far as the first stop. Turn the torque converter while pushing toward the transmission using light force, until the cut outs in the torque converter hub lock into the pump wheel plate. The torque converter slides in. The torque converter is installed correctly if it is easy to turn by hand and if it fits evenly in the transmission bell housing. Additionally, it should spin freely when the transmission bell housing bolts are torqued to the engine block, prior to installation of the flywheel to converter bolts (reference VWIQ121).
When diagnosis on the above engine leads to the testing of the N75, please refer to the picture below.
Read full bulletin
The diagram shows which vacuum ports on the N75 valve should hold vacuum and which ones should not.
Volkswagen Engine Oil Standards, updated to include model year 2024.
Engine Oil Consumption Measurement Instruction and Work sheet.
Correct engine oil level during Perfect Delivery Inspection (PDI)
Gasoline quality information in regards to gasoline engine performance.
Diagnostic Aid for engine misfire.
When replacing the complete vehicle lock set (all vehicle keys and lock cylinders) for any reason, be aware that the...
Read full bulletin
?Adapt keys? test plan will not allow the new keys to adapt to the vehicle. Instead, perform the test plan for ?New identity?. During this test plan, make the appropriate selection to indicate only the lock set has been replaced, as shown below in figures 1 and 2.
Volkswagen Engine oil quality standards, update to attachments.
Introduce new engine coolant compatible with all models and all model years.
Fuel Additive to Help Prevent Sporadic Misfire Faults
Fuel additive to help prevent sporadic misfire faults.
Engine Control Module software.
Engine oil quality standards, update to attachments.
Volkswagen Engine Oil Quality Standards
Engine Oil Quality Standards updated to include the latest Engine Oil attachments (excludes Routan & ID.4).
Engine Oil Quality Standards updated to include the latest Engine Oil attachments (excludes Routan & ID.4).
Engine Oil Quality Standards updated to include the latest Engine Oil attachments (excludes Routan & ID.4).
Engine Oil Quality Standards updated to include the latest Engine Oil attachments (excludes Routan & ID.4).
Engine Oil Quality Standards updated to include the latest Engine Oil ) excluding Routan & ID.4attachments.
Read full bulletin
(excludes Routan & ID.4)
Engine Oil Quality Standards updated to include the latest Engine Oil attachments.
Read full bulletin
(excludes Routan & ID.4)
Engine Oil Quality Standards updated to include the latest Engine Oil attachments.
Read full bulletin
(excludes Routan & ID.4)
Engine Oil Quality Standards updated to include model year 2023 and the latest Engine Oil attachments.
Read full bulletin
(excludes Routan & ID.4)
Engine oil consumption measurement.
VW engine oil specifications.
Read full bulletin
Update to model year applicability.
VW engine oil specifications.
Read full bulletin
Update to attachments.
Checking engine oil during PDI.
Recommended fuel additive to avoid engine misfires.
Engine misfire diagnostic aid.
All Volkswagen engines are filled to a specific volume before leaving the factory.
Read full bulletin
This level may vary depending on the testing conditions, but will always be within the allowable specification for engine protection.
Engine oil pressure priming.
Update engine oil quality standard lists (attachments)
Rattling noises from engine compartmen area or exhaust system.
Update engine oil quality standard lists (attachments)
Engine oil consumption measurement.
Read full bulletin
Update procedure and work sheet.
Update engine oil quality standard lists (attachments)
Update engine oil quality standard lists (attachments)
Update engine oil quality standard lists (attachments)
Update engine oil quality standard lists (attachments)
Update engine oil quality standard lists (attachments)
Update engine oil quality standard lists (attachments)
Update engine oil quality standard lists (attachments)
DTC P0401 diagnostic assistance, additional smoke test and cold air control valve test
Update engine oil quality standard lists (attachments)
Properly checking and reading engine oil level instruction
Engine Misfire Diagnostic Aid.
Read full bulletin
Updated to include additional model and model year applicability.
Engine oil consumption measurement.
Fuel Additive to Help Prevent Sporadic Misfire Faults
Update engine oil quality standard lists (attachments)
DTC P0401 diagnostic assistance, additional smoke test and cold air control valve test
Update engine oil quality standard lists (attachments)
Update engine oil quality standard lists (attachments)
Updated to include update recommended engine oil attachments.
Body surfaces (engine compartment and underside of hood) are not directly visible (exposed) therefore do not match...
Read full bulletin
exterior paint finish.
Oil consumption test updated to include additional models and model year applicability.
Engine oil level checking, updated to include model year 2021
Customer states MIL-on with P0496 Customer states MIL-on with U0284 Customer states oil leak from the engine Customer...
Read full bulletin
states oil leak from the engine Customer states MIL-on with P0111 Customer states MIL-on with P2407 "Customer states MIL-on with P11A1/P11A2/P11A3/P11A4/P11A5/P11A6/P11A7/P11A8/ P11A9/P11AA/P11AB/P11AC/P11AD/P11AE/P11AF/P11B0" Customer states rattle noise from under vehicle Customer states MIL-on, HPFP mounting bolts loose/broken No crank, no start Driver seat heater inoperative Customer states both headlights are cracked Customer states noise heard when adjusting air distribution on HVAC controls Wind noise from front doors Customer states MIL-on with P0401
Oil pressure priming after engine replacement or internal repair.
Customer states MIL-on with P0496 Customer states MIL-on with U0284 Customer states oil leak from the engine Customer...
Read full bulletin
states oil leak from the engine Customer states MIL-on with P0111 Customer states MIL-on with P0442 Customer states MIL-on with P2407 "Customer states MIL-on with P11A1/P11A2/P11A3/P11A4/P11A5/P11A6/P11A7/P11A8/ P11A9/P11AA/P11AB/P11AC/P11AD/P11AE/P11AF/P11B0" Customer states MIL-on, HPFP mounting bolts loose/broken No crank, no start Driver seat heater inoperative Customer states both headlights are cracked Customer states noise heard when adjusting air distribution on HVAC controls Wind noise from front doors Customer states MIL-on with P0401
Customer states MIL-on with P0496 Customer states MIL-on with U0284 Customer states oil leak from the engine Customer...
Read full bulletin
states oil leak from the engine Customer states MIL-on with P0111 Customer states MIL-on with P0442 Customer states MIL-on with P2407 "Customer states MIL-on with P11A1/P11A2/P11A3/P11A4/P11A5/P11A6/P11A7/P11A8/ P11A9/P11AA/P11AB/P11AC/P11AD/P11AE/P11AF/P11B0" Customer states MIL-on, HPFP mounting bolts loose/broken No crank, no start Customer states both headlights are cracked Customer states noise heard when adjusting air distribution on HVAC controls Wind noise from front doors Customer states MIL-on with P0401
Customer states MIL-on with P0496 Customer states MIL-on with U0284Customer states oil leak from the engine Customer...
Read full bulletin
states oil leak from the engine Customer states MIL-on with P0111Customer states MIL-on with P0442 Customer states MIL-on with P2407 "Customer states MIL-on with P11A1/P11A2/P11A3/P11A4/P11A5/P11A6/P11A7/P11A8/ P11A9/P11AA/P11AB/P11AC/P11AD/P11AE/P11AF/P11B0" Customer states MIL-on, HPFP mounting bolts loose/broken No crank, no start Customer states both headlights are cracked Customer states noise heard when adjusting air distribution on HVAC controls Wind noise from front doors Customer states MIL-on with P0401
Customer states MIL-on with P0496 Customer states MIL-on with U0284 Customer states oil leak from the engine Customer...
Read full bulletin
states oil leak from the engine Customer states MIL-on with P0111 Customer states MIL-on with P0442 Customer states MIL-on with P2407 Customer states MIL-on, HPFP mounting bolts loose/broken No crank, no start Customer states both headlights are cracked Customer states noise heard when adjusting air distribution on HVAC controls Wind noise from front doors Customer states MIL-on with P0401
Customer states MIL-on with P0496 Customer states MIL-on with U0284 Customer states oil leak from the engine Customer...
Read full bulletin
states oil leak from the engine Customer states MIL-on with P0111 Customer states MIL-on with P0442 Customer states MIL-on, HPFP mounting bolts loose/broken No crank, no start Customer states both headlights are cracked Wind noise from front doors Customer states MIL-on with P0401
Customer states MIL-on with P0496 Customer states MIL-on with U0284 Customer states MIL-on with P02CC, P02CE, P02D0,...
Read full bulletin
P02D2, P02D4, and P02D6 P02D7 Customer states oil leak from the engine Customer states MIL-on with P0442 Customer states MIL-on, HPFP mounting bolts loose/broken No crank, no start Customer states both headlights are cracked Customer states MIL-on with P0401
Customer states MIL-on with P0496 Customer states MIL-on with P2440 Customer states MIL-on with U0284 Customer states...
Read full bulletin
MIL-on with P02CC, P02CE, P02D0, P02D2, P02D4, and P02D6 P02D7 Customer states oil leak from the engine Customer states MIL-on with P0442 Customer states MIL-on, HPFP mounting bolts loose/broken No crank, no start Customer states both headlights are cracked Customer states MIL-on with P0401
Customer states MIL-on with P0496 Customer states MIL-on with P2440 Customer states MIL-on with U0284 Customer states...
Read full bulletin
MIL-on with P02CC, P02CE, P02D0, P02D2, P02D4, and P02D6 P02D7 Customer states oil leak from the engine Customer states MIL-on with P0442 Customer states MIL-on, HPFP mounting bolts loose/broken No crank, no start Customer states both headlights are cracked Customer states MIL-on with P0401
Customer states MIL-on with P0496 Customer states MIL-on with P2440 Customer states MIL-on with U0284 Customer states...
Read full bulletin
MIL-on with P02CC, P02CE, P02D0, P02D2, P02D4, and P02D6 P02D7 Customer states oil leak from the engine Customer states MIL-on with P0442 Customer states MIL-on, HPFP mounting bolts loose/broken No crank, no start Customer states both headlights are cracked Customer states MIL-on with P0401
Update to Volkswagen engine oil specification attachments.
Timing chain reset adaptation.
Update to Volkswagen engine oil specification attachments.
Update to Volkswagen engine oil specification attachments.
Engine Oil Checking at Pre-Delivery Inspection (PDI).
Read full bulletin
Updated to include model year 2020 applicability.
Engine and/or transmission control software designed and certified for a similar model/model year was used in vehicles affected by this action.
Read full bulletin
This could impact vehicle tailpipe emissions.
Engine and/or transmission control software designed and certified for a similar model/model year was used in vehicles affected by this action.
Read full bulletin
This could impact vehicle tailpipe emissions.
Update to Volkswagen engine oil standards.
Update to Volkswagen engine oil standards.
Update to Volkswagen engine oil standards.
Update to Volkswagen engine oil standards.
Read full bulletin
Also includes 2004 and 2005 Jetta Wagon and 2018-2020 Tiguan LWB
Engine oil quality standards.
Read full bulletin
Also includes all models for 1997-2003. Also Rabbit from 2006-2009.
Engine oils which meet Volkswagen oil quality standards.
SERV_ACT - Engine Control Module (ECM) Software_REVISED
SERV_ACT - Engine Control Module (ECM) Software_REVISED
Engine oils which meet Volkswagen oil quality standards.
SERV_ACT - Engine Control Module (ECM) Software_REVISED
SERV_ACT - Engine Control Module (ECM) Software_REVISED
Update to model year applicability.
Read full bulletin
Generator Replacement Charging System inoperative/malfunctions, noise from engine compartment, accessory drive belt damaged or missing.
Engine Oils Which Meet Volkswagen Oil Quality Standards
Valve spring diagnosis.
Gasoline Engine Misfire Diagnosis document
SERV_ACT - Engine Control Module (ECM) Software_REVISED
2.0L TDI Engine (GEN 1) Emissions Modification ? Customer Only (Retail Sold) USA ONLY - The Environmental Protection...
Read full bulletin
Agency and California Air Resources Board have determined that Volkswagen vehicles equipped with a 2.0L 4-cylinder TDI engine do not comply with applicable emissions regulations. The emissions control systems on the vehicles will not control emissions under off-cycle conditions as effectively as during the federal test procedure. The extent of the emissions increase under off-cycle conditions depends upon how the vehicles are driven. Revision Summary Updated work instructions.
Technical Bulletin (Rattling Noises from Engine Compartment Area or Exhaust System): Customers may complain of a...
Read full bulletin
rattling noise from engine or exhaust area while accelerating from 1800-3000 RPM. In order to complete proper diagnosis and ensure that the noise is coming from the turbocharger use the procedure in this document.
Technical Bulletin (Electric Coolant Fans Continue to Run after Ignition is Switched OFF): This document informs it...
Read full bulletin
is considered normal operation for the electric coolant fans to continue to run for up to 15 minutes after the ignition is switched off in gasoline engine applications, and up to 16 minutes in diesel engine applications.
Technical Bulletin (Oil Consumption Measurement): Customers have stated oil consumption is higher than the Volkswagen...
Read full bulletin
oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. This document informs how to test the oil consumption rate
Tech Tips (CBEA, CJAA, CKRA engine codes DPF replacement and/or DTCS P2413, P2463): This document informs of the use...
Read full bulletin
of aftermarket air filters such as cotton bed steel mesh or cone style, can cause the MAF sensor to not read accurately, affecting vehicle performance and critical monitoring functions for the diesel particulate filter. This can also result in premature DPF failure. Only use factory air filters. The use of aftermarket air filters is not supported as the system was designed and calibrated to work with factory air filters.
Technical Bulletin (Frozen Charge Air Cooler ? Engine Will Not Start): Engines will not start after standing in cold...
Read full bulletin
weather below 0C (32F), MIL may be illuminated with various induction and/or boost system faults stored in ECM. Moisture from the intake air condenses and collects in the charge air cooler. At cold temperatures this moisture can freeze causing blockage of the intake air system. This document informs how to Install a revised charge air cooler kit P/N 1K0 198 803B to avoid the formation of this moisture in the boost system.
Instruction to protect oil pressure sw.
Read full bulletin
to prevent contamination and possible failure when removing 1.8L & 2.0L engines
SERV_ACT - Engine Control Module (ECM) Software_REVISED
2.0L TDI Engine (GEN 1) Emissions Modification ? Customer Only (Retail Sold) USA ONLY - The Environmental Protection...
Read full bulletin
Agency and California Air Resources Board have determined that Volkswagen vehicles equipped with a 2.0L 4-cylinder TDI engine do not comply with applicable emissions regulations. The emissions control systems on the vehicles will not control emissions under off-cycle conditions as effectively as during the federal test procedure. The extent of the emissions increase under off-cycle conditions depends upon how the vehicles are driven. Revision Summary Updated work instructions.
Technical Bulletin (Rattling Noises from Engine Compartment Area or Exhaust System): Customers may complain of a...
Read full bulletin
rattling noise from engine or exhaust area while accelerating from 1800-3000 RPM. In order to complete proper diagnosis and ensure that the noise is coming from the turbocharger use the procedure in this document.
Technical Bulletin (Electric Coolant Fans Continue to Run after Ignition is Switched OFF): This document informs it...
Read full bulletin
is considered normal operation for the electric coolant fans to continue to run for up to 15 minutes after the ignition is switched off in gasoline engine applications, and up to 16 minutes in diesel engine applications.
Technical Bulletin (Oil Consumption Measurement): Customers have stated oil consumption is higher than the Volkswagen...
Read full bulletin
oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. This document informs how to test the oil consumption rate
Technical Bulletin (Frozen Charge Air Cooler ? Engine Will Not Start): Engines will not start after standing in cold...
Read full bulletin
weather below 0C (32F), MIL may be illuminated with various induction and/or boost system faults stored in ECM. Moisture from the intake air condenses and collects in the charge air cooler. At cold temperatures this moisture can freeze causing blockage of the intake air system. This document informs how to Install a revised charge air cooler kit P/N 1K0 198 803B to avoid the formation of this moisture in the boost system.
Instruction to protect oil pressure sw.
Read full bulletin
to prevent contamination and possible failure when removing 1.8L & 2.0L engines
SERV_ACT - Engine Control Module (ECM) Software_REVISED
Engine Control Module (ECM) Software_REVISED
This Document was revised to include information on when the replacement engine contains a Timing Chain or Timing Chain Tensioner.
Read full bulletin
Also includes the CPPA engine code labor operation and time units.
The Vehicle Maintenance Declaration has been added back to WISE for the Timing Chain Warranty Extension.
Incorrect removal of Turbocharger oil feed line may cause engine damage
Engine replacement tip
SERV_ACT - Engine Control Module (ECM) Software
SERV_ACT - Engine Control Module (ECM) Software
This document advises dealers regarding the Timing Chain/Timing Chain Tensioner Limited Warranty Extension
Technicians may find during PDI that the oil level is below the full mark, but still within the hash marks on the engine...
Read full bulletin
oil dip stick.
Clarification that no G410 is installed on these engines.
Timing Chain Class Action Update
17 17 01 July 5, 2017 2012855 Supersedes Technical Bulletin 17-16-02 (V171602) dated April 29, 2016 due to updated oil...
Read full bulletin
standards lists to current specifications. Engine Oils Which Meet Volkswagen Oil Quality Standards
VOLKSWAGEN DEALERSHIP COMMUNICATION: The vehicle?s engine management software has been improved to assure the vehicle?s...
Read full bulletin
tailpipe emissions are optimized and operating efficiently for Volkswagen Vehicles Equipped with a 2.0L TDI Clean Diesel Engine
Emissions Service Action: The vehicle?s engine management software has been improved to assure the vehicle?s tailpipe...
Read full bulletin
emissions are optimized and operating efficiently.
VOLKSWAGEN DEALERSHIP COMMUNICATION (Upcoming Update 64D6 ? Window Lifter Motors): On certain Beetle and Beetle...
Read full bulletin
convertibles within a limited production period, the incorrect window regulator motors were fitted in the front doors. This can lead to malfunctions in the front window lifter operation. The corrective action taken was to Replace the window regulator motors
Emissions Service Action (Certain 2010-2014 Volkswagen Vehicles with 2.0L TDI Clean Diesel Engine ECM Software Update):...
Read full bulletin
The vehicle?s engine management software has been improved to assure the vehicle?s tailpipe emissions are optimized and operating efficiently. Under certain operating conditions, the earlier strategy may have increased the chance of the vehicle?s MIL light illuminating. If the MIL illuminates for any reason, the vehicle will not pass an IM emissions inspection in some regions. The corrective action taken was to Install updated ECM software
To add model year 2016 and 2017 applicability and reminder about Programming Activation of Oil Pressure...
Read full bulletin
Regulation/Retraction on all models with 1.8L CPKA and CPRA engines after engine assembly, cylinder head or turbocharger replacement.
Update TB to include model year 2017 and include additional engine applicability.
Alternative repair direction to address DTC P1386 on the 2.5l engine.
Read full bulletin
Update to include Beetle and Beetle convertible applicability.
2014 Volkswagen Beetle Convertible Maintenance Schedule For USA 2.5L Engine: This document contains the maintenance...
Read full bulletin
service schedule for a vehicle from 10,000 miles to 120,000 miles.
Technical Bulletin (Generator Replacement): This document informs of Charging System inoperative/malfunctions, noise...
Read full bulletin
from engine compartment, accessory drive belt damaged or missing. From this condition one or more of the following symptoms are possible * Discharged Battery * No Start * Battery Indicator illuminated in Instrument Cluster * "Low Voltage" DTCs in various control modules * Engine noise * Accessory Drive Belt damaged or missing If a generator is replaced, there must be a confirmed failed GFF Test Plan available, or in the event of a mechanical failure of the component, complete and detailed documentation of the reason for the replacement, which must be submitted into the warranty claim comments.
2014 Volkswagen Beetle Convertible Maintenance Schedule For USA 2.0TSI Engine: This document contains the maintenance...
Read full bulletin
service schedule for a vehicle from 10,000 miles to 120,000 miles.
2014 Volkswagen Beetle Convertible Maintenance Schedule For USA 2.0L TDI Engine: This document contains the...
Read full bulletin
maintenance service schedule for a vehicle from 10,000 miles to 130,000 miles.
Technical Bulletin (Oil Consumption Measurement): Customer states oil consumption is higher than the Volkswagen oil...
Read full bulletin
consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. In order to provide effective lubrication and cooling of internal engine components, all internal combustion engines consume a certain amount of engine oil. Oil consumption varies from engine to engine and may change significantly over the life of the engine. Typically, engines with specified break-in periods consume more oil during the break-in period, and the oil consumption will stabilize after the break-in period. This document informs of oil consumption tests to check a vehicles performance.
Technical Bulletin Activated Charcoal Filter System, Solenoid Valve 1 -N80- (Canister Purge Valve) Diagnosis): ...
Read full bulletin
Completing the GFF function test and performing a vacuum check on the Canister Purge Valve -N80- are essential to diagnose proper operation and to avoid unnecessary replacements. This document informs how to perform the Diagnosis check
2.0L TDI Engine (GEN 1) Emissions Modification - Customer Only (Retail Sold) USA ONLY - The Environmental Protection...
Read full bulletin
Agency and California Air Resources Board have determined that Volkswagen vehicles equipped with a 2.0L 4-cylinder TDI engine do not comply with applicable emissions regulations. The emissions control systems on the vehicles will not control emissions under off-cycle conditions as effectively as during the federal test procedure. The extent of the emissions increase under off-cycle conditions depends upon how the vehicles are driven.
2.0L TDI Engine (GEN 1) Emissions Modification - Customer Only (Retail Sold) USA ONLY - The Environmental Protection...
Read full bulletin
Agency and California Air Resources Board have determined that Volkswagen vehicles equipped with a 2.0L 4-cylinder TDI engine do not comply with applicable emissions regulations. The emissions control systems on the vehicles will not control emissions under off-cycle conditions as effectively as during the federal test procedure. The extent of the emissions increase under off-cycle conditions depends upon how the vehicles are driven. - Revision Summary Updated LOANER claiming instructions.
2.0L TDI Engine (GEN 1) Emissions Modification - Customer Only (Retail Sold) USA ONLY - The Environmental Protection...
Read full bulletin
Agency and California Air Resources Board have determined that Volkswagen vehicles equipped with a 2.0L 4-cylinder TDI engine do not comply with applicable emissions regulations. The emissions control systems on the vehicles will not control emissions under off-cycle conditions as effectively as during the federal test procedure. The extent of the emissions increase under off-cycle conditions depends upon how the vehicles are driven. - Updated Saga claiming instructions for glow plug control module.
2.0L TDI Engine (GEN 1) Emissions Modification - Customer Only (Retail Sold) USA ONLY - The Environmental Protection...
Read full bulletin
Agency and California Air Resources Board have determined that Volkswagen vehicles equipped with a 2.0L 4-cylinder TDI engine do not comply with applicable emissions regulations. The emissions control systems on the vehicles will not control emissions under off-cycle conditions as effectively as during the federal test procedure. The extent of the emissions increase under off-cycle conditions depends upon how the vehicles are driven. Updated loaner/rental and label placement instructions.
Tech Tips (TDI Engine - N75 Solenoid Valve Diagnosis): This document informs with graphical aid the testing of the N75...
Read full bulletin
Solenoid Valve in the event of a turbocharger fault code such as P0299 or P0234. This applies to Mechanical Injection Style Diesel Engines, Pumpe Duse Style Diesel Engines and the new Common Rail Style Diesel Engines.
Technical Bulletin (Oil Consumption Measurement): Customer states oil consumption is higher than the Volkswagen oil...
Read full bulletin
consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. In order to provide effective lubrication and cooling of internal engine components, all internal combustion engines consume a certain amount of engine oil. Oil consumption varies from engine to engine and may change significantly over the life of the engine. Typically, engines with specified break-in periods consume more oil during the break-in period, and the oil consumption will stabilize after the break-in period. Refer to the Owners Manual for specific break-in procedures. Under normal conditions, the rate of oil consumption depends on the quality and viscosity of the oil, the RPM at which the engine is operated, the ambient temperature and road conditions. Further factors include the amount of oil dilution from water condensation or fuel residue and the oxidation level of the oil. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also available.
Technical Bulletin (Frozen Charge Air Cooler ? Engine Will Not Start): Engine will not start after standing in cold...
Read full bulletin
weather below 0C (32F), MIL may be illuminated with various induction and/or boost system faults stored in ECM. Moisture from the intake air condenses and collects in the charge air cooler. At cold temperatures this moisture can freeze causing blockage of the intake air system. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also available.
Technical Bulletin (TDI Common Rail High Pitch Whine Noise after Switching Ignition OFF): With the implementation of...
Read full bulletin
the new ?Clean Diesel Technology?, changes to the EGR system were implemented as compared to previous Diesel engines. After switching ignition OFF, the EGR system must go through an adaption of the valves to maintain calibration. These noises are considered normal and no repairs are necessary.
Technical Bulletin (HVAC, Unpleasant Odor): Condensation, which is a normal condition in all A/C systems, can cause a musty odor.
Read full bulletin
If the odor is noticeable in the vehicle when the engine is not turned on, the cause may be mold and mildew in the passenger compartment, and not be related to the A/C system. All other possible sources of the odor must be investigated before this document can be performed. This document contains the procedure for the VW method to remove musty odors
VOLKSWAGEN DEALERSHIP COMMUNICATION: This update has been proactively released to prevent the air conditioning from...
Read full bulletin
blowing warm while operating the engine within a certain constant RPM range. The corrective action taken for this issue was to Install updated climatic software.
UPDATE Technical Bulletin (Climatic Software issues): This update has been proactively released to prevent the air...
Read full bulletin
conditioning from blowing warm while operating the engine within a certain constant RPM range. SW version 0205 in the climatic controller may not recognize constant RPM and will report compressor shut off code 5 in MVB. The product solution for this issue was the introduction of new software
UPDATE Technical Bulletin (Climatic Software): This update has been proactively released to prevent the air...
Read full bulletin
conditioning from blowing warm while operating the engine within a certain constant RPM range. This UPDATE ensures the proper performance of the Air Conditioning (A/C) Control Head.
Technical Bulletin The use of contaminated gasoline, seasonal fuel changes (summer/winter fuel) or gasoline with a low...
Read full bulletin
content of deposit control additives may result in one or more of the following conditions: -Excessive accumulation of deposits on intake valves, intake manifold, fuel injectors and combustion chambers. -Engine runs rough after cold start. -Excessive engine cranking time. -Stumbles while driving. -Rough engine idle. -Loss of engine performance. -Poor fuel economy. This document informs of the procedure for the vehicle if it is diagnoised with poor quality gas
Technical Bulletin (Proper Removal of Engine Cover to Avoid Breakage): Pulling on the engine cover in some areas can cause damage.
Read full bulletin
This document informs on the procedure to remove the engine cover.
Technical Bulletin (No Start, or Rough Running issues): When diagnosing a MIL ON, no-start or rough running concern on...
Read full bulletin
a common rail diesel vehicle, and no root cause is found after following all GFF diagnostic procedures, it may be necessary to check for metallic particles in the High Pressure Fuel Pump. If such an inspection is necessary, the guidelines in this document must be observed when removing the N290 Fuel Metering Valve
Technical Bulletin (No Start, or Rough Running due to Fuel Rail issues): When diagnosing the condition above on a...
Read full bulletin
common rail diesel vehicle, if no root cause is found after checking all other components and all GFF diagnostic procedures have been performed, it may be necessary to check for metallic particles in the High Pressure Fuel Pump using the service section of this document. If such an inspection is necessary, the following guidelines must be observed when removing the N290 Fuel Metering Valve.
UPDATE Technical Bulletin: On certain Beetle and Beetle Convertible vehicles within a limited production period, the...
Read full bulletin
incorrect window regulator motors were fitted in the front doors. This can lead to malfunctions in the front window lifter operation. The production solution was to Correct window regulator motors installed in production
Technical Bulletin (Current ECM software causing erroneous faults): This document informs of new programming for...
Read full bulletin
updating the diagnostic hardware The document also informs how to Update the Engine Control Module using the SVM Unit code
Technical Bulletin (Update Programming ECM to Correct Engine Load Calculations): Current ECM programing does not...
Read full bulletin
efficiently control engine valve timing causing stumbling and rough idle. The document discusses the procedures for updating the programming. It discusses the codes necessary to service the vehicle, and inquire if the service is under warranty
Tech Tips: The document discusses the conditions of when turbo can to be fixed or replaced
Tech Tips (Coolant Leak or Repeat Coolant Leak from the Water Pump Area): The document informs to inspect for issues, and why issues may happen.
Read full bulletin
It also notes how to fix the issue, and other issues that could happen while repairing the issue
Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt...
Read full bulletin
meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engine running and heated rear window switched on. Switch OFF the ignition and visually locate the damage.
Technical Bulletin: This document refers to direction on DTC P2014 Intake Manifold Position Sensor -G336- Replacement,...
Read full bulletin
and its fault codes.
Technical Bulletin (Fuel Additive to Help Prevent Sporadic Misfire Faults): Fuel quality impacts the operating...
Read full bulletin
performance, efficiency and service life of the engine. The use of poor quality fuels may result in deposit build up on the fuel injectors and intake valves. This may result in a rough running condition, sporadic misfires, or cold start misfire faults storing in the ECM fault memory. This document informs a Volkswagen approved fuel additive is available to help remove and prevent deposits on fuel injectors and intake valves.
Technical Bulletin (Manifold Absolute Pressure Range / Performance issues): This document informs that the monitoring...
Read full bulletin
strategy for the manifold absolute pressure sensor being too sensitive, causing P0106 to incorrectly set in the engine control module. The product solution for this issue was improved software.
2014 Volkswagen Beetle/Beetle Convertible Quick Reference Specification Book: This document is an overview which...
Read full bulletin
covers multiple -Engine Code -Fuel and Air Mixture -Ignition System -Additional Exhaust Regulation -Speed and Idle Control -Control Module and Output Signals -Fuel and Air Ratios Control Module -Additional Emissions Regulations
Technical Bulletin (Fuel Additive to Help Prevent Sporadic Misfire Faults): Fuel quality impacts the operating...
Read full bulletin
performance, efficiency and service life of the engine. The use of poor quality fuels may result in deposit build up on the fuel injectors and intake valves. This may result in a rough running condition, sporadic misfires, or cold start misfire faults storing in the ECM fault memory. A Volkswagen approved fuel additive is available to help remove and prevent deposits on fuel injectors and intake valves. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also available.
Technical Bulletin (Engine, Misfire Diagnostic Aid): This document informs that Multiple components SHOULD NOT be replaced for 1 misfiring cylinder.
Read full bulletin
Repeat repairs must be carefully addressed to identify the root cause of the concern. If misfires are determined to be related to a specific component(s) (fuel injector, spark plug, ignition coil), replace only one defective component at a time and re-evaluate the concern
Technical Bulletin (Cylinder Contribution/Balance Faults): This document informs that the diagnostic strategy for...
Read full bulletin
zero fuel calibration too sensitive. The production solution for this issue was new Software implemented. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also available.
Technical Bulletin (Camshaft Adjustment Valve 1 -N205- Diagnosis): Completing the GFF function test and performing...
Read full bulletin
basic settings on the camshaft adjustment valve are essential to diagnose proper operation and to avoid unnecessary replacements. The production solution to this issue was to optimized engine cleaning procedure in production.
Technical Bulletin (Electric Coolant Fans Continue to Run after Ignition is Switched OFF): This documentation informs...
Read full bulletin
it is considered normal operation for the electric coolant fans to continue to run for up to 15 minutes after the ignition is switched off in gasoline engine applications, and up to 16 minutes in diesel engine applications. The production solution to service this issue is that no production change is required.
Tech Tips (2.0L CCTA/CBFA Coolant Leak or Repeat Coolant Leak from the Water Pump Area): Inspect the water pump for...
Read full bulletin
signs of contact with engine oil. Engine oil may cause the water pump gasket to swell, which may lead to a coolant leak. This document informs of the precaustions necessary if a water pump replacement is necessary.
Technical Bulletin (DTC P2014 Intake Manifold Position Sensor -G336- Replacement): Direction on proper part replacement...
Read full bulletin
when diagnosing fault code P2014 in the ECM
Technical Bulletin (Frozen Charge Air Cooler ? Engine Will Not Start): Document discusses diagnosis Codes necessary to...
Read full bulletin
diagnosis, and potential remedy of engine issue. The diagnosis codes for checking warranty coverage for servicing the vehicle are also available
Fuel Additive to Help Prevent Sporadic Misfire Faults A Volkswagen approved fuel additive is available to help remove...
Read full bulletin
and prevent deposits on fuel injectors and intake valves.
Document discusses possible needs for Generator Replacement, Charging System inoperative/malfunctions, noise from engine...
Read full bulletin
compartment, accessory drive belt damaged or missing. Document also discusses where to find warranty information for coverage.
Technical Bulletin about a customer concern stating that customer observed one or more of the shocks/struts appearing to have an oil leak.
Read full bulletin
Document contains examples of Strut or Shock Absorber Leak Assessments
Technical Bulletin (Engine Oils Which Meet Volkswagen Oil Quality Standard): This document informs of a sample list...
Read full bulletin
of products generally available in the North American market that meet the Volkswagen Oil Quality Standard
Other
213 bulletinsGFF Requirements regardless of concern plus System flush requirement
G12Evo can now be mixed with previous coolants.
This special notice is to inform dealers to return the parts listed if it meets the criteria provided.
Additional reporting
Fluid requirements
Model Year 2014 Prepaid PDI Time Units
Damage to Data Link Connector (DLC) from Aftermarket Devices (Cannot Communicate with Vehicle OBD System)
Vehicles equipped with Immobilizer 4 (Download) ? Adapting Keys after Vehicle Lock Set Replacement
New Loaner Policy for VW Customer Mobility Vehicles
Volkswagen Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
Safety Related Inquiry and Reporting
Elsa newsletter
FLUID CAPACITY CHART
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
VW Elsa Newsletter
2014 Volkswagen Beetle/Beetle Convertible Quick Reference Specification Book
2014 Volkswagen Beetle/Beetle Convertible Quick Reference Specification Book
By-Pack At Delivery
Prepaid PDI Time Units (U.S.
Read full bulletin
Only)
By-Pack At Delivery
By-Pack At Delivery
Squeaks, Rattles, Noise, Repair Materials
Helpline & Parts Dept.
Read full bulletin
contact information.
Volkswagen Perfect Delivery Process ? Sales Consultant Delivery Checklist
Volkswagen Perfect Delivery Process ? Sales Consultant Delivery Checklist
Please contact VW Helpline before attempting repair
Please contact VW Helpline before attempting repair
Please contact VW Helpline before attempting repair
Please contact VW Helpline before attempting repair
Please contact VW Helpline before attempting repair
Please contact VW Helpline before attempting repair
please contact VW Helpline before attempting repair
Customer Letter
Generator Replacement
Diagnostic assistance for excessive static current draw
Erratic Oil Temperature Gauge
Damage on External Chrome or Aluminum Surfaces
Parts Returned to the WPRC Must be Complete and Packaged Correctly to Prevent Transit Damage
2014 Volkswagen Beetle/Beetle Convertible Quick Reference Specification Book
When diagnosing fault code P2279-Leaking Air in Intake System, be sure to check the cam timing first.
2014 MODEL YEAR VOLKSWAGEN VEHICLE COVERAGE SUMMARY
Listed in the table below are the time units used in the calculation of the Prepaid PDI (PPDI) payment for model year...
Read full bulletin
2014 vehicles
CV boot damage identified.
Monroney Label Placement
ElsaWeb Newsletter
Elsa Newsletter
Elsa Newsletter
On-car analysis list please contact VW Helpline before attempting repair
On-car analysis list please contact VW Helpline before attempting repair
On-car analysis list.
On-car analysis list.
On-car analysis list.
On-car analysis list.
On-car analysis list.
On-car analysis list.
Generator replacement.
Contacting the parts helpline
Generator Replacement
This Document informs dealers on VWP-23-01
Evaluate TDI vehicle for repurchase prior to repairs
Mandatory Installation from Web-Server.
Part ordering
This Document informs dealers on VWP-22-03
Customer Notification 3G-Sunset
VW Car-Net - Letter MY 2014-2016
This Document was revised to include 2022 Model Year information
Diagnostic assistance when vehicle readiness will not set.
Additional safety related Inquiry and Reporting instruction.
Parts ordering information
This special notice is to inform dealers to return the parts listed if it meets the criteria provided.
This Document was revised to include 2021 Model Year
Data link diagnostics and tips
This special notice is to inform dealers to return the part numbers listed (State of California only).
Mandatory fastener.
Electronic Stabilization Program (ESP) function test may not end on its own causing DTC.
New machine version added to table.
Tool number added to table.
Read full bulletin
Removal of Behr Flush Kit. VAS 6337/1A
Volkswagen After Sales Weekly Communication - March 10, 2020
ERP fault information.
Micro switch customer call list.
Car Net Direction summary
Include new special tool adapter and 2018 model year Jetta only
Added: Torque Spec table
Include additional photo's of water ingress.
Read full bulletin
Also includes 2018-2020 Tiguan LWB
TT 001202........Also includes 2005 Jetta wagon and 2018-2020 Tiguan LWB
The part number listed in the document is to be returned if it meets the criteria provided.
Additional Safety Inquiry and Reporting instruction.
Additional Safety Inquiry and Reporting instruction.
Email Important TDI Announcement Duplicate Photos in IN-FORM
Additional Safety Inquiry and Reporting instruction.
Email Important TDI Announcement Duplicate Photos in IN-FORM
Additional Safety Inquiry and Reporting instruction.
Volkswagen Perfect Delivery Process ? Sales Consultant Delivery Checklist: This document informs the seller of a...
Read full bulletin
vehicle with a checklist to cover the experience of a customer who is interested in purchasing a vehicle"
UDS Basic settings directions
The part number listed in the document is to be returned if it meets the criteria provided.
Volkswagen Perfect Delivery Process ? Sales Consultant Delivery Checklist: This document informs the seller of a...
Read full bulletin
vehicle with a checklist to cover the experience of a customer who is interested in purchasing a vehicle"
Iinclude additional model year applicability and tool information.
Tip demonstrating label information for clarity
The 2.0L Gen1 FAQ document is to assisty our VWGoA dealers with frequently asked questions and answers to allow them to...
Read full bulletin
assist the VW & Audi owners.
Tech Tips (Remote Functions Inoperative and/or Faults 00955, 00956, 02660): If the remote key fob is depressed...
Read full bulletin
repeatedly or a button is held down while outside the remote operating range, the key remote functions may no longer operate. This document informs Before running GFF or attempting any adaptation with the scan tool, attempt to restore remote functionality by following the key synchronization procedure in this document.
Adhesive application for installation on all areo parts solds as an accessory
VAS 6154 Replacement Part Setup Guide
Iinclude additional model year applicability and tool information.
Tip demonstrating label information for clarity
The 2.0L Gen1 FAQ document is to assist our VWGoA dealers with frequently asked questions and answers to allow them to...
Read full bulletin
assist the VW & Audi owners.
Tip to assist in setting readiness.
Tech Tips (Remote Functions Inoperative and/or Faults 00955, 00956, 02660): If the remote key fob is depressed...
Read full bulletin
repeatedly or a button is held down while outside the remote operating range, the key remote functions may no longer operate. This document informs Before running GFF or attempting any adaptation with the scan tool, attempt to restore remote functionality by following the key synchronization procedure in this document.
Adhesive application for installation on all areo parts solds as an accessory
This special notice is to inform dealers to return all part numbers listed in the document and order the superseded part...
Read full bulletin
numbers going forward.
This Document informs dealers that 2.0L TDI Gen 1, Gen 2 and Gen 3 Customer Vehicles are no longer eligible for the...
Read full bulletin
Pre-existing MIL-On Condition.
This Document informs is the dealer FAQ associated with VWP-18-07
Balance shaft direction for debris issues.
2.0L TDI Settlement Deadline 12/30/2018 - Important Reminders
On-car analysis list of Customer Complaints: Mil?on with fault code P046C, untouched vehicles
On-car analysis list of Customer Complaints: Mil?on with fault code P046C, untouched vehicles
On-car analysis list of Customer Complaint: Mil?on with fault code P046C, untouched vehicles
On-car analysis list of Customer Complaint: Mil?on with fault code P046C, untouched vehicles
On-car analysis list of Customer Complaint: Mil?on with fault code P046C, untouched vehicles
On-car analysis list of Customer Complaints: Mil?on with fault code P046C, untouched vehicles
DTC Status Bit Definitions.
Email_Important TDI Announcement - Final Months of 2.0L Claims Program_VW
This Document informs dealers on the Revised VWP-18-07.
Read full bulletin
New info on coverage for consequential damages
Alternate diagnostic process for overheating.
To include an additional model year applicability.
On-car analysis list of Customer Complaint: Mil-on with fault code P046C, untouched vehicles
This special notice is to inform dealers to return all part numbers listed in the document.
Read full bulletin
Only superseded part numbers to be ordered going forward.
On-car analysis list Customer Complaint: Mil?on with fault code P046C, untouched vehicles
On-car analysis list of Customer Complaints: Mil?on with fault code P046C, untouched vehicles
On-car analysis list of Customer Complaints: Mil?on with fault code P046C, untouched vehicles
On-car analysis list of Customer Complaints: Mil?on with fault code P046C, untouched vehicles
On-car analysis list of Customer Complaint: Mil?on with fault code P046C, untouched vehicles
On-car analysis list of Customer Complaints: Mil-on with fault code P046C, untouched vehicles
On-car analysis list of Customer Complaint: Mil?on with fault code P046C, untouched vehicles
On-car analysis list of Customer Complaints: Mil?on with fault code P046C, untouched vehicles
On-car analysis list for Customer Complaint: Mil?on with fault code P046C, untouched vehicles
On-car analysis list of Customer Complaints: Mil?on with fault code P046C, untouched vehicles
On-car analysis list of customer compliants: Mil?on with fault code P046C, untouched vehicles
On-car analysis list of Customer Complaint: Mil?on with fault code P046C, untouched vehicles
On-car analysis list of Customer Complaints: Mil?on with fault code P046C, untouched vehicles
Tip for Scan tool concerns that may occur duing a test plan
On-car analysis list of customer compliants Customer Complaint: Mil?on no electric drive mode, untouched vehicles
Reminder for dealers to reference the repair manual and replace all necessary fasteners (bolts, nuts) that cannot be...
Read full bulletin
re-used
additional symptom gathering information and guidence to isolate customer concern before beginning repair.
Technical Bulletin (Prepaid PDI Time Units): Listed in the table within this document are the time units used in the...
Read full bulletin
calculation of the Prepaid PDI (PPDI) payment through model year 2015
Beetle Convertible - 2014 FLUID CAPACITY CHART This document contains information on what fluids, and how much for each...
Read full bulletin
of them are necessary to have a car up and running
Technical Bulletin (CV Boot Replacement): Recommended procedure for removing damaged CV boot.
Read full bulletin
This document informs of the expected condition of a CV boot upon removal
Technical Bulletin: Listed in the table in this document are the time units used in the calculation of the Prepaid PDI...
Read full bulletin
(PPDI) payment through model year 2016.
Technical Bulletin (CV Boot Replacement): The Recommended procedure for removing damaged CV boot.
Tech Tips: Vehicle Health Report Received by Customer Indicating a Concern, but Cannot Verify any Conditions or DTC?s...
Read full bulletin
to Facilitate Diagnosis
Tech Tips: Car Net Equipped Vehicles-Vehicle Health Report Received by Customer Indicating a Concern, but Cannot Verify...
Read full bulletin
any Conditions or DTC?s to Facilitate Diagnosis
On-car analysis list of Customer Complaints: Mil?on with fault code P046C, untouched vehicles
On-car analysis list of Customer Complaints: Mil?on with fault code P046C, untouched vehicles
This document includes what incentives are included in the Volkswagen TDI Customer Goodwill Package.
On-car analysis list of Customer Complaints: Mil-on with fault code P046C, untouched vehicles
On-car analysis list of Customer Complaints: Mil-on with fault code P046C, untouched vehicles
Technical Bulletin: Diagnosing with Damage on External Chrome or Aluminum Surfaces
Tech Tips: Vehicles with Immobilizer with Download/Discharge? New Key Will Not Program
Tech Tips Damage to Data Link Connector (DLC) from Aftermarket Devices (Cannot Communicate with Vehicle OBD System)
TDI IN-FORM Rewards Announcement
Software & Calibration
111 bulletinsHow to manage software versions using VW diagnostic Tool
3G Sunset Update
ODIS Service Update
Climatic Software (NVLW)
Climatic Software (NVLW)
Software Version Management
Software Version Management (SVM) instruction.
ODIS Service application update V2.2.0
Update model year applicability to include 2023.
ACC Calibration Process
update to required vehicle wash shampoo.
Update warranty table labor operation numbers due to recent Saga updates.
Update warranty table labor operation numbers due to recent Saga updates.
Update Technical Bulletein.
Cleaning of Heating and Ventilation system, Updated to include additional model year applicability and cost of cleaning...
Read full bulletin
solution in warranty table.
Update model and model year applicability, introduce new coolant G12Evo.
3G Sunset Update - E-mail
3G Sunset Update
This bulletin contains general instructions for software updates.
Update to model year applicability.
Update to model year applicability.
KESSY equipped Key Adaptation, updated to add model year applicability.
Software Version Management (SVM)
Update to brochure purchase url
Update to top tier brochure purchasing url.
Software Version Management (SVM) instruction updated to include model year 2021
Updated to include an additional model year applicability.
Updated key ordering protocol
Update to part quantity in Part Table.
Updated to include additional models and model year applicability.
Updated to include additional models and model year applicability.
Updated to remove duplicate bolt part number in Passat part table.
Update Top Tier brochure part number.
Update brochure part number and recording URL.
Read full bulletin
Update model and model year applicability.
Metadata update (add MY 2014 Eos (missing).
Updated to include model year 2021
Update to include 2020-2021 model and model year applicability.
Updated to include additional models and model year applicability.
Generator replacement, updated to include model years 2020 & 2021
Additional Guided Functions programming assistance.
Read full bulletin
Updated to include additional model year applicability.
Update to Volkswagen Identifying and mixing of coolant.
Read full bulletin
Introducing new coolant type.
Update to Volkswagen Identifying and mixing of coolant.
Read full bulletin
Introducing new coolant type.
Update model applicability to MY 2020.
Information regarding updated cam bracket fastener length.
Update to mode; and model year applicability.
Update to mode; and model year applicability.
Update to mode; and model year applicability.
Update to CD part number and also where to obtain additional copies.
Updated to include additional model and model year applicability.
Quick Reference Update Guide.
Update vehicle metadata to include pull ahead models.
Read full bulletin
Also includes R32 2002-2007 and 2002-2006 Jetta Wagon.
Update vehicle metadata.
Update to TB to include model year 2018 & 2019 applicability.
Update vehicle metadata.
Update to TB to include model year 2018 & 2019 applicability.
Updated to include additional labor operations due to labor time updates in Elsa.
Instrument cluster production mode solution, updated to include additional model and model year applicability.
Update brochure part number, literature ordering websie address and include an additional model year applicability
Updated to include model year 2014 thru 2018 applicability.
Updated to address additional model years.
Read full bulletin
Tip to reinforce dealer scan tool update importance in regards to 23Q3/24CV/23U3 campaign
Warranty Information (Volkswagen DoubleCheck Labor Operations): Volkswagen DoubleCheck Labor Operations for All VW...
Read full bulletin
Models Except Routan ElsaWeb/Pro was updated on August 12, 2013 with the following Volkswagen DoubleCheck labor operations for all Volkswagen models except Routan. This document informs where in ElsaWeb/Pro this information can be located.
Update to existing tip for addressing Kessy vehicles in the AEM flash
Instrument cluster production mode solution, updated to include additional model and model year applicability.
Update brochure part number, literature ordering websie address and include an additional model year applicability
Updated to include model year 2014 thru 2018 applicability.
Updated to address additional model years.
Read full bulletin
Tip to reinforce dealer scan tool update importance in regards to 23Q3/24CV/23U3 campaign
Warranty Information (Volkswagen DoubleCheck Labor Operations): Volkswagen DoubleCheck Labor Operations for All VW...
Read full bulletin
Models Except Routan ElsaWeb/Pro was updated on August 12, 2013 with the following Volkswagen DoubleCheck labor operations for all Volkswagen models except Routan. This document informs where in ElsaWeb/Pro this information can be located.
Instrument cluster production mode solution, updated to include additional model and model year applicability.
Remote lock function.
Read full bulletin
Update to model year applicability.
Update parts table.
Information for additional diagnosis should the Driver Assistance Systems Front Camera not calibrate, complete...
Read full bulletin
calibration or set a limit exceeded fault.
Update to include additional model and model year applicability.
Updated existing tip to include latest model years for explanation of P130A
Updated to include additional model and model year applicability.
Addressing concerns after campaign 24DR software update
Update content and include additional models and model year applicability.
Updated to include additional models and model year applicability.
Updated to include additional models and model year applicability.
Modify service instruction and to update GFF Time expenditure in the warranty table.
Updated work procedure, 2010 Model Year pre-repair aftertreatment system inspection.
Updated to include additional model year applicability.
This communication is to update our ProFi dealers of the current status of the latest inbound and outbound ProFi...
Read full bulletin
requests.
Updated vendor code and parts table.
Data Link connector pin assignment chart that is applicable to all models.
Read full bulletin
Update model year applicability.
Updated to include additional model year and required documentation instruction.
Update tech tip to include missing Figure 6 and final repair instruction.
Informing of a update of codes for the Inventory Vehicle Open Campaign/Action Report
Update to include model year 2017 applicability.
Updated to include additional model year applicability.
Update to include additional model year applicability.
Update model year applicability.
Updated to include an additional model year applicability.
Updated to include model year 2017 applicability
Update model year applicability.
Updated to include additional model year applicability.
Update to model year applicability.
Updated to include additional model year applicability.
Update model year applicability to include 2017.
Update model and model year applicability.
e-mail TDI ODIS AEM Update.
Technical Bulletin (Car-Net Operating Control Unit (OCU/J949) Service Guidelines & General Information): This document...
Read full bulletin
informs of installation methods to prevent corruption of software while diagnosing vehicle parts, and servicing vehicles
Tip to reinforce dealer scan tool update importance in regards to 24CV campaign.
Updated to include an additional diagnostic trouble code (P04F0)
Update Touareg Part Table.
Technical Bulletin This Technical Bulletin details the general process for carrying out a Software Version Management...
Read full bulletin
(SVM) software update for any Technical Bulletin (TSB) / Required Vehicle Update (RVU).
Updated vendor code and parts table.
Updated to include additional model year and required documentation instruction.
Update Jetta vendor code in the warranty table.
Updated to require additional print outs during warranty claiming.
01 16 01 January 8, 2016 2034898 Supersedes Technical Bulletin V011526 dated November 5, 2015 to update warranty labor...
Read full bulletin
operations due to ELSA updates.
Update parts table.
Electrical
102 bulletinsThis is a notice for software changes with the ODIS diagnostic program to correct the communication during vehicle...
Read full bulletin
programming function: A software fix is needed to correct a test that is not reading any information from the battery data module (BDM) and will output:
Multiple Update closures: 20AH Atlas Quality Package 1, 24AE 1.8T ECM/TCM SW, 24BG Jetta Hybrid ECM SW, 24BM 2.0L Jetta...
Read full bulletin
MPI SW Update, 24X7 Jetta ECM SW, 24X8 CC ECM/TCM SW, 24Y4 MPI Jetta SW, 24Z5 Jetta Hybrid System SW, 27G2 Battery, 37H3 DSG SW, 37J2 TCM SW, 69V7 Atlas Quality Package 3, 87F6 Atlas Quality Package 2, 91P3 Adaptive Cruise Calibration
Battery testing
Keyless Entry Inoperative after Access / Start (KESSY) Module Replacement
Washer Level Sensor
Washer Level Sensor
Washer Level Sensor
AC Compressor Replacement, Refrigerant Circuit Flushing Requirement
Addressing Cybersecurity or Vehicle Hack concerns
Battery Testing and Charging Using Midtronics VAS6161 and or GRX3000VAS Charger.
Read full bulletin
Update Tool terminology
Electric Coolant Fans Continue to Run after Ignition is Switched OFF
Electric Coolant Fans Continue to Run after Ignition is OFF
MIL ON, DTC P0401 Exhaust Gas Recirculation Flow Insufficient Stored in ECM Fault Memory, Could be accompanied with...
Read full bulletin
Fault P2463 DPF Soot Accumulation
MIL ON, DTC P0401 Exhaust Gas Recirculation Flow Insufficient Stored in ECM Fault Memory, Could be accompanied with...
Read full bulletin
Fault P2463 DPF Soot Accumulation
MIL ON, DTC P0401 Exhaust Gas Recirculation Flow Insufficient Stored in ECM Fault Memory, Could be Accompanied with...
Read full bulletin
Fault P2463 DPF Soot Accumulation
MIL ON, DTC P0401 Exhaust Gas Recirculation Flow Insufficient Stored in ECM Fault Memory, Could be Accompanied with...
Read full bulletin
Fault P2463 DPF Soot Accumulation
MIL ON - Glow Plug Pressure Sensor Faults Stored in ECM Fault Memory
MIL ON - Glow Plug Pressure Sensor Faults Stored in ECM Fault Memory
Battery, Testing and Charging Using Midtronics VAS6161, MCR340V, InCharge 940, or GRX3000 Charger
TDI Common Rail High Pitch Whine Noise after Switching Ignition OFF
MIL ON, No Start, or Rough Running with DTCs P0087, P0088 or P0191 Stored in ECM Fault Memory (TDI ONLY)
MIL ON, No Start, or Rough Running with DTCs P0087, P0088 or P0191 Stored in ECM Fault Memory (TDI ONLY)
Battery Testing and Charging using Midtronics VAS6161 and or GRX3000 Vas Charger
Keyless Entry Inoperative after Access / Start (KESSY) Module Replacement
Washer Level Sensor
Air Conditioning, Cleaning of the Refrigerant Circuit (U.S.Only)
If the remote key fob is depressed repeatedly or a button is held down while outside the remote operating range, the key...
Read full bulletin
remote functions may no longer operate. Fault codes 00955 005 ?Key 1 no or incorrect basic settings?, 00956 005 ?Key 2 no or incorrect basic settings?, or 02660 ?Radio Remote control operation not adapted? may be set in the Vehicle Electrical System Control Module -J519- if GFF is run.
The location of the G85 steering angle sensor in these vehicles depends upon the steering system.
To clear static ECM fault P1250 ?Fuel Level Too Low?, add fuel to vehicle and complete a road test of at least 10 miles.
Read full bulletin
Simply adding fuel without completing a road test may not allow fault to clear.
Battery Testing and Charging using Midtronics VAS6161 and or GRX3000 Vas Charger
The indicator lamp in the I.P.
Read full bulletin
for washer fluid remains illuminated and the washer reservoir is full. Validate the washer reservoir is full with the proper washer solvent (G-052-164). Refer to Elsa for proper fluid type and fluid quantities under repair manual, maintenance, fluid capacity table. If the fluid is not blue in color, drain the fluid, remove the sensor and clean with cleaner (D-009-401-04) or equivalent. Reinstall the sensor, top off washer reservoir with proper fluid and validate that the indicator lamp in the I.P. is no longer illuminated.
The indicator lamp in the I.P.
Read full bulletin
for washer fluid remains illuminated and the washer reservoir is full. Validate the washer reservoir is full with the proper washer solvent (G-052-164). Refer to Elsa for proper fluid type and fluid quantities under repair manual, maintenance, fluid capacity table. If the fluid is not blue in color, drain the fluid, remove the sensor and clean with cleaner (D-009-401-04) or equivalent. Reinstall the sensor, top off washer reservoir with proper fluid and validate that the indicator lamp in the I.P. is no longer illuminated.
Electric coolant fans continue to run after ignition is switched off.
Emissions service action 24DR/ECM Software.
Battery testing and charging using special tools VAS6161 & GRX3000VAS Charger.
Read full bulletin
Updated to include additional model year applicability.
Minimum battery charger requirements during software updates
Battery Testing and Charging using VAS6161 and or GRX3000VAS
Software Version Management (SVM) instruction.
Read full bulletin
Update to require 70amp minimum battery charger during procedure.
Battery Testing and Charging using recommended VW test equipment.
Battery Tester VAS 6161 introduction.
Discharged Battery, Diagnosis for excessive current draw.
Battery testing using VW special tools, updated to include additional model year applicability and include I.D.4.
Explanation of error message received from scan tool when erasing diagnostic trouble codes (DTCs) in Control Module...
Read full bulletin
-623- after repair.
Customer states MIL-on with P013E in the ECM Customer states MIL-on with P0087 P0149 P053F in the ECM Hood release...
Read full bulletin
inoperative Customer states MIL-on with P0401
Customer states MIL-on with P013E in the ECM Customer states MIL-on with P0087 P0149 P053F in the ECM Customer states...
Read full bulletin
MIL-on with P0461 in the ECM Customer states front suspension noise while driving Customer states the rear view mirror is loose Hood release inoperative Customer states MIL-on with P0401
Key battery diagnosis, updated to include additional model year applicability.
Battery testing. Updated to include additional model and model year applicability.
Directions to assist in performing basic settings for the ac control module
Voltage Drop Testing.
Read full bulletin
Updated for picture clarity.
Voltage Drop Testing.
REMOVED all 12 hour wait period before starting references.
Read full bulletin
ADDED EFB to "Select correct battery type" in bottom box. Also Jetta Wagon 2005 and 2018-2020 Tiguan LWB.
Vehicle Fuse location assistance.
Remote Key Battery Replacement
Directions to assist in performing basic settings for the ac control module
Remote Key Battery Replacement.
Coding concerns after module replacement
Coding concerns after module replacement
Battery Testing and Charging instruction.
Read full bulletin
Updated to include model year 2019 applicability.
Instructions to address oil sensor warning.
Technical Bulletin (Exhaust Gas Recirculation Flow Insufficient Stored in ECM Fault Memory, Could be Accompanied with...
Read full bulletin
Fault P2463 DPF Soot Accumulation): High soot loads prior to regeneration can cause possible restrictions in the EGR filter. This production solution to this issue is new software implemented in current production.
Technical Bulletin (Keyless Entry Inoperative after Access / Start (KESSY) Module Replacement): After replacing the...
Read full bulletin
Access/Start (KESSY) module, the keyless entry does not work. The Access/Start (KESSY) module service parts are programmed incorrectly, resulting in a lack of functionality. This document informs of the conditions necessary to allow the software to be reprogrammed
Instructions to address oil sensor warning.
Coding information for replacement ECM to address specific fault setting after the install.
Technical Bulletin (Keyless Entry Inoperative after Access/Start (KESSY) Module Replacement): After replacing the...
Read full bulletin
Access/Start (KESSY) module, the keyless entry does not work. The Access/Start (KESSY) module service parts are programmed incorrectly, resulting in a lack of functionality. This document informs of the conditions necessary to allow the software to be reprogrammed
Technical Bulletin (Exhaust Gas Recirculation Flow Insufficient Stored in ECM Fault Memory, Could be Accompanied with...
Read full bulletin
Fault P2463 DPF Soot Accumulation): High soot loads prior to regeneration can cause possible restrictions in the EGR filter. This production solution to this issue is new software implemented in current production.
Coding information for replacement ECM to address specific fault setting after the install.
Instructions to address oil sensor warning.
Low side fuel pressure sensor explanation.
Comfort/BCM Replacement direction, updated to include additional model year applicability.
Key Battery Diagnostic Process
This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, technical...
Read full bulletin
bulletins, pending service solutions, tech tips, campaigns, updates, and suggestions.
This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, ElsaPro...
Read full bulletin
infomedia icons grayed out, workshop equipment tool storage application, technical bulletins, pending service solutions, tech tips, campaigns, updates, and suggestions.
Inlet Air Box Housing Snow Flap Replacement & Oxygen Sensor Inspection/Replacement.
Read full bulletin
The snow flap in the inlet air box housing may remain partially to fully open. Should this occur, excess warm air could enter the air intake through the snow flap inlet. The oxygen sensor will be checked during this service and, if measured degradation tolerances are met, the sensor will be replaced.
Inlet Air Box Housing Snow Flap Replacement & Oxygen Sensor Inspection/Replacement.
Read full bulletin
The snow flap in the inlet air box housing may remain partially to fully open. Should this occur, excess warm air could enter the air intake through the snow flap inlet. The oxygen sensor will be checked during this service and, if measured degradation tolerances are met, the sensor will be replaced. Updated measuring value range for Heated Oxygen Sensor -G39- replacement in work procedure.
Inlet Air Box Housing Snow Flap Replacement & Oxygen Sensor Inspection/Replacement.
Read full bulletin
The snow flap in the inlet air box housing may remain partially to fully open. Should this occur, excess warm air could enter the air intake through the snow flap inlet. The oxygen sensor will be checked during this service and, if measured degradation tolerances are met, the sensor will be replaced. Updated work procedure and claiming instructions. Included new ODIS test plans, and 2009 MY work and claiming instructions.
Inlet Air Box Housing Snow Flap Replacement & Oxygen Sensor Inspection/Replacement.
Read full bulletin
The snow flap in the inlet air box housing may remain partially to fully open. Should this occur, excess warm air could enter the air intake through the snow flap inlet. The oxygen sensor will be checked during this service and, if measured degradation tolerances are met, the sensor will be replaced.
Directions to assist in performing basic settings for the ac control module and include model year 2017 applicability.
Tech Tips (Comfort Module (J393) or BCM (J519) Replacement): This document informs If a comfort or body control module...
Read full bulletin
is replaced during normal diagnosis, make sure the factory mode has been switched OFF. This can be accomplished by selecting the test plan through GFF or through Vehicle Self Diagnosis in adaptation channel 99. Failure to deactivate factory mode will create a concern where the door locks will not lock and/or unlock with the switch and/or the remotes.
Tech Tips (G85 Steering Angle Sensor Location Tip): If a GFF test plan has indicated that the G85 sensor should be...
Read full bulletin
replaced, it is critical to verify the location of the sensor to ensure the correct part is replaced. This document informs of the locations of the G85 steering angle sensor
Tech Tips (Washer Level Sensor issues): This document discusses approved windshield washer fluids and the damages non - approved fluids can cause.
Read full bulletin
The document also informs on the procedure to Validate the washer reservoir is full with the proper washer solvent
Washer Level Sensor issues: The indicator lamp in the I.P.
Read full bulletin
for washer fluid remains illuminated and the washer reservoir is full. This documet explains thelocation of the procedure to Validate that the washer reservoir is full with the proper washer solvent
Technical Bulletin (Washer Level Sensor): The issue is caused by the outside influence of non-approved formulated washer fluids.
Read full bulletin
Non-approved washer fluids leave a clear film coating on the sensor probes, insulating the probes so they cannot read the fluid level. This This document informs Validate the washer reservoir is full with the proper washer solvent. Refer to Elsa for proper fluid type and fluid quantities under repair manual, maintenance, fluid capacity table. Non-approved fluids can cause residues to form on the sensor which causes the washer fluid lamp to remain on when reservoir is full. The document also contains a photo of the sensor and an example of an approved cleanser
Technical Bulletin (Current ECM software causing erroneous faults): This document contains the procedure to update the...
Read full bulletin
programming on the diagnostic hardware
Technical Bulletin (Exhaust Gas Recirculation Flow Insufficient Stored in ECM Fault Memory): High soot loads prior to...
Read full bulletin
regeneration can cause possible restrictions in the EGR filter. This document contains the procedure to update the programming on the diagnostic hardware. This document contains the fault codes necessary to check the warranty coverage for servicing this issue. The document also contains the procedure for servicing the possible causes of restrictions in the EGR filter.
Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit (U.S.Only)): In cases where an air...
Read full bulletin
conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or component is circulated throughout the refrigerant circuit, the refrigerant circuit must be cleaned of any and all debris or damage to the replacement components will result. This document contains information on how to diagnose, and service this issue.
Technical Bulletin (Update Programming, DTCs P0491 and or P2440 stored in the ECM Fault Memory): Current ECM software are causing erroneous faults.
Read full bulletin
This document contains the codes necessary to update the software to diagnose issues
VOLKSWAGEN DEALERSHIP COMMUNICATION (Upcoming UPDATE 92D2 ? Rain Sensor Software): From the factory, coding for the rain/light sensor is incorrect.
Read full bulletin
The rain sensing feature of the windshield wipers is inoperative. The corrective action taken for this issue was to recode the gateway module to enable the rain sensing wiper function
Technical Bulletin (Washer Level Sensor issues): The sensitivity of the washer solvent level sensor (G33) can be...
Read full bulletin
affected by the type, concentration, and the presence of additives in the washer solvent currently in the tank. The operation of the level sensor relies on the composition of the solvent to provide an accurate message on the solvent level. Incorrect concentration and the presence of additives can contaminate the sensor and reduce its sensitivity. This document discusses the diagnosis, and potential remedy of the issue.
Tech Tips (ECM Fault P1250 "Fuel Level Too Low" Will Not Clear): This document informs to clear static ECM fault...
Read full bulletin
P1250 "Fuel Level Too Low", add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without completing a road test may not allow fault to clear.
Tech Tips (Test Plan to Calibrate Adaptive Cruise Control Sensors Will Not Begin notice): Notification that If the test...
Read full bulletin
plan to calibrate the Adaptive Cruise Control Sensors will not begin, turn off the overhead lights in the shop. The wavelengths of some shop lighting interfere with the sensors during calibration.
Technical Bulletin (Update Programming to Eliminate O2 Sensor DTC P2414 and/or P2237 along with O2 Sensor Replacement):...
Read full bulletin
Current ECM catalyst heating process may cause damage to the front oxygen sensor
Technical Bulletin: Battery, Discharged, Diagnosis for Excessive Static Current Draw
Technical Bulletin: Update Programming to Eliminate O2 Sensor DTC P2414 and/or P2237 along with O2 Sensor Replacement
Technical Bulletin: Battery, Testing and Charging Using Midtronics VAS6161, MCR340V, InCharge 940, or GRX3000VAS...
Read full bulletin
Charger
Tech Tips for No Charging System Voltage issue
Technical Bulletin: This document concerns the sensitivity of the washer solvent level sensor (G33) can be affected by...
Read full bulletin
the type, concentration, and the presence of additives in the washer solvent currently in the tank. The operation of the level sensor relies on the composition of the solvent to provide an accurate message on the solvent level. Incorrect concentration and the presence of additives can contaminate the sensor and reduce its sensitivity.
Tech Bullentin concerning Electric Coolant Fans that Continue to Run after Ignition is Switched OFF
Glow Plug Pressure Sensor Faults Stored in ECM Fault Memory: When diagnosing MIL ON with glow plug pressure sensor...
Read full bulletin
DTC?s it important to perform diagnosis prior to replacing the glow plug.
Technical Bulletin (Glow Plug Pressure Sensor Faults): When diagnosing MIL ON with glow plug pressure sensor DTC?s it...
Read full bulletin
is important to perform a diagnosis prior to replacing the glow plug. This document contains the fault code interperatation after such a diagnosis. the production solution is that the codes were implementated into production. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also available.
Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit): In cases where an air conditioning system...
Read full bulletin
component (such as a compressor or other system component) has failed and debris from the compressor or component is circulated throughout the refrigerant circuit, the refrigerant circuit must be cleaned of any and all debris or damage to the replacement components will result. Debris can be dispersed throughout the refrigerant circuit after a/c component damage. In order to maintain A/C operating efficiency, it is important to flush the refrigerant circuit after A/C component repairs.
Tech Tips (Comfort Module (J393) or BCM (J519) Replacement): This document informs if a comfort or body control module...
Read full bulletin
is replaced during normal diagnosis, make sure the factory mode has been switched OFF. This can be accomplished by selecting guided function of either the J393 or J519 or control module OBD of J393 or J519 then selecting adaptation channel 99. Failure to deactivate factory mode will create a concern where the door locks will not lock and/or unlock with the switch and/or the remotes.
Tech Tips (AC Compressor Replacement, Refrigerant Circuit Flushing Requirement): This document informs when replacing...
Read full bulletin
the Air Conditioning compressor it is necessary to flush the entire system to remove all the PAG oil. Replacement AC compressors come with a full charge of oil. Any time another compressor is installed with a different vendor (such as Sanden to Denso) it is necessary to replace all the oil in the system to the new vendor type PAG oil. This document also informs When installing the new AC compressor immediately transfer the AC compressor caps to the original compressor. There is also a photo to show the necessary part placement.
Transmission
61 bulletinsCautions about using aftermarket transmission flush machines and aftermarket transmission fluids.
Diagnosing Manual Transmission Noise
Manual transmission noise diagnosing
Choosing Service Numbers ? Transmission and Drivetrain
Customer states there is a noise from the clutch, transmission or driveline components under varying driving conditions...
Read full bulletin
with varying sound levels.
Automatic Transmission Fluid Requirements
Noise Diagnostic for Manual Transmission vehicles.
This bulletin provides a procedure to determine ?repair? versus ?replacement? of an automatic transmission.
Read full bulletin
This procedure is to be used ?After? the transmission has been removed from the vehicle.
Automatic Transmission Fluid Requirements
Automatic transmission fluid requirements.
Manual transmission noise diagnosing.
Choosing service numbers-Transmission and Drivetrain.
Manual transmission noise diagnostic assistance
Auto Trans fluid requirements.
Customer states MIL-on with P0087 P0149 P053F in the ECM Customer states MIL-on with any combination of P0300, P0301,...
Read full bulletin
P0302, P0303, P0304, P1D74 and/or P1D75 in the ECM Customer states rattle noise from the underbody heat shields Customer states noise from front suspension Customer states noise during clutch pedal operation Customer concern of vehicle door hard to close/out of adjustment Customer states airbag light on Customer states no crank/no start. Vehicle is towed in. Customer states there is a popping/clicking noise while operating temperature settings Customer states MIL-on with P0401
Customer states MIL-on with P0087 P0149 P053F in the ECM Customer states noise from front suspension Customer states...
Read full bulletin
noise during clutch pedal operation Customer concern of vehicle door hard to close/out of adjustment Customer states airbag light on Customer states no crank/no start. Vehicle is towed in. Customer states there is a popping/clicking noise while operating temperature settings Customer states MIL-on with P0401
Customer states MIL-on with P0087 P0149 P053F in the ECM Customer states noise from front suspension Customer states...
Read full bulletin
noise during clutch pedal operation Customer concern of vehicle door hard to close/out of adjustment Customer states no crank/no start. Vehicle is towed in. Customer states there is a popping/clicking noise while operating temperature settings Customer states MIL-on with P0401
Customer states MIL-on with P0087 P0149 P053F in the ECM Customer states noise from front suspension Customer states...
Read full bulletin
noise during clutch pedal operation Customer states no crank/no start. Vehicle is towed in. Customer states there is a popping/clicking noise while operating temperature settings Customer states MIL-on with P0401
Customer states MIL-on with P0087 P0149 P053F in the ECM Customer states noise during clutch pedal operation Customer states no crank/no start.
Read full bulletin
Vehicle is towed in. Customer states there is a popping/clicking noise while operating temperature settings Customer states MIL-on with P0401
Customer states MIL-on with P0087 P0149 P053F in the ECM Customer states noise during clutch pedal operation Customer states no crank/no start.
Read full bulletin
Vehicle is towed in. Hood release inoperative Customer states there is a popping/clicking noise while operating temperature settings Customer states MIL-on with P0401
Customer states MIL-on with P0087 P0149 P053F in the ECM Customer states noise during clutch pedal operation Hood...
Read full bulletin
release inoperative Customer states there is a popping/clicking noise while operating temperature settings Customer states MIL-on with P0401
Customer states MIL-on with P0087 P0149 P053F in the ECM Customer states noise during clutch pedal operation Hood...
Read full bulletin
release inoperative Customer states MIL-on with P0401
Customer states MIL-on with P013E in the ECM Customer states MIL-on with P0087 P0149 P053F in the ECM Customer states...
Read full bulletin
noise during clutch pedal operation Hood release inoperative Customer states there is a popping/clicking noise while operating temperature settings Customer states MIL-on with P0401
Customer states MIL-on with P013E in the ECM Customer states MIL-on with P0087 P0149 P053F in the ECM Customer states...
Read full bulletin
noise during clutch pedal operation Hood release inoperative Customer states MIL-on with P0401
Transmission Fluid requirements updated to include additional model year applicability.
Addressing Transmission Fluid Temperature Sensor Concerns, update authing system metadata.
Addressing Transmission Fluid Temperature Sensor Concerns, update authing system metadata.
Addressing Transmission Fluid Temperature Sensor Concerns, update authing system metadata.
Addressing Transmission Fluid Temperature Sensor Concerns, update authing system metadata.
Update to model year applicability and existing tip for Dual clutch basic settings procedure.
Update model year applicability and existing tip for transmission basic settings direction.
On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex)
On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex)
On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex)
On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex)
On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex)
On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex)
Technical Bulletin (Choosing Service Numbers ? Transmission and Drivetrain): To ensure that customer concerns are...
Read full bulletin
being properly addressed, Volkswagen created a reference Service Numbers example sheet available for customer concerns/technician findings. Proper Service Number usage will ensure customer concerns/technician findings are properly addressed allowing for more accurate and timely repair information, Required Vehicle Updates and Technical Bulletins.
On-car analysis list of customer complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex)
On-car analysis list from customer complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex)
Update to model year applicability and existing tip for Dual clutch basic settings procedure.
Update model year applicability and existing tip for transmission basic settings direction.
On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex)
Technical Bulletin (Choosing Service Numbers ? Transmission and Drivetrain): To ensure that customer concerns are...
Read full bulletin
being properly addressed, Volkswagen created a reference Service Numbers example sheet available for customer concerns/technician findings. Proper Service Number usage will ensure customer concerns/technician findings are properly addressed allowing for more accurate and timely repair information, Required Vehicle Updates and Technical Bulletins.
On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex)
On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex)
On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex)
On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex)
On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex)
On-car analysis list of customer complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex)
On-car analysis list from customer complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex)
On-car analysis list of Customer Complaints: Transmission Concerns(including clutch assembly, bevel box and Haldex)
UPDATE Technical Bulletin 37J2 UPDATE - AQ250 TCM Software (FED_EMS): This update has been proactively released to...
Read full bulletin
prevent harsh shifting and perceived hesitation.
Technical Bulletin (Automatic Transmission Fluid Requirements): At this time, Volkswagen Group of America, Volkswagen...
Read full bulletin
Canada do not support or warranty any use of aftermarket universal automatic transmission fluids or the machines used to flush the transmissions. This applies to all standard automatic and DSG transmissions.
Technical Bulletin (Manual Transmission Noise Diagnosing): Customer states there is a noise from the clutch,...
Read full bulletin
transmission or driveline components under varying driving conditions with varying sound levels. This document informs the dealer to follow specific diagnostic steps to assess the condition a vehicle
Warranty Information (Loaner/Rental Reimbursement Support for Transmission Oil Cooler (38B9) Recall): This...
Read full bulletin
communication contains important information regarding Loaner/Rental vehicle reimbursement support for VW customers affected by the Transmission Oil Cooler (38B9) Recall.
On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex)
Tech Tips: Generator Charging Concern Diagnosis Tip - One Way Clutch Pulley Testing
Document informs meaning of service numbers to discribe issuse with If the customer is experiencing clutch related...
Read full bulletin
issues and the concern is found to be within the clutch components If the customer is experiencing manual gearbox related issues and the concern is found to be within the standard gearbox If the customer is experiencing automatic transmission-related issues and the concern is found to be within the automatic transmission If the customer is experiencing drivetrain related issues and the concern is found to be within the drivetrain components
Discusses possible causes of customer concern Customer states there is a noise from the clutch, transmission or...
Read full bulletin
driveline components under varying driving conditions with varying sound levels
This document was created In response to multiple dealership inquires about aftermarket universal (one fluid fits all)...
Read full bulletin
automatic transmission fluids and transmission flushing, Volkswagen Group of America, Volkswagen Canada have prepared the following statement. At this time, Volkswagen Group of America, Volkswagen Canada do not support or warranty any use of aftermarket universal automatic transmission fluids or the machines used to flush the transmissions. This applies to all standard automatic and DSG transmissions. Due to the functional and design variations in each automatic transmission, the transmission fluid is developed and used by Volkswagen for specific purpose within each application. Under no circumstances are these fluids to be used outside their designated transmission and replacing any of the Volkswagen approved automatic transmission fluids with a universal ?one fluid fits all? approach is not accepted.
Pre-Delivery & Maintenance
61 bulletinsVehicle Concerns Before Recall Repair Available
2014 Model Year Volkswagen Vehicle Warranty, Roadside Assistance, and Carefree Maintenance
Wiper Blade Inspection for Proper Warranty Coding
Car-Net? Operating Control Unit (OCU/J949) Service Guidelines & General Information
Car-Net? Operating Control Unit (OCU/J949) Service Guidelines & General Information
Car-Net? Operating Control Unit (OCU/J949) Service Guidelines & General Information
Car-Net? Operating Control Unit (OCU/J949) Service Guidelines & General Information
Inspection Service Reminder, ?Inspect Now? Message
Quick Spec Guides Now published on ServiceNet
PDI - Vehicle Inspection, Protection Removal and Detailing
PDI - Vehicle Inspection, Protection Removal and Detailing
Dealer Principal, Sales Manager, Service Manager, Parts Manager and Warranty Administrator
Wiper Blade Inspection for Proper Warranty Coding
Car-Net? Operating Control Unit (OCU/J949) Service Guidelines & General Information
Car-Net? Operating Control Unit (OCU/J949) Service Guidelines & General Information
Car-Net? Operating Control Unit (OCU/J949) Service Guidelines & General Information
Car-Net? Operating Control Unit (OCU/J949) Service Guidelines & General Information
Temporary warranty process and parts return program (car-net equipped models)
Temporary warranty process and parts return program (UMI equipped models)
Temporary warranty process and parts return program (car-net equipped models)
Temporary warranty process and parts return program (car-net equipped models)
Temporary warranty process and parts return program (UMI equipped models)
Temporary warranty process and parts return program (car-net equipped models)
Temporary warranty process and parts return program (UMI equipped models)
Volkswagen Warranty Policies and Procedures ? April 2014
Volkswagen Warranty Policies and Procedures Manual ? US Edition, November 2014
Until further notice, Volkswagen will reimburse up to $35 per day to provide customers affected by the 38B9 Recall with...
Read full bulletin
a loaner or rental vehicle while their existing vehicle is being repaired.
If a needed service part is on back order, upgrade the daily order to a red order and check the ?Car Down? box to escalate the order.
Read full bulletin
If parts assistance is needed, please call 800-767-6552 to speak with a VWGoA Parts Specialist.
If a needed service part is on back order, upgrade the daily order to a red order and check the ?Car Down? box to escalate the order.
Read full bulletin
If parts assistance is needed, please call 800-767-6552 to speak with a VWGoA Parts Specialist.
When performing repairs on air vents under warranty, it is important to determine if the damage was caused by outside influence or customer abuse.
Read full bulletin
If there are no signs of abuse, please replace the vent(s). DO NOT disassemble or in any way attempt to repair the vent(s).
Warranty.
Recall Reminder Part Labels
Tech Tips (All Models 2000-2014 - Part ordering): If a needed service part is on back order, upgrade the daily order...
Read full bulletin
to a red order and check the ?Car Down? box to escalate the order. This document informs how to contact VWGoA Parts Specialist for help.
Service Information (2014 Car-Net equipped Models - Market Introduction): During the market introduction of 2014 models...
Read full bulletin
equipped with Car-net, Volkswagen will collect all warranty repair information related to any components / failures specific to Car - Net to ensure prompt analysis and resolution of any emerging concerns.
2014 UMI equipped models - Market Introduction: During the market introduction of 2014 models equipped with UMI,...
Read full bulletin
Volkswagen will collect all warranty repair information related to any components / failures specific to UMI to ensure prompt analysis and resolution of any emerging concerns
Service Information (2014 Car-Net Equipped Models - Market Introduction): During the market introduction of 2014 models...
Read full bulletin
equipped with Car-Net, Volkswagen will collect all warranty repair information related to any components / failures specific to Car-Net to ensure prompt analysis and resolution of any emerging concerns.
Tech Tips (All Models 2000-2014 - Part ordering): If a needed service part is on back order, upgrade the daily order...
Read full bulletin
to a red order and check the ?Car Down? box to escalate the order. This document informs how to contact VWGoA Parts Specialist for help.
Service Information (2014 Car-Net equipped Models - Market Introduction): During the market introduction of 2014 models...
Read full bulletin
equipped with Car-net, Volkswagen will collect all warranty repair information related to any components / failures specific to Car - Net to ensure prompt analysis and resolution of any emerging concerns.
2014 UMI equipped models - Market Introduction: During the market introduction of 2014 models equipped with UMI,...
Read full bulletin
Volkswagen will collect all warranty repair information related to any components / failures specific to UMI to ensure prompt analysis and resolution of any emerging concerns
Service Information (2014 Car-Net Equipped Models - Market Introduction): During the market introduction of 2014 models...
Read full bulletin
equipped with Car-Net, Volkswagen will collect all warranty repair information related to any components / failures specific to Car-Net to ensure prompt analysis and resolution of any emerging concerns.
This Document informs dealers on the Revised VWP-18-07.
Read full bulletin
New info on 10% maintenance intervals
This service xpress document give information on the various fluids a vehicle can hold, how to check the fluids and when...
Read full bulletin
the vehicle should be serviced for maintenance
Process for checking the storage of the convertible top fabric when top is open.
To add associated labor operation numbers to warranty table and include model year 2017 applicability.
Technical Bulletin (Wiper Blade Inspection for Proper Warranty Coding): Wiper blade inspection guidelines for wear...
Read full bulletin
and tear, outside influence or a factory issue. This document informs what is under coverage for wiper blade issues.
Service Information (2014 UMI equipped models - market introduction): During the market introduction of 2014 models...
Read full bulletin
equipped with UMI, Volkswagen will collect all warranty repair information related to any components / failures specific to UMI to ensure prompt analysis and resolution of any emerging concerns
2014 Car-Net equipped models - Market Introduction: During the market introduction of 2014 models equipped with...
Read full bulletin
Car-net, Volkswagen will collect all warranty repair information related to any components / failures specific to Car-Net ensure prompt analysis and resolution of any emerging concerns.
Warranty Information (2014 Model Year Volkswagen Vehicle Warranty, Roadside Assistance, and Carefree Maintenance): This...
Read full bulletin
document contains the "2014 MODEL YEAR VOLKSWAGEN VEHICLE COVERAGE SUMMARY".
Technical Bulletin (Damage on External Chrome or Aluminum Surfaces) The surfaces of chrome parts can get damaged in...
Read full bulletin
the production process or by external influences. This document discusses options for repairs covered under warranty, and methods to prevent damage.
Service Information (Temporary Warranty Process and Parts Return Program): During the Market Introduction of 2014...
Read full bulletin
models equipped with UMI, Volkswagen will collect all warranty repair information related to any components/failures specific to UMI to ensure prompt analysis and resolution of any emerging concerns.
Service Information (2014 Car-Net Equipped Models - Market Introduction) During the market introduction of 2014 models...
Read full bulletin
equipped with Car-Net Volkswagen will collect all warranty repair information for any emerging concerns
Download ODIS Service Diagnostic Version for 24CV recall.
Precautionary steps to Error Code ERP0203E when performing campaign 23U3.
PROFI Dealer Vehicle Information Request Form: This document informs of the requirements to test vehicles for an upcoming VW campaign.
Read full bulletin
It contains the number of vehicles to be tested, and what is to be tested.
2014 Volkswagen Beetle Convertible Maintenance Schedule from 10,000 miles to 120,000 miles
Technical Bulletin (Car-Net Unresponsive - Verizon Telematics Service Interruptions and Outages): When beginning...
Read full bulletin
diagnosis for customer concerns related to functionality of the Car-Net system, it is important to understand that the symptom(s) may not be related to any problem with the vehicle itself. If there are any problems with the AT&T 3G service and/or a service interruption or outage with the Verizon Telematics system, one or more Car-Net functions may be inoperative. This document discusses the diagnosis, and potential remedy of the issue.
Technical Bulletin (By-Pack At Delivery): Components may be missing from the by-pack at delivery.
Read full bulletin
Components missing from the by-pack should be claimed in one of two ways. (Warranty or Transportation) Understanding when to claim one versus the other is very important. This document informs how to tell the difference.
Technical Bulletin (Car-Net Unresponsive - Verizon Telematics Service Interruptions and Outages): This document...
Read full bulletin
informs how to service potiential Interruptions and Outages. When beginning diagnosis for customer concerns related to functionality of the Car-Net system, it is important to understand that the symptom(s) may not be related to any problem with the vehicle itself. If there are any problems with the AT&T 3G service and/or a service interruption or outage with the Verizon Telematics system, one or more Car-Net functions may be inoperative.
Technical Bulletin: A notification that Components may be missing from the by-pack at delivery.
Read full bulletin
It also informs that Components missing from the by-pack should be claimed in one of two ways. (Warranty or Transportation)
Adjustment of Time Unit Correction Payments for 2014/2015 Model Year Maintenance Claims
Reminder that ODIS Service V3.0.0 is now available for installation, and that it is mandatory on all diagnostic devices...
Read full bulletin
used on vehicles covered by the new vehicle warranty. With the release of V3.0.0. Installation DVDs are no longer used. New installations on new devices and re-installations on existing devices are now performed directly from the web server
Fuel System
46 bulletinsA list of suggested fuel stations
Fuel Additive
Diesel Models only. Repurchase Prior to Repairs
Recommended Gasoline Quality
Diesel Fuel System and Repair
Gasoline Quality
2009-2015 Model Year Volkswagen TDI Clean Diesel Vehicles Registered in Minnesota
Gasoline fuel additive
The DLC is intended for use with diagnostic scan tools and by emissions testing stations.
Read full bulletin
However, aftermarket devices (i.e., drive data recorders) that connect to the DLC have now become available.
Diesel fuel system diagnosis repair.
Gasoline quality.
Gasoline quality check.
Read full bulletin
Update to model and model year applicability.
High soot loads prior to regeneration can cause possible restrictions in the Exhaust Gas Recirculation (EGR) filter.
Read full bulletin
Update to clarify procedural step and add "if needed" to warranty and part tables.
Gasoline quality.
High soot loads prior to regeneration can cause possible restrictions in the EGR filter.
High soot loads prior to regeneration can cause possible restrictions in the Exhaust Gas Recirculation (EGR) filter.
Read full bulletin
Update to MAF labor operation number.
High soot loads prior to regeneration can cause possible restrictions in the Exhaust Gas Recirculation (EGR) filter.
Diagnosis for EGR flow insufficient.
Read full bulletin
Update to parts table.
Diagnosis for EGR flow insufficient.
Read full bulletin
Update to parts table.
VW approved gasoline fuel additive, update to include additional models and model year applicability.
VW approved gasoline fuel additive, update to include additional models and model year applicability.
Update to existing tip for fuel quality checking.
Catalytic Converter Regeneration Scan Tool instruction.
Due to a parts catalog error, incorrect emissions related component(s) may have been installed on some vehicles during a past service repair visit.
Read full bulletin
Dealers will inspect and, if needed, replace the component(s) as a proactive measure to ensure continued emissions compliance.
Due to a parts catalog error, incorrect emissions related component(s) may have been installed on some vehicles during a past service repair visit.
Read full bulletin
Dealers will inspect and, if needed, replace the component(s) as a proactive measure to ensure continued emissions compliance.
This document informs dealers of a revision to the Extended Emissions Warranty Limited Warranty Extension for 2.0L TDI Gen 1 vehicles.
Read full bulletin
Added clarification on totaled vehicles and loaners
Fuel System Diagnosis & Repair, Updated to include an additional warranty claiming statement.
Alternative diagnosis for lean fuel trim.
Diesel Fuel System Repair procedure modification.
Read full bulletin
TDI models.
Alternative diagnosis for lean fuel trim.
Volkswagen of America is requesting your cooperation in supplying us with technical information related to the repair...
Read full bulletin
process for vehicles on which the TDI Generation I, II, and III 2.0L emissions modification is being performed ?Campaigns 23U3?. Volkswagen will use this information to ensure prompt analysis and resolution of any emerging concerns.
Technical Bulletin (Exhaust Gas Recirculation Flow Insufficient issues): This document informs that high soot loads...
Read full bulletin
prior to regeneration can cause possible restrictions in the EGR filter. The production solution to this issue is New software being implemented in current production.
Volkswagen of America is requesting your cooperation in supplying us with technical information related to the repair...
Read full bulletin
process for vehicles on which the TDI Generation I, II, and III 2.0L emissions modification is being performed ?Campaigns 23U3?. Volkswagen will use this information to ensure prompt analysis and resolution of any emerging concerns.
Technical Bulletin (Exhaust Gas Recirculation Flow Insufficient issues): This document informs that high soot loads...
Read full bulletin
prior to regeneration can cause possible restrictions in the EGR filter. The production solution to this issue is New software being implemented in current production.
This document gives answers to frequently ask questions concerning the current owners and lessees of TDI vehicles...
Read full bulletin
affected by the emissions issue eligiblality options and issues.
This document informs of Volkswagen AG and Audi AG received notice from the US Environmental Protection Agency, US...
Read full bulletin
Department of Justice and the California Air Resources Board of an investigation related to emissions compliance matters.
This notice gives an update on the settlement for the emissions issues with regards to 2.0L TDI vehicles.
Update to expand fuel testing for lean DTCS.
Update to existing tip for fuel quality checking.
VSS 17-08 - TDI Monitoring Program - Campaigns 23Q3/23U4/23U3 2.0L Emissions Modification - Gen I, Gen II and Gen...
Read full bulletin
III.
Technical Bulletin (Exhaust Gas Recirculation Flow, Could be accompanied with Soot Accumulation): High soot loads prior...
Read full bulletin
to regeneration can cause possible restrictions in the EGR filter. The production solution for this issue is New software implemented in current production. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also available.
Technical Bulletin: High Pressure Fuel Pump Diagnosis.
Read full bulletin
Completing the GFF high pressure pump function test is essential to diagnose proper pump operation and to avoid unnecessary replacements. This document contains the procedure to update the programming on the diagnostic hardware. This document contains the fault codes necessary to check the warranty coverage for servicing this issue.
Discusses the issues associated with using contaiminated gasoline.
Read full bulletin
There are recommendations to use top tier gasoline retailers
Technical tips on what to do if improper gasoline has been added to the vehicle.
A how to guide for Diesel Fuel System Diagnosis and Repair
Technical Bulletin (Exhaust Gas Recirculation Flow Insufficient, and Soot Accumulation issues): This document informs...
Read full bulletin
of high soot loads prior to regeneration which can cause possible restrictions in the EGR filter. The production solution to this issue was new software being implemented in current production. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also available.
Infotainment
36 bulletinsInfotainment Worksheet (U.S.
Read full bulletin
Only)
RNS 315 Navigation Radio Software Update for Locking, Rebooting, Switches Off at Random
UMI Software Update for Various Bluetooth Concerns
Infotainment Worksheet (U.S.
Read full bulletin
Only)
All Navigation Radios-All Models
Infotainment Worksheet (U.S.
Read full bulletin
Only)
RNS 315 Navigation Radio Software Update for Locking, Rebooting, Switches Off at Random
UMI Software Update for Various Bluetooth Concerns
Infotainment Worksheet (U.S.
Read full bulletin
Only)
When performing SVM updates, the scan tool should be hardwired to the vehicle and the Bluetooth physically turned off.
Read full bulletin
A hard wired internet connection is also recommended.
When the Navigation RNS 850/510/315 is in 3D mode, the top portion of the screen may not display streets.
Read full bulletin
This line represents the horizon and is a normal operation of system. No repairs should be made. Examples below of day and night modes
If an ?Inspect Now? message is displayed in the vehicle?s MFI, check the value of the inspection service reminder.
Read full bulletin
Note that the inspection service reminder is different than the oil change service reminder and is reset independently from the oil change service reminder.
Radio knob replacement instead of radio replacement w/ knob part number.
Infotainment Worksheet.
Navigation for addressing incorrect Part direction.
Elsa2Go campaign information is now 100% aligned with ElsaPro.
Read full bulletin
This update to Elsa2Go ensures that both systems are displaying the same campaign information, including OPEN/CLOSED status, repair date as well as criterions at the same time without any discrepancy.
Cam screen damage.
Infotainment worksheet.
Addressing Component Protection display .
Read full bulletin
Update model and model year applicability.
Addressing Component Protection display .
Read full bulletin
Update model and model year applicability.
Alternative method for radio code retrieval.
Update to existing information to address phone concerns via bluetooth resulting from saved emoji information
Service Information (Wheel Locks Missing at Delivery): Wheel Locks are not standard equipment for all 2014 models (excluding Golf).
Read full bulletin
This document informs if a vehicle's Monroney label displays wheel locks in the "Packages/Options" (highlighted in this document) and Wheel Locks are missing, dealers should contact their respective SOM to have a new Monroney label assigned.
Technical Bulletin (Infotainment Worksheet): This bulletin provides a document that will allow more detail to be...
Read full bulletin
provided for repairs related to the Infotainment System (radio, navigation, Bluetooth, telephone systems, etc.).
Update to existing information to address phone concerns via bluetooth resulting from saved emoji information
Service Information (Wheel Locks Missing at Delivery): Wheel Locks are not standard equipment for all 2014 models (excluding Golf).
Read full bulletin
This document informs if a vehicle?s Monroney label displays wheel locks in the ?Packages/Options? (highlighted in this document) and Wheel Locks are missing, dealers should contact their respective SOM to have a new Monroney label assigned.
Technical Bulletin (Infotainment Worksheet): This bulletin provides a document that will allow more detail to be...
Read full bulletin
provided for repairs related to the Infotainment System (radio, navigation, Bluetooth, telephone systems, etc.).
Alternative method for radio code retrieval.
Tech Tips (Inspection Service Reminder, ?Inspect Now? Message): If an ?Inspect Now? message is displayed in the...
Read full bulletin
vehicle?s MFI, check the value of the inspection service reminder. Note that the inspection service reminder is different than the oil change service reminder and is reset independently from the oil change service reminder. To reset the inspection service reminder after completing an inspection service, perform the applicable procedure within this document.
Tech Tips (All Navigation Radios-All Models): When the Navigation RNS 850/510/315 is in 3D mode, the top portion of the...
Read full bulletin
screen may not display streets. This line represents the horizon and is a normal operation of system. This document provides Examples of day and night modes:
Technical Bulletin (Filling out the Infotainment Worksheet) This bulletin provides instructions and information for...
Read full bulletin
completing and submitting the updated web version of the Infotainment Worksheet. Like the previous version, the Infotainment Worksheet allows more detail to be provided for repairs related to the Infotainment System (radio, navigation, Bluetooth, telephone systems, etc.). The new web version provides an easier approach by which to complete and submit the information.
Tech Tips (Instrument Cluster Production Mode): This document informs the procedure to remove the production mode...
Read full bulletin
setting when it is displayed in the instrument cluster.
Technical Bulletin: This document refers to the software update for RNS 510 Welcome Screen Image Distorted.
Read full bulletin
This procedure corrects the concerns listed above by updating the RNS 510 to the latest software 5382
Tech Tips (SVM Update Instructions): This document informs when performing SVM updates, the scan tool should be...
Read full bulletin
hardwired to the vehicle and the Bluetooth physically turned off. A hard wired internet connection is also recommended.
Tech Tips (Convertible Front Window Contacts Rear Window Glass, Window misaligned): This document informs of...
Read full bulletin
Complaints of the front window glass contacting the rear glass may be caused by the front window glass becoming loose in the regulator clamps. The document displays how to service this issue and correct the front window glass
Technical Bulletin: UMI Software Update for Bluetooth Concerns ? Voice Prompts stuck in Non-English Language ? Poor...
Read full bulletin
Call Clarity on Receiving End ? Various Bluetooth Connectivity & Paring issues This procedure in the document corrects the concerns by updating the UMI to the latest software
Body & Paint
33 bulletinsLack of paint under roof
Wind & Water Leak Checking
Broken or Difficult to Adjust, Dash Panel Air Vents
Removing Paint Contaminants from Exterior Paint
Removing Paint Contaminants from Exterior Paint
Complaints of the front window glass contacting the rear glass may be caused by the front window glass becoming loose in the regulator clamps.
Read full bulletin
(See Figs. 1 and 2)
Complaints of a rattle noise when closing the front door, or rattle from door when driving on bump roads may be caused...
Read full bulletin
when the front window regulator mounting nuts have become loose in the door. This concern may be more noticeable with the window closed. (See Fig. 1)
Complaints of a rattle noise when closing the front door or a rattle from door when driving on bumpy roads, may be...
Read full bulletin
caused by the front window regulator mounting nuts becoming loose in the door. This concern may be more noticeable with the window closed. (See Fig. 1)
Noise from Door Panel while Driving
Front Door Locks Hard to Release
Customer may comment that the front door is hard to open with exterior handle.
Front Door Latches Hard to Release
Front door locks hard to release.
Broken or Difficult to Adjust, Dash Panel Air Vents.
Republication of archived technical tip for water leak testing fixture.
Technical Bulletin (PDI - Vehicle Inspection, Protection Removal and Detailing): This document informs of the...
Read full bulletin
procedure to perform when a dealer receives a car. Its contents include: ? Inspecting vehicle for damage (to be completed within 48 hours of delivery to Dealership) ? Shipping damage ? Detailers responsibilities (to be completed prior to delivery to Customer) ? Full Body Covers (FBC), removal and disposal ? RAPGARD, removal and disposal ? Paint finish, inspecting for swirl marks ? Exterior glass, cleaning ? Interior, cleaning ? New vehicle detailing products
Tech Tips (Broken or Difficult to Adjust, Dash Panel Air Vents): This document informs when performing repairs on air...
Read full bulletin
vents under warranty, it is important to determine if the damage was caused by outside influence or customer abuse. If there are no signs of abuse, please replace the vent(s). DO NOT disassemble or in any way attempt to repair the vent(s).
Technical Bulletin (PDI - Vehicle Inspection, Protection Removal and Detailing): This document informs of the...
Read full bulletin
procedure to perform when a dealer receives a car. Its contents include: ? Inspecting vehicle for damage (to be completed within 48 hours of delivery to Dealership) ? Shipping damage ? Detailers responsibilities (to be completed prior to delivery to Customer) ? Full Body Covers (FBC), removal and disposal ? RAPGARD, removal and disposal ? Paint finish, inspecting for swirl marks ? Exterior glass, cleaning ? Interior, cleaning ? New vehicle detailing products
Tech Tips (Broken or Difficult to Adjust, Dash Panel Air Vents): This document informs when performing repairs on air...
Read full bulletin
vents under warranty, it is important to determine if the damage was caused by outside influence or customer abuse. If there are no signs of abuse, please replace the vent(s). DO NOT disassemble or in any way attempt to repair the vent(s).
explaination of cross car distorion when looking through the windshield and how the "effect" in normal.
UPDATE Technical Bulletin: This software update has been proactively released to enable functionality of the rain...
Read full bulletin
sensing windshield wipers
Technical Bulletin (Squeaks, Rattles, Noise, Repair Materials): This doucment contains a list of components and...
Read full bulletin
applications developed to repair concerns of squeaks, rattles, noise and trim fit conditions.
Technical Bulletin (Windshield Wipers Streak or Smear): Windshield or rear window is streaked, has a snakeskin appearance, or the surface feels rough.
Read full bulletin
To avoid unnecessary replacement of wiper blades, the condition and cleanliness of the windshield, rear window and wiper blades, should be checked first. This document contains information on how to diagnose, and service this issue.
Technical Bulletin (Paint Defect - Water Migration Under the RAPGARD): Water migration under the RAPGARD can be...
Read full bulletin
mistaken as a paint defect when in fact it is only moisture trapped in the clear coat of the paint. This document discusses. - RAPGARD, removal and disposal - Inspecting for water migration in areas where RAPGARD was removed. - Examples of water migration after the RAPGARD is removed
Technical Bulletin (PDI - Vehicle Inspection, Protection Removal and Detailing): This document refers to a pre check...
Read full bulletin
inspection on the quality of a vehicle such as - Inspecting vehicle for damage (to be completed within 48 hours of delivery to Dealership) - Shipping damage - Detailers responsibilities (to be completed prior to delivery to Customer) - Full Body Covers (FBC), removal and disposal - RAPGARD, removal and disposal - Vehicles are shipped with RAPGARD. This self-adhering plastic product is applied in certain areas of the vehicle and is designed to provide protection from all types of possible damages. - Paint finish, inspecting for swirl marks - Exterior glass, cleaning - Interior, cleaning - New vehicle detailing products
Technical Bulletin (Sunroof or Power Sunshade, Does Not Open/Close or Automatic Operation Does Not Function).
Read full bulletin
This document contains Warranty information for coverage, and informs of methods to to service the issue
Tech Tips (Rattle Noise when Closing Door-Window Regulator Loose): Complaints of a rattle noise when closing the front...
Read full bulletin
door or a rattle from door when driving on bumpy roads, may be caused by the front window regulator mounting nuts becoming loose in the door. This concern may be more noticeable with the window closed. This document informs how to service this issue
Technical Bulletin (Front Door Locks Hard to Release): This document informs of Customers who comment that the front...
Read full bulletin
door is hard to open with exterior handle. For concerns of front door lock hard to release from the outside door handle, or the outside handle binds. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also available.
Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt...
Read full bulletin
meter to check for 0 V, which will be present after the open in the grid line. This document informs of how to diagnose the issue and tips on servicing the issue
Technical Bulletin (Removing Paint Contaminants from Exterior Paint): This document informs how to remove paint...
Read full bulletin
contaminants such as rail dust and industrial fallout from exterior paint.
Technical Bulletin (Car-Net Operating Control Unit (OCU/J949) Service Guidelines & General Information): For...
Read full bulletin
informational purposes this document informs of Software related fault codes Software operating characteristics Swapping of OCU During PDI, LED does not illuminate issues Unsuccessful Over The Air Registration (OTAR) Does not include the "S" trim for Passat, Jetta, Beetle, and Tiguan.
Tech Tips: Front Window Contacts Rear Window Glass, Window Misaligned issue
Technical Bulletin about Paint Finish, Reducing Swirl Marks and Fine Scratches New vehicles (prior to Retail Delivery)...
Read full bulletin
with swirl marks and or fine scratches from polishing or cleaning. The document also have infromation about where to find warrenty coverage for the service
Lighting
30 bulletinsVolkswagen Care Scheduled Maintenance Interval Time or Mileage Guidelines
Exterior Lights, Moisture Accumulation
Exterior Lights, Moisture Accumulation
Exterior Lights, Moisture Accumulation
Interior Light Assembly Rattle Noise
With HID headlights
Exterior Lights, Moisture Accumulation
Exterior Lights, Moisture Accumulation
Exterior Lights, Moisture Accumulation
For vehicles with HID headlights, the headlight range can be manually adjusted to the vehicle loading condition once the...
Read full bulletin
low beams are switched on (Figure 1, adjustment knob 2). This feature helps ensure proper aiming of the vehicle headlights.
Exterior Lights, Moisture Accumulation.
Read full bulletin
Update model year applicability to include 2022.
Exterior lighting moisture in lens updated to exclude LED lighting.
Adaptive front lighting descriptive
Condensation and or water droplets visible on inside of exterior light lenses.
Read full bulletin
TB updated to include model year 2019 applicability.
Condensation and/or water droplets visible on inside of exterior light lenses.
Read full bulletin
TB updated to include model year 2019 applicability.
Condensation and or water droplets visible on inside of exterior light lenses.
Read full bulletin
TB updated to include model year 2019 applicability.
Car Net diagnosis for no green light (OTAR: Over the Air Registration Indicator) issues
On-car analysis list of Customer Complaints: Customer states the oil light is on
On-car analysis list of Customer Complaints: Customer states the oil light is on
On-car analysis list Customer Complaints: Customer states the oil light is on
On-car analysis list of Customer Complaints: Customer states the oil light is on
On-car analysis list of Customer Complaints: Customer states the oil light is on
On-car analysis of Customer Complaints: Customer states the oil light is on
VOLKSWAGEN DEALERSHIP COMMUNICATION (Upcoming UPDATE 45D7 ? TPMS/ESC Software Update): This document informs of an...
Read full bulletin
upcomming update which states that Illumination of the TPMS and/or ESC light at vehicle start-up and/or under low speed (e.g. <7mph) driving conditions after vehicle start-up. The condition goes away immediately after start up or at speeds greater than 7 mph. The action taken to correct this issue was a SVM software update
On-car analysis list of Customer Complaints: Customer states the oil light is on
Technical Bulletin (Exterior Lights, Moisture Accumulation): Exterior light assemblies (headlights, taillights, fog...
Read full bulletin
lights, turn signals) are vented and may collect moisture on their inner surfaces, depending on humidity and other climatic changes. This document discusses necessary to diagnosis, and potential remedy of the issue.
Tech Tips (With HID headlights): For vehicles with HID headlights, the headlight range can be manually adjusted.
Read full bulletin
This document informs of the advantages of this feature
UPDATE Technical Bulletin (TPMS/ESC Software): This update has been proactively released to prevent illumination of the...
Read full bulletin
TPMS and/or ESC light at vehicle start-up and/or under low speed (e.g. <7mph) driving conditions after vehicle start-up. The condition goes away immediately after start up or at speeds greater than 7 mph.
Technical Bulletin: Condensation and or water droplets becomming visible on inside of exterior light lenses issue is...
Read full bulletin
discussed in this document
This update has been proactively released to prevent illumination of the TPMS and/or ESC light at vehicle start-up and/or under low speed (e.g.
Read full bulletin
<7mph) driving conditions after vehicle start-up. The condition goes away immediately after start up or at speeds greater than 7 mph.
Brakes
29 bulletinsUpdate Programming, MIL ON, DTC P0106 Manifold Absolute Pressure Range / Performance Stored in ECM Fault Memory
Rear Disc Brakes, Replacing Rear Brake Pads and Rotors for Squeal
Rear Disc Brakes, Replacing Rear Brake Pads and Rotors for Squeal
Brake Disc Pulsation or Vibration (U.S.
Read full bulletin
Only)
Vibration or noise when braking may be due to brake disc corrosion protection which has not been completely removed by...
Read full bulletin
normal braking or surface rust built up during transportation.
Brake Disc Pulsation or Vibration (U.S.
Read full bulletin
Only)
Brake Disc Pulsation or Vibration
Vibration or noise when braking may be due to brake disc corrosion protection which has not been completely removed by...
Read full bulletin
normal braking, or surface rust built up during transportation.
Vibration or noise when braking may be due to brake disc corrosion protection which has not been completely removed by...
Read full bulletin
normal braking, or surface rust built up during transportation.
Strut or Shock Absorber Leak Assesment.
Brake Rotor, Vibration / Pulsation.
Read full bulletin
Addition of mandatory brake form and reference to Volkswagen Warranty Policy and Procedures Manual.
Rear Disc Brakes, Replacing Rear Brake Pads and Rotors for Squeal.
Vibration or noise when braking may be due to brake disc corrosion protection which has not been completely removed by...
Read full bulletin
normal braking or surface rust built up during transportation completely.
Brake Rotor, Vibration / Pulsation Instruction (U.S.
Read full bulletin
Only)
Antilock brake function test direction.
Antilock brake function test direction.
Brake disc Pulsation or Vibration repair instruction
Technical Bulletin (Brake Disc Pulsation or Vibration): When applying brakes at highway speeds the following symptoms...
Read full bulletin
may occur: ? Brake pedal pulsation ? Vibration felt in vehicle body ? Steering wheel shakes A detailed brake disc inspection is needed to determine if the brake disc should be machined or replaced.
Technical Bulletin (Vibration or Noise When Braking): Vibration or noise when braking may be due to brake disc...
Read full bulletin
corrosion protection which has not been completely removed by normal braking or surface rust built up during transportation. This document contains the method to diagnose, and to service this issue
Technical Bulletin (Brake Disc Pulsation or Vibration issues): When applying brakes at highway speeds the following...
Read full bulletin
symptoms may occur: - Brake pedal pulsation - Vibration felt in vehicle body - Steering wheel shakes For brake vibration or pulsation concerns, brake disc machining is allowed. This document contains the fault codes to diagnose and service this issue. It also contains fault codes to inquire if the service is covered under warranty.
Technical Bulletin (Rear Disc Brakes, Replacing Rear Brake Pads and Rotors for Squeal): Rear brake pad composition may...
Read full bulletin
result in a squeal from the rear braking system. This document contains the fault codes to diagnosis and Warrenty coverage codes for this issue
Tech Tips (Electro ? Steering - DTC 01309 008 ?No Communication with -J500-? is Stored in the ABS/ESP Module Only): ...
Read full bulletin
This document informs If, after replacement of the steering rack, fault code 01309 008 is set in the ABS/ESP module only, follow the test plan in GFF for Driver Steering Recommendation (DSR) or channel 3 activation. If the test plan fails to clear the fault, follow the directions in this document using Vehicle Self Diagnosis in Address Word 44 - Steering Assistance:
2014 Volkswagen Beetle/Beetle Convertible Quick Reference Specification Book: This document is an overview which...
Read full bulletin
covers -General Information -Vehicle Identification -Sales Codes -Vehicle Lifting -Suspension, Wheels, Steering -Brake System -Body -Heating, Ventilation & Air Conditioning -Electrical System
Technical Bulletin (Vibration or Noise When Braking): Vibration or noise when braking may be due to brake disc...
Read full bulletin
corrosion protection which has not been completely removed by normal braking, or surface rust built up during transportation. This document informs that vehicles requiring front, rear, or both disc cleaning will exhibit vibration and/or noise. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also available.
Technical Bulletin (Rear Disc Brakes, Replacing Rear Brake Pads and Rotors for Squeal): Rear brake pad composition...
Read full bulletin
may result in a squeal from the rear braking system. Condition as described DOES NOT affect brake performance. The production solution determined lead to improved rear brake pads.
Technical Bulletin: Vibration or Noise When Braking issues are addressed
Technical Bulletin informing that When applying brakes at highway speeds the following symptoms may occur: - Brake...
Read full bulletin
pedal pulsation - Vibration felt in vehicle body - Steering wheel shakes It informs how to inspect brakes. It informs of where to find warranty information for servicing the issue
Rear Disc Brakes, Replacing Rear Brake Pads and Rotors for Squeal
Technical Bulletin (Rear Disc Brakes, Replacing Rear Brake Pads and Rotors for Squeal issues): This document informs...
Read full bulletin
that the rear brake pad composition may result in a squeal from the rear braking system. Condition as described DOES NOT affect brake performance. The production solution for this issue was Improved rear brake pads. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also available.
HVAC & Climate
21 bulletinsHow to check for HVAC system leaks using nitrogen.
Reporting procedure for A/C compressor replacement regardless of the reason for failure.
Read full bulletin
Update to model year applicability and new warranty GFF labor operation number
HVAC, Unpleasant Odor
HVAC, Unpleasant Odor
When replacing the Air Conditioning compressor it is necessary to flush the entire system to remove all the PAG oil.
Read full bulletin
Replacement AC compressors come with a full charge of oil. Any time another compressor is installed with a different vendor (Sanden to Denso) it is necessary to replace all the oil in the system to the new vendor type PAG oil.
A/C requirements, update to model year applicability.
Refrigerant leak diagnosis using Nitrogen.
Read full bulletin
Updated to include ID.4
Refrigerant leak diagnosis using Nitrogen.
Read full bulletin
Updated to include additional model and model year applicability.
A/C Compressor replacement requirements, updated to include additional model year applicability.
Removing musty odor from A/C system.
Read full bulletin
Updated to include additional model and model year applicability.
A/C requirements, update to title.
Using Nitrogen to assist in finding A/C refrigerant leaks.
Using Nitrogen to assist in finding A/C refrigerant leaks.
Statement referring to TB 2043893 removed.
Read full bulletin
To include additional models and model year applicability. A.C. Compressor Replacement, GFF Required Regardless of Concern and Flush Requirement
New a/c machine version added to table.
Read full bulletin
Removal of Behr Flush kit.
Technical Bulletin (HVAC, Unpleasant Odor): Unpleasant odor is coming from Heating and Ventilation system.
Read full bulletin
Odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first started. Condensation is a normal characteristic in all A/C systems. If odor is noticeable continue to follow this document. Contaminants are effectively neutralized using the AIRCOMATIC? II Ultrasonic Climate System Cleaner (VAS 6189A) or AIRCOMATIC? III Ultrasonic Climate System Cleaner (VAS 6189B) and AIRCO-CLEAN? Ultrasonic HVAC Treatment (30208). All other cleaning methods are no longer permitted. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also available.
Technical Bulletin (HVAC, Unpleasant Odor): Unpleasant odor is coming from Heating and Ventilation system.
Read full bulletin
Odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first started. This document contains information on how to diagnose, and service this issue.
Document discusses the customer concern of Customer may comment that the front door is hard to open with exterior handle.
Read full bulletin
The front door lock operation is affected by various climate or temperature conditions and as a result may require increased effort to release. The document also discusses where to find warranty coverage information for possible concern and its documentation
Technical Bulletin (Front Door Latches Hard to Release): This document informs the front door latch operation is...
Read full bulletin
affected by various climate or temperature conditions and as a result may require increased effort to release. Therefore Customers may comment that the front door is hard to open with exterior handle. This document is for informing only and informs how to service this issue.
Technical Bulletin (Front Door Locks Hard to Release): This document informs the customer may comment that the front...
Read full bulletin
door is hard to open with exterior handle. This is due to the front door lock operation being affected by various climate or temperature conditions, and as a result may require increased effort to release. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also available.
Technical Bulletin (Front Door Locks Hard to Release): The front door lock operation is affected by various climate or...
Read full bulletin
temperature conditions and as a result may require increased effort to release. Due to this the customer Customer may comment that the front door is hard to open with the exterior handle. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also available.
Tires & Wheels
11 bulletinsTPMS/ESC Software (FED_EMS)
TPMS/ESC Software (FED_EMS)
TPMS/ESC Software Update
The use of tire dressing gives your tires that shiny finish that completes the image of a clean (new) vehicle.
Read full bulletin
There are many different tire dressing products available. When choosing a product please pay close attention to its contents. Always use a water based product.
AS EQUIPPED, THIS VEHICLE MAY NOT BE OPERATED WITH TIRE CHAINS, BUT MAY ACCOMMODATE SOME OTHER TYPE OF TIRE TRACTION DEVICE.
Read full bulletin
SEE OWNER?S MANUAL FOR DETAILS.
Wheel Locks Missing at Delivery
Starting with model year 2014 wheel locks are no longer standard equipment.
Tire Chain Information (for California dealers only) All Model Years.
Read full bulletin
Information only for all other dealers.
2014 Tire Chain Information (Tire Chain Information (for California dealers only)): As equipped, this vehicle may not...
Read full bulletin
be operated with tire chains, but may accommodate some other type of tire traction device. This document informs what chains can fit on what tires.
Notification of the 2.0l Gen 1, TDI remediation fix monitoring via the VTA system, in alignment with campaigns 23U3.
Tech Tips: This Tech Tip provides an overview of vehicle four wheel alignment, and important steps that should be...
Read full bulletin
followed when performing four wheel alignments
Steering
5 bulletinsSteering Wheel Off Center.
This Document informs dealers the warranty extension for the steering column lock housing has been revised to include...
Read full bulletin
2014 and 2015 model year
Horn and ancillary steering wheel controls diagnosis.
Technical Bulletin (Squeaking Noises From Front Of Vehicle): Squeaking/creaking noise from front of vehicle while fully turning steering wheel.
Read full bulletin
The document also gives information on servicing the issue
Tech Tips: This Tech Tip was established to explain the influence the adjustable steering column tilt position has on...
Read full bulletin
the steering wheel being off center and to provide information on checking for steering wheel off center
Suspension
4 bulletinsWhat is and what is not a leaking suspension strut.
How to identify and when to replace a leaking strut
This can be the due to the Encoder Ring being ground down on the wheel bearing hub unit, resulting in a damaged part.
Strut or Shock leak assessment.
Air Bags & Safety
4 bulletinsAirbag / Pyrotechnic Safety Belt Deployment Inquiries, update to contact information due to retirement.
VW contact when reporting a Airbag or Pyrotechnic safety belt deployment.
Read full bulletin
Update to model year applicability.
Airbag Issues.
Takata Recall Update / Future Recalls for Vehicles with Takata SDI-D Airbag Inflators
Hybrid & EV
4 bulletinsUpdate to regeneration instruction.
Nox regeneration information.
Read full bulletin
Updated to correct the tech tip number in the title.
Campaign Reminder Communication.
Read full bulletin
Also includes: 1998-2004 Beetle, 2003-2004 Beetle Convertible, 2019 Beetle Convertible, 1994-2004 Eurovan, 1994-2004 Golf, 1994-2004 Jetta, 2001-2004 Jetta Wagon, 2018-2019 Tiguan LWB, 1994-2004 Passat, 1994-2004 Passat Wagon, 2004 Phaeton, 2013-2016 Jetta Hybrid, 2004 R32 and 1995-2006 Cabrio.
Technical Bulletin: The document refers to diagnosing charging systems for issues