2006 Suzuki Forenza TSBs
20 Technical Service Bulletins across 8 categories
Categories
Engine
5 bulletinsThis Service Bulletin was sent by Suzuki Motor Corporation to its authorized Suzuki automobile distributors in the U.S.,...
Read full bulletin
explaining the importance of proper inspection and maintenance of suspension lower arm ball joints to prevent the ball stud from becoming separated from the suspension lower arm.
SUZUKI VEHICLE: COUNTER MEASURE PROCEDURE FOR DTC P2135.
Read full bulletin
MIL LIGHT IS ON; DTC P2135 STORED WITHOUT FULLY CHECKING SYSTEM AND CIRCUITS AFTER REPAIRS AND/OR REPLACEMENT TO THROTTLE BODY. *PE
ENGINE CRANKS CUT WILL NOT START MIL ON WITH DTC P0606 (CONTROL MODULE PERFORMANCE) STORED.
Read full bulletin
*KB
ENGINE CRANKS BUT WILL NOT START MIL ON WITH DTC P0606 STORED (CONTROL MODULE PERFORMANCE).
Read full bulletin
*KB
OIL CONSUMPTION OR EXHAUST SMOKE (EXCESSIVE).
Read full bulletin
*TT
Electrical
4 bulletinsSUZUKI: ON CERTAIN VEHICLES, WITHIN THE FRONT PASSENGER SEAT BOTTOM CUSHION, THE SENSING SENSOR MAT, AN ELECTRIC...
Read full bulletin
CIRCUIT DISCONNECTION MAY HAVE DEVELOPED, DUE TO REPEATED FLEXING. *PE
SUZUKI VEHICLES: COUNTER MEASURE PROCEDURE FOR DTC P2138.
Read full bulletin
MIL LIGHT IS ON, DTC P2138 STORED. FAILURE OF THE CONNECTOR AND/OR WIRING CIRCUITS BETWEEN THE ECM AND THE ACCELERATOR PEDAL POSITION SENSOR. MODELS FORENZA, FORENZA WAGON AND RENO (RQ420). *PE
HARD START WITH EXTENDED CRANKING TIME.
Read full bulletin
ECM SOFTWARE LOGIC. *KB
EVAPORATIVE EMISSION SYSTEM CONTINUOUS PURGE FLOW.
Read full bulletin
ECM SOFTWARE COULD CAUSE UNNECESSARY ILLUMINATION OF THE MALFUNCTION INDICATOR LAMP. SUZUKI. *KB
Transmission
3 bulletinsSUZUKI VEHICLES: AUTOMATIC TRANSMISSION SHIFT LEVER IS LOOSE IN THE SHIFT GATE AND/OR IGNITION KEY CANNOT BE REMOVED.
Read full bulletin
THE TRANSMISSION GEAR SHIFT LEVER DOES NOT HOLD FIRMLY TO THE LEFT OF THE SHIFT GAGE AS EXPECTED. *PE
REQUIRED AUTOMATIC TRANSMISSION CONTROL MODULE INITIALIZATION PROCEDURE.
Read full bulletin
MY 2004-2008 FORENZ SEDAN/WAGON, RENO (RQ420). *NJ
DTC P0703 EXPLAINED. AUTOMATIC TRANSMISSION DTC P0703 IS PRESENT.
Read full bulletin
ALL FORENZA MODELS. SUZUKI. *TT
Fuel System
3 bulletinsHARD TO FIND FUEL ODOR; DIAGNOSTIC INFORMATION.
Read full bulletin
*NJ
P0441 OR P0496 (EVAPORATIVE EMISSION SYSTEM CONTINUOUS PURGE FLOW).
Read full bulletin
*NJ
NO FUEL PUMP PRIME BEFORE START UP.
Read full bulletin
*KB
Software & Calibration
2 bulletinsTHIS SERVICE BULLETIN UPDATES A BULLETIN ORIGINALLY ISSUED ON MAY 18, 2016, CONCERNING A SPECIAL WARRANTY EXTENSION (ZH)...
Read full bulletin
FOR 2005-2008 SUZUKI FORENZA AND SUZUKI RENO VEHICLES. THE UPDATES ARE: (1) THE EXISTENCE OF DIAGNOSTIC TROUBLE CODE (DTC) B1379 IS ADDED TO THE LIST OF DTCS THAT MAKE A VEHICLE ELIGIBLE FOR REPAIR UNDER SPECIAL WARRANTY EXTENSION ZH; AND (2) THE PROCEDURE FOR INSPECTING THE SEAT HEIGHT ADJUSTER FOR DAMAGE HAS BEEN CLARIFIED.
SERVICE MANUAL UPDATE, DTC P2106 THROTTLE ACTUATOR CONTROL (TAC) SYSTEM PERFORMANCE.
Read full bulletin
THROTTLE LIMITATION
Suspension
1 bulletinReminder of the importance to conduct safety inspections for rust damage to suspension and related parts that could be...
Read full bulletin
caused by road salt or other chemicals applied to the roadway.
Other
1 bulletinSUZUKI: SUZUKI HAS REPLACEMENT OIL PUMPS THAT HAVE A THREADED PLUG.
Read full bulletin
THE THREADED PROVES TO BE DIFFICULT TO REMOVE WITHOUT CAUSING DAMAGE TO THE NEW OIL PUMP. THIS BULLETIN PROVIDES PROCEDURES WHEN REPLACING THE OLD OIL PUMP. *JS
Air Bags & Safety
1 bulletinAIRBAG LIGHT ON; DTC B1378 (DRIVER SIDE AIRBAG RESISTANCE TOO HIGH) AND/OR DTC B1382 (PASSENGER SIDE AIRBAG RESISTANCE TOO HIGH).
Read full bulletin
FORENZA, SEDAN/WAGON, RENO (RQ420) 2005-2006. VIN(S) -6K425022. *NJ