2005 Suzuki Forenza TSBs
20 Technical Service Bulletins across 10 categories
Categories
Transmission
4 bulletinsSUZUKI VEHICLES: AUTOMATIC TRANSMISSION SHIFT LEVER IS LOOSE IN THE SHIFT GATE AND/OR IGNITION KEY CANNOT BE REMOVED.
Read full bulletin
THE TRANSMISSION GEAR SHIFT LEVER DOES NOT HOLD FIRMLY TO THE LEFT OF THE SHIFT GAGE AS EXPECTED. *PE
REQUIRED AUTOMATIC TRANSMISSION CONTROL MODULE INITIALIZATION PROCEDURE.
Read full bulletin
MY 2004-2008 FORENZ SEDAN/WAGON, RENO (RQ420). *NJ
DTC P0703 EXPLAINED. AUTOMATIC TRANSMISSION DTC P0703 IS PRESENT.
Read full bulletin
ALL FORENZA MODELS. SUZUKI. *TT
HARSH 4TH TO 3RD AUTOMATIC DOWNSHIFT AND UNWANTED P1884 DTC.
Read full bulletin
2004 SUZUKI RENO-RQ420 *SC
Engine
3 bulletinsThis Service Bulletin was sent by Suzuki Motor Corporation to its authorized Suzuki automobile distributors in the U.S.,...
Read full bulletin
explaining the importance of proper inspection and maintenance of suspension lower arm ball joints to prevent the ball stud from becoming separated from the suspension lower arm.
OIL LEAK FROM DRAIN PLUG.
Read full bulletin
*TT
VEHICLES WITH MANUAL TRANSMISSION MAY EXHIBIT A HIGH IDLE (2000+R.P.M.) FOR UP TO TEN SECONDS WHEN COMING TO A STOP WITH THE CLUTCH RELEASED.
Read full bulletin
*TT
Air Bags & Safety
3 bulletinsAIRBAG LIGHT ON; DTC B1378 (DRIVER SIDE AIRBAG RESISTANCE TOO HIGH) AND/OR DTC B1382 (PASSENGER SIDE AIRBAG RESISTANCE TOO HIGH).
Read full bulletin
FORENZA, SEDAN/WAGON, RENO (RQ420) 2005-2006. VIN(S) -6K425022. *NJ
PASSENGER AIR BAG SENSING SYSTEM.
Read full bulletin
PASSENGER AIR BAG OFF LIGHT ON WHEN IF SHOULD BE OFF. *TT
PASSENGER AIR BAG SENSING SYSTEM.
Read full bulletin
PASSENGER AIR BAG OFF LIGHT ON WHEN IF SHOULD BE OFF. *TT
Suspension
2 bulletinsReminder of the importance to conduct safety inspections for rust damage to suspension and related parts that could be...
Read full bulletin
caused by road salt or other chemicals applied to the roadway.
NOISE FROM THE FRONT STABILIZER BAR BUSHINGS.
Read full bulletin
2004-2005 SUZUKI/FORENZA SEDAN/WAGON AND RENO. *SC
Electrical
2 bulletinsEVAPORATIVE EMISSION SYSTEM CONTINUOUS PURGE FLOW.
Read full bulletin
ECM SOFTWARE COULD CAUSE UNNECESSARY ILLUMINATION OF THE MALFUNCTION INDICATOR LAMP. SUZUKI. *KB
WIRE HARNESS INSULATION DAMAGE BEHIND THE LEFT FRONT FENDER LINER.
Read full bulletin
*TT
Body & Paint
2 bulletinsDRIVER DOOR LOCK TUMBLER FALLS INTO DOOR WHEN THE KEY IS INSERTED.
Read full bulletin
2004-2005 SUZUKI FORENZA SEDAN/WAGON AND RENO-RQ420. *SC
DRIVER DOOR LOCK TUMBLER FALLS INTO DOOR WHEN THE KEY IS INSERTED.
Read full bulletin
*EH
Software & Calibration
1 bulletinTHIS SERVICE BULLETIN UPDATES A BULLETIN ORIGINALLY ISSUED ON MAY 18, 2016, CONCERNING A SPECIAL WARRANTY EXTENSION (ZH)...
Read full bulletin
FOR 2005-2008 SUZUKI FORENZA AND SUZUKI RENO VEHICLES. THE UPDATES ARE: (1) THE EXISTENCE OF DIAGNOSTIC TROUBLE CODE (DTC) B1379 IS ADDED TO THE LIST OF DTCS THAT MAKE A VEHICLE ELIGIBLE FOR REPAIR UNDER SPECIAL WARRANTY EXTENSION ZH; AND (2) THE PROCEDURE FOR INSPECTING THE SEAT HEIGHT ADJUSTER FOR DAMAGE HAS BEEN CLARIFIED.
Other
1 bulletinSUZUKI: SUZUKI HAS REPLACEMENT OIL PUMPS THAT HAVE A THREADED PLUG.
Read full bulletin
THE THREADED PROVES TO BE DIFFICULT TO REMOVE WITHOUT CAUSING DAMAGE TO THE NEW OIL PUMP. THIS BULLETIN PROVIDES PROCEDURES WHEN REPLACING THE OLD OIL PUMP. *JS
Fuel System
1 bulletinP0441 OR P0496 (EVAPORATIVE EMISSION SYSTEM CONTINUOUS PURGE FLOW).
Read full bulletin
*NJ
Pre-Delivery & Maintenance
1 bulletinCUSTOMER SATISFACTION CAMPAIGN WATER PUMP PULLEY INSPECTION.
Read full bulletin
*KB