2013 Subaru Forester TSBs

engines.

(SOA) has determined that a defect, which relates to motor vehicle safety, exists on certain 2005-2009 model year Subaru Legacy and Outback vehicles, 2009- 2013 Subaru Forester vehicles, 2008-2011 Subaru Impreza, WRX, and STI vehicles, and 2012-2014 Subaru WRX and STI vehicles currently or formerly registered in at least one of the salt-belt states listed below or in the District of Columbia. Part numbers in the bulletin has been updated.

on FA and FB type engines.

has determined that a defect, which relates to motor vehicle safety, exists in certain 2003-2014 model year Legacy and Outback vehicles, 2003-2006 model year Baja vehicles, 2009-2013 model year Forester vehicles, 2004-2011 model year Impreza vehicles, and 2004- 2014 WRX (including STI) vehicles equipped with a non-desiccated Takata-sourced passenger-side frontal air bag containing the propellant Phase Stabilized Ammonium Nitrate (PSAN).

from the timing chain cover, front camshaft cap, camshaft carrier and / or upper oil pan.

from the timing chain cover, front camshaft cap, camshaft carrier and / or upper oil pan.

type engines.

(Subaru) is recalling 100,127 vehicles including certain 2007-2009 model year Legacy and Outback (turbo models only), 2008-2014 model year Impreza (turbo models only) and 2009-2013 model year Forester (turbo models only) vehicles to replace the secondary air pump relay.

is initiating a program to extend the original New Car Powertrain Limited Warranty coverage for excessive engine oil consumption on applicable vehicles to 8 years / 100,000 miles from the original warranty start date.

is initiating a program to extend the original New Car Powertrain Limited Warranty coverage for excessive engine oil consumption on applicable vehicles to 8 years / 100,000 miles from the original warranty start date.

is initiating a program to extend the original New Car Powertrain Limited Warranty coverage for excessive engine oil consumption on applicable vehicles to 8 years / 100,000 miles from the original warranty start date.

is initiating a program to extend the original New Car Powertrain Limited Warranty coverage for excessive engine oil consumption on applicable vehicles to 8 years / 100,000 miles from the original warranty start date.

from the timing chain cover, front camshaft cap, camshaft carrier, and/or upper oil pan.

-related DTCs on the FA and FB engine equipped models listed above. The applicable Service Manuals will be revised with this new information in the near future.

Forester Turbo and applicable WRX models.

has determined that a defect, which relates to motor vehicle safety, exists in certain 2003-2014 model year Legacy and Outback vehicles, 2003-2006 model year Baja vehicles, 2009-2013 model year Forester vehicles, 2004-2011 model year Impreza vehicles, and 2004-2014 WRX (including STI) vehicles equipped with a non-desiccated Takata-sourced passenger-side frontal air bag containing the propellant Phase Stabilized Ammonium Nitrate (PSAN).

has determined that a defect, which relates to motor vehicle safety, exists in certain 2003-2014 model year Legacy and Outback vehicles, 2003-2006 model year Baja vehicles, 2009-2013 model year Forester vehicles, 2004-2011 model year Impreza vehicles, and 2004- 2014 WRX (including STI) vehicles equipped with a non-desiccated Takata-sourced passenger-side frontal air bag containing the propellant Phase Stabilized Ammonium Nitrate (PSAN).

from the timing chain cover, front camshaft cap, camshaft carrier and / or upper oil pan. There are five areas that should be closely inspected if an oil leak is reported by the customer: 1. The 6mm tapped hole casting boss area in the left-hand camshaft cap 2. The sealing surfaces between either the left or right-hand camshaft cap and camshaft carrier 3. The sealing surfaces between the cylinder head and camshaft carrier 4. The sealing surface between the upper oil pan and the engine block 5. The sealing surfaces of the front timing chain cover

-related DTCs on the FA and FB engine equipped models listed above. The applicable Service Manuals will be revised with this new information in the near future.

has determined that a defect, which relates to motor vehicle safety, exists in certain Subaru vehicles listed above, equipped with a non-desiccated Takata-sourced passenger side frontal airbag containing the propellant Phase Stabilized Ammonium Nitrate (PSAN).

-related DTCs on the FA and FB engine equipped models listed above. The applicable Service Manuals will be revised with this new information in the near future.

which contain a redesigned internal oil seal. The new seal will eliminate potential oil seepage into the wire harness connector portion of the valve. If oil seeps into the connector, over time, the Check Engine lamp may illuminate and set various AVCS-related DTCs.

has determined that a defect, which relates to motor vehicle safety, exists in certain Subaru vehicles listed above, equipped with a non-desiccated Takata-sourced passenger side frontal airbag containing the propellant Phase Stabilized Ammonium Nitrate (PSAN).

The new springs have different color paint marks to help identify their application.

has determined that a defect, which relates to motor vehicle safety, exists in certain Subaru vehicles listed above, equipped with a non-desiccated Takata-sourced passenger side frontal airbag containing the propellant Phase Stabilized Ammonium Nitrate (PSAN). This phase of the Takata recall expansion includes all remaining vehicles equipped with a non-desciccated Takata-sourced passenger side frontal air bag containing the propellant PSAN. Recall Codes TKA-19-TKB-19-TKC-19

assembly line efficiency and increase durability. In some cases, the Check Engine light may illuminate and a knock sensor-related DTC set in the ECM memory: P0327, P0328, P0332 and P0333. The knock sensor for DIT engines is now utilized for NA engines to improve durability and resistance to heat.

Return Policy (See Parts Policy & Procedures Manual ? Section 12.3 Core Returns ? Reman) and provide suggestions for removal and handling of the short block.

is initiating a program to extend the original New Car Powertrain Limited Warranty coverage for excessive engine oilconsumption on applicable vehicles to 8 years / 100,000 miles from the original warranty start date.This Warranty Extension will not cover any excessive engine oil consumption found to be a result ofany condition(s) other than those specifically described in this bulletin.This condition must be verified during an inspection and when determined necessary, an oil consumption test performed by an authorized Subaru retailer. SOA will inform vehicle owners this condition may exist via a customer letter.

assembly to determine whether or not replacement is necessary. Read through and understand this information completely before proceeding with any repairs to the cylinder block. All Models with FA and FB Engines, 2011MY and Later.

to the full right or left position when the vehicle is parked, it may be caused by the relief valve vibrating within the pump. In lieu of replacing the power steering pump, the relief valve is now available as a replacement part.

Recently SOA has become aware of some retailer questions regarding the VIN breakpoint information supplied as part of the class action notice.

is initiating a program to extend the original New Car Powertrain Limited Warranty coverage for excessive engine oil consumption on applicable vehicles to 8 years / 100,000 miles from the original warranty start date.

is initiating a program to extend the original New Car Powertrain Limited Warranty coverage for excessive engine oil consumption on applicable vehicles to 8 years / 100,000 miles from the original warranty start date.

This seepage may accumulate along the bottom sealing surface of the rocker cover. The new o-ring utilizes material which has an increased resistance to engine heat.

?AVCS Slow Response? or ?AVCS System Failure? DTCs listed above are found to be stored in the ECM memory. A possible cause of these conditions is contamination within the camshaft sprocket and / or oil control solenoid valve (OCV) mechanism.

This seepage may accumulate along the bottom sealing surface of the rocker cover. The new o-ring utilizes material which has an increased resistance to engine heat.

customer concerns of the green Hill Holder light blinking and cancel warning alarm sounding during cranking / starting the engine

Forester (Manual Transmissions Only), with 2.5L FB Engines, 2012-13 MY Impreza and XV Crosstrek Models with 2.0 FB Engines, 2014-15 MY Impreza and XV Crosstrek Models (Manual Transmissions Only) with 2.0 FB Engine As part of our dedication to customer satisfaction, Subaru of America, Inc. is initiating a program to extend the original New Car Powertrain Limited Warranty coverage for excessive engine oil consumption on applicable vehicles to 8 years / 100,000 miles from the original warranty start date. This Warranty Extension will not cover any excessive engine oil consumption found to be a result of any condition(s) other than those specifically described in this bulletin

As part of our dedication to customer satisfaction, Subaru of America, Inc. is initiating a program to extend the original New Car Powertrain Limited Warranty coverage for excessive engine oil consumption on applicable vehicles to 8 years / 100,000 miles from the original warranty start date. This Warranty Extension will not cover any excessive engine oil consumption found to be a result of any condition(s) other than those specifically described in this bulletin. This condition must be verified during an inspection and when determined necessary, an oil consumption test performed by an authorized Subaru retailer. SOA will inform vehicle owners this condition may exist via a customer letter. For vehicles within the coverage guidelines listed in this bulletin, customers can schedule an inspection appointment with an authorized Subaru retailer. IMPORTANT: ALWAYS perform a Vehicle Coverage Inquiry on Subarunet to determine eligibility for this Warranty Extension before proceeding. The VIN should also be checked for any open campaigns or recalls at this time.

Forester (Manual Transmissions Only) with 2.5L FB Engines - 2012-13 MY Impreza and XV Crosstrek Models with 2.0 FB Engines - 2014-15 MY Impreza and XV Crosstrek Models (Manual Transmissions Only) with 2.0 FB Engines. As part of our dedication to customer satisfaction, Subaru of America, Inc. is initiating a program to extend the original New Car Powertrain Limited Warranty coverage for excessive engine oil consumption on applicable vehicles to 8 years / 100,000 miles from the original warranty start date. This Warranty Extension will not cover any excessive engine oil consumption found to be a result of any condition(s) other than those specifically described in this bulletin. This condition must be verified during an inspection and when determined necessary, an oil consumption test performed by an authorized Subaru retailer. SOA will inform vehicle owners this condition may exist via a customer letter. For vehicles within the coverage guidelines listed in this bulletin, customers can schedule an inspection appointment with an authorized Subaru retailer.

Due to circumstances beyond the control of Subaru of America, Inc. (SOA), the accessory Turbo Boost Gauge, p.n. H501SFG500 is no longer available. In the interest of customer satisfaction, SOA will address customer concerns involving a failure of the gauge by returning the vehicle to it?s OEM configuration.

regarding a major change to the repair procedures previously outlined in Service Bulletins 02-143-13R, 02-144-13R and 02-145-13R.

customer concerns of a slipping belt (squeal or chirping) sound.

There have been isolated cases where the sealer used between the upper oil pan and the crankcase has become displaced resulting in engine oil seepage. Revisions made to the upper oil pan casting: * The mating flange thickness of the casting in the area identified as the cause for the seepage has been increased by 5.5mm. (See images provided in the Parts Information section below.) This thickness increase creates the need for a longer bolt to provide proper tightening and retention. * An additional mounting point has been added to the ribbing inside the casting to increase retention of the steel baffle plate and eliminate vibration.

There have been isolated cases where the sealer used between the upper oil pan and the crankcase has become displaced resulting in engine oil seepage.

BULLETINS 02-143-13R, 02-144-13R AND 02-145-13R. THESE BULLETINS PROVIDED A REPAIR PROCEDURE FOR THE REPLACEMENT OF THE PISTON RINGS TO ADDRESS VERIFIED CONCERNS OF UNUSUAL ENGINE OIL CONSUMPTION. VEHICLES CONFIRMED AS HAVING THIS CONDITION WHICH ARE WITHIN THE SUPPLIED VIN RANGES WILL NO LONGER BE REPAIRED WITH PISTON RING REPLACEMENT. THE REVISED REPAIR PROCEDURE TO ADDRESS VERIFIED UNUSUAL OIL CONSUMPTION CONCERNS ON THESE SPECIFIC VEHICLES WILL CONSIST OF REPLACING THE ENGINE SHORT BLOCK ASSEMBLY.

FROM THE TIMING CHAIN COVER, FRONT CAMSHAFT CAP, CAMSHAFT CARRIER AND / OR UPPER OIL PAN.

THE CHANGE WAS MADE AS A RESULT OF SOME LIMITED FINDINGS OF UNANTICIPATED WEAR OF THESE RINGS. OIL CONSUMPTION WILL BE HIGHER THAN NORMAL AND CONSISTENT, IF THIS WEAR OCCURS, THE CONDITION REMAINS UNTIL REPAIR. UNUSUAL SWINGS OR VARIATIONS IN OIL CONSUMPTION ARE NOT CONSISTENT WITH THIS CONDITION AND MAY BE THE RESULT OF VEHICLE USAGE RATHER THAN THE CONDITION DESCRIBED HERE. ADDITIONAL INFORMATION IS SUPPLIED IN THIS BULLETIN TO ASSIST IN THE ASSESSMENT AND DETERMINATION IF VEHICLE USAGE IS A REASON FOR THIS VARIED OIL CONSUMPTION.

BULLETINS 02-143-13R, 02-144-13R AND 02-145-13R. THESE BULLETINS PROVIDED A REPAIR PROCEDURE FOR THE REPLACEMENT OF THE PISTON RINGS TO ADDRESS VERIFIED CONCERNS OF UNUSUAL ENGINE OIL CONSUMPTION. VEHICLES CONFIRMED AS HAVING THIS CONDITION WHICH ARE WITHIN THE SUPPLIED VIN RANGES WILL NO LONGER BE REPAIRED WITH PISTON RING REPLACEMENT. THE REVISED REPAIR PROCEDURE TO ADDRESS VERIFIED UNUSUAL OIL CONSUMPTION CONCERNS ON THESE SPECIFIC VEHICLES WILL CONSIST OF REPLACING THE ENGINE SHORT BLOCK ASSEMBLY.

BULLETINS 02-143-13R, 02-144-13R AND 02-145-13R. THESE BULLETINS PROVIDED A REPAIR PROCEDURE FOR THE REPLACEMENT OF THE PISTON RINGS TO ADDRESS VERIFIED CONCERNS OF UNUSUAL ENGINE OIL CONSUMPTION. VEHICLES CONFIRMED AS HAVING THIS CONDITION WHICH ARE WITHIN THE SUPPLIED VIN RANGES WILL NO LONGER BE REPAIRED WITH PISTON RING REPLACEMENT. THE REVISED REPAIR PROCEDURE TO ADDRESS VERIFIED UNUSUAL OIL CONSUMPTION CONCERNS ON THESE SPECIFIC VEHICLES WILL CONSIST OF REPLACING THE ENGINE SHORT BLOCK ASSEMBLY.

THIS DTC CAN RESULT FROM SPECIFIC CLUTCH OPERATION (ON MT MODELS) AND / OR DRIVING PATTERNS OCCURRING IMMEDIATELY AFTER STARTING THE ENGINE.

TURBOCHARGED VEHICLES SPECIFIED ABOVE.

IN THESE RARE CASES, AFTER AN EXTENDED COLD SOAK, COOLANT MAY ENTER THE THERMOSTATS INTERNAL PISTON. IF THIS OCCURS, THE THERMOSTAT MAY OPEN AT A TEMPERATURE WHICH IS LOWER THAN SPECIFIED AND CAUSE DTC P0128 TO BE STORED IN THE ECM MEMORY."

THE CHANGE WAS MADE AS A RESULT OF SOME LIMITED FINDINGS OF UNANTICIPATED WEAR OF THESE RINGS. OIL CONSUMPTION WILL BE HIGHER THAN NORMAL AND CONSISTENT, IF THIS WEAR OCCURS, THE CONDITION REMAINS UNTIL REPAIR. UNUSUAL SWINGS OR VARIATIONS IN OIL CONSUMPTION ARE NOT CONSISTENT WITH THIS CONDITION AND MAY BE THE RESULT OF VEHICLE USAGE RATHER THAN THE CONDITION DESCRIBED HERE. ADDITIONAL INFORMATION IS SUPPLIED IN THIS BULLETIN TO ASSIST IN THE ASSESSMENT AND DETERMINATION IF VEHICLE USAGE IS A REASON FOR THIS VARIED OIL CONSUMPTION."

BULLETINS 02-143-13R, 02-144-13R AND 02-145-13R. THESE BULLETINS PROVIDED A REPAIR PROCEDURE FOR THE REPLACEMENT OF THE PISTON RINGS TO ADDRESS VERIFIED CONCERNS OF UNUSUAL ENGINE OIL CONSUMPTION. VEHICLES CONFIRMED AS HAVING THIS CONDITION WHICH ARE WITHIN THE SUPPLIED VIN RANGES WILL NO LONGER BE REPAIRED WITH PISTON RING REPLACEMENT. THE REVISED REPAIR PROCEDURE TO ADDRESS VERIFIED UNUSUAL OIL CONSUMPTION CONCERNS ON THESE SPECIFIC VEHICLES WILL CONSIST OF REPLACING THE ENGINE SHORT BLOCK ASSEMBLY."

WHENEVER REPLACEMENT OF EITHER OF THESE COMPONENTS IS REQUIRED, THE IDENTIFICATION PROCEDURE PROVIDED BELOW MUST BE FOLLOWED TO INSURE THE PROPER PARTS ARE ORDERED AND INSTALLED AS A SET.

OF THE EVAPORATIVE LEAK CHECK MODULE (ELCM) BY THE ECM WHICH COULD SET DIAGNOSTIC TROUBLE CODE (DTC) P0451 IN ERROR. SOME EXAMPLES OF OTHER DTCS AFFECTED BY THIS HARNESS CHANGE ARE: P0068, P0452, P0453, P0107, P0108 AND P0300. THE CHANGE INVOLVES A REPOSITIONING OF THE SENSOR AND ACTUATOR WIRING GROUND JUNCTION POINT TO A LOCATION UNAFFECTED BY ENGINE MOVEMENT AND HIGH TEMPERATURES (NEAR TURBOCHARGER) WHICH MAY DEVELOP EXCESSIVE RESISTANCE. SINCE THIS CONDITION DEVELOPS OVER TIME, DTC(S) MAY SET VERY INTERMITTENTLY WITH LONG PERIODS OF TIME BETWEEN OCCURRENCES. A MORE FREQUENT OCCURRENCE OF ANY OF THESE DTC(S) MAY INDICATE A DIFFERENT ROOT CAUSE OTHER THAN THE CONDITION DESCRIBED IN THIS BULLETIN."

FROM THE TIMING CHAIN COVER, FRONT CAMSHAFT CAP, CAMSHAFT CARRIER AND / OR UPPER OIL PAN.

BULLETINS 02-143-13R, 02-144-13R AND 02-145-13R. THESE BULLETINS PROVIDED A REPAIR PROCEDURE FOR THE REPLACEMENT OF THE PISTON RINGS TO ADDRESS VERIFIED CONCERNS OF UNUSUAL ENGINE OIL CONSUMPTION. VEHICLES CONFIRMED AS HAVING THIS CONDITION WHICH ARE WITHIN THE SUPPLIED VIN RANGES WILL NO LONGER BE REPAIRED WITH PISTON RING REPLACEMENT. THE REVISED REPAIR PROCEDURE TO ADDRESS VERIFIED UNUSUAL OIL CONSUMPTION CONCERNS ON THESE SPECIFIC VEHICLES WILL CONSIST OF REPLACING THE ENGINE SHORT BLOCK ASSEMBLY."

BULLETINS 02-143-13R, 02-144-13R AND 02-145-13R. THESE BULLETINS PROVIDED A REPAIR PROCEDURE FOR THE REPLACEMENT OF THE PISTON RINGS TO ADDRESS VERIFIED CONCERNS OF UNUSUAL ENGINE OIL CONSUMPTION. THE PURPOSE OF REVISING THIS BULLETIN IS TO CORRECT THE TRANSMISSION TYPE.

BEFORE THE ENGINE STARTS.

MISFIRE DTCS FOR THE FA AND FB ENGINE-EQUIPPED MODELS LISTED ABOVE. THE CAMSHAFT POSITION SENSOR (CPS) CLEARANCE MAY BE OUT OF SPECIFICATION CAUSING THESE CONDITION(S) AND ONE OR MORE OF THE DTCS LISTED ABOVE TO SET. IN ADDITION TO A CHECK ENGINE LIGHT COMING ON, THERE MAY OR MAY NOT BE CUSTOMER CONCERNS OF ROUGH IDLE, EXTENDED CRANKING OR NO START.

UNANTICIPATED WEAR OF THESE RINGS.

P0301, P0302, P0303 OR P0304 - THIS BULLETIN PROVIDES INSPECTION AND REPAIR PROCEDURES FOR INTAKE AND EXHAUST CAMSHAFT POSITION-RELATED AND/OR ENGINE MISFIRE DTCS FOR THE FA AND FB ENGINE-EQUIPPED MODELS LISTED ABOVE."

MISFIRE DTCS FOR THE FA AND FB ENGINE-EQUIPPED MODELS LISTED ABOVE. THE CAMSHAFT POSITION SENSOR (CPS) CLEARANCE MAY BE OUT OF SPECIFICATION CAUSING THESE CONDITION(S) AND ONE OR MORE OF THE DTCS LISTED ABOVE TO SET. IN ADDITION TO A CHECK ENGINE LIGHT COMING ON, THERE MAY OR MAY NOT BE CUSTOMER CONCERNS OF ROUGH IDLE, EXTENDED CRANKING OR NO START.

UNANTICIPATED WEAR OF THESE RINGS.

CAUSED BY CAMSHAFT POSITIONING AT THE TIME THE ENGINE IS SHUT OFF.

MISFIRE DTCS FOR THE FA AND FB ENGINE-EQUIPPED MODELS LISTED ABOVE. THE CAMSHAFT POSITION SENSOR (CPS) CLEARANCE MAY BE OUT OF SPECIFICATION CAUSING THESE CONDITION(S) AND ONE OR MORE OF THE DTCS LISTED ABOVE TO SET. IN ADDITION TO A CHECK ENGINE LIGHT COMING ON, THERE MAY OR MAY NOT BE CUSTOMER CONCERNS OF ROUGH IDLE, EXTENDED CRANKING OR NO START.

ARTICLES REGARDING SUBARU OF AMERICA, INC. REACHING A PROPOSED SETTLEMENT IN A CLASS ACTION LAWSUIT FOR ALLEGED OIL CONSUMPTION CONCERNS ON CERTAIN SUBARU VEHICLES. SOME MEDIA OUTLETS ALSO SUPPLIED VARYING INFORMATION ON THE CONTENTS OF THIS SETTLEMENT. THE FOLLOWING INFORMATION IS BEING PROVIDED TO YOU, OUR RETAILERS, IN ADVANCE OF ANY CUSTOMER NOTIFICATION."

AVCS SLOW RESPONSE OR AVCS SYSTEM FAILURE DTCS LISTED ABOVE ARE FOUND TO BE STORED IN THE ECM MEMORY. A POSSIBLE CAUSE OF THESE CONDITIONS IS CONTAMINATION WITHIN THE CAMSHAFT SPROCKET AND / OR OIL CONTROL SOLENOID VALVE (OCV) MECHANISM.

BULLETINS 02-143-13R, 02-144-13R AND 02-145-13R. THESE BULLETINS PROVIDED A REPAIR PROCEDURE FOR THE REPLACEMENT OF THE PISTON RINGS TO ADDRESS VERIFIED CONCERNS OF UNUSUAL ENGINE OIL CONSUMPTION. THE PURPOSE OF REVISING THIS BULLETIN IS TO CORRECT THE TRANSMISSION TYPE.

FROM THE TIMING CHAIN COVER, FRONT CAMSHAFT CAP, CAMSHAFT CARRIER AND / OR UPPER OIL PAN.

REGARDING A MAJOR CHANGE TO THE REPAIR PROCEDURES PREVIOUSLY OUTLINED IN SERVICE BULLETINS 02-143-13R, 02-144-13R AND 02-145-13R.

BEFORE THE ENGINE STARTS.

REGARDING A MAJOR CHANGE TO THE REPAIR PROCEDURES PREVIOUSLY OUTLINED IN SERVICE BULLETINS 02-143-13R, 02-144-13R AND 02-145-13R.

THIS IS CAUSED BY AN IRREGULAR STAMPING OF THE CAMSHAFT POSITION SENSOR PLATE. TO REMEDY THE CONDITION, A SHIM WILL NEED TO BE ADDED TO THE BANK 1 (RIGHT HAND) CAMSHAFT POSITION SENSOR TO BRING THE AIR GAP INTO SPECIFICATION. NOTE: DTCS P0341 AND P0346 ARE APPLICABLE TO 2013MY VEHICLES ONLY.

SEPARATES FROM DUCT AND LEAKS BOOST PRESSURE, LOSS OF POWER AND INCREASED SOUND LEVELS OCCURS. MODEL 2005-12 LEGACY, OUTBACK TURBO, 2009-13 FORESTER TURBO, 2008-14 IMPREZA WRX. *PE

(DTC) P050A RESULTED FROM SPECIFIC CLUTCH OPERATIONS AND/OR DRIVING PATTERNS AFTER STARTING ENGINE. MODEL 2011-2013 LEGACY, FORESTER, IMPREZA. *PE

THIS BULLETIN CONTAINS THE INSPECTION AND REPAIR. *JS UPDATED 11/18/14. *PE

TO START AND NEED A SHIM ADDED TO BANK 1 CAMSHAFT POSITION SENSOR TO HAVE AIR GAP IN SPECIFICATION. MODEL 2011-2013 FORESTER. *PE

proper exchange procedure.

202 and / or 204 may occur preventing the process from completing successfully.

the operation of their Gen 2/Gen 3 Telematics system equipped Subaru.

proper exchange procedure.

vehicle's production.

Subaru Lock Information web-site.

retailers of the SOA321152 and SOA321153 Terminal Test Kits.

preventing the process from completing successfully.

impacts the way some vehicles with accessories are sold. This regulation applies to any automobile retailer installing accessories on a vehicle prior to its first sale.

proper exchange procedure.

proper exchange procedure for 2025MY vehicles.

Subaru Lock Information web-site.

Subaru Lock Information web-site.

proper exchange procedure.

track assembliesd.

track assemblies used on the models listed.

Subaru Lock Information web-site.

This procedure must be used in place of tonneau cover assembly replacement for stopper failure. Replacing the complete tonneau cover assembly due to a stopper failure is no longer an accepted repair.

Subaru Lock Information web-site.

Subaru Lock Information web-site.

THE PURPOSE OF REVISING THIS BULLETIN WAS TO CORRECT THE TRIBECA REAR SEAT DVD UNIT PART NUMBERS.

(Immobilizer Key Collation Diagnosis).

center.

models.

February.

models.

models.

models.

models.

Information System (STIS) web site.

models

(SOA) has developed the following cross reference list to help locate the appropriate Special Service Tool.

Technical Information System (STIS) web site.

Technical Information System (STIS) web site.

Technical Information System (STIS) web site.

(SOA) has developed the following cross reference list to help locate the appropriate Special Service Tool.

Technical Information System (STIS) web site. The tables contained within this bulletin are to be used as guides for becoming aware of the latest changes. We advise you to always refer to the STIS web site when looking for the latest Service information.

Technical Information System (STIS) web site. The tables contained within this bulletin are to be used as guides for becoming aware of the latest changes.

The exchange program policy can also be found in Sections 8.4.9 and 11.2.10 of your Service Policies and Procedures Manual found in subarunet.

to increase durability

MANUALS AVAILABLE VIA THE SUBARU TECHNICAL INFORMATION SYSTEM (STIS) WEB SITE.

BUT DO NOT HAVE THE ORIGINAL MATS THAT WERE IN THE VEHICLE AT THE TIME OF SALE. IN MOST CASES, THE CUSTOMERS HAVE STATED THAT THEY HAVE DISCARDED OR DESTROYED THE MATS. IN OTHER INSTANCES, THE CUSTOMERS INDICATED THAT THEIR VEHICLE DID NOT HAVE THE MATS WHEN THEY PURCHASED THE VEHICLE. IF, OR WHEN, THIS SITUATION ARISES, PLEASE FILL OUT THE ATTACHED FORM AND HAVE THE CUSTOMER SIGN IT AND RETAIN THE SIGNED FORM WITH THE REPAIR ORDER. IF YOU HAVE ANY QUESTIONS, PLEASE CONTACT THE CLAIMS HELPLINE AT 866-782-2782."

THE EXCHANGE PROGRAM POLICY CAN ALSO BE FOUND IN SECTIONS 8.4.9 AND 11.2.10 OF YOUR SERVICE POLICIES AND PROCEDURES MANUAL FOUND IN SUBARUNET.

TECHNICAL INFORMATION SYSTEM (STIS) WEB SITE.

THE EXCHANGE PROGRAM POLICY CAN ALSO BE FOUND IN SECTIONS 8.4.9 AND 11.2.10 OF YOUR SERVICE POLICIES AND PROCEDURES MANUAL FOUND IN SUBARUNET. 2013MY SUBARU VEHICLES

Infotainment concerns.

The update will take place in multiple batches with the first beginneing November 15th and the last being Decemeber 3rd. This update is for approximatelt 714,000 VINs.

1.5.

Inprovement for CarPlay concerns with hands-free calls when the receiving party is not able to hear the caller.

repair of the Infotainment concerns. (Applicable to all models with Harman or Denso CP1 Infotainment).

This bulletin announces a new procedure for updating the operating software used in F10 Gen1 audio / navigation systems. This new procedure eliminates the need to exchange the head unit / SD card to obtain software-related updates and operating enhancements.

This new procedure eliminates the need to exchange the head unit / SD card to obtain software-related updates and operating enhancements. All 2012 to 2015 Models Equipped with FujitsuTen (F10) Generation 1 (Gen1) Audio / Navigation Systems

INVOLVING THE PAIRING AND USE OF CELLULAR PHONES WITH CLARION AUDIO UNITS. THIS INCLUDES CUSTOMER CONCERNS WHERE THE PHONE WILL NOT AUTOMATICALLY PAIR ITSELF BUT INSTEAD REQUIRES MANUAL PHONE SELECTION ON THE AUDIO UNIT TO ALLOW PAIRING TO PROCEED.

INVOLVING THE PAIRING AND USE OF CELLULAR PHONES WITH CLARION AUDIO UNITS. THIS INCLUDES CUSTOMER CONCERNS WHERE THE PHONE WILL NOT AUTOMATICALLY PAIR ITSELF BUT INSTEAD REQUIRES MANUAL PHONE SELECTION ON THE AUDIO UNIT TO ALLOW PAIRING TO PROCEED.

WHEN USING THE F10 AUDIO / NAVIGATION SYSTEM. WE WILL CONTINUE TO ADD MORE HELPFUL TIPS TO THIS TSB AS INFORMATION IS RECEIVED FROM F10.

THIS NEW PROCEDURE ELIMINATES THE NEED TO EXCHANGE THE HEAD UNIT / SD CARD TO OBTAIN SOFTWARE-RELATED UPDATES AND OPERATING ENHANCEMENTS. ALL 2012 TO 2015 MODELS EQUIPPED WITH FUJITSUTEN (F10) GENERATION 1 (GEN1) AUDIO / NAVIGATION SYSTEMS

THIS NEW PROCEDURE ELIMINATES THE NEED TO EXCHANGE THE HEAD UNIT / SD CARD TO OBTAIN SOFTWARE-RELATED UPDATES AND OPERATING ENHANCEMENTS. ALL 2012 TO 2015 MODELS EQUIPPED WITH FUJITSUTEN (F10) GENERATION 1 (GEN1) AUDIO / NAVIGATION SYSTEMS

WHEN USING THE F10 AUDIO / NAVIGATION SYSTEM.

AVAILABLE Q3 2012.

in vehicles experiencing battery drain when the ignition is off, leading to no-start conditions or frequent jump-starts.

Battery Diagnostic tool.

Telematics which are enrolled in the Subaru STARLINK Security Plus Service featuring Stolen Vehicle Recovery Plus with Immobilizer.

Module (DCM) is being tested as a dark current/standby current source.

a dark current/standby current source. All models equipped with Telematics except Solterra.

(Subaru) is recalling certain vehicles in the ranges listed below to inspect and potentially replace the ignition switch. A total of 511 U.S. vehicles will be affected by this recall.

(Subaru) is recalling certain vehicles in the ranges listed below to inspect and potentially replace the ignition switch. A total of 511 U.S. vehicles will be affected by this recall.

(Subaru) is recalling certain vehicles in the ranges listed below to inspect and potentially replace the ignition switch. A total of 511 U.S. vehicles will be affected by this recall.

Both of these relays are located on the back (front facing) side of the passenger compartment fuse box (F/B).

AVCS SLOW RESPONSE OR AVCS SYSTEM FAILURE DTCS LISTED ABOVE ARE FOUND TO BE STORED IN THE ECM MEMORY.

PROVIDES BETTER SEALING AND RESISTANCE TO INTRUSION OF MOISTURE THAT CAN COMPROMISE ELECTRICAL CONNECTION, AND MAY BE IN SOME CASES, CAUSE OIL PRESSURE LAMP TO ILLUMINATE. MODEL 2012-2013 IMPREZA,2011-2013 FORESTER. *PE

involve applying additional anti-corrosion material to the four-way (2-2 way) joint connector area of the brake line system on Forester, Impreza, WRX, and STI vehicles previously repaired under the WQK-47 (14V-311) brake line corrosion recall prior tothe December 23, 2014 WQK-47 recall bulletin revision."

applying additional anti-corrosion material to the four-way (2-2 way) joint connector area of the brake line system on Forester, Impreza, WRX, and STI vehicles previously repaired under the WQK-47 (14V-311) brake line corrosion recall prior to the December 23, 2014 WQK-47 recall bulletin revision. The revisions to the bulletin are for part number changes.

This information has been developed to reduce unnecessary brake caliper replacement.

customer concerns of a squeaking or squealing sound on the models listed above.

Under certain circumstances, some customers may have a concern regarding a howling-type sound from the rear of the vehicle later diagnosed as a faulty hub / bearing assembly. Unevenness of the backing plate surfaces may affect the concentricity (roundness) of the hub / bearing after torqued during assembly and over time, cause the howling -type sound to develop. Production changes for the backing plates have been implemented to optimize their mounting surface quality.

This will prevent the pad from dragging due to corrosion buildup which may result in uneven or premature wear of the replacement brake pads. This additional instruction applies to all models with brake pads using the upper and lower pad clips and has been added to the brake pad installation procedures found in the related Service Manuals.

(Subaru) is recalling certain Crosstrek, Forester, Impreza, and WRX vehicles to replace the brake lamp switch. A total of 1,303,530 U.S. vehicles will be affected by this recall.

customer concerns of a squeaking or squealing sound on the models listed. The new shims incorporate a new laminated design with increased damping characteristics to eliminate vibration identified as the root cause of the sound. The new kits include shims only (NO brake pads).

PROCEDURE FOR THE WQK-47 BRAKE LINE CORROSION RECALL.

THE IMPREZA, WRX, STI, AND FORESTER REPAIR PROCEDURE FOR THE WQK-47 BRAKE LINE CORROSION RECALL.

interface firmware has been updated.

will release an OTA to perform a software update to the DCM. This is a preventive OTA.

Technical Information System (STIS) web site. The tables contained within this bulletin are to be used as guides for becoming aware of the latest changes. We advise you to always refer to the STIS web site when looking for the latest Service information. Printed pages will not be made available to update printed Service Manuals.

Technical Information System (STIS) web site. The tables contained within this bulletin are to be used as guides for becoming aware of the latest changes. We advise you to always refer to the STIS web site when looking for the latest Service information. Printed pages will not be made available to update printed Service Manuals.

TECHNICAL INFORMATION SYSTEM (STIS) WEB SITE. THE TABLES CONTAINED WITHIN THIS BULLETIN ARE TO BE USED AS GUIDES FOR BECOMING AWARE OF THE LATEST CHANGES. WE ADVISE YOU TO ALWAYS REFER TO THE STIS WEB SITE WHEN LOOKING FOR THE LATEST SERVICE INFORMATION. PRINTED PAGES WILL NOT BE MADE AVAILABLE TO UPDATE PRINTED SERVICE MANUALS.

TECHNICAL INFORMATION SYSTEM (STIS) WEB SITE. THE TABLES CONTAINED WITHIN THIS BULLETIN ARE TO BE USED AS GUIDES FOR BECOMING AWARE OF THE LATEST CHANGES. WE ADVISE YOU TO ALWAYS REFER TO THE STIS WEB SITE WHEN LOOKING FOR THE LATEST SERVICE INFORMATION. PRINTED PAGES WILL NOT BE MADE AVAILABLE TO UPDATE PRINTED SERVICE MANUALS. PAPER MANUALS MAY HAVE DIFFERENT PAGE NUMBERING THEN WHAT IS REFLECTED BELOW, BASED ON MULTIPLE NEW AND REVISED PAGES. PLEASE REFER TO THE INFORMATION CONTAINED ON THE STI WEB SITE FOR ALL FUTURE, UPDATE SERVICE MANUAL INFORMATION."

WATER ACCUMULATION AND NEW REPLACEMENT IS DOUBLE THICK TEFLON COATING. MODEL 2009-13 FORESTER AT, 20089-11 IMPREZA AT. *PE UPDATED 08/05/2015 *LJ

retailer-installed accessory exeeds 1.5 percent of the GVWR or 100 pounds, which ever is lower.

combination lamps, where moisture and or condensation may develop on the inside of the lamp lenses.

Owners with a valid email address on file will also be notified by email. Subaru retailers with affected vehicles will receive an affected VIN list from their Zone Office prior to owner notification. Service, Parts, and Claim Instructions Detailed service, parts, and claim information is available in the WUF-91 Product Campaign Bulletin on STIS. A copy of the owner notification is included at the end of the bulletin.

An improperly adjusted (or faulty) stop lamp switch can cause any of the DTCs listed to set and result in the related system?s (e. g. VDC and/or EyeSight) warning lamp to illuminate.

on how to obtain immobilizer codes and key cut codes for Subaru vehicles from the 2000MY to present. This bulletin identifies the equipment required to initialize (reset) the immobilizer code and cut the key blanks, for both immobilizer and non-immobilizer type keys. Subaru of America began using immobilizer systems in some 2005MY vehicles (please refer to Immobilizer Chart for more detailed information).

An improperly adjusted (or faulty) stop lamp switch can cause any of the DTCs listed above to set and result in the related system?s (e. g. VDC and/or EyeSight) warning lamp to illuminate.

NICKEL PLATING HAS BEEN APPLIED TO THE INTERNAL SWITCH CONTACTS TO ENHANCE THEIR DURABILITY AND REDUCE THE POSSIBILITY OF POOR CONTACT WHICH COULD AFFECT OPERATION OR CAUSE IMPROPER ILLUMINATION OF THE OIL PRESSURE WARNING LAMP. A SMALL PILOT PORTION WAS ADDED TO THE THREADED AREA ON P.N. 25240KA051 AS SHOWN IN THE ILLUSTRATION BELOW. REVISED PRODUCTION CHANGE INFORMATION."

NICKEL PLATING HAS BEEN APPLIED TO THE INTERNAL SWITCH CONTACTS TO ENHANCE THEIR DURABILITY AND REDUCE THE POSSIBILITY OF POOR CONTACT WHICH COULD AFFECT OPERATION OR CAUSE IMPROPER ILLUMINATION OF THE OIL PRESSURE WARNING LAMP. A SMALL PILOT PORTION WAS ADDED TO THE THREADED AREA ON P.N. 25240KA051 AS SHOWN IN THE ILLUSTRATION BELOW."

INTERMITTENT OPERATION OF THE HILL START ASSIST WARNING LAMP.

STORED DTC C0076 WITH DETAIL CODES 2610H AND/OR 2620H. *JS

available.

high-pitched sound coming from the transmission extension housing area.

certain CVT solenoid related DTCs as listed.

related DTCs.

During assembly of the bearing, a different type of grease is used which has a higher resistance to heat. In cases where the operator keeps a foot on the clutch pedal for extended periods, an increased amount of heat is generated which can cause the grease inside the bearing to deteriorate. In a case of prolonged clutch pedal application, seizure of the bearing can occur with potential damage to other related components.

During assembly of the bearing, a different type of grease is used which has a higher resistance to heat. In cases where the operator keeps a foot on the clutch pedal for extended periods, an increased amount of heat is generated which can cause the grease inside the bearing to deteriorate. In a case of prolonged clutch pedal application, seizure of the bearing can occur with potential damage to other related components.

TRANSMISSION (AT) FLUID COOLER PIPING AND AN ADDITION TO THE SERVICE PROCEDURE USED DURING THEIR REPLACEMENT.

BULLETIN PROVIDES PRODUCTION CHANGE, REPAIR PROCEDURE AND PARTS INFORMATION TO ADDRESS A CUSTOMER CONCERN OF A HIGH-PITCHED SOUND COMING FROM THE TRANSMISSION EXTENSION HOUSING AREA.

exposure to pollen on painted surfaces on vehicles imported from Japan. This bulletin does not apply to SIA built vehicles.

concerns: Power windows inoperative from the drivers door master and / or passenger front door switch Unable to remotely operate other door windows from the drivers door master switch One-Touch Auto Up / Down features inoperative from either / both front door switches"

concerns: ? Power windows inoperative from the driver?s door master and / or passenger front door switch ? Unable to remotely operate other door windows from the driver?s door master switch ? One-Touch Auto Up / Down features inoperative from either / both front door switches

retention and prevent water intrusion into the converter case.

THAT THE 3M TAPE WHICH ATTACHES THE MOLDING HAS NOT ADHERED PROPERLY. PLEASE USE THE FOLLOWING REPAIR PROCEDURE FOR REPLACING THE MOLDING(S).

(Subaru) is initiating a new safety recall for certain 2009-2013 model year Forester vehicles, in which a defective left front seat belt may have been installed as a replacement part.

(Subaru) is initiating a new safety recall for certain 2009-2013 model year Forester vehicles, in which a defective left front seat belt may have been installed as a replacement part.

(Subaru) is initiating a new safety recall for certain 2009-2013 model year Forester vehicles, in which a defective left front seat belt may have been installed as a replacement part.

(Subaru) is initiating a new safety recall for certain 2009-2013 model year Forester vehicles, in which a defective left front seat belt may have been installed as a replacement part.

seat belt buckle assembly attaches to the seat frame.

seat belt buckle assembly attaches to the seat frame.

seat belt buckle assembly attaches to the seat frame.

seat belt buckle assembly attaches to the seat frame.

seat belt buckle assembly attaches to the seat frame.

seat belt buckle assembly attaches to the seat frame.

concerns possibly resulting from an undetected A/C refrigerant leak.

concerns possibly resulting from an undetected A/C refrigerant leak.

concerns possibly resulting from an undetected A/C refrigerant leak. To improve Fixed Right First-Time (FRFT) and customer satisfaction, SOA is introducing a new procedure and fail code for first-time suspected A/C refrigerant leaks for cases when a Technician is unable to find the source of the leak or believes there was a potential factory under charge of the A/C system refrigerant."

(A/C) performance concerns possibly resulting from an undetected A/C refrigerant leak.

concerns possibly resulting from an undetected A/C refrigerant leak. To improve Fixed Right First-Time (FRFT) and customer satisfaction, SOA is introducing a new procedure and fail code for first-time suspected A/C refrigerant leaks for cases when a Technician is unable to find the source of the leak or believes there was a potential factory under charge of the A/C system refrigerant.

The change involves the addition of a rubber end cap and retaining clip onto the bottom of the receiver-dryer tank portion to prevent corrosion intrusion and enhance sealing.

WILL EVAPORATE WHEN TEMPERATURE RISES INSIDE LAMPS. MODEL ALL. NO YEARS LISTED. *PE

SNOW CONDITIONS, REPAIR METHOD IS PROVIDED FOR REMOVAL OF DRAIN SEPARATOR AND INSTALLATION OF EVAPORATIVE HOSE KIT FOR PREVENTION OF CONDITION. MODEL 2011-2013 FORESTER. *PE

B2A20 with gen 4 Telematics.

new vehicle inventory.

new vehicle inventory wjhich must be tested and reported every 30 days.

unnecessary bushing replacement.