2006 Sprinter 2500 TSBs
65 Technical Service Bulletins across 12 categories
Categories
Other
30 bulletinsUse of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry...
Read full bulletin
awareness regarding the use of aftermarket parts.
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to...
Read full bulletin
structural repair parts usage.
Disinfectant Solution Recommended for COVID-19
Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry...
Read full bulletin
awareness regarding the use of aftermarket parts.
Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to...
Read full bulletin
structural repair parts usage.
Noise on propeller shaft/rear axle from approx.
Read full bulletin
25mph
Status of Parts Ordering - Sprinter
Status of Parts Ordering - Sprinter
Status of Parts Ordering - Sprinter
Status of Parts Ordering - Sprinter
Status of Parts Ordering - Sprinter
Status of Parts Ordering - Sprinter
Status of Parts Ordering - Sprinter
Status of Parts Ordering - Sprinter
Status of Parts Ordering - Sprinter
Status of Parts Ordering - Sprinter
Status of Parts Ordering - Sprinter
Signal tone of Parktronic system (PTS) too quiet
Lane Keeping Assist: Fault message in instrument cluster, function not available.
Status of Parts Ordering - Sprinter
Status of Parts Ordering - Sprinter
Status of Parts Ordering - Sprinter
Noise on propeller shaft/rear axle as from 35mph
Transport mode active/transport mode cannot be deactivated
Status of Parts Ordering - Sprinter
82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states ...
Read full bulletin
(Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc), and some ladco states (Illinois, Michigan, and Ohio). Mopar offers an alternative product (82213192) which is a water based product approved for sale in the aforementioned states.~ ~ Please inform the customer & your prep dept that spraying excessive amounts of the fabric protector on load floors will result in the breaking down of the adhesive (glue) that is used to create the bond between the fabric (carpet) and the load floor. This will apply to any vehicles equipped with rear load floors such as WK, WD, PM, MK, KA, KK. The carpet will appear to be loose, wrinkly, or bunch up~
14TL8 TorcUP? Non-Impacting Torque Tool.
14CSA23 CSC Announces ?Tech Tips? ? DDCSN
14CSA21 Holiday Schedule for the Detroit Customer Support Center ?
sb2080 Australian CST M1400 Isolated Radiator Retrofit
Engine
11 bulletinsPart Description: 5.7L Long Block Issue Description: This 5.7L Long Block Assembly is compatible with both EGR and Non-EGR applications.
Read full bulletin
An EGR Block-Off Plate (53032739AA) must be ordered when installing this Long Block Assembly in a Non-EGR application. Unless, the EGR Block-Off Plate is being transferred from the old engine.
Part Description: Valve Body Assembly Issue Description: Valve body design was changed between 2010MY and 2011MY applications.
Read full bulletin
To prevent mix matching valve bodies and solenoid packs the connectors are color coded.~ Valve bodies with a white connector can be used on 2010, 2009, 2008..., model years. Valve bodies with a gray connector can only be used on 2011, 2012, 2013..., model years.~ Solenoid packs with a white connector are used with 2010, 2009, 2008..., model years. Solenoid packs with a gray connector are used with 2011, 2012, 2013..., model years.
Valve Body. These may cause over drive cycling.
Emissions Recall T21 Reprogram Engine Control Unit
Check engine light on and fault codes P3005A9, P3005FF, P30074B in CDI Control Unit
Noise from area of blower motor with climate control switched on
Engine oil level above max, oil indicator light on
Exhaust gas recirculation (EGR) valve leaking or not closing properly
Engine running complaints - Fault code P062700 current and/or stored in FSCU (N118)
14TL2 DD Platform Engine Stand Adapter W060589023100
NAG1 (5A580) Valve Body As per Warranty Bulletin D-13-22, please use R2108213A$ valve body for all Warranty (W), Mopar...
Read full bulletin
(M) and Mopar Vehicle Protection (F) claims.~ Assembly also includes Filter (52108325AA) and Gasket (52108332AA).~
Electrical
4 bulletinsCharging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test...
Read full bulletin
equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are necessary.
ESM (electronic selector lever module) fault 0002 "Undervoltage"
Fuel Injector Electrical Fault With Fault Codes
14CSA22 DTNA Chassis Wiring Diagrams
Pre-Delivery & Maintenance
3 bulletinsKEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number.
Read full bulletin
The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehicle, use the "AC" NIC level part and submit a part warranty.
KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number.
Read full bulletin
The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehicle, use the "AC" NIC level part and submit a part warranty.
14TL9 Special Tool Warranty Program.
Lighting
3 bulletinsUse of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair...
Read full bulletin
industry awareness regarding the use of recycled or salvage parts.
Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair...
Read full bulletin
industry awareness regarding the use of recycled or salvage parts.
ESP indicator lamp active, fault code C007500 in ESP control unit
Transmission
3 bulletins447 Metris does not shift out of Park
Automatic transmission housing cracked - Consequential damage due to cracked diesel particulate filter bracket
SPRINTER: REPLACING TORSION BAR MOUNTS.
Read full bulletin
CODES C40 FRONT AXLE STABILIZER BAR AND C45 REINFORCED FRONT AXLE STABILIZER BAR (EXCEPT CODES ZG1 ENGAGEABLE ALL WHEEL DRIVE AND EXCEPT CODE ZG3 ENGAGEABLE ALL WHEEL DRIVE WITH GEAR REDUCTION. *PE
Fuel System
3 bulletinsOM651 Exhaust Bracket Cracking
14TS19 DD Platform High Pressure Fuel Lines
16TS7 Reman Diesel Particulate Filter Serial Number
Air Bags & Safety
2 bulletinsSRS Lamp Illuminated
Seat belt does not roll up correctly
Body & Paint
2 bulletinsInstallation position of fender liner twisted at rear
Sliding door in partition wall cannot be locked in open position
Suspension
2 bulletinsBall joint check on front axle
Creaking noises at front spring at low outside temperatures
Brakes
1 bulletin14TL5 ABS Power Line Carrier Converter Available Through PDC
Tires & Wheels
1 bulletin14TL7 DD Platform Flywheel Housing Runout Tool W470589032100