2001 Saturn Ls TSBs
191 Technical Service Bulletins across 16 categories
Categories
Engine
66 bulletinsSUBJECT REGARDING SERVICE ENGINE SOON (SES) LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE (DTC) P1441 SET IN PCM HISTORY...
Read full bulletin
(INSTALL NEW PCM CALIBRATION) *JG
SUBJECT REGARDING SERVICE MANUAL UPDATE FOR ENGINE SERVICE MANUALS REGARDING EVAPORATIVE EMISSION (EVAP) SYSTEM FLOWCHART.
Read full bulletin
*JG
SUBJECT REGARDING SERVICE MANUAL UPDATE FOR ENGINE SERVICE MANUALS REGARDING BALANCE SHAFT TIMING PROCEDURE.
Read full bulletin
*JG
SUBJECT REGARDING SERVICE MANUAL UPDATE FOR ENGINE SERVICE MANUALS REGARDING NEW POSITIVE AND NEGATIVE BATTERY CABLE REPLACEMENT PROCEDURES.
Read full bulletin
*JG
SUBJECT REGARDING WHISTLE NOISE UNDER CERTAIN ENGINE OPERATING CONSITIONS.
Read full bulletin
*JG
SUBJECT REGARDING SERVICE MANUAL AND QUICK REFERENCE SPECIFICATIONS GUIDE UPDATE REGARDING INCORRECT CYLINDER HEAD BOLT TORQUE SPECIFICATIONS.
Read full bulletin
*SLC
INFORMATION REGARDING WHISTLE NOISE UNDER CERTAIN ENGINE OPERATING CONDITIONS.*JB
INFORMATION ON SERVICE ENGINE SOON LAMP ILLUMINATED.*JB
SOME CUSTOMERS MAY COMMENT ABOUT A VIBRATION OR BOOM NOISE INSIDE THE VEHICLE WHILE AT IDLE AND THE AIR CONDITIONER IS ON.
Read full bulletin
*JG
SOME CUSTOMERS MAY COMPLAIN ABOUT THE SERVICE ENGINE SOON TELLTALE AND/OR THE REDUCED POWER TELLTALE COMING ON.
Read full bulletin
*JG
SOME CUSTOMERS MAY COMPLAIN ABOUT A VIBRATION OR BOOM NOISE INSIDE THE VEHICLE WHILE AT IDLE AND THE AIR CONDITIONER IS ON.
Read full bulletin
(ALSO VEHICLE LS300 2002 AND LW300 2002) *JG
INFORMATION REGARDING ENGINE OIL LEAKS AND OR ENGINE COOLANT LEAKS.
Read full bulletin
*YH
INFORMATION REGARDING ENGINE OIL LEAKS AND/OR ENGINE COOLANT LEAKS, ON V-6 ENGINES.*JB
INFORMATION ON MALFUNCTION INDICATOR LAMP SERVICE ENGINE SOON TELLTALE COMING ON.*JB
SERVICE MANUAL UPDATE FOR ENGINE SERVICE MANUALS REGARDING CRUISE CONTROL DIAGNOSTICS.
Read full bulletin
*JG
THE ENGINE CRANKS BUT WILL NOT START AND/OR DECKLID RELEASE IS INOPERATIVE.
Read full bulletin
*JG
INFORMATION REGARDING 1ST AND 2ND DESIGN OIL FILTER ELEMENTS AND OIL FILTER CAPS AVAILABLE FOR THE 4 CYLINDER ENGINE AND...
Read full bulletin
HOW TO DETERMINE WHICH OIL FILTER AND CAP COMBINATION SHOULD BE USED. *SLC
SOME CUSTOMERS MAY COMMENT ABOUT INTERMITTENT CLICK / TICK NOISE COMING FROM ENGINE COMPARTMENT.
Read full bulletin
*TT
THIS PURPOSE OF THIS BULLETIN IS TO UPDATE ENGINE COOLING FAN SCHEMATICS.
Read full bulletin
*TT
SOME CUSTOMERS MAY COMMENT ABOUT THE ENGINE RUNNING ROUGH AT IDLE AFTER A COLD ENGINE START IN AMBIENT TEMPERATURES...
Read full bulletin
BETWEEN 10 DEGREES - 30 DEGREES CELSIUS (50 DEGREES - 85 DEGREES FAHRENHEIT. *TT
SOME CUSTOMERS MAY COMMENT ABOUT THE ENGINE CRANKS BUT WILL NOT START AND / OR THE ENGINE STARTS AND THEN STALLS.
Read full bulletin
*TT
SOME CUSTOMERS MAY COMMENT THAT THE MALFUNCTION INDICATOR LAMP (MIL) SERVICE ENGINE SOON IS ILLUMINATED AND DIAGNOSTIC...
Read full bulletin
TROUBLE CODE (DTC) P0440 OR DTC P0455 HAS BEEN STORED. *TT
SOME LS 300 AND LW 300 MODEL VEHIBLES MAY EXHIBIT A VIBRATION OR BOOM NOISE INSIDE THE VEHICLE WHILE AT IDLE AND THE A/C IS ON.
Read full bulletin
THE VIBRATION OR BOOM MAY ALSO BE MORE NOTICEABLE WHILE VEHICLE IS IN GEAR. *TT
CUSTOMERS MAY COMMENT THE SERVICE ENGINE SOON LAMP IS ILLUMINATED AND / OR THE TRANSAXLE SHIFTS ARE HARSH OR ERRATIC.
Read full bulletin
*TT
ON SOME VEHICLES, THE ENGINE WILL START AND THEN STALLS, ENGINE CRANKS BUT WILL NOT START, OR ENGINE HESITATES UNDER HEAVY ACCELERATION.
Read full bulletin
*TT
This technical bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct...
Read full bulletin
conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels should be used to reduce carbon build-up.
This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil Cooler Lines...
Read full bulletin
and Oil Tank if the engine was replaced where large amounts of debris has flowed throughout the oiling system.
This PI bulletin advises the technician on the proper way to install the pistons in an engine.
This service bulletin provides graphics, information and guidelines for engine component wear to assist service...
Read full bulletin
personnel as a guideline to perform necessary engine repairs and prevent unnecessary engine replacement.
This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil Cooler Lines...
Read full bulletin
and Oil Tank if the engine was replaced where large amounts of debris has flowed throughout the oiling system.
This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil Cooler Lines...
Read full bulletin
and Oil Tank if the engine was replaced where large amounts of debris has flowed throughout the oiling system.
Refinishing Aluminum Wheels This bulletin updates General Motor's position on refinishing aluminum wheels.
Read full bulletin
GM does not endorse any repairs that involve welding, bending, straightening o re-machining. Only cosmetic refinishing of the wheel's coatings, using recommended procedures, is allowed. Evaluating Damage In evaluating damage, it is the GM Dealer's responsibility to inspect the wheel for corrosion, scrapes, gouges, etc. The Dealer must insure that such damage is not deeper than what can be sanded or polished off. The wheel must be inspected for cracks. If cracks are found, discard the wheel. Any wheels with bent rim flanges must not be repaired or refinished. Wheels that have been refinished by an outside company must be returned to the same vehicle. The Dealer must record the wheel ID stamp or the cast date on the wheel in order to assure this requirement. Refer to Refinisher's Responsibility Outside Company later in this bulletin.
Refinishing Aluminum Wheels This bulletin updates General Motor's position on refinishing aluminum wheels.
Read full bulletin
GM does not endorse any repairs that involve welding, bending, straightening o re-machining. Only cosmetic refinishing of the wheel's coatings, using recommended procedures, is allowed. Evaluating Damage In evaluating damage, it is the GM Dealer's responsibility to inspect the wheel for corrosion, scrapes, gouges, etc. The Dealer must insure that such damage is not deeper than what can be sanded or polished off. The wheel must be inspected for cracks. If cracks are found, discard the wheel. Any wheels with bent rim flanges must not be repaired or refinished. Wheels that have been refinished by an outside company must be returned to the same vehicle. The Dealer must record the wheel ID stamp or the cast date on the wheel in order to assure this requirement. Refer to Refinisher's Responsibility Outside Company later in this bulletin.
This technical bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct...
Read full bulletin
conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels should be used to reduce carbon build-up.
This Preliminary Information communication provides information to the technician about vibration complaints that are...
Read full bulletin
one of the most challenging complaints to accurately diagnose and repair. Technician will need to use Pico Oscilloscope Diagnostic Kit to effectively diagnosis vehicles. Technician should drive the vehicle will using the Pico Oscilloscope to record data. After the data is recorded it should be reviewed to determine the root cause of the concern. If a repair attempt made the concern better but not eliminated or had no affect at all, and are requesting assistance from General Motors Technical Assistance Center record another Pico file and save it to the computer. After the new Pico Oscilloscope data has been saved email the data to General Motors Technical Assistance Center in the subject line include “Vibration” “Business Associate Code” and the last 8 of the Vehicle Identification Number.
This Preliminary Information communication provides information to the technician about vehicles that have a loud tick...
Read full bulletin
or rattle noise under the hood at all operating conditions. Technician will need to check the lower and oil pressure to the upper end oil pressure. Technician will need to inspect the oil feed orifice in the cylinder head. Technician will clean out and debris found in the orifice.
This Preliminary Information communication provides information to the technician about installing General Motors Accessory pats.
Read full bulletin
Technician can check Service Information for some accessories. Technician can also contact Partect for assistance. Technician can also contact Techline Customer Support Center for programming issues.
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN THE STEPS ON REPAIRING THE CONCERN.
Read full bulletin
A CUSTOMER MAY IDENTIFY A CONCERN OF UNABLE TO REACTIVATE A VEHICLE'S ONSTAR THAT HAS BEEN PREVIOUSLY DISABLED BY ONSTAR. DEALER IS TO CALL GENERAL MOTORS TECHNICAL ASSISTANCE CENTER FOR FURTHER ASSISTANCE IF THE CONCERN IS STILL PRESENT.
THIS INFORMATIONAL BULLETIN PROVIDES ADDITIONAL INFORMATION ON HOW TO INSTALL PISTONS AND SUGGEST WHAT TOOLS TO USE.
THIS INFORMATIONAL BULLETIN PROVIDES INFORMATION TO GM DEALERS ON THE CORRECT CLEANING METHODS WHEN CLEANING ENGINE...
Read full bulletin
GASKET SEALING SURFACES.
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN THE STEPS ON REPAIRING THE CONCERN.
Read full bulletin
A CUSTOMER MAY IDENTIFY A CONCERN OF UNABLE TO REACTIVATE A VEHICLE'S ONSTAR THAT HAS BEEN PREVIOUSLY DISABLED BY ONSTAR. DEALER IS TO CALL GENERAL MOTORS TECHNICAL ASSISTANCE CENTER FOR FURTHER ASSISTANCE IF THE CONCERN IS STILL PRESENT.
GENERAL MOTORS: INFORMATION PROVIDED BY BULLETIN FOR ALL 2012 AND PRIOR GENERAL MOTOR TRUCKS AND PASSENGER VEHICLES...
Read full bulletin
REGARDING THE ADJUSTABLE COMFORT AND CUSTOM UPHOLSTERY OF THE DRIVER AND THE PASSENGER HEAD RESTRAINT. *PE
GM: THERE MAY BE NOISE COMING FROM THE CYLINDER HEAD, BECAUSE OF LOW OIL PRESSURE WHICH IS CAUSED BY DEBRIS.
Read full bulletin
*RM
GENERAL MOTORS: INFORMATION ON TIRE RADIAL FORCE VARIATION.
Read full bulletin
VEHICLE MUST BE DRIVEN BEFORE MEASURING TIRES ON EQUIPMENT HUNTER GSP9700 TOENSURE REMOVAL OF ANY FLATSPOTTING. MODELS INCLUDE ALL GM PASSENGER CARS AND LIGHT TRUCKS, AS WELL AS CERTAIN HUMMERS, SAABS, AND SATURNS. *PE
SATURN: E109213-FUEL SMELL/ODOR OR LEAK NEAR FUEL TANK AREA *ENGINEERING INFORMATION).
Read full bulletin
CUSTOMERS COMPLAIN ABOUT A FUEL SMELL/ODOR WHILE DRIVING OR AFTER THE VEHICLE IS PARKED. SOME DAMPNESS MAY ALSO BE NOTICED ON THE GROUND NEAR THE FUEL TANK AREA. *PE
INFORMATION ON 4T40-E (MN4) AND 4T45-E (MN5) FRONT WHEEL DRIVE AUTOMATIC TRANSMISSION VALVE BODY RECONDITIONING, DTC...
Read full bulletin
P0741, P0742, P0751, P0752, P0756, P0757, P1811, HARSH SHIFTS, SLIPS, NO DRIVE, NO REVERSE. *NJ
PARTS UPDATE - TIMING CHAIN TENSIONER DESIGN CHANGE.
Read full bulletin
*KB
TIMING BELT REPLACEMENT.
Read full bulletin
*KB
HESITATION ON ACCELERATION AFTER INTERNAL ENGINE REPAIRS - CHECK INJECTOR HARNESS ORIENTATION.
Read full bulletin
*TT
TICK NOISE FROM ENGINE.
Read full bulletin
*TT
SERVICE ENGINE SOON (SES) AND/OR REDUCED POWER LAMP ILLUMINATING FOLLOWING COLD ENGINE START UP IN SUBFREEZING...
Read full bulletin
TEMPERATURES, DIAGNOSTIC TROUBLE CODES (DTC) P0638, P1510 AND/OR P1516 STORED IN ENGINE CONTROL MODULE (ECM). *TT
SERVICE ENGINE SOON (SES) TELLTALE ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0171, P0172, P0174 AND/OR P0175.
Read full bulletin
*TT
POP NOISE FROM ENGINE AREA DURING HEAVY THROTTLE INPUT.
Read full bulletin
*TC
SES ILLUMINATED ENGINE MISS/MISFIRE FEEL OR ROUGH IDLE.
Read full bulletin
*SC
INFORMATION REGARDING AIR CONDITIONING (A/C) COMPRESSOR NOISE AT ENGINE START (A/C OR DEFROST MODE SELECTED) OR AT A/C...
Read full bulletin
OR DEFROST ACTIVATION (AFTER ENGINE START). *TT
SERVICE MANUAL UPDATE FOR ENGINE BLOCK CLEARANCE, CYLINDER HEAD CLEARANCE AND FASTENER TORQUE SPECIFICATIONS.
Read full bulletin
*TT
BLUE SMOKE AT ENGINE START-UP.
Read full bulletin
*TT
OIL LEAK FROM FRONT COVER SEAL DURING EXTREMELY COLD WEATHER.
Read full bulletin
*TT
SERVICE ENGINE SOON (SES) LAMP ILLUMINATED WITH DTC P0135 HO2S HEATER CIRCUIT PERFORMANCE BANK 1 SENSOR 1 AND/OR DTC...
Read full bulletin
P0155 HO2S HEATER PERFORMANCE BANK 2 SENSOR 1. *MR THIS BULLETIN REPLACES PREVIOUS 04-06-04-008. *EH
SERVICE INFORMATION REGARDING ENGINE SUPPORT DURING REMOVAL OF RIGHT FRONT ENGINE MOUNT ASSEMBLY.
Read full bulletin
*TT
SERVICE INFORMATION REGARDING SATURN REAR DRUM WHEEL CYLINDER INSPECTIONS.
Read full bulletin
*TT UPDATE. *TT
MALFUNCTION INDICATOR LAMP (MIL) SERVICE ENGINE SOON TELLTALE LAMP ON, REDUCED POWER LAMP MAY ILLUMINATE WITH DIAGNOSTIC...
Read full bulletin
TROUBLE CODES P0121, P0221, AND/OR P2135. *TT
SERVICE MANUAL UPDATE - REVISED ENGINE TORQUE SPECIFICATION TABLE.
Read full bulletin
*TT
TIMING CHAIN DESIGN CHANGE AND REVISED SERVICE PROCEDURES.
Read full bulletin
*TT
BLEEDING PROCEDURE FOR HYDRAULIC CLUTCH RELEASE SYSTEM INCLUDING CLUTCH ACTUATOR CYLINDER.
Read full bulletin
*TT
SERVICE INFORMATION REGARDING THE ENGINE CONTROL MODULE (ECM) CONNECTOR AND TERMINAL LOCATIONS ON SATURN V6 ENGINES.
Read full bulletin
*TT
Body & Paint
25 bulletinsSUBJECT REGARDING SERVICE INFORMATION ON NEW OIL COOLER COVER SEALANT.
Read full bulletin
*JG
SERVICE INFORMATION REGARDING DESIGN CHANGE TO THERMOSTAT HOUSING, THERMOSTAT HOUSING BOLTS, AND THERMOSTAT HOUSING O-RING SEAL.
Read full bulletin
*TT
CUSTOMERS MAY COMPLAIN OF REAR DOOR GLASS BEING INOPERATIVE OR OPERATES ERRACTICALLY.*JB
SUBJECT REGARDING HEADLINER SAGS OR HANGS TOO LOW AT REAR OF SUNROOF OPENING.
Read full bulletin
*YD
SOME CUSTOMERS MAY COMMENT ABOUT THE HEADLINER SAGGING OR HANGING TOO LOW AT THE REAR OF THE SUNROOF OPENING.
Read full bulletin
*JG
SOME CUSTOMERS MAY COMPLAIN OF RATTLE NOISES HEARD IN AREA OF DOME LAMP, SUNROOF, OR HEADLINER DURING NORMAL OPERATING CONDITIONS.
Read full bulletin
*SLC
CUSTOMERS MAY COMPLAIN THAT THE REAR FASCIA TO QUARTER PANEL IS NOT CORRECTLY ALIGNED.
Read full bulletin
*SLC
CUSTOMERS MAY COMPLAIN OF WATER LEAKING INTO THE PASSENGER COMPARTMENT AND/OR REAR COMPARTMENT CARGO AREA.
Read full bulletin
*SLC
CUSTOMERS MAY COMPLAIN OF HEADLINER SAGGING OR HANGING TOO LOW AT THE REAR OF THE SUNROOF OPENING.
Read full bulletin
*SLC
INFORMATION REGARDING AN UPDATED PROGRAMMING PROCEDURE FOR THE CUSTOMER PROGRAMMABLE AUTOMATIC DOOR LOCK AND UNLOCK FEATURE.
Read full bulletin
*SLC
EXPERIENCING RATTLE NOISES HEARD IN AREA OF DOME LAMP, SUNROOF, ORHEADLINER DURINGNORMAL OPERATING CONDITIONS.
Read full bulletin
*TT
SOME CUSTOMERS MAY COMMENT ABOUT THE HEADLINER SAGGING ORH ANGING TOO LOW AT THE REAR OF THE SUNROOF OPENING.
Read full bulletin
*TT
CONCERNS THAT THE REAR FASCIA TO QUARTER PANEL IS NOT CORRECTLY ALIGNED.
Read full bulletin
*TT
SOME CUSTOMERS MAY COMMENT ABOUT WATER LEAKING INTO THE PASSENGER COMPARTMENT AND / OR REAR COMPARTMENT / REAR CARGO AREA.
Read full bulletin
*TT
THE PURPOSE OF THIS BULLETIN IS TO PROVIDE AN UPDATED PROGRAMMING PROCEDURE FOR THE CUSTOMER PROGRAMMABLE AUTOMATIC DOOR...
Read full bulletin
LOCK AND UNLOCK FEATURE FOR VEHICLES BUILT AFTER AND INCLUDING VIN 1Y585334. *TT
THE PURPOSE OF THIS BULLETIN IS TO INFORM SATURN RETAILER PERSONNEL OF THE SYSTEM FUNCTION AND PROCEDURE USED TO INSTALL THE TRAP-RESISTANT TRUNK KIT.
Read full bulletin
*TT
SOME VEHICLES BUILT BEFORE AND INCLUDING VIN 1Y530200 MAY EXHIBIT WINDSHIELD WIPERS THAT CHATTER OR HOP ACROSS THE WINDSHIELD DURING WIPER OPERATION.
Read full bulletin
*TT
EXPERIENCING RATTLE NOISES HEARD FROM THE AREA OF DOME LAMP, SUNROOF, OR HEADLINER DURING NORMAL OPERATING CONDITIONS.
Read full bulletin
*TT
SOME CUSTOMERS MAY COMMENT ABOUT THE HEADLINER SAGGING OR HANGING TOO LOW AT THE REAR OF THE SUNROOF OPENING.
Read full bulletin
*TT
This service bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Water Leaks and...
Read full bulletin
Replacement Guidelines.
Underbody Component Corrosion The following information may be helpful when addressing underbody component corrosion with customers.
Read full bulletin
Some customers may comment that one or more of their vehicle's underbody components are showing some form of corrosion. This corrosion may be red in appearance (rust) if the component is steel, forged iron or cast iron. This corrosion may also be grey or white in color if the component is constructed of an aluminum alloy.
Underbody Component Corrosion The following information may be helpful when addressing underbody component corrosion with customers.
Read full bulletin
Some customers may comment that one or more of their vehicle's underbody components are showing some form of corrosion. This corrosion may be red in appearance (rust) if the component is steel, forged iron or cast iron. This corrosion may also be grey or white in color if the component is constructed of an aluminum alloy.
DARK RECTANGLES OR CIRCLES IN THE CENTER OF THE ROOF.
Read full bulletin
*TT
LITTLE OR NO WINDSHIELD SOLVENT COMING FROM WASHER NOZZLES.
Read full bulletin
*TT
SERVICE MANUAL UPDATE FOR REMOVAL OF THE SEALER USED ON OIL PUMP GASKET DURING OIL PUMP INSTALLATION.
Read full bulletin
*TT
Electrical
23 bulletinsSUBJECT REGARDING SERVICE MANUAL UPDATE FOR BODY /ELECTRICAL VOLUME II SERVICE MANUALS REGARDING LIFTGATE RELEASE-WAGON...
Read full bulletin
CIRCUIT DESCRIPTION AND OPERATION. *JG
SUBJECT REGARDING MASS AIR FLOW SENSOR FAILURE DUE TO OIL CONTAMINATION OF SENSOR MEMBRANE (INSTALL NEW MASS AIR FLOW...
Read full bulletin
(MAF) SENSOR AND UPDATE ELECTRONIC CONTROL MODULE CALIBRATION) *JG
SUBJECT REGARDING INACCURATE ODOMETER READING AFTER LOSS OF BATTERY POWER.
Read full bulletin
*JG
THE PURPOSE OF THIS BULLETIN IS TO PROVIDE NEW POSITIVE AND NEGATIVE BATTERY CABLE REPLACEMENT PROCEDURES.
Read full bulletin
*TT
SUBJECT REGARDING INACCURATE ODOMETER READING AFTER LOSS OF BATTERY POWER.*JB
SERVICE MANUAL REGARDING SOLENOID CIRCUIT SCHEMATIC, INPUT SPEED SENSOR PERFORMANCE, AND INPUT SPEED SENSOR CIRCUIT LOW VOLTAGE SCHEMATICS.
Read full bulletin
*JG
SERVICE MANUAL REVISION ON BODY ELECTRICAL VOLUME I AND VOLUME II.
Read full bulletin
*SLC
SERVICE MANUAL UPDATE FOR 2000 AND 2001 L-SERIES BODY ELECTRICAL VOLUME I AND VOLUME II SERVICE MANUALS REGARDING INNER DOOR PULLHANDLE REMOVAL.
Read full bulletin
*TT
SOME CUSTOMERS MAY COMMENT THT THE IGNITION KEY WILL NOT TURN OUT OF THE LOCK POSITION.
Read full bulletin
*TT
Vehicle Wide Programming (VWP) is a new process to update software on GM Vehicles.
Read full bulletin
It provides the ability via a single selection within Techline Connect to first identify which modules need updating and then proceed to updating affected modules (with some exceptions). The updating of modules is completed in parallel instead of the technician needing to update one module at a time. This allows a more streamlined approach for dealers and customers.
Programming And Activation Of Replacement OnStar Modules.
Programming And Activation Of Replacement OnStar Modules.
Expanded Availability for Remanufacture and Return (R&R) Electronic Control Modules
OnStar Voice Fallback Number Update Some customers may have received a letter from OnStar stating that "We recently...
Read full bulletin
tried to provide a software update to the OnStar hardware in your vehicle. However, your system could not be updated remotely. As a result, some of your OnStar system functions may not be working as expected." The customer is further instructed in this letter to "Please contact your dealer or any dealer near you as soon as possible to schedule an appointment for this no-cost software update. Your dealer will reprogram your OnStar module with an update. This is for vehicles that have previously received the Canada upgrade as described in Service Bulletin #15-08-44-001F."
This informational bulletin provides information on Part Restriction and Ordering Process Information for OnStar Vehicle...
Read full bulletin
Communication Interface Modules (VCIM) (GMNA Only)
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN ABOUT VEHICLES THAT HAVE AN ONSTAR SYSTEM THAT WILL NOT POWER UP.
Read full bulletin
TECHNICIAN SHOULD TURN OFF THE IGNITION AND CANCEL RETAINED ACCESSORY POWER. AFTER THE VEHICLE HAS POWERED DOWN REMOVE POWER TO THE ONSTAR MODULE FOR FIVE MINUTES. AFTER THE POWER HAS BEEN REMOVED FOR FIVE MINUTES, IF THE ONSTAR SYSTEM IS WORKING RELEASE THE VEHICLE. IF THE ONSTAR SYSTEM IS STILL INOPERATIVE CONTINUE WITH PUBLISHED SERVICE INFORMATION DIAGNOSTICS.
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN, IF UNABLE TO PLACE AN ONSTAR CALL IN THE IGNITION ON...
Read full bulletin
MODE AFTER THE ONSTAR CANADA UPGRADE TO CONTACT THE GM TECHNICAL ASSISTANCE CENTER ONSTAR GROUP FOR FURTHER ASSISTANCE.
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN IF UNABLE TO PLACE AN ONSTAR CALL IN THE IGNITION ON...
Read full bulletin
MODE AFTER THE ONSTAR CANADA UPGRADE, TO CONTACT THE GM TECHNICAL ASSISTANCE CENTER ONSTAR GROUP FOR FURTHER ASSISTANCE.
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO HELP THE DEALERSHIP TECHNICIANS PERFORM A PARASITIC...
Read full bulletin
DRAIN TEST FOR THE ONSTAR MODULE. WHEN PERFORMING BATTERY PARASITIC DRAIN TEST, THERE MAY BE SOME CONFUSION AS TO WHAT THE NORMAL POWER CONSUMPTION READING SHOULD BE FROM THE ONSTAR SYSTEM.
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO HELP THE DEALERSHIP TECHNICIANS PERFORM A PARASITIC...
Read full bulletin
DRAIN TEST FOR THE ONSTAR MODULE. WHEN PERFORMING BATTERY PARASITIC DRAIN TEST, THERE MAY BE SOME CONFUSION AS TO WHAT THE NORMAL POWER CONSUMPTION READING SHOULD BE FROM THE ONSTAR SYSTEM.
INFORMATION ON INTERMITTENT DIMMING (FLICKERING) OF HEADLAMPS AND/OR INSTRUMENT PANEL LIGHTING-NORMAL CHARACTERISTIC.
Read full bulletin
THIS MAY OCCUR BECAUSE OF TRANSIENT CURRENT LOADS ON THE ELECTRICAL SYSTEM DURING NORMAL VEHICLE OPERATION. *MN
INTERMITTENT SECURITY TELLTALE ILLUMINATION AND/OR DIAGNOSTIC TROUBLE CODE B2960.
Read full bulletin
*TT
INFORMATION FOR CONCERNS ON NOISE HEARD THROUGH THE AUDIO SYSTEM WHEN ANOTHER ELECTRICAL COMPONENT IS ACTIVATED OR USED.
Read full bulletin
*TT
Other
18 bulletinsTHE DRIVER'S SIDE 6-WAY POWER SEAT FUNCTIONS ARE INOPERATIVE.
Read full bulletin
*JG
CUSTOMERS MAY COMPLAIN OF A RATTLE TYPE NOISE THAT SEEMS TO BE COMING FROM REAR OF VEHICLE WHEN TRAVELING OVER ROUGH ROAD SURFACES.
Read full bulletin
*SLC
CUSTOMERS MAY COMMENT ABOUT A RATTLE TYPE NOISE THAT SEEMS TO BE COMING FROM REAR OF VEHICLE WHEN TRAVELING OVER ROUGH ROAD SURFACES.
Read full bulletin
*TT
VEHICLES EQUIPPED WITH REMOTE KEYLESS ENTRY UP TO AND INCLUDING VIN 1Y570729 MAY EXPERIENCE POOR REMOTE KEYLESS ENTRY (RKE) TRANSMITTER RANGE.
Read full bulletin
*TT
SOME CUSTOMERS MAY COMMENT OF POOR REMOTE KEYLESS ENTRY (RKE) RANGE WHILE TRYING TO LOCK OR UNLOCK VEHICLE(S) UP TO AND INCLUDING VIN 1Y570729.
Read full bulletin
*TT
This PI communicates the requirement to provide a pico file to receive diagnostic assistance from TAC.
This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product...
Read full bulletin
Allegation Resolution (PAR) claim.
Canadian Customers Unable To Place Calls And Turn By Turn Inoperative In The United States.
Canadian Customers Unable To Place Calls In The United States
THIS PRELIMINARY INFORMATION COMMUNICATION PROVIDES INFORMATION TO THE TECHNICIAN ABOUT FINDING NEEDLE BEARINGS DURING AN OIL CHANGE.
Read full bulletin
TECHNICIAN WILL GAIN ACCESS TO THE ROLLER ROCKERS TO INSPECT THEM. ONLY REPLACE THE ROLLER ROCKER THAT IS MISSING NEEDLE BEARINGS. BE SURE TO CLEAN THE OIL DRAINS TO RETRIEVE THE NEEDLE BEARINGS. EACH ROLLER ROCKER HAS 66 BEARINGS.
THIS PRELIMINARY INFORMATION COMMUNICATION ADVISES THE TECHNICIAN ON THE STEPS FOR DIAGNOSING THE CONCERN.
Read full bulletin
THE VEHICLE MAY BE UNABLE TO CONNECT TO ONSTAR USING THE WHITE, BLUE OR RED ONSTAR BUTTONS.
NO SELECTION FIR SATURN WHEN PROGRAMMING A SATURN VEHILCLE.
Read full bulletin
*SC
AUX COOLANT PUMP WILL NOT CONNECT TO REPLACEMENT RADIATOR.
Read full bulletin
*SC
RETURN FORM FOR COMPACT DISCS (CDS) OR DIGITAL VERSATILE DISCS (DVDS) THAT ARE STUCK IN CD PLAYER WHEN RETURNED AS A CORE RETURN.
Read full bulletin
*TT
SATURN FIELD PRODUCT REMINDER- VEHICLE FIX IT RIGHT THE FIRST TIME ISSUES, PARTS RESTRICTION INFORMATION AND TECHNICAL...
Read full bulletin
BULLETINS RELEASED IN JANUARY, FEBRUARY, AND MARCH 2004. *MR
COMPACT DISCS (CDS) SKIP IN SINGLE CD PLAYER.
Read full bulletin
*TT
OIL FILTER CAP ASSEMBLY AND OIL FILTER ELEMENT DESIGN CHANGE.
Read full bulletin
*TT
LOOSE OR TORN SEAT COVERS.
Read full bulletin
*TT
Pre-Delivery & Maintenance
12 bulletinsSERVICE INFORMATION REGARDING REDESIGNED WIPER LINKAGE AND NEW SERVICE PROCEDURES.
Read full bulletin
*JG
SUBJECT REGARDING SERVICE INFORMATION REGARDING NEW DESIGN LINE PRESSURE CONTROL SOLENOIDS.
Read full bulletin
*JG
SERVICE INFORMATION REGARDING REDESIGNED OIL FILTER ELEMENT AND OIL FILTER CAP.
Read full bulletin
*TT
This service bulletin provides information for dealers/technicians on Service Programming System (SPS) Error Codes...
Read full bulletin
E4398, E4399, E4401, E4403, M4404, M4413, M6954, M6955, E4414, E4423, E4491, E4492, or E6961 and resolution information.
Vehicle Recalls
This service bulletin provides information for dealers on how to submit a product information report (PIR) (Canada...
Read full bulletin
Only).
This service bulletin provides service information on new torque specification and installation procedure for ACDelco...
Read full bulletin
Spin-On Oil Filters.
This warranty administration bulletin provides information regarding the field action courtesy transportation policy.
This service bulletin provides information for dealers on how to submit a product information report (PIR) (Canada...
Read full bulletin
Only).
This service bulletin provides service information on new torque specification and installation procedure for ACDelco...
Read full bulletin
Spin-On Oil Filters.
This service bulletin provides service information on new torque specification and installation procedure for ACDelco...
Read full bulletin
Spin-On Oil Filters.
This service bulletin provides service information on new torque specification and installation procedure for ACDelco...
Read full bulletin
Spin-On Oil Filters.
Steering
10 bulletinsSOME CONSUMERS MAY COMPLAIN ABOUT A STEERING WHEEL SHAKE OR VIBRATION FELT WHEN DRIVING VEHICLE AT HIGHWAY SPEEDS.
Read full bulletin
THIS CONDITION IS MOST NOTICEABLE ON SMOOTH ROAD SURFACES AT VEHICLE SPEEDS ABOVE 65MPH (105 KM/H) *JG
SERVICE INFORMATION REGARDING POWER STEERING SYSTEM NOISE AND/OR LEAK DIAGNOSIS.
Read full bulletin
*JG
SOME VEHICLES MAY EXPERIENCE STEERING WHEEL SHAKE OR VIBRATION AT HIGHWAY SPEEDS.*JB
SOME CUSTOMERS MAY COMMENT REGARDING A STEERING WHEEL SHAKE OR VIBRATION FELT WHEN DRIVING VEHICLE AT HIGHWAY SPEEDS.
Read full bulletin
*TT
POWER STEERING SYSTEM NOISE AND/OR LEAK DIAGNOSIS.
Read full bulletin
*TT
ROUTING THE LONGER TUNED POWER STEERING HOSE PER TSB 03-02-32-045.
Read full bulletin
*SC
CLUNK NOISE FROM FRONT OF VEHICLE DURING TURNING MANEUVER/STEERING WHEEL ROTATION.
Read full bulletin
*TT
MOAN OR GROAN NOISE WHEN TURNING STEERING WHEEL AT LOW SPEEDS.
Read full bulletin
*TT
STEERING WHEEL SHAKE OR VIBRATION AT HIGHWAY SPEEDS.
Read full bulletin
*TT UPDATE. *TT
WHISTLE NOISE FROM POWER STEERING WHILE TURNING LEFT.
Read full bulletin
*TT
HVAC & Climate
7 bulletinsSUBJECT REGARDING SQUEAK, RATTLE AND POOR FIT FROM DEFROSTER GRILLE (INSTALL REDESIGNED DEFROSTER GRILLE) *JG
SUBJECT REGARDING INSTALLATION PROCEDURES FOR STANDARD HVAC CONTROLLER WITH 3RD MOUNTING BOSS.
Read full bulletin
*JG
This bulletin provides an updated repair procedure to correct a customer concern of a musty odor from A/C system, most...
Read full bulletin
noticeable at vehicle start-up.
ODOR FROM AIR CONDITIONING AT VEHICLE START-UP.
Read full bulletin
*TT
DEFROSTER GRILLE POPPING NOISE ENCOUNTERED DURING COLD TEMPERATURES.
Read full bulletin
*TT
SERVICE INFORMATION REGARDING ELIMINATION OF AUXILIARY WATER PUMP AND INSTRUMENTS TO INSTALL 2ND DESIGN HEATER INLET...
Read full bulletin
HOSE AND HEATER INLET ELBOW IN PLACE OF THE 1ST DESIGN WATER PUMP AND HEATER INLET HOSE. *TT
SERVICE INFORMATION REGARDING ELIMINATION OF AUXILIARY WATER PUMP AND INSTRUCTIONS TO INSTALL 2ND DESIGN HEATER INLET...
Read full bulletin
HOSE AND HEATER INLET ELBOW IN PLACE OF THE 1ST DESIGN WATER PUMP AND HEAT INLET HOSE. *TT
Lighting
7 bulletinsThis informational bulletin provides information for dealers/technicians on Headlamp, Tail Lamp, License Lamp or...
Read full bulletin
Fog/Driving Lamp Damage.
This Preliminary Information communication provides information to the technician on the programming and activation of the OnStar system.
Read full bulletin
For many 2008 and prior model year GM vehicles, the programming is performed using the Tech 2 and the activation is initiated by a Service Programming System. For the 2010 and UP model year vehicles, the OnStar set-up procedure and OnStar Activation request have been combined into a single programming event called OnStar Set-up and Activation in Service Programming System.
This informational bulletin provides information to assist dealership personnel with the identification of vehicle...
Read full bulletin
headlamp, tail lamp, license lamp or fog/driving lamp damage that are not considered warrantable.
INFORMATION ON TIRE RADIAL FORCE VARIATION (RFV).
Read full bulletin
2008 AND PRIOR GM PASSENGER CARS AND LIGHT DUTY TRUCKS INCLUDING 2008 AND PRIOR HUMMER H2, H3 AND 2005-08 SAAB 9-7X AND 2000-05 SATURN L SERIES AND 2003-07 SATURN ION. *KB UPDATED 4/11/08. *NJ UPDATED 5/27/09. *PE
TRAILER, RECREATIONAL AND DISABLED VEHICLE TOWING INFORMATION.
Read full bulletin
*KB UPDATED 08-15-07. *KB UPDATED 10/09/07. *NJ UPDATED 4/3/08. *NJ
RECREATIONAL AND DISABLED VEHICLE TOWING INFORMATION.
Read full bulletin
*TT
TRAILER, RECREATIONAL AND DISABLED VEHICLE TOWING INFORMATION.
Read full bulletin
*TT *SC
Suspension
5 bulletinsSUBJECT REGARDING SERVICE MANUAL UPDATE FOR CHASSIS SERVICE MANUALSS REGARDING ALIGNMENT SPECIFICATIONS AND SERVICE...
Read full bulletin
PROCEDURE FOR INSTALLATION OF SPACERS BETWEEN REAR SUSPENSION SUPPORT AND VEHICLE BODY WHEN PERFORMING WHEEL ALIGNMENT. *JG
SUBJECT REGARDING SERVICE MANUAL UPDATE FOR CHASSIS SERVICE MANUALS REGARDING FRONT STRUT ASSEMBLY PROCEDURE.
Read full bulletin
*SLC
SERVICE MANUAL UPDATE FOR CHASSIS SERVICE MANUALS REGARDING FRONT STRUT ASSEMBLY PROCEDURE.
Read full bulletin
*SLC
SUBJECT REGARDING FRONT AND REAR SUSPENSION TORQUE SPECIFICATIONS.
Read full bulletin
*JG
SERVICE MANUAL UPDATE REGARDING THE USE OF SATURN SPECIAL TOOL J-42065 CRANK HUB HOLDING TOOL.
Read full bulletin
*TT
Transmission
4 bulletinsSUBJECT REGARDING SERVICE MANUAL UPDATE FOR TRANSAXLE SERVICE MANUALS REGARDING NEW DIFFERENTIAL RING GEAR REPLACEMENT PROCEDURE.
Read full bulletin
*JG
IGNITION KEY WILL NOT ROTATE BACK TO OFF POSITION OR SHIFT LEVER WILL NOT MOVE OUT OF PARK.
Read full bulletin
*TT
SERVICE WRENCH AND SES TELLTALE MAY BE ILLUMINATED AND TRANSAXLE MAY SHIFT HARSHLY.
Read full bulletin
*EH
SERVICE VEHICLE SOON LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE (DTC) P1811 MAXIMUM ADAPT AND LONG SHIFTS.
Read full bulletin
*TT
Infotainment
3 bulletinsSOME CONSUMERS MAY COMPLAIN THAT THE REAR DOOR GLASS IS INOPERATIVE OR DISPLAYS ERRATIC OPERATION.
Read full bulletin
*JG
Information On Requests To Add OnStar Bluetooth Option.
CHANGES TO THE AM/FM STEREO AND AUDIO DISC PLAYER RADIO ON-BOARD DIAGNOSTIC MODES AND CD LOAD OPERATION.
Read full bulletin
*TT
Brakes
3 bulletinsSERVICE MANUAL UPDATE REGARDING FRONT SEAT CUSHION COVER/PAD REMOVAL AND INSTALLATION.
Read full bulletin
*SLC
INFORMATION REGARDING FRONT BRAKE ROTOR MINIMUM THICKNESS AFTER REFINISH AND DISCARD THICKNESS SPECIFICATONS.
Read full bulletin
*SLC
INFORMATION ON FRONT BRAKE ROTOR MINIMUM THICKNESS AFTER REFINISH AND DISCARD THICKNESS SPECIFICATIONS.
Read full bulletin
*TT
Tires & Wheels
3 bulletinsThis service bulletin provides information about the Hunter wheel Road Force balancers that should be utilized for all...
Read full bulletin
repairs requiring balance and Road Force measurement.
This service bulletin provides information about the Hunter wheel Road Force balancers that should be utilized for all...
Read full bulletin
repairs requiring balance and Road Force measurement.
THUMP NOISE/VIBRATION/FLAT SPOTTED TIRES ON VEHICLE.
Read full bulletin
*TT
Software & Calibration
3 bulletinsTHIS TECHNICAL BULLETIN PROVIDES A PROCEDURE TO REPROGRAM THE MEDIA DISC PLAYER WITH THE LATEST CALIBRATIONS TO CORRECT...
Read full bulletin
A CONDITION OF THE REAR ENTERTAINMENT SYSTEM NOT OPERATING AS INTENDED IN COLDER AMBIENT TEMPERATURE AREAS DUE TO CALIBRATION CONCERNS.
LOW OIL PRESSURE - INSPECT OIL FILTER FOR DAMAGE.
Read full bulletin
*KB UPDATED 10/18/07. *NJ
CLARIFICATION OF LABOR CODES USED FOR REPROGRAMMING VEHICLE CONTROLLERS.
Read full bulletin
VARIOUS MODELS INCLUDING THE 2004 L-SERIES. *TT
Air Bags & Safety
1 bulletinGM: THERE ARE SEAT BELT PROBLEMS: DIFFICULTY LATCHING AND UNLATCHING BUCKLE.
Read full bulletin
BUCKLE RELEASE BUTTON IS STICKING. SEAT BELT WARNING LIGHT ILLUMINATED. LIKELY CAUSED BY STICKY BEVERAGES THAT ARE SPILLED INTO THE BUCKLE ASSEMBLY. *RM UPDATED 4/3/12. *PE
Fuel System
1 bulletinFUEL GAUGE DISPLAYS AN ERRATIC OR FALSE READING OR NO START CONDITION AFTER VEHICLE IS SHUT OFF WITH LOW FUEL LEVEL.
Read full bulletin
*TT THIS BULLETIN REPLACES PREVIOUS DATED 12/01/03. *TT THIS BULLETIN REPLACES PREVIOUS DATED 08/01/04. *TT