2009 Prevost X3-45 TSBs
67 Technical Service Bulletins across 13 categories
Categories
Engine
22 bulletinsKIT POWER STEERING TANK CONVERTION CUMMINS TO ZF WITH D13 ENGINE
Improved bearings are now available to replace the original bearings used on some Prevost vehicles idler pulleys.
INTRODUCING A NEW ENGINE COOLANT INTO PREVOST SERVICE CENTER NETWORK
Rev A: Mention added concerning DDC Series 60 engine SCA requirement
INTRODUCING A NEW ENGINE COOLANT INTO SERVICE
Explains that improved bearings are now available to replace the original bearings used on some Prevost vehicles idler...
Read full bulletin
pulleys.
PREVOST: INFORMATION BEING PROVIDED REGARDING THE MODIFICATION OF D13 US07 ENGINES' IMPROVED BELT TENSIONER TO PROLONG BELT LIFE.
Read full bulletin
*PE
PREVOST: VOLVO D13 ENGINE CORRECTION OF THE DRV CONTROL VALVE AIR SUPPLY CIRCUIT.
Read full bulletin
*KB UPDATED ON 5/9/2012. *KB
PREVOST: VOLVO D13 ENGINE - TURBOCHARGER SMART REMOTE ACTUATOR (SRA) FAULTS.
Read full bulletin
*KB
PREVOST: VOLVO D13 ENGINE - NEW EGR MIXER INLET TUBE.
Read full bulletin
*KB
PREVOST: VOLVO D13 ENGINE OIL SEEPAGE AT UNIT INJECTOR HARNESS PASS-THROUGH FITTING.
Read full bulletin
*KB
PREVOST: VOLVO D13 ENGINE - AFTERTREATMENT HYDROCARBON INJECTOR (AHI) FUEL LINE FITTINGS - PROPER TIGHTENING VERIFICATION.
Read full bulletin
*KB
PREVOST: VOLVO D13 ENGINE HARNESS REPLACEMENT - OIL SEEPAGE AT UNIT INJECTOR PASS - THROUGH FITTING.
Read full bulletin
*KB
PREVOST: ON VOLVO D13 ENGINES DASHBOARD 'CHECK ENGINE' WARNING LAMP COULD COME ON DUE TO CODE PID 110.
Read full bulletin
ALSO INCLUDED MODEL MTH XLL45E BUS MODEL YEAR 2009 *JS
PREVOST: CHECK IF VOLVO ENGINES ARE NOT EQUIPPED WITH 'DAVCO FUEL PRO 382' FILTER ARE FITTED WIH TWO FUEL FILTERS.
Read full bulletin
*JS
PREVOST: ON VOLVO D13 ENGINES DASHBOARD 'CHECK ENGINE' WARNING LAMP COULD COME ON DUE TO CODE PID 171.
Read full bulletin
ALSO INCLUDED MODEL MTH XLII-45E BUS SHELLS MODEL YEAR 2009. *JS
PREVOST: MODIFICATION OF THE AIR SUPPLY CIRCUIT FOR THE TP3-DC TRAILER BRAKE CONTROL VALVE.
Read full bulletin
ALSO INCLUDED MODEL VIP MOTORHOMES MODEL YEARS 2007-2009; MODELS XLII MOTORHOMES AND ENTERTAINER XLII MODEL YEARS 2008-2009. *JS
PREVOST: INSPECTING THE RADIATOR FAN DRIVE MECHANISM SUPPORT ON A DETROIT DIESEL ENGINE.
Read full bulletin
ALSO INCLUDED MODEL VIP-45 BUS MODEL YEARS 2001-2010; MODEL XLII MTH BUS MODEL YEARS 2008-2009. *JS
PREVOST: VOLVO D13 ENGINE: REPLACEMENT OF COPPER INJECTOR SLEEVE WITH CONICAL STAINLESS STEEL INJECTOR SLEEVE.
Read full bulletin
*KB UPDATED 5/4/2012. *KB
PREVOST: VOLVO D13 ENGINE- WATER PUMP REPLACEMENT (REF.
Read full bulletin
SP262-003). *JS
PREVOST: VOLVO D13 ENGINE WITH VEB (VOLVO ENGINE BRAKE)- ROCKER ARMS REPLACEMENT & CAMSHAFT INSPECTION (REF.
Read full bulletin
SP215-015) CONTACT YOUR PREVOST REGIONAL SERVICE MANAGER TO FIND OUT THE NEAREST SERVICE CENTER LOCATION. *JS
PREVOST: REPLACEMENT OF THE DASHBOARD STATIONARY REGENERATION SWITCH- DETROIT DIESEL ONLY.THIS SWITCH WOULD NOT BE ABLE...
Read full bulletin
TO INITIATE A STAIONARY REGENERATION AFTER DDEC VI SOFTWARE UPGRADE. ALSO INCLUDED MODEL VIP MOTORHOMES MODEL YEARS 2007-2008; MODEL XLII MOTORHOMES MODEL YEAR 2008; MODEL ENTERTAINER MODEL YEARS 2008-2009. *JS
Other
12 bulletinsThe gasket thickness was increased from 1.5 mm to 3 mm to prevent interference between the collar ends, which previously...
Read full bulletin
made it impossible to reach the specified tightening torque. Increasing the gasket thickness ensures sufficient clearance between the collar ends and thus guarantees optimal tightening.
Air Tanks Draining Sequence.
Read full bulletin
Revision: A - Erroneous Secondary & Accessory tanks location.
Air Tanks Draining Sequence
X3 SERIES ENVIROCARE - IONS AIR SANITIZER
X3 SERIES ENVIROCARE - IONS AIR SANITIZER
PREVOST VEHICLE DISINFECTION PROCEDURE
HAND SANITIZER DISPENSER INSTALLATION
On vehicles mentioned above, should the curbside electric sunshade fail to operate without encountering a drive...
Read full bulletin
mechanism issue, perform the following procedure.
On the vehicles affected by this bulletin, replace the existing positive booster block and cable terminal by a protected...
Read full bulletin
assembly.
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
PREVOST: SOME BUSES NEED TO HAVE PROTECTED ASSEMBLY FOR REPLACING OF THE EXISTING POSITIVE BOOSTER BLOCK AND CABLE TERMINAL.
Read full bulletin
MODEL 2008-10 X3-45. *PE
PREVOST: INFORMATION BEING PROVIDED REGARDING THE REPLACEMENT OF DIPSTICK ON CERTAIN COACHES.
Read full bulletin
MODELS 2009-2013 H3-45, H3-41, X3-45, XL11-45, X3-45. *PE
Steering
5 bulletinsSTEERING GATEWAY. Revision B - PIN 2 and 10 were inverted on connector A139
STEERING GATEWAY Revision A Cancel watch dog removal from EFD part of the instruction
TIE ROD 610052 FIRST INSTALLATION INSTRUCTIONS: Use these instructions when replacing the drop joint tie rod on S82, S84 / S84U I-beam axles.
Read full bulletin
The new tie rod will be adjusted to the length of the original; however, a steering alignment needs to be performed after replacement.
Vehicles identified below are compatible with a new tie rod design.
Read full bulletin
This new tie rod 610052 has updated ball joints and a fine adjuster sleeve. It replaces former drop type ball joint tie rods. Refer to IS-18091 for installation instructions. This document details maintenance inspection and toe-in adjustment with the new design tie rod.
POWER STEERING PUMP DISCHARGE HOSE (PRESSURE) REPLACEMENT
Electrical
5 bulletinsSound Selector replacement, VSS04 to VSS05; When replacing a vehicle sound selector model VSS04 with a new sound...
Read full bulletin
selector model VSS05, an interface harness is required to connect the vehicle harness to the new sound selector model and a new VSS05 compatible radio unit must also be installed. This procedure describes the steps required to perform this update.
Added: Power cables for L.H.
Read full bulletin
side alternator & fan drive breaker box
WHEN REPLACING A VEHICLE SOUND SELECTOR MODEL VSS04 WITH A NEW SOUND SELECTOR MODEL VSS05, AN INTERFACE HARNESS IS...
Read full bulletin
REQUIRED TO CONNECT THE VEHICLE HARNESS TO THE NEW SOUND SELECTOR MODEL AND A NEW VSS05 COMPATIBLE RADIO UNIT MUST ALSO BE INSTALLED. THIS PROCEDURE DESCRIBES THE STEPS REQUIRED TO PERFORM THIS UPDATE.
PREVOST: REPLACING T1 BOSCH ALTERNATORS AND WATER PUMP BELT TENSIONERS.
Read full bulletin
*KB
PREVOST: REPROGRAMMING OF I/O-A & I/O-B MODULES FOR IMPLEMENTATION OF THE ESSENTIAL FUNCTIONS TO OPERATE THE VEHICLE (BASIC LIMP-HOME FUNCTIONS).
Read full bulletin
*KB
Software & Calibration
4 bulletinsAir Tanks Draining Sequence.
Read full bulletin
Revision: B - General Update
STORAGE AND STARTUP GUIDELINES : part number updates
ITEM 5060078 WAS 5002151, ITEMS 530175 and 641074 ADDED, SOME STEPS ADDED AND SOME UPDATED
PREVOST: KIDDE FIRE EXTINGUISHER CONTROL HEAD REPLACEMENT.
Read full bulletin
*KB UPDATED 5/9/2012. *KB
HVAC & Climate
4 bulletinsCENTRAL HVAC MERV FILTERS INSTALLATION
CENTRAL HVAC MERV FILTERS INSTALLATION REVA
This Maintenance Information explains how to run a n Air Conditionning performance test
PREVOST: 12" BRUSHLESS CONDENSER FAN REPLACEMENT.
Read full bulletin
MODELS INCLUDE XLII MTH, AND H3VIP MTH. MODEL YEARS ARE 2008-2011. *KB
Transmission
4 bulletinsFAN CLUTCH PLATE BOLTS RE-TORQUING
JERKY, NOISY OR HARD TO TURN STEERING GEARBOX.
Read full bulletin
HYDRAULIC END LIMITER ADJUSTMENT. All models equipped with RB Bosch/ZF Servocom or Servocomtronic steering gearbox
This Maintrenance infomration explains that the Castrol Syntrans oil isn?t fully approved for 500 000 miles (800 000 km)...
Read full bulletin
extended drain intervals on the Volvo I-Shift transmission. For this reason, this oil has been downgraded to regular drain intervals. Find below, a list of Volvo?s approved oils for extended drain as well as regular drain intervals.
PREVOST: INSTALLIN AN AIR DEFLECTOR IN ORDER TO REDUCE AMBIENT TEMPERATURE AROUND LINNIG RADIATOR FAN GEARBOX.
Read full bulletin
*KB
Suspension
3 bulletinsSway bar collars improvement.
Read full bulletin
Revision A : Add front sway bar support replacement and change bolts lenght.
SWAY BAR COLLARS IMPROVEMENT
RONT & TAG AXLE UNITIZED HUB BEARING END PLAY VERIFICATION AND REPLACEMENT
Pre-Delivery & Maintenance
3 bulletinsSTORAGE AND STARTUP GUIDELINES: Periodically, circumstances arise requiring operators to temporarily park a coach in storage.
Read full bulletin
Whether it is a few weeks or several months, sporadic out of service times or a full stop, Prevost recommends following the guidelines in this document during times when: The coach can be operated on a regular/weekly basis while in storage. The coach will be in storage for an extended period without any operation. The coach will return to service following an extended period of downtime.
STORAGE AND STARTUP GUIDELINES Revision: B Parts added to Suggested Material 08-10-2020
STORAGE AND STARTUP GUIDELINES - ALL PREVOST VEHICLES & VOLVO 9700
Body & Paint
2 bulletinsPlexiglass Panel Behind Driver X3
This instruction sheet explains how to install 780428 door actuator replacement.
Lighting
1 bulletinHalogen to LED fog light replacement kit.
Read full bulletin
Revision: C - Advanced kits canceled
Hybrid & EV
1 bulletinSTORAGE AND STARTUP GUIDELINES: Rev A: 21516229 replaced by 23381562 20523393 replaced by 21454749 800383 removed ...
Read full bulletin
611471 replaced by 611360 70376808 replaced by 21036050 21396642 replaced by 20967831
Infotainment
1 bulletinMP-1000 MULTIMEDIA PLAYER INSTALLATION