2008 Prevost H3-Vip TSBs
37 Technical Service Bulletins across 12 categories
Categories
Engine
10 bulletinsImproved bearings are now available to replace the original bearings used on some Prevost vehicles idler pulleys.
INTRODUCING A NEW ENGINE COOLANT INTO PREVOST SERVICE CENTER NETWORK
Rev A: Mention added concerning DDC Series 60 engine SCA requirement
INTRODUCING A NEW ENGINE COOLANT INTO SERVICE
This Maintenance Information explains how to perform an inspection of the vehicle power cables.
Read full bulletin
Power cables in poor condition can be the cause of failures and serious damages in the engine compartment.
The Beru sensors used on Prevost vehicles to monitor tire pressure (TPMS system) are being replaced by new Huf sensors...
Read full bulletin
and their corresponding stainless valves stems. Since the older and newer sensors are using different valve stems, replacement of a defective sensor on older vehicles will require the use of a new kit number (valve stem and sensor assembly). The table below provides a quick overview between the older and newer part numbers depending on wheel application.
The Beru sensors used on Prevost vehicles to monitor tire pressure (TPMS system) are being replaced by new Huf sensors...
Read full bulletin
and their corresponding stainless valves stems. Since the older and newer sensors are using different valve stems, replacement of a defective sensor on older vehicles will require the use of a new kit number (valve stem and sensor assembly). The table below provides a quick overview between the older and newer part numbers depending on wheel application.
The Beru sensors used on Prevost vehicles to monitor tire pressure (TPMS system) are being replaced by new Huf sensors...
Read full bulletin
and their corresponding stainless valves stems. Since the older and newer sensors are using different valve stems, replacement of a defective sensor on older vehicles will require the use of a new kit number (valve stem and sensor assembly). The table below provides a quick overview between the older and newer part numbers depending on wheel application.
This Instruction sheet explains how to prevent AC Copper Pipes Chaffing at Engine Bulkhead
This Instruction Sheet explains how to retrofit the DEF tank left side filler neck on H3 VIP motorhomes with central or...
Read full bulletin
small a/c system
Other
4 bulletinsAir Tanks Draining Sequence.
Read full bulletin
Revision: A - Erroneous Secondary & Accessory tanks location.
Air Tanks Draining Sequence
Slide-out Linear Bearing and Guides Kit
PREVOST VEHICLE DISINFECTION PROCEDURE
Pre-Delivery & Maintenance
4 bulletinsSTORAGE AND STARTUP GUIDELINES: Periodically, circumstances arise requiring operators to temporarily park a coach in storage.
Read full bulletin
Whether it is a few weeks or several months, sporadic out of service times or a full stop, Prevost recommends following the guidelines in this document during times when: The coach can be operated on a regular/weekly basis while in storage. The coach will be in storage for an extended period without any operation. The coach will return to service following an extended period of downtime.
STORAGE AND STARTUP GUIDELINES Revision: B Parts added to Suggested Material 08-10-2020
STORAGE AND STARTUP GUIDELINES - ALL PREVOST VEHICLES & VOLVO 9700
This Maintenance Information does explain how five year old vehicles and older should be subjected to a thorough...
Read full bulletin
structural inspection.
Electrical
4 bulletinsAdded: Power cables for L.H.
Read full bulletin
side alternator & fan drive breaker box
This Instruction sheet explains how to replace the ?MASTER ID? WITH ?MCM? Module
This Instruction sheet explains how to replace the "MASTER ID WITH MCM" Module
This Instruction sheet explains how to remplace MASTER ID? WITH ?MCM? Module
HVAC & Climate
3 bulletinsCENTRAL HVAC MERV FILTERS INSTALLATION
CENTRAL HVAC MERV FILTERS INSTALLATION REVA
This Instruction Sheet explains how to use Retrofit kit for obsoleted small AC condensers (950018 & 950335)
Body & Paint
3 bulletinsThis instruction sheet explains how to install 780428 door actuator replacement.
The light switch may operate incorrectly when doors are closed for vehicles affected by this bulletin.
Read full bulletin
Corrective action is presented.
This Maintenance Information explains that polyester reinforced silicone hoses and elbowscan be repalced by aramid...
Read full bulletin
reinforced hoses and elbows for improved long term durability, and that constant torque hose clamps for silicone hoses with 5/8po, 3/4po, 7/8po, 1 1/8po and 1 3/8po inside diameter (I.D) can be replaced by new WAVE SEAL type constant torque hose clamps.
Software & Calibration
2 bulletinsAir Tanks Draining Sequence.
Read full bulletin
Revision: B - General Update
STORAGE AND STARTUP GUIDELINES : part number updates
Lighting
2 bulletinsHalogen to LED fog light replacement kit.
Read full bulletin
Revision: C - Advanced kits canceled
Use this maintenance information procedure to resolve an undesired behaviour on 2008-2012 vehicles.
Read full bulletin
In sleep mode, certain marker lights may remain illuminated.
Brakes
2 bulletinsThis instructions sheet explains how to program a Wabco Smart Trac ABS ECU.
This Instruction Sheet explains how to install Keyless Keypad using either kit 069140 or 069141
Steering
1 bulletinSTEERING GATEWAY. Revision B - PIN 2 and 10 were inverted on connector A139
Transmission
1 bulletinJERKY, NOISY OR HARD TO TURN STEERING GEARBOX.
Read full bulletin
HYDRAULIC END LIMITER ADJUSTMENT. All models equipped with RB Bosch/ZF Servocom or Servocomtronic steering gearbox
Hybrid & EV
1 bulletinSTORAGE AND STARTUP GUIDELINES: Rev A: 21516229 replaced by 23381562 20523393 replaced by 21454749 800383 removed ...
Read full bulletin
611471 replaced by 611360 70376808 replaced by 21036050 21396642 replaced by 20967831