2003 Prevost H3-45 TSBs
38 Technical Service Bulletins across 13 categories
Categories
Other
8 bulletinsH3 LAVATORY FAN RETROFIT KIT
Air Tanks Draining Sequence.
Read full bulletin
Revision: A - Erroneous Secondary & Accessory tanks location.
Air Tanks Draining Sequence
Revision : A Torque value reduced
LAVATORY FAN RETROFIT KIT Applicable for H3 Series coaches from R-1012 (1994) Revision A: Added installation detail at...
Read full bulletin
step 8
H3 DRIVERS PARTITION LITE INSTALLATION
PREVOST VEHICLE DISINFECTION PROCEDURE
HAND SANITIZER DISPENSER INSTALLATION
Steering
6 bulletinsSTEERING GATEWAY. Revision B - PIN 2 and 10 were inverted on connector A139
TIE ROD 610052 FIRST INSTALLATION INSTRUCTIONS: Use these instructions when replacing the drop joint tie rod on S82, S84 / S84U I-beam axles.
Read full bulletin
The new tie rod will be adjusted to the length of the original; however, a steering alignment needs to be performed after replacement.
This Instruction Sheet explains how to perform the first installation of Tie Rod 610052 on Prevost vehicles equipped...
Read full bulletin
with Dana S82, S84 / S84U I-beam axles, 1994- today
Vehicles identified below are compatible with a new tie rod design.
Read full bulletin
This new tie rod 610052 has updated ball joints and a fine adjuster sleeve. It replaces former drop type ball joint tie rods. Refer to IS-18091 for installation instructions. This document details maintenance inspection and toe-in adjustment with the new design tie rod.
This instruction sheet explains how to install the Tie Rod 610052.
INSPECTION & REPLACEMENT OF POWER STEERING PRESSURE HOSE.
Read full bulletin
PREVOST. *TT
Transmission
4 bulletinsFAN CLUTCH PLATE BOLTS RE-TORQUING
JERKY, NOISY OR HARD TO TURN STEERING GEARBOX.
Read full bulletin
HYDRAULIC END LIMITER ADJUSTMENT. All models equipped with RB Bosch/ZF Servocom or Servocomtronic steering gearbox
THIS INSTRUCTION SHEET EXPLAINS HOW TO REPLACE CLUTCH AND RADIATOR FAN TRANSFER MECHANISM MOUNTING BASE
MODIFICATION OF SPEED SENSOR CONNECTORS ON ALLISON WORLD TRANSMISSION.
Read full bulletin
PREVOST. *TT
Suspension
3 bulletinsSway bar collars improvement.
Read full bulletin
Revision A : Add front sway bar support replacement and change bolts lenght.
SWAY BAR COLLARS IMPROVEMENT
PREVOST: OIL LUBRICATED WHEEL HUB BEARINGS.
Read full bulletin
FOR MAXIMUM PERFORMANCES AND SAFETY, ENSURING THAT THE WHEEL HUBS ARE INSPECTED DAILY AND LUBRICATED IN REGULAR INTERVALS IS OF THE UTMOST IMPORTANCE. *JS
Pre-Delivery & Maintenance
3 bulletinsSTORAGE AND STARTUP GUIDELINES: Periodically, circumstances arise requiring operators to temporarily park a coach in storage.
Read full bulletin
Whether it is a few weeks or several months, sporadic out of service times or a full stop, Prevost recommends following the guidelines in this document during times when: The coach can be operated on a regular/weekly basis while in storage. The coach will be in storage for an extended period without any operation. The coach will return to service following an extended period of downtime.
STORAGE AND STARTUP GUIDELINES Revision: B Parts added to Suggested Material 08-10-2020
STORAGE AND STARTUP GUIDELINES - ALL PREVOST VEHICLES & VOLVO 9700
Engine
3 bulletinsRev A: Mention added concerning DDC Series 60 engine SCA requirement
INTRODUCING A NEW ENGINE COOLANT INTO SERVICE
Engine Exhaust Gas Recirculation Differential Pressure - Mechanical system not responding properly US13 US20...
Read full bulletin
Emissions
Lighting
2 bulletinsHalogen to LED fog light replacement kit.
Read full bulletin
Revision: C - Advanced kits canceled
REPLACEMENT OF HOSES AND CLAMPS AND VERIFICATION OF MINIMUM CLEARANCE ON THE CHARGE AIR COOLER (CAC) SYSTEM.
Read full bulletin
PREVOST WARRANTY BULLETIN. VARIOUS PREVOST 2004 MODELS. *TT
HVAC & Climate
2 bulletinsCENTRAL HVAC MERV FILTERS INSTALLATION
CENTRAL HVAC MERV FILTERS INSTALLATION REVA
Electrical
2 bulletinsAdded: Power cables for L.H.
Read full bulletin
side alternator & fan drive breaker box
ELIMINATION OF CONNECTOR C530, C531 & C532 FROM THE INTERIOR FLUORESCENT LIGHTING AND READING LIGHTS FUSE HOLDER.
Read full bulletin
THIS INCLUDES MODEL YEAR 2004 MODELS. *TT
Infotainment
2 bulletinsMP-1000 MULTIMEDIA PLAYER INSTALLATION
MESSAGE CENTER DISPLAY (MCD) REPLACEMENT
Software & Calibration
1 bulletinAir Tanks Draining Sequence.
Read full bulletin
Revision: B - General Update
Hybrid & EV
1 bulletinSTORAGE AND STARTUP GUIDELINES: Rev A: 21516229 replaced by 23381562 20523393 replaced by 21454749 800383 removed ...
Read full bulletin
611471 replaced by 611360 70376808 replaced by 21036050 21396642 replaced by 20967831
Fuel System
1 bulletinThis instruction sheets explains how to replace the fuel tank on H-series vehicles.
Read full bulletin
(Replacing older series tanks by newer model)