2006 Prevost H3-41 TSBs
44 Technical Service Bulletins across 14 categories
Categories
Other
10 bulletinsH3 LAVATORY FAN RETROFIT KIT
Air Tanks Draining Sequence.
Read full bulletin
Revision: A - Erroneous Secondary & Accessory tanks location.
Air Tanks Draining Sequence
Revision : A Torque value reduced
LAVATORY FAN RETROFIT KIT Applicable for H3 Series coaches from R-1012 (1994) Revision A: Added installation detail at...
Read full bulletin
step 8
H3 DRIVERS PARTITION LITE INSTALLATION
PREVOST VEHICLE DISINFECTION PROCEDURE
PREVOST: REPLACE DECAL IN THE MAIN POWER COMPARTMENT.
Read full bulletin
CB11 WAS CHANGED FROM 35A TO 50A. *JS
PREVOST - INSTALLING DECAL WARNING AGAINST PERFORMING ANY WELDING WORK.
Read full bulletin
*NJ
DECAL REPLACEMENT IN THE MAIN POWER COMPARTMENT.
Read full bulletin
*KB
Engine
7 bulletinsRev A: Mention added concerning DDC Series 60 engine SCA requirement
INTRODUCING A NEW ENGINE COOLANT INTO SERVICE
This Maintenance Information explains how to install harness #7770134, designed to bypass the Engine Compartment Harness...
Read full bulletin
(Prevost part), connecting the DPF harness (10-pin connector) and the Engine Harness (31-pin connector).
This instruction sheet explains how to relocate engine door gas spring.
This instruction sheet explains how to relocate engine door gas spring.
POWER WINDOW HARNESS- REMOVAL OF ZENER SUPPRESSOR DIODES.
Read full bulletin
A FAULTY DIODE WILL CAUSE THE BURNING OF THE FUSE PROTECTING THE CIRCUIT. ALSO INCLUDED MODEL XLII-40, XLII-45 MOTORHOMES & ENTERTAINER XLII-45. MODEL YEARS 2007-2008. MODEL VIP MOTORHOMES. MODEL YEARS 2006-2007. *JS
PREVOST: NEW FIXING HARDWARE FOR THE REAR HEIGHT CONTROL VALVE LINK ROD.
Read full bulletin
THERE IS A POSSIBILTY THAT THE LINK ROD THAT CONNECTS THE HEIGHT CONTROL VALVE TO THE DRIVE AXELS SUPPORT FRAME COMES APART WHEN THE VEHICLE IS MOVING. MODEL VIP-45MTH MODEL YEAR 2004 ALSO INCLUDED. *JS
Steering
4 bulletinsTIE ROD 610052 FIRST INSTALLATION INSTRUCTIONS: Use these instructions when replacing the drop joint tie rod on S82, S84 / S84U I-beam axles.
Read full bulletin
The new tie rod will be adjusted to the length of the original; however, a steering alignment needs to be performed after replacement.
This Instruction Sheet explains how to perform the first installation of Tie Rod 610052 on Prevost vehicles equipped...
Read full bulletin
with Dana S82, S84 / S84U I-beam axles, 1994- today
Vehicles identified below are compatible with a new tie rod design.
Read full bulletin
This new tie rod 610052 has updated ball joints and a fine adjuster sleeve. It replaces former drop type ball joint tie rods. Refer to IS-18091 for installation instructions. This document details maintenance inspection and toe-in adjustment with the new design tie rod.
This instruction sheet explains how to install the Tie Rod 610052.
Transmission
4 bulletinsFAN CLUTCH PLATE BOLTS RE-TORQUING
JERKY, NOISY OR HARD TO TURN STEERING GEARBOX.
Read full bulletin
HYDRAULIC END LIMITER ADJUSTMENT. All models equipped with RB Bosch/ZF Servocom or Servocomtronic steering gearbox
PREVOST: REMOVE ZF TRANSMISSION NEUTRAL POSITION RELAY ON H3 MULTIPLEX VEHICLES.
Read full bulletin
RELAY INDICATING THAT ZF TRANSMISSION IS IN NEUTRAL POSITION MUST BE REMOVED TO AVOID FUSE BURNING AND TO BE STANDARDIZED WITH OTHER VEHICLES. *JS
REMOVAL OF ZF TRANSMISSION NEUTRAL POSITION RELAY ON H3 MULTIPLEX VEHICLES.
Read full bulletin
*KB
Suspension
3 bulletinsSway bar collars improvement.
Read full bulletin
Revision A : Add front sway bar support replacement and change bolts lenght.
SWAY BAR COLLARS IMPROVEMENT
FRONT AND TAG AXLE HUB BEARING AND KING PIN PERIODIC MAINTENANCE.
Read full bulletin
BEARINGS MUST BE INSPECTED AT INTERVALS OF 30,000 MILES (48 000KM). KING PINS SHOULD BE SERVICED EVERY 6, 250 MILES (10,000 KM) OR TWICE A YEAR. ALSO INCLUDED MODEL VIP-45 MTH MODEL YEARS 2004-2008. MODEL XLII MTH MODEL YEARS 2004-2008. *JS
HVAC & Climate
3 bulletinsCENTRAL HVAC MERV FILTERS INSTALLATION
CENTRAL HVAC MERV FILTERS INSTALLATION REVA
This instruction sheet explains how to replace the two older generation (brush type) condenser fans by four newer style...
Read full bulletin
(brushless) fans.
Pre-Delivery & Maintenance
3 bulletinsSTORAGE AND STARTUP GUIDELINES: Periodically, circumstances arise requiring operators to temporarily park a coach in storage.
Read full bulletin
Whether it is a few weeks or several months, sporadic out of service times or a full stop, Prevost recommends following the guidelines in this document during times when: The coach can be operated on a regular/weekly basis while in storage. The coach will be in storage for an extended period without any operation. The coach will return to service following an extended period of downtime.
STORAGE AND STARTUP GUIDELINES Revision: B Parts added to Suggested Material 08-10-2020
STORAGE AND STARTUP GUIDELINES - ALL PREVOST VEHICLES & VOLVO 9700
Electrical
3 bulletinsAdded: Power cables for L.H.
Read full bulletin
side alternator & fan drive breaker box
This internal instruction explains how to bench program the FMS gateway module used in the ELD (Electronic Logging...
Read full bulletin
Device) interface kit for pre-OBD13 vehicles.
This Instruction sheet explains how to remplace MASTER ID? WITH ?MCM? MODULE
Infotainment
2 bulletinsMESSAGE CENTER DISPLAY (MCD) REPLACEMENT
This instruction sheet explains how to install the Audio Converter 405842
Software & Calibration
1 bulletinAir Tanks Draining Sequence.
Read full bulletin
Revision: B - General Update
Hybrid & EV
1 bulletinSTORAGE AND STARTUP GUIDELINES: Rev A: 21516229 replaced by 23381562 20523393 replaced by 21454749 800383 removed ...
Read full bulletin
611471 replaced by 611360 70376808 replaced by 21036050 21396642 replaced by 20967831
Fuel System
1 bulletinThis instruction sheets explains how to replace the fuel tank on H-series vehicles.
Read full bulletin
(Replacing older series tanks by newer model)
Air Bags & Safety
1 bulletinPREVOST: INSTALLING THREE-POINT PASSENGER SEAT RESTRAINT SYSTEM.
Read full bulletin
THE PURPOSE OF THE FOLLOWING PROCEDURE IS TO FACILITATE THE JOB AND TO HELP IDENTIFY THE DIFFICULT AREAS. ALSO INCLUDED MODELS HE-41 AND HE-45 COACHES MODEL YEARS 1998-2008; MODEL XLII AND X3-45 COACHES MODEL YEARS 1998-2008. *JS
Body & Paint
1 bulletinIMPROVED AIR CIRCULATION ON H3 COACHES EQUIPPED WITH WCL AND SLIDING DOOR.
Read full bulletin
IN ORDER TO IMPROVE THE PASSENGERS COMFORT IT IS NECESSARY TO INCREASE THE AIR CIRCULATION IN THE OVERHEAD COMPARTMENT AS WELL AS BEHIND THE WHEELCHAIR LIFT DOOR. *JS