2016 Porsche Macan TSBs
569 Technical Service Bulletins across 16 categories
Categories
Other
149 bulletinsTechnical Information for Damage to Nano Plug Contacts Due to Utilization of Incorrect Measuring Equipment
Special Tools and Equipment Information for Diagnostic Equipment Standards for all USA Porsche Centers
Porsche Approved Collision Center Acquiring Special Tools and Equipment
Porsche Approved Collision Center Acquiring Special Tools and Equipment
Parts Withdrawal - Various Parts
Parts Withdrawal - Various Parts
Parts Withdrawal - Various Parts
Porsche Approved Collision Center Acquiring Special Tools and Equipment
Tech live look information bulletin for How to use Frontline.io on the HoloLens 2
Tech live look information bulletin for how to use fronline.io on mobile devices and tablets.
Parts information for Parts Withdrawal - Oil Pressure Sender.
Read full bulletin
The vehicles affected are ones that use the part number PAB906060.
Parts information for parts withdrawal involving various parts.
Read full bulletin
The vehicles affected are ones that use the part numbers mentioned. Part numbers: 0PD145703E, 0PD145703H, 0PD907123G, 0PD907123K
Symptom based workshop manual involving the Belt Lock Warning on Driver's Side Permanently Active in Conjunction with...
Read full bulletin
Fault Memory Entry with Regard to Belt Lock Switch "B101C07". The vehicles affected are listed in the attached PDF.
Parts information for parts withdrawal - CTRL UNIT.
Read full bulletin
Part number 9J1035287C. The vehicles involved are ones that use the part number mentioned.
Parts information for parts withdrawal involving the cover - 95C867769A.
Read full bulletin
The vehicle(s) affected are ones that use the part number mentioned.
Special tools and equipment information for PACC information
Parts information for parts withdrawal involving (95C615269E) Coolant Pump.
Read full bulletin
The vehicles affected are ones that use the part number mentioned
Parts information for parts withdrawal involving the bellows.
Read full bulletin
Part number 9P1501136 is affected. The vehicles affected are ones that use the part number mentioned.
Parts information for parts withdrawal involving the lock 95C827447A.
Read full bulletin
The vehicles affected are ones that use the part number listed.
Parts information for parts withdrawal involving the coolant pump.
Read full bulletin
Part numbers involved are 0PB121010G and 0PB121005E. The vehicles affected are cars that use the part numbers mentioned.
Parts information for parts withdrawal involving the coolant pump.
Read full bulletin
The part number involved is PAB121014C. The vehicles affected are cars that use the part number mentioned.
Parts information for parts withdrawal involving the power mod - 95B941329A.
Read full bulletin
the vehicles affected are ones that use the part number mentioned.
Parts information for parts withdrawal involving the actuating lever.
Read full bulletin
The part numbers mentioned are in the attached PDF
Parts information for parts withdrawal involving the Thermostat (PAB121115C).
Read full bulletin
The cars affected are ones that use this part number.
Parts information for parts withdrawal involving the thermostat on certain vehicles.
Read full bulletin
The cars affected are cars that use part number PAB121115D
Parts information for Parts Withdrawal - Warning Sign (1EA010505).
Read full bulletin
The vehicles affected use the part number mentioned.
Parts information for parts withdrawal involving the belt latch.
Read full bulletin
9Y0857755D and 9Y0857755E, the vehicles affected use the part numbers mentioned.
Parts information for Parts Withdrawal - Air Line (9Y1616719 & 9Y2616719).
Read full bulletin
The vehicles affected are cars that use the part numbers mentioned
Parts information for parts withdrawal involving the belt latch.
Read full bulletin
Part numbers 9Y0857755D & 9Y0857755E are involved. The vehicles considered would use the part numbers mentioned.
Parts information for parts withdrawal involving the belt latch - part numbers 992857756E & 992857755D.
Read full bulletin
The vehicles affected are cars that use the part numbers mentioned
Special tools and equipment information for snap-on (SBS) pricing adjustments
Tech live look information for dynamics 365 remote assist environment verification steps.
Read full bulletin
Includes all Porsche models
Tech live look information for dynamics 365 remote assist user guide
Parts information for parts withdrawal involving Adhesive Tape (9GT827972B).
Read full bulletin
The vehicles are not listed, but the affected cars are ones that use the part number mentioned.
Parts information for Parts Withdrawal -Coolant pipe (PAB12113103).
Read full bulletin
Vehicles not listed, but the affected cars are ones that use part number PAB12113103
Parts information for parts withdrawal involving all the part numbers below.
Read full bulletin
The vehicles affected are cars that use the part numbers in the PDF. 9Y0919620E, 9Y1919599H, 9Y2919599H, 976919597E, 976919599F, 977919599F, 9J1919597AE, 9J1919599AF, 9J1919599AG, 992919597AH, 992919597AJ
Parts information for parts withdrawal involving the part numbers below.
Read full bulletin
The vehicles affected are cars that use the part numbers listed. 971260601SX, 971260601SU, 971260601RU, 971260601QX, 971260601QU, 971260601Q
Parts information for parts withdrawal involving part number 9A7317801D.
Read full bulletin
The vehicles affected are cars that use the part number.
Parts information for parts withdrawal involving the high pressure injector (0PB128615C)
Parts information for parts withdrawal involving various parts.
Read full bulletin
Please refer to the attached PDF for list of affected part numbers.
Technical information Loss of a Drivers Key While Transporting the Vehicle
Special tools and equipment information for New MRT Toolbox Foam Organizational System
Tech live look information for dynamics 365 remote assist application.
Read full bulletin
Please ignore previous submission for this as this provides the correct date.
Parts information for parts withdrawal involving the 2k pane adhesive.
Read full bulletin
Vehicles affected are cars that use part number 00004330535
Tech live look information for dynamics 365 remote assist application
Parts information for parts withdrawal involving the 2k pane adhesive.
Read full bulletin
The vehicles affected are cars that use part number 00004330535
Parts information for parts withdrawal involving all the part numbers listed in the PDF.
Read full bulletin
The vehicles affected are cars that use the mentioned part numbers.
Parts information for Parts Withdrawal - Adhesive Tape (9GT827972B).
Read full bulletin
Vehicles affected are cars that use part number 9GT827972B
Tech live look information on transition to dynamics 365 remote assist
Special tools and equipment information for data signal strength and speed in the Porsche Center - MRT Requirments
Special tools and equipment information for model logo templates available for rent.
Read full bulletin
The affected vehicles are cars that are listed in the attached PDF.
Tech live look information for all Porsche models - inspectron tools product improvement communication
Parts information for parts withdrawal involving 992501201K.
Read full bulletin
The vehicles affected are cars that use the part number in the PDF.
Parts Information - Parts Withdrawal - Hexagon Flange Screw (Combi)
Symptom-based workshop manual - Noise Symptom-Strong Vibrations During Acceleration: Replacing Front Drive Shafts (SY...
Read full bulletin
16/15)
Parts information with parts withdrawal involving the hydro-mounting - 992199384F The affected vehicles are cars that...
Read full bulletin
use the part number mentioned.
Parts information for parts withdrawal involving the oil separator.
Read full bulletin
The affected vehicles are cars that use part number 0PC115099A
Special tools and equipment information for the WiScope UV upgrade - affecting all Porsche models
Special tools and equipment information for the mobile data signal strength in the workshop
Parts information for parts withdrawal involving the booster - 7PP035223M, 7PP035223AA, 99164548000.
Read full bulletin
Vehicles affected are cars that use the part numbers listed.
Parts information for parts withdrawal involving the chain tensioner - 0PB109507D
Parts information for parts withdrawal involving the seat frame - 992885456CY
Parts information for parts withdrawal involving the booster - 7PP035223M, 7PP035223AA, and 99164548000
Parts information for parts withdrawal involving the wire set - 976971227 & 976971227A
Parts information for parts withdrawal involving the ball screw - PAF004835
Special tools and equipment information VAS6292 Hunter Aligner License Program Change
Technical information for a loss of drivers key while transporting vehicle
Parts information for parts withdrawal for spoiler matt black/drive unit
Technical information on a loss of a drivers key while transporting the vehicle.
Symptom-based workshop manual for the noise symptom - strong vibrations during acceleration - replacing front drive...
Read full bulletin
shafts
Technical information for an assessment of cracks on elastomer bearings on the front and rear axles.
Instructions on advanced technical information for the new water drain nozzle on the Macan.
Instructions on advanced technical information for the permanent diagnostic trouble codes
Technical information on WMM7 - replacing VTS control unit
Installation and conversion instructions for the Porsche rear seat entertainment
Instructions on advanced technical information for the Macan - new water drain nozzle.
Special tools and equipment information for all Porsche models.
Read full bulletin
Diagnostic equipment standards.
Special tools and equipment information for the Pico Oscilloscope Extended Functionality
Parts information for parts withdrawal on the locks made to original key code
Parts information on parts withdrawal for the oil pump
Special tools information on an upgrade to the pushers for the VAS5237
Special tools information for the pneumatic cartridge gun.
Installation and conversion instructions for the trailer hitch on the Macan from MY14-18
Instructions on advanced technical information for improper odometer and speedometer function
Special tools information for the logo templates and exchangeable inserts.
Special tools information for welding tools for the 911, 718, Macan, Panamera, Cayenne, Taycan.
Parts information for parts withdrawal involving the gateway
Special tools information for new blitz table replacement castors.
Special tools information for HV lift tools kit - for the Macan, Panamera, Cayenne, and Taycan
Special tools information for the TKR connector kit for the Macan.
Advanced technical information for WMM7.
Information on WMM7 - replacing VTS control unit.
Technical information for WMM7 - replacing VTS control unit.
Installation and conversion instructions on the loading sill guard.
Installation and conversion instructions for retrofitting loading sill guard.
Technical information on WMM7 - replacing VTS control unit.
Special tools information for logo templates and exchangeable inserts.
Special tools information for a new contact surface cleaning set.
Installation and conversion instructions for retrofitting a bicycle rack on a variety of vehicles.
Information on new special tool requirements for all vehicles.
Special tools information for a 12V Power Supply for PT3G Oscilloscope.
Special tools information for new VAS 5908 Requirements.
Special tools information on new Redline Dual Purpose Diagnostic Leak Locator.
Information on new PIWIS Tester program for independent repair facilities.
Loading Sill Guard - Concern Retrotitting model as of 2014
1997 to Present - Vehicle Analysis Log Types - In an effort to prode accurate information regarding the state of the...
Read full bulletin
vehicle at the time fof VAL creation, a "log type" drop down menu was added at the end of the VAL creation menu.
The Approval and Support Management Program (ASM)
Special tools information for pinout tool box tools.
Historical information on Porsche product evolution.
Instructions for what to do if the selector lever position P is not detected and the driver's key cannot be removed.
New parts promotion for all weather mats and cargo liner.
Parts withdrawal information for a tube used on the Macan.
Special tools information on Logo Templates and exchangeable inserts.
Special tools information on Logo templates and exchangeable inserts.
Special tools information on renting logo templates.
Installation instructions for putting snow chains on the Macan.
Advanced Technical information on a NVH Lubrication kit.
Parts withdrawal information for a Macan water pump.
Information on Parts withdrawal of a buffer for the Macan.
Information on replacing the control unit for the auxiliary alarm system in the event of fault codes.
Information on new special tool - VAS 891 001 Pneumatic Glue Gun.
Information on new special tool - VAS 1978/35 Connector Release Tools.
Instructions on replacing the front drive shafts on the Macan.
Information on new special tool - Pinout/Diag Tool Box w/ Foam
Information on a new pressure loss tester for all new models.
Instructions for retrofitting a trailer hitch on the MY14-18 Macan.
Instructions for how to assist if the selector lever is in Park position but not detected, and the key cannot be...
Read full bulletin
removed.
Recommendations on how to store any Porsche vehicle since 2009.
Document showing the evolution of Porsche Vehicles since 1948.
Installation and Conversion instructions for installing a Cool Bag on several models.
Information on a parts withdrawal of an outdated diagnosis pump.
Information on a new recommended smoke machine.
Information on new VCI cables available for purchase by dealers.
Instructions for clearing adaptive cruise control faults and warnings.
Instructions for reworking the seat cover in the event that dark spots begin to appear as a result of using seat...
Read full bulletin
ventilation.
Instructions for what to do in the event that the customer loses the driver's key while transporting the vehicle.
Advanced information on clearing lane change assist warning faults.
Bulletin outlining new blitz table replacement castors due to a high rate of failure reported by dealers.
Instructions for addressing leather seat wrinkling on older models.
Parts withdrawal bulletin for various outdated control units on a variety of vehicles.
Bulletin outlining parts withdrawal of an injector used in new Macan and Cayenne vehicles.
List of valid Advanced Technical Information bulletins (ATIs) as of 11/22/2019
Parts Withdrawal bulletin for the Ski Bag included with the Macan and Cayenne.
Announcement of new Tech Live look, which will put technicians into live chats with technical support if they should...
Read full bulletin
have an urgent issue
The rear lid does not close normally.
Symptom: When locking the vehicle, the locking beep can sometimes be heard only once instead of twice.
Read full bulletin
Cause: Insufficient communication between the horn and rear-end electronics control unit can cause the locking beep to sound only once.
Concerns: Belt tensioner Information: Checking belt tensioner in the event of a complaint about "leaks" before carrying...
Read full bulletin
out any other work.
Concerns: Belt tensioner Information: Checking belt tensioner in the event of a complaint about "leaks" before carrying...
Read full bulletin
out any other work.
Information: The Approval and Support Management system was created to offer assistance to the dealer organization with...
Read full bulletin
new and complex technical issues by utilizing the Support Specialists within Porsche R&D. As a result, this process has reduced vehicle downtime and repeat repairs substantially.
Software & Calibration
113 bulletinsPorsche Tester Software Update Information Software Version: 44.300.000
PiUS Update Information Software Version: 3.2
PiUS Update Information Software Version: 3.2
Porsche Tester Software Update Information Software Version: 44.200.051
Porsche Tester Software Update Information Software Version: 44.200.041
Porsche Tester Software Update Information Software Version: 44.200.040
Porsche Tester Software Update Information Software Version: 44.200.035
Porsche Tester Software Update Information Software Version: 44.200.031
Porsche Tester Software Update Information Software Version: 44.200.030
Porsche Tester Software Update Information Software Version: 44.200.023
Porsche Tester Software Update Information Software Version: 44.200.022
Porsche Tester Software Update Information Software Version: 44.200.022
Porsche Tester Software Update Information Software Version: 44.200.015
Porsche Tester Software Update Information Software Version: 44.200.010
Porsche Tester Software Update Information Software Version: 44.200.010
Porsche Tester Software Update Information Software Version: 44.200.001
Special tools and equipment information for VAS 6296/10 Auto-Ship and Q1 2026 Software Spec Update Available
Technical information for a software update of various control units: Software Network VR28.13 SQ4
Special tools and equipment information on VAS 6292 Spec Update 2025.0.4 (VAS 6292/9 & VAS 6292/10 Required)
Parts information for parts withdrawal involving the combi-instrument black.
Read full bulletin
The part numbers listed on the PDF and All parts with software version 005 are affected. Only software version 006 is OK.
Technical information on WSJ0 Update to Software Network VR28.13 (Workshop Campaign)
Special tools and equipment information on VAS 6292 Spec Update 2025.0.3 (VAS 6292/9 & VAS 6292/10 Required)
Special tools and equipment information for VAS 6292 Spec Update 2025.0.2 (VAS 6292/9 & VAS 6292/10 Required).
Read full bulletin
All vehicles affected.
Special tools and equipment information for VAS 6292 Spec Update 2025.0.1.
Read full bulletin
All models
Special tools and equipment information for T40123A Update to T40123B
Information on PIWIS tester update 43.300.015
Special tools and equipment information for AVL HV Tool calibration and certification service
Information on PIWIS tester update 43.000.020 & .021.
Read full bulletin
PIWIS tester updates applies to all Porsche models that have an OBD2 port.
Information on PIWIS tester update 43.000.017.
Read full bulletin
PIWIS tester updates applies to all Porsche models that have an OBD2 port.
Information on PIWIS tester update 43.000.016.
Read full bulletin
PIWIS tester updates applies to all Porsche models with an OBD2 port.
Information on PIWIS tester update 43.000.010, .011 & .015.
Read full bulletin
PIWIS tester updates applies to all Porsche models with an OBD2 port.
Information on PIWIS tester update 42.950.048
Information on PIWIS tester update 42.950.040.
Read full bulletin
PIWIS tester updates applies to all Porsche models that have an OBD2 port.
Information on PIWIS tester update 42.950.032.
Read full bulletin
PIWIS tester updates applies to all Porsche models that have an OBD2 port.
Information on PIWIS tester update 42.950.030.
Read full bulletin
PIWIS tester updates applies to all Porsche models that have an OBD2 port.
Information on PIWIS tester update 42.950.025
Information on PIWIS tester update 42.950.021
Information on PIWIS tester update 42.950.020
Information on PIWIS tester update 42.950.015
Information on PIWIS tester update 42.950.010 & .011
Information on PIWIS tester update 42.950.000 & .001
Information on PIWIS tester update 42.900.030
Information on PIWIS tester update 42.900.020
Information on PIWIS tester update 42.900.010
Information on PIWIS tester update 42.900.000
Information on PIWIS tester update 42.800.070 & .072
Information on PIWIS tester update 42.800.060
Information on PIWIS tester update 42.800.052 & .055
Information on PIWIS tester update 42.800.050
Information on PIWIS tester update 42.800.040
Information on PIWIS tester update 42.800.030
Information on PIWIS tester update 42.800.000 42.800.020
Information on PIWIS tester update 42.700.050
Information on PIWIS tester update 42.700.040
Information on PIWIS tester update 42.700.033 & .035
Information on PIWIS tester update 42.700.030 & .032
Information for PIWIS tester update 42.500.020
Information for PIWIS tester update 42.300.050 & .052
Information for PIWIS tester update 42.300.040 & .041
Information for PIWIS tester update 42.300.035
Information for PIWIS tester update 42.300.030 - .032
Special tools and equipment information on PIWIS tester update 42.250.050
Information on PIWIS tester update 42.250.045
Information on PIWIS tester update 42.250.042
Information PIWIS tester update 42.250.040
Information on PIWIS tester update 42.250.032
Information on PIWIS tester update 42.250.030
Information on PIWIS tester update 42.200.025
Information on PIWIS tester update 42.200.020 & .022
Information for PIWIS tester update 42.100.000, .010 & .011
Information for PIWIS tester updates 42.000.050 & .051
Information for PIWIS tester update 42.000.048
Information for PIWIS tester update 42.000.040
Information for PIWIS tester update 42.000.035
Information for PIWIS tester update 41.750.045 & .046
Information for PIWIS tester update 41.500.020 & .022
Information for PIWIS tester update 41.400.000 & .010.
Information for PIWIS tester update #41.375.050
Information for PIWIS tester update #41.375.045.
Information for PIWIS tester update #41.375.040
Information for PIWIS tester update #41.300.000, .010 & .012
Special tools information regarding the surround view calibration mats.
Special tools information for coolant cart foam update.
Information on new PIWIS Tester update #40.300.020.
Information on PIWIS tester update #40.300.000 & .010.
Information on new PIWIS Tester update #40.250.040
Information on Porsche PIWIS Tester update #40.250.030 & .035.
Information on Porsche PIWIS Tester III Online Update 40.200.020.
Information on Porsche PIWIS Tester III Online Update 40.200.000, .010, .015 & .016.
Information on PIWIS Tester update 40.000.020 & .022.
Porsche Specials tools update for an offline SD Card update for the Map services.
Information on PIWIS Tester III Online Update 39.700.030
Information on PIWIS Tester III Online Update 39.700.020
Information on PIWIS Tester III Online Update 39.700.000, .010 & .012
Information on new PIWIS tester update 39.500.020 and .025.
Instructions on how to perform a PVTS Software update in the event that a car will not start.
Instructions for how to perform a software update on the Control unit for the auxiliary alarm system in the event that...
Read full bulletin
the vehicle will not start.
Bulletin outlining new PIWIS tester update 39.100.030 & .035
Bulletin outlining PIWIS tester update 39.200.000, .010, .015, .016, & .017
Technical information outlining the customer complaint that the locking "beep" not working as specified.
Read full bulletin
The issue can be corrected by reprogramming the vehicle's rear end electronics.
Updated worksheet for Chassis and VIN numbering system.
Read full bulletin
Updated to include 2020 Models including the Taycan.
Updated bulletin with the full list of Porsche model type designations.
Information about new PIWIS Tester update 39.050.010
Information about new PIWIS Tester update 39.050.012
Information about new PIWIS Tester updates 39.000.022 and 39.050.000
Information about PIWIS Tester update 39.000.020
New PIWIS Tester update 38.800.030
New PIWIS Tester update 38.800.020
New PIWIS tester updates 38.800.000 &.010
Bulletin outlining PIWIS Tester updates 38.600.030 & 035.
Bulletin outlining PIWIS Tester updates 38.600.020.
Bulletin outlining PIWIS Tester updates 38.600.000, .010, & .015.
Concern: Coding failures of the instrument cluster.
Read full bulletin
Information: Ensure the Auto Memory option is deselected prior to replacing or coding an Instrument Cluster on all Macan models. Due to the numerous options and software available to support those options, coding faults can occur. To turn off Auto Memory through the Instrument Cluster; Select Setting-> Locking-> Auto Memory. If the vehicle is not equipped with Auto Memory, no work around is necessary.
Engine
102 bulletinsManufacturer's Certificate for Overview of Approved Porsche C40 Engine Oils.
Read full bulletin
Note that this bulletin covers all models back to model year 1984, for which C40 engine oils are allocated.
Manufacturer's Certificate for Overview of Approved Porsche C20 Engine Oils.
Read full bulletin
Note that the bulletin covers all models back to model year 1984, for which C20 engine oils are allocated.
Manufacturer's Certificate for Overview of Approved Porsche C30 Engine Oils.
Read full bulletin
Note that the bulletin includes all models back to model year 1984, for which C30 engine oils are allocated.
Manufacturer's Certificate for Overview of Approved Porsche A40 Engine Oils.
Read full bulletin
Note that this bulletin covers all vehicles from model year 1997 to 2020, for which A40 engine oils are assigned. Model years 1997-2001 are not available for selection in the system.
Allocation of Approved Engine Oils MY 2027 (13/26)
Overview of Approved Porsche C20 Engine Oils (20/26)
Overview of Approved Porsche C30 Engine Oils (19/26)
Overview of Approved Porsche C40 Engine Oils (21/26)
Overview of Approved Porsche A40 Engine Oils (15/26)
Overview of Approved Porsche C30 Engine Oils (16/26)
Overview of Approved Porsche C30 Engine Oils (16/26)
Overview of Approved Porsche C20 Engine Oils (17/26)
Overview of Approved Porsche C40 Engine Oils (18/26)
Parts information for parts withdrawal involving servomotor and rear light.
Read full bulletin
Part numbers affected are 976411881E, 976511881E, PAD411881B, PAD511881A, PAD411881C, 973945093BC. The vehicles involved are ones that use the part numbers mentioned.
Manufacturers certificate for an overview of approved engine oils (C30).
Read full bulletin
The vehicles involved are ones that use the engine oil mentioned. MY2004-2020
Manufacturers certificate for an overview of approved engine oils (C40).
Read full bulletin
The vehicles involved are ones that use the engine oil mentioned. MY2012-2020
Manufacturers certificate for an overview of approved engine oils (A40).
Read full bulletin
The vehicles involved are ones that use the engine oil mentioned. MY1997-2020
Parts information for parts withdrawal involving the engine mounting.
Read full bulletin
Part numbers PAB199371A, PAB199372A, PAB199371C, PAB199372C are affected. The cars that use the part number(s) mentioned should be included.
Parts information for parts withdrawal involving the Window regulator motor.
Read full bulletin
The part numbers affected are PAB959801 and PAB959802. The vehicles involved are ones that use the part numbers mentioned.
Manufacturers certificate for an Overview of Approved Porsche A40 Engine Oils.
Read full bulletin
MY1997-2020 affected.
Manufacturers certificate for an Overview of Approved Porsche C30 Engine Oils.
Read full bulletin
MY2004-2020 affected.
Manufacturers certificate for an Overview of Approved Porsche C40 Engine Oils.
Read full bulletin
MY12-20 affected.
Parts information for parts withdrawal involving Solenoid Valve for Coolant Circuit.
Read full bulletin
the vehicles affected are cars that use part numbers 9J1963375N, 9J1963375P, 9J1963375Q, 9J1963375R, 9J1906459C
Parts information for parts withdrawal involving the wiring set for engine and wire set.
Read full bulletin
The vehicles affected are cars that use the part numbers in the PDF.
Manufacturers certificate for allocation of approved engine oils from MY20
Manufacturers certificate for an overview of approved Porsche C30 engine oils.
Read full bulletin
Model year 2004-2020 vehicles affected.
Manufacturers certificate for overview of approved Porsche A40 engine oils.
Read full bulletin
The vehicles affected are cars that use A40 engine oils. MY1997-2020
Manufacturers certificate for overview of approved Porsche C40 engine oils.
Read full bulletin
The vehicles affected are cars that use C40 engine oils. MY12-20
Manufacturers certificate for overview of approved Porsche C20 engine oils.
Read full bulletin
The vehicles affected are cars that use C20 engine oils. MY17-20
Manufacturers certificate for an Overview of Approved Porsche C40 Engine Oils.
Read full bulletin
The vehicles affected are cars that use engine C20 oil as of MY 2021.
Parts information for parts withdrawal involving the piston - 0PB107066J and 0PB107066K.
Read full bulletin
The cars affected are ones that use the two part numbers mentioned.
Technical Information - Coolant Loss in the Body Front Section/Engine Compartment Area- Locate and Eliminate Cause of...
Read full bulletin
Coolant Loss (60/22)
Parts Information - Parts Withdrawal - Motor for Tailgate Closing Aid (95C827888B)
Manufacturer's Certificate - Overview of Approved Porsche C40 Engine Oils (06/25)
Manufacturer's Certificate - Overview of Approved Porsche C30 Engine Oils (05/25)
Manufacturers certificate with an overview on approved Porsche A40 engine oils.
Read full bulletin
See attached for list of affected vehicles.
Manufacturers certificate with an overview on approved Porsche C40 engine oils.
Read full bulletin
See attached for list of affected vehicles.
Manufacturers certificate with an overview on approved Porsche C30 engine oils.
Read full bulletin
See attached for list of affected vehicles. All MY04-20
Parts information for parts withdrawal involving the engine oil (00004321093)
Instructions on advanced technical information for various vehicles - engine start inhibited and fault code present
Technical information on a coolant loss in the body front section/engine compartment area - locate and eliminate cause...
Read full bulletin
of coolant loss
Technical information for a complaint - engine faults (knocking/tapping combustion) under loads
Manufacturers certificate - allocation of approved engine oils up until MY2020
Instructions on manufactures certificate for approved Porsche A40 engine oils
Instructions on manufactures certificate for approved Porsche C30 engine oils
Instructions on manufacturers certificate for approved C20 engine oils
Manufacturers certificate for an overview of approved Porsche A40 engine oils.
Manufacturers certificate for an overview of approved Porsche C40 engine oils.
Manufacturers certificate for an overview of approved Porsche C30 engine oils.
Manufacturers certificate for an overview of approved Porsche C20 engine oils.
Manufacturers certificate for allocation of approved engine oils
Instructions on advanced technical information for the engine - will not start for updating PVTS CU software via dealer...
Read full bulletin
web portal
Manufacturers certificate for approved engine C20 engine oils.
Overview of approved engine A40 oils for all Porsche models that use A40 oil.
Overview of approved engine C40 oils for all Porsche models that use C40 oil.
Overview of approved engine C30 oils for all Porsche models that use C30 oil.
Instructions on advanced technical information - Macan I R4 Engine
Instructions on advanced technical information for various vehicles with 3GVTS - engine start inhibited and fault code...
Read full bulletin
present.
Technical information for a warning message "engine control system fault"
Overview of approved engine C20 engine oils for all Porsche models using this oil.
Overview of approved engine C40 engine oils for all Porsche models using this oil.
Instructions on the manufacturers certificate for approve Porsche A40 engine oils.
Overview of approved engine C30 oils for Porsche models using C30 oils.
Instructions on advanced technical information for vehicles with 3G VTS - engine start inhibited and fault code present.
Technical information: coolant loss in the body front section/engine compartment area.
Engine symptom - loose/broken screws and oil leaks in the area of the chain housing cover and/or camshaft phaser.
Instructions on the manufacturers certificate for allocation of approved engine oils up until MY2020.
Read full bulletin
(starting back at MY1984). An overview of the approved engine oils.
Technical information regarding a warning message - "engine control system fault" in conjunction with fault memory...
Read full bulletin
entries in the PDK control unit.
List of approved C20 engine oils for all Porsche models using C20 oil.
List of approved engine C30 engine oils for all Porsche vehicles using C30 oil.
List of approved engine oils for all Porsche models using C40 oil.
Advanced technical information for updating the PVTS CU Software in the event that the engine will not start.
Advanced technical information on Updating PVTS CU Software in the event that the Engine will not start.
List of approved engine oils for new and classic Porsche models.
List of approved C20 style engine oils for classic and new Porsche models since 1984.
List of approved A40 style engine oils for new and classic Porsche vehicles MY 1984 and newer.
List of approved C40 engine oils for new and classic Porsche vehicles MY 1984 and newer.
List of approved C30 engine oils for all new and Classic Porsche vehicles MY1984 and newer.
List of approved C20 engine oils for all new and classic Porsche models 1984 and newer.
List of approved A40 style engine oils for new and classic Porsche models.
List of approved C40 style engine oils for new and classic Porsche vehicles.
Warranty information for Timing Chain cover repairs.
List of approved engine oils for all Porsche models since 2003.
Overview of Approved Porsche C20 Engine Oils
Updated warranty and repair information concerning timing chain cover repairs due to any failure of the chain.
List of approved A40 engine oils for all applicable vehicles as of 1984.
List of approved C40 engine oils for all Porsche models since 1984.
List of approved engine oils for all Porsche models.
List of approved C30 engine oils for all Porsche vehicles since 1984.
Technical information concerning possible leaking coolant pipes at the front of the cylinder head in certain Cayenne and Macan vehicles.
Read full bulletin
The remedy is to install a coolant pipe with a toothed ring.
List of approved C20 engine oils for all Porsche vehicles since 1984.
List of approved A40 engine oils for all Porsche vehicles since 1984.
Repair instructions for Timing chain repair.
Read full bulletin
If an oil leak is identified from the timing chain cover and it has been found that any part on the timing cover has failed, then the engine must be removed and the entire timing chain cover resealed per the WM instructions.
List of approved A40 engine oils for Porsche vehicles.
Information about possible engine knocking and how to clean carbon deposits is they are dirty and causing knocking.
Concern: An oil leak can occur close to the connection point between the intermediate housing (? Oil leak on PDK...
Read full bulletin
transmission -item 1-) and cover (? Oil leak on PDK transmission -item 2-) on the PDK transmission due tomanufacturing tolerances.
Subject: Intake valves and intake ports Information: Carboned-up valves in the engine can be reworked and cleaned using cleaning equipment.
Read full bulletin
If there is a complaint about knocking combustion, e.g. during acceleration at high load, the condition of the intake valves and portsmust be checked before doing any other work. If the check shows that the intake valves and intake ports have carbon deposits and are dirty, they must be cleaned using the VAS 294 011 - cleaning unit. There should be no need to replace the components. Date of Introduction: The VAS 294 011 - cleaning unit can be ordered immediately for dealers. Remedial Action: The VAS 294 011 - cleaning unit is used for cleaning carboned-up intake valves and intake ports. Compressed air is used to spray a special granulatemixture into the intake port,where it loosens and removes carbon build-up. The dirty granulate is extracted during spraying using an industrial vacuum cleaner.
The "transfer case" is designed as an active all-wheel drive system that is dynamically adapted to the respective driving state.
Read full bulletin
Power transmission between the front and rear axle is controlled electronically via the "all-wheel drive servomotor (transfer case)" and themulti-plate clutches integrated in the transfer case. ? On all-wheel drive vehicles, the drive train can become strained at low speeds and when the steering is turned sharply when "Off-roadmode" is activated, depending on design. ? Under extreme conditions, the drive train can also become strained when "Off-roadmode" is deactivated. ? Customers with little experience with all-wheel drive vehicles can interpret this behavior as a fault, which in turn can result in incorrect diagnoses in the workshop. Remedial action: Customer complaint to be checked: ? Rough-running engine or ? thevehicle vibrates or ? theengine jerks under load/during acceleration.
Oil leak/leak on PDK transmission close to the connection point between the intermediate housing and cover.
Read full bulletin
Insufficient cross-cut made at the flange and as a result, the sealant has not bonded sufficiently.
There is increased friction in the air spring compressor valves at temperatures below ?13 F (?25 C).
Read full bulletin
This can result in a situation in which the maximum control current is not sufficient to actuate the valves. As a result, a warning message will be displayed in the instrument cluster and Porsche Active Suspension Management (PASM) will stop working temporarily. Re-program PASM control unit using the PIWIS Tester with software version 33.010.030 (PIWIS Tester 3) or version 17.100.030 (PIWIS Tester II) or a higher software version installed.
Information: In certain driving situations, the transmission only switches from 1st to 2nd gear at a significantly ...
Read full bulletin
higher engine speed when selector-lever position "D" is engaged.
"THERE IS INCREASED FRICTION IN THE AIR SPRING COMPRESSOR VALVES AT TEMPERATURES BELOW 13 F (25 C).
Read full bulletin
THIS CAN RESULT IN A SITUATION IN WHICH THE MAXIMUM CONTROL CURRENT IS NOT SUFFICIENT TO ACTUATE THE VALVES. AS A RESULT, A WARNING MESSAGE WILL BE DISPLAYED IN THE INSTRUMENT CLUSTER AND PORSCHE ACTIVE SUSPENSION MANAGEMENT (PASM) WILL STOP WORKING TEMPORARILY. RE-PROGRAM PASM CONTROL UNIT USING THE PIWIS TESTER WITH SOFTWARE VERSION 33.010.030 (PIWIS TESTER 3) OR VERSION 17.100.030 (PIWIS TESTER II) OR A HIGHER SOFTWARE VERSION INSTALLED."
Electrical
42 bulletinsParts information for parts withdrawal involving 9J1827447B, PAA971221B, and 95B201060AA.
Read full bulletin
The lock, the fuel tank attachments, and the module connector. The vehicles affected are ones that use the part number(s) mentioned.
Parts information for parts withdrawal involving the (976809858) Fuel filler flap module.
Read full bulletin
The vehicles affected are ones that use the part number mentioned.
Parts information for parts withdrawal involving the high-voltage battery.
Read full bulletin
The vehicles affected are ones that use the part numbers mentioned. 9J1915099AS, 9J1915100AS, and 9J1915100AQ
Technical information for a Time and Date Display Not Up-to-Date/Available After the 12-Volt Vehicle Electrical System Battery.
Read full bulletin
The vehicles affected are in the attached PDF. has been Disconnected for a Long Time
Parts information for Parts Withdrawal - Pressure Sensor (9A790605201) The cars affected are ones that use the part...
Read full bulletin
number mentioned.
Parts information for parts withdrawal involving various parts - battery module and high voltage battery.
Read full bulletin
The vehicles affected are ones that use the part numbers in the attached PDF
Parts information for Parts Withdrawal - Repair Set for Seat Occupied Sensor.
Read full bulletin
Part numbers 9J1881256AJ, 9J1881256AK, 9J1881256AL, 9J1881256AM, 9J1881256AN are affected. The cars involved are ones that use the part numbers mentioned.
Parts information for parts withdrawal for Repair Set for Seat Occupied Sensor.
Read full bulletin
Parts involved are 95C881256F and 95C881256H. The cars affected are ones that use the part numbers mentioned
Technical information for Important Information for Maintaining, Diagnosing and Checking the (AGM) Battery
Parts information for parts withdrawal involving a various number of parts all listed in the attached PDF.
Read full bulletin
Hose, air conditioning, door warning light, control line with differential pressure sensor
Instructions on advanced technical information for paint thickness or decals affecting corner radar sensor operation.
Read full bulletin
Affects all model lines
Parts information for parts withdrawal involving the pressure sensor.
Read full bulletin
The vehicles affected are cars that use the part number 9A790605201
Parts information for parts withdrawal involving the high voltage connector.
Read full bulletin
The affected vehicles are ones that use part number PAC915161(High-voltage connector)
Parts information for parts withdrawal involving the high voltage battery.
Read full bulletin
The affected vehicles are ones that use part number 0Z3915913BN (High-voltage Battery)
Parts information for parts withdrawal involving the high voltage battery.
Read full bulletin
The affected vehicles are ones that use part number 0Z3915913BN (High-voltage Battery)
Parts information for parts withdrawal involving the high voltage battery - 0Z3915913BN.
Read full bulletin
Vehicles affected are cars that use the part number mentioned
Parts information for parts withdrawal involving the control unit for battery monitoring.
Read full bulletin
Part numbers related are PAC915234, PAC915234A, PAC915234B, PAC915234C, PAC915234D. The vehicles affected are cars that use the part number mentioned
Parts information for parts withdrawal involving the high voltage battery - 9J1915590M and 9J1915589M.
Read full bulletin
The vehicles are not listed, but the affected cars are ones that use the part numbers mentioned.
Parts information for parts withdrawal involving the high-voltage connector (PAC915161).
Read full bulletin
Vehicles not listed but the cars affected are cars that use part number PAC915161
Parts information for parts withdrawal involving the charger for the high-voltage battery
Installation and conversion instructions for the PCM - nav update
Installation and conversion instructions for the PCM3.1 - Navigation update
New Special tools information for a Schumacher 100 Amp Reprogrammer / Power Supply with Battery Support.
PCM3.1 Navigation Update (data status: model year 2016) - New maps with data status model year 2016
Information on how to deal with a potential cyber security breach.
Information on a Navigation system update for the PCM3.1
Resubmitting at request of Mr.
Read full bulletin
Bernard Hardgrave. Instructions for reworking the wire harness for the outside temperature sensor in the event that outside temperature display is implausible.
Instruction for checking the component type on front and rear speed sensors and replacing if necessary.
Information on map update services to be applied offline via and SD card.
Read full bulletin
Applies to vehicles with PCM 4, 5.
Information on PCM3.1 - Navigation Update for MY13.
Information on new special tool for offline updates of the PCM Versions 4 and 5.
Information on Extended Warranty for the wheel speed sensors on the Macan.
Instructions for manually setting the date and time on older model vehicles with GPS and PCM 2.1 or older.
Subject: Front camera Symptom: The customer complains that certain functions of the front camera are not available at...
Read full bulletin
times: Lane Change Assist not available Porsche Dynamic Light System not available Traffic sign recognition not available Cause: Image sensor fault in the front camera. Insufficient contrast causes certain functions to fail at times. Remedial Action: Check front camera and replace it if necessary.
Subject: Outside temperature sensor Symptom: The outside temperature display shows implausible values.
Read full bulletin
Cause: The outside temperature display can show implausible values because the wire harness for the outside temperature sensor is too long.
Subject: Outside temperature sensor Symptom: The outside temperature display shows implausible values.
Read full bulletin
Cause: The outside temperature display can show implausible values because the wire harness for the outside temperature sensor is too long.
Model Line: Cayenne (92A) Macan (95B) Concerns: AGM starter battery (referred to below simply as ?battery?) ...
Read full bulletin
Situation: Customer complaints concerning battery-related topics Recurring customer complaints concerning topics relating to battery capacity and quality.
Information: This document updates information previously published in EQ 1105, EQ 1105, and EQ 1401.
Read full bulletin
To provide stable voltage and sufficient current throughout certain service operations, you should connect the vehicle to a battery charger (sometimes referred to as a power supply). However, you may experience ECU programming and coding issues if the chosen battery charger has insufficient power. Many workshop manuals currently advise use of a battery charger with a 40 or 70 A current rating. However, with the increasing current requirements of modern Porsche vehicles, we recommend a battery charger capable of producing a minimum current of 90 A.
Information: It is possible that a faulty wheel speed sensor can be the root cause of the multiple warnings.
Read full bulletin
Check the fault memory for the following types of faults for one or more wheel speed sensors. * Sensor Fault * Sensor Electrical Fault * Sensor Implausible Fault
Information: The customer complains that certain functions of the front camera are not available at times: * Lane...
Read full bulletin
Change Assist not available * Porsche Dynamic Light System not available * Traffic sign recognition not available Cause: Image sensor fault in the front camera. Insufficient contrast causes certain functions to fail at times.
Customer Concern: Vehicle has an issue that ends up requiring a wheel alignment.
Read full bulletin
Technical Concern: The VAS 6918 adapters may be confused, resulting in an improper alignment. Service Information: There are two different diameter collars to use on the adapter. The smaller diameter collar is for the Macan (VAS 6918/3) and the larger diameter collar is for all other vehicles without center locks.
The customer observes an MIL.
Read full bulletin
The technician is able to verify the MIL and notices fault code P0071 stored in the DME. PCNA is aware of this this issue. As background information, the fault is caused by the temperature sensor not communicating with the DME via CAN.
Body & Paint
41 bulletinsParts information for parts withdrawal involving the door lock.
Read full bulletin
The part numbers involved are all included in the PDF. All parts before generation status S08 and before pro-duction date 01.09.2024. The vehicles affected are ones that use the part numbers mentioned.
Parts information for parts withdrawal involving the door lock.
Read full bulletin
The vehicles affected are ones that use the part number(s) mentioned in the attached PDF.
Porsche intranet posting with information on workshop campaign WTB3 - applying corrosion protection to door.
Technical information for WTB3 - Applying Corrosion Protection to the Door (Workshop Campaign)
Parts information for parts withdrawal involving the door lock.
Read full bulletin
part numbers 9Y0839015, 9Y0839016, 9Y0839016A, 9Y0839015A, 9Y0839015B, 9Y0839016B. Vehicles affected are cars that use the part numbers mentioned.
Parts information for parts withdrawal involving the glass roof - 9J0877069BY & 9J0877069CY.
Read full bulletin
The vehicles affected are ones that use the part numbers mentioned.
Parts information for parts withdrawal for a roof console - part numbers 992501031H, 992501032H, 992501033AB, and 992501033AC.
Read full bulletin
The vehicles affected are cars that use any of the four part numbers mentioned.
Parts information for parts withdrawal involving the roof console.
Read full bulletin
95C959551AETM0, 95C959551ABTM0, 95C959551ACTM0, 95C959551ADTM0. The vehicles affected are cars that use the part number(s) mentioned.
Parts information for parts withdrawal involving the door lock.
Read full bulletin
The affected cars are cars that use part numbers 971839016B, 971839015D, 971839015B, 971839016D, 971839016C, 971839015C, 9Y0839015, 9Y0839016, 9Y0839016A, 9Y0839015A
Instructions on advanced technical information for all models - Updated Primer Substance and Application Guidelines For...
Read full bulletin
Glass Installation/ Windshield and Glass Roof
Technical information for a complaint on the exterior mirror - does not fold in and out
Parts information for parts withdrawal for the seal ring - 0PB115625A
Parts information for parts withdrawal involving the roof glass - 9J0877069EY and 9J0877069DY
Instructions on advanced technical information for damages to clearcoat from paint protection film application
Symptom-based workshop manual for the body exterior.
Read full bulletin
drains on rear panoramic roof blocked - checking water drain hoses, cleaning, and replacing drain sleeves
Technical information for the glass sunroof - does not open
Parts information for parts withdrawal involving the glass roof - 9J0877069EY and 9J0877069DY
Installation and conversion instructions for the door entry guard on the Macan - MY14-21
Special tools information for an assembly tool and thrust piece for the Cayenne and Macan
Technical information on the glass sunroof does not open on the Macan - observe specified procedure.
Instructions on advanced technical information for the lubricant for the sunroof/sliding roof.
Information on eliminating symptoms in body interior: re-calibrating surround view camera control unit.
Symptom based workshop manual information - eliminating symptoms in body interior: Re-calibrating Surround View Camera Control Unit (for I-no.
Read full bulletin
8A4)
Parts withdrawal information for a Windshield.
Installation instructions for retrofitting a roof box on a variety of Porsche models.
Door Entry Guard, Illuminated - Retrotittting
Longgitudinal member for front left wheel housing - WG03-Applying corrosion Protection to Longitudinal M ember for Front...
Read full bulletin
Left Wheel Housing (Workshop Campaign)
Eliminating Noise Symptoms - Replacing Rubber Stops on Front Hood (Creaking noise from around the dashboard or...
Read full bulletin
A-pillar/SY0116)
Technical information for how to deal with cracks in the clamping plate at the front of the roof transport system.
RESUBMITTING AT THE REQUEST OF B HARDGRAVE.
Read full bulletin
This bulletin from January 2017 contains instructions on how to eliminate noise symptoms in the Macan when opening the hood.
Advanced technical information about how to handle outside door handle cracks and breaks.
Information on parts withdrawal of roof rail bars on the Macan.
Instructions for retrofitting stainless steel rear trim on the Macan.
Instructions for retrofitting an illuminated door entry guard on the Macan.
Instructions for how to treat a leaking paroramic roof
Instructions for installing the Porsche Bicycle Rack on applicable models with an already installed roof transportation...
Read full bulletin
system
Instructions for installing the Porsche Roof Box on applicable models with an already installed roof transportation...
Read full bulletin
system
Outer seal on Panoramic roof is faulty, causing water to leak into vehicle.
The outside door handle may crack and break.
Read full bulletin
It initially looks like the paint is cracking, but will grow to larger size cracks.
Information: The upper front hood latches have a fine adjustment not mentioned in the workshop manual.
Read full bulletin
A fine adjustment to change the depth of the upper latch striker may be made at the bolt shown in the photo above. This is a useful adjustment for front latch issues that cause a warning in the instrument cluster for the front hood being open as well as fine tuning the closed height of the hood.
There is a possibility that covers on front and rear doors can become loose and start to stick up due to adhesion problems.
Read full bulletin
In the event of a customer complaint, all four covers on front and rear doorsmust be replaced.
Brakes
23 bulletinsParts information for parts withdrawal involving (992513031K) Shock absorber (spring cyl.).
Read full bulletin
The vehicles affected are ones that use the part number mentioned.
Parts information for parts withdrawal involving various parts.
Read full bulletin
The part numbers affected are 9GT501135B, PAD411881A, 992915099KY. The vehicles affected are ones that use the part numbers affected
Parts information for parts withdrawal involving the caliper without brake pads.
Read full bulletin
The part numbers affected are in the attached PDF. The vehicles associated are cars that use the part numbers in the PDF.
Parts information for parts withdrawal involving the brake disc 9Y0615301AJ
Parts information with parts withdrawal involving the stowage compartment for Mobile.
Read full bulletin
The vehicles affected are cars that use part number PAD035507
Parts information for Parts Withdrawal - 1 Set of Brake Pads for Disk Brake.
Read full bulletin
Vehicles included are all cars that use part number 992698451R
Parts information for parts withdrawal involving the primer - PAD181220.
Read full bulletin
Vehicles affected are cars that use part number PAD181220
Technical Information - Improper Handling of the Brake Caliper During Assembly Work on the Front Axle (215/23)
Parts information for parts withdrawal involving the socket and throttle control element.
Read full bulletin
The vehicles affected are cars that use part numbers 9J1821941G, 9J1821942G, 9J1959774F, PAD959774
Parts information for parts withdrawal for information on the cardan shaft and shock absorber.
Read full bulletin
The vehicles affected are cars that use part numbers 958521101, 958521101A, 9J1413031G
Parts information for parts withdrawal for information on the cardan shaft and shock absorber.
Read full bulletin
The vehicles affected are cars that use part numbers 958521101, 958521101A, 9J1413031G
Parts information for parts withdrawal involving the camera and control unit with the camera - PAD980551 & PAD980568C.
Read full bulletin
The affected vehicles are cars that use the part numbers mentioned.
Parts information for parts withdrawal involving the brake hose 9J1611707F and 9J1611708F
Parts information for parts withdrawal involving the retainer for brake hose/brake line
Parts information for parts withdrawal involving the retainer for brake hose/pressure difference sender.
Read full bulletin
(9J1611845C, 9J1611846C, PAB906051C)
Technical information for improper handling of brake caliper during assembly work on front axle
Instructions on advanced technical information for the Macan - brake hose retaining bracket
Advanced technical information for a brake squeal.
Understanding and addressing brake squeal complaints.
Resubmitting at request of Mr.
Read full bulletin
Bernard Hardgrave. Advanced technical information on brake fluid for all Porsche vehicles.
Special tools bulletin for new brake fluid tester.
Technical Background Front brakes are squealing with light pedal at low speed.
Read full bulletin
The noise is primarily in the 8 kHz range. Service Information Test drive the vehicle and verify the noise with an FFT plot. Low speed, light pedal squeal is most easy to duplicate when the brakes are cooling. Make sure to attach the FFT plot and relevant photographs to the PQIS job as outlined in the brake squeal ATI (Group 4 - 1801).
Information: A Cayenne with optional equipment no.
Read full bulletin
1D6 will come with a Trailer hitch receiver and wiring up to the receiver hitch that includes a control unit to operate the trailer parking lights, turn signals and brake lights. The Cayenne is also pre-wired for a brake controller. You will need to do the following to hook up the trailer electrics and/or an electric brake controller:
Lighting
20 bulletinsProduct Knowledge for Model Type Designations
Product Knowledge for Chassis/VIN Numbering Systems
VAS 621001A Matrix Headlamp Aimer Automatic Shipment / Maha Installation
VAS 621001A Matrix Headlamp Aimer Automatic Shipment / Maha Installation
Parts information for Parts Withdrawal - LED Headlight.
Read full bulletin
Vehicles affected are cars that use the part numbers in the attached PDF.
Product Knowledge for the Porsche evolution from 1948-2025
Product Knowledge - Chassis/VIN Numbering Systems
Product Knowledge on the chassis/VIN numbering systems
Technical information on a complaint - seat cover wrinkled
Product knowledge for the Porsche evolution from 1948-2023.
Technical information for ANB4 - retrofitting locking caps on the front left and right headlights.
Special Tools information for Deutronic Signal Lamps.
Special tools information for new Deutronic Signal Lamps.
Headlamp moisture - Headlamp assemblies are vented to the atmosphere to accompdate changes in temperature with the assembly.
Read full bulletin
The result of this is that humidity in the headlamp atmosphere can condense when the temperature falls below the dew point. It is cormal for a mist or fog of dmoisture to condense on the inside of the lens. Moisture levels in the headlamp become abnomals when there is a large amount of water drops forming on the lens, as in the photos below.
Resubmitting at request of Mr.
Read full bulletin
Bernard Hardgrave. Information on fogging lighting components.
Tools and equipment document highlighting new connector release tool set.
Bulletin highlighting new updates 38.750, 38.750.000 for the Porsche PIWIS Tester 3
Instructions for retrofitting Sport Plus Mode on vehciles without sport chrono package already installed.
Instructions for retrofitting Sport Plus Mode on vehciles without sport chrono package already installed.
Symptom: Symptom 1: Right headlight has interior condensation.
Read full bulletin
Symptom 2: One or both headlights has/have interior condensation Remedial action 1: The breather hose 95B.941.560.B (without corrugated hose) must be replaced by the breather hose 95B.941.560.C (with corrugated hose). It is important to check that the breather hose is routed without kinks.
Pre-Delivery & Maintenance
14 bulletinsPorsche intranet posting with information on Workshop Campaign WMM7 - replacing VTS control unit
Special tools and equipment for the VAG 1561 storage kit in foam with blades
Information for recall campaign WMM7 replacing VTS control unit.
Information for recall campaign AMA2 - replacing seat occupancy detection system for passenger seat.
Information for recall campaign AMA2 - replacing seat occupancy detection system for passenger seat.
Porsche Recall repair instructions for recall campaign AMA2 - Replacing Seat Occupancy Detection System for Passenger...
Read full bulletin
Seat.
Porsche intranet posting with preliminary information on WLN1 stop sale/workshop campaign.
Info on a new customer tool for looking up campaigns and recalls on their vehicle.
Parts withdrawal for various parts that were used in Recall and workshop campaigns.
Porsche Intranet posting outlining the Warranty Credit stop that takes place at the end of every calendar year.
Bulletin outlining SD card storage for PIWIS Testers.
Notice to dealers that coolants will be moved out of the special tool cabinet in the dealer service department in order...
Read full bulletin
to make room for new special tools. All coolant tools will be moved to the "Coolant Cart" because they need to be housed in the same place.
Service Information There was a parts supply error and incorrect parts were stocked.
Read full bulletin
An order to correct this error has been initiated and the stock will be clean soon.
Information: Very small leaks may not be found on a normal inspection.
Read full bulletin
Extra effort to locate these leaks is required.
Tires & Wheels
13 bulletinsSpecial Tools and Equipment Information for alignment machines - Q3 2026 Software Spec Update Available
Special Tools and Equipment Information for alignment machines - Q2 2026 Software Spec Update Available
Wheel Bolt Replacement Requirement - Change from Wheel Bolts with Aluminum Washers to Wheel Bolts with Steel Washers...
Read full bulletin
(40/26)
Parts information for the thatcham wheel lock information.
Read full bulletin
Since model year 2015, nearly all new vehicles (SUV's may have Thatcham or previous style wheel lock) come equipped with Thatcham-style wheel locks from the factory. Each vehicle equipped with Thatcham-style wheel locks uses a unique key. The vehicles affected are cars that use this wheel lock
Manufacturer's Certificate - Approved: Wheels, Tires and Spacers (54/24)
Parts Information - Thatcham Wheel Lock Information
List of approved wheels and tires for the Macan.
This bulletin replaces bulletin Group 4 #5/15 dated May 4, 2015 Approved Wheels and Tires Approved status January 2016
This bulletin replaces bulletin Group 4, #1/16 dated Approved Wheel and Tires
2003 to Present All with tire pressure monitoring system.
Special tools information on a measuring and alignment system.
Subject: Transfer case and transfer case control unit (all-wheel drive control unit)
Subject: Transfer case and transfer case control unit (all-wheel drive control unit)
Fuel System
13 bulletinsParts information for parts withdrawal involving the fuel filler flap and the charge cable for mains socket.
Read full bulletin
Part numbers 976809857E and 7PP971678GS
Parts information for parts withdrawal involving the multi-purpose additive for gasoline.
Read full bulletin
Part number is 00004320902. The vehicles affected are ones that use part number mentioned.
Parts information for parts withdrawal involving the - Diagnosis Pump for Fuel System 958906243B and 958906243A.
Read full bulletin
Vehicles affected are ones that use either of the part numbers mentioned.
Symptom based workshop manual for Eliminating Symptoms on Body Exterior: Cleaning Tailpipe Cover(s) on Exhaust System - Dirt on Tailpipe Cover.
Read full bulletin
The vehicles affected are cars that have the mentioned tailpipe
Parts information for parts withdrawal involving a number of parts for the flange, fuel pump, and fuel filter
Parts information for parts withdrawal involving the rear muffler/high pressure pump
Parts information for parts withdrawal involving the sender for fuel gauge.
Symptom-based workshop manual for a rattling noise from the rear area of the exhaust system.
Parts information for parts withdrawal involving the fuel filler flap
Instructions for fixing a rattling noise in the rear area of the exhaust system.
Parts withdrawal information for a Macan muffler.
Information on new model designation logos which can be purchased and applied to the rear exhaust area of a vehicle,...
Read full bulletin
displaying the model designation on the outside of the vehicle.
Concerns: Control unit for air-conditioning system Information: This is to inform you of a voluntary Workshop Campaign...
Read full bulletin
on the above-mentioned vehicles. The evaporator for the air-conditioning system on the affected vehicles can freeze at high outside temperatures with high humidity. As a result, the air-conditioning system will no longer cool the vehicle.
Transmission
11 bulletinsNon-Deletable Fault Memory Entries for Clutch Slip/Speed Adjuster in Transmission Electronics (PDK) Control Unit After...
Read full bulletin
Repair (26/26)
Warranty Information: Warranty Extension for Transmission Electronics Control Unit (39/26)
Parts information for parts withdrawal involving the transmission oil.
Read full bulletin
Part number 00004321012 is affected - the vehicles that use this part number should be included.
Parts information for parts withdrawal involving the transmission oil.
Read full bulletin
The vehicles affected are ones that use the part number 00004330563
Parts information for parts withdrawal involving the transmission fluid.
Read full bulletin
Part number 00004321048. The cars affected are ones that use the part number listed.
Parts information for parts withdrawal involving the (00004321048) Transmission fluid.
Read full bulletin
The vehicles affected are ones that use the part number mentioned.
Parts information for parts withdrawal involving the 7 speed dual clutch gear box.
Read full bulletin
Part numbers 0BG300047 and 0BG300047X are affected. Cars that are involved are ones that use the part numbers mentioned.
Parts information for parts withdrawal involving (PAD423051B) the Steering Gear with Track Rods.
Read full bulletin
The vehicles affected are cars that use the part mentioned.
Symptom based workshop manual information: customer complaint is a vibration/jerking during acceleration.
Read full bulletin
Check transfer gear.
Information on extended warranty for the Macan Transfer Gear on MY 14-18 models.
Various repair symptoms and their associated repairs for all PDK transmissions.
HVAC & Climate
9 bulletinsParts information for parts withdrawal involving the compressor.
Read full bulletin
Part numbers 971260601Q, 971260601QU,971260601QX, 971260601RU, 971260601SU, 971260601SX, 971260601R, 971260601RX are all affected. The vehicles that use any of the part numbers listed should be considered for this.
Symptom-based workshop manual for the interior of the vehicle - auxiliary heater does not function.
Read full bulletin
Retrofitting heat protection mat.
Special tools information for a Macan Air Conditioning tool.
Announcement of a 6 month warranty extension on VAS 581005P R1234yf Service Units for air conditioning.
Instructions for using VAS 581005P in order to chech and service R1234yf Air Conditioning Unit.
Subject: Air-conditioning control unit (also control panel/switch console) Symptom: When starting the vehicle, an...
Read full bulletin
unsuitable air conditioning setting is preset in the rear air-conditioning control unit.
Subject: Air-conditioning control unit (also control panel/switch console) Symptom: When starting the vehicle, an...
Read full bulletin
unsuitable air conditioning setting is preset in the rear air-conditioning control unit. Only air conditioning settings from driver's key 1 are stored and applied to all other driver's keys. Cause: The last air conditioning settings from driver's keys 2-4 cannot be read out quickly enough. The last stored setting from driver's key 1 is used.
The customer observes a MIL and the HVAC controls are not functioning.
Read full bulletin
Also, other Comfort CAN commodities may not function. PCNA is aware of this issue. The following part numbers are out of date and should be replaced if present on the vehicle: 95B 907 040 J 95B 907 040 K 95B 907 040 L
The customer observes a MIL and the HVAC controls are not functioning.
Read full bulletin
Also, other Comfort CAN commodities may not function. PCNA is aware of this issue. The following part numbers are out of date and should be replaced if present on the vehicle: 95B 907 040 J 95B 907 040 K 95B 907 040 L
Infotainment
6 bulletinsParts information for parts withdrawal involving the display and controls.
Read full bulletin
The list of part numbers are provided in the PDF. The vehicles affected are cars that use those part number(s).
Parts information for parts withdrawal involving the windscreen.
Read full bulletin
Vehicles affected are cars that use part numbers 992845011Q, 992845011AN, 992845011S, 992845011AM, 992845011BL, 992845011DB, 992845047DY, 992845047FY
Parts information for parts withdrawal involving the windscreen.
Read full bulletin
The cars involved are cars that use the part numbers 992845011Q, 992845011AN, 992845011S, 992845011AM, 992845011BL, 992845011DB, 992845047DY, 992845047FY
Instructions on how to reprogram the central computer using and SD card in the event that the surround view camera show...
Read full bulletin
the vehicle offset on the screen.
Due to incorrect fitting of the front hood lock cable, there is a possibility that the cable will rub against the microswitch for the hood lock.
Read full bulletin
This will damage the microswitch. As a result, the warning "Hood open" will be displayed in the instrument cluster.
Subject: Outside temperature display in the instrument cluster Information: Customers complain that the outside...
Read full bulletin
temperature value in the instrument cluster is implausible and does not change.
Air Bags & Safety
5 bulletinsTechnical information for WPC6 - Replacing Drivers Airbag Unit
Technical information for the rear seat belt warning implausible/no phonebook scroll function available.
Read full bulletin
Check and update instrument cluster as necessary
Technical information on WPC6 - replacing drivers airbag unit
Technical information for APA9 - replace screw connection for seat belt mount at rear left and/or right
PASSENGER AIRBAG WARNING
Steering
5 bulletinsParts information for parts withdrawal involving the rear axle steering.
Read full bulletin
The part numbers are 992501031H, 992501032H, 992501033AB, 992501033AC. The vehicles affected are cars that use the part numbers listed
Symptom-based workshop manual for a Noise Symptom - Noises from Around the Steering Shaft: Replace Intermediate Steering...
Read full bulletin
Shaft
Information on retrofitting Power Steering Plus on the Macan.
Updated bulletin with instructions for replacing the intermediate steering shaft on affected Macan vehicles.
Instructions for replacing the intermediate steering shaft in the event that there are noise complaints from the...
Read full bulletin
customer.
Suspension
3 bulletinsParts information for Parts Withdrawal - Hub Cap.
Read full bulletin
Part numbers involved are 9Y0601149F, 9Y0601149G, 9Y0601149H, 9Y0601149J, 9Y0601149L, and 9Y0601149M. The vehicles affected are ones that use the part numbers mentioned.
Parts information for parts withdrawal involving the retaining spring.
Read full bulletin
The vehicles affected are cars that use part number 95C615269E
Parts information for parts withdrawal involving the air spring