1997 Pontiac Sunfire TSBs

SUBJECT REGARDING REVISED INSTRUMENT PANEL CLUSTER (IPC) REPLACEMENT.

EXPERIENCING A RATTLE / SQUEAK IN RIGHT SIDE OF INSTRUMENT PANEL OR RIGHT FRONT DOOR TRIM PANEL SCRATCHED OR RIGHT SIDE...

ON SOME CONVERTIBLE MODELS, THE DOOR RATTLES WHEN CLOSING.

CONCERNS WITH THE LEFT HAND MANUAL MIRROR NOT ADJUSTING WHEN THE ADJUSTMENT LEVER IS MOVED.

CONDITIONS WITH WATER LEAK AT FRONT HEADER.

REAR COMPARTMENT (TRUNK) LID LATCH DIFFICULT TO UNLOCK / OPEN.

A RATTLE COMING FROM THE DOOR(S) WHEN THE DOOR WINDOW GLASS IS LOWERED.

LEFT HAND MIRROR DOES NOT ADJUST WHEN ADJUSTMENT LEVER IS MOVED (ADJUST LEVER TO ALIGN WITH LEVER SLIDE).

SCUFFED INTERIOR QUARTER TRIM PANELS ON CONVERTIBLE TOPS (ADD LOOP FASTENER TAPE/RE-STAKE REINFORCEMENT/ADD LOOP FASTENER).

LEAK IN THE AXLE SEAL AREA (SHORTEN VENT HOSE).

MIRROR VIBRATES AT HIGHWAY SPEEDS.

LEFT OUTSIDE BREAKAWAY MIRROR INOPERATIVE.

INOPERATIVE MANUAL OUTSIDE REARVIEW MIRROR(S).

OWNERS OF SOME VEHICLES EQUIPPED WITH HYDRA-MATIC 3T40, 4T60, 4T60-E OR 4T65-E TRANSAXLES MAY COMMENT ON A GRINDING AND...

EXHIBITING A RATTLE TYPE NOISE FROM GLOVE BOX DOOR OR KEY LOCK CYLINDER.

SOME VEHICLES WITH 2.2L ENGINES MAY EXHIBIT A ENGINE / TRANSMISSION WHINE AT 2800 - 32000 RPM.

VEHICLES MAY EXHIBIT A CLATTERING NOISE AT IDLE SPEED ORIGINATING FROM THE TIMING CHAIN AND FRONT COVER AREA.

CONCERNS THAT LOW ENGINE COOLANT LIGHT WILL ILLUMINATE DURING SUSTAINED DRIVING.

EXHIBITING DIAGNOSTIC TROUBLE CODES P0300, P0301, P0302, P0303, AND P0304 INDICATING ENGINE MISFIRE CONDITIONS.

INFORMATION CONCERNING ENGINE KNOCK/RATTLE OR TAP NOISE BEFORE ENGINE HAS REACHED OPERATING TEMPERATURE OR UNDER LIGHT...

ENGINE STALL AT COLD START, ROUGH IDLE, OIL FILTER EXPANSION, HIGH OIL PRESSURE AND ENGINE MISFIRE DTC'S (REPLACE OIL...

COOLANT LOSS, VISIBLE COOLANT LEAKAGE, LOW COOLANT LAMP ON OR COOLANT ODOR CAUSED BY COOLANT LEAKAGE.

INFORMATION ON 4T40-E (MN4) AND 4T45-E (MN5) FRONT WHEEL DRIVE AUTOMATIC TRANSMISSION VALVE BODY RECONDITIONING, DTC...

NEUTRAL FLARE AND/OR RPM FLARE WHILE IN DRIVE, NO 1-2 UPSHIFT, SERVICE ENGINE SOON (SES) LIGHT ILLUMINATED, DIAGNOSTIC...

NEUTRAL FLARE AND/OR RPM FLARE WHILE IN DRIVE, NO 1-2 UPSHIFT, SERVICE ENGINE SOON (SES) LIGHT ILLUMINATED, DIAGNOSTIC...

ENGINEERING CHANGES TO THE VALVE BODY, PRESSURE REGULATOR VALVE, 2-3 ACCUMULATOR VALVE AND BORE FOR 2002-2003 MODEL YEAR...

SOME CUSTOMERS MAY COMMENT ON A CLUNK TYPE NOISE COMING FROM THE FRONT OF THE VEHICLE DURING A TURNING MANEUVER.

SOME OWNERS MAY COMMENT ON LEAKAGE OF A FEW DROPS OF COOLANT AFTER PARKING THEIR VEHICLE.

CONVERTIBLE TOP COVER SHOWS WEAR OR PERMANENT DAMAGE IN VARIOUS AREAS.

SOME VEHICLES EQUIPPED WITH HYDRA-MATIC 3T40, 4T60 OR 4T60-E TRANSXALES MAY COMMENT ON A GRINDING AND / OR GROWLING...

CUSTOMERS MAY COMPLAIN THAT THE FRONT SEAT SHOULDER BELT PLASTIC COVER WILL NOT STAY SNAPPED IN PLACE ON COUPE MODELS ONLY.

SOME CUSTOMERS MAY COMMENT THAT THERE IS A BULGE IN THE MATERIAL ON THE TOP BACKSIDE OF EITHER FRONT BUCKET SEAT.

SOME OWNERS MAY COMMENT THAT A METALLIC NOISE OR

COMMENTS ON THE CONVERTIBLE TOP COVER SHOWING WEAR OR PERMANENT DAMAGE.

VARIOUS AREAS OF THE VEHICLE CONVERTIBLE TOP COVER SHOWS WEAR OR PERMANENT DAMAGE.

VARIOUS INFORMATION REGARDING OVERNIGHT COLD SOAK CONDITIONS.

RATTLE/SQUEAK FROM PASSENGER (RIGHT) SIDE OF REAR FOLDING SEATBACK AREA (REPOSITION RIGHT HAND FRAME ARM).

SOME CUSTOMERS MAY COMMENT ON A CLUNK TYPE NOISE COMING FROM THE FRONT OF THE VEHICLE DURING A TURNING MANEUVER.

INFORMATION REGARDING SNOW INTRUSION INTO REAR DRUM BRAKE ASSEMBLIES.

SUBJECT REGARDING REQUEST FOR CUSTOMER COMPLAINT VEHICLES WHICH HAVE A FRONT BRAKE SQUEAK / SQUEAL NOISE COMPLAINT.

COMMENTS THAT THE REAR BRAKES MAY DRAG/HEAT UP OR REAR OF CAR IS SQUATTING DUE TO AGGRESSIVE REAR BRAKE.

COMMENT THAT THE ABS LIGHT IS ON WITH DIAGNOSTIC TROUBLE CODES (DTC'S) 46 AND 86 SET AS CURRENT OR HISTORY.

ABS PUMP RUNNING WHEN NOT NEEDED.

VEHICLES MAY SET ANYONE OR A COMBINATION OF FRONT-WHEEL SPEED SENSOR ANTI-LOCK BRAKE SYSTEM CODES AS INTERMITTENT OR HARD FAILURES.

ANTI-LOCK BRAKING SYSTEM (ABS) FRONT WHEEL SPEED CODES - JUMPER HARNESS.

ABS FRONT WHEEL SPEED CODES - JUMPER HARNESS.

CLN INDICATOR APPEARS ON RADIO DISPLAY AND DOES NOT TURN OFF (RESET CLN INDICATOR WITH THE EJECT BUTTON ON TAPE).

This informational bulletin provides information for dealers/technicians on Procedures to Unlock Delco Radio with...

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco Theft Lock.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock.

INFORMATION ON ERROR CODES ON RADIO DISPLAY THEIR CAUSE AND CORRECTIVE ACTION.

COMMENTS THAT A METALLIC NOISE OR COLD RAP HEARD ON COLD EXHAUST SYSTEM.

COMMENTS THAT A METALLIC NOISE ON COLD EXHAUST SYSTEMS.

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for...

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for...

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for...

This informational bulletin provides the technician with information on what E85 fuel may due to a non E85 vehicle.

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for...

SOME VEHICLES MAY EXHIBIT A CLUNK TYPE NOISE ESPECIALLY FELT IN THE STEERING WHEEL WHILE TURNING.

THIS MESSAGE CONCERNS VEHICLES EXHIBITING A CLUNK NOISE COMING FROM THE FRONT OF THE VEHICLE.

INFORMATION ON DIAGNOSING CLUNK OR BUMP NOISE USUALLY HEARD WHEN TURNING EMITTING FROM THE FRONT OF THE VEHICLE.

CUSTOMERS MAY COMPLAIN OF A CLUNK NOISE FROM FRONT END OF THE VEHICLE DURING TURNING MANEUVERS OR STEERING WHEEL ROTATION.

CONCERNS WITH CLUNK NOISE FROM FRONT OF VEHICLE TURNING MANEUVER / STEERING WHEEL ROTATION.*JB (LUBRICATE OR REPLACE...

CLUNK NOISE FROM FRONT OF VEHICLE DURING TURNING MANEUVER/STEERING WHEEL ROTATION.

THIS BULLETIN IS BEING ISSUED TO REVISE THE FRONT SUSPENSION FASTNER TIGHTENING SPECIFICATIONS.*TT

PRODUCT RECALL CAMPAIGN TO REPLACE THE REAR SUSPENSION TRAILING ARM FASTENERS ON VEHICLES HAVING A CONDITION WHICH COULD...

SUBJECT PERTAINING TO FRONT AND / OR REAR STABILIZER SHAFT SQUAWK / SQUEAK NOISE.

REAR SHOCK NOISE IN TRUNK AREA - SOUNDS LIKE LOOSE LUMBER.

FRONT SUSPENSION STEER NOISE SMOOTH ROAD TURNS.

DELAY ENGAGEMENT INTO DRIVE AFTER COLD SOAK (REPLACE WITH REVISED FORWARD CLUTCH HOUSING ASSEMBLY COMPLETE).

CLUNK FELT/NOISE HEARD FROM STEERING COLUMN, STEERING GEAR AND/OR FRONT OF VEHICLE DURING TURNING MANEUVER AND/OR...

CLUNK FELT/NOISE HEARD FROM STEERING COLUMN, STEERING GEAR AND/OR FRONT OF VEHICLE DURING TURNING MANEUVER AND/OR STEERING WHEEL ROTATION.

VEHICLE WILL NOT MOVE IN EITHER DIRECTION.

4T40E OR 4T45E WILL NOT SHIFT NO DIAGNOSTIC TROUBLE CODES.

CUSTOMER CONCERN OF PREMATURE FOG LAMP FAILURE.

COMMENTS THAT THE DECK LID WILL NOT OPEN WHEN THE INTERIOR REMOTE RELEASE HANDLE IS PULLED.

SOME CUSTOMERS MAY WANT TO TOW THEIR VEHICLE BEHIND ANOTHER VEHICLE WITH ALL FOUR TIRES ONT HE GROUND.

SOME CUSTOMERS MAY WANT TO TOW THEIR VEHICLE BEHIND ANOTHER VEHICLE WITH ALL FOUR TIRES ONT HE GROUND.

Vehicle Recalls

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

This warranty administration bulletin provides policy information with the field action courtesy transportation policy.

CONDITIONS REGARDING WEAK OR DISCHARGED BATTERY, SLOW STARTING, GEN OR MIL LAMP ON, VARIOUS DRIVEABILITY SYMPTOMS.

INTERIOR DOME LIGHT STAYS ON ALL THE TIME (REROUTE WIRE HARNESS).

Expanded Availability for Remanufacture and Return (R&R) Electronic Control Modules

SEAT BELT LATCH SLIDES TO SEAT BELT ANCHOR SLEEVE.

COMMENTS THAT THE SEAT BELT LATCH SLIDES TO THE SEAT BELT ANCHOR SLEEVE.

SOME CUSTOMERS MAY WANT TO TOW THEIR VEHICLE BEHIND ANOTHER VEHICLE WITH ALL FOUR TIRES ONT HE GROUND.

THIS TECHNICAL BULLETIN PROVIDES A PROCEDURE TO REPROGRAM THE MEDIA DISC PLAYER WITH THE LATEST CALIBRATIONS TO CORRECT...