1997 Plymouth Voyager TSBs

SUBJECT REGARDING WIRE SPLICE REPAIRS.

SUBJECT REGARDING CHILD SEAT TETHER ANCHORS.

SUBJECT ON THE CHILD SEAT TETHER ANCHORS.

SUBJECT REGARDING CHILD SEAT TETHER ANCHORS.

THIS BULLETIN PROVIDES A REVISED WIRE SPLICE PROCEDURE AND RELATED PARTS.

SUBJECT REGARDING MISDIAGNOSED LEAK DETECTION PUMP SYSTEMS WITH DIAGNOSTIC TROUBLE CODES P1494, P0442 P0455, OR P0456.

TEST

CONCERNS WITH HIGH EFFORT REQUIRED TO U NLATCH REAR BENCH SEATS FROM THE FLOOR.

THIS BULLETIN INVOLVES INTERMITTENT POPPING ON FRONT END.

CONCERNS WITH "HONK" NOISE DURING PARKING LOT MANEUVERS.

CONCERNS WITH "HONK" NOISE DURING PARKING LOT MANEUVERS.

INFORMATION ON LEAK DETECTION PUMP (LDP) DEALER TEST MODE.

VEHICLE MAY EXPERIENCE REMOTE KEYLESS ENTRY TRANSMITTER BATTERIES DISCHARGE PREMATURELY.

CONCERNS WITH SERPENTINE BELT COMING OFF OR OUTBOARD RIBS OF BELT ARE FRAYED.

CONCERNS WITH THUMPING NOISE AT REAR OF VEHICLE DURING COLD OPERATION.

INFORMATION ON CHILD SEAT TETHER ANCHORS.

CONCERNS WITH SPEED CONTROL WHICH DOES NOT MAINTAIN SET SPEED WHILE CLIMBING A GRADE.

THIS BULLETIN EXPLAINS THE OPERATION AND APPLICATION OF THE LEAK DETECTION PUMP (LDP) MONITOR TEST.

EXPERIENCING TICK TYPE NOISE AT TOP OF LEFT B-PILLAR.

CONDITIONS WITH INTERMITTENT LOSS OF SPEED CONTROL.

SUBJECT PERTAINING TO SMOOTH ROAD HIGH-SPEED VIBRATION OR SHAKE CONDITION.

SUBJECT PERTAINING TO A TICKING TYPE NOISE AT TOP OF LEFT B-PILLAR.

RIGHT SIDE HALF SHAFT CV BOOT IS MADE OF A SPECIAL HIGH TEMPERATURE RESISTANT MATERIAL THAT CAN SHOW HEAVY GREASE...

RATTLE NOISE FROM REAR OF THE VEHICLE WHEN DRIVING OVER ROAD BUMPS.

A "HONK" OR SQUEAL NOISE DURING PARKING LOT MANEUVERS.

*DURING LOW SPEED VEHICLE EXPERIENCES SIDE TO SIDE OSCILLATION/WOBBLE WHILE DRIVING BETWEEN 10-45MPH.

35 MPH CYCLIC VIBRATION.

CREAK SOUND HEARD UPON ACCELERATION AND/OR DECELERATION- SOUND SEEMS TO COME FROM FLOORPAN/DASH AREA.

Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry...

Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to...

Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry...

Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to...

SUBJECT REGARDING CAMSHAFT / BEARING SERVICE.

CONCERNS WITH THE PCV VALVE FREEZING UNDER EXTREMELY COLD CONDITIONS.

INFORMATION ON GASKET SURFACE PREPARATION ON ALUMINUM ENGINE COMPONENTS.

CONCERNS WITH ENGINE COOLANT USAGE.

TECHNICAL SERVICE BULLETIN REGARDING MULTI-LAYER STEEL (MLS) HEAD GASKET INSTALLATION PROCEDURES.

CONCERNS WITH SERPENTINE BELT SLIPPING OFF IDLER PULLEY.

CONCERNS WITH FRONT AND / OR SLIDING DOOR POWER LOCK MOTORS MAKING A WHIRLING NOISE.

SUBJECT REGARDING OIL SEEPAGE AT CAM POSITION SENSOR / MISINTERPRETED HEAD GASKET LEAK.

A NEW MULTI-LAYER STEEL ( MLS ) HEAD GASKET HAS BEEN DEVELOPED AND IS BEING IMPLEMENTED INTO PRODUCTION VEHICLES.

VEHICLE EXPERIENCING A TICKING NOISE WHILE AT IDLE FROM ENGINE.

SUBJECT ON LABOR OPERATION TIME CHANGE FOR DOMESTIC 2.OL DOHC AND 2.4L HEAD GASKET REPLACEMENT.

SUBJECT ON TIP-IN SAGS/HESITATIONS OR ROUGH IDLE AFTER A HOT SOAK RESTART.

CONDITION WITH UNDERHOOD NOISE DUE TO SERPENTINE BELT OUTBOARD RIBS FRAYING OR SPLITTING FROM THE MAIN PORTION OF THE...

VARIOUS CAR OWNER'S HAVE EXPRESSED INTEREST IN USING ENGINE COOLANTS MADE WITH PROPYLENE GLYCOL INSTEAD OF ETHYLENE GLYCOL.

VEHICLES WITH 3.0L ENGINES - INTAKE VALVE DEPOSITS - DRIVEWAY DIE OUT, ROUGH IDLE, LACK OF POWER, SAGS OR HESITATION.

2.4L CRANKSHAFT/CAMSHAFT TIMING.

FRONT HVAC BLOWER MOTOR RESISTOR CONNECTOR SERVICE.

Valve Body. These may cause over drive cycling.

SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT.

SUBJECT REGARDING OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT.

THIS BULLETIN INVOLVES INSTALLATION OF A NEW COMPONENT TO ASSIST CAM SEAL RETENTION.

SUBJECT REGARDING OUTSIDE MIRROR GLASS REPLACEMENT.

EXPERIENCING A CHATTER SOUND COMING FROM THE SLIDING DOOR POWER LOCK ACTUATOR(S) WHEN THE POWER LOCK FEATURE IS REPEATEDLY ACTIVATED.

A CONDITION EXIST WHERE THE ROOF PANEL SURFACE EXHIBITS WAVINESS OR DEPRESSION(S) NEAR THE FRONT OF THE CHARACTER...

THIS BULLETIN INVOLVES SLIDING DOOR POOR FIT - LOW AT REAR.

INFORMATION ON ALL WHEEL DRIVE (AWD) SYSTEM SEAL REPLACEMENT.

WINDNOISE AROUND FRON DOOR GLASS, ESPECIALLY AT TOP OF THE B PILLAR.

FRONT WINDSHIELD WIPERS SELF-ACTIVATE WHILE DRIVING OR WILL NOT TURN OFF.

WINDSHIELD WIPERS SELF-ACTUATE WHILE DRIVING OR WILL NOT TURN OFF.

SYMPTOMS WITH ROOF RACK RATTLES AT HIGHWAY SPEEDS.

CONCERNS OF THUMPING NOISE FROM THE REAR JOUNCE BUMPERS WHEN DRIVING OVER SMALL BUMPS AFTER THE VEHICLE HAS BEEN IN VERY COLD TEMPERATURES.

WINDSHIELD WIPERS DO NOT PARK PROPERLY AND/OR WIPE IN THE INTERMITTENT MODE PROPERLY.

WINDSHIELD WIPERS DO NOT PARK PROPERLY AND/OR WIPE IN THE INTERMITTENT MODE PROPERLY.

DIFFICULT TO CLEAN LIGHT COLORED "CHALKY" RESIDUE FROM PLASTIC BODY COMPONENTS THAT ARE MOLDED IN BLACK.

SNOW/WATER INGESTION INTO REAR BRAKE DRUM.

A CONDITION MAY EXIST WHERE A LOW FREQUENCY HOWL / MOAN NOISE IS HEARD FROM THE REAR BRAKE AREA DURING LOW SPEED AND /...

ON SOME VEHICLES, WHILE DRIVING THROUGH DEEP OR BLOWING SNOW / WATER, THE SNOW / WATER MAY ENTER THE REAR BRAKE DRUMS...

INFORMATION ON REAR WHEEL PARK BRAKE ACTUATOR / LEVER SERVICE.

INFORMATION REGARDING SNOW / WATER ENTERING THE REAR BRAKE DRUMS.

CONCERNS WITH BRAKE ACTUATOR LEVER RATTLE (ALL WHEEL DRIVE).

SOME VEHICLES MAY EXPERIENCE A RATTLE IN THE AREA OF THE REAR WHEELS CAUSED BY THE PARKING BRAKE ACTUATOR LEVER(S).

REAR BRAKE MOAN/HOWL NOISE.

REAR BRAKE CYCLIC RUBBING NOISE.

VEHICLES BUILT ON OR AFTER NOV 6, 1996 (MDH 1106XX) HAVE TWO 1/4IN FOAM PADS ATTACHED TO THE TOP OF THE FUEL TANK, ONE...

SNOW/WATER INGESTION INTO REAR BRAKE DRUM.

SNOW/WATER INGESTION INTO REAR BRAKE DRUM.

SNOW/WATER INGESTION INTO REAR BRAKE DRUM.

CONCERN WITH WATER LEAK ONTO THE PASSENGER SIDE FLOOR FROM THE HVAC HOUSING.

EXHIBITING A PERIODIC BUMP IN POWER TRAIN WHEN THE A/C IS OPERATING

CONCERNS WITH SAGS / HESITATION / STUMBLE / START & STALL, A/C BUMP IMPROVEMENTS, ADDITION OF LEAK DETECTION PUMP (LDP) MONITOR TEST.

SUBJECT REGARDING A/C SUCTION AND / OR DISCHARGE LINE REQUIRES REPLACEMENT DUE TO CRACKING AT OR NEAR COMPRESSOR.

EXHIBITING A MOANING AND GROANING SOUND ACCOCIATED WITH A/C COMPRESSOR OPERATION.

SOME VEHICLES MAY EXPERIENCE A BUMP FEELING DURING A/C COMPRESSOR ENGAGEMENT.

WATER LEAKS ONTO THE PASSENGER SIDE FLOOR FROM THE HVAC HOUSING.

EXHIBITING A PERIODIC ''BUMP'' IN POWER TRAIN WHEN THE A/C IS OPERATING.

A/C SUCTION AND/OR DISCHARGE LINE SERVICE.

COOLANT SEEPAGE AT UNDERBODY AUXILLARY REAR HEATER LINE HOSE CONNECTION.

SUBJECT REGARDING TRANSMISSION OIL COOLER LINE HOSE CLAMP SERVICE.

THIS BULLETIN INVOLVES TRANSMISSION FLUID AUXILIARY COOLER.

CONCERNS WITH 41TE/42LE TRANSAXLE SHUDDER DURING AN EMCC (ELECTRONICALLY MODULATED CONVERTER CLUTCH) SHIFT.

THIS BULLETIN INVOLVES TRANSAXLE KICKDOWN, LINKAGE WEARS THE WIRING HARNESS.

THIS BULLETIN ANNOUNCES THE AVAILABILITY AND INSTALLATION OF A RESUABLE AUTOMATIC TRANSMISSION OIL PAN GASKET.

SUBJECT REGARDING REUSABLE AUTOMATIC TRANSMISSION OIL PAN GASKET.

SERVICE AND PARTS INFORMATION ON 1999 RUNNING CHANGES TO TRANSMISSION RANGE SENSOR (TRS) *TT

SUBJECT ON DELAYED TRANSAXLE ENGAGEMENT.

CONDITION WITH TRANAXLE SHUDDER DURING A 3RD GEAR TO 3RD GEAR PARTIAL EMCC ( ELECTRONICALLY MODULATED CONVERTER CLUTCH)...

CONCERNS WITH THE AIR BAG WARNING INDICATOR LAMP ON INTERMITTENTLY OR CONSTANTLY.

SUBJECT REGARDING NON-DEPLOYED AIRBAG HANDLING PROCEDURES.

DAIMLERCHRYSLER CORPORATION IS NOW OFFERINB AIRBAG ON / OFF SWITCHES FOR SELECTED VEHICLES.

INFORMATION REGARDING NHTSA AUTHORIZED AIRBAG DEACTIVATION FOR MEDICAL NECESSITY.

SUBJECT REGARDING AIRBAG ON - OFF SWITCHES.

SUBJECT REGARDING THE AIRBAG ON-OFF SWITCHES.

AUTHORIZED AIRBAG DEACTIVATION FOR MEDICAL NECESSITY.

AIR BAG WARNING LABELS.

THIS BULLETIN CONTAINS PROCECURES TO REMOVE WAVINESS OR DEPRESSIONS FROM THE ROOF PANEL SURFACE.

INFORMATION ON NO START DIAGNOSTIC CAM/CRANK SENSOR $01 AND $28.

CHILD SAFETY SEAT VIDEO AND HARNESS CLIPS FOR MINIVANS EQUIPPED WITH INTEGRATED CHILD SEATS.

INFORMATION REGARDING THE IGNITION SWITCH HOUSING SERVICE.

SOME VEHICLES MAY EXHIBIT A CONDITION WHERE THE POWERTRAIN CONTROL MODULE (PCM) RESETS WHILE THE CUSTOMERS IS DRIVING THE VEHICLE.

INFORMATION ON BODY CONTROL MODULE (BCM) REPLACEMENT.

ERRONEOUS MIL ILLUMINATION WITH HEX CODE $29, $2A, $2B, ERRONEOUS PCM RESETS, DISPLAYED FUEL ECONOMY INACCURACY.

Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test...

EXPERIENCING A POP/TICK SOUND HEARD COMING FROM THE STEERING WHEEL AREA WHILE THE VEHICLE IS IN MOTION.

A CONDITION WHERE A CLICK / RATTLE SOUND MAY BE HEARD COMING FROM THE AREA OF THE STEERING WHEEL WHILE THE VHICLE IS IN MOTION.

SOME VEHICLES EXPERIENCE A MOMENTARY LOSS OF POWER ASSIST FOR THE STEERING WHEN TURNING CORNERS WITH THE A/C OR...

DURING HIGH HUMIDITY CLIMATE CONDITIONS, SOME VEHICLES MAY EXPERIENCE A MOMENTARY LOSS OF POWER ASSIST FOR THE STEERING...

POP/TICK SOUND IN STEERING WHEEL AREA.

VEHICLE OPERATOR MAY COMPLAIN OF POOR AM RADIO RECEPTION.

VEHICLE MAY EXPEREIENCE INOPERATIVE CD PLAYER SALES CODE RAZ RADIO.

INFORMATION ON INSTALLATION OF RADIO TRANSMITTING EQUIPMENT.

THE CD PLAYER MAY BECOME INOPERATIVE, AND WILL NOT ACCEPT THE CD WHEN ATTEMPTING TO INSERT THE DISK INTO THE RADIO.

CONCERNS WITH CD PLAYER NOT ACCEPTING CD WHEN ATTEMPTING TO INSERT THE DISK INTO THE RADIO.

FLASH PROGRAMMING FAILURE RECOVERY.

INFORMATION ON SERVICE PUBLICATION UPDATES.

SUBJECT ON FLASH PROGRAMMING FAILURE RECOVERY.

EXPERIENCING A SQUAWK / CREAK / GROAN SOUND FROM FRONT SUSPENSION WHILE DRIVING OVER ROUGH / BUMPY ROADS.

SUBJECT REGARDING AIRBAG / CLOCK SPRING SERVICE FOR VARIOUS MODELS INCLUDING 2002 MODEL YEAR JEEP LIBERTY.

COSMETIC CORROSION OR PERFORATION AT UPPER STRUT TOWER/S USUALLY BETWEEN THE STRUT AND UPPER LOAD PATH BEAM INNER PANEL (INNER FENDER).

SUBJECT REGARDING GENERIC SCAN TOOL (GST), PUBLICATION NO.

INFORMATION ON 41TE/42LE SERVICE INFORMATION.

SUBJECT REGARDING I/M ( INSPECTION MAINTENANCE ) TESTING - OBD II "CARB" READINESS MONITOR INFORMATION.

THIS BULLETIN INVOLVES VIBRATION/DRONE AT ALL VEHICLE SPEEDS AND/OR SLIGHT JERK DURING INITIAL ACCELERATION AND/OR COMING TO A FULL STOP.

Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair...

Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair...

CONCERNS WITH A/C EVAPORATOR ODOR.

INFORMATION ON POOR DRIVABILITY WITH HIGH DI (DRIVABILITY INDEX) FUEL.

INFORMATION ON TIRE AND WHEEL RUNOUT.

CUSTOMER MAY COMPLAIN OF LOW SPEED TIRE WOBBLE.