2010 Peterbilt 579 TSBs
23 Technical Service Bulletins across 9 categories
Categories
Electrical
9 bulletinsNon-Safety Campaign Chassis with the City Horn option may generate unexpected alerts.
Read full bulletin
A VECU software update is available to resolve the issue.
Non-Safety Campaign The batteries may drain quickly due to the VECU not going to sleep.
Read full bulletin
Updated VECU software is available to resolve the issue.
Information Only: This bulletin provides dealers with a battery warranty quick reference guide to ensure the...
Read full bulletin
appropriate tests for battery warranty are performed in order to prevent battery warranty claims filed with incorrect or incomplete information.
Fix as Fail: For all conventional models, except 387/587, equipped with Side-of-Cab (SOC) exhaust and built from...
Read full bulletin
03/6/2006 to 1/20/2020, the clamps that secure the SOC exhaust stacks may not be tightened properly. This may allow the exhaust stack to rotate and contact the cab or sleeper.
Information Only Vehicles may have the connector seals on the wheel speed sensor incorrectly installed, which may lead...
Read full bulletin
to water intrusion and corrosion in some vehicles.
Information Only: Proper jump-starting voltage will eliminate high voltage related issues and equipment damage.
Information Only: Vehicles may have the connector seal on the wheel speed sensor incorrectly installed, which may lead...
Read full bulletin
to sensor corrosion.
Information Only - Quick Reference Guide for Electric harness damage repairs.
Fix-As-Fail: Repair for horizontal exhaust diffuser configurations with broken brackets or cracked diffuser.
Body & Paint
3 bulletinsInformation Only Windshield washer pumps have a high No Trouble Found rate.
Read full bulletin
Washer pumps may fail to spray due to a clogged filter.
Information Only: Proper instructions for closure of power distribution box cover to prevent corrosion.
Informational Only - Peterbilt 579 aero bumper radar cover license plate grommets require 1/4"x 20 x 3/4"long...
Read full bulletin
fasteners.
Brakes
3 bulletinsFix as Fail: Peterbilt has determined that certain model 348, 365, 367, 382, 384, 386, 388, 389, 567, 579, and 587...
Read full bulletin
trucks, built between 4/13/2010 and 3/16/2020 and equipped with a flush mounted battery box, utilized rubber washers that could rub through and cause the aluminum box mounting tabs to rub directly on the steel frame brackets. This could result in cracked battery box mounting angles. Resolution is to add the reinforcement bracket(s) to affected vehicles.
Safety Recall Bulletin: Updated with permanent repair path for phase 1 vehicles.
Read full bulletin
The Tractor ABS Lamp May Not Illuminate When ABS Controller Loses Battery and/or Ignition Power. NHTSA recall number is 18V368. Non compliance to FMVSS and CMVSS 121 and 136. Resolution is to Reflash software.
Safety Recall Interim Bulletin: The Tractor ABS Lamp May Not Illuminate When ABS Controller Loses Battery and/or Ignition Power.
Read full bulletin
NHTSA recall number is 20V199 Non compliance to FMVSS and CMVSS 121 and 136. Resolution is to Reflash software.
HVAC & Climate
2 bulletinsInformation Only: This bulletin provides guidance for repairing an air-conditioning system after internal failure of the...
Read full bulletin
A/C compressor.
FIX-AS-FAIL: AN INTERNAL ISSUE MAY CAUSE SOME HVAC MODE DOOR ACTUATORS TO FAIL.
Read full bulletin
THIS WILL CAUSE THE HVAC SYSTEM TO ACT ERRATICALLY OR CONSTANTLY TURN ON AND OFF.
Software & Calibration
2 bulletinsInformation: Bendix ACOM Software version 6.16.5.0 for diagnostics may introduce an unrecoverable error.
Read full bulletin
Notice to dealers to replace this version with older software version until Bendix introduces new version.
Information - Recommended Practices for Updating ESA Software
Other
1 bulletin"Kenworth: Dealers should check the chassis list and SIR weekly for VIN changes.
Read full bulletin
2 chassis added to the chassis list. Peterbilt: Dealers should check the chassis list and SIR weekly for VIN changes. 10 chassis added to the chassis list."
Infotainment
1 bulletinSmartNav 2.0 Hardware retrofit for quality validation and vehicle validation units.
Pre-Delivery & Maintenance
1 bulletinInformation only: Hendrickson Softek front axle maintenance intervals and requirements.
Lighting
1 bulletinInformation only - Customer installed inverters may be wired incorrectly.