2017 Peterbilt 348 TSBs
38 Technical Service Bulletins across 13 categories
Categories
Electrical
9 bulletinsFix As Fail Chassis that were manufactured with certain battery cable routing brackets may experience rubbing or...
Read full bulletin
chafing of the battery cables.
Fix-As-Fail Due to undersupply issues, only a limited supply of Diesel Exhaust Fluid (DEF) sensors are available.
Read full bulletin
As a temporary solution, after PACCAR confirms a DEF sensor is not available, a temporary software update will allow a vehicle to continue operation with a failed DEF sensor by disabling the DEF sensor diagnostics.
Safety Recall Cummins Fuel Rail Leak NHTSA ID: 21V391 / TC: 2021-323, Cummins Recall: C2423.Cummins PX9 and ISX12 fuel...
Read full bulletin
rails may leak around a sealing washer, potentially resulting in fuel leaks.Undetected prolonged diesel fuel spray in the presence of an ignition source may increase the risk of fire.
Information Only: This bulletin provides dealers with a battery warranty quick reference guide to ensure the...
Read full bulletin
appropriate tests for battery warranty are performed in order to prevent battery warranty claims filed with incorrect or incomplete information.
Fix as Fail: For all conventional models, except 387/587, equipped with Side-of-Cab (SOC) exhaust and built from...
Read full bulletin
03/6/2006 to 1/20/2020, the clamps that secure the SOC exhaust stacks may not be tightened properly. This may allow the exhaust stack to rotate and contact the cab or sleeper.
Information Only Vehicles may have the connector seals on the wheel speed sensor incorrectly installed, which may lead...
Read full bulletin
to water intrusion and corrosion in some vehicles.
Information Only: Proper jump-starting voltage will eliminate high voltage related issues and equipment damage.
Information Only: Vehicles may have the connector seal on the wheel speed sensor incorrectly installed, which may lead...
Read full bulletin
to sensor corrosion.
Information Only - Quick Reference Guide for Electric harness damage repairs.
Engine
5 bulletinsInfo Only Unnecessary starter replacements can result from customer complaints regarding engine starting issues.
Read full bulletin
A new Starter Troubleshooting Guide has been created to provide a comprehensive list of starting system checks, which should reduce unnecessary starter replacements and associated warranty claims. Engine starting system warranty claims now require a completed Starter Checklist, a Battery Pack Midtronics Report, and a Cable Drop Midtronics Report. Claims filed without these documents may be denied.
An engine software defect exists in certain vehicles equipped with EMY17 MX-13 and MX-11 engines that pertains to timer...
Read full bulletin
action and count calibrations for a time-based diagnostic. This diagnostic action checks fuel pressure and has no negative impact on tailpipe emissions. This soft ware may incorrectly set DTC P1092.
Info Only - PACCAR is introducing Over-the-Air (OTA) software updates for engine MY17 and newer chassis equipped with...
Read full bulletin
Cummins X15, X12, ISX12, ISX12N, L9N, PX-7, and PX-9 engines The technology will leverage the existing Remote Diagnostic cs hardware to deliver secure software updates remotely. This will reduce downtime and save on maintenance costs for eligible vehicles.
Fix-As-Fail On certain chassis with Low Air Leaf Suspension or Low-Low Air Leaf Suspension, the Height Control Valve...
Read full bulletin
(HCV) arm may be rubbing on other components when the bend in the arm is facing outboard. Flipping the bend in the HCV arm inboard prevents the rub.
Fix-As-Fail - Composite fittings used in the cooling system may crack, resulting in coolant leaks.
Read full bulletin
Brass fittings are available to replace the composite fittings.
Software & Calibration
4 bulletinsThe service information for Bendix Air Dryer maintenance is being updated to include new procedures.
Information Only - Vehicles built with NAMUX software from 2013 to present may experience accuracy issues with the tachometer.
Read full bulletin
The issue can be temporarily resolved using any one of the included procedures.
Information: Bendix ACOM Software version 6.16.5.0 for diagnostics may introduce an unrecoverable error.
Read full bulletin
Notice to dealers to replace this version with older software version until Bendix introduces new version.
Information - Recommended Practices for Updating ESA Software
Brakes
4 bulletinsFix as Fail: Peterbilt has determined that certain model 348, 365, 367, 382, 384, 386, 388, 389, 567, 579, and 587...
Read full bulletin
trucks, built between 4/13/2010 and 3/16/2020 and equipped with a flush mounted battery box, utilized rubber washers that could rub through and cause the aluminum box mounting tabs to rub directly on the steel frame brackets. This could result in cracked battery box mounting angles. Resolution is to add the reinforcement bracket(s) to affected vehicles.
Fix-As-Fail - Bendix New-Gen Lightweight Steer Axle Drum Brake Spider Cracking
Safety Recall Bulletin: Updated with permanent repair path for phase 1 vehicles.
Read full bulletin
The Tractor ABS Lamp May Not Illuminate When ABS Controller Loses Battery and/or Ignition Power. NHTSA recall number is 18V368. Non compliance to FMVSS and CMVSS 121 and 136. Resolution is to Reflash software.
Safety Recall Interim Bulletin: The Tractor ABS Lamp May Not Illuminate When ABS Controller Loses Battery and/or Ignition Power.
Read full bulletin
NHTSA recall number is 20V199 Non compliance to FMVSS and CMVSS 121 and 136. Resolution is to Reflash software.
Other
3 bulletins"Kenworth: Dealers should check the chassis list and SIR weekly for VIN changes.
Read full bulletin
2 chassis added to the chassis list. Peterbilt: Dealers should check the chassis list and SIR weekly for VIN changes. 10 chassis added to the chassis list."
DEF tank covers may become loose and potentially crack on vehicles built before October 2019 with DEF tank part number...
Read full bulletin
M86-6221-003**(TANK-DEF MEDIUM ASSY) and M86-6222-003**(TANK-DEF LARGE, ASSY). Resolution is to resolve the vibration on the tank cover by adding bottom tank washers.
Fix-As-Fail: Two separate causes have been identified as root cause of intermittent low coolant indicator illumination.
Fuel System
2 bulletinsDue to major data carriers phasing out 3G networks, chassis currently utilizing first generation Peoplenet Mobile...
Read full bulletin
Gateway (PMG001) will experience severe 3G service degradation as early as January of 2022. Chassis currently utilizing 3G antennas as a primary antenna may experience this degradation.
Information Only: An improved procedure has been developed for servicing the fuel filter on model 348 chassis equipped...
Read full bulletin
with a PX-9 and 11 5/8 frame rails.
Steering
2 bulletinsSample Customer Letter - Field Repair 11151: Steering Column Mounting Bolts Loose.
Sample Customer Letter - 216-1 Dana Intermediate Steering Shaft Unseated or Missing C-clip.
Body & Paint
2 bulletinsInformation Only Windshield washer pumps have a high No Trouble Found rate.
Read full bulletin
Washer pumps may fail to spray due to a clogged filter.
Information Only: Proper instructions for closure of power distribution box cover to prevent corrosion.
Infotainment
2 bulletinsSmartNav 2.0 Hardware retrofit for quality validation and vehicle validation units.
FIX-AS-NEEDED - SMARTNAV SOFTWARE UPDATE IS AVAILABLE FOR IMPROVEMENTS TO IN-CALL AUDIO, RADIO SETTINGS AND WHEEL SEEK...
Read full bulletin
FUNCTIONALITY.
Pre-Delivery & Maintenance
2 bulletinsInformation only: Hendrickson Softek front axle maintenance intervals and requirements.
Information Only This bulletin provides information about the California Air Resources Board (CARB) Periodic Smoke...
Read full bulletin
Inspection Program (PSIP) and Heavy Duty Vehicle Inspection Program (HDVIP).
HVAC & Climate
1 bulletinInformation Only: This bulletin provides guidance for repairing an air-conditioning system after internal failure of the...
Read full bulletin
A/C compressor.
Transmission
1 bulletinNon-Safety Campaign - Chassis with Eaton Manual or Ultrashift transmissions may experience loosening of the bellhousing...
Read full bulletin
bolts.
Suspension
1 bulletinFix-As-Fail ? There is an updated plug to fix leaking steer axle hubcaps.