1996 Nissan D21 TSBs
50 Technical Service Bulletins across 13 categories
Categories
Electrical
7 bulletinsSUBJECT REGARDING REVISED THROTTLE POSITION SENSOR (TPS) ADJUSTMENT PROCEDURE.
Read full bulletin
*TT
INFORMATION REGARDING ESSENTIAL TOOL: THROTTLE POSITION SENSOR TEST CONNECTOR.
Read full bulletin
*SLC
CONDITIONS WITH MIL 'ON'; DTC P0180 (FUEL TEMPERATURE SENSOR) STORED IN ECM.
Read full bulletin
*TT
VEHICLE HAS A MIL 'ON' AND DTC P0505 STORED IN THE ECM.
Read full bulletin
*YC
SILICONE-BASED LUBRICANT OR GREASE CAN DAMAGE ELECTRICAL COMPONENTS SERVICE INFORMATION Do not apply Silicone-based...
Read full bulletin
lubricants or grease to, or around, any interior electrical components. To avoid the risk of death or severe personal injury, do not directly spray Silicone-based lubricant or grease, or inadvertently overspray Silicone-based lubricant or grease onto any interior electrical components. These types of lubricants can be detrimental to the proper operation of electrical components.
12 VOLT BATTERY TESTING FOR IN-SERVICE VEHICLES SERVICE INFORMATION The following Service Information lists NNA...
Read full bulletin
procedural recommendations for establishing good connections while performing 12V battery testing. These recommendations are expected to promote uniformity during the connection process, therefore reducing the number of incorrect Test with DCA and Replace results. HINT: If 12 volt batteries are allowed to discharge for a prolonged period of time, battery life may be drastically reduced. This condition may lead to premature battery replacement and customer dissatisfaction. IMPORTANT: CPX-900 is now an accepted testing tool to use along with or in place of the DSS-5000 CPX-900 operating instructions are found at: https://nissancpx900.midtronics.com/ DSS-5000 operating instructions are found at: https://nissandss5000.midtronics.com/ DCA-8000 is now a required testing tool to be used for all warranty replacement decisions. The DCA-8000 is also a more efficient charger than previously available, and will charge any available 12 volt lead acid battery safely and accurately as long as all precautions and inputs are made correctly. The DCA-8000 operating instructions are found at: https://nissandca8000.midtronics.com/
SERVICE INFORMATION Information necessary to service the Supplemental Restraint System (SRS) safely is included in the...
Read full bulletin
"RESTRAINTS" section of the Electronic Service Manual (ESM) for each vehicle. IMPORTANT: Turn the ignition switch OFF, disconnect both battery terminals, and wait at least 3 minutes before performing any service on the SRS. See this bulletin for further detail.
Fuel System
7 bulletinsSOME VEHICLES MAY EXHIBIT A MALFUNCTION INDICATOR LAMP ON WITH EVAP SYSTEM DIAGNOSTIC TROUBLE CODES STORED DUE TO LAUNCHING A WATERCRAFT.
Read full bulletin
*TT
VEHICLES BUILT BEFORE 1N6SD11S9VC389078 MAY EXHIBIT A MALFUNCTION INDICATOR LIGHT ON WITH EVAPORATIVE EMISSION SYSTEM...
Read full bulletin
DIAGNOSTIC TROUBLE CODES P0440, P0443, P0446, P0450 AND P1445 STORED. *TT
SOME VEHICLES EXPERIENCING MIL 'ON' WITH EVAPORATIVE EMISSION SYSTEM DIAGNOSTIC TROUBLE CODE(S) (DTC(S) STORED.
Read full bulletin
*TT
SUBJECT ON MIL ' ON ' WITH EVAP SYSTEM DTCS STORED DUE TO LAUNCHING A WATERCRAFT.
Read full bulletin
*YC
SUBJECT ON MIL 'ON' WITH EVAP SYSTEM DTCS STORED DUE TO LAUNCHING A WATERCRAFT.
Read full bulletin
*YC
SOME VEHICLES EXPERIENCE MIL ' ON ' WITH EVAPORATIVE EMISSION SYSTEM DTC(S) STORED.
Read full bulletin
*YC
VEHICLES EXHIBITING A MIL 'ON' WITH ONE OR MORE OF THE BELOW DTCS STORED, THE CAUSE MAY BE INSECT NEST(S) IN THE...
Read full bulletin
EVAPORATIVE ( EVAP ) EMISSION CONTROL SYSTEM. *YC
Other
6 bulletinsINFORMATION ON NISSAN REVISED TPS ADJUSTMENT PROCDURE.
Read full bulletin
*SLC
SUBJECT REGARDING ESSENTIAL TOOL - REAR AXLE BEARING REMOVAL KIT.
Read full bulletin
*TTTHE KIT IS AN ESSENTIAL TOOL AND AND WILL BE AUTOMATICALLY SENT TO ALL NISSAN DEALERS.
A CONDITION MAY EXIST WHERE WATER MAY HAVE ENTERED THE DISTRIBUTOR ASSEMBLY.
Read full bulletin
*TT
VEHICLES EXHIBIT A MIL 'ON' WITH ONE OR MORE OF THE BELOW DTCS STORED.
Read full bulletin
*YC
INTELLIGENT KEY REPLACEMENT OR SWAPPING BETWEEN VEHICLES This bulletin has been amended.
Read full bulletin
See AMENDMENT HISTORY on the last page. Discard all previous versions of this bulletin.
NISSAN: LOCK/UNLOCK REQUEST BUTTON ON OUTSIDE HANDLE DOES NOT RESPOND.
Read full bulletin
*JS
Engine
6 bulletinsSOME ENGINES MAY EXHIBIT A RATTLE NOISE WHEN THE ENGINE IS IDLING AT FULL OPERATING TEMPERATURE.
Read full bulletin
*TT
CONCERNS WITH TRUCK EXHIBITING A ROUGH / NO IDLE AND / OR DTC P0400 STORED IN THE ECM DUE TO EGR VALVE STICKING.
Read full bulletin
*TT
COMPLAINTS OF AN OBJECTIONABLE NOISE FROM THE EVAP CANISTER PURGE VOLUME CONTROL VALVE.
Read full bulletin
*YC
VEHICLE KEY NOT DETECTED / AUTHENTICATED, ENGINE WILL NOT START This bulletin has been amended.
Read full bulletin
See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
NISSAN: VENT CONTROL VALVE REPLACEMENT.
Read full bulletin
WHEN REPLACING THE EVAP CANISTER VENT CONTROL VALVE FOR REASON: USE THE ONE LISTED ON PAGE 2; FOR VENT CONTROL VALVE REPLACEMENT PROCEDURE, REFER TO THE APPROPRIATE SECTION OF THE ELECTRONIC SERVICE MANUALS (ESM; WHEN INSTALLING THE NEW VALVE, DO NOT ADD ANY LUBE TO ITS O RING; FOR FRONTIER (D40 SERIES) ONLY, INSTALL THE PROTECTOR LISTED IN PARTS INFORMATION. *PE INCLUDES 2005-09 FRONTIER. UPDATED 12/8/10. *PE
NISSAN: THE 12 VOLT BATTERY IS AN IMPORTANT PART OF THE VEHICLE ELECTRICAL SYSTEM AND IS REQUIRED TO STAY CONNECTED WHEN THE ENGINE IS RUNNING.
Read full bulletin
TO PREVENT DAMAGE TO VEHICLE ELECTRONIC COMPONENTS FOLLOW THE INSTRUCTIONS/CAUTIONS. NO MODEL YEARS LISTED. *PE
Air Bags & Safety
5 bulletinsSEAT BELT LATCH PLATE RETAINING BUTTON MISSING.
Read full bulletin
*TT
CONCERNS WITH THE FRONT SEAT BELT LATCH PLATE STOPPER BUTTON MISSING.
Read full bulletin
*TT
NISSAN: SRS PRECAUTIONS DURING SERVICE;IMPROPER MAINTENANCE, INCLUDING INCORRECT REMOVAL AND INSTALLATION OF THE SRS,...
Read full bulletin
CAN LEAD TO A SERIOUS INJURY OR DEATH CAUSED BY UNINTENTIONAL ACTIVATION OF THE SRS ON ALL NISSAN MODELS WITH THE SRS SYSTEMS. *PE UPDATED 2/21/14. *PE
FRONT SEAT BELT LATCH PLATE RETAINING BUTTON MISSING.
Read full bulletin
*TT
FRONT SEAT BELT LATCH PLATE RETAINING BUTTON MISSING.
Read full bulletin
*TT
Lighting
5 bulletinsA VOLUNTARY SERVICE CAMPAIGN FOR VEHICLES EXHIBITING A MALFUNCTION INDICATOR LIGHT (MIL) ISSUES.
Read full bulletin
*TT
SUBJECT ON MALFUNCTION INDICATOR LIGHT ( MIL ) ISSUES.
Read full bulletin
*YC
VEHICLES MAY EXHIBIT A MALFUNCTION INDICATOR LIGHT ON WITH DTCS P0120, P0510, P0731, P0732 OR P0733 WITH NO DRIVEABILITY INCIDENTS.
Read full bulletin
*YC
VOLUNTARY SERVICE CAMPAIGN 1996 TRUCK MALFUNCTION INDICATOR LIGHT (MIL) ISSUES Service Campaign ID #s P8159, P8160, and P8161 are no longer active.
Read full bulletin
Repair orders opened after this bulletins published date are no longer eligible for reimbursement under Campaign ID #s P8159, P8160, and P8161. Discard all previous versions of NTB98-074.
NISSAN: TIRE PRESSURE MONITORING SYSTEM (TPMS) WARNING LIGHT ON/FLASHING.
Read full bulletin
NO MODELS OR MODEL YEARS LISTED. *PE UPDATED ON 08-11-2011. *KB
Body & Paint
4 bulletinsINFORMATION FOR VEHICLES EXHIBITING CORROSION AT THE HIGH MOUNT STOP LAMP.
Read full bulletin
(TT
CONDITION WITH REAR SLIDING WINDOW LEAKS WATER.
Read full bulletin
*YC
REMOVING FOREIGN MATERIAL FROM THE WINDOW GLASS This bulletin has been amended.
Read full bulletin
See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
WINDSHIELD CRACKING This bulletin has been amended.
Read full bulletin
See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
Pre-Delivery & Maintenance
2 bulletinsSUBJECT REGARDING REVISED MAINTENANCE PROCEDURES.
Read full bulletin
*SLC
SUBJECT PERTAINING TO REVISED MAINTENANCE PROCEDURES.*JB
Transmission
2 bulletinsALL VEHICLES BUILT BEFORE 1N6SD11S8VC327106 WITH A FS5W71C TRANSMISSION MAY EXHIBIT A WHINE NOISE WHILE DRIVING IN ALL FORWARD GEARS EXCEPT 4TH.
Read full bulletin
THE WHINE NOISE IS MORE PRONOUNCED IN 1ST, 2ND OR 3RD GEARS AT SLOW SPEEDS. *TT
4WD TRUCK W71C MANUAL TRANSMISSION WHINE NOISE ON ACCELERATION.
Read full bulletin
*JD
Steering
2 bulletinsDIAGNOSIS OF VEHICLE PULL (DRIFT) AND/OR STEERING WHEEL OFF-CENTER This bulletin has been amended.
Read full bulletin
See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
DIAGNOSIS OF VEHICLE PULL (DRIFT) AND/OR STEERING WHEEL OFF-CENTER This bulletin has been amended.
Read full bulletin
See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
Brakes
2 bulletinsSTRUT AND SHOCK ABSORBER REPLACEMENT GUIDELINES This bulletin has been amended.
Read full bulletin
See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
STRUT AND SHOCK ABSORBER REPLACEMENT GUIDELINES This bulletin has been amended.
Read full bulletin
See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
Infotainment
1 bulletinEXHIBITING POOR OR NO FM AUDIO RECEPTION.
Read full bulletin
*YC
Suspension
1 bulletinWHEEL BEARING COLLISION DAMAGE This bulletin has been amended.
Read full bulletin
See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.