1991 Nissan D21 TSBs
30 Technical Service Bulletins across 10 categories
Categories
Other
5 bulletinsSUBJECT REGARDING ESSENTIAL TOOL - REAR AXLE BEARING REMOVAL KIT.
Read full bulletin
*TTTHE KIT IS AN ESSENTIAL TOOL AND AND WILL BE AUTOMATICALLY SENT TO ALL NISSAN DEALERS.
A CONDITION MAY EXIST WHERE WATER MAY HAVE ENTERED THE DISTRIBUTOR ASSEMBLY.
Read full bulletin
*TT
UNKNOWN
INTELLIGENT KEY REPLACEMENT OR SWAPPING BETWEEN VEHICLES This bulletin has been amended.
Read full bulletin
See AMENDMENT HISTORY on the last page. Discard all previous versions of this bulletin.
NISSAN: LOCK/UNLOCK REQUEST BUTTON ON OUTSIDE HANDLE DOES NOT RESPOND.
Read full bulletin
*JS
Transmission
5 bulletinsALL VEHICLES BUILT BEFORE 1N6SD11S8VC327106 WITH A FS5W71C TRANSMISSION MAY EXHIBIT A WHINE NOISE WHILE DRIVING IN ALL FORWARD GEARS EXCEPT 4TH.
Read full bulletin
THE WHINE NOISE IS MORE PRONOUNCED IN 1ST, 2ND OR 3RD GEARS AT SLOW SPEEDS. *TT
EXHIBITING A WHINE NOISE WHILE DRIVING IN ALL FORWARD GEARS EXCEPT 4TH.
Read full bulletin
*YC
4WD TRUCK W71C MANUAL TRANSMISSION WHINE NOISE ON ACCELERATION.
Read full bulletin
*JD
FS5R30A TRANSMISSION WHINE.
Read full bulletin
*JD
TRANSMISSIONS DETENT HOLES ELIMINATED FROM ADAPTER PLATE.
Read full bulletin
*JD
Engine
5 bulletinsSOME ENGINES MAY EXHIBIT A RATTLE NOISE WHEN THE ENGINE IS IDLING AT FULL OPERATING TEMPERATURE.
Read full bulletin
*TT
K24E TENSION SIDE TIMING CHAIN GUIDE BROKEN.
Read full bulletin
*TW
VEHICLE KEY NOT DETECTED / AUTHENTICATED, ENGINE WILL NOT START This bulletin has been amended.
Read full bulletin
See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
NISSAN: VENT CONTROL VALVE REPLACEMENT.
Read full bulletin
WHEN REPLACING THE EVAP CANISTER VENT CONTROL VALVE FOR REASON: USE THE ONE LISTED ON PAGE 2; FOR VENT CONTROL VALVE REPLACEMENT PROCEDURE, REFER TO THE APPROPRIATE SECTION OF THE ELECTRONIC SERVICE MANUALS (ESM; WHEN INSTALLING THE NEW VALVE, DO NOT ADD ANY LUBE TO ITS O RING; FOR FRONTIER (D40 SERIES) ONLY, INSTALL THE PROTECTOR LISTED IN PARTS INFORMATION. *PE INCLUDES 2005-09 FRONTIER. UPDATED 12/8/10. *PE
NISSAN: THE 12 VOLT BATTERY IS AN IMPORTANT PART OF THE VEHICLE ELECTRICAL SYSTEM AND IS REQUIRED TO STAY CONNECTED WHEN THE ENGINE IS RUNNING.
Read full bulletin
TO PREVENT DAMAGE TO VEHICLE ELECTRONIC COMPONENTS FOLLOW THE INSTRUCTIONS/CAUTIONS. NO MODEL YEARS LISTED. *PE
Air Bags & Safety
4 bulletinsSEAT BELT LATCH PLATE RETAINING BUTTON MISSING.
Read full bulletin
*TT
CONCERNS WITH THE FRONT SEAT BELT LATCH PLATE STOPPER BUTTON MISSING.
Read full bulletin
*TT
FRONT SEAT BELT LATCH PLATE RETAINING BUTTON MISSING.
Read full bulletin
*TT
FRONT SEAT BELT LATCH PLATE RETAINING BUTTON MISSING.
Read full bulletin
*TT
Electrical
3 bulletinsSILICONE-BASED LUBRICANT OR GREASE CAN DAMAGE ELECTRICAL COMPONENTS SERVICE INFORMATION Do not apply Silicone-based...
Read full bulletin
lubricants or grease to, or around, any interior electrical components. To avoid the risk of death or severe personal injury, do not directly spray Silicone-based lubricant or grease, or inadvertently overspray Silicone-based lubricant or grease onto any interior electrical components. These types of lubricants can be detrimental to the proper operation of electrical components.
12 VOLT BATTERY TESTING FOR IN-SERVICE VEHICLES SERVICE INFORMATION The following Service Information lists NNA...
Read full bulletin
procedural recommendations for establishing good connections while performing 12V battery testing. These recommendations are expected to promote uniformity during the connection process, therefore reducing the number of incorrect Test with DCA and Replace results. HINT: If 12 volt batteries are allowed to discharge for a prolonged period of time, battery life may be drastically reduced. This condition may lead to premature battery replacement and customer dissatisfaction. IMPORTANT: CPX-900 is now an accepted testing tool to use along with or in place of the DSS-5000 CPX-900 operating instructions are found at: https://nissancpx900.midtronics.com/ DSS-5000 operating instructions are found at: https://nissandss5000.midtronics.com/ DCA-8000 is now a required testing tool to be used for all warranty replacement decisions. The DCA-8000 is also a more efficient charger than previously available, and will charge any available 12 volt lead acid battery safely and accurately as long as all precautions and inputs are made correctly. The DCA-8000 operating instructions are found at: https://nissandca8000.midtronics.com/
SERVICE INFORMATION Information necessary to service the Supplemental Restraint System (SRS) safely is included in the...
Read full bulletin
"RESTRAINTS" section of the Electronic Service Manual (ESM) for each vehicle. IMPORTANT: Turn the ignition switch OFF, disconnect both battery terminals, and wait at least 3 minutes before performing any service on the SRS. See this bulletin for further detail.
Steering
2 bulletinsDIAGNOSIS OF VEHICLE PULL (DRIFT) AND/OR STEERING WHEEL OFF-CENTER This bulletin has been amended.
Read full bulletin
See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
DIAGNOSIS OF VEHICLE PULL (DRIFT) AND/OR STEERING WHEEL OFF-CENTER This bulletin has been amended.
Read full bulletin
See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
Body & Paint
2 bulletinsREMOVING FOREIGN MATERIAL FROM THE WINDOW GLASS This bulletin has been amended.
Read full bulletin
See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
WINDSHIELD CRACKING This bulletin has been amended.
Read full bulletin
See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
Brakes
2 bulletinsSTRUT AND SHOCK ABSORBER REPLACEMENT GUIDELINES This bulletin has been amended.
Read full bulletin
See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
STRUT AND SHOCK ABSORBER REPLACEMENT GUIDELINES This bulletin has been amended.
Read full bulletin
See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
Suspension
1 bulletinWHEEL BEARING COLLISION DAMAGE This bulletin has been amended.
Read full bulletin
See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
Lighting
1 bulletinNISSAN: TIRE PRESSURE MONITORING SYSTEM (TPMS) WARNING LIGHT ON/FLASHING.
Read full bulletin
NO MODELS OR MODEL YEARS LISTED. *PE UPDATED ON 08-11-2011. *KB