2008 Newmar Mountain Aire TSBs

relating to motor vehicle safety exists in specific motor homes. Issue: Certain motorhomes may have a defective refrigerator travel latch that may activate without the user?s knowledge when the doors are closed. If the latch locks the door shut, the refrigerator cannot be opened from the inside. This could potentially cause entrapment/injury to an individual. This only applies to French door style refrigerators with a specific travel latch. Attached is a list of specific coaches affected.

(Spartan) has decided a defect which relates to motor vehicle safety exists in certain incomplete motor home chassis. Newmar Corp. has built on these chassis. The list of specific Newmar affected units is attached. Newmar NHTSA# 15v 654, TC# 2015-467 Tag axle wheel bearings may overheat. Overheating of the tag axle may be detected by distortion or melting of the Stemco cover or ABS lamp illumination. If the wheel bearings overheat, there may be an increased risk of a wheel end fire.

This recall is the result of information provided to Newmar by Spartan Motors. NHTSA # 15v 752 TC # 2015-534 On certain vehicles, the engine cooling fan may separate from the drive without warning. If the engine area is open and the cooling fan is operating and detaches, it could potentially cause personal injury.

AND THE 12 VOLT THERMOSTAT AND 12 VOLT HEATED WATER LINE COULD ALSO BE WIRED INCORRECTLY, CAUSING IT TO HAVE THE INCORRECT WIRING OR NO POWER. THE INCORRECT CIRCUIT BREAKER AMPERAGE RATING COULD INCREASE THE RISK OF A FIRE CAUSING INJURY AND/OR DAMAGE TO PROPERTY. NHTSA 14V-602, TC# 2014-425

MODELS 2004-2012 KING AIRE, MOUNTAIN AIRE, ESSEX. *PE

PLEASE NOTE THAT WHEN CHANGING OUT WARRANTY AMSAFE SEAT BELTS, BOTH HARNESS STRAP WITH CLIP AND BUCKLE PORTION WILL NEED TO BE RETURNED. ALL MOTORIZED MODELS AND ALL MODEL YEARS ARE INCLUDED. *PE

A THERMAL LIMIT SWITCH IS ADDED TO CERTAIN 1200 LR, 1200 LRIM, AND 1201 LRIM REFRIGERATORS TO PREVENT POSSIBLE EXCESS OR OVERHEATING CONDITIONS IN THE HEATER AREA OF THE COOLING UNIT TO EXCEED A CERTAIN LEVEL. *PE

CHANGE COOLING UNIT HEATING ELEMENT VENDORS; THERE IS A NEW STYLE ELECTRIC HEATING ELEMENT THAT MUST BE USED IN CERTAIN NEW COOLING UNITS. *PE

Torque the mounting bolts (if needed) to 30 ft. pounds. A ground cable may also be installed to improve the overall grounding of the HWH pump assembly.

*PE

*PE

MORE THAN 100 LBS HAS BEEN ADDED TO THE UNIT BETWEEN THE TIME OF MANUFACTURE AND THE TIME OF FIRST RETAIL DELIVERY. *NJ

CONCERN IS THAT THE DISCOLORATION IS DUE TO EXPOSURE TO HEAT FROM THE FLUE. *NJ