2018 Newmar London Aire TSBs

motorhomes built on Freightliner chassis NHTSA # 20V 404. In response, Newmar Corporation is issuing NHTSA Recall # 20V 421

motorhomes built on Freightliner chassis (NHTSA # 18V 582 ). In response, Newmar is releasing NHTSA # 19V 426.

the WiFi Ranger option and a specific power supply.

motorhomes built on Freightliner Chassis (NHTSA 18V 703). In response, Newmar Corporation is releasing recall NHTSA 18V 859 and TC # 2018-669. Issue: On certain motorhomes, the brake caliper mounting bolts may be incorrectly torqued. Insufficiently torqued bolts may not provide adequate clamping force between the brake caliper and brake anchor plate potentially resulting in reduced brake effectiveness. Reduced brake effectiveness could lead to a vehicle crash and/or property damage.

NHTSA 18V 518, TC# 2018-413. Issue: On certain motorhomes, the latch on the entry door may not engage properly. This may allow the door to open unexpectedly while the vehicle is in transit, increasing the risk of injury.

motorhomes built on Freightliner Chassis (NHTSA 18V 353). In response, Newmar Corporation is releasing recall NHTSA 18V 505 and TC # 2018-401. Issue: On certain motorhomes equipped with air disc brakes, the brake caliper mounting bolts may be incorrectly torqued. The caliper bolts may loosen, which may lead to the caliper detaching. Insufficiently torqued fasteners may not provide adequate clamping force between the brake caliper and brake anchor plate, potentially resulting in reduced brake effectiveness. This scenario would result in greater stopping distances, increasing the risk of a crash causing injury and/or damage to property.

NHTSA # 18V 438, TC# 2018-349 Issue: After the battery disconnect is turned on, the slideout controller may cause the slideouts to extend or retract without warning. This could increase the risk of injury and/or damage to property. This condition can only occur with the battery disconnect on and the ignition key in the off/accessory position.

NHTSA 18V 387 TC 2018-303 Issue: On certain motorhomes, the windshield wiper arms may have been manufactured incorrectly. This may reduce the driver?s visibility under certain conditions and increase the risk of a crash and/or property damage.

Recall NHTSA 18V 236, TC 2018-182. On certain motorhomes, there may be loose electrical connections in the breaker box that were not properly tightened. A loose power connection may cause a buildup of heat at the connection, potentially increasing the risk of overheating or a fire causing injury and/or damage to property.

Issue: On certain motorhomes, there may be a loose electrical connection to the automatic transfer switch (ATS) that was not properly tightened. If the power connection is loose, it may result in a buildup of heat at the connection, which may increase the risk of fire causing injury and/or damage to property.

In response, Newmar is publishing TSB 493. Issue: On specific vehicles equipped with Stoneridge light bar control units (LBCU), the instrument panel odometer value may reset and no longer match the engine ECU odometer value.

communicate with the engine computer using the 500k baud rate. In response, Newmar has issued TSB 491. Issue: During coach startup, the TM102 Coach Management module may crash the 500k data bus.

Custom Chassis X-line motorhome and shuttle bus chassis equipped with multiplex wiper controls, manufactured March 21, 2016, through January 2, 2017. In response, Newmar Corporation published TSB 485 to inform our dealers and customers. Issue: On some vehicles, the windshield wiper intermittent delay function is incorrectly set to a fixed delay.

In response, Newmar is issuing recall NHTSA # 17v 413. Issue: On certain motorhomes, the drive gear on the fuel pump may spin loose on the drive shaft, resulting in loss of pumping function. If this occurs, the engine may stall without warning and cannot be restarted. An unexpected engine stall without the ability to restart may increase the risk of a crash.

has decided that a defect relating to motor vehicle safety exists in specific motor homes built on Spartan chassis. In response, Newmar Corporation is publishing the following recall: NHTSA #17V 195 TC #2017-162. Issue: On certain motorhomes, the ball joints on the independent front suspension may be loose. If not detected, the loose ball joints could separate over time. This could affect vehicle handling and increase the risk of a crash causing injury and/or damage to property.

warning on the SilverLeaf touchscreen that reads transfer switch 0-0 failure unknown. This is a false warning caused by the TRC transfer switch program code.

If affected, the USB ports may not be active as the USB input to the Xite Infotainment center. The affected USB input is normally located on the driver side console

After testing, Riverpark believes that some of the Kingston SD cards were defective from the factory. In response to their findings, Newmar Corporation is issuing TSB 487 to inform dealers and service personnel of the defective parts. Issue: When the SD card plays in the Xite Infotainment Center, it loses communication after a period of time (typically 7-10 minutes). The system becomes sluggish and tries to re-boot continuously. This is partly due to the inability to read the cards information quickly enough, causing the radio?s CPU to ?max out,? resulting in the previously described freezing and rebooting symptoms.

In most cases, the 10 amp fuse installed by the factory is sufficient. However, some coaches equipped with a ShurFlo water pump (Newmar part # 127488) blow the 10 amp water pump fuse.

with the 4525 floorplan equipped with a 85,000 BTU Oasis NES hydronic heating system, the hydronic heating system fuse and wiring may be undersized. Issue: The fuse may blow due to overload.

coach in the event of a sensor or door switch failure. In the event of a step failure, the person(s) inside the coach would have a large gap between the door threshold and the ground. The person(s) may have to exit via the large gap or the emergency exit door to get out of the coach.

G3 system.

binding linkages to the power actuator. This issue often creates difficulty when locking or unlocking the compartment door using the key and is only relevant on 2016 to early 2019 model year coaches equipped with power baggage locks.

Torque the mounting bolts (if needed) to 30 ft. pounds. A ground cable may also be installed to improve the overall grounding of the HWH pump assembly.

This will only apply to coaches equipped with an HDMI/ CAT6 splitter AND the customer has installed a Geni-type satellite receiver. In this scenario, the customer may have issues trying to select satellite stations that toggle between high definition (HD) and standard definition.

The switch has been added to the front overhead cabinet during production on later 2018 models. If the HWH system fails to operate the pump assembly when using the leveling system touchpad, slideout switches, or the entrance step, this reset switch will provide the coach owner with a more convenient location for resetting the HWH system. This will eliminate the need to pull the F-11 fuse or exit the coach to turn off the chassis disconnect in the event of a system lockout. Issue: In the event of a step failure, the person(s) inside the coach would have a large gap between the door threshold and the ground. The person(s) may have to exit via the large gap or the emergency exit door to get out of the coach.