2016 Newmar London Aire TSBs

If any bolt is under- torqued, remove the bolt, and add blue LOCTITE thread sealant to the bolt threads. If there is no washer on the nut side of the bolt, add a flat washer. Reinstall and torque all 5/16 bolts to 19 ft. lbs. and all 3/8 bolts to 33 ft. lbs.

If any bolt is under- torqued, remove the bolt, and add blue LOCTITE thread sealant to the bolt threads. If there is no washer on the nut side of the bolt, add a flat washer. Reinstall and torque all 5/16" bolts to 19 ft. lbs. and all 3/8" bolts to 33 ft. lbs.

Issue: On certain motorhomes, there may be a loose electrical connection to the automatic transfer switch (ATS) that was not properly tightened. If the power connection is loose, it may result in a buildup of heat at the connection, which may increase the risk of fire causing injury and/or damage to property.

issued field service campaign SF546AB. In response, Newmar is publishing PIB 495. Issue: On certain coaches, a check valve is missing on the auxiliary air tank, causing the tag axle steer tires to remain in a turned position when stopping the vehicle during a turn and shifting into reverse. In addition, some of these vehicles also require an air line retrofit.

In response, Newmar is publishing TSB 493. Issue: On specific vehicles equipped with Stoneridge light bar control units (LBCU), the instrument panel odometer value may reset and no longer match the engine ECU odometer value.

Custom Chassis X-line motorhome and shuttle bus chassis equipped with multiplex wiper controls, manufactured March 21, 2016, through January 2, 2017. In response, Newmar Corporation published TSB 485 to inform our dealers and customers. Issue: On some vehicles, the windshield wiper intermittent delay function is incorrectly set to a fixed delay.

with low fluid level in HWH hydraulic system. This TSB only applies to units with a hydraulic Slideout system built prior to 9/14/2015. If there is not enough fluid in the reservoir tank; the HWH slide system (when activated) will draw in air with the fluid and cause uneven pressure on the HWH chain/bracket while opening and closing the slide. This could cause the chain/bracket to loosen over time.

has decided that a defect relating to motor vehicle safety exists in specific motor homes built on Spartan chassis. In response, Newmar Corporation is publishing the following recall: NHTSA #17V 195 TC #2017-162. Issue: On certain motorhomes, the ball joints on the independent front suspension may be loose. If not detected, the loose ball joints could separate over time. This could affect vehicle handling and increase the risk of a crash causing injury and/or damage to property.

has decided a defect which relates to motor vehicle safety exists in certain motor home chassis. Newmar has provided the list of coaches affected by this Spartan Recall. NHTSA # 15V 492 TC# 2015-345. The control module for the air suspension may experience a loss of power resulting in the air suspension not being able to achieve ride height. If the ride height of the suspension is less than specified ride height, negative impact to roll steer could occur. This could cause the vehicle to be difficult to control and increase the risk of a crash. This could occur without warning.

POSSIBLE WATER INTRUSION AROUND THE LIFT CYLINDER ON THE FULL WALL HYDRAULIC SLIDEOUT.

ISSUE: LOOSE MOUNTING BOLTS MAY CAUSE NOISE, AND MAY RESULT IN DAMAGE TO THE SLIDEOUT MOTOR HOUSING.

HOMES BUILT ON FREIGHTLINER CHASSIS AND IN RESPONSE NEWMAR IS PUBLISHING RECALL NHTSA# 16V 478 TC# 2016-325. ON CERTAIN MOTORHOMES, WHEN THE THROTTLE PEDAL IS RELEASED, THE ASSOCIATED PEDAL SENSOR MAY NOT RETURN TO ZERO, CAUSING THE ENGINE BRAKE TO POTENTIALLY NOT ACTIVATE AS EXPECTED. A SUDDEN LOSS OF AN ENGINE BRAKE, WITHOUT WARNING ON A MOTORHOME, MAY LEAD TO A REDUCED BRAKE CAPACITY POTENTIALLY INCREASING THE RISK OF A VEHICLE CRASH.

binding linkages to the power actuator. This issue often creates difficulty when locking or unlocking the compartment door using the key and is only relevant on 2016 to early 2019 model year coaches equipped with power baggage locks.

Torque the mounting bolts (if needed) to 30 ft. pounds. A ground cable may also be installed to improve the overall grounding of the HWH pump assembly.

warning on the SilverLeaf touchscreen that reads transfer switch 0-0 failure unknown. This is a false warning caused by the TRC transfer switch program code.

In most cases, the 10 amp fuse installed by the factory is sufficient. However, some coaches equipped with a ShurFlo water pump (Newmar part # 127488) blow the 10 amp water pump fuse.

structure to reinforce an HWH slideout wall.

There are a limited number of coaches since units built after 6/12/15 will not be affected and inventory not shipped were inspected prior to shipment. Issue: Increased noise level in Bedroom from a/c vent. Note: This does not affect the operation of the AC system, just the noise level.

THIS CHANGE CAUSED AN ISSUE IN ITCS LED RECESSED LIGHTS WITH A MANUFACTURED DATE CODES IN THE RANGE OF NOVEMBER 2014 TO MARCH 2015. LIGHTS MAY PREMATURELY QUIT WORKING OR ONLY HAVE A PORTION OF LEDS WORKING WITHIN EACH LIGHT FIXTURE.

THIS MAY CAUSE PREMATURE TAG AXLE TIRE WEAR. THIS COMMUNICATION INCLUDES LIST OF COACHES POSSIBLY AFFECTED, INSTRUCTIONS TO VERIFY IF ALIGNMENT IS NEEDED AND INSTRUCTIONS TO PERFORM ALIGNMENT.