2012 Newmar Dutch Star TSBs

relating to motor vehicle safety exists in specific motor homes. Issue: Certain motorhomes may have a defective refrigerator travel latch that may activate without the user?s knowledge when the doors are closed. If the latch locks the door shut, the refrigerator cannot be opened from the inside. This could potentially cause entrapment/injury to an individual. This only applies to French door style refrigerators with a specific travel latch. Attached is a list of specific coaches affected.

has decided that a defect relating to motor vehicle safety exists in specific motor homes built on Spartan chassis. In response, Newmar Corporation is publishing the following recall: NHTSA #17V 195 TC #2017-162. Issue: On certain motorhomes, the ball joints on the independent front suspension may be loose. If not detected, the loose ball joints could separate over time. This could affect vehicle handling and increase the risk of a crash causing injury and/or damage to property.

CERTAIN MOTORHOMES MAY HAVE A DEFECTIVE REFRIGERATOR TRAVEL LATCH THAT MAY ACTIVATE WITHOUT THE USERS KNOWLEDGE WHEN THE DOORS ARE CLOSED. IF THE LATCH LOCKS THE DOOR SHUT, THE REFRIGERATOR CANNOT BE OPENED FROM THE INSIDE. THIS COULD POTENTIALLY CAUSE ENTRAPMENT/INJURY TO AN INDIVIDUAL. THIS ONLY APPLIES TO FRENCH DOOR STYLE REFRIGERATORS WITH A SPECIFIC TRAVEL LATCH. ATTACHED IS A LIST OF SPECIFIC COACHES AFFECTED.

NHTSA#: 16V 008 TC#: 2016-018 NEWMAR CORPORATION HAS BEEN ADVISED BY LIPPERT COMPONENTS THAT ON CERTAIN MOTORHOMES USING LCI COACHSTEP ELECTRIC DOUBLE OR TRIPLE ENTRANCE STEPS, THERE IS THE POTENTIAL OF A STRUCTURAL FRACTURE WITHIN THE LIPPERT STEP ASSEMBLY. THERE IS THE POTENTIAL OF A STRUCTURAL FRACTURE OF THE CENTER BOLT OF THE FAN GEAR ASSEMBLY WHICH MAY CAUSE THE FAN GEAR ASSEMBLY TO DISENGAGE FROM THE STEPS. THIS ISSUE CREATES AN UNSTABLE PLATFORM, WHICH COULD CAUSE A PERSON TO FALL AND RESULT IN INJURY.

AND THE 12 VOLT THERMOSTAT AND 12 VOLT HEATED WATER LINE COULD ALSO BE WIRED INCORRECTLY, CAUSING IT TO HAVE THE INCORRECT WIRING OR NO POWER. THE INCORRECT CIRCUIT BREAKER AMPERAGE RATING COULD INCREASE THE RISK OF A FIRE CAUSING INJURY AND/OR DAMAGE TO PROPERTY. NHTSA 14V-602, TC# 2014-425

Torque the mounting bolts (if needed) to 30 ft. pounds. A ground cable may also be installed to improve the overall grounding of the HWH pump assembly.

The new part (# 024193) is a replacement for both of the obsolete parts and will mount the same way. The wire connections have changed from a plug to two barrel connectors. The barrel connectors may be used or cut off to install with spade terminals, which allows wires to be reversed easily.